Cal Flame LTR20091039 User's Manual
Contents
1. Never put a cover on a hot oven Allow the oven to cool before covering OAU Flame 2009 Pizza Cart www calspas com LTR20091039 Rev A Troubl Problem Solution Problem Solution Problem Solution 2009 Pizza Cart j LTR20091039 Rev A _ www calspas com eshooting Smell of gas is present Check for loose connections in the gas line Perform a leak test following the procedure described in this man ual Burner does not ignite Use the following procedure with the figure below Check the position of the sparker tip It should be point ing forward towards the front of the burner e Make sure there is a blue spark at the electrode tip to the burner e Make sure the igniter wire is connected firmly to the valve ignition device and the electrode e Make sure the valve orifice is free of any debris dust or grease e Make sure the valve orifice is aligned inside the front hole of the burner e If there is no spark at all replace the electrode or igniter wire Note Turn off the gas at the source while troubleshoot ing Obstruction in the gas line Remove the fuel line from grill Do not smoke or per form any maintenance in the vicinity of an open flame Open the gas valve for one second to blow out any de bris Close off the gas valve and reconnect the fuel line securely ClF lane xipueddy Appendix Problem Solution Problem Solution Problem Solution2. remember to always leak test your pizza oven outdoors in a well ventilated area Never smoke or permit sources of ignition in the area while doing a leak test Do not use a flame such as a lighted match to test for leaks Use a solution of soapy water Prepare a leak testing solution of soapy water by mixing in a spray bottle one part liquid soap to one part water Make sure all the control knobs are in the OFF position Turn on the gas On natural gas systems turn the main feed valve to the pizza oven On LP systems turn the cylinder valve knob counter clockwise one turn to open Apply the leak testing solution by spraying it on joints of the gas delivery system Blowing bubbles in the soap solution indicates that a leak is present Stop a leak by tightening the loose joint or by replacing the faulty part with a replacement part recommended by the manu facturer Do not attempt to repair the cylinder valve if it is dam aged The cylinder must be replaced 6 Turn all control knobs back to the full OFF position If you are unable to stop a leak Turn all control knobs back to the full OFF position Shut off the gas supply to the pizza oven and release pressure in the hose and manifold by pushing in and turning any of the control valves one quarter turn counter clockwise On LP systems remove the cylinder from the pizza oven Call an authorized gas appliance service technician or an LP gas dealer Do not use the applianc
3. Plugged orifice Unplug the orifice as follows e Remove cooking grills flame tamer and grease tray e Remove burners from the bottom of the firebox by pulling the cotter pin from beneath the burner peg using a standard screwdriver or needle nose pliers e Carefully lift each burner up and away from the gas orifice e Remove the orifice from the control valve e Gently clear any obstruction with a fine wire e Reinstall the orifice reinstall the burners over the orifices and seat each burner peg into position hole at the bottom ledge of the firebox e Replace all cotter pins e Replace cooking components and grease collectors If an obstruction is suspected in the control valve con tact your local Cal Flame dealer for assistance Burner tube is misaligned over the orifice Reposition the burner tube so that it is properly seated over the orifice Yellow Flame Once the entire burner is operating check the flame color to be sure that it is mostly blue Some yellow at the tips may be present due to impurities in the fuel If the flame is golden or yellow in color the reason could be seasoning salts oil film or other foreign matter on the burner ATAO 2009 Pizza Cart www calspas com LTR20091039 Rev AN Problem Misalignment of Igniter on Burner Solution e Check for proper position of the electrode tip which should be pointing forward towards the front of the burner and free of grease to allow proper sparkin
4. in Canada must be in accordance with the standard CAN CGA B149 2 Propane Installation Code A licensed contractor or local gas company representative must per form all natural gas connections Ensure that the service supplying the pizza oven is fitted with a shut off valve conveniently positioned near the pizza oven and giving ease of access The pizza oven and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressure in excess of 0 5 psi 3 5 kPa Your pizza oven for use with natural gas comes equipped with its own regulator that MUST NOT be removed If this regulator needs to be re placed use only the type specified by Cal Flame for this appliance Connection 1 Remove the rear panel from the pizza oven to gain access to the regulator and gas connection point 2 Connect a suitable flex connector to the regulator 3 Check the controls to ensure all control valves are in the full OFF position 4 Turn on the main gas supply and check all connections for leaks using soapy water as described in the leak testing procedure sec tion Warning If you see bubbles in the soapy solution at any of the connec tions turn off the gas supply and tighten the connection If tightening the connection does not seal the leak it may be necessary to replace the flex hose ATO 2009 Pizza Cart www calspas com LTR20091039 Rev A Installing the Tr
5. of this or any other appliance when it is not being used e Do not attempt to move the stainless steel cart while it is hot or in use e It is extremely important to lock all caster wheels even on flat surfaces Operation e To prevent fire and smoke damage remove all packaging material before operating e Do not use the pizza oven for other than intended use 2009 Pizza Cart A LTR20091039 Rev A _ www calspas com suoijzonajsuy Kes Safety Instructions In the event that the burner goes out turn the burner knob to the full OFF position fully open the oven door and let it air out Do not attempt to use the pizza oven until the gas has had time to dissipate Never use the pizza oven if the drip pan is not properly installed Drip pan should be pushed in all the way Fire or explosion can result from an improperly installed drip pan Never use the pizza oven in windy conditions If used in a consis tently windy area a windbreak will be required Always adhere to the specified clearances listed in this manual Never line the pizza oven with aluminum foil Do not install or operate your pizza oven in such a manner that the cross ventilation openings are blocked Fresh air must be able to pass though installed vents to safeguard against residual gas accumulation Failure to allow proper ventilation may cause fire or explosion When handling LP gas line and connectors do not allow them to come in contact
6. use If you need a replacement hose contact your Cal Flame dealer Ensure the area around the pizza oven is clear of flammable substances such as gasoline yard debris wood etc Ensure there is no blockage of the airflow through the vent space located below the face of the unit When using propane gas keep the special ventilation openings in the enclosure free and clear of debris If connected to a propane cylinder carefully inspect the rubber hose attached to the regulator before each use Ensure the propane cylinder regulator and rubber hose are in stalled in a location not subject to heating above 125 F 51 C Ensure the in line gas valve or gas cylinder valve is always shut OFF when the pizza oven is not in use OhF lune 2009 Pizza Cart www calspas com LTR20091039 Rev A To ensure safe and proper maintenance we recommend you follow these directions carefully Clean internal parts regularly as determined by the amount of use and foods cooked The entire pizza oven should be cleaned at least once a year In addition keep the area around your pizza oven clear and free from combustible materials gasoline and other flammable vapors and liquids Do not obstruct the flow of combustion and ventilation air If your LP gas pizza oven is placed in a stationary barbecue island keep the access door for the propane cylinder clear of any obstruc tion Ensure the ventilation opening for cylinder enclosure is ke
7. with any metal surfaces of the cart or cabinet Do not drop LP connectors Do not use fuel such as charcoal briquettes or wood in the pizza oven Gas source to the pizza oven must be regulated Do not operate the pizza oven if the regulator has been removed Fire or explosion can occur When using the pizza oven do not touch the rack bricks or im mediate surroundings as these areas become extremely hot and can cause burns Use handles or knobs Only use dry pot holders and do not use a towel or other bulky cloth in place of pot holders Moist or damp pot holders used on hot surfaces can cause burns Do not reach over your pizza oven or any other surfaces when hot or in use It is dangerous to use this product in any manner other than for what it is designed for Do not use charcoal in a gas burning product Do not heat sealed containers such as cans or jars in or on the pizza oven Explosion may result resulting in injury or death PIZ HN 2009 Pizza Cart www calspas com LTR20091039 Rev A e Never put combustible material such as paper cloth or flammable liquids inside or on your pizza oven at any time Do not use the pizza oven to store flammable materials e Never allow temperature to exceed 500 F Maintenance and Repair e Unless specifically recommended in this manual do not repair or replace any part of the pizza oven A qualified technician should perform all service Any repairs made by a non LMS approved
8. www calspas com xipueddy Appendix 2009 WARRANTY LMS offers the following limited warranty against defects in material and workmanship on Cal Flame pizza carts All Cal Flame pizza carts are manufactured with the highest quality appli ances and are warranted to be free from defects in material and workman ship at time of delivery Lifetime Equipment and Component Warranty LMS warrants the following against deterioration and corrosion Cast stainless steel burner e Stainless steel rack e Stainless steel mountings e Stainless steel body and door LMS warrants carts and associated hardware from defects in material and workmanship for a period of one year from the original date of purchase LMS warrants the cart s structural frame all non stainless steel fasteners temperature gauge plastic items stainless steel drawers doors igniters tube stainless steel burners and gas valves for a period of one year Extent of Warranty This limited warranty is only valid on Cal Flame models delivered in the United States or Canada and extends through the selling dealer to the original purchaser at the original site of installation This warranty be comes valid at time of purchase and ends either by specified time frame listed above or upon owner transfer or relocation Warranty Performance In the event of a malfunction or defect covered under the terms of this warranty a factory authorized service agent of LMS will perfo
9. 2009 OWNER S MANUAL United States and Canada www calspas com Installation Assembly Leak Testing Procedure ssr oss rr rar RR RR RR REA 5 Gas Requirements and Connection 2 000000000es 6 LP GaS ideas td seers Beha Vee eae bee eed 6 Natural GaS ss ss sne aa eee ee ee ee KE 8 Installing the Transformer 00000ceen ae ee eens 9 Installing the Bricks and Rack 0000eeeeeeeuee 10 Operating Your Pizza Oven Electronically Lighting the Oven 0000e0euee 11 Manually Lighting the Oven ssssserrrrr rr ers rr nn na 12 Basic Operation sossar eee 13 Turning on and off the Lights and Fan 000005 13 Safety Considerations 00 00ccce eee e een eeeeees 14 Cleaning and Maintenance After Use Cal ss svea es ee eee es sir eS 15 Drip Pan cece 15 BUMGr 2220 chee orini a naa ete ke eee Er RER 16 Care of Stainless Steel 00 cece 16 Covering Your Pizza Oven cc eee e eee 16 Appendix Troubleshooting 000cee eee eens 17 Replacement Cover ccc cece eee 19 Warranty 2 0 eee Copyright 2008 2009 LMS Inc All rights re CONTACT INFORMATION served Duplication without written consent For customer service please contact is strictly prohibited your authorized dealer immediately If Cal Flame is a registered trademark you need additional information and or assistance please contact Due to continuous improvement programs Customer Service Department all models ope
10. 20091039 Rev A www calspas com UPAO LZZ d ANOASuIze4edQ Operating Your Pizza Oven Manually Lighting the Oven Use the match extender that comes with the pizza oven for manu ally lighting Do not use standard matches or cigarette lighters to perform match lighting procedures Serious burns can occur and lighters can explode If you have just attempted to light the burner allow five minutes for any accumulated gas to dissipate Slide the small access plate located next to the over control Slide out the drip tray from the pizza oven Light and insert a long stem match holding it near the burner ports Turn the control knob just past the LIGHT position to HIGH Listen for the sound of the gas igniting If the burner does not light after five seconds turn the control knob to the OFF posi tion Wait five minutes until the gas clears before attempting to light it again If the burner does not light after several attempts see Trouble shooting Guide in the back of this manual ATUA 2009 Pizza Cart www calspas com LTR20091039 Rev A Basic Operation Before lighting make sure the burner control is off Do not attempt to light the burner if the smell of gas is present Check the connec tion with a soap and water solution after attaching the hose For LP units make sure there is gas in the tank and it is sitting upright For natural gas units make sure the shut off valve is on Make sure the drip tray i
11. A Read all instructions before use We recommend you wash your entire pizza oven with soap and water prior to lighting it for the first time Oils are used during the manufac turing process and some residual oil may still be on the stainless steel parts of your pizza oven Washing will reduce the possibility of discolor ation We also recommend you keep your pizza oven covered when not in use This will minimize the amount of dust and dirt that accumulates on your pizza oven and extend its life DANGER What To Do If You Smell Gas Shut off gas to the appliance Extinguish any open flame Open lid If odor continues keep away from the appliance and immediately call your gas supplier or your fire de partment Electronically Lighting the Oven Push the knob in fully and rotate it about 1 4 turn to the left counter clockwise until you hear a loud click Listen for the sound of the gas igniting If the burner does not light on the first try rotate the knob back to the OFF position and try relighting until the gas ignites If the burner does not light after several attempts turn the con trol knobs to the OFF position Wait five minutes until the gas clears before attempting to light it again Repeat the procedure or try the manual lighting procedure 5 To shut off the burners turn the knob to the OFF position It is normal to hear a popping sound when the burners are turned off 2009 Pizza Cart OAU F aye LTR
12. al Any implied warranty shall have duration equal of the applicable warranty stated above Legal Remedies This limited warranty gives you specific legal rights You may have other rights which may vary from state to state See your Cal Flame barbecue dealer for a copy of the applicable warranty details and any questions you may have regarding the warranty coverage on your pizza cart Don t forget to register your new product at www calspas com 2009 Pizza Cart LTR20091039 Rev A www calspas com xipueddy 2 LMS Customer Service Department 1462 East Ninth Street Pomona CA 91766 Toll Free 1 800 CAL SPAS Fax 1 909 629 3890 www calspas com LTR20091039 Rev A 3 16 09
13. ansformer All grills with electrical components such as lights or a convection fan will require the transformer to be installed and plugged in before you can use it This needs to be done before the grill is inserted in the island or modular cart When the transformer is attached to the grill chassis use care in placing the grill in the island cutout to avoid hitting the transformer 1 Remove the transformer and the metal screws from the plastic bag Place the grill on a sturdy surface and tilt it back to show the underside of the grill Using the metal screws attach the transformer to the left side of the grill near the internal electri cal connection Attach the metal plate to the out side surface of the grill as shown in the figure below When you have firmly tightened the screws and nuts connect the plug from the transformer to the grill Screw on the stainless steel retainer 2009 Pizza Cart iy Ajquassy uorejjeasuj Installation Assembly Installing the Bricks and Rack The pizza oven uses three white bricks for diffusing heat from the burners After you have removed the pizza oven from the box and removed all packing materials place the three racks lengthwise on the left and right ledge above the burner Then place the three white bricks on the racks in the same way Remove the packing material from the rack and slide it in place on top of the bricks www calspas com ba 0 A
14. deal er technician will void your warranty Storage e When your pizza oven is not in use turn off the gas at the supply cylinder e Storage of a pizza oven caddy indoors is permissible only if the supply cylinder is disconnected and removed Precautions Regarding Children e Never leave children unattended in the area where the pizza oven is being used Close supervision of children is necessary when any appliance is use near children e Do not store items of interest to children around or below the pizza oven or caddy e Never allow children to sit or stand on any part of the pizza oven or caddy 2009 Pizza Cart gt OU Flame LTR20091039 Rev A www calspas com suoijzonajsuy Kes gt Installation Assembly Most cities and counties require permits for exterior construction and electrical circuits In addition some communities have codes requiring residential barriers such as fencing and or self closing gates on prop erty to prevent unsupervised access to the property by children under the age of five Your dealer can provide information on which permits may be required and how to obtain them prior to the delivery of your equipment We recommend the installation adjustment and service of your new pizza oven be performed by LMS qualified installers and service techni cians to ensure proper operation and prevent accidents When planning the location of your Cal Flame pizza oven consider ac cess to gas line
15. e until the leak is corrected 2009 Pizza Cart LTR20091039 Rev A www calspas com Aiquiassy uorejjeasuj C Installation Assembly Gas Requirements and Connection IMPORTANT Cal Flame pizza ovens are manufactured to operate on liquid propane LP but can be converted to natural gas NG To verify the oven s operating fuel check the serial number label in the back of the chassis Either LP or NG will be marked on the operating tab indicating the proper operating fuel Always check the rating plate to make sure the gas supply you are hooking up to is the gas type the pizza oven is manufactured for If you do not have an updated filler valve on your existing propane tank you will need to purchase one at your local hardware store Without it you will not be able to attach your tank to your Cal Flame pizza oven or refill the tank at your local propane refill station LP Gas Tank Requirements Maximum line pressure for plumbed in propane is 14 WC 3 5 kPa Minimum line pressure for propane is 11 WC The pizza oven must be used with the gas pressure regulator The regulator will control and maintain a uniform gas pressure in the mani fold The burner orifices have been sized for the gas pressure delivered by the regulator WARNING Attempting to operate the pizza oven unit without the gas regulator installed could cause an explosion and possible death Cylinder Specification Any LP gas supply c
16. g e The ignition wire should be connected firmly to the valve ignition device and electrode Replace the ig nition wire if it is frayed or cracked e With the gas supply closed and all control knobs set to the off position check each position igniter indi vidually for the presence of a spark at the electrode Push each knob in fully and rotate it about 1 4 turn to the left counter clockwise until you hear a loud click The trigger hitting the strike block should produce a blue spark at the electrode tip Return control knob to the off position before checking the next igniter e While the grill is still hot wait for a minimum of five minutes before commencing re ignition This allows accumulated gas fumes to clear If all checks corrections have been made and the gas grill still fails to operate properly contact your local Cal Flame dealer Problem Flashback Solution When fire occurs in and around the burner tubes im mediately turn off gas at its source and turn the con trol knobs clockwise to the OFF position Wait until the grill has cooled off and then clean the burner tubes and burners as described on page of this manual Replacement Cover We recommend covering your pizza oven to protect it from the ele ments You may order a cover for your pizza oven through your dealer or by calling 1 800 CAL SPAS The part number for the 22 pizza oven cover is BBQ878CVR 2009 Pizza Cart LTR20091039 Rev A
17. nsions so as to permit the entrance of a 1 8 inch 3 2 mm diameter rod Transporting and Storing LP Gas Place the dust cap on the cylinder valve outlet whenever the cylinder is not in use Only install the type of dust cap on the cylinder valve outlet that is provided with the cylinder valve Other types of caps or plugs may result in leakage of propane Transport only one cylinder at a time Ensure the cylinder is secured in an upright position with the control valve turned off and the dust cap in place Store cylinders outdoors and out of reach of children Do not store cylinders in a building garage or any other enclosed area er 7 5 Pressure Relief Valve Coupling Nut 2 Turn clockwise to ES Bleed Off Valve connect E A J Turn clockwise to close E We Regulator p S W a z ff R AJ A N e 4 Dust Cover 2009 Pizza Cart LTR20091039 Rev A www calspas com i Installation Assembly Natural Gas Warning All pizza ovens use LP unless they are converted to natural gas Do not connect natural gas to an unconverted pizza oven Requirements Always check the rating plate to make sure the gas supply you are hooking up to is the gas type the pizza oven is manufactured for IMPORTANT Never connect the pizza oven to an unregulated gas sup ply The installation of this appliance must conform with local codes or in the absence of local codes to the national fuel gas code ANSI Z223 1a 1998 Installation
18. ntatives acts of God and other cases beyond the control of LMS are not covered by this warranty Please refer to the owner s manual for examples of exclusions and common acts invalidating this warranty This limited warranty applies only to pizza carts and associated hardware used for personal family and outdoor household purposes This warranty does not apply to labor charges on pizza carts replacement parts and hardware This limitation is retroactive and applies to all pizza carts and hardware manufactured from 2000 and hereafter Examples of common acts invalidating this warranty include but are not limited to e Scratches caused by normal use e Damage caused by extreme weather conditions hot cold etc e Damage caused by dirt sand and or water damage e Damage caused by continued operation of the pizza cartwith either known or unknown problems e Damage caused by direct sunlight e Damage caused as a result of failure to follow the operating instruc tions as defined in this owner s manual This limited warranty applies only to pizza ovens normally used for per sonal family or household purposes and specifically excludes commercial pizza carts Disclaimers LMS shall not be liable for loss of use of the pizza cart related hardware or other incidental or consequential costs expense or damages which may include but are not limited to removal of permanent deck or other custom fixtures or the necessity for crane remov
19. procedure turn OFF all of the gas control knobs shut off the fuel supply and disconnect the fuel line To access the burner remove the racks and bricks from the oven 1 Unscrew the Phillips screw holding the burner in place and care fully lift up and remove the burner 2 Use a wire brush to clean the outer surface of the burner to re move food residue and dirt Clean any clogged ports with a stiff wire such as an opened paper clip 3 Inspect the burner for damage cracks and holes If any damage is found replace the burner and discontinue oven usage 4 Upon reinstallation inspect the gas valve orifice for cleanliness and condition and the location of the igniters Care of Stainless Steel Do NOT use wire wool pads scrappers harsh abrasive scoring materi als bleaches or harsh cleaners on your pizza oven or allow salt and vinegar mixtures to remain in contact for a long period of time This will cause scratching scoring rusting and pitting We recommend that you clean stainless steel components with a clean er that is approved for stainless steel and only clean when the pizza oven is cool and in indirect light Never use steel wool Covering Your Pizza Oven When not in use and after cooling cover your pizza oven with our full length zippered side canvas cover See your local Cal Flame dealer for details The cover will help protect your pizza oven from detrimental effects of weather and environmental pollutants
20. pt clear Do not perform any maintenance or cleaning while the pizza oven is still hot After Use Care The easiest way to clean the pizza oven is immediately after cooking is completed and after turning off the flame Remove the rack from the oven and scrub it with a brass bristle brush and hot soapy water Wipe the bricks with a damp soapy cloth and rinse with warm hot clean water For more stubborn deposits including oil grease and wa ter borne deposits use a multipurpose cream cleanser and apply with a soft damp cloth Dry with a soft dry clean towel if preferred Drip Pan The full width drip pan will collect liquid run off from the oven The pan should be cleaned after every use to avoid the possibility of a grease fire Be sure to allow the drip pan to cool prior to cleaning You may clean the drip pan with a solution of warm soapy water Make sure to rinse thoroughly to avoid staining 2009 Pizza Cart CF bane LTR20091039 Rev A oo www alspas com DULUJJUIE W pure SuluLs gt 5D Cleaning and Maintenance Burner Spiders and small insects occasionally inhabit or make nests in the burner tubes obstructing the gas flow Sometimes this results in a type of fire in and around the gas tubes called flashback To reduce the risk of flashback this procedure should be followed at least once a month or when your pizza oven has not been used for an extended period of time IMPORTANT Prior to starting this
21. ration and or specifications 1462 East Ninth Street are subject to change without prior notice Pomona CA 91766 LTR20091039 Rev A Toll Free 1 800 CAL SPAS 3 16 09 Fax 1 909 629 3890 www calspas com Save these instructions WARNING Improper installation adjustment al teration service or maintenance can cause injury or property damage Read the installation operating and maintenance instructions thoroughly before installing or servicing this equipment Placement and Location e The Cal Flame pizza oven is designed for outdoor use only e Never locate this appliance in an enclosed room under a sealed overhead structure or in any type of enclosed area such as a ga rage shed or breezeway Keep clear of trees and shrubs e Do not place the pizza oven under or near windows or vents that can be opened into your home e The Cal Flame pizza oven is not intended for installation in or on recreational vehicles or boats e Maintain sufficient distance as to not overheat any overhead com bustible material such as a patio cover e The area surrounding your pizza oven should be kept clean and free from flammable liquids and other combustible materials such as mops rags or brooms as well as solvents cleaning fluids and gasoline e Do not use the pizza oven pizza caddy or area surrounding the pizza oven as a storage area for flammable or plastic items Do not store the liquid propane LP cylinder in the vicinity
22. rm the nec essary repairs To obtain service contact the selling dealer In the event the consumer is unable to obtain satisfactory customer service from the selling dealer or service agent written notification must be given to the LMS Customer Relations Department within 30 days of the reported failure There will be no charge for parts or labor on a covered item However the service agent may assess a reasonable travel or mileage charge per service call If LMS determines that repair of a covered item is not feasible LMS reserves the right to replace the defective merchandise with merchandise equal in value to the original purchase price Warranty repair and or re placement is the sole discretion of LMS and this warranty does not cover costs therein including but not limited to freight removal re installation etc This warrant is non transferable and may not be extended beyond the above mentioned time frames under any circumstances by any of LMS s representatives 2009 Pizza Cart LTR20091039 Rev A www calspas com Warranty Limitations This warranty is void if the pizza cart has been subject to negligence al teration misuse repairs dings dents scratches or incorrect and or pro hibited applications as specified in the owner s manual Gas lines must be installed by a licensed plumber only or local gas company agent Incorrect electrical installation by unlicensed electricians service by non LMS autho rized represe
23. s The location with the shortest gas line run is recom mended When determining a suitable location consider factors such as expo sure to wind proximity to traffic paths and windows that open into the home Locate your pizza oven only in a well ventilated area and only on a solid flat foundation e g deck or cement slab Do NOT place stain less steel carts on dirt or grass We recommend that a licensed contractor install your Cal Flame pizza oven Installation must conform to local codes or in the absence of local codes with either the National Fuel Gas Code ANSI Z223 1 NFPA54 Natural Gas and Propane Installation Code CSA B149 1 or Propane Storage and Handling Code B149 2 as applicable Before installing a built in pizza oven in an enclosure copy all product information such as model number serial number and type of fuel e g natural gas or LP and store information in a safe place This informa tion is located on a plate located behind the pizza oven on the right side of the chassis There is an area on the back cover of this manual where you can write down this information Ft 2009 Pizza Cart Ze EES Leak Testing Procedure Perform a leak test at least once a year whether the gas supply cyl inder has been disconnected or not In addition whenever the gas cylinder is connected to the regulator or whenever any part of the gas system is disconnected or replaced perform a leak test As a Safety precaution
24. s in place Light the oven using the instructions on the next page Turn the control knob to HIGH and preheat the oven for 15 min utes Close the door during the preheat period Place the food in the oven and cook to desired completion Ad just heat setting if necessary You may set the control knob to any position between HIGH and LOW Allow the pizza oven to cool and clean the bricks and drip tray after each use Do not leave the pizza oven unattended while cooking Turning on and off the Lights and Fan The ON OFF switch controlling your halogen light is located at the control panel on the front lower left side Certain models of the Cal Flame grill are equipped with either one or two halogen light Your grill is equipped with a grounded 3 prong 120 VAC plug located in the lower left rear corner of your cart and must be plugged into a permanent grounded 120 VAC outlet with a dedi cated 15amp GFI breaker DO NOT cut or remove the ground prong as this may result in fire electrical shock or other personal injury This electrical source provides power to the lights 2009 Pizza Cart P LTR20091039 Rev A f www calspas com U AO LZZ d ANOASuIze4edQ Operating Your Pizza Oven Safety Considerations Each time you light the pizza oven check the following e Inspect the hose before using the pizza oven If there is exces sive abrasion or wear or if the hose is cut it must be replaced prior to
25. ylinder used with this pizza oven must be con structed and marked in accordance with either e Specifications for LP Gas Cylinders of the U S Department of Transportation or e National Standard of Canada CAN CSA B339 Cylinders Spheres and Tubes for Transportation of Dangerous Goods and Commission The LP cylinder must be approximately 12 inches in diameter and 18 inches high The maximum fuel capacity is 20 Ibs of propane or 5 gallons Full cylinder weight should be approximately 38 Ibs 43 7 Ibs nominal water capacity Never fill the cylinder beyond 80 full CF bane 2009 Pizza Cart www calspas com LTR20091039 Rev A LP Gas Hook Up Vent the enclosure for an LP gas cylindar with openings at the level of the cylinder valve and at the floor level Ensure one side of the enclosure is completely open For enclosures that have four sides complete with a top and bottom e At least two ventilation openings at cylinder valve less than one square inch per pound 7 1 cm2 kg of stored fuel capacity and not less than a total free area of 10 square inches 64 5cm2 If ventilation openings at floor level are in a sidewall there shall be at least two openings The bottom of the openings shall be at floor level and the upper edge no more than 5 inches 127 mm above the floor The openings shall be equally sized spaced at 180 3 14 rad and unobstructed Aiquiassy uorejjeasuj 5 e Every opening shall have minimum dime
Download Pdf Manuals
Related Search