Cres Cor FL-2291 User's Manual
Contents
1. TW HOLIMS al 94 JVOH lt 9 ay dW3LHOIH A o b 9 6 A 5 oo o 5 9 c 5 lt lt 6 5 gt 0 Call Toll free 877 CRES COR 273 7267 Fax 800 822 0393 www crescor com2. plastic or stainless steel pads for cleaning and scouring Delime or descale water pan parts as 4 Rinse thoroughly with fresh water after every reguired to prevent damaging build up cleaning operation 5 Always wipe dry to avoid water marks AWARNING BEFORE CLEANING CABINET 1 Unplug cord from wall Allow cabinet to cool 2 Do NOT hose cabinet with water 3 Do NOT get water on controls 4 Do NOT use abrasives or harsh chemicals WARRANTY COVERAGE MAY BE AFFECTED WITHOUT PROPER CLEANING SOIL CLEANER METHOD Soap ammonia or mild 1 Sponge on with cloth CABINET Routine Cleaning detergent and water 2 Rinse Stubborn Spots Mild abrasive made for 1 Apply with damp sponge or cloth Inside and Stains Stainless Steel 2 Rub lightly Outside Burnt on Foods or Chemical oven cleaner Follow oven cleaner manufacturer s Grease made for Stainless Steel directions Hard Water Spots 1 Swab or wipe with cloth Stainless Steel amp Scale vinegar 2 Rinse and dry Mild detergents include soaps and non abrasive cleaners Call Toll free 877 CRES COR 273 7267 Fax 800 822 0393 www crescor com Undercounter a CRES Ey O 9 5925 Heisley Road Mentor 44060 1833 MAINTENANCE INSTRUCTIONS TROUBLE SHOOTING GUIDE AWARNING IF UNIT GETS TOO HOT OR WON T SHUT OFF DISCONNECT POWER AT BRANCH PANEL DO NOT UNPLUG CORD If hot unit
3. 12 2 3 Press START STOP button Adjust time by using UP and DOWN arrow until this has been done Push switch to ON Set the COOK RETHERM thermostat to 350 177 Set the Hold thermostat to 150 F 66 C Set the timer to one 1 hour Allow oven to run automatically for one 1 hour of COOK RETHERM cycle and 30 minutes of Hold cycle buttons A WA R N Air is VERY HOT when door is opened Press START STOP button to restart oven Note Cold food is NOT to be added when unit is operating in HOLD mode Call Toll free 877 CRES COR 273 7267 Fax 800 822 0393 www crescor com Undercounter CRES COR 5925 Heisley Road Mentor OH 44060 1833 SD age gt o MAINTENANCE INSTRUCTIONS HOW TO CLEAN THE UNIT MAINTENANCE WATER PAN MAINTENANCE CABINET Drain wipe and fill water pan daily Clear vinyl 1 Wipe the inside of cabinet after daily use drain hose is provided 2 Leave doors slightly open to fully dry interior 1 Push hose onto drain nozzle under the base 2 Turn knob to open the drain HOW TO CLEAN THE UNIT Pr ee i Cleaning Hints An cone 1 Use the mildest cleaning procedure that will do 2 Turn humidity Thermostat to High until water the job 3 oe 2 Always rub in direction of polish lines to avoid scratching the surface 3 Use only a soft cloth sponge fibrous brushes A U T 0
4. is NOT working first check the following causes 1 Cord is unplugged from wall outlet 3 Switch is turned off 2 Circuit breaker fuse to wall outlet is blown 4 Thermostat is turned off or is set too low PROBLEM POSSIBLE CAUSE SOLUTION Humidity is low 1 Water in pan may be low 1 Add water y 2 Thermostat set too low 2 Turn up thermostat 1 Thermostat 1 Replace Cabinet does not heat A heater reay h or doesn t heat properly 3 Loose wiring at eater relay 3 Replace 4 High limit switch 4 Replace 5 On Off Switch 5 Replace Blowers do notoperate 1 On Off Switch 1 Replace 2 Blower 2 Replace 1 Thermostat 1 Replace Heater will not shut off 2 Relay 2 Replace 1 Replace Vent fans do not shut off vent TaN 2 Wait until it cools Check 2 Control compartment is still hot 2 Heaters will not shut off NOTE Vent fans will not operate until the control compartment reguires ventilation to limit temperatures Replacement of electrical components must be done by a gualified electrician Refer to our Service Agency list FL 1400 found in the back of this manual of authorized service centers Instructions for replacing parts are included in replacement parts list Call Toll free 877 CRES COR 273 7267 Fax 800 822 0393 www crescor com Page 7 of 10 Undercounter Rev 3 5 08 CRES COR 5925 Heisley Road Mentor OH 44060 1833 MAINTENANCE I
5. 393 www crescor com Sy EEE Undercounter Rev 3 5 08 Page 3 of 10 CRES COR 5925 Heisley Road Mentor OH 44060 1833 INSTALLATION INSTRUCTIONS 3 Most jurisdictions consider our low temperature ovens maximum temperature is 350 F 177 C as low heat appliances not requiring vent hoods VENTING YOUR OVEN 1 The purpose of ventilating hoods is to direct and capture smoke grease laden vapors heat odors 4 Installation must conform with local codes The authority having jurisdiction of enforcement of or fumes 2 Low temperature equipment maximum temperature 250 F 121 C does not produce heat odors fumes grease laden vapors or smoke and the codes will have the responsibility for making interpretations of the rules is not required to be vented MODEL NO ELECTRICAL SPECIFICATIONS All models are designed for AC Service Model numbers may have the letters L M or S LOW WATER LIGHT When water needs to be added to the pan the Low HOW TO INSTALL CABINETS 1 Remove all packing material from inside and Water Light will stay on until the pan is refilled outside of cabinet 2 Position cabinet on level floor install the cabinet interior pan slides if not already installed 3 Plug power cord into proper wall receptacle 4 Fill water pan with three 3 gallons of HOT water see CAUTION CAUTION Use of treated water is recommended for proper operation and to maintai
6. NSTRUCTIONS TROUBLE SHOOTING GUIDE continued DISCONNECT PLUG HERE HOW TO ADJUST DOOR LATCH 1 For vertical adjustment up and down movement a Loosen 2 screws located in magnetic strike b Move strike up or down for alignment to magnet on latch c Tighten screws to secure 2 For horizontal adjustment greater or lesser magnetic draw a Loosen 4 screws in door latch b Move latch forward or backward to adjust magnetism c Tighten screws to secure FIGURE 2 HOT UNIT REMOVAL 1 Disconnect power cord from wall outlet 2 Remove screws around top cover 3 Disconnect the yellow cord between top and bottom in the back of the cabinet see Figure 2 4 Lift off Hot Unit Fax 800 822 0393 www crescor com Call Toll free 877 CRES COR 273 7267 Undercounter mem CRES COR ey 5925 Heisley Road Mentor OH 44060 1833 Rev 3 5 08 Page 8 of 10 REPLACEMENT PARTS Include all information on nameplate when ordering parts OQ o 3 Roast N Hold 0 4 N N 7 190 310 3 150 350F 9 2 RETHERM HUMIDITY O 8 Figure 3 Control Panel Hot Unit Replacement Parts ITEM DESCRIPTION Part No ITEM DESCRIPTION Part
7. No 1 Switch On Off 0808 113 K 17 Hi Limit Switch 0848 079 2 Timer Digital 0849 088 K 18 Fan Switch 0848 034 3 Light Low Water 0766 094 19 Relay Water 0857 130 a n ISA 5238 031 20 Transformer 0769 159 5 6 7 Knob Thermostat 0595 061 21 Relay Cook N Hold 0857 100 5 6 Control Board 0848 069 22 Sensor Thermostat 0848 058 K1 7 Thermostat 0848 008 ACK 23 Sensor Bushing 0818 066 8 Light Yellow 0766 094 24 Receptacle 6 pin 0810 154 02 9 Light Green 0766 098 25 Power Cord 0810 039 06 12 Vent Fan 0769 165 26 Heater Kit 0811 022 K 13 Fan Guard 0769 167 27 Strain Relief 0818 057 14 Blower Kit aluminized 0769 180 K Float Switch 0857 122 Blower Kit Stainless 0769 180 01 Water Pan Kit 0756 033 internal parts Complete SSK except outer housing Heater Water Pan 0811 271 15 Terminal Block Front 0852 096 Drip Pan 1017 098 16 Terminal Block Rear 0852 093 Cabinet Replacement Parts DESCRIPTION PART NO Hot Unit 120V 1 Ph HU675049 Door Latch Kit 1006 120 01 K Latch Strike 1006 120 02 K Door Hinge 0519 074 K Door Assembly 1221 545 K Door Gasket 0861 250 K Universal Angles 0621 281 SSK Casters 0569 310 Casters w brake 0569 310B Call Toll free 877 CRES COR 273 7267 Fax 800 822 0393 www crescor com Undercounter Rev 3 5 08 Page 9 of 10 CRES COR 5925 Heisley Road Mentor OH 44060 1833 REPLACEMENT PARTS Include all infor
8. Undercounter CRES COR 5925 Heisley Road Mentor OH 44060 1833 INSTALLATION OPERATION and MAINTENANCE MANUAL for Cres Cor AQUATEMP HUMIDITY UNDERCOUNTER OVENS 2000 WATTS C0151XWUA5B Call Toll free 877 CRES COR 273 7267 Fax 800 822 0393 www crescor com Undercounter CRES COR o Page 20110 5925 Heisley Road Mentor OH 44060 1833 Rev 3 5 08 Page 2 of 10 TABLE OF CONTENTS SUBJECT PAGE INSTALLATION INSTRUCTIONS Y NO OPERATING INSTRUCTIONS AGA OA 4 Illustration Figure bac wb ddn r EREEREER OE 4 MAINTENANCE INSTRUCTIONS How to Clean the Unit Lee NF NF 5 Trouble 6 7 Replacement FF SN WW FFR NF YT 7 8 Illustrations Hot Ut ee y 9 Winne WE uu a TR Y NF YF 10 TIMER CW DO RA FL 2222 SERVICE POLICY and AGENCY LIS To i HD dy FL 1400 A RISK OF FIRE OR ELECTRIC SHOCK WARNING TO REDUCE THE RISK OF FIRE OR ELECTRIC SHOCK DO NOT REMOVE COVER OR BACK NO USER SERVICEABLE PARTS INSIDE REPAIR SHOULD BE DONE BY AUTHORIZED SERVICE PERSONNEL ONLY Call Toll free 877 CRES COR 273 7267 Fax 800 822 0
9. mation on nameplate when ordering parts 19 17 15 Call Toll free 877 CRES 273 7267 Fax 800 822 0393 www crescor com weer 9 WHIHLTH IOOD SdV31 Gadus 6 Sava 40102 anos a lis YW 15 0 9 167 6 Ly 6 O thor 90 9 liwn 8 ts M 1 sl 7 5 1 29 06 SO tO 10 9 S r Nano _ HOSN3S ON WOD USN ty T 4 2 Y k aL a v ws 1 CRES 5925 Heisley Road Mentor OH 44060 1833 a 5 WIRING DIAGRAM 1 0 6 HOSN3S ro HOLIMS Z L 40 oi 16 Ys H3MOd M3IV3H id uc 6L 02 T AVIau ATH o 149 1180 Nd MSC6 NOCL
10. n warranty It will reduce scaling Call Toll free 877 CRES COR 273 7267 Fax 800 822 0393 www crescor com Rev 3 5 08 Page 4 of 10 FL 2291 7 a CRES COR o Page4ofio 5925 He 5925 Heisley Road Mentor OH 44060 1833 OPERATING INSTRUCTIONS 2353 7 O COOK RETHERM HUMIDITY HOW TO SET TIMER A Press increa down the DOWN arrow button using the same method will cause the time to decrease 1 B Press START STOP button on Timer to begin 2 9 Figure 1 Control Panel PARTS DESCRIPTION Switch On Off Timer Digital Low Water Light Thermometer Thermostat Hold Thermostat Cook Retherm Thermostat Humidity Yellow Light Hold Green Light Cook Retherm HOW TO START UNIT the UP arrow button on the Timer to for first time operation only se the time The longer the button is held A new oven needs to burn off factory oils and glue the faster the time will increase Pressing before it s first use Do NOT load food into oven cooking cycle GREEN roast light will light up The timing light on the Timer will flash Timer will 3 down to 0 00 4 Cooking time can be changed while oven is in 5 count mode
Download Pdf Manuals
Related Search