Cres Cor EB-150 User's Manual
Contents
1. Insulated CRES COR FL 2257 5925 Heisley Road Mentor OH 44060 1833 OPERATING and MAINTENANCE INSTRUCTIONS Models EB 150 Banquet Warming Cabinet ELECTRICAL SPECIFICATIONS Model No Volts Watts Hertz Phase NEMA EB 150 120 1500 12 5 60 1 5 15P EB 150 CAN 120 1500 12 5 60 1 5 20P EB 150 208 208 1500 7 3 60 1 6 15P EB 150 240 240 1500 6 3 60 1 6 15P Models are designed for AC Service For Canadian use TO TURN OFF UNIT Push the POWER switch to OFF The yellow light will go out HOW TO INSTALL UNIT 1 Remove all packing material from inside the cabinet and clean cabinet thoroughly 2 Install all channels and shelves before the unit is put into operation 3 Plug the power cord into the proper wall outlet HOW TO START UNIT 1 Turn the POWER switch ON The yellow light will turn on 2 Turn the thermostat to no 10 3 Preheat assuming a cold cabinet of 75 F 25 C To 150 F 65 C takes about 30 mins To 175 F 79 C takes about 45 mins To 190 F 88 C takes about 1 hour Thermostat Switch w Light Thermometer 4 Put food into the cabinet 5 Turn the thermostat to the required temperature NOTE No 8 is about 180 F 82 C No 6 is about 155 F 69 C Proper food holding temperature is 140 F 60 C or higher Call Toll free 877 CRES COR 273 7267 Fax 800 822 0393 www crescor com Insulated FL 2257 CRES COR Page 2014 5922. 5 Heisley Road Mentor OH 44060 1833 Rev 4 4 07 Page 2 of 4 OPERATING and MAINTENANCE INSTRUCTIONS Models EB 150 Banquet Warming Cabinet 4 WARNING E Cleaning hints Hot Unit Removal Instructions 1 Wipe up spills as soon as possible 1 Unplug power cord from wall outlet 2 Clean cabinet regularly to avoid heavy dirt build up 2 Lift unit off from the front and rear of cabinet 3 Make a test spot with cleaner 4 Follow manufacturer s directions on cleaner 5 Do not mix cleaners 6 Avoid drips and splashes HOW TO CLEAN THE UNIT BEFORE Cleaning the Cabinet 1 Allow cabinet to cool 2 Remove hot unit from cabinet 3 Do NOT use abrasives or harsh chemicals 4 High pressure cleaning is recommended for cabinet exterior HOW TO CLEAN UNIT SOIL CLEANER METHOD Routine cleaning Soap ammonia or 1 Sponge on with cloth detergent and water 2 Rinse CABINET 1 Apply with damp sponge or cloth Stubborn spots Mild abrasive made for 1 i Stainless Steel and stains stainless steel 2 Rub lightly Burnt on foods or Chemical oven cleaner Follow oven cleaner grease manufacturer s directions Mild detergent include soaps and non abrasive cleaners Call Toll free 877 CRES COR 273 7267 Fax 800 822 0393 www crescor com Insulated CRES COR nr anf 5925 Heisley Road Mentor OH 44060 1833 OPERATING and MAINTENANCE INSTRUCTIONS Models EB 150 Banquet
3. 5925 Heisley Road Mentor OH 44060 1833 Rev 4 4 07 Page 4 of 4 OPERATING and MAINTENANCE INSTRUCTIONS Models EB 150 Banquet Warming Cabinet YSL AOvZ VSL A802 9NTd d94 9 aT Sa lt V l U a4 I Sc m Q D gt _ 5 A z OO A wo l g O NU gt ae MD Cov Gaz Jo mom ora D N JO o T No o wo gt 4D L_c m o wo w S O m I Call Toll free 877 CRES COR 273 7267 Fax 800 822 0393 www crescor com
4. Warming Cabinet TROUBLE SHOOTING CHART FAILURE POSSIBLE CAUSE 1 Yellow light at switch does NOT light la Circuit breaker fuse to wall outlet is blown 1b Cord is unplugged from wall outlet lc Switch is OFF 2 Unit does not heat 2a Thermostat set too low or is OFF 2b Switchis OFF 3 Unit gets too hot or won t shut off 3a Defective electrical parts UNPLUG UNIT FROM WALL OUTLET 4 Blower does not work or makes noise 4a Defective blower 5 Excess moisture in cabinet 5a Open vent 5b Slack out foods from oven or fryer for 5 minutes before putting in hot cabinet If cause is none of the above refer to our list of Authorized Service Centers FL 1400 REPLACEMENT PARTS DESCRIPTION 120 VOLT 208 VOLT 240 VOLT Power Unit 1254 047 1254 048 1254 049 Blower Kit 0769 005 K 0769 006 K1 0769 006 K1 Heater Kit 0811 244 0811 245 0811 246 Thermostat Kit 0848 062 K 0848 062 K 0848 062 K Thermometer Kit 5238 030 K 5238 030 K 5238 030 K Power Cord 0810 029 02 0810 039 03 0810 039 03 Power Switch 0808 113 K 0808 113 01 K 0808 113 01 K CABINET PARTS Door Latch 1006 143 K Door Strike 1006 151 K Door Hinge 0519 084 Door Gasket Kit 0861 243 Door Assembly Complete 1221 529 Wire Grid 1170 205 Push Handle 1072 117 K EB 150 CAN 120V for Canada Power Unit 1254 050 Power Cord 08 10 029 03 Call Toll free 877 CRES COR 273 7267 Fax 800 822 0393 www crescor com Insulated FL 2257 CRES COR O
Download Pdf Manuals
Related Search