Frigidaire Side Burner FOR OUTDOOR USE User's Manual
Contents
1. Frigidaire Side Burner Built In Usage USE AND CARE MANUAL FOR OUTDOOR USE ONLY MADE IN THE USA General Safety Instructions IMPORTANT SAFETY INFORMATION Read this manual carefully before using your grill to reduce the risk of fire burn hazard or other injury Extreme care should be used because of the high temperatures produced by this appliance CHILDREN SHOULD NOT BE LEFT UNATTENDED IN AN AREA WHERE THE GRILL IS BEING OPERATED This appliance must be kept clear from combustible materials gasoline or other flammable vapors and liquids Do not allow flammable materials to come in contact with grate burner or hot surfaces Do not repair or replace any part of this appliance unless it is specifically recommended in this manual A qualified service technician should conduct all other service Follow the installation and servicing instructions provided with this product Have your grill installed by a qualified service technician Locate the main gas supply valve so that you know how to shut the gas off to your grill If you smell gas make sure all gas connections are tight before operation If you continue to smell gas call a qualified technician When lighting the burners always pay close attention to what you are doing Be certain you are pushing the igniter to light the burners you intend on using WARNING TESTED IN ACCORDANCE WITH ANSI Z21 58a 1998 CGA 1 6a M98 STANDARD If you smell gas FOR OUTDOOR COOKING GAS2. 2 Install burner cap onto burner See Fig 2 3 Install grate into burner See Fig 3 Fig 2 Lighting The Side Burner LEAK TESTING Make sure all burners are turned to OFF Turn on the gas at the cylinder LP models or main valve Natural models DO NOT turn on the side burner Perform a leak test at all connections and fit tings by spraying a 50 50 solution of water and soap If any bubbles appear correct the leak before attempting to light the grill or side burner LIGHTING INSTRUCTIONS Push and turn the control knob to the HIGH position and immediately press and hold the electronic igniter button You ll hear a snapping sound It may be nec essary to hold the electronic starter button for about 4 seconds If the burner does not light in 4 seconds turn the knob to the OFF position and wait 5 min utes before trying again Repeat above steps to light remaining burners See Fig 5 Fig 5 Match Lighting If by chance the electronic igniter does not light the burner the burner may be lit with a match Keep your face as far away from the burner as possible and place a lit long stem match through the spaces in the grate to the ports of the burner Position the match near the burner ports and push and turn the control knob to the HIGH position Warranty LIMITED LIFETIME WARRANTY Electrolux Icon Grills have a limited lifetime warranty on all stainless steel panels a l
3. APPLI ANCES THIS GRILL IS FOR OUTDOOR 1 Shut off gas to the appliance USE ONLY 2 Extinguish any open flames Check your local building codes for the proper 3 Open lid method of installation In the absence of local 4 If odor continues immediately codes this unit should be installed in accor call your gas supplier dance with the National Fuel Gas Code No Z223 1 and the National Electrical Code ANSI NFPA No 70 CALIFORNIA PROPOSITION 65 WARNING The Burning of gas cooking fuels gen erates some by products which are on the list of sub stances which are known by the State of California to DO NOT store or use gasoline or other flam cause cancer or reproductive harm California law mable vapors and liquids in the vicinity of this requires businesses to warn customers of potential grill exposure to such substances To minimize exposure to these substances always operate this unit accord ing to the use and care manual ensuring you provide good ventilation when cooking with gas FOR YOUR SAFETY FOR YOUR SAFETY DO NOT try lighting this grill without reading the LIGHTING INSTRUCTIONS section of this manual This appliance is not intended to be installed in or on recreational vehicles or boats Built In Instructions The Frigidaire side burner is designed to be installed as a built in side burner in conjunction with a Frigidaire amp Frigidaire Gallery grills If installed as a built in Grill the Grill surround mu
4. U S A Puerto Rico and Canada Product features or specifications as described or illustrated are subject to change without notice In the U S A all warranties are made by Electrolux Home Products North America In Canada your appliance is warranted by Electrolux Canada Corp If you have any other questions please contact the Customer Service Hotline at 1 800 320 0859 Because of continuing product improvement these specifications are subject to change without notice RMP 122 FSSBIM 01 18 05
5. e Fig 12 with grill 2 Using an adjustable wrench remove the flare fitting coming out of the bottom of the grill Once the flare fitting is removed the main gas pipe will be showing under grill See Fig 13 4 Using pipe sealant attach the T Fitting to the main gas pipe coming out of the bottom of the grill and tighten with a wrench See Fig 14 5 Using pipe sealant attach a 3 8 flared fitting to the side and bottom of the T fitting See Fig 15 6 Attach the Flex Line to the fitting on the side of the T fitting Connect the other end of the flex line to the side burner valve See Fig 16 Note This line can be extended using a 3 8 flared coupling and an additional flex line if necessary 7 Attach the LP gas hose assembly to the bottom flared fitting See Fig 17 Be sure your L P cylinder has an overfill protection device on it Max inlet pressure cannot exceed 10 11 water column Installation Instructions Tools Required Adjustable wrench flat head screwdriver and a 1 4 socket wrench Please use the built in information on the following pages for the exact dimensions needed to fit the side burner into the structure Once installed into the structure use the following steps to complete the side burner installation INSTALLATION OF SIDE BURNER PARTS 1 Install burner into side burner tray lining up the three cutouts on the underside of the burner See Fig 1
6. he back of the grill to non combustible construction is required You should allow at least 6 side clearance to non combustible construction The side vents on this unit can be covered for built in installations without danger of fire or without impairing the operation of the grill UTILITIES For natural gas grills consult your local gas utility company for hook up requirements All gas connections should be made by a certified technician or a gas supply company For natural gas installation the supply line must be at least 1 2 diameter The rotisserie requires a 110 120 volt electric supply and GFI receptacle 6 5 amp min that should be installed by a qualified electrical technician If your plan includes a sink arrange for a certified plumbing technician to run a water line to the site Built In Instructions 132 Needed From Topo oer To Mount Side Burner CSL te lt p ae 4 187 4 43 16 Ay Additional Requirements e If using a backsplash apron or rear wall locate electrical service on the left hand side for rotisserie motor construc tion A minimum clearance of 12 from the back of the outdoor cooking center must be maintained between the grill and any combustible construction such as wood siding of residence 3 minimum for non combustible construction e The side vents on this unit can be covered for built in installations without danger of fire or without impairing the operation of the grill Na
7. imited 3 year warranty on stainless steel burners including labor within one year of the date of purchase and a limited 1 year warranty on all other parts labor included In the U S A your appliance is warranted by Electrolux Home Products North America We authorize no person to change or add to any of our obligations under this warranty Our obligations for service and parts under this warranty must be performed by an authorized Electrolux Home Products North America qualified service technician WARRANTY PERIOD THROUGH OUR AUTHORIZED SERVICERS WE WILL THE CONSUMER WILL BE RESPONSIBLE FOR LIMITED ONE YEAR WARRANTY One Year from original purchase date Cost of service calls that are listed under NORMAL RESPONSIBILITIES OF THE CONSUMER Pay all costs for repairing or replacing any parts of this appliance which prove to be defective in materials or workmanship LIMITED 3 YEAR WARRANTY ON STAINLESS STEEL BURNERS 2nd through 3rd years from original purchase date Provide a replacement for any defective stainless steel burner which prove to be defective in materials or workmanship Diagnostic and any transportation and labor costs which are required because of service LIMITED LIFETIME WARRANTY ON STAINLESS PANELS Some restrictions apply NORMAL RESPONSIBILITIES OF THE CUSTOMER EXCLUSIONS IF YOU NEED SERVICE From original date of purchase All of the provisions of the f
8. ome Products North America or its authorized servicers use of parts other than genuine Electrolux Home Products parts or parts obtained from persons other than authorized servicers or external causes such as abuse misuse inadequate power supply or acts of God Products with original serial numbers that have been removed or altered and cannot be readily determined All other warranties including implied warranties of merchantability and fitness for a particular purpose which are expressly excluded consequential or incidental damages resulting from breach of warranty which are expressly excluded This limited warranty does not cover corrosion or discoloring due to lack of maintenance misuse hostile environments alterations accidents or abuse or neglect This limited warranty does not cover any scratches dents corrosion or discoloring by heat abrasive and chemical cleaners nor any components used in the installation of the appliance Keep your bill of sale delivery slip or some other appropriate payment record The date on the bill establishes the warranty period should service be required If service is performed it is in your best interest to obtain and keep all receipts This written warranty gives you specific legal rights You may also have other rights that vary from state to state Service under this warranty must be obtained by contacting Electrolux Home Products This warranty only applies in the 50 states of the
9. ont of side burner See Fig 4 Grasp and remove NG valve assembly from the side burner tube assembly and remove from the side burner See Fig 5 Install LP valve assembly into the side burner See Fig 6 Fig 6 Fig 1 Flex Line Fig 2 Fig 3 Fig 4 LP Side Burner Conversion 7 Reattach bezel and screw new LP valve onto front of side burner See Fig 4 again 8 Reattach the flex line to the LP valve assem bly and tighten securely See Fig 7 9 Reattach the control knob onto the manifold stem See Fig 3 again 10 Looking down at top of side burner use a 7mm nut driver to remove the NG See Fig 8 16 Install the new LP orifice See Fig 9 17 From the bottom of the side burner place the LP orifice into the main burner assembly fin ger tighten See Fig 10 18 Using the 7mm nut driver tighten the LP orifice in the main burner assembly See Fig 11 19 This completes the side burner conversion Fig 7 Top of Side Burner Looking down a Fig 8 NG orific LP orice Fig 9 Bottom of side burner main Fig 10 Nut driver through top of side burner Fig 11 LP Grill Conversion IMPORTANT Make sure you have converted the side burner to Liquid Propane prior to completing the following steps LP hose 1 Remove the LP gas hose assembly from the leguiator flare fitting this has the regulator attached to supplied it Se
10. st be constructed of Non combustible material PLANNING AND DESIGN Start by identifying the number and size of components you want to include in your outdoor cooking center Countertops must be constructed of non combustible outdoor safe materials Consider out door lighting to illuminate after dark grilling For assistance in designing and building your outdoor cooking center contact a landscape architect or general contractor Review the drawings on the following pages to determine the exact dimensions and items needed for an outdoor cooking center Keep in mind that the gas line hook up is on the right hand side of the main built in grill The structure grill and support items must be kept level throughout the installation to ensure proper operation LOCATION Take into account convenience and visual impact as well as traffic flow wind exposure and the site s structural suitability The grill should never be placed in an enclosed area without an approved ventilation system or beneath a combustible overhang Because the grill exhausts to the rear it should never be located in front of a window or less than 12 from hard to clean surfaces We rec ommend keeping your gas supply lines as short as possible for best performance To ensure a per fect fit we strongly recommend that you have all components on hand prior to final construction CLEARANCE TO NON COMBUSTIBLE CONSTRUCTION For your safety a minimum of 3 clearance from t
11. tural Gas Installation Under the grill remove the NG gas regulator assembly from the main gas pipe Once the NG gas regulator is removed the main gas pipe will be showing under grill See Fig 1 Fig 1 2 Using pipe sealant attach the T Fitting to the main gas pipe coming out of the bottom of the grill See Fig 2 3 Using pipe sealant attach a 3 8 flared fitting to the side of the T fitting See Fig 3 4 Attach the one end of the flex line to the fitting on the side of the T fitting Connect the other end of the flex line to the side burner valve A _ See Fig 4 ris 2 Note This line can be extended using a 3 8 flared coupling and an additional flex line if necessary 5 Using pipe sealant attach a 3 8 nipple to the bottom of the T fitting See Fig 5 6 Using pipe sealant attach the NG gas regulator to the 3 8 nipple See Fig 6 7 Attach the NG gas line to the bottom flared fitting See Fig 7 Note Make sure all fittings are tightened with a wrench Fig 4 Fig 7 LP Side Burner Conversion Loosen the flex line attached to the side burn er valve using an adjustable wrench See Fig 1 Remove the flex line completely from the side burner valve See Fig 2 Remove the control knob from the front of the side burner See Fig 3 Remove the screw holding the bezel in place on the side burner and remove bezel from fr
12. ull and limited warranties above and the exclusions listed below apply Costs of the technicians travel to the home and any costs for pick up and delivery of the appliance required because of service This warranty applies only to products in ordinary household use and the consumer is responsible for the items listed below 2 3 4 1 Proper use of the appliance in accordance with instructions provided with the product Proper installation by an authorized servicer in accordance with instructions provided with the appliance and in accordance with all local plumbing electrical and or gas codes Expenses for making the appliance accessible for servicing such as removal of trim cupboards shelves etc which are not a part of the appliance when it was shipped from the factory Damages to finish after installation This warranty does not cover the following 1 CONSEQUENTIAL OR INCIDENTAL DAMAGES SUCH AS PROPERTY DAMAGE AND INCIDENTAL EXPENSES RESULTING FROM ANY BREACH OF THIS WRITTEN OR ANY IMPLIED WARRANTY NOTE Some states do not allow the exclusion or limitation of incidental or consequential damages so this limitation or exclusion may not apply to you Service calls which do not involve malfunction or defects in workmanship or material or for appliances not in ordinary household use The consumer shall pay for such service calls Damages caused by services performed by servicers other than Electrolux H
Download Pdf Manuals
Related Search