Echo SHR-210 User's Manual
Contents
1. Correct the spark gap if it is wider or narrower than the standard gap Fastening torque 15 to 17 Nem 130 to 145 inelb CHEMICAL TANK BREATHER Breather valve e Clean breather valve and breather hole periodically e Bad sealing of the breather valve may cause a leakage of the chemical Clogging of the breather hole may cause a dent or a breakage of the chemical tank Breather hole CHEMICAL STRAINER e Clean chemical strainer periodically e Clogging of the chemical strainer may cause insufficient discharge of the chemical BYPASS NOZZLE PLATE e Clean bypass nozzle plate if liquid chemical is X Bypass nozzle plate not well stired up in the tank gt AA O NS WHEN SPRAYING IS FINISHED e Fill chemical tank with water and spray through nozzle for 2 to 3 minutes for cleaning e Drain water from the machine through misting nozzle and remove pump drain plug e Wipe off the liquid chemical on the machine after use Remove the drain plug Drain plug EMISSION DATA EMISSION CONTROL EXHAUST EPA 2010 and or C A R B TIER Ill The emission control system for the engine is EM TWC Engine Modification and 3 way Catalyst An Emission Control Label is located on the engine This is an example only information on label varies by engine family High Altitude Operation This engine has been factory adjusted to maintain satisfactory starting emission and durability performance up to 1100 fee2. do not try to repair it yourself but have your distributor or dealer do it for you For detailed TROUBLE SHOOTING refer to tables 1 and 2 Locate the problem on the following charts and repair as necessary Table 1 Engine does not start or is difficult to start Engine cranks There is fuel in the tank Fuel is reaching carburetor a Fuel is reaching cylinder There is spark at high tension cord end m There is spark at plug Starting procedures correct Fuel is not reaching carburetor No spark at high No spark at plug Fuel does not keep running Accelera tion and Fuel is not reaching cylinder tension cord a Fuel filter clogged Fuel pipe clogged Suction insufficient Fuel filter clogged Carburetor out of order C D I module defective Ignition coil defective Wire connection defective High tension cord connection defective Switch is grounded Insulator cracked Spark gap incorrect Covered with carbon Fouled with fuel Starting procedures incorrect Fuel passage clogged with dust Fuel passage locked with air Fuel leaking from fixing surfaces of carburetor low speed function defective Carburetor overflow Engine does Air passage fuel tank clogged with dust Fuel inlet needle valve clogged with dust Muffler sticky with fuel Bearing damaged Piston and or cylinde
3. Inc at 1 800 673 1558 web site WWW ECHO USA COM WHAT DOES THIS WARRANTY COVER ECHO Inc warrants that your equipment SORE was designed built and equipped to conform with applicable EPA and C A R B emissions standards and that your equipment SORE is free from defects in material and workmanship that would cause it to fail to conform with applicable requirements for 2 years or the length of the ECHO Inc warranty whichever is longer The warranty period begins on the date the product is purchased by an end user HOW WILL A COVERED PART BE CORRECTED If there is a defect in a part covered by this warranty any ECHO Inc Authorized Service Dealer will correct the defect You will not have to pay anything to have the part adjusted repaired or replaced This includes any labor and diagnosis for warranted repairs performed by the dealer In addition engine parts not expressly covered under this warranty but whose failure is a result of a failure of a covered part will be warranted WHAT PARTS ARE COVERED Any applicable emission related part not scheduled for required maintenance will be repaired or replaced within the warranty period The repaired or replaced part will be warranted for the remaining ECHO Inc warranty period Any warranted part that is scheduled only for regular inspection in the written instructions supplied is warranted for the warranty period stated above Any such part repaired or replaced under warranty will be warran
4. System Warranty is extended to the original owner including all subsequent owners MANUFACTURER S WARRANTY COVERAGE The emission control system is warranted for 2 years or the length of the ECHO Inc warranty whichever is longer If any emission related part on your equipment is defective the part will be repaired or replaced by ECHO Inc or its Authorized Service Representative OWNER S WARRANTY RESPONSIBILITIES As the equipment SORE owner you are responsible for the performance of the required maintenance listed in your Operator s Manual ECHO Inc recommends that you retain all receipts covering maintenance on your equipment SORE however ECHO Inc cannot deny warranty solely for the lack of receipts or for your failure to ensure the performance of all scheduled maintenance As the equipment SORE owner you should be aware that ECHO Inc may deny you warranty coverage if your equipment SORE or a part has failed due to abuse neglect improper maintenance or unapproved modifications You are responsible for presenting your equipment SORE to an ECHO Inc authorized service representative as soon as a problem exists The warranty repairs should be completed in a reasonable amount of time not to exceed 30 days If a warrantable condition exists and there is no Authorized Dealer within 100 miles ECHO Inc will pay to ship the unit to the nearest authorized dealer If you have questions regarding your warranty coverage you should contact ECHO
5. or emission components or running engines above specified and recommended engine speeds as listed in your operators manual e Operation of the unit with improperly maintained removed cutting shield or removed damaged air filter e Damage caused by dirt pressure or steam cleaning the unit salt water corrosion rust varnish abrasives and moisture e Defects malfunctions or failures resulting from abuse misuse neglect modifications alterations normal wear improper servicing or use of unauthorized attachments e Incorrect storage procedures stale fuel including failure to provide or perform required maintenance services as prescribed in the operators manual Preventative maintenance as outlined in the operators manual is the customer s responsibility e Failures due to improper set up pre delivery service or repair service by anyone other than authorized ECHO servicing dealer during the warranty period e Certain parts and other items are not warranted including but not limited to lubricants starter cords and engine tune ups e Use of spark plugs other than those meeting performance and durability requirements of the OEM spark plug listed in the Operators Manuals e Overheating or carbon scoring failures due to restricted clogged exhaust port or combustion chamber including damage to spark arrester screen e Adjustments after the first 30 thirty days and beyond such as carburetor adjustment and throttle cable adjustment e D
6. or unapproved accessories This Emission Control Warranty is valid only for the U S A it s Territories and Canada 16
7. 104 1061 1 Optional Optional nozzles are available at extra cost Nozzle specifications At 1 0 MPa 10kgf cm e For some country a optional nozzle is supplied 142 2 psi as standard part Discharge volume Spraying distance Nozzle L min FI oz US min 2 head nozzle 2 4 81 2 Standard line type Adjustable jet nozzle Mist 2 4 3 10 Pistol grip type Spray 5 0 5 16 7 Adjustable jet nozzle Mist 2 4 3 10 Long distance type Spray 5 0 5 16 7 1 Discharge volume Nozzle L min FI oz US min 2 head nozzle Line type 7 head nozzle Line type 4 2 142 4 head nozzle 1 5 50 8 Ring type 2 0 67 6 IMPORTANT RULES FOR SAFE OPERATION 1 Handle gasoline with care It is highly inflammable 3 Do not allow bystanders in work area Refuel before starting work 4 Do not point the nozzle in the direction of people Do not smoke while handling fuel 5 Always wear safety glasses and gloves Do not refuel a hot engine 6 Avoid wearing loose clothing or loose scart Avoid spilling fuel or oil Always wipe unit dry before 7 Always use a face filter mask to avoid breathing using chemicals Move at least 3 m 10 feet away from the fueling 8 Handle agricultural chemicals with care It is point before starting engine poisonous Always store gasoline in an approved container Always remove chemicals from the tank when not 2 Do not operate in unventilated area in use Store chemicals in a safety c
8. Disassemble check and 6 piston ring stuck or worn replace if necessary out Cylinder chromium plating Replace cylinder Other troubles peeled or worn out 5 Exhaust port clogged with Clean as necessary Cc carbon z a Throttle is not fully open Readjust D g Pump case blade worn out Replace Low pressure Chemical liquid line _ Replace defective l Mechanical seal or packing Spray is not a fine mist beg Cracked spraying hose is Replace used Nozzle orifice is too large Replace Too much chemical is eae Chemical line is completely Clean clogged with dirt L No spray Chemical tank is empty Refill Pump is damaged Replace WARNING DANGER FUEL VAPORS ARE EXTREMELY FLAMMABLE AND MAY CAUSE FIRE AND OR EXPLOSION NEVER Output engine speed sufficient TEST FOR IGNITION SPARK BY GROUNDING SPARK PLUG NEAR CYLINDER PLUG HOLE OTHERWISE SERIOUS PERSONAL INJURY MAY RESULT 54D STORAGE AFTER USE e Drain remaining liquid out of the chemical tank e Inspect and adjust every part of the sprayer Completely clean every part and repair if necessary Apply thin coating of oil on metal parts to prevent rust Remove spraying hose and pipe Drain fuel tank pull starter slowly a few times to drain fuel from carburetor Pour a small amount of clean motor oil into sp
9. UEGAE A OPERATOR S MANUAL POWER SPRAYER SHR 210 READ INSTRUCTIONS CAREFULLY AND FOLLOW RULES FOR SAFE OPERATION or WARNING 4 DANGER FAILURE TO DO SO COULD RESULT IN SERIOUS INJURY X750 004 14 4 ECHO INCORPORATED X750604 530 4 400 Oakwood Road Lake Zurich Illinois 60047 1564 Phone 847 540 8400 Printed in Japan 1002Ash 1135 ES A WARNING A The engine exhaust from this product contains chemicals known to the State of California to cause cancer birth defects or other reproductive harm Copyright 2002 YAMABIKO CORPORATION All Rights Reserved VARIETY OF NOZZLE FOR ECHO POWER SPRAYER SHR 210 Convenient to use and reliable the go anywhere SHR 210 power sprayer is highly versatile with a large vari ety of optional nozzles which adapts it to a wide range of applications The use of this power sprayer at home on the farm or in a commercial environment are limit less Most importantly what used to take hours takes only minutes with the SHR 210 making it an unequaled value for the homeowner and professional alike 2 head nozzle Standard line type 224 203 1061 0 Standard Adjustable jet nozzle Pistol grip type 224 000 10610 Optional 4 head nozzle Ring type Adjustable jet nozzle Long distance type Part No E025 000260 Optional 2 head nozzle Line type 224 202 1061 0 Optional 7 head nozzle Line type y AT Part No 224 101 1061 0 Optional 224
10. amage to gears or gear cases caused by contaminated grease or oil use of incorrect type or viscosity of lubricants and or failure to comply with recommended grease or oil change intervals e Damage caused by loading SHRED N VAC beyond recommended capacity e Damage caused by pump or sprayer running dry pumping or spraying caustic or flammable materials or lack of or broken strainers e Additional damage to parts or components due to continued use after operational problem or failure occurs Should operational problem or failure occur the product should not be used but delivered as is to an authorized ECHO servicing dealer It is a dealers and or customer s responsibility to complete and return the warranty registration card supplied with your ECHO product or by visiting WWW ECHO USA COM Your receipt of purchase including date model and serial number must be maintained and presented to an authorized ECHO servicing dealer for warranty service Proof of purchase rests solely with the customer Some states do not allow limitations on how long an implied warranty lasts so the above limitations may not apply to you Some states do not allow the exclusion or limitation of incidental or consequential damages so you may also have other specific legal rights which vary from state to state This limited warranty is given by ECHO Incorporated 400 Oakwood Rd Lake Zurich IL 60047 DISCLAIMER OF IMPLIED WARANTIES This limited warranty is in
11. ark plug hole pull starter and crank the engine until the TOP DEAD CENTER Store in a dry area free from dust TECHNICAL DATA Dimension 330 x 405 x 590 13 0 x 15 9 x 23 2 Mass w o Spraying hose kg Ib 7 4 16 3 and nozzle Capacity Chemical liquid tank L gal US 19 0 5 0 Engine Type Displacement mL cu in Rated speed r min Carburetor Ignition Spark plug Starter Fuel Mixing ratio Tank capacity L fl oz US Pump Type Discharge volume Nozzle Pressure L min fl oz US min MPa kgf cm psi Nozzle Spraying hose Technical data may be changed without advance notice 13 Air cooled two stroke single cylinder 21 2 1 3 7500 ZAMA diaphragm type Flywheel magneto CDI Capacitor discharge ignition system NGK BPM8Y Recoil starter Mixture of gasoline unleaded 89 octane minimum and specially blended 50 1 ECHO two cycle engine oil 0 5 16 9 Regenerative pump 0 8 7 0 27 236 7 0 6 1 0 6 10 85 3 142 2 2 head nozzle 7 5mm Inner diameter Other nozzles are available as optional supply WARRANTY STATEMENTS ECHO LIMITED WARRANTY STATEMENT FOR PRODUCT SOLD IN USA AND CANADA BEGINNING 01 01 2010 ECHO S RESPONSIBILITY ECHO Incorporated s Limited Warranty provides to the original purchaser that this ECHO product is free from defects in material and workmanship Under normal use and maintenance from date of purchase ECHO agrees to re
12. d keep at idle speed for a while to warm it up e lftemperature is high or engine is warm keep choke lever half opened or totally opened WARNING Engine exhaust IS HOT and contains Carbon Monoxide CO a poison gas Breathing CO can cause unconsciousness serious injury or death Exhaust can cause serious burns ALWAYS blow exhaust away from your face and body SPRAYING e Ensure that chemical liquid valve is closed before starting engine e After engine is warmed up turn throttle lever to the high speed position Upper position and open liquid valve NOTE Since this unit is equipped with a centrifugal clutch sprinkling is not possible when the engine is running at low speeds idling FOR SAFE OPERATION Secure the chemical tank cap Check all connections to avoid chemical leak Nozzle Nozzle pipe hose etc Avoid wearing loose clothing and always wear safety glasses and gloves Use a face filter mask to avoid breathing chemical Check wind direction before spraying Do not point nozzle in the direction of people Stop the engine when refueling and or replacing parts Close fuel chemical liquid valve when not in use Avoid using at engine speeds where the clutch slips Sener So NS STOPPING ENGINE e Turn throttle lever to the lowest position and the ignition switch to STOP position CAUTION When misting liquid is over stop the engine Do not keep engine running when chemical tank has been em
13. eice E i a NE 14 NOMENCLATURE Safety decal Part number 890160 13210 Chemical liquid tank Fuel tank cap Fuel tank Spray hose Ignition switch Air cleaner Locate this safety decal on your unit The complete unit illustration found in the NOMENCLATURE sec tion will help you locate them Make sure the decal is legible and that you understand and follow the instructions on them If a decal cannot be read a new one can be ordered from your ECHO dealer WARNING 44 DANGER This sprayer is operated with liquid under pressure Failure to observe safety precautions or follow instructions for operating and cleaning can cause tank hose and other parts to be weakened and or rupture under pressure This can result in SERIOUS INJURY form high pressure discharge of liquids or forceable ejection of parts WARNING A DANGER DO NOT use flammable materials in this sprayer Material could ignite or explode causing SERIOUS INJURY DO NOT use caustics or acids Either can cause corrosion and weaken hose and gaskets DO NOT use hot water Excess heat can weaken plastic and rubber components DO NOT use sprayer if hose is frayed cracked or shows signs of swelling ALWAYS read and understand directions supplied by manufacturer packager of product to be sprayed ALWAYS wear goggles that meet ANSI Z87 1 specification and protective clothing when using sprayer ALWEYS use ECHO replacement parts Use of improper parts may lead to a failure and
14. il usage as prescribed in the operators manual Should a product difficulty occur you must at your expense deliver or ship your ECHO unit to an authorized ECHO servicing dealer for warranty repairs within the applicable warranty period and arrange for pick up or return of your unit after the repairs have been made For your nearest authorized ECHO servicing dealer call ECHO s Dealer Referral Center at 1 800 432 ECHO or you can locate an ECHO servicing dealer at WWW ECHO USA COM Should you require assistance or have questions concerning ECHO s Warranty Statement you can contact our Consumer Product Support Department at 1 800 673 1558 or contact us through the web at WWW ECHO USA COM PRODUCT WARRANTY PERIOD RESIDENTIAL APPLICATION e 5 YEAR WARRANTY All units for residential or non income producing use will be covered by this limited warranty for five 5 years from date of purchase EXCEPTIONS e For two stroke engine powered products the electronic ignition module flexible drive cables SRM solid drive shafts and TC tines are warranted for the life of the product on parts only e Cutting attachments such as but not limited to bars chains sprockets blades and nylon trimmer heads for residential or non income producing use will be covered for failures due to defects in material or workmanship for a period of 60 days from original product purchase date Any misuse from contact with concrete rocks or other structures is not c
15. ing e Inspect for fuel leakage If fuel leakage is found do not start or operate until leakage is repaired e Move at least 3 m 10 feet from refueling location before starting the engine Chemical liquid tank HANDLING FUEL MIXING INSTRUCTIONS 1 Fillan approved fuel container with half of the required amount of gasoline 2 Add the proper amount of two stroke oil to gasoline 3 Close container and shake to mix oil with gasoline 4 Add remaining gasoline close fuel container and remix IMPORTANT e Spilled fuel is a leading cause of hydrocarbon emissions Some states may require the use of automatic fuel shut off containers to reduce fuel spillage e Stored fuel ages Do not mix more fuel than you expect to use in thirty 80 days ninety 90 days when a fuel stabilizer is added e Stored two stroke fuel may separate ALWAYS shake fuel container thoroughly before each use AFTER USE DO NOT store a unit with fuel in its tank Leaks can occur Return unused fuel to an approved fuel storage container STORAGE Fuel storage laws vary by locality Contact your local government for the laws affecting your area As a precaution store fuel in an approved unoccupied building away from sparks and flames CHEMICAL Liquid TANK e Fill the tank with liquid chemical through the strainer Do not fill without strainer Dust in the tank may cause clogging of the liquid line or pump e The tank contain
16. lieu of all other expressed or implied warranties including any warranty of FITNESS FOR A PARTICULAR PURPOSE OR USE and any implied warranty of MERCHANTABILITY otherwise applicable to this product ECHO and its affiliated companies shall not be liable for any special incidental or consequential damage including lost profits There are no warranties extended other than as provided herein This limited warranty may be modified only by ECHO 15 ECHO INCORPORATED EMISSION CONTROL WARRANTY STATEMENT FOR ECHO BRAND The Environmental Protection Agency EPA and the California Air Resources Board C A R B and ECHO Incorporated ECHO Inc are pleased to explain the emission control system warranty on your 2010 and later equipment small off road engine SORE New equipment SORE must be designed built and equipped to meet stringent EPA and C A R B anti smog standards ECHO Inc must warrant the emission control system on your equipment SORE for the periods of time listed below provided there has been no abuse neglect or improper maintenance of your equipment SORE Your emission control system may include parts such as carburetor fuel injection system ignition system catalytic converter muffler fuel tank fuel feed lines fuel cap assembly spark plug air filters and other associated components Where a warrantable condition exists ECHO Inc will repair your equipment SORE at no cost to you including diagnosis parts and labor The Emission Control
17. lly formulated to meet ISO L EGD ISO CD 13738 and JASO M345 FC FD Standards The use of two stroke oils designed for other applications such as for outboard motors or lawnmowers can result in severe engine damage and will void your two stroke engine limited warranty THIS WARANTY DOES NOT COVER DAMAGE CAUSED BY e Lack of lubrication or engine failure due to the use of two stroke oils that do not meet the ISO L EGD ISO CD 13738 and JASO M345 FC FD Standards Engine problems due to inadequate lubrication caused by failure to use an ISO L EGD compliant and JASO M345 FC FD registered oil will void the two stroke engine limited warranty ECHO Power Blend X Two Stroke Oil meets the ISO L EGD and JASO M345 FC FD Standard Emission related parts are covered for 5 years residential use or 2 years commercial use regardless of two stroke oil used per the statement listed in the EPA or California Emission Defect Warranty Explanation e Damage caused by use of gasohol containing methanol wood alcohol or gasoline containing less than 89 octane Only use gasoline which contains 89 octane or higher Gasohol which contains a maximum 10 ethanol grain alcohol or 15 MTBE methyl tertiary butyl ether is also approved The prescribed mixing ratio of gasoline to oil is listed on the ECHO oil label and covered in your operator s manual e Engine damage caused by use of ether or any starting fluids e Damage caused by tampering with engine speed governor
18. ontainer A WARNING Moving parts can amputate fingers or cause severe injuries Keep hands clothing and loose objects away from all openings e ALWAYS stop engine disconnect spark plug and make sure all moving parts have come to a complete stop before removing obstructions clearing debris or servicing unit e DO NOT start or operate unit unless all guards and protective covers are properly assembled to unit e NEVER reach into any opening while the engine is running Moving parts may not be visible through openings A WARNING Check fuel system for leaks due to fuel tank damage especially if the unit is dropped If damage or leaks are found do not use unit otherwise serious personal injury or property damage may occur Have unit repaired by an autho rized servicing dealer before using CONTENTS RULES POR SAFE Or BRON csias ere nacenecacacnitetete denencsiesiqeqnecemraeeo E EAE DANS AREE ERA R 2 NOMENCLATURE oaea n ET E err eee ere eee 3 Aoao E NEIN seipa eee re E E A ee ere EEE E E 4 OPERATION marmorissa nnen o Ee E A EE E E E eon aeoe 4 MAINTENANCE AND CARE acest cc sats cece sacs serene aaan ES iaa aa 2 set cae RES iana 8 EMG Bene ne A E E ere ee ee 10 TROUBLE SHOOTING ereeeer meer eer ne ere ee ere eee er ere re 11 STORACE AFTER U E ease ce att cecesceien nE a rece yeenpies oy ees SEE A EE eevee cen teen eee cee 13 Ht S 1 Ms DB 2 ear ne eee E ee ee en eee 13 WARRANTY EAE IN Ss oss care sete eda cas es ee aoe cece es p
19. overed by this warranty e ECHO s Rapid Loader String Head carries a lifetime warranty on the line locking system parts only no labor Refer to your operators manual for string head installation and maintenance instructions e All SB Series and PRO ATTACHMENT SERIES Split Shaft attachments carry the same warranty duration as the units they are designed to fit COMMERCIAL APPLICATION e 1 YEAR WARRANTY All Chain Saws QuikVent Saws and Cut Off Saws for commercial institutional agricultural industrial or income producing use will be covered by this limited warranty for a period of one 1 year from the date of purchase e 2 YEAR WARRANTY All other units for commercial institutional agricultural industrial or income producing use will be covered by this limited warranty for a period of two 2 years from the date of purchase EXCEPTIONS e For two stroke engine powered products the electronic ignition module flexible drive cables SRM solid drive shafts and TC tines are warranted for the life of the product on parts only e Cutting attachments such as but not limited to bars chains sprockets blades and nylon trimmer heads for commercial institutional agricultural industrial rental or income producing will be covered for failures due to defects in material or workmanship for a period of 30 days from original product purchase date Any misuse from contact with concrete rocks or other structures is not covered by this war
20. pair or replace at ECHO s discretion any defective product free of charge at any authorized ECHO servicing dealer within listed below application time periods limitations and exclusions THIS LIMITED WARRANTY IS ONLY APPLICABLE TO ECHO PRODUCTS SOLD BY AUTHORIZED ECHO DEALERS IT IS EXTENDED TO THE ORIGINAL PURCHASER ONLY AND IS NOT TRANSFERABLE TO SUBSEQUENT OWNERS EXCEPT FOR EMISSION RELATED PARTS Repair parts and accessories replaced under this warranty are warranted only for the balance of the original unit or accessory warranty period Any damage caused by improper installation or improper maintenance is not covered by this warranty All parts or products replaced under warranty become the property of ECHO Inc This warranty is separate from the Emission Control Warranty Statement supplied with your new product Please consult the Emission Control Warranty Statement for details regarding emission related parts For a list of Authorized ECHO Dealers refer to WWW ECHO USA COM or call 1 800 432 ECHO OWNER S RESPONSIBILITY To ensure trouble free warranty coverage it is important that you register your ECHO equipment on line at WWW ECHO USA COM or by filling out the warranty registration card supplied with your unit Registering your product confirms your warranty coverage and provides a direct link if we find it necessary to contact you The owner shall demonstrate reasonable care and use and follow preventative maintenance storage fuel and o
21. ptied NOZZLE e 2 head nozzle Standard type is provided with this power sprayer e Standard nozzle discharge volume and pressure are as follows Chemical liquid Discharge 2 4 L min 81 2 Fl oz US min 1 0 MPa 142 2 psi 1 Nozzlebody 4 Nozzle 2 Guide 5 Cap 3 Strainer NOTE You can use a nozzle other than standard nozzle discharges liquid under 7 0 L at nozzle pressure 1 0 MPa 10 kgf cm as required Long hose approx 100 m is available as required In this case use standard nozzle indicated above or less discharge volume nozzle e As for variety of optional nozzles please refer to Page 1 we MAINTENANCE AND CARE ALWAYS KEEP THE MACHINE CLEAN AIR FILTER Carburetor Reg Filter Air cleaner cover Check before every use Remove filter cover Remove wing nut Brush off dust lightly or wash in a non inflammable solvent if necessary Dry well before reinstalling CHECK FUEL SYSTEM Check before every use After refueling make sure fuel does not leak or exude from around fuel pipe fuel grommet or fuel tank cap In case of fuel leakage or exudation there is a danger of fire Stop using the machine immediately and request your dealer to inspect or replace SPARK PLUG Clean or replace the plug if fouled with heavy or oily deposits Replace the plug if the center electrode is worn or rounded at the end The standard spark gap is 0 6 to 0 7 mm 0 024 to 0 028 in
22. r seized not crank Crankshaft worn Crankshaft contacting crankcase 11 Clean or replace Clean Make sufficient Clean or replace Disassemble and check Remove and replace Remove and replace Reconnect Repair as necessary Switch on Replace plug Adjust Clean or replace Clean or replace Start correctly Disassemble and clean Remove air Retighten all screws Replace or clean Clean This is because fuel mixture is too rich Start the engine several times with choke rod fully open and run at fast idle until engine does not smoke Disassemble and replace Disassemble and replace Disassemble and replace Disassemble and replace Table 2 Improper fuel is used Use fuel with correct mixing ratio Never use gasoline of poor quality Spark plug defective burnt Replace Engine overheated As cooling fins clogged air Clean fins does not pass well Excessive deposits in Disassemble and remove combustion chamber carbon 5 D l l Plug damaged or fouled Replace or clean Firing function defective 9 Combustion poor due to Check wiring defective wiring O Q N Carburetor overflow Refer to Table 1 2 Carburetor defective Air filter clogged _ Clean as necessary 3 Compression insufficient
23. ranty e ECHO s Rapid Loader String Head carries a lifetime warranty on the line locking system parts only no labor Refer to your operators manual for string head installation and maintenance instructions e All SB Series and PRO ATTACHMENT SERIES Split Shaft attachments carry the same warranty duration as the units they are designed to fit RENTAL APPLICATION 90 DAYS WARRANTY e Units for rental use will be covered against defects in material and workmanship for a period of 90 days from the date of purchase ECHQ s liability under the Lifetime coverage is limited to furnishing parts specified under the PRODUCT WARRANTY PERIOD section of this Warranty Statement for Life free of charge for a period of ten 10 years after the date of the complete unit s final production 14 PURCHASED REPAIR PARTS SHORT BLOCKS AND ACCESSORIES e 90 day residential or non income producing warranty e 30 day commercial institutional agricultural industrial income producing or rental application warranty ATTENTION TWO STROKE ENGINE POWER PRODUCT OWNERS This ECHO two stroke engine power product is a quality engineered unit which has been manufactured to exact tolerances to provide superior performance To help ensure the performance of the unit it is required to use two stroke oil which meets the ISO L EGD Standard per ISO CD 13738 and JASO M345 FC FD Standards ECHO Power Blend X Two Stroke Oil is a premium two stroke oil specifica
24. s 19 L 5 0 gal US of liquid NOTE Each mark on the side of the tank indicates the 5 10 and 15 L levels e Ensure that tank cap is on tightly to avoid chemical leak e Itis not necessary to apply grease oil to pump Shoulder level Choke lever START Ges NNS RUN Open Throttle lever Starter handle STARTING ENGINE Never start and operate engine before filling chemical tank to avoid damage to pump WARNING A DANGER e WHEN ENGINE IS STARTED CONFIRM IF THERE IS NOT ANY ABNORMAL VIBRATION OR SOUND IF THERE IS ABNORMAL VIBRATION OR SOUND ASK YOUR DEALER TO REPAIR e AFTER REFUELING TIGHTEN FUEL CAP FIRMLY AND CHECK FOR LEAKAGE IN CASE OF FUEL LEAKAGE REPAIR BEFORE STARTING OPERATION SINCE THERE ISA DANGER OF FIRE e Fill fuel tank with fuel e tis not permitted to fill fuel above the shoulder level of fuel tank e Place ignition switch in START RUN position e Turn choke lever to CLOSE START position e Keep throttle lever at idle position in the middle of scale e Operate the carburetor s purge bulb several times with your finger press lt gt release to make sure that fuel flows from the fuel return line e Pull starter handle until engine starts NOTE Recoil starter Use short pulls Do not pull starter rope all the way out and rewind it back gradually e Pull back choke lever OPEN position slowly after engine starts an
25. serious injury ALWAYS KEEP SPRAYER AND SPRAY MATERIALS OUT OF THE REACH OF CHILDREN IMPORTANT DO NOT operate without liquid in the chemical tank Damage to the pump will occur Safety decal Part number 890160 13210 ASSEMBLING SPRAY HOSE AND NOZZLE e Install spray hose liquid valve nozzle pipe and nozzle to the machine Nozzle pipe og p M Nozzle Liquid valve Spray hose SHOULDER STRAPS e Shoulder straps are adjustable to fit any operator e Adjust straps so that pads rest comfortably on the operator s shoulders OPERATION GENERAL CHECK e Ensure that all nuts screws and bolts installed are properely tightened Spray hose 44 WARNING Alternative fuels such as E 20 20 ethanol E 85 85 ethanol or any fuels not meeting above requirements are NOT approved for use in ECHO 2 stroke gasoline engines Use of alternative fuels may cause performance problems loss of power overheating fuel vapor lock and unintended machine operation including but not limited to improper clutch engagement Alternative fuels may also cause premature deterioration of fuel lines gaskets carburetor and other engine components Fuel mix chart 50 1 OIL mL 160 400 FUEL STATEMENT GASOLINE Use 89 Octane R M 2 mid grade or higher gasoline or gasohol known to be good quality Gasohol may contain up to 10 Ethyl grain alcohol or 15 MTBE methyl tertiary butyl ether Gasohol containing me
26. t above sea level ASL 96 0 kPa To maintain proper engine operation and emission compliance above 1100 feet ASL the carburetor may need to be adjusted by an authorized ECHO service dealer IMPORTANT If the engine is adjusted for operation above 1100 feet ASL the carburetor must be readjusted when operating the engine below 1100 feet ASL otherwise severe engine damage may result 10 PRODUCT EMISSION DURABILITY EMISSION COMPLIANCE PERIOD The 300 hours emission compliance period is the time span selected by the manufacturer certifying the engine emissions output meets applicable emissions regulations provided that approved maintenance procedures are followed as listed in the Maintenance Section of this manual EMISSION CONTROL INFORMATION ENGINE FAMILY E EHXS 0214EE DISPLACEMENT 21 2cc EMISSION COMPLIANCE PERIOD 300Hours REFER TO OWNER S MANUAL FOR MAINTENANCE SPECIFICATIONS AND ADJUSTMENTS TROUBLE SHOOTING Poor performance of the engine and or spraying mechanism can normally be prevented by carefully following the above instructions Poor performances can easily be corrected even by a beginner When the engine does not function properly check the following three 3 points first Is engine compression adequate Is fuel system in good condition and is enough fuel being supplied Is electrical system in good condition and is spark plug operating normally When there is serious trouble with the unit
27. ted for the remaining ECHO Inc warranty period Any emission related part scheduled for replacement during required maintenance is warranted for the period of time prior to the first scheduled replacement point for that part Any such part repaired or replaced under warranty shall be warranted for the remainder of the period prior to the first scheduled replacement point for that part Any manufacturer approved replacement part may be used in the performance of any warranty maintenance or repairs on emission related parts and must be provided without charge if the part is still under warranty Any replacement part that is equivalent in performance and durability may be used in non warranty maintenance or repairs and shall not reduce the warranty obligations of the manufacturer Throughout the equipment SORE warranty period ECHO Inc will maintain a supply of warranted parts sufficient to meet the expected demand for such parts SPECIFIC EMISSION RELATED WARRANTED PARTS e Electronic Ignition System e Spark Plug e Catalytic Converter Muffler Assembly e Carburetor complete assembly or replaceable components e Choke e Fuel Injection Assembly or replaceable components e Fuel Tank e Fuel Cap Assembly e Air Filter e Fuel Feed Line and associated clamps connectors as applicable WHAT IS NOT COVERED Any failure caused by abuse neglect improper maintenance unapproved modifications use of unapproved add on parts modified parts
28. thyl wood alcohol is NOT approved TWO STROKE OIL A two stroke engine oil meeting ISO L EGD ISO CD 13738 and JASO M345 FC FD Standards must be used ECHO brand premium Power Blend X Universal 2 Stroke Oil meets these standards Engine problems due to inadequate lubrication caused by failure to use an ISO L EGD ISO CD 13738 and JASO M345 FC FD certified oil such as ECHO premium Power Blend X will void the two stroke engine warranty IMPORTANT e ECHO premium Power Blend X Universal 2 Stroke Oil may be mixed at 50 1 ratio for application in all ECHO engines sold in the past regardless of ratio specified in those manuals e Use of unmixed improperly mixed or fuel older than 90 days stale fuel may cause hard starting poor performance or severe engine damage and void the product warranty Read and follow instructions in the Storage section of this manual 44 DANGER Fuel is VERY flammable Use extreme care when mixing storing or handling or serious personal injury may result e Use an approved fuel container e DO NOT smoke near fuel e DO NOT allow flames or sparks near fuel e Fuel tanks cans may be under pressure Always loosen fuel caps slowly allowing pressure to equalize e NEVER refuel a unit when the engine is HOT e NEVER refuel a unit with the engine running e DO NOT fill fuel tanks indoors ALWAYS fill fuel tanks outdoors over bare ground e Securely tighten fuel cap after refuel
Download Pdf Manuals
Related Search