Karcher K 6.85 M User's Manual
Contents
1. 1 Coupling element for water connection 2 Waterfilter 3 Fine filter in the water connection 4 Storage for accessories 5 Water connection 6 Appliance switch 0 OFF I ON 7 Storage for trigger gun 8 Transport handle 9 Detergent suction hose with filter 10 Dosage regulator for detergent 11 Detergent Tank 12 Storage for mains connection cable 13 Mains cable with mains plug 14 Storage for spray lance 15 Hose drum 16 hand crank for hose drum 17 Bearing wheel 18 High pressure hose 19 Trigger gun 20 Lock trigger gun 21 Key to detach the high pressure hose from the trigger gun 22 Spray lance with pressure regulation Vario Power 23 Storage for accessories Special accessories Special accessories expand the possibili ties of using your appliance Please contact your KARCHER dealer for further informa tion Assembly see page 12 13 English 5 Before Startup Mount loose parts delivered with appliance prior to start up Assemble appliance as shown on page 12 and 13 gt Illustration Mi Insert holder for trigger gun gt Illustration FA Insert the transport handle and screw in gt Illustration El Lock the detergent tank in place on the appliance Close the detergent tank with the lid gt Illustration Attach the accessories holder gt Illustration EH Push the high pressure hose into the trigger gun until it locks audibly Note Make sure the connection nipple is2. KARCHER o EEE PEER SI K 6 85 M Operating Instructions Before first use of the unit read these operating instructions and act in accordance with them A 5 962 612 0 02 08 Environmental protection General information 2 Safety instructions 3 Operation 4 Maintenance and care 8 Troubleshooting 9 Customer Service 10 Technical specifications 10 Assembly 12 Spare Parts 15 General information Dear Customer Please read and comply with AI these instructions prior to the in itial operation of your appliance Retain these operating instructions for future refer ence or for subsequent possessors Hazard levels Danger Immediate danger that can cause severe injury or even death Warning Possible hazardous situation that could lead to severe injury or even death Caution Possible hazardous situation that could lead to mild injury to persons or damage to property Proper Use This high pressure cleaner is designed for domestic use only to clean machines vehicles buildings tools facades terraces garden equip ment etc using a high pressure water jet and detergents if required with accessories replacement parts and detergents approved by Karcher Observe the instructions provided with these detergents 2 English Oy The packaging material can be recy cled Please do not place the packag ing into the ordinary refuse for di
3. tion using flat nose pliers and clean with running water Frost protection Caution Protect the appliance and its accessories against frost The appliance and its accessories can get destroyed through frost if there are any wa ter residues in them To avoid damage to them gt Store the appliance and the entire ac cessories in a frost safe room Spare parts Use only original KARCHER spare parts You will find a list of spare parts at the end of these operating instructions Troubleshooting You can rectify minor faults yourself with the help of the following overview If in doubt please consult the authorized customer service Danger Turn off the appliance and remove the mains plug prior to any care and mainte nance work Repair works may only be performed by the authorized customer service Appliance is not running gt Check whether the voltage indicated on the type plate corresponds to the volt age of the mains supply gt Check the mains connection cable for damages Pressure does not build up in the appliance gt Check setting at the spray lance gt Remove air from appliance before oper ation Switch on the appliance without mount ed spray lance and run it until the water discharging from the trigger gun is free of bubbles Switch off appliance and connect spray lance Check the water supply Pull out the fine filter in water connec tion using flat nose pliers and clean with
4. aligned correctly Check the secure connection by pulling on the high pressure hose 6 English Water supply According to the applicable regula tions the appliance must never be used on the drinking water supply without a system separator Use a suitable system separator manufactured by K RCHER or as an alternative a system separator as per EN 12729 Type BA Note Impurities in the water can damage the high pressure pump and accessories For protection the use of the KARCHER water filter optional accessory order no 4 730 059 is recommended Water supply from mains Observe regulations of water supplier For connection values see type plate tech nical data gt Use a fibre reinforced water hose not included with a standard coupling Minimum diameter 1 2 inch 13 mm minimum length 7 5 m gt Screw the water filter on the water con nection of the device gt Screw the delivered coupling part on the water filter gt Push the water supply hose onto the coupling unit then connect it to the tap Drawing in water from open reservoirs This high pressure cleaner is suited to work with the KARCHER suction hose with back flow valve Optional accessory order no 4 440 238 to draw in surface water e g from water butts or ponds see specifica tions for max suction height gt Fill the KARCHER suction hose with backflow valve with water screw to wa ter supply and hang into he water butt gt Remo
5. coupling of an extension cable must be watertight and must never lay in the water Unsuitable extension cables can be hazardous Only use extension cables outdoors which have been approved for this purpose and labelled with a suffi cient cable cross section 1 10m 1 5 mm 10 30 m 2 5 mm Always fully unroll electrical cables from the cable drum High pressure hoses fixtures and cou plings are important for the safety of the appliance Only use high pressure hos es fixtures and couplings recommend ed by the manufacturer This device is not intended for use by persons including children with re duced physical sensory or mental abil ities or lacking experience and or knowledge unless they are supervised by a person responsible for their safety or are instructed by these persons on the use of the device Children should be supervised to ensure that they do not play with the device The operator must use the appliance correctly When working with the appli ance he must consider the local condi tions and pay due care and attention to other persons in particular children who are nearby Do not use the appliance when there are other persons around unless they are also wearing safety equipment Wear protective clothing and safety goggles to protect against splash back containing water or dirt English 3 Caution Observe a distance of at least 30 cm when using the jet to clean painted sur faces to avoid dama
6. service or a skilled electrician Check the high pressure hose for dam age before every use Please arrange for the immediate exchange of a dam aged high pressure hose The appliance may not be used in areas where a risk of explosion is present Ifthe appliance is used in hazardous ar eas e g filling stations the corre sponding safety provisions must be observed High pressure jets can be dangerous if improperly used The jet must not be directed at persons ani mals live electrical equipment or at the appliance itself The high pressure jet must not be di rected at other persons or directed by the user at him herself to clean clothing or footwear Never use the appliance to clean ob jects containing hazardous substances e g asbestos Vehicle tyres or tyre valves are suscep tible to damage from the high pressure jet and may burst The first indication of this is a discolouration of the tyre Dam aged vehicle tyres tyre valves are high ly dangerous Ensure that a distance of at least 30 cm is observed when clean ing with the jet Never draw in fluids containing solvents or undiluted acids and solvents This in cludes petrol paint thinner and heating gt oil The spray mist thus generated is highly inflammable explosive and poi sonous Do not use acetone undiluted acids and solvents as they are aggres sive towards the materials from which the appliance is made Warning The mains plug and the
7. For particularly dirty items or areas Not suitable for use with detergents Working with detergent We recommend the KARCHER cleaning and care program that will match the re spective cleaning requirements Please seek consultation or request information on the subject gt Fill the detergent solution in the deter gent tank observe dosage instructions on the packaging of the detergent gt Adjust the suction volume of the deter gent solution by means of the dosage regulator for detergents Medium quantity Central position Large quantity position Small quantity position gt Use spray lance with pressure regula tion Vario Power gt Turn the spray lance to Mix position Note This will mix the detergent with the water stream Recommended cleaning method gt Spray the detergent sparingly on the dry surface and allow it to react but not to dry gt Spray off loosened dirt with the high pressure ray Interrupting operation gt Release the lever on the trigger gun gt Illustration see page 13 Lock the lever on the trigger gun gt During longer breaks more than 5 min utes also turn the appliance off using the 0 OFF switch gt Insert the trigger gun in its holder English 7 Finish operation Caution Only separate the high pressure hose from the trigger gun or the appliance while there is no pressure in the system gt After operation with detergent Fill the detergent ta
8. ging paintwork Never leave the appliance unattended when it is in operation Make sure that the power cable or ex tension cables are not damaged by run ning over pinching dragging or similar Protect the power cable from heat oil and sharp edges All current conducting parts in the work ing area must be protected against jet water The appliance may only be connected to an electrical supply which has been installed in accordance with IEC 60364 The appliance may only be connected to alternating current The voltage must correspond with the type plate on the appliance The maximum tolerable mains imped ance at the electrical contact point see Technical Data must not be exceeded For safety reasons we recommend that you operate the appliance only via a earth leakage circuit breaker max 30 mA Cleaning operations which produce oily waste water e g engine washes un derbody washes may only be carried out using washing stations equipped with an oil separator This appliance was designed to be used with detergents which are sup plied or recommended by the manufac turer The use of other detergents or chemicals may compromise the safety of the appliance 4 English Description of the Appliance When unpacking the product make sure that no accessories are missing and that none of the package contents have been damaged If you detect any transport dam ages please contact your dealer Illustrations on Page 5
9. n Detergent flow rate 0 0 2 l min Recoil force of trigger gun 21N Hand arm vibration 0 8 m s ISO 5349 Sound pressure level 73 dB A Lpa EN60704 1 Sound power level 92 dB A Lwa 2000 14 EG Dimensions Length 400 mm Width 395 mm Height 925 mm Weight 19kg Subject to technical modifications 10 English English 11 gt Ro lt 12 English gt 7 7 lt English 13 14 English 5 962 612 0 01 08 6 389 870 0 lt gt Spare Parts 2 641 610 0 d 6 363 410 0 6 391 794 0 A 6 363 410 0 S 8 2 gs gt W AR 4 071 132 0 4 063 807 0 fo D 6 362 740 0 6 388 21 N Be 5 731 609 0 4 760 527 0 D A SD 2 640 729 0 4 763 977 0 5 044 632 0 6 648 943 0 KL _ gt Ne 5 731 620 0 4 515 103 0 English 15 KARCHER www karcher com au
10. nk with clear water turn the spray pipe with pressure regulator to the position Mix switch the appliance on for about 1 minute and rinse with clear water Release the lever on the trigger gun Turn off the appliance 0 OFF Turn off tap Detach the appliance from the water supply Press the lever on the trigger gun to re lease any remaining pressure in the system Illustration F see page 13 Lock the lever on the trigger gun Pull out the mains plug Roll up the power cord and loop it e g round the handle Roll the high pressure hose on to the hose drum Pull out the hose drum han dle turn it clockwise then retract the handle gt Insert the trigger gun in its holder Y VIVY Y VS 4 Transport Caution Empty the detergent tank before transport ing in horizontal position 8 English Maintenance and care Danger Tum off the appliance and remove the mains plug prior to any care and mainte nance work Maintenance The appliance is maintenance free Storage Prior to longer periods of storage e g in the winter gt Completely drain all water from the ap pliance Switch the appliance on with detached high pressure hose and de tached water supply max 1 minute and wait until no more water exits at the high pressure connection Turn off the appliance gt Remove filter from suction hose for de tergent and clean under running water gt Pull out the fine filter in water connec
11. running water VY Appliance does not start motor hums Cause Voltage reduction due to weak mains supply or when using an extension cable gt When switching on first pull the lever of the trigger gun and then switch the ap pliance switch to VON Strong pressure fluctuations gt Clean high pressure nozzle Remove dirt and debris from the nozzle bore us ing a needle and rinse through with wa ter from the front gt Check water flow quantity Appliance is leaking gt Slight leakage from the appliance pump is normal If the leakage increases con tact the authorized customer service No detergent infeed gt Use spray lance with pressure regula tion Vario Power Turn the spray lance to Mix position gt Check the settings at the detergent dos aging regulator Clean the detergent suction hose filter Check the detergent suction hose for kinks yy English 9 Technical specifications Australia Power connection K rcher Pty Ltd 40 Koornang Road Voltage en ee Scoresby Victoria 3179 Connected load 2 2 kW 1800 675 714 Free Call Mains fuse slow blow 16A www karcher com au Maximum allowed net im 0 388 Ohm pedance j0 243 Ohm Protective class Protection class IP X5 Water connection Max feed temperature 60 C Min feed volume 11 l min Max feed pressure 0 6 MPa Max Suction height 0 5m Performance data Working pressure 13 MPa Max permissible pressure 15 MPa Water flow rate 8 2 l mi
12. sposal but arrange for the proper recycling 9 Old appliances contain valuable ma x terials that can be recycled Please arrange for the proper recycling of old appliances Please dispose your old appliances using appropriate collec tion systems Warranty The warranty terms published by our com petent sales company are applicable in each country We will repair potential fail ures of your appliance within the warranty period free of charge provided that such failure is caused by faulty material or de fects in fabrication In the event of a warran ty claim please contact your dealer or the nearest authorized Customer Service cent er Please submit the proof of purchase See address on the reverse Safety Devices Caution Safety devices protect the user and must not be modified or bypassed Power switch The appliance switch prevents unintention al operation of the appliance Lock trigger gun This lock locks the lever of the trigger gun and prevents the inadvertent start of the ap pliance Safety instructions A n Danger Never touch the mains plug and the socket with wet hands The appliance must not be used if the power cord or important parts of the ap pliance e g high pressure hoses trig ger gun or safety devices are damaged Check the power cord with mains plug for damage before every use If the power cord is damaged please arrange immediately for the exchange by an au thorized customer
13. ve air from appliance before oper ation Switch on the appliance without mount ed spray lance and run it until the water discharging from the trigger gun is free of bubbles Switch off appliance and connect spray lance Start up Caution Use the high pressure cleaner only when you have mounted the water filter Never operate the high pressure cleaner when the tap is turned off as dry running will damage the high pressure pump gt Unwind the high pressure hose from the hose drum gt Push the spray lance into the trigger gun and fasten it by turning it through 90 Completely open the water tap Insert the mains plug into the socket Turn on the appliance I ON Yyy Operation A Danger The trigger gun is subjected to a recoil force when the water jet is discharged Make sure that you have a firm footing and are also holding the trigger gun and spray lance firmly gt Illustration I see page 13 Unlock the lever on the trigger gun gt Pull on the lever of the trigger gun the device will switch on Note Release the lever of the trigger gun the device will switch off again High pres sure remains in the system Spray lance with pressure regulation Carrying out the most common cleaning tasks The work pressure can be stageless ly regulated between Min and Max gt Release the lever on the trigger gun gt Turn the spray lance to the desired po sition Spray lance with dirt blaster
Download Pdf Manuals
Related Search