Karcher K 4.93 M User's Manual
Contents
1. pliance switch or remove the mains plug Do not operate the appliance at temper atures below 0 C Observe a distance of at least 30 cm when using the jet to clean painted sur faces to avoid damaging paintwork Never leave the appliance unattended when it is in operation Make sure that the power cable or ex tension cables are not damaged by run ning over pinching dragging or similar Protect the power cable from heat oil and sharp edges All current conducting parts in the work ing area must be protected against jet water The appliance may only be connected to an electrical supply which has been installed in accordance with IEC 60364 The appliance may only be connected to alternating current The voltage must correspond with the type plate on the appliance The maximum tolerable mains imped ance at the electrical contact point see Technical Data must not be exceeded For safety reasons we recommend that you operate the appliance only via a earth leakage circuit breaker max 30 mA Cleaning operations which produce oily waste water e g engine washes un derbody washes may only be carried out using washing stations equipped with an oil separator This appliance was designed to be used with detergents which are supplied or recommended by the manufacturer The use of other detergents or chemi cals may compromise the safety ofthe appliance Safety Devices Caution Safety devices protect the user an2. ter supply Drawing in water from open reservoirs This high pressure cleaner is suited to work with the KARCHER suction hose with back flow valve Optional accessory order no 4 440 238 to draw in surface water e g from water butts or ponds see specifica tions for max suction height gt Fill the K RCHER suction hose with backflow valve with water screw to wa ter supply and hang into he water butt gt Separate the high pressure hose from the high pressure connection of the ap pliance gt Switch the appliance on I ON for a max of 2 minutes and wait until the wa ter exits the high pressure connection without bubbles gt Turn off the appliance 0 OFF Start up Caution Dry runs lasting longer than two minutes lead to damages to the high pressure pump If the appliance does not build up pressure within two minutes switch it off and proceed as instructed in the Chapter Help with faults gt Connect the high pressure hose to the high pressure connection of the appli ance gt Push the spray lance into the trigger gun and fasten it by turning it through 90 Completely open the water tap Insert the mains plug into the socket Turn on the appliance ON Yyy Operation Danger The trigger gun is subjected to a recoil force when the water jet is discharged Make sure that you have a firm footing and are also holding the trigger gun and spray lance firmly gt Un
3. Tamaki Auckland Z 09 274 4603 P Neoparts Com e Ind Autom vel Lda Largo Vitorino Damasio 10 1200 Lisboa m 21 3950 040 PL Karcher Sp z 0 0 Ul Stawowa 140 31 346 Krak w m 012 6397 222 PRC Karcher Cleaning Systems Co Ltd Part B Building 30 No 390 Ai Du Road Shanghai Waigaoquiao 200131 m 021 5046 3579 RO Karcher Romania s r l Sos Odaii Nr 439 013606 Bucuregti m 0372709001 RUS 000 Kepxep 109147 MockBa yn TaraHckaa 0 34 cTp 3 7 495 228 39 45 S K rcher AB Tagenev gen 31 42502 Hisings K rra m 031 577 300 SGP Karcher Asia Pacific Pte Ltd 5 Toh Guan Road East 01 00 Freight Links Express Distripark Singapore 608831 T 6897 1811 SK K rcher Slovakia s r o Beniakova 2 94901 Nitra m 037 6555 798 TR K rcher Servis Ticaret A S 9 Eyl l Mahallesi 307 Sokak No 6 Gaziemir Izmir m 0232 252 0708 TWN Karcher Limited 5F 6 No 7 Wu Chuan 1st Rd Wu Ku Industrial Zone Taipei County T 02 2299 9626 UA K rcher Ukraine Kilzeva doroga 9 03191 Kyiv T 044 594 75 75 UAE Karcher FZE Jebel Ali Free Zone RA 8 XB 1 Jebel Ali Dubai m 04 8836 776 USA Alfred Karcher Inc 2170 Satellite Blvd Suite 350 Duluth GA 30097 T 678 935 4545 877 527 2437 ZA Karcher Pty Limited 144 Kuschke Street Meadowdale Edenvale 1614 m 011 574 5360 KARCHER www kaercher com
4. Check the detergent suction hose for kinks English 9 Specifications Power connection Voltage 240 V 1 50 Hz Connected load 1 9 KW Mains fuse slow blow 10 A Protective class I Protection class IP X5 Water connection Max feed temperature 40 C Min feed volume 10 l min Max feed pressure 1 2 MPa Performance data Working pressure 12 MPa Max permissible pressure 13 MPa Max Suction height 0 5 m Water flow rate 6 7 l min Detergent flow rate 0 0 3 l min Recoil force of trigger gun 15N Hand arm vibration 0 8 m s ISO 5349 Sound pressure level 74 5 dB A Lpa EN60704 1 Sound power level 87 dB A Lwa 2000 14 EG Dimensions Length 290 mm Width 340 mm Height 805 mm Weight 12 5 kg Subject to technical modifications 10 English CE declaration We hereby declare that the machine de scribed below complies with the relevant basic safety and health requirements ofthe EU Directives both in its basic design and construction as well as in the version put into circulation by us This declaration shall cease to be valid ifthe machine is modified without our prior approval Product High pressure cleaner Type 1 636 xxx Relevant EU Directives 98 37 EC 2006 95 EC 2004 108 EC 2000 14 EC Applied harmonized standards EN 60335 1 EN 60335 2 79 EN 55014 1 2006 EN 55014 2 1997 A1 2001 EN 61000 3 2 2006 EN 61000 3 3 1995 A1 2001 A2 2005 Applied conformity evaluation method Appendix
5. KARCHER nenn Sa K 4 93 M Operating Instructions Before first use of the unit Please read these Operating Instructions and act in accor dance with them AU 59632480 02 09 Dear Customer AU Please read and comply with these original operating instruc tions prior to the initial operation of your ap pliance and store them for later use or subsequent owners General information Hazard levels Proper Use Environmental protection Warranty Proper Use This high pressure cleaner is designed for domestic use only to clean machines vehicles buildings tools facades terraces garden equip ment etc using a high pressure water jet and detergents if required with accessories replacement parts and detergents approved by KARCH ER Observe the instructions provided with these detergents Environmental protection Safety instructions Safety Devices Operation Description of the Appliance Before Startup Water supply Start up Operation Operation with detergent Interrupting operation Finish operation Maintenance and care Troubleshooting Specifications CE declaration General information Hazard levels Ol O ol ol CO W W wal ol Ol gt gt w w co I w _ Danger Immediate danger that can cause severe injury or even death Warning Possible hazardous situatio
6. Pol Industrial Font del Radium Calle Doctor Trueta 6 7 08400 Granollers Barcelona Z 902 170 068 F K rcher S A S 5 Avenue des Coquelicots Z A des Petits Carreaux 94865 Bonneuil sur Marne Z 01 43 996 770 FIN K rcher OY Yritt j ntie 17 01800 Klaukkala Z 0207 413600 GB K rcher UK Limited K rcher House Beaumont Road Banbury Oxon OX16 1TB m 01295 752 200 GR K rcher Cleaning Systems A E 31 33 Nikitara str amp Konstantinoupoleos str 13671 Acharnes m 210 2316 153 H Karcher Hung ria Kft Torm sr t ut 2 2051 Biatorbagy Z 023 530 640 HK K rcher Limited Unit 10 17 F APEC Plaza 49 Hoi Yuen Road Kwun Tong Kowloon m 02 357 5863 I Karcher S p A Via A Vespucci 19 21013 Gallarate VA m 848 99 88 77 IRL Karcher Limited 12 Willow Business Park Nangor Road Clondalkin Dublin 12 m 01 409 77 77 KOR Karcher Co Ltd South Korea Youngjae B D 50 1 51 1 Sansoo dong Mapo ku Seoul 121 060 T 032 465 8000 MAL Karcher Cleaning Systems Sdn Bhd No 8 Jalan Serindit 2 Bandar Puchong Jaya 47100 Puchong Selangor Z 03 5882 1148 MEX Karcher M xico SA de CV Av Gustavo Baz No 29 C Col Naucalpan Centro Naucalpan Edo de M xico C P 53000 M xico m 01 800 024 13 13 N K rcher AS Stanseveien 31 0976 Oslo Z 24177700 NL K rcher BV Postbus 474 4870 AL Etten Leur m 0900 33 444 33 NZ Karcher Limited 12 Ron Driver Place East
7. V Sound power level dB A Measured 84 Guaranteed 87 The undersigned act on behalf and under the power of attorney ofthe company man agement ie WV Coser H Jenner S Reiser CEO Head of Approbation Alfred Karcher GmbH Co KG Alfred Karcher Str 28 40 D 71364 Winnenden Phone 49 7195 14 0 Fax 49 7195 14 2212 2 641 610 0 2 880 296 0 2 641 706 0 AS 410 0 y w 9 011 711 0_ 9 011 711 0 9 011 711 0_ I Pe 9 011 711 0 9 037 167 0 za A 2 640 729 0 a 4 760 534 0 6 389 870 0 5 963 248 0 01 09 A Alfred K rcher Ges m b H Lichtblaustra e 7 1220 Wien m 01 250 600 AUS K rcher Pty Ltd 40 Koornang Road Scoresby VIC 3179 Z 03 9765 2300 B LUX K rcher N V Industrieweg 12 2320 Hoogstraten T B 0900 10027 LUX 0032 900 10027 BR K rcher Industria e Com rcio Ltda Av Prof Benedicto Montenegro 419 CEP 13 140 000 Paulinia SP 0800 176 111 CDN K rcher Canada Inc 6975 Creditview Road Unit 2 Mississauga Ontario L5N 8E9 Z 1 800 465 4980 CH K rcher AG Industriestra e 16 8108 D llikon T 0844 850 863 cz Karcher spol s r o Modletice p 141 251 01 Ricany u Prahy m 0323 606 014 D Alfred K rcher GmbH amp Co KG Service Center Gissigheim Im Gewerbegebiet 2 97953 K nigheim Gissigheim m 07195 903 2065 DK Karcher Rengoringssystemer A S Gejlhavegard 5 6000 Kolding Z 70206 667 E K rcher S A
8. d must not be modified or bypassed Power switch The appliance switch prevents unintention al operation of the appliance Lock trigger gun This lock locks the lever of the trigger gun and prevents the inadvertent start ofthe ap pliance Overflow valve with pressure switch The overflow valve prevents the permissi ble working pressure from being exceeded Ifthe lever on the trigger gun is released the pressure switch turns off the pump the high pressure jet ist stopped Ifthe lever is pulled the pump is turned on again English 5 Scope of delivery The scope of delivery of your appliance is il lustrated on the packaging Check the con tents of the appliance for completeness when unpacking In the event of missing accessories or any transport damage please contact your dealer Description of the Appliance These operating instructions describe the maximum equipment Depending on the model there are differences in the scopes of delivery see packaging Illustrations on Page 2 Coupling element for water connection Connection for water supply with filter Dosage regulator for detergent Suction hose for detergent Transport handle Detergent Tank Storage for trigger gun Storage for accessories 9 Power cable with plug 10 ON OFF switch for appliance 11 High pressure connection 12 Trigger gun 13 Lock trigger gun 14 High pressure hose 15 Spray lance with Dirtblaster 16 Spray lance with pressure regulation Var
9. e before every use Ifthe power cord is damaged please arrange for it to be replaced immediately by an authorised repair agent or a skilled elec trician Check the high pressure hose for dam age before every use Please arrange for the immediate replacement ofa damaged high pressure hose The appliance may not be usedin areas where a risk of explosion is present Ifthe appliance is used in hazardous ar eas e g filling stations the corre sponding safety provisions must be observed High pressure jets can be dangerous if improperly used The jet must not be directed at persons ani mals live electrical equipment or at the appliance itself The high pressure jet must not be di rected at other persons or directed by the user at him herself to clean clothing or footwear Never use the appliance to clean ob jects containing hazardous substances e g asbestos Vehicle tyres or tyre valves are suscep tible to damage from the high pressure jet and may burst The first indication of this is a discolouration of the tyre Dam aged vehicle tyres tyre valves are highly dangerous Ensure that a distance of at least 30 cm is observed when cleaning with the jet 4 English Never draw in fluids containing solvents or undiluted acids and solvents This in cludes petrol paint thinner and heating oil The spray mist thus generated is highly inflammable explosive and poi sonous Do not use acetone undiluted acids and solve
10. gulator to the right Additional dosage from the right detergent tank Recommended cleaning method gt Spray the detergent sparingly on the dry surface and allow it to react but not to dry gt Spray off loosened dirt with the high pressure jet English 7 Interrupting operation gt Release the lever on the trigger gun gt Lock the lever on the trigger gun During longer breaks more than 5 min utes also turn the appliance off using the O OFF switch gt Insert the trigger gun in its holder Finish operation Caution Only separate the high pressure hose from the trigger gun or the appliance while there is no pressure in the system gt After working with detergent suspend detergent suction hose in a container filled with clear water switch the appli ance on for around 1 minute once the spray lance has been removed and rinse until water runs clear Release the lever on the trigger gun Turn off the appliance 0 OFF Turn off tap Detach the appliance from the water supply Press the lever on the trigger gun to re lease any remaining pressure in the system Lock the lever on the trigger gun Pull out the mains plug Insert the trigger gun in its holder Stow away the mains cable the high pressure hose and accessory at the ap pliance Y by yy Yhyy 8 English Maintenance and care Danger Turn off the appliance and remove the mains plug prior to any care and mainte nance
11. io Power Special accessories Special accessories expand the possibili ties of using your appliance Please contact your K RCHER dealer for further informa tion NOO NN 6 English Before Startup Illustrations on Page 2 Illustration EN E Mount loose parts delivered with appli ance prior to start up Illustration D gt Push the high pressure hose into the trigger gun until it locks audibly Note Make sure the connection nipple is aligned correctly gt Check the secure connection by pulling on the high pressure hose Water supply According to the applicable regula tions the appliance must never be used on the drinking water supply without a system separator Use a suitable system separator manufactured by KARCHER or as an alternative a system separator as per EN 12729 Type BA Water flowing through a system separator is con sidered non drinkable Note Impurities in the water can damage the high pressure pump and accessories For protection the use of the KARCHER water filter optional accessory order no 4 730 059 is recommended Water supply from mains Observe regulations of water supplier For connection values see type plate tech nical data gt Use a fibre reinforced water hose not included with a standard coupling Minimum diameter 1 2 inch 13 mm minimum length 7 5 m gt Push the water supply hose onto the coupling unit then connect it to the wa
12. lock the lever on the trigger gun gt Pull on the lever of the trigger gun the device will switch on Note Release the lever of the trigger gun the device will switch off again High pres sure remains in the system Spray lance with pressure regulation Carrying out the most common cleaning tasks The work pressure can be stageless ly regulated between Min and Max gt Release the lever on the trigger gun gt Turn the spray lance to the desired po sition Spray lance with Dirtblaster For particularly dirty items or areas Not suitable for use with detergents Operation with detergent Please use exclusively KARCHER deter gents and care products to carry out the re spective cleaning task as these were specifically developped for your appliance The use of other detergents and care prod ucts may lead to premature wear and can invalidate your warranty claims Please ob tain information at your local dealer or re quest information directly from KARCHER gt Use spray lance with pressure regula tion Vario Power gt Turn the spray lance to Mix position low pressure gt Fill the detergent solution in the deter gent tank observe dosage instructions on the packaging of the detergent gt Adjust the suction volume of the deter gent solution by means of the dosage regulator for detergents Turning the regulator to the left Addi tional dosage from the left detergent tank Turning re
13. n that could lead to severe injury or even death Caution Possible hazardous situation that could lead to mild injury to persons or damage to property Qy The packaging material can be recy ES cled Please do not place the packag ing into the ordinary refuse for disposal but arrange for the proper recycling Old appliances contain valuable ma terials that can be recycled Please m arrange for the proper recycling of old appliances Please dispose your old appli ances using appropriate collection sys tems Notes about the ingredients REACH You will find current information about the ingredients at http www karcher de de unternehmen umweltschutz REACH htm Warranty The warranty terms published by the rele vant sales company are applicable in each country We will repair potential failures of your appliance within the warranty period free of charge provided that such failure is caused by faulty material or defects in man ufacturing In the event of a warranty claim please contact your dealer or the nearest authorized Customer Service centre Please submit the proof of purchase See address on the reverse English 3 Safety instructions Danger Never touch the mains plug and the socket with wet hands The appliance must not be used if the power cord or important parts of the ap pliance e g high pressure hoses trig ger gun or safety devices are damaged Check the power cord and mains plug for damag
14. nts as they are damag ing to the materials from which the ap pliance is made Warning The mains plug and the coupling of an extension cable must be watertight and must never lay in the water Unsuitable extension cables can be hazardous Only use extension cables outdoors which have been approved for this purpose and labelled with a suffi cient cable cross section 1 10 m 1 5 mm 10 30 m 2 5 mm Always fully unroll electrical cables from the cable drum High pressure hoses fixtures and cou plings are important forthe safety ofthe appliance Only use high pressure hos es fixtures and couplings recommend ed by the manufacturer The operator must use the appliance correctly When working with the appli ance he must consider the local condi tions and pay due care and attention to other persons in particular children who are nearby Do not use the appliance when there are other persons around unless they are also wearing safety equipment Wear protective clothing and safety goggles to protect against splash back containing water or dirt Caution This appliance is notintended for use by persons with reduced physical sensory or mental capabilities The appliance must not be operated by children or persons who have not been instructed accordingly Children should be supervised to pre vent them from playing with the appli ance In case of extended downtimes switch the appliance off at the main switch ap
15. ther the voltage indicated on the type plate corresponds to the volt age of the mains supply Check the mains connection cable for damages Pressure does not build up in the appliance Check setting at the spray lance gt Appliance ventilation Switch the appli ance on with the high pressure hose de tached and operate max 2 minutes until the water exits the high pressure connection without bubbles Switch off appliance and reconnect high pressure hose Check the water supply Pull out the sieve in the water connec tion using flat nose pliers and clean un der running water Appliance does not start motor hums Cause Voltage reduction due to weak mains supply or when using an extension cable gt When switching on first pull the lever of the trigger gun and then switch the ap pliance switch to I ON Strong pressure fluctuations gt Clean high pressure nozzle Remove dirt and debris from the nozzle bore us ing a needle and rinse through with wa ter from the front gt Check water flow quantity gt gt Appliance is leaking gt Slight leakage from the appliance pump is normal If the leakage increases con tact the authorized customer service No detergent infeed gt Use spray lance with pressure regula tion Vario Power Turn the spray lance to Mix position gt Check the settings at the dosage regu lator for detergent gt Clean the detergent suction hose filter gt
16. work Maintenance The appliance is maintenance free Storage Prior to longer periods of storage e g in the winter gt Completely drain all water from the ap pliance Switch the appliance on with detached high pressure hose and de tached water supply max 1 minute and wait until no more water exits at the high pressure connection Turn off the appliance gt Remove filter from suction hose for de tergent and clean under running water gt Pull out the sieve in the water connec tion using flat nose pliers and clean un der running water Frost protection Caution Protect the appliance and its accessories against frost The appliance and its accessories can get destroyed through frost if there are any wa ter residues in them To avoid damage to them gt Store the appliance and the entire ac cessories in a frost safe room Spare parts Use only original K RCHER spare parts You will find a list of spare parts at the end of these operating instructions Troubleshooting You can rectify minor faults yourself with the help of the following overview If in doubt please consult the authorized customer service Danger Turn offthe appliance and remove the mains plug prior to any care and mainte nance work Repair works may only be performed by the authorized customer service Appliance is not running gt Pull on the lever of the trigger gun the device will switch on gt Check whe
Download Pdf Manuals
Related Search