Johnson Hardware 2222 Series User's Manual
Contents
1. For 13 Doors Up to 50 Ibs single wheel hanger 2222 Series double whee hanger www johnsonhardware com SLI DI NG DOOR HAR DWAR E OPENING SIZES PREPARE OPENING sd ale et opening H ae tH Straight Stated dimensions allow for shim gst 2165 STOPS 4 DOOR SETS ming of finished jamb Place header ends into dado of side jambs and nail in place Place assembled frame into rough opening and shim in place being certain that FRONT edge is on room side See diagram Fasten track to rough header with screw through hole in center of track Do not overtighten Opening may be finished with trim at this time SE OPENING 3 x DR WIDTH 14 4 gt 4 DOORS Finish doors ON ALL SURFACES before mounting hangers This seals against moist ure which causes warping Fasten hangers 2po0r FINISH OPENING 2 x DR WIDTH 34 2165 STOP 2165 STOPS on BACK side of doors 1 from each edge i empory er hangers to highest posi ERE A aOR tion for easier hanging Screws must be 4 DOOR V a k ef N placed at top end of slots when hanger is He FINISH OPENING 4 x DR WIDTH 144 _ _ _ gt in the lowest position 1 1 4 8 PAN Holes for pulls may be drilled at this time or after doors are hung Holes must be large enough to avoid splitting but snug enough to hold pull in place If holes are too large wrap tape around pull Hang back door first Tilt top of doo2. r back and place both hangers on rear rail of track Let hang free Repeat with front door on front rail Adjust hangers to raise doors as high as possible keeping door edges square with DOOR GUIDE side jambs Push doors to one side of opening Place Guide between doors flush with edge Plumb doors with door casing and fasten FRONT guide in place DOOR sox DOOR HEIGHT ROOM SIDE 5 DOOR lt 2 NOTE OPTIONAL ACCESSORIES Is are available in z When using Pulthres finishes x yy or 134 ere thick doors 8 O a write factory for type of Hy OFFSET 3 OFFSET 21 PULL hangers to use DOORS TO DOORS TO i 35 Ibs 75 Ibs ERRA 35 PULL 40 PULL WOODTONE ONLY 5 S 30 PULL J O 17 PULL NYLON Vie T OFFSET Mig POFFSET FOR 1 4 OR 134 DOORS PaL OPTIONAL CARPET RISER 2136 If carpet riser is used cut A F4 ets A BU 54 from door bottoms cane T Se VIRE OR 13 DOORS L E JOHNSON PRODUCTS INC 2100 STERLING AVE ELKHART IN 46516 574 293 5664 IN222SD_ Rev 9 05
Download Pdf Manuals
Related Search