Chauvet CRT Television Hurricane 1300 User's Manual
Contents
1. 1300 User Manual 2 3 26 2009 3 18 PM 1 BEFORE YOU BEGIN What is included 1 x Hurricane 1300 1 x FC T wired timer remote 1 x Warranty Card 1 x User Manual Unpacking Instructions VVVV Immediately upon receiving a fixture carefully unpack the carton check the contents to ensure that all parts are present and have been received in good condition Notify the shipper immediately and retain packing material for inspection if any parts appear damaged from shipping or the carton itself shows signs of mishandling Save the carton and all packing materials In the event that a fixture must be returned to the factory it is important that the fixture be returned in the original factory box and packing AC Power To determine the power requirements for a particular fixture see the label affixed to the back plate of the fixture or refer to the fixture s specifications chart A fixture s listed current rating is its average current draw under normal conditions All fixtures must be powered directly off a switched circuit and cannot be run off a rheostat variable resistor or dimmer circuit even if the rheostat or dimmer channel is used solely for a 0 to 100 switch Before applying power to a fixture check that the source voltage matches the fixture s requirement Check the fixture or device carefully to make sure that if a voltage selection switch exists that it is set to the correct line voltage you will use Hurricane 1300 U2. pin3 5V pin4 ground pin5 none ground none ORDERING INFORMATION TMT AA O kaaa F1300 Wired manual remote 0phonal cgis FC M Wired Timer remote included erien r E E Er EEE EEr FC T Wireless manual remote optional sacra ario METADATA IA ARDER TNA SAAN FC W SPARE PARTS ORDERING INFORMATION Master POB E A A Ueda P170 F3MSPCB O A 1P20 HT13 NN P200 F3PUMP FIA COM AM P170 F3FLC PUGS RE P170 F1FLOS AUG BAN AAO P170 THEF1 1 BOC KEL MMOD AA P111 F3BKNOB Ano feiss AA AEEA P170 FUSEHOL Manualit DUMON aa dla P111 F3FOGB WARRANTY INFORMATION GG AA 1 year limited warranty Hurricane M 1300 User Manual 14 3 26 2009 3 18 PM
3. to damage or malfunction Please contact the nearest authorized technical assistance center Always use the same type spare parts o Never connect the device to a dimmer pack Make sure the power cord is never crimped or damaged e Never disconnect the power cord by pulling or tugging on the cord e Avoid direct eye exposure to the light source while it is on Caution There are no user serviceable parts inside the unit Do not open the housing or attempt any repairs yourself In the unlikely event your unit may require service please contact CHAUVET at 954 929 1115 Hurricane 1300 User Manual 4 3 26 2009 3 18 PM 2 INTRODUCTION Features Output 20 000cfm 3 3L tank capacity Uses 1L every 8min continuous use at full output 5 minute heat up Manual fog button Low fluid indicator and auto shut down Wired timer remote included Water based fogger Product Dimensions 314 MA 43 3 HUH n s Hurricane M 1300 User Manual 5 3 26 2009 3 18 PM Product Overview Hanging bracket Safety eyebolt Fluid container Handle Tilt Adjustment asa knob OZZIe Low Fluid indicator Manual Fluid level controller ula leve Ba AN indicator ER Ay ON OH k Mani comeoul LO Fuse holder Bea 3 e J pe _ Ca Power input hardwired r ai A Manual Fog Wireless button Controller Hurricane 1300 User Manual 6 3 26 2009 3 18 PM Disc
4. Contact Chauvet or a Chauvet Dealer distributor for further instruction Remote does not Make sure connector is firmly connected to device work Try using another controller Possible bad controller Check the internal fuse Check the external fuse Fluid indicator states Try resetting the fog machine by turning the power off and then on again no fog but the Possible bad part Contact Chauvet or a Chauvet Dealer distributor for further container if full instruction If you still have a problem after trying the above solutions please contact CHAUVET Technical Support at the location listed below Contact Us World Wide General Information CHAUVET 3000 North 29 Court Hollywood FL 33020 voice 954 929 1115 fax 954 929 5560 toll free 800 762 1084 Technical Support CHAUVET 3000 North 29 Court Hollywood FL 33020 voice 954 929 1115 Press 4 fax 954 929 5560 Attention Service World Wide Web www chauvetlighting com Hurricane 1300 User Manual 10 3 26 2009 3 18 PM 4 APPENDIX General Maintenance To maintain optimum performance and minimize wear fixtures should be cleaned frequently Usage and environment are contributing factors in determining frequency As a general rule fixtures should be cleaned at least twice a month Dust build up reduces light output performance and can cause overheating This can lead to reduced lamp life and increased mechanical wear Be sure to power off fixture before conducting main
5. Snapshot Y HURRICANE LA 1300 Outdoor OK Sound Activated S DMX512 Master Slave S 115V 230V Switch amp Q Replaceable Fuse S User Serviceable S Duty Cycle Fa pi 5 a oe en ee Pa ma n mo E v CHAUVEL 3000 N 29 Ct Hollywood FL 33020 U S A 800 762 1084 954 929 1115 FAX 954 929 5560 www chauvetlighting com TABLE OF CONTENTS 1 B fore YOU Begin AA aca 3 VA Joa acs do o AA 0 Eo E a gee re ee eee 3 Unpacking MSU C UON Sta A EA at hr er ee ee E 3 AO PONET ANAN ANA A A E ANAN NAAN AA ANG AD ANG 3 Sale AA AA AN KANA AA ANA 4 2 INTFOGCUCTION maa NANANA NANA GAAN AA AGANG 5 PAA aan ANA a a AA AA AA AA 5 Produc AA AA tae 5 Product ONE NEN AA yg AA AA AA AA aumapunaumaauiate 6 Fuse HEplacementiaaa naanakan alaala thana AD BALAAN GAAN AA 7 NG AA AA AA AA tea eas saan tees mel T emal AA ts e e E Onn ee ee 7 RUSS are E ii S 7 32 Operating INSTUCUONS A GG 8 OPA AA AA ar 8 Manual Remote Operation FC M Optional AA 8 Timer Remote Operation FCT SMA Ni da 8 Wireless CoOntrolen EC WILODIIA A ata 9 Hurricane 1300 General Troubleshooting 1101017711171 nn 10 Contact Ugat hada a Gina UA 10 Ah PAPC IK AA AA AA 11 General Maintenance sus ISSUE AAA 11 Returns POC AA 11 Gaan a A 11 BIOWS0U D ai aaa ana aa aai DAN aca NANA NA AA NA aa 12 Connections DRAWING aman ANAN ANING ANAN TANAN ANA NUN ANAN E NAA NAA NAGIN 13 Ci e AA 14 Hurricane
6. fittings not shown P170 F3COP Hurricane 1300 User Manual 12 3 26 2009 3 18 PM Connections Drawing In the event that any part s may need to be replaced repaired you may use the below diagram to assist in this operation Warning All repairs should only be performed by Authorized Service Personnel gm AN ri re LA Sw tch ni 7 Fuse tow NIN wf Ye gt ET yo TS Cn T 7 ff X q o i Q L 1 AY py Wreless Controller F pa F Manual ntrol l er Heat er og Hurricane M 1300 User Manual 13 3 26 2009 3 18 PM Technical Specifications WEIGHT 8 DIMENSIONS AGUA PA o A vena la oAbee a E a EEA 16 5 in 419 mm a A ae 12 3 in 313 mm AA o e E 12 1 in 306 mm A ETETA A AA TEAT E ETE neces Seer SUE pa AL aa Scenes BU cane St 21 lbs 9 5 kg POWER A A A 120V 60Hz AC or 230V 50Hz PP A 13A 250V POWer GON SUI A AA AAA 1 328W 11 2A max at 120V USONG Paa RMA RP cr nt E ne Pee Seas ee ee 11 2A at 120V ls A en AA en AGA A 0 99 at 120V A a ROE SU SUT E NOT SOO AP NA 7A 250V POWER CONSUMO rissa E ERA IEAI 1 325W 5 8A max at 230V rush FOWE PR O T NAAN NAA AR NAAN 1 83A at 230V Power FAClOM ne S 0 99 at 230V THERMAL Maximum ambient temperature oocccncccncccccccccccnonnncnnnnnnnnnonnnonnnnnnnnnnnnnnnnnnonnnnnnnnnnnnnnnnnnnnnnnnnnnos 104 40 C CONTROL 8 PROGRAMMING DIO AAA 5 pin amp ground DIN5 female socket Data pin configuration pin1 LED pin2 control
7. n them simultaneously See the below instructions on setting up your fogger to operate with the FC W 1 Plug the wires receiver into the fog machine 5 pin port labeled Wireless Controller 2 There are 4 buttons on the wireless remote transmitter which act as triggers Each button can be assigned to a different fog machine You may only choose 1 dipswitch on each receiver See the below configuration for setting the receivers to operate with the transmitter remote Mode Dipswitches CH1 1 On 2 4 Off CH2 2 On 1 3 4 Off CH3 3 On 1 2 4 Off CH4 4 On 1 2 3 Off 3 Press the fog button and the fog machine will output fog momentarily for as long as you hold down the button LED indicator LED indicator KN heating Dipswitches Wireless Transmitter Fog Wireless Triggers Receiver Hurricane 1300 User Manual 9 3 26 2009 3 18 PM Hurricane Y 1300 General Troubleshooting Symptom Solution s No Power Check mains power Check external fuse Check internal fuse No fog output Check fluid level Check remote If using wireless check batteries If using wireless check dipswitches on receiver Breaker Fuse keeps Possible electrical short Contact Chauvet or a Chauvet Dealer distributor for blowing further instruction Check that the fog machine is plugged into the correct voltage Fog machine is not Check to replace the external fuse heating up Check to replace the internal fuse Possible bad part
8. om inadequate packaging is the customer s responsibility CHAUVET reserves the right to use its own discretion to repair or replace product s As a suggestion proper UPS packing or double boxing is always a safe method to use Note If you are given a RMA please include the following information on a piece of paper inside the box kh Your name NO Your address gt O Your phone number The RMA al A brief description of the symptoms Damage incurred in shipping is the responsibility of the shipper therefore the damage must be reported to the carrier upon receipt of merchandise It is the customer s responsibility to notify and submit claims with the shipper in the event that a fixture is damaged due to shipping Any other claim for items such as missing component part damage not related to shipping and concealed damage must be made within seven 7 days of receiving merchandise Hurricane 1300 User Manual 11 3 26 2009 3 18 PM Blow out Diagram 7 6 2 3 1 4 8 9 Description Part Number 1 Master PCB P170 F3MSPCB 2 P120 HT13 3 P200 F3PUMP 4 P170 F3FLC 5 Fluid sensor not shown P170 F1FLOS 6 Thermal switch 115 Celsius 7 Bracket Knob P111 F3BKNOB 8 Fuse holder P170 FUSEHOL 9 Manual fog button P111 F3FOGB 10 Fuse 13A 250V not shown P170 FUSE013 11 Fluid filter not shown P110 F1FLAS 12 Fluid hose with fittings not shown P170 F3RUB 13 Copper tubing with
9. onnect the power cord before replacing a fuse and always replace with the same type fuse Fuse Replacement With a flat head screwdriver wedge the fuse holder out of its housing Remove the damaged fuse from its holder and replace with exact same type fuse Insert the fuse holder back in its place and reconnect power The fuse is located inside this compartment Remove using a flat head screwdriver Mounting ORIENTATION This fixture should only be mounted used on a flat surface This fixture may not be tilted RIGGING It is important never to obstruct the vents pathways Mount the fixture using a suitable C or O type clamp e When selecting installation location take into consideration the fluid reservoir access and routine maintenance e Safety cables must always be used utilizing the provided safety eye bolt e Never mount in places where the fixture will be exposed to rain high humidity extreme temperature changes or restricted ventilation Hanging Clamp Angled Down Angled Up Note Clamp is sold separately Hurricane 1300 User Manual 7 3 26 2009 3 18 PM 3 OPERATING INSTRUCTIONS Operation Manual Remote Operation FC M Optional 1 Plugin the fog machine to power and turn the power switch to the fixture on 2 Plug in the wired manual remote to the Manual Controller socket on the rear of the fog machine 3 Press the single button located on the remote to trigge
10. r the fog output Note The button is momentary which means that the fog machine will only output while the button is pressed Once the button is released the fog will stop outputting Timer Remote Operation FC T Standard This mode will allow you to control the fogger manually set the fog machine to run continuously or to set the fog machine to run off bursts with adjustable interval and duration settings 1 Plugin the fog machine to power and turn the power switch to the fixture on 2 Plug inthe timer remote to the Manual Controller socket on the rear of the fog machine 3 Press the TIMER ON OFF button on the timer remote The LED above the button should light indicating activation of function 4 You may now set the INTERVAL amp DURATION adjustment knobs to the desired position Note The INTERVAL is the time in between bursts of fog Note The DURATION is the time that the fog machine will run during the burst Duration Adjustment Interval Adjustment 7 Timer LED Manual Indicator Momentary LED Manual Power LED Indicator Manual control momentary button Timer latching button Continuous latching button 8 Hurricane 1300 User Manual 3 26 2009 3 18 PM Wireless Controller FC W Optional This mode will allow you to control the fogger using the optional wireless controller This consists of the transmitter and the receiver You may control up to 4 independent fog machines or many more if you ru
11. ser Manual 3 3 26 2009 3 18 PM Safety Instructions Please read these instructions carefully which includes important information about the installation usage and maintenance of this product o Please keep this User Guide for future consultation If you sell the unit to another user be sure that they also receive this instruction booklet e Always make sure that you are connecting to the proper voltage and that the line voltage you are connecting to is not higher than that stated on the decal or rear panel of the fixture This product is intended for indoor use only If applicable e Toprevent risk of fire or shock do not expose fixture to rain or moisture Make sure there are no flammable materials close to the unit while operating e The unit must be installed in a location with adequate ventilation at least 20in 50cm from adjacent surfaces Be sure that no ventilation slots are blocked e Always disconnect from power source before servicing or replacing lamp or fuse and be sure to replace with same lamp source o Secure fixture to fastening device using a safety chain Never carry the fixture solely by its head Use its carrying handles e Maximum ambient temperature Ta is 104 F 40 C Do not operate fixture at temperatures higher than this o In the event of a serious operating problem stop using the unit immediately Never try to repair the unit by yourself Repairs carried out by unskilled people can lead
12. tenance Unplug fixture from power Use a vacuum or air compressor and a soft brush to remove dust collected on external vents and internal components Clean all glass when the fixture is cold with a mild solution of glass cleaner or Isopropyl Alcohol and a soft lint free cotton cloth or lens tissue Apply solution to the cloth or tissue and drag dirt and grime to the outside of the lens Gently polish optical surfaces until they are free of haze and lint The cleaning of internal and external optical lenses and or mirrors must be carried out periodically to optimize light output Cleaning frequency depends on the environment in which the fixture operates damp smoky or particularly dirty surrounding can cause greater accumulation of dirt on the unit s optics Clean with soft cloth using normal glass cleaning fluid Always dry the parts carefully Clean the external optics at least every 20 days Clean the internal optics at least every 30 60 days Returns Procedure Claims Returned merchandise must be sent prepaid and in the original packing call tags will not be issued Package must be clearly labeled with a Return Merchandise Authorization Number RMA Products returned without a RMA will be refused Call CHAUVET and request a RMA prior to shipping the fixture Be prepared to provide the model number serial number and a brief description of the cause for the return Be sure to properly pack fixture any shipping damage resulting fr
Download Pdf Manuals
Related Search