Fisher & Paykel HI120DXB1 User's Manual
Contents
1. line mark is central to the four mounting screw holes Drill holes in the ceiling at the points marked When fitting to a 50 mm truss drill a pilot hole through the ceiling and into the truss If securing to any other ceiling type please use appropriate fasteners and follow their instructions of use carefully For the ducting mark out and cut a 160 mm min hole in the ceiling Fix the ceiling bracket to the ceiling using the screws supplied Using duct tape secure the ducting to the top of the motor housing Tape the power plug to the top of the ducting this will enable easy access to the plug after installation Mount a set of four angle brackets to the canopy Use eight self tapping screws one per side and one per corner Determine the installed height of the canopy and attach the second set of four angle brackets to the first to achieve this height Secure with eight self tapping screws one per side per corner Fig 4 Plan view of support frame 10 11 12 13 14 Installation instructions L5 Strip the plastic protective film off the two chimney pieces and place these over the corners Note Fisher amp Paykel logo to go to the front of the product The lower chimney will rest on top of the canopy hood and the upper chimney will be extended and secured to the ceiling bracket To ensure that the upper chimney does not slip inside the lower chimney secure it so that the upper2. instructions and user guide Published 02 2009 Part No 400006 E
3. Fisher amp Paykel innovative living Installation instructions and User guide Designer series island canopy HI120DXB1 HI120DMB1 models NZ AU GB IE Contents Safety and warnings Installation instructions Getting started quickly Cleaning and maintenance Manufacturer s warranty Customer care Important SAVE THESE INSTRUCTIONS The models shown in this User Guide may not be available in all markets and are subject to change at any time For current details about model and specification availability in your country please visit our local website listed on the back cover or contact your local Fisher amp Paykel dealer CON AUN Safety and warnings L Important Please read the entire set of instructions before installing the island canopy This island canopy is not intended for use by young children or infirm persons without supervision Young children should be supervised to ensure that they do not play with the island canopy There must be adequate ventilation of the room when the island canopy is used at the same time as appliances burning gas or other fuels A partial vacuum in the room could result in too high a concentration of gas in the air You must read the details concerning the method and frequency of cleaning There is a fire risk if cleaning is not carried out in accordance with the instructions Do not flamb under the island canopy Exhaust air must not be discharged
4. ced noise and increased airflow Flexible ducting should only be used as a last resort ie in difficult installations and if used ensure that it is pulled tight The smoother straighter and shorter the ducting the quieter and more efficient the wall canopy will perform All ducting must comply with local requirements and building codes Note we recommend an Easy Fit by Fisher amp Paykel or a UNIDUCT ducting system products that have been designed to expel air efficiently Preparing the island canopy for installation Before drilling any holes check that the area behind the surface to be drilled is clear of any electrical cables pipes etc Fixing to a solid joist or 50 mm deep truss is recommended Whenever possible protect the cooktop with cardboard or the like to prevent damage on installation 4 Installation instructions Important An additional person will be required for Step 11 of this 115 operation or a simple support frame made to the correct dimensions will aid assembly of the island canopy Before commencement unpack the island canopy B and check that it functions correctly Use a plumb line to mark the centre of the cooking surface on the ceiling Front face of canopy Using the ceiling bracket as a template Fig 3 mark Fig 3 Ceiling bracket as template the four holes on the ceiling Ensure that the ceiling bracket front edge is parallel with the bench top and that the plumb
5. chimney is showing Duct tape or placing two screws nails through the upper chimney securing holes will do this Offer the island canopy angle brackets chimneys and ducting up to the ceiling bracket and secure in place with eight screws provided one per side per corner The dimension between the filters and the cooking surface should be in line with those suggested in the Height of island canopy section An additional person will be required for this operation or a simple support frame manufactured to the correct dimensions will aid assembly of the island canopy Finish assembling the ducting ensuring the path is as short straight and smooth as possible Connect to the supply and switch on the power using switch socket outside the island canopy Slide the upper chimney piece up to the ceiling and secure in place with four screws supplied Getting started quickly Control panel II IH F Fan On Off Mid Speed High Speed Delay Off Switch Light On Off Fig 5 Control panel DELAY OFF SWITCH Enables the island canopy to remain on a low mid or high speed for five minutes to clear away all residual cooking odours before switching off automatically OV Cleaning and maintenance Caution Never use abrasive or oil based liquid cleaners General maintenance The manufacturer is not liable for any damage caused by not following these instructions The island canopy should be cleaned regularly using warm wa
6. ctly installed customer Car E You are familiar with its normal operation If after checking these points you still need assistance please refer to your nearest AUTHORISED SERVICE CENTRE or contact us through our local website listed on the back cover In New Zealand if you need assistance Call your Fisher amp Paykel retailer who is trained to provide information on your appliance or if we can be of any further help please contact our Customer Care Centre Toll Free 0800 FP CARE or 0800 37 22 73 Fax 09 273 0656 Email customer care fp co nz Postal address P O Box 58732 Greenmount Auckland If you need service Fisher amp Paykel has a network of independent Fisher amp Paykel Authorised Service Centres whose fully trained technicians can carry out any service necessary on your appliance Your dealer or our Customer Care Centre can recommend an Authorised Service Centre in your area In Australia if you need assistance Call the Fisher amp Paykel Customer Care Centre and talk to one of our Customer Care Consultants Toll Free 13 00 650 590 Fax 07 3826 9298 Email customer care fp com au Postal Address PO Box 798 Cleveland QLD 4163 If you need service Fisher amp Paykel Australia Pty Ltd has a network of independent Fisher amp Paykel Authorised Service Centres whose fully trained technicians can carry out any service necessary on your appliance Our Customer Care Centre can recommend an Authorise
7. d Service Centre in your area In United Kingdom if you need assistance Phone 0845 066 2200 Fax 0845 331 2360 Email customer care fisherpaykel co uk Postal Address Fisher amp Paykel Appliances Limited Maidstone Road Kingston Milton Keynes Buckinghamshire MK10 OBD In Ireland if you need assistance Phone 01800 625 174 Fax 01800 635 012 Email customer care fisherpaykel ie Postal Address Fisher amp Paykel Appliances Irl Ltd Unit D2 North Dublin Corporate Park Swords Co Dublin Customer care 9 If you call or write please provide name address model number serial number date of purchase and a description of the problem This information is needed in order to better respond to your request for assistance Product Details Fisher amp Paykel Appliances Ltd Model Serial No Date of Purchase Purchaser Dealer Suburb Town Country Copyright Fisher amp Paykel 2009 All rights reserved The product specifications in this booklet apply to the specific products and models described at the date of issue Under our policy of continuous product improvement these specifications may change at any time You should therefore check with your Dealer to ensure this booklet correctly describes the product currently available www fisherpaykel co nz www fp com au www fisherpaykel co uk www fisherpaykel ie NZ AU GB IE Designer series island canopy Installation
8. ectrical Shock Hazard All electrical work must be done in accordance with local and or national electrical codes as applicable For safety this product must be earthed If you are unfamiliar with methods of installing electrical wiring employ the services of a qualified electrician Turn off power at service entrance before installing wiring or servicing this product A WARNING Weight Hazard The island canopy is heavy Please ensure adequate care is taken when installing the island canopy to prevent personal injury The island canopy must be installed onto a solid wall stud beam or truss Weight of the product is 43 2 kg N Installation instructions Thank you for purchasing a quality Fisher amp Paykel island canopy Each island canopy is tested and approved before it leaves the factory ensuring our high standard of quality control is met Contents of packaging 1x island canopy 2x chimney pieces 8xangle brackets a 1x installation instructions 4x aluminium mesh filters 4x12x 40mm screw 30x6x 4 self tapping screw 2 spare pL Typical equipment required a Electric drill ZZ Screwdriver AA a Ducttape a Jigsaw eee Ladder Ye Ducting Tape measure Drill bits ao Fig 1 Designer island canopy a Spirit level Accessories Chimney ext 3048 mm 10 ceiling SS 89094 Chimney ext 3048 mm 10 IR 89095 Recirculation kit RR1744 Re
9. into an existing flue that is used for exhausting fumes from appliances burning gas or other fuels The minimum distance between the cooktop surface and the filters of the island canopy shall be 600 mm or 650 mm if installed over a gas cooktop Attention should be given to ensure that any applicable regulations concerning the discharge of exhaust air is fulfilled If the supply cord of this equipment is damaged it must only be replaced by the manufacturer its service agent or similarly qualified person in order to avoid a hazard Always switch the power off prior to installation servicing or cleaning the island canopy Never use the island canopy without the filters in place Stainless steel is very easily damaged during installation if abraded or knocked by tools It is recommended to protect the top of the canopy with cardboard or polystyrene during the installation to minimise the risk of damage occurring A power outlet should be within 750 mm of the motor assembly and can be either on the wall behind the chimney or in the ceiling To comply with electrical safety regulations this canopy must be plugged into a socket near the appliance The socket must be accessible or have an accessible isolating switch to enable the end user to isolate the canopy from the power for the purpose of internal cleaning or maintenance Ducting accessories are not supplied All ducting must comply with local requirements and building codes A WARNING El
10. n bulb 12 Volts 20 Watt Switch off the power to the island canopy Use a small bladed screwdriver to prise off the light cover taking care not to damage the surrounding material Remove the defective bulb from the canopy hood Replace with a new bulb using a cloth Do not touch the bulb with fingers as this will shorten the life of the bulb Snap the cover back into place Fig 6 Replacing a light bulb Manufacturer s warranty L7 You automatically receive a 2 year Manufacturer s Warranty with the purchase of this Product covering parts and labour for servicing within the country of purchase Fisher amp Paykel undertakes to Repair or at its option replace without cost to the owner either for material or labour any part of the Product the serial number of which appears on the Product which is found to be defective within TWO YEARS from the date of purchase This warranty DOES NOT cover Service calls which are not related to any defect in the Product The cost of a service call will be charged if the problem is not found to be a Product related fault For example 1 Correcting the installation of the Product 2 Instructing you how to use the Product 3 Replacing house fuses or correcting house wiring 4 Correcting fault s caused by the user 5 Noise or vibration that is considered normal eg fan sounds refrigeration noises or user warning beeps 6 Correcting damage caused by pests eg rats cock
11. placement charcoal filter R104165 Light bulb R104467 Replacement aluminium filter R104660 Installation instructions L3 Height of island canopy The island canopy is designed for 2440 mm high ceilings The chimney is telescopic and is designed for hood installations gt 4 between 600 to 750 mm above the cooking surface Filter surface Ascertain the desired installation height of the island canopy Q Any installation above 750 mm will compromise the Ea a ee extraction performance Cooktop The air outlet from the motor requires 150 mm round ducting which requires a 160 mm min diameter hole in the ceiling A 600 min electric cook top A 650 min gas cook top Fig 2 Positioning Ducting options Recirculation For recirculation please purchase a recirculation kit part no RR1744 The recirculation kit is required to channel the air out through the side vents at the top of the flue Note a ducting hole is not required to be cut in the ceiling if a recirculation kit is fitted Ducting For ducted installation it is recommended that you use 150 mm diameter rigid or semi rigid ducting This will require a 160 mm min round hole in the ceiling which the decorative chimney will cover Care should be taken to align the canopy with the decorative chimney allowing sufficient clearance to accommodate the ducting For optimum efficiency use smooth wall solid galvanized or plastic ducting for redu
12. roaches etc Defects caused by factors other than 1 Normal domestic use or 2 Use in accordance with the Product s User Guide Defects to the Product caused by accident neglect misuse or Act of God The cost of repairs carried out by non authorised repairers or the cost of correcting such unauthorised repairs Normal recommended maintenance as set out in the Product s User Guide Repairs when the appliance has been dismantled repaired or serviced by other than a Fisher amp Paykel AUTHORISED CUSTOMER SERVICE CENTRE or the selling dealer Pick up and delivery Transportation or travelling costs involved in the repair when the Product is installed outside the Fisher amp Paykel AUTHORISED CUSTOMER SERVICE CENTRE S normal service area This Product has been designed for use in a normal domestic environment It is not intended for commercial use Doing so may affect Product warranty Service under this manufacturer s warranty must be provided by an Authorised Service Agent refer to the Customer care section for contact details Such service shall be provided during normal business hours This warranty certificate should be shown when making any claim Note This Warranty is an extra benefit and does not affect your legal rights Please keep this User Guide in a safe place lee Customer care Check the things you can do yourself 5 Refer to your User Guide and check RENT es Your appliance is corre
13. ter with soap or mild liquid detergents This ensures that no build up of grease occurs as these deposits are corrosive Do not use abrasives or harsh detergents cleaning fluids Note in areas of high humidity and coastal environments cleaning should be carried out frequently Aluminium filters The grease filters must be periodically cleaned at least every two months Remove the grease filters and wash them either by hand using hot soapy water or place them in the dishwasher using mild detergent Badly smoked filters may be cleaned with cookware cleaners Note some discolouration of the frame may occur Charcoal filters Charcoal filters are designed to remove grease and odours from cooking vapours prior to the cleansed air re entering the kitchen when the island canopy is in recirculating mode Charcoal filters are disposable items and it is recommended that these should be replaced every three to six months depending on use Note Fully saturated charcoal filters can become a barrier to air movement impeding the island canopy s performance In the event of fire fully grease laden filters could be flammable and therefore regular replacement is recommended In ducted installations conventional aluminium filters are recommended For replacement charcoal filters ducting accessories spare parts and service please contact your local supplier or Fisher amp Paykel Customer Care Centre Light bulb replacement Haloge
Download Pdf Manuals
Related Search