GE Monogram Compactor User's Manual
Contents
1. 1 Remove bolt in center of ram with a 1 2 wrench 4 Clean ram with normal mild household cleaners rinse and dry 5 Fit ram into grooves on the compacting mechanism and slide it forward until it snaps into position 6 Replace center bolt removed in Step 1 Changing Front Panel Models ZCG3100 and ZCG3300 only Remove drawer by pulling to first stop and lifting front to clear second stop Place drawer on its back Remove two screws in bottom edge of trim Slide panel out and reverse Reinstall trim and place drawer back in compactor INSTALLATION Electrical Requirements A CAUTION Before Plugging In Compactor Read The Following Electrical Requirements A CAUTION For Personal Safety Do Not Use An Extension Cord Or Adapter Plug With This Appliance Do Not Under Any Circumstances Cut Or Remove The Third Grounding Prong From The Power Cord Follow National Electrical Codes Or Prevailing Local Codes And Ordinances Grounding Instructions This appliance must be grounded In the event of a malfunction or breakdown grounding will reduce the risk of electric shock by providing a path of least resistance for electric current PREFERRED METHOD a Ensure proper ground exists before use This appliance is equipped with a cord having an equipment grounding conductor and a grounding plug The plug must be plugged into an appropriate outlet that is properly installed and grounded in accordan2. 1845 e Replacement of house fuses or resetting of circuit breakers e Failure of the product if it is used for other than its intended purpose or used commercially Damage to product caused by accident fire floods or acts of God WARRANTOR IS NOT RESPONSIBLE FOR CONSEQUENTIAL DAMAGES Some states do not allow the exclusion or limitation of incidental or consequential damages so the above limitation or exclusion may not apply to you This warranty gives you specific legal rights and you may also have other rights which vary from state to state To know what your legal rights are in your state consult your local or state consumer affairs office or your state s Attorney General Warrantor General Electric Company If further help is needed concerning this warranty write Manager Consumer Affairs GE Appliances Louisville KY 40225 Part No 93042834A Part No 165D4700P193 ZCG3100 Pub No 49 5868 ZCG3300 ZCG3500 6 99 JR Printed in the United States
3. CLEANING The inside and outside of your compactor are finished with durable baked on enamel Cleaning Outside Keep the outside dean Do not wipe with a soiled Stainless Sted Pandis The stainless steel panels can dishwashing cloth it may leave a residue that can be cleaned with Stainless Steel Magic or a similar damage the paint Do not use harsh or gritty cleansers product using a clean soft cloth You can order or scouring pads that may mar the finish Apply a coat Stainless Steel Magic Cat No WX10X15 through of kitchen appliance wax when the compactor is new GE Parts by calling 800 626 2002 and then several times a year Appliance Polish and Wax Cleaner Cat No WR97X216 is available from GE Appliance Parts Marts Cleaning Inside To clean the cabinet interior 2 Place hand on ram face being careful to support 2 Lift up on drawer slightly then pull out drawer to its entire length second stop 1 Pull out trash drawer until it stops 3 Lift drawer up and out of compactor A Vacuum clean cabinet base track channels and drawer particularly in corners 5 Wash the cabinet interior and trash drawer with normal mild household cleaners rinse and dry with a clean cloth Be sure trash drawer is thoroughly dry before inserting a new bag 3 With other hand press back on front of ram sliding it until it releases To clean the ram With trash drawer out of cabinet remove the ram as follows
4. apart this appliance Incorrect reassembly can cause electric shock when subsequently used e Do not compact food waste such as raw meat and fish grapefruit rinds personal hygiene items and disposable diapers These items create very strong odors and should not go into the compactor Precautions against unreasonable use of your compactor e Never compact shotgun shells cartridges for firearms fireworks etc which are highly explosive e Never compact flammable materials such as paint oil or gasoline saturated rags engine starting fluid cans paint thinner cans etc spontaneous combustion or explosive vapor concentrations could occur e Never compact containers of toxic chemicals such as strong insecticides or other poisonous materials compaction could release hazardous fumes e Never compact aerosol cans containing explosive or highly toxic chemicals If you are sure the aerosol cans contain non hazardous materials such as shaving cream cheese spread and whipped cream they may be compacted e Do not compact lighted cigarettes cigars or other hot or burning items e Unplug the compactor before making any repairs NOTE We strongly recommend that any servicing be performed by a qualified person e DO NOT USE AN ADAPTER PLUG OR AN EXTENSION CORD WITH THIS APPLIANCE e Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance SAVE THESE INSTR
5. to the START position hold it momentarily at START and then release it back to ON The motor will start and compacting will proceed CAUTION DO NOT FORCE KEY WHEN TURNING The key should always rotate easily Forcing may break the key and damage the switch The ram travels downward into the drawer compacting the trash At the bottom of the stroke the ram automatically reverses direction retracts out of the drawer returns to its starting position and the compactor shuts off automatically The cycle takes about one minute As the trash drawer fills cycle time gets progressively shorter To Stop Compacting The compactor may be stopped at any time by turning the key to OFF Restarting the compactor will allow the ram to move upward into its starting position e Folded newspaper will also help prevent glass fragments from flying out of the drawer into the mechanism when compacting a large glass bottle or several bottles or jars or any other items that might shatter e Refuse too bulky to go into the drawer can be folded to fit If it cannot be folded to fit into the drawer do not attempt to force it in e Although it is not necessary to compact until the drawer is full or nearly full we suggest that for maximum compaction you start the compactor each time a significant amount of trash is added Glass bottles can make a loud noise when they break during compaction This is normal Also bottles in the trash drawer w
6. ELP US HELP YOU For quick reference the model number is also located behind the key lock switch knob Turn the knob to the OFF LOCK position and remove it to reveal the model number Use these numbers in any correspondence or service calls concerning your compactor If you received a damaged compactor Immediately contact the dealer or builder that sold you the compactor Save time and money Before you call for service Check the Problem Solver in the back of this book It lists causes of minor operating problems that you can correct yourself IF YOU NEED SERVICE in the back of this guide We re proud of our service and want you to be pleased If for some reason you are not happy with the service you receive here are some steps to follow for further help FIRST contact the people who serviced your appliance Explain why you are not pleased In most cases this will solve the problem NEXT if you are still not pleased write all the details including your phone number to Manager Consumer Relations GE Appliances Appliance Park Louisville KY 40225 IMPORTANT SAFETY INSTRUCTIONS Read all instructions before using this appliance WARNING When using this appliance always exercise basic safety precautions including the following e This compactor is for household use only Use this appliance only for its intended purpose as described in the Use and Care book e To prev
7. UCTIONS J 3 ua pe aes N lt DR e p CO s a pi o VN FEATURES OF YOUR COMPACTOR Odor Control Pane Key Lock Switch Drawer Handle ET cue Reference Model lift to pull out ws Wz Number is located behind drawer the Key Lock switch knob Ee 4 gt Mount optional air freshener here not included Drawer Ram Buttons 4 L Model and Serial number location A Fy Bag Caddy Removable Trash Drawer Changeable Container Latch Door Panels gt Leveling Legs Modes ZCG3100 and ZCG3300 come with reversible black and white pands These units will also accept 1 4 and 3 4 custom panes Modes ZC G3500 has a stainless sted wrapped drawer pand What It Does Your compactor reduces household trash to as little as It compacts most refuse including paper cans 25 of its original volume bottles jars plastic containers wrappings sweepings and some food wastes How it Works Drop trash into a disposable bag that lines the trash NOTE The trash drawer must be 1 2 full before you drawer and close the drawer When you start the will notice compaction because the ram travels only compactor an electrically operated ram moves down about 2 3 of the way down into the drawer into the drawer compacts trash moves back up again and the compactor shuts off automatically Key Lock Switch A key lock switch is provided for your p
8. Your Monogram Compactor Monogram CE QV A q ow gy 7 Feo To obtain service see the Consumer Services page Safety Instructions 3 Operating Instructions Tips Features of Your Compactor 4 5 Trash Bag Installation 6 Operating Your Compactor 7 Care and Cleaning Changing Front Panel 9 Cleaning Inside and Outside 8 When Going on Vacation 8 Problem Solver 10 More questions call GE Answer Center 800 626 2000 Installation Electrical Requirements 9 GrOUNCING ccescsceseseseeeeseeeeseeeees 9 Consumer Services 11 Appliance Registration 2 Model and Serial Numbers 2 Warranty ccccccee Back Cover Before using your compactor read this book carefully It is intended to help you operate and maintain your new compactor properly Keep it handy for answers to your questions If you don t understand something or need more help call GE Answer Center 800 626 2000 24 hours a day 7 days a week Write down the model and serial numbers You ll find them by pulling the drawer out and locating the rating label on the inside wall These numbers are also on the Consumer Product Ownership Registration Card that came with your compactor Before sending in this card please write these numbers here Model Number Serial Number H
9. atedly this protector may have opened the motor circuit Wait a few minutes and the cutout will reclose automatically e In the unlikely event that the actuator on the inside of the door breaks off the compactor will not operate DO NOT ATTEMPT TO OPERATE COMPACTOR IN ANY OTHER MANNER A replacement actuator can be ordered from Monogram Preferred Service 800 444 1845 e Trash may have fallen behind the drawer and is preventing the safety switch from being closed e On rare occasions a large can placed near the side of the drawer may become wrapped around the edge of the ram interfering with the opening of the drawer Grasp the drawer handle and move the drawer back and forth until the stuck can becomes dislodged e The Key Lock switch may have been turned to OFF LOCK before the ram returned to the full UP position Close the drawer and turn the Key Lock switch to ON The ram will return to the UP position automatically e Unusual or unbalanced loads may result in compactor stopping before ram has fully returned to UP position Turn key switch to START and hold momentarily at START then release it back to ON The motor will start and the ram will return to the UP position and stop To avoid an unbalanced load distribute the trash evenly in the drawer keeping bottles and large cans flat and in the center of the drawer e Drawer must be at least 1 2 full of trash before you will see any appreciable amount of compacting because the ram
10. ce with local codes and ordinances OQ amp en 5 ou OQ 2 N 5 a QE A SA re This appliance must be supplied with 120V 60HZ and connected to an individual properly grounded branch circuit protected by a 15 or 20 amp circuit breaker or time delay fuse If the electric supply provided does not meet the above requirements call a licensed electrician A DANGER Improper connection of the equipment grounding conductor can result in a risk of electric shock Check with a qualified electrician if A you are in doubt as to whether the appliance is S properly grounded Do not modify the plug with this appliance If it will A not fit the outlet installed have a proper outlet S installed by a qualified electrician PROBLEM COMPACTOR DOES NOT OPERATE DRAWER IS HARD TO CLOSE DRAWER WILL NOT OPEN LITTLE OR NO APPARENT COMPACTION GREASE LEAKING FROM MECHANISM QUESTIONS USE THIS PROBLEM SOLVER POSSIBLE CAUSE e May not be plugged into a live electrical outlet e If plug is secure and compactor still fails to operate plug a lamp or small appliance into the same outlet to determine if there is a tripped circuit breaker or burned out fuse e Key lock switch may not be in ON position e Key lock switch may not have been held at START long enough to start the compaction cycle e Drawer may not be firmly closed e Compactor has an automatic thermal cutout If you have just compacted repe
11. does not travel all the way to the bottom Trash in bottom of drawer will be crushed during subsequent compaction cycles e Early in the life of your compactor grease from the mechanism may drop into the drawer or be found on the front of the bag This is normal and will soon stop If you need more help call toll free GE Answer Center 800 626 2000 consumer information service 10 With the purchase of your new Monogram appliance receive the assurance that if you ever need information or assistance from GE we ll be there All you have to do is call toll free Monogram Preferred Service 800 444 1845 A GE consumer service professional will provide expert repair service scheduled at a time that s convenient for you Many GE Consumer Service company operated locations offer you service today or tomorrow or at your convenience 7 00 a m to 7 00 p m weekdays 9 00 a m to 2 00 p m Saturdays Our factory trained technicians know your appliance inside and out so most repairs can be handled in just one visit GE Answer Center 800 626 2000 Whatever your question about any Monogram major appliance GE Answer Center information service is available to help Your call and your question will be answered promptly and courteously And you can call any time GE Answer Center service is open 24 hours a day 7 days a week 800 626 2000 Upon request GE will provide Braille controls for a variety of Mon
12. ent hazard of electrical shock this compactor must be properly installed and grounded in accordance with the Installation Instructions before it is used SAVE YOUR INSTALLATION INSTRUCTIONS FOR FUTURE USE SHOULD YOU MOVE OR RELOCATE YOUR COMPACTOR If you did not receive an Installation Instruction sheet with your compactor you can obtain one by contacting the service location nearest you e Close supervision is necessary when any appliance is operated near children Do not allow the compactor to be used as a toy or to run unattended at any time e Turn the key to OFF and remove it when not compacting trash This will help prevent anyone from tampering with the compactor or children from operating it e Do not push trash into the drawer with hands or feet Trash might contain broken glass sharp pieces of metal or other sharp objects that might cause injury e When removing or carrying the trash bag keep the bag away from your body Sharp objects may have pierced it e When cleaning the inside of the cabinet be careful Glass fragments may be stuck to the ram or be lying in the bottom of the cabinet e When cleaning the trash drawer be careful Glass fragments may be imbedded in the surface of the drawer e Do not touch moving parts e Do not operate with a damaged cord set plug motor or after damage in any manner Have the appliance examined repaired or adjusted by an authorized serviceman e Do not take
13. from date of original purchase we will provide free of charge parts and service labor in your home to repair or replace any part of the compactor that fails because of a manufacturing defect e Service trips to your home to teach you how to use the product Read your Use and Care material If you then have any questions about operating the product please contact your dealer or our Consumer Affairs office at the address below or call toll free GE Answer Center 800 626 2000 consumer information service Improper installation If you have an installation problem contact your dealer or installer You are responsible for providing adequate electrical and other connecting facilities Staple sales slip or cancelled check here Proof of original purchase date is needed to obtain service under warranty This warranty is extended to the original purchaser and any succeeding owner for products purchased for ordinary home use in the 48 mainland states Hawaii and Washington D C In Alaska the warranty is the same except that it is LIMITED because you must pay to ship the product to the service shop or for the service technician s travel costs to your home All warranty service will be provided by our Factory Service Centers or by our authorized Customer Care servicers during normal working hours Should your appliance need service during warranty period or beyond call Monogram Preferred Service 800 444
14. ill not always break during the first cycle Breaking glass and associated noise may occur several cycles later depending on the type and volume of the trash When bottles and cans are compacted small tears in the bag may occur This is normal and in no way affects the performance of the compactor Always use the bag caddy to carry the compacted trash to storage or pick up areas and keep the bag away from your body to prevent injury from sharp objects that may have pierced the bag CAUTION When emptying waste baskets into the trash drawer some items may spill into the compactor behind the drawer Items behind the drawer could prevent it from closing completely and prevent the compactor from operating To remove such items from behind the drawer open the drawer and if necessary remove it to clean them out See Care and Cleaning instructions Anti Jamming Feature Should unusual loads cause misalignment compactor will automatically stop to prevent damage to the unit To reset the unit and return the ram to the UP position turn the key switch to START and hold momentarily at START then release it back to ON The motor will start and the ram will return to the UP position and stop Redistribute the load evenly in the drawer placing bottles and large cans flat and centered in the drawer before recycling the compactor F UOTLT VISUT Seg ysel m S gt Ta 5 3 5 z 5 CARE AND
15. o drawer Set trash bag into bag caddy and fold over rear of drawer only Lift drawer in front and reengage wheels on track so that the drawer is self supporting at its outermost position TRASH BAG INSTALLATION e Open container latch on right side of drawer and swing door open e Pull bag over front of drawer and smooth and shape the bag to conform to the drawer Hook the prepunched holes in the bag over the drawer buttons e Gently swing door shut assuring that the door guide V is aligned properly with the V groove in the drawer and that the bag is captured just above the V groove e Finally use the container latch to completely close the door This will pull the door guide V snug in the V groove in the drawer flange and tightly grasp the bag Failure to align the V s properly or to latch the drawer to the door may cause the compactor to not function properly OPERATING YOUR COMPACTOR After installing a trash bag the compactor is ready to use Loading Pull the trash drawer out as far as necessary to load the items e Bottles and large cans compact best when laid flat near the center of the drawer e To help keep the ram clean when compacting messy food waste place a couple of folded sheets of newspaper or a large grocery bag on top of the load to be compacted Compacting To start the compactor 1 Close the drawer 2 Rotate the key past ON
16. ogram appliances anda brochure to assist in planning a barrier free kitchen for persons piar E with limited mobility To obtain these items free of charge call 800 626 2000 Service Contracts 800 626 2224 For Customers With Special Needs Consumers with impaired hearing or speech who have access to a TDD or a conventional teletypewriter may call 800 TDD GEAC 800 833 4322 to request information or service You can have the secure feeling that GE Consumer Service will still be there after your warranty expires Purchase a GE contract while your warranty is still in effect and you ll receive a substantial discount With a multiple year contract you re assured of future service at today s prices Parts and Accessories 800 626 2002 Individuals qualified to service their own appliances can have needed parts or accessories sent directly to their home The GE parts system provides access to over 47 000 parts and all GE Genuine Renewal Parts are fully warranted VISA MasterCard and Discover cards are accepted User maintenance instructions contained in this booklet cover procedures intended to be performed by any user Other servicing generally should be referred to qualified service personnel Caution must be exercised since improper servicing may cause unsafe operation YOUR MONOGRAM TRASH COMPACTOR WARRANTY WHAT IS COVERED WHAT IS NOT COVERED FULL ONE YEAR WARRANTY For one year
17. rotection as a safety measure When the key lock switch is in the OFF position the compactor will not operate Lock the compactor when it is not in use and remove the key for safekeeping to keep children from operating the compactor or to prevent anyone from tampering with it Odor Control Panel A panel behind the drawer front is designed to hold an adhesive backed freshener such as a Stick Up brand Air Freshener package Simply open the drawer and fasten the opened air freshener package on the panel Replace the air freshener as needed o S VN 5 z OQ 5 Ss z Adjustable Base The base of this compactor can be adjusted forward or backward to achieve a toekick to match the cabinet see Installation Instructions Reinforced polyethylene bags come with your compactor These bags are ready to be installed You must use the specially designed heavy duty trash bags included with your compactor Replacement bags can be obtained by calling 800 626 2000 The part number for replacement bags for your model is WC60X5015 e With trash drawer pulled out to first stop move the drawer to the second stop by lifting the front of the drawer slightly and pulling forward Now lower the front edge of the drawer to the floor allowing the rear wheels to remain on the track This will clear the back of the container from the cabinet for easy installation of the bag Set bag caddy int
Download Pdf Manuals
Related Search