Fisher-Price W2604 User's Manual
Contents
1. Large Tab e Fit the large tab on the steering wheel cover into the large slot in the steering wheel e Insert and snap the small tab on the steering wheel cover into the small slot in the steering wheel Screws BACK VIEW e Insert two screws into the top of the wing and tighten e Insert two screws into the back edge of the wing and tighten 9 W2604a 0920 DECORATION e Wipe the vehicle with a clean dry cloth to remove any oils before applying labels e Apply labels exactly as shown in the illustrations For best results avoid repositioning the label after it has been applied e Starting at the center of a label rub firmly with a dry cloth and smooth towards the outer edges to remove air bubbles 16 0 a Cy W2604a 0920 10 DECORATION Ee N N 8 N I cam BACK VIEW 11 W2604a 0920 BATTERY INSTALLATION IMPORTANT Use only a Power Wheels 6 volt rechargeable battery Use of any other battery will damage your vehicle Assembly Tool e Place the battery in the battery compartment and release the battery retainer Make sure the battery retainer slides over the top of the battery e Close the hood and fit the tabs on the hood into the Slots in the vehicle slot on the side of the hood e Press down to snap the hood in place e Insert the end of the assembly tool or a coin into the e Use the tool to lift the hood and access the battery compartment Pow2. No action required If your battery does not make noise or swell slightly during charging it does not mean that it is not accepting the charge W2604a 0920 Dead Spot on motor Damaged battery Child is switching between FORWARD and REVERSE without stopping Broken gears It is normal for some chargers to get warm during use and is not reason for concern It is normal for some batteries to make noise and swell slightly while charging and is not reason for concern 19 Battery s thermal fuse constantly trips but the vehicle is not overloaded nor the driving conditions too severe Loud clacking or grinding noise from a motor gearbox Charger gets warm during use Battery makes a sizzling or gurgling noise when charging Before first time use you must charge the battery 18 hours Charge the battery immediately after each use Charge the battery once a month even if the vehicle is not used or stored Do not return your vehicle to the store We re a toll free phone call away and we can help If you are missing parts or need assistance please call 1 800 348 0751 Or contact your local independently owned and operated Power Wheels Authorized Service Center For the location nearest you visit us on line at www powerwheels com Disney Pixar www disney com cars Fisher Price Inc a subsidiary of Mattel Inc East Aurora New York 14052 U S A 2011 Mattel Inc All Rights
3. Disney PIXAR LIGHTNING Please read this manual and save it with your original sales receipt e Required tools Phillips Screwdriver and Slotted Screwdriver both not included and Assembly Tool included e Use only with a Power Wheels 6 Volt Rechargeable Battery and Power Wheels Super 6 Volt Charger with A style connector both included e Requires one AA LR6 alkaline battery for sound box operation not included SEE ORC eh aie EEE 7 0 T eaee i eee 0 0 SOR cons RE Geno aoe SR ee ZS A oe oP Songun 3 Sak ete RoHS Ue Pe noe By Be ee 5 ine RRS UIA areas ESS Do AS LIE EREY ae aye SISOS A E SS Product features may vary from the picture above Fisher Price l 0 Owner s Manual POWER WHEELS with Assembly Instructions For Model W2604 IMPORTANT INFORMATION ELECTRICAL HAZARD WARNING e Battery can fall out and injure a child if vehicle tips over Always use battery retainer e PREVENT FIRE Never modify the electrical system Alterations could cause a fire resulting in serious injury and could also ruin the electrical system Use of the wrong type battery or charger could cause a fire or explosion resulting in serious injury Use of Power Wheels components in products other than Power Wheels vehicles could cause overheating fire or explosion The battery must be handled by adults only The battery is heavy
4. The vehicle could roll backwards at an unsafe speed e Never put anything near any moving parts Rotating parts such as motors gear boxes and wheels can snag fingers hair etc causing serious injury Do not allow operation of the vehicle when it is on its side or in an upside down position Do not operate the vehicle near flammable vapors gasoline paint thinner acetone liquid wax etc The vehicle s electrical switches like most electrical switches emit an internal spark when first turned on or turned off which could cause an explosion or fire e To prevent unsupervised use of the vehicle disconnect the motor harness from the battery when the vehicle is not in use 14 Riding Areas These areas must be away from swimming pools and other bodies of water to prevent drownings generally level to prevent tipovers away from steps steep inclines Cars roads and alleys Riding Rules Make sure children know and follow these rules for safe driving and riding Always sit on the seat Always wear shoes Only 1 one rider at a time Use vehicle on generally level ground ONLY W2604a 0920 VEHICLE OPERATION e Help your child practice steering to learn how far and Sound and Language how quickly to turn the steering wheel when driving Switch and automatically knows how to stop e Make sure the shifter is in the forward position e Press down on the foot pedal The vehicle goes
5. Never give emetics or induce vomiting Call a physician Do not allow the battery to run down completely before charging e Charge the battery before storing the vehicle and at least once per month even if the vehicle has not been used e Charge the battery after each use regardless of how long the vehicle was used e Leaving the battery in a discharged condition will ruin it e Always remove an exhausted battery from the vehicle Battery leakage and corrosion can damage the vehicle e Do not store the battery in temperatures above 75 F or below 10 F SAFE DRIVING RULES Before children use this vehicle an adult should carefully evaluate the driving area as well as the child s skill level and ability to drive the vehicle safely Teach appropriate Safety rules to your child before allowing operation of this vehicle These rules should also be reviewed with other playmates who want to drive the vehicle e A child who is not sitting on the seat could fall off cause a tip over or block the driver s view Only operate the vehicle in the daytime in a well lit area e Driving near steep inclines can cause RIDING HAZARD WARNING Prevent Injuries and Deaths Direct Adult Supervision Required e Never Ride at Night e Keep Children Within Safe The vehicle to gain unsafe speed even if the pedal is released to stop The vehicle to tilt and tip over The wheels to lose traction causing the vehicle to slip
6. Reserved and designate U S trademarks of Mattel Inc unless otherwise indicated PRINTED IN MEXICO W2604a 0920
7. all wires and connectors Make sure the charger connector is plugged into the battery and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Do not charge the battery longer than 30 hours If you suspect that your battery is damaged as a result of overcharging contact your local Power Wheels authorized service center They can test your battery for you Even with proper care a rechargeable battery does not last forever Average battery life is 1 to 3 years depending on vehicle use and use conditions Replace the battery with a new Power Wheels 6 volt rechargeable battery Do not substitute parts The built in thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped remove your foot from the pedal and wait approximately 25 seconds before operating the vehicle again To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 65 lbs 29 5 kg maximum weight capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first
8. and contains sulfuric acid electrolyte Dropping the battery could result in serious injury Never allow children to charge the battery Battery charging must be done by adults only A child could be injured by the electricity involved in charging the battery e Read the safety instructions on the battery e Examine the battery charger and their connectors for excessive wear or damage each time you charge the battery If damage or excessive wear is detected do not use the charger or the battery until you have replaced the worn or damaged part HOT motors Handle carefully RIDING HAZARD WARNING Prevent Injuries and Deaths Direct Adult Supervision Required Never Ride at Night Keep Children Within Safe Riding Areas These areas must be away from swimming pools and other bodies of water to prevent drownings generally level to prevent tipovers away from steps steep inclines cars roads and alleys e Riding Rules Make sure children know and follow these rules for safe driving and riding Always sit on the seat Always wear shoes Only 1 one rider at a time A CAUTION e Use the charger in dry locations only W2604a 0920 2 IMPORTANT INFORMATION e Read this manual carefully for important safety e f a thermal fuse in a battery continually trips under information and operating instructions before using normal driving conditions please contact your local your vehicle Keep this manua
9. nationwide Our authorized service detailed instructions centers will repair or replace parts under warranty at e The battery charger is not a toy no extra charge and can perform non warranty repairs e Do not short circuit the batter for a minimal charge To find the authorized service ry center nearest you please visit us online at e Adults Note Regularly examine the charger for WWW powerwheels com or call 1 800 348 0751 damage to the cord plug housing or other parts that 5 po 1 may result in the risk of fire electric shock or injury TS at www powerwheels com to In the event of any damage do not use the charger until the damage has been properly repaired e Your Power Wheels 6 volt battery is equipped with a built in thermal fuse The thermal fuse is a self resetting safety device which automatically trips and shuts down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped release the button on the steering wheel and wait approximately 25 seconds before operating the vehicle again To avoid repeated automatic shut downs avoid severe driving conditions 3 W2604a 0920 PARTS e f you experience a problem with this product or are missing a part please call us at 1 800 348 0751 rather than return this product to the store e Please identify all parts before assembly and save all packaging material until assembly is complete to ensure that no part
10. ne doit pas produire de brouillage et 2 l utilisateur du dispositif doit tre pr t a accepter tout brouillage radio lectrique re u m me si ce brouillage est susceptible de compromettre le fonctionnement du dispositif LIMITED WARRANTY Bumper to Bumper Limited Warranty One year limited warranty from the date of purchase on the Power Wheels vehicle Six month limited warranty on the 6 volt battery For the original purchaser this one year limited warranty covers the Power Wheels ride on vehicle purchased from Power Wheels against defects in materials and workmanship The six month limited warranty applies only to the 6 volt battery included by Power Wheels with the original purchase of the vehicle This warranty covers normal use and does not cover the Power Wheels vehicle or battery if damaged by unreasonable use neglect accident abuse misuse improper service or other causes not arising out of defects in materials or workmanship Evidence of any attempt at consumer repair will void this warranty THIS WARRANTY DOES NOT COVER AND IS INTENDED TO EXCLUDE ANY LIABILITY ON THE PART OF POWER WHEELS WHETHER UNDER THIS WARRANTY OR IMPLIED BY LAW FOR ANY INDIRECT OR CONSEQUENTIAL DAMAGES FOR BREACH OF WARRANTY SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION SO THIS LIMITATION MAY NOT APPLY TO YOU Should you need service or assistance with your vehicle during the warranty period do not return the ve
11. or charger could cause a fire or explosion resulting in serious injury Use of Power Wheels components in products other than Power Wheels vehicles could cause overheating fire or explosion The battery must be handled by adults only The battery is heavy and contains sulfuric acid electrolyte Dropping the battery could result in serious injury e Never allow children to charge the battery Battery charging must be done by adults only A child could be injured by the electricity involved in charging the battery Read the safety instructions on the battery e Examine the battery charger and their connectors for excessive wear or damage each time you charge the battery If damage or excessive wear is detected do not use the charger or the battery until you have replaced the worn or damaged part N CAUTION Use the charger in dry locations only ASSEMBLY WARNING Children can be harmed by small parts sharp edges and sharp points in the vehicle s unassembled state or by electrical items Care should be taken in unpacking and assembly of the vehicle Children should not handle parts including the battery or help in assembly of the vehicle xum Bumper a Screws 3 Set the vehicle upright e Insert two screws into the front bumper and tighten 1 Steering Column e Carefully lift the front end of the vehicle Fit the front bumper to the front of the vehi
12. time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all connectors Make sure the charger connector is plugged into the battery and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Be sure to charge the battery after each use Even with proper care a rechargeable battery does not last forever Average battery life is 1 to 3 years depending on the vehicle use and use conditions Replace the battery with a new Power Wheels 6 volt rechargable battery Do not substitute parts Make sure you do not overload the vehicle by allowing more than one rider at one time by exceeding the 65 Ib maximum weight capacity or by towing objects behind the vehicle Use only on generally level ground PROBLEM POSSIBLE CAUSE Short run time Undercharged battery Less than 1 3 hours per charge Overcharged battery Battery is old and will not accept full charge Tripped thermal fuse Vehicle runs sluggishly Undercharged battery Battery needs charging Battery is old and will not accept full charge Vehicle is overloaded Driving conditions are too stressful W2604a 0920 18 PROBLEMS AND SOLUTIONS GUIDE PROBLEM POSSIBLE CAUSE SOLUTION It is possible that only one rear wheel may spin when both rear wheels are raised off the ground and the vehicle is in low speed This does not necessarily indi
13. CLE CARE Check all screws and their protective coverings regularly and tighten as required Check plastic parts on a regular basis for cracks or broken pieces e During snowy or rainy weather the vehicle should be Stored inside or under a protective cover e Avoid operating the vehicle in wet or snowy conditions and do not spray the vehicle with a hose Water or moisture in the motors or electrical switches can cause them to corrode and could cause switch or motor failure e Avoid operating the vehicle on sand loose dirt or gravel Sand loose dirt or gravel in the motors or electrical switches can cause them to jam and could cause switch or motor failure e The vehicle can be wiped down with a soft dry cloth For a shiny finish you can wipe plastic parts with a non wax furniture polish applied to a soft cloth Do not use automotive wax Do not use soap and water or spray the vehicle with a hose e To ensure your vehicle stays in good operating order we recommend you periodically have your vehicle checked by a Power Wheels authorized service center W2604a 0920 BATTERY CARE If a battery leak develops avoid contact with the leaking acid and place the damaged battery in a plastic bag See next section for proper disposal If acid comes in contact with skin or eyes flush with cool water for at least 15 minutes and call a physician If acid is internally ingested give water milk of magnesia or egg whites immediately
14. atteries or batteries of different types alkaline standard carbon zinc or rechargeable nickel cadmium e Insert batteries as indicated inside the battery compartment e Remove batteries during long periods of non use Always remove exhausted batteries from the product Dispose of batteries safely Do not dispose of product in a fire The batteries may explode or leak e Never short circuit the battery terminals e Use only batteries of the same or equivalent type as recommended Do not charge non rechargeable batteries Remove rechargeable batteries from the product before charging e f removable rechargeable batteries are used they are only to be charged under adult supervision 1 5V ASSEMBLY Loosen the screw in the sound box battery compartment door with a Phillips screwdriver Remove the door e Insert one AA LR6 alkaline battery as indicated inside the battery compartment Hint We recommend using an alkaline battery for longer battery life e f this toy begins to operate erratically you may need to reset the electronics Remove the battery and reinsert it e Replace the battery compartment door and tighten the screw with a Phillips screwdriver Do not over tighten W2604a 0920 ASSEMBLY Sound Box e Fit the wing onto the back of the vehicle e Fit the sound box into the center of the steering wheel Make sure the buttons on the sound box are upright Screws
15. cate a problem Check for proper operation of the drive system by raising the rear wheels off the ground and pressing the foot pedal If only one rear wheel spins carefully press your hand on the spinning wheel to slow it down The other rear wheel should begin to spin If the other rear wheel does not begin to spin there may be a problem with the vehicle Contact your local Power Wheels authorized service center for diagnosis and repair When the foot pedal Operation of vehicle in low speed is pressed one rear wheel spins Sometimes the vehicle doesn t run but other times it does Loose wire or connector Check all wires around the motors and all connectors to make sure they are tight Contact your local Power Wheels authorized service center for diagnosis and repair Motor or electrical switch damage Loose wire or connector Check all wires around the motors and all connectors to make sure they are tight When the go foot pedal is pressed the vehicle wont run without a push Contact your local Power Wheels authorized service center for diagnosis and repair Contact your local Power Wheels authorized service center for diagnosis and repair Teach your child to stop the vehicle before switching direction Contact your local Power Wheels authorized service center for diagnosis and repair No action required If your charger does not get warm during use it does not mean that it is not working properly
16. cle Screws BOTTOM VIEW DASH VIEW e Wipe the steering column with a paper towel to remove any excess lubricant e Carefully lift the front end of the vehicle Pal 4 e Insert four screws into the underside of the bumper Insert the straight end of the steering column through and tighten the slot in the vehicle and out through the large hole in Hints the center of the dash You may need to turn the wheels to fit all four screws Be sure the steering column comes through the hole into the bumper in the dash You may need to push and pull on the bumper to align the screw holes W2604a 0920 6 ASSEMBLY Steering Linkage Steering Wheel Lock Nut e Fit the curved end of the steering column through the hole in the steering linkage Lock Nut 3 C DASH VIEW 0 Hold the steering column in place and gently lower the vehicle e While supporting the steering column fit the steering wheel onto the steering column e Place the lock nut rounded side out onto the end of the steering column Tighten the lock nut firmly using of the assembly tool e Place the lock nut rounded side out onto the end of the steering column e Tighten the lock nut firmly using the assembly tool 7 W2604a 0920 BATTERY SAFETY INFORMATION In exceptional circumstances batteries may leak fluids that can cause a chemical burn injury or ruin your product To avoid battery leakage e Do not mix old and new b
17. er They can test your charger for you The built in thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped remove your foot from the pedal and wait approximately 25 seconds before operating the vehicle again To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 65 Ibs 29 5 kg maximum weight Capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center Check all wires and connectors Make sure the motor harness connector is plugged into the battery and that there are no loose wires around the motors If your battery is old or if you have not followed Battery Care instructions your battery may be dead If you are unsure whether or not the battery is dead you can have it tested at your local Power Wheels authorized service center The electrical switches can become corroded due to exposure to water or moisture or can jam due to loose dirt sand or gravel Contact your local Power Wheels authorized service center for diagnosis and repair Contact your local Power Wheels authorized service center for diagnosis and repair Check all wires and connectors Make sure the m
18. er Wheels 6 Volt Battery Battery Retainer B Motor Harness Connector e Lift and pull the battery retainer forward e Plug the motor harness connector into the battery W2604a 0920 12 BATTERY DISPOSAL 25 e Your Power Wheels battery is a non spillable Sealed lead acid battery It must be recycled or disposed of in an environmentally sound manner e Do not dispose of a lead acid battery in a fire The battery may explode or leak Do not dispose of a lead acid battery in your regular household trash The incineration landfilling or mixing of sealed lead acid batteries with household trash is prohibited by law in most areas e Protect the environment by not disposing of this product with household waste 2002 96 EC Check your local authority for recycling advice and facilities e Return an exhausted battery to a federal or state approved lead acid battery recycler such as a Power Wheels authorized service center or a local seller of automotive batteries For the authorized service center location nearest to you please visit us on line at www powerwheels com or Call 1 800 348 0751 Contact your local waste management officials for other information regarding the environmentally sound collection recycling and disposal of lead acid batteries If you live in the State of Florida or the State of Minnesota it is prohibited by law for anyone to throw away lead acid batteries in the municipal waste stream VEHI
19. forward Sound Button at a maximum of 3 5 mph 5 6 km h IMPORTANT To avoid damaging the motors and e Fit a Slotted screwdriver into the slot on the steering wheel gears stop the vehicle before shifting from forward e Carefully remove the steering wheel cover from the to reverse steering wheel Once your child is comfortable operating the vehicle in e Slide the language switch to 1 for engine sounds the forward mode introduce reverse 2 for Spanish and engine sounds or 3 for English and e Make sure the shifter is in the reverse position engine sounds e Press down on the foot pedal Carefully replace the steering wheel cover and push to Snap in place Press the sound button for sounds and music e Your vehicle has a patented electronic braking system that automatically stops the vehicle when your child s foot lifts from the pedal 15 W2604a 0920 FCC STATEMENT United States Only This equipment has been tested and found to comply with the limits for a Class B digital device pursuant to Part 15 of the FCC Rules These limits are designed to provide reasonable protection against harmful interference in a residential installation This equipment generates uses and can radiate radio frequency energy and if not installed and used in accordance with the instructions may cause harmful interference to radio communications However there is no guarantee that interference will not occur in a particular insta
20. hicle to the store Power Wheels has provided a nationwide network of authorized service centers If there is not an authorized service center in your area please visit us on line at www powerwheels com or call Consumer Relations for information 1 800 348 0751 This warranty gives you specific legal rights and you may also have other rights which may vary from state to state PLEASE SAVE YOUR ORIGINAL SALES RECEIPT W2604a 0920 PROBLEMS AND SOLUTIONS GUIDE IMPORTANT If you experience a problem with your vehicle first check the Problems and Solutions Guide below If you still experience a problem please contact Power Wheelse Consumer Relations toll free at 1 800 348 0751 Or contact your local Power Wheels authorized service center For the location nearest you please visit us online at SOLUTION Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all connectors Make sure the charger connector is plugged into the battery and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON There is no sure way to tell if your charger is working unless you have a volt meter If you suspect there is a problem with your charger contact your local Power Wheels authorized service cent
21. l for future reference Power Wheels Authorized Service Center as it contains important information e To prevent damaging the motors and gears teach your e The vehicle is designed for use on grass asphalt child to stop the vehicle before switching direction and other hard Surfaces on generally level terrain e If you have any questions about your Power Wheelse and by children 3 years of age and older Do not exceed vehicle please call our toll free service lines at the maximum weight capacity of 65 Ibs 29 5 kg 1 800 348 0751 Trained customer service e Your new vehicle requires adult assembly Please set representatives are available to take your call in aside 30 minutes for assembly English or French Habla Espa ol Si usted tiene e Use this vehicle ONLY outdoors Most interior flooring alguna pregunta necesita asistencia llame gratis can be damaged by riding this vehicle indoors 1 800 348 0755 para los Estados Unidos Tenemos Fisher Price will not be responsible for damage to the representantes que hablan espa ol para atender floor if the vehicle is used indoors su llamada e You must charge your battery for 18 30 hours e For your convenience Power Wheels maintains before you use your vehicle for the first time We an independently owned and operated Authorized recommend charging your battery before beginning Service Center Network with more than 300 authorized assembly Please see the Battery Charging section for service centers
22. llation If this equipment does cause harmful interference to radio or television reception which can be determined by turning the equipment off and on the user is encouraged to try to correct the interference by one or more of the following measures e Reorient or relocate the receiving antenna e Increase the separation between the equipment and receiver Connect the equipment into an outlet on a circuit different from that to which the receiver is connected e Consult the dealer or an experienced radio TV technician for help Note Changes or modifications not expressly approved by the manufacturer responsible for compliance could void the user s authority to operate the equipment This device complies with Part 15 of the FCC Rules Operation is subject to the following two conditions 1 this device may not cause harmful interference and 2 this device must accept any interference received including interference that may cause undesired operation ICES 003 This Class B digital apparatus complies with Canadian ICES 003 Operation is subject to the following two conditions 1 this device may not cause harmful interference and 2 this device must accept any interference received including interference that may cause undesired operation NMB 003 Cet appareil num rique de la classe B est conforme a la norme NMB 003 du Canada Lutilisation de ce dispositif est autoris e seulement aux conditions suivantes 1 il
23. only in a wall outlet Do not plug the charger into a ceiling outlet Once the battery is charged disconnect the battery connector from the charger connector Unplug the charger from the wall outlet Refer to the Battery Installation section for instructions on installing your battery If your battery is already installed in your vehicle simply re connect the motor harness connector to the battery e You do not need to remove the battery from your vehicle to recharge it Before charging the battery examine the battery case for cracks and other damage which may cause sulfuric acid electrolyte to leak during the charging process If damage is detected do not charge the battery or use it in your vehicle Battery acid is very corrosive and can cause severe damage to surfaces it contacts e Do not place the battery on a surface such as kitchen counter tops which could be damaged by the acid contained inside the battery Take precautions to protect the surface on which you place your battery e Charge the battery in a well ventilated area e Please see page 12 for Battery Installation instructions W2604a 0920 ELECTRICAL HAZARD WARNING Battery can fall out and injure a child if vehicle tips over Always use battery retainer e PREVENT FIRE Never modify the electrical system Alterations could cause a fire resulting in serious injury and could also ruin the electrical system Use of the wrong type battery
24. otor harness connector is plugged into the battery and that there are no loose wires around the motors The built in thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped remove your foot from the pedal and wait approximately 25 seconds before operating the vehicle again To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 65 Ibs 29 5 kg maximum weight capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center W2604a 0920 www powerwheels com or call 1 800 348 0751 PROBLEM POSSIBLE CAUSE Vehicle does not run Undercharged battery Charger is not working Tripped thermal fuse Loose wire or loose connectors Dead battery Electrical switch damage Motor damage Vehicle was running Loose wire or loose connectors but suddenly stopped Tripped thermal fuse 17 PROBLEMS AND SOLUTIONS GUIDE SOLUTION Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check
25. s are discarded e Metal parts have been coated with a lubricant to protect them during shipment Wipe all metal parts with a paper towel to remove any excess lubricant Vehicle Front Bumper Sound Box Steering Wheel Cover Steering Wheel 6 Volt Battery Super 6 Volt Charger NM 8 X 3 4 1 9 cm Screw 10 ine 3 s 1 cm 16 Lock Nut 2 Steering Column L Fasteners Shown Actual Size Assembly Tool Wing For your convenience we included extra fasteners Note Tighten and loosen all screws with a Phillips screwdriver Do not over tighten Part not shown Label Sheet W2604a 0920 4 BATTERY CHARGING e Make sure you charge the battery for at least 18 hours using the enclosed Power Wheelse 6 volt charger before operating your vehicle for the first time Charge the battery for at least 14 hours after each use of the vehicle Never charge the battery longer than 30 hours Failure to follow these instructions may damage your battery and will void your warranty e Use only a Power Wheels Super 6 Volt charger with A Style connector 120 VAC 60 Hz with an output of 6 VDC to charge your Power Wheels 6 volt battery q7 Battery must be upright while charging e Plug the battery connector into the charger connector e Plug the charger into a standard wall outlet Notes If power flow to the wall outlet is controlled by a switch make sure the switch is ON Use the charger
Download Pdf Manuals
Related Search