Huffy M580001 User's Manual
Contents
1. FAILURE FOLLOW THESE WARNINGS MAY RESULT IN SERIOUS INJURY AND OR PROPERTY DAMAGE Owner must ensure that all players know and follow these rules for safe operation of the system DO NOT HANG on the rim or any part of the system including backboard support braces or net During play especially when performing dunk type activities keep player s face away from the backboard rim and net Serious injury could occur if teeth face come in contact with backboard rim or net Do not slide climb shake or play on base and or pole After assembly is complete fill system completely with water or sand Never leave system in an upright position without filling base with weight as system may tip over causing injuries When adjusting height or moving system keep hands and fingers away from moving parts Do not allow children to move or adjust system During play do not wear jewelry rings watches necklaces etc Objects may entangle in net Surface beneath the base must be smooth and free of gravel or other sharp objects Punctures cause leakage and could cause system to tip over Keep organic material away from pole base Grass litter etc could cause corrosion and or deterioration Check pole system for signs of corrosion rust pitting chipping and repaint with exterior enamel paint If rust has penetrated through the steel anywhere replace pole immediately Check system before each u2. 1 1 1 2 4 1 1 3 1 1 1 Part No 20664903 918130 918133 918132 203099 20378701 203223 203617 203740 201344 908134 908129 203739 203218 203309 203679 203100 910454 910255 204178 PARTS LIST Description Tank Black Top Pole Section Middle Pole Section with Label Bottom Pole Section Nut Ny Lock 5 16 18 Net Cap Pole Bolt Carriage 5 16 18 x 1 Long Cap Tank Bolt Hex 5 16 18 x 2 63 Long Knob Plastic 3 sided Rim Backboard Backboard Mounting Bracket Rim Bracket Bolt Carriage 5 16 18 x 3 25 Long Washer Flat 5 16 Washer Flat 1 0 O D Bolt Hex 3 8 16 x 2 Long Nut Flange 5 16 18 Strut Left Strut Right Label Height Adjustment You may have extra parts with this model 05 05 ID 580001 PARTS IDENTIFIER Actual Size og 9 5 1 17 4 LL QU AY H 19 1 SZ 20 3 10 1 PARTS IDENTIFIER Not Actual Size 22 1 10 M580001 05 05 6 SECTION A ASSEMBLE THE POLES 1 Correctly identify each pole section Poles have an identification sticker g that will be used as a reference point in the next step Reference Stickers BOTTOM 7 05 05 1 580001 IMPORTANT ONCE POLE SECTIONS POUNDED TOGETHER THEY CANNOT BE TAKEN APART middle poles together by bouncing them on a scrap piece of li t k wood on the ground as shown in FIG A until they no longer move toward
3. for leakage Slow leaks could cause the system to tip over unexpectedly Seat the pole sections properly if applicable Failure to do so could allow the pole sections to separate during play and or during transport of the system Climate corrosion or misuse could result in system failure If technical assistance is required contact Huffy Sports Minimum operational height 15 6 6 1 98m to the bottom of backboard NOTICE TO ASSEMBLERS ALL Sports basketball systems including those used for DISPLAYS MUST be assembled and ballasted with sand or water according to instructions Failure to follow instructions could result in SERIOUS INJURY It is NOT acceptable to devise a makeshift weight system IMPORTANT Remove all contents from boxes Be sure to check inside pole sections hardware and additional parts are packed inside Questions or Missing Parts DONT go hack to store edens man i U www huffysports com warrantycard mail in CallTOLL FREE Customer Service the enclosed postcard Number listed on the front page WARRANTY CARD 3 05 05 10 M580001 ELEVATOR ASSEMBLY 7 7 77 Yn 2 Y 3 E 5 gt Y x 2 Q Q gt x MIDDLE POLE 05 05 ID M580001 Silver Qty O1 O EEE eye 1 1 1 1 1 1 1 3 1 1 2 1
4. pole identification stickers add bottom pole section and pound together in the same way 2 Align poles using alignment marks First pound top and THE IDENTIFICATION STICKER IS LOCATED 3 3 4 FROM THE END OF THE POLE WHEN PROPERLY POUNDED TOGETHER THE POLE SECTIONS SHOULD HAVE A 2 1 2 MINIMUM OVERLAP LEAVING 1 1 4 BETWEEN THE OVERLAPPING POLE AND THE IDENTIFICATION STICKER alignment mark MIDDLE IDENTIFICATION STICKER scrap wood Not Supplied alignment mark BOTTOM IDENTIFICATION fr ICKER ID M580001 05 05 8 Attach pole assembly to tank as shown Secure pole assembly to tank by turning the pole assembly clockwise as shown CAREFULLY TIPPING THE SYSTEM FORWARD WILL ALLOW EASIER ACCESS TO UNDERSIDE OF BASE TWO PEOPLE REQUIRED FOR THIS PROCEDURE FAILURE TO FOLLOW THIS WARNING COULD RESULT IN SERIOUS INJURY PROPERTY DAMAGE 9 05 05 10 M580001 4 Secure tank struts 21 amp 22 to pole E TIGHTEN BOLT 10 IN LOCK NUT 5 UNTIL FLUSH EVEN WITH LOCK NUT S OUTER EDGE FAILURE TO FOLLOW THIS WARNING COULD RESULT IN SERIOUS INJURY AND OR PROPERTY DAMAGE Rotate struts down and bend struts outward to line up with holes on base as shown Secure free ends of tank struts to tank with carriage bolt 8 and nut 20 as shown Repeat for other side ID M580001 05 05 Pole bracket will need to be lightly pressed into backboard rib
5. REQUIRED MATERIALS ADIVISION OF RUSSELL CORPORATION 2People Portable System Owners Manual Wood Board Customer Service Center N53 W24700 South Corporate Circle Sussex WI 53089 U S A scrap Sawhorse or Support Table 2 each Wrenches and or Socket Wrenches and Sockets pm 12 9 16 AND OR Write Model Number 9 16 READ AND UNDERSTAND From Box Here OPERATOR S MANUAL BEFORE USING THIS UNIT 1 2 FAILURE TO FOLLOW PERATING INSTRUCTIONS OPTIONAL TOOLS COULD RESULT IN INJURY AND MATERIALS OR DAMAGE TO PROPERTY 9 Toll Free Customer Service Number for U S 1 800 558 5234 hus For Canada 1 800 284 8339 For Europe 00 800 555 85234 Sweden 009 555 85234 For Australia 1 800 632 7921 Internet Address http www huffysports com COPYRIGHT 2005 by HUFFY SPORTS 1 05 05 ID M580001 HEIGHT ADJUSTMENT Rest unit on support table Remove adjustment knobs A and carriage bolts B to extend or retract backboard and rim Height adjustment from 4 1 2 6 1 2 AWARNING Backboard may rotate during height adjustment AWARNING Do not adjust height of system in upright position System must be in down position to adjust 204178 05 04 ID M580001 05 05 A WARNING FAILURE TO FOLLOW THESE WARNINGS MAY RESULT IN SERIOUS INJURY AND OR PROPERTY DAMAGE Owner must ensure that all players know and follow these r
6. bing Be sure to press completely into place Attach rim to backboard and pole bracket 14 with nut 20 reinforcement bracket 15 and carriage bolt 8 as shown Tighten nut completely BOARD STYLE MAY VARY PRESS BRACKET 14 INTO PLACE Carefully tip unit forward and slide backboard assembly onto pole as shown SAWHORSE OR SUPPORT TABLE 11 05 05 10 M580001 Attach board assembly to pole with carriage bolts 16 and knobs 11 as shown Install pole cap 7 as shown liters or sand approx 170 16 77 kg and snap tank cap 9 in place Place assembled unit in desired location Fill tank completely with water 14 gallons 53 8 ADD ONE GALLON 3 78 LITERS OF NON TOXIC ANTIFREEZE IN SUB FREEZING CLIMATES IF USING SAND 2 GALLONS OF ANTI FREEZE IS NOT REQUIRED 10 M580001 05 05 12 Install net 6 Attach height and moving label 23 to front of e pole as shown Regulation rim height is 10 feet READ AND UNDERSTAND FAILURE TO FOLLOW OPERATING INSTRUCTIONS COULD RESULT IN INJURY OR DAMAGE TO PROPERTY HEIGHT ADJUSTMENT Rest unit on support table Remova adjustment knobs A and cariage bolts B to extend or retract backboard and rim Height erent rm WARNING Backboard may rotate during height adjustment AAWARNING Dori adus height of sys in upright postion System must be in down positon to adjust
7. evere weather conditions system may tip over Place system in the storage position and or in an area protected from the wind and free from personal property and or overhead wires Never play on damaged equipment See instruction manual for proper installation and maintenance When moving system use caution to keep mechanism from shifting Keep pole top covered with cap at all times Do not allow water in tank to freeze During sub freezing weather add non toxic antifreeze sand or empty tank completely and store Do not use salt Use extreme caution if placing system on sloped surface System may tip over more easily HUFFY SPORTS In the U S 1 800 558 5234 and Canada 1 800 284 8339 For Europe 00 055 85234 Sweden 009 555 85234 For Australia 1 800 632 792 203782 07 04 SAFETY INSTRUCTIONS A FAILURE TO FOLLOW THESE SAFETY INSTRUCTIONS MAY RESULT IN SERIOUS INJURY OR PROPERTY DAMAGE AND WILL VOID WARRANTY Owner must ensure that all players know and follow these rules for safe operation of the system To ensure safety do not attempt to assemble this system without following the instructions carefully Proper and complete assembly use and supervision are essential for proper operation and to reduce the risk of accident or injury A high probability of serious injury exists if this system is not installed maintained and operated properly If using a ladder during assembly use extreme caution Check base regularly
8. se for proper ballast loose hardware excessive wear and signs corrosion and repair before use Check system before each use for instability Do not use system during windy and or severe weather conditions system may tip over Place system in the storage position and or in an area protected from the wind and free from personal property and or overhead wires Never play on damaged equipment See instruction manual for proper installation and maintenance When moving system use caution to keep mechanism from shifting Keep pole top covered with cap at all times Do not allow water in tank to freeze During sub treezing weather add non toxic antifreeze sand or empty tank completely and store Do not use salt Use extreme caution if placing system on sloped surface System may tip over more easily HUFFY SPORTS In the U S 1 800 558 5234 and Canada 1 800 284 8339 203782 0504 13 05 05 1 M580001 ID M580001 05 05 HEIGHT ADJUSTMENT HEIGHT AND MOVING LABEL MUST NOT OBSTRUCT FACTORY ATTACHED WARNING LABEL DO NOT LEAVE ASSEMBLY UNATTENDED WHEN EMPTY IT MAY TIP OVER 14
9. ules for safe operation of the system DO NOT HANG on the rim or any part of the system including backboard support braces or net During play especially when performing dunk type activities keep player s face away from the backboard rim and net Serious injury could occur if teeth face come in contact with backboard rim or net Do not slide climb shake or play on base and or pole After assembly is complete fill system completely with water or sand Never leave system an upright position without filling base with weight as system may tip over causing injuries When adjusting height or moving system keep hands and fingers away from moving parts Do not allow children to move or adjust system During play do not wear jewelry rings watches necklaces etc Objects may entangle in net Surface beneath the base must be smooth and free of gravel or other sharp objects Punctures cause leakage and could cause system to tip over Keep organic material away from pole base Grass litter etc could cause corrosion and or deterioration Check pole system for signs of corrosion rust pitting chipping and repaint with exterior enamel paint If rust has penetrated through the steel anywhere replace pole immediately Check system before each use for proper ballast loose hardware excessive wear and signs of corrosion and repair before use Check system before each use for instability Do not use system during windy and or s
Download Pdf Manuals
Related Search