Attwood 66320 User's Manual
Contents
1. 12 Volt Stainless 1 Mile Navigational Light Without Wire Leads 66320 With 7 Wire Leads 66318 66319 Attwood marine hardware navigational lighting bilge pumps and other marine accessories are specified more than any other brand by America s best known boat manufacturers as original equipment Look to Attwood for quality replacement parts and marine accessories SAVE THESE INSTRUCTIONS Form Number 69376 Rev B 03 10 FEATURES The Attwood 12 volt DC stainless steel one mile navigational sidelights are designed for mounting on horizontal surfaces such as the gunwale or deck Meets USCG CFR 183 810 ABYC A 16 requirements and all applicable standards as tested by ITS ETL 5 23 1995 1 Nautical Mile visibility Uses Lamp 9231 12V 8 Watt The housing is made of highly polished stainless steel for corrosion resistance The lens completely encapsulates the bulb and socket assembly for splash resistance The lens rests on a rubber gasket making these lights virtually waterproof when used with the optional base gasket REQUIRED FOR INSTALLATION e 1 Phillips head screwdriver e Drill with suitable bits 1 2 13mm e Base gasket Attwood 910410 or marine sealant e Three 4 or 6 stainless steel pan head screws LOCATION 1 Be sure that sidelights shine straight ahead Combination sidelight must be aligned on centerline See Figure 1a sidelights pairs must be parallel to centerline See Figure 1b 2 Posit2. aluminum surfaces Place gasket then lens and housing over the base CAUTION Position carefully on aluminum boats so that wires do not contact the hull 4 Insert mounting screws through housing and fasten into deck See Figure 3 Figure 3 Screws Not Supplied Housing Lens Gasket Bulb Centerline Lae of Boat Base WIRING INSTRUCTIONS The power source must be 12 volt DC ONLY Use marine grade wire connectors only Protect all connections with suitable materials NOTE Failure to make proper connections and fuse the light properly will void the product warranty 1 Connect one terminal to the negative post of the 12 volt battery Connect the other terminal to the positive lead through a 2 amp fuse and suitable dash mounted switch See Figure 4 Figure 4 2 Test lights for proper operation from dash mounted control switch MAINTENANCE Replace bulb when necessary with standard 8 watt automotive festoon type Attwood 9231 SAVE THESE INSTRUCTIONS ATTWOOD LIMITED WARRANTY Attwood Corporation 1016 North Monroe Lowell Michigan 49331 Attwood warrants to the original consumer purchaser that Attwood brand products will be free from defects in materials and workmanship under normal use and service for one year from the date of original consumer purchases This limited warranty is not applicable if the product has been damaged by accident improper installa
3. ion light s on a horizontal surface 5 of the gunwale or deck If installing a combination light place it on the furthermost tip of the bow on the centerline of the boat See Figure 1a Sidelight pairs must be equal distance from the bow The red lens must be on the port left and the green on the starboard right as you stand onboard facing the bow of the boat See Figure 1b Figure 1a Figure 1b 112 5 Arc Must Be Clear Green Starboard Green Starboard 3 Ensure that there are no front or side obstructions such as rail stanchions chocks anchors etc within the arc of visibility 112 5 each side 4 Measure and mark location of terminal clearance hole Hole s must be on boat centerline for combination sidelight 66318 Figure 1a or equal distance from bow for sidelight pairs 66320 and 66319 figure 1b Drill a 18mm dia hole See Figure 2 Figure 2 2 1 2 64mm 2 1 16 2 1 4 57mm Centerline 1 11 16 27mm 7 8 1 3mm 22mm MOUNTING INSTRUCTIONS 1 Place base into hole and align so that light s shine straight ahead Use base to mark pilot holes for the mounting screws Drill pilot holes 2 Feed the power source leads up through the deck and attach to base terminals or wires Insulated terminals are recommended 3 Apply base gasket or sealant to the deck mounting area Gasket is highly recommended on
4. products No implied warranty including without limitation the implied warranties of merchantability and fitness for a particular purpose shall be extended beyond the warranty period stated above for each product Attwood shall not be liable for any damages for loss of use of this product nor for any other incidental or consequential damages costs or expenses Some states do not allow limitations on how long an implied warranty lasts or the exclusion or limitation of incidental or consequential damages so the above limitations and exclusions may not apply to you This warranty gives you specific legal rights and you may have other rights which vary from state to state 2003 Attwood Corporation 1016 N Monroe Street Lowell MI 49331 0260 www attwoodmarine com
5. tion unreasonable or improper use lack of proper maintenance unauthorized repairs or modifications normal wear and tear or other causes not arising out of defects in materials or workmanship Attwood products are warranted for use on pleasure boats Any other use including but not limited to commercial racing or non marine use are not covered under this warranty Attwood s obligation under this warranty is limited to repair of the product at Attwood s plant or replacement of the products at Attwood s option without expense to the original consumer purchaser Any expenses involved in the removal reinstallation or transportation of the product are not covered by this warranty The product must be returned to Attwood s plant at the address above postage pre paid and insured with proof of original purchase including date If Attwood is unable to replace the product and repair is not commercially practical or cannot be timely made or if the original consumer purchaser is willing to accept a refund in lieu of repair or replacement Attwood may refund the purchase price less an amount for depreciation The acceptance by Attwood of any product returned or any refund provided by Attwood shall not be deemed an admission that the product is defective or in violation of any warranty Products that are replaced or for which a refund is issued become the property of Attwood This warranty is Attwood s only expressed warranty of these
Download Pdf Manuals
Related Search