Cal Spas Spa Surrounds User's Manual
Contents
1. OF THE ARC PLACE BAR LEGS CORBALS AS SHOWN PLACE SCREWS AT THESE POINTS 2009 Spa Surrounds Cal Desiqui LTR20091033 Rev A www calspas com Package P and G NOTE The manufacturer recommends mounting corbels on the cabinet so that the bar top sits just under the spa lip 1 Using 2 1 2 screws mount the corbels directly to the cabinet wall Make sure that the corbels are horizontally level with each other Assembly 8 2 Mount the bar top to the corbels with the 2 1 2 screws The screws must be mounted from the underside of the bar top Make sure that the bar top rests just below the lip of the spa MAKE SURE TO ALICN CORNER amp STRAICHT BEFORE ATTACHINC TOCETHER WITH SCREWS MAKE SURE TO ALIGN CORNER amp STRAICHT BEFORE ATTACHING TOGETHER WITH SCREWS ON CERTAIN SPA MODELS BAR TOPS WILL BE IN TWO PIECES Cal Designs 2009 Spa Surrounds www calspas com I LTR20091033 Rev A Aigwsssy AFTER PLACING CORBALS ON TO SPA CABINET START PLACING CAL SELECT TOP ON TOP OF LEGS NOTE CORBALS SHOULD BE ATTACHED SUCH THAT THERE IS SPACE 1 1 2 FROM THE SPA LIP TO THE TOP OF THE CORBAL 2009 Spa Surrounds Cal Designs LTR20091033 Rev A www calspas com gt Package R 2 n lt m SS PLACE BENCH PIECES TOGETHER AND TOE IN TO ATTACH BOTTOM VIEW OF BENCH WITH PLACEMENT OF BENCH LEGS Cal Desigus www calspas com SURROUND SERIES BENCH2. SCREWS FACTORY DRILLED HOLES FRONT VIEW ASSEMBLY ASSEMBLY STEP 2 GUSSET INSTALLATION STEP 2 GUSSET INSTALLATION 2009 Spa Surrounds Cal Designs LTR20091033 Rev A www calspas com 2009 Spa Surrounds LTR20091033 Rev A m Package R Step Assembly USE TOE IN METHOD AS SHOWN ON BOTH SIDES Cal Desigus www calspas coi Alqwassy Package D E and I Step Assembly A quiassy ZZ ez ez e e MIDDLE PIECE WILL BE STAMPED WITH A M MIDDLE LEC STEP I STEP SUPPORT 5 8 SPACE THIS METHOD APPLIES TO CURVED STEPS AND STRAICHT SIDE VIEW UPSIDE DOWN 2009 Spa Surrounds Cal Desiqui LTR20091033 Rev A www calspas com Assembly Cal Select Step Assembly LEG ASSEMBLY CORNER STEPS Cal Designs www calspas com D CAP ON OPEN ENDS OF STEPS 2009 Spa Surrounds LTR20091033 Rev A gt Assembly Planter Assembly STEP 1 ASSEMBLY ASSEMBLY Lu gt DROP IN PLANTER BOTTOM Cal Desiqui www calspas co 2009 Spa Surrounds LTR20091033 Rev A m Bar Stool Assembly 1 Attach the bar stool legs to support the brace using the provided 2 screws There will be a total of 12 screws Place the bar stool seat on a flat surface Make sure the finish side is on the ground
3. WITH SCREWS AS SHOWN 2271 1 SS AFTER ATTACHING LATTICE PANELS TOCETHER PLACE CLASS TOWEL HOLDER ACAINST ASSEMBLED LATTICE PANELS AND USE SCREWS TO ATTACH lt Ry gt 2 6 lt RE 2 2 RD Qu 2 lt TXT 22572 y ELLERI RE D R RR NN RRI RN gt AFTER ASSEMLBING THE THREE PIECES TOGETHER FIT AROUND SPA AND TOE INTO PLACE WITH SCREWS 2009 Spa Surrounds www calspas com LTR20091033 Rev A Your surround package was designed with low cleaning and maintenance in mind We recommend that the surround package be cleaned at least twice a month or more if needed When cleaning your surround package do not use cleaning solvents using a sponge and water will be fine For ground in dirt and grime refer to the following section Maintaining your surround package is an easy task We recommend that every six months you inspect your surround package If your surround package is redwood take note of any deformities in the wood i e cracking peeling dirt grime etc Wipe the stained area clean and reapply until the sanded area matches the rest of the surround package If your surround package is Cal Select wipe off any dirt or grime using a sponge and water Condition the Cal Select with Cal Spas Vinyl Cleaner and Conditioner Follow directions on label 2009 Spa Surrounds Cal Designs LT
4. 2009 OWNER S MANUAL Cal Spas Home R www calspas com LTR20091033 Rev A 12 16 08 Assembly 1 Tools and Materials 1 Step 1 Planter Assembly 5 Bar Stool Assembly 6 Bar Assembly and Installation 7 Bench Assembly 13 Panel Assembly 15 Maintenance 17 Warranty Information 18 Copyright 2008 2009 LMS Inc All rights reserved Duplication without written consent is strictly prohibited Cal Spas and Cal Enclosures are registered trademarks Due to continuous improvement programs all models operation and or specifications are subject to change without prior notice LTR20091033 Rev A 12 16 08 Read This First Carefully read and follow all safety instructions When installing and assembling your surround package it is recommended that two or more people be involved Do not use the unit during an electrical storm Do not climb on top of the surround package While the surround package is made out of high quality material and is extremely durable it is not meant to support weight In addition falling off of the surround package while climbing on it can result in serious injury or death Do not attempt any repair without consulting the manufacturer first Unauthorized repairs will void the ma
5. Attach the leg Assembly 2 assembly using four 2 screws SIEP 1 LEG ASSEMBLY 1 SCREW ON EACH SIDE ALL FOUR 2 INSTALLTION COMPLETED STOOL Cat Designs 2009 Spa Surrounds LTR20091033 Rev A www calspas com Bar Assembly and Installation gt 5 lt CHROME STRIP BOTTOM VIEW SPA SHELL PLACE BAR TOP JUST UNDER CHROME STRIP PLACE BAR TOP JUST UNDER TOP RAIL AFTER LINING UP BAR PLACE THREE SCREWS INTO PRE DRILLED HOLES TO HOLD BAR INTO PLACE AFTER LINING UP BAR PLACE THREE SCREWS INTO PRE DRILLED HOLES TO HOLD BAR INTO PLACE 2009 Spa Surrounds Cal Designs LTR20091033 Rev A www calspas com 2 2 lt Package C J and N CHROME STRIP TOP OF BAR PLACE BAR TOP JUST UNDER CHR0ME STRIP SIDE VIEW OF SPA WITHOUT TOP RAIL AFTER LINING UP BAR PLACE THREE SCREWS INTO PRE DRILLED HOLES TO HOLD BAR INTO PLACE SPA SHELL PLACE BAR TOP JUST UNDER TOP RAIL CHROME STRIP AFTER LININC UP BAR TOP RAIL PLACE THREE SCREWS INTO PRE DRILLED HOLES TO HOLD BAR INTO PLACE VIEW W Cal Descqus 2009 Spa Surrounds www calspas com I LTR20091033 Rev A Argwusssy MAKE SURE ALICN CORNER amp STRAICHT BEFORE ATTACHING TOGETHER WITH SCREWS PLACE BAR CENTERD OVER CONNECTION POINT OF CORNER AND STRAICHT PIECE EVENLY SPACE THESE TWO LECS PLACE THIS LEG IN THE CENTER
6. R20091033 Rev A www calspas com Warranty Information See your Cal Enclosures surround package dealer for a copy of the applicable warranty details and any questions you may have regarding the warranty coverage on your surround package Warranty Limitations The Limited Warranty is void if the surround package has been subject to negligence alteration misuse abuse repairs by non LMS authorized representatives acts of God and any other cases beyond the control of LMS Examples of common acts invalidating this warranty include but are not limited to e Use of the surround package in a non residential application e Scratches caused by normal use e Damage caused by extreme weather conditions heat cold etc e Damage caused by dirt sand and or water damage e Damage caused by direct sunlight Damage caused as a result of failure to follow the assembly instructions as defined in this Owner s Manual This Limited Warranty applies only to surround packages normally used for personal family or household purposes This Limited Warranty is obsolete 90 days after the original purchase date Warranty Exclusions LMS warranties the surround package from defects in material and workmanship for a period of 90 days from the original date of purchase DON T FORGET TO REGISTER YOUR NEW PRODUCT AT WWW CALSPAS COM Customer Service For customer service contact the authorized selling dealer immediately If
7. STOOL ASSEMBLY TOE IN BENCH LEGS INTO BENCH AS SHOWN BOTTOM VIEW OF BENCH WITH PLACEMENT OF BENCH LEGS 2009 Spa Surrounds LTR20091033 Rev A Bench Assembly Package P and G Ajquuess y 5 MAKE SURE TO ALIGN CORNER amp STRAICHT BEFORE ATTACHING TOGETHER WITH SCREWS MAKE SURE TO ALIGN CORNER amp STRAICHT BEFORE ATTACHING TOGETHER WITH SCREWS ON CERTAIN SPA MODELS BAR TOPS WILL BE IN TWO PIECES 2009 Spa Surrounds Cal Designs LTR20091033 Rev A www calspas com Package R Assembly TOE IN LEGS INTO BENCH AS SHOWN PLACE BENCH PIECES TOGETHER AND TOE IN TO ATTACH BOTTOM VIEW OF BENCH WITH PLACEMENT OF BENCH LEGS BOTTOM VIEW BENCH WITH PLACEMENT OF BENCH LEGS Cal Descqus 2009 Spa Surrounds www calspas com LTR20091033 Rev A Panel Assembly Package I TAKE 4 X 4 POST AND PLACE UP AGAINST THE LATTICE PANEL ATTACH WITH SCREWS AS SHOWN AFTER ASSEMLBING THE THREE PIECES TOGETHER FIT AROUND SPA AND TOE INTO PLACE WITH SCREWS AFTER ATTACHING LATTICE PANELS TOGETHER PLACE CENTER LATTICE AGAINST ASSEMBLED LATTICE PANELS AND USE SCREWS TO ATTACH BOTTOM VIEW BOTTOM VIEW ATTACH SIDES TO LECS FIRST THEN ATTACH TOP SEAT PIECE 2009 Spa Surrounds Cal Designs LTR20091033 Rev A www calspas com A quuessy Package J Assembly TAKE 4 X 4 AGAINST THE LATTICE PANEL ATTACH
8. nufacturer s warranty within the first 90 days CONTACT INFORMATION For customer service please contact your authorized dealer immediately If you need additional information and or assistance please contact LMS Customer Service Department 1462 East Ninth Street Pomona CA 91766 Toll Free 1 800 CAL SPAS Fax 1 909 629 3890 Tools and Materials Whether you assemble your surround package yourself or hire someone to do it your new surround package needs to be assembled in a specific order Our Cal Enclosures professionals have determined through their experience that this is the easiest way to assemble your surround package Ajquuess y Utility knife 25 tape measure Cordless drill 100 extension cord Electric drill Phillips head drill tips 1 8 pilot hole drill bit 9 16 socket Slotted head drill tips Sandpaper various grades Redwood stain Wood putty Gray wash stain Rags 1 2 ratchet and impact drill 1 2 carbide drill bit masonry bit Step Assembly Two Tier 30 Step 1 Stand the legs up at 30 apart Place the upper step on top of the upper section of the step 2 To attach the step screw 4 screws 2 at each rear corner 1 into the step leg and 1 into the step itself 3 Place the lower step on the lower section of the step 4 To attach the step screw in 4 screws 2 on each on the outside of the step Use the toe in method on both sides as shown THROUGH TYPICAL TWO
9. you need additional information and assistance please contact the LMS Customer Relations Department at 1462 East Ninth Street Pomona CA 91766 or call 909 623 8781 Cal Spa Dealer s Phone Number Cal Spa Dealer s Address
Download Pdf Manuals
Related Search