Hans Grohe 35807801 User's Manual
Contents
1. Axor Steel 35807801 Axor Steel Kitchen Faucet 35807801 A A 2 1 E Y yy A A 81 16 3 8 Max water pressure 145 PSI Recommended water pressure 45 72 5 PSI Recommended hot water temp 120 140 F Hole size in mounting surface 11 2 Max mounting surface thickness 2 1 4 Flow rate 2 2 GPM Please know and follow all applicable local codes when setting the temperature on the water heater In Massachusetts the water heater may be set no higher than 1 12 F Installer Notes Significant pressure differences between the hot and cold water supplies should be corrected The supply hoses on this faucet require 3 8 compression fittings not included Backflow prevention is provided by check valve in the sprayhead 2 Preparation for Installation Turn the water supplies off before removing the old faucet Flush the supply lines of debris before beginning installation Damage to the cartridge caused by debris is not covered under the Hansgrohe limited lifetime warranty Install the faucet Position the faucet and sealing ring on top of the mounting surface From beneath install the plastic washer slide washer and metal washer Thread on the collar nut loosely If the total thickness of the mounting surface is greater than 1 3 8 omit the plastic washer Inspect the placement of the faucet Reposition if necessary The spout should swivel equa2. Turn off the water at the supply stops Close the drain or cover it with a cloth Gently pry off the screw cover Put it aside in a safe place Use a 4mm hex wrench to loosen the handle screw 4 revolutions Remove the handle and the decorative flange underneath Remove the nut Remove the handle screw from the stem of the cartridge Remove the high temperature limit stop Replace the high temperature limit stop so that the pin is in the desired notch The temperatures marked on the diagram assume an incoming hot water temperature of 140 F and an incoming cold water temperature of 50 F and a water pressure of 45 psi Your results will vary IN Ben SR 100 F AY LA 122 F 108 F BT F 95 F Replace the nut nut cover screw and handle User Instructions Turn the water on by raising the handle Lower the handle to turn the water off Pivot the handle to the right for cooler water to the left for warmer water When the faucet is turned on the sprayhead is in the stream mode Press the button on top of the sprayhead to activate the spray mode When the water is turned off the sprayhead will revert to the stream mode The spray channels on the handspray use the Rubit cleaning system If mineral deposits are noticed in the spray channels turn the water on lightly and wipe the spray channels with your thumb or with a cloth If the flow of water diminishes over time remove and clean
3. the filter located at the end of the handspray hose Replacement Parts OONAnARWN N 0 handle screw cover flange nut M3 cartridge hose handspray aerator mounting set check valve connection hose hose weight squeezing connection 35891800 94186000 97650800 94194000 92730000 95048000 35893800 97691000 95049000 97350000 96510000 98551000 96099000 Cleaning Recommendation for Hansgrohe Products Modern lavatory faucets kitchen faucets and showers consist of very different materials to comply with the needs of the market with regard to design and functionality To avoid damage and returns it is necessary to consider certain criteria when cleaning Cleaning Materials for Faucets and Showers Acids are a necessary ingredient of cleaning materials for removing lime however please pay attention to the follow ing points when cleaning faucets and showers e Only use cleaning materials which are explicitly intended for this type of application e Never use cleaning materials which contain hydrochloric formic phosphoric or acetic acid as they cause considerable damage Never mix one cleaning material with another Never use cleaning materials or appliances with an abrasive effect such as unsuitable cleaning powders sponge pads or micro fiber cloths Cleaning Instructions for Faucets and Showers Please follow the cleaning material manufacturer s instru
4. Bluegrass Lakes Parkway e Alpharetta GA 30004 Tel 770 360 9880 e Fax 770 360 9887 www hansgrohe USA com US Installation Instructions e Part No 90870404 e Revised 06 2007
5. ansgrohe manufactured product Hansgrohe warrants this product against defects in material or workmanship as follows Hansgrohe will repair at no charge for parts only or at its option replace any product or part of the product that proves defective because of improper workmanship and or material under normal installation use service and maintenance If Hansgrohe is unable to provide a replacement and repair is not practical or cannot be timely made Hansgrohe may elect to refund the purchase price in exchange for the return of the product LENGTH OF WARRANTY Replacement or repaired parts of products will be covered for the term of this warranty as stated in the following two sentences If you are a consumer who purchased the product for use primarily for personal family or household purposes this warranty extends for as long as you own the product and the home in which the product is originally installed If you purchased the product for use primarily for any other purpose including without limitation a commercial purpose this warranty extends only i for 1 year with respect to Hansgrohe and Commercial products and ii for 5 years with respect to AXOR products THIS WARRANTY DOES NOT COVER and HANSGROHE WILL NOT PAY FOR A Conditions malfunctions or damage not resulting from defects in material or workmanship B Conditions malfunctions or damage resulting from 1 normal wear and tear improper installation improper maintenance m
6. ctions In addition pay attention to the following points e Clean the faucets and showers as and when required e Use the amount of cleaning product and the amount of time recommended by the manufacturer Do not leave the cleaner on the fixture longer than necessary e Regular cleaning can prevent calcification e When using spray cleaners spray first onto a soft cloth or sponge Never spray directly onto the faucet as drop lets can enter openings and gaps and cause damage e After cleaning rinse thoroughly with clean water to remove any cleaner residue Important Residues of liquid soaps shampoos and shower foams can also cause damage so rinse with clean water after using Please note if the surface is already damaged the effect of cleaning materials will cause further damage Components with damaged surfaces must be replaced or injury could result Damage caused by improper treatment is not covered under the warranty Limited Lifetime Consumer Warranty his product has been manufactured and tested to the highest quality standards by Hansgrohe Inc Hansgrohe This warranty is imited to Hansgrohe products which are purchased by a consumer in the United States after March 1 1996 and installed in either the United States or Canada WHO IS COVERED BY THE WARRANTY his warranty extends to the original consumer purchaser only This warranty is non transferable WHAT IS COVERED BY THE WARRANTY his warranty covers only your H
7. isuse abuse negligence accident or alteration or 2 the use of abrasive or caustic cleaning agents or no rinse cleaning products or the use of the product in any manner contrary to the product instructions 3 Conditions in the home such as excessive water pressure or corrosion C Labor or other expenses for the disconnection deinstallation or return of the product for warranty service or for installation or reinstallation of the product including but not limited to proper packaging and shipping costs or for installation or reinstallation of the product O OBTAIN WARRANTY PARTS Hansgrohe Inc 492 Bluegrass Lakes Parkway Alpharetta GA 30004 ollfree 800 334 0455 The sales receipt or other A description of the prob Wn Bluegrass Lakes Parkway When warranty service is comp EXCLUSIONS AND LIMITATIONS REPAIR OR REPLACEMENT OR WARRANTY IS THE EXCLUSIVE D Accessories connected materials and products or related products not manufactured by Hansgrohe OR INFORMATION Contact your Hansgrohe retailer or contact Technical Service at n requesting warranty service you will need to provide evidence of the date and place of purchase em Delivery of the product or the defective part postage prepaid and carefully packed and insured to Hansgrohe Inc 1492 Alpharetta Georgia 30004 Attention Technical Service if required by Hansgrohe eted any repaired or replacement product or part wil
8. l be returned to you postage prepaid IN LIMITED CIRCUMSTANCES REFUND OF THE PURCHASE PRICE AS PROVIDED UNDER THIS REMEDY OF THE PURCHASER HANSGROHE NEITHER ASSUMES NOR AUTHORIZES ANY PERSON TO CREATE FOR IT ANY OBLIGATION OR LIABILITY IN CONNECTION WITH THIS PRODUCT HANSGROHE SHALL NOT BE L ABLE TO PURCHASER OR ANY PERSON FOR ANY INCIDENTAL SPECIAL OR CONSEQUENTIAL DAMAGES ARISING OUT OF BREACH OF THIS WARRANTY OR ANY IMPLIED WARRANTY INCLUDING MERCHANTABILITY Some States do not allow the exclusion or limitation of incidental or consequential damages so the above limitation or exclusion may not apply to you This warranty gives you specific legal rights and you may have other rights which vary from State to State You may be required by law to give us a reasonable opportunity to correct or cure any failure to comply before you can bring any action in court against us under the Magnuson Moss Warranty Act PRODUCT INSTRUCTIONS AND QUESTIONS Upon purchase or prior to install installing always carefully study lation please carefully inspect your Hansgrohe product for any damage or visible defect Prior to the enclosed instructions on the proper installation and the care and maintenance of the product If you have questions at any time about the use installation or performance of your Hansgrohe product or this warranty please call or write to us or call us toll free at 800 334 0455 ansgrone Hansgrohe Inc e 1490
9. lly to the right and to the left If it appears to swivel more to one side than to the other pivot the faucet body until the swivel is even When you are satisfied that everything is oriented properly finish tightening the collar nut Tighten the tensioning screws a Connect the handspray hose Loosen the compression fitting on the end of the flexible handspray hose Slide it onto the end of the handspray supply hose While holding the hose still with a 12 mm wrench tighten the nut with a 17 mm wrench DO NOT ALLOW THE HOSE TO TWIST IF THE HOSE TWISTS THE FLOW FROM THE SPRAYHEAD MAY BE REDUCED CD cxec Connect the supplies Connect the hot and cold supply hoses to the supplies with 3 8 compression fittings not included Tighten them wrench tight Use two wrenches as shown in the diagram Do not allow the hot and cold supply hoses to twist Install the hose weight Proper installation of the hose weight will insure that the handspray hose retracts smoothly On the handshower side of the hose use a ruler to measure 15 down from the body of the faucet Install the hose weight at this point Pull out on the handspray and guide it back into the faucet It should move easily and retract smoothly Reposition the hose weight if necessary Turn on the water Check all connections for leaks Check the faucet for proper operation Set the High Temperature Limit Stop optional
Download Pdf Manuals
Related Search