Home

Airstream LAND YACHT MOTORHOME User's Manual

1. D 1 Sofa ugue Nen F 1 Solar Power eere H 17 Spare Tire ose eet ere C 8 Specifications K 1 K 2 Step Electric uui ee C 14 Stordpe qe E G 29 Switch Over Box I 1 Table F 1 Tank Capacities K 1 Tank etre tee G 31 Tank Holding D 7 G 25 G 32 Tank Sewage G 10 G 24 G 32 Tank Water au u u abu aq G 5 Tank LPG incre et ete qasa G 1 Tires RE C 7 Air Pressure C 7 K 1 Alignment C 8 Changing t qasa C 8 Torque eene et C 9 Rotation sese C 10 SUPPOLt u Su eee C 11 Toilet hes iere G 19 TOMINE thetic tree em B 5 TV Antenna H 14 TV Monitor D 7 Tub Shower F 2 Upholstery eerte ete RS F 3 Vent Power x s ener J 6 Ventilation D 8 F 2 Walls 3 Washing Waxing E 1 Warning iuniore Introduction Warranty certes A 1 A 3 Warranty Transfer A 3 Warranty Exclusions A
2. 14 Filtering Appliance 15 Lower Spout Assembly 16 Threaded Shank 17 Supply Tubes 2 18 Bottom Bearing Washer 19 12 Threaded Fitting 20 Deck Ring with Gasket Deck Plate N 22 Mounting Bracket 23 Mounting Nut 24 Designer Spray Head Spray Models 25 Hose Guide with Gasket Side Spray Models 26 Spray Hose 27 Extended Locknut Side Spray Models 28 Swivel Nut Spray Models 29 Mounting Tool 30 Deck Plate Spray in Deck Models 31 Support Plate with Gasket AIRSTREAM LAND YACHT GAS MICROTECH FILTER INSTALLATION REPLACEMENT 1 Install a new filter by wetting the outlet ports with water and then inserting into the round filter ports on the faucet head and pushing the filter and head together Both outlet ports must be fully inserted into the filter ports 2 Install the filter and faucet head assembly on to the spout by wetting the faucet head o ring seal and then carefully sliding the free end of the filter into the spout The head will need to be initially turned approximately 1 2 turn counter clockwise from its normal position to slip past the safety catch Lock the head into place by simultaneously pushing and twisting the head clockwise When properly installed the head will feel secure and will be correctly oriented on the spout 3 Reset the filter life indicator by pushing the filter button 3 times Wait 10 seconds You should not be running water while resetting the
3. 000 1 00 00 DALITIGLNI 489165 S V ZH09 29 001 902 DNILVE HOLIAS 20123135 DILVWOLNV AAVONOIAS AIRSTREAM LAND YACHT GAS 8 AIRSTREAM LAND YACHT GAS NOTES 1 9 AIRSTREAM LAND YACHT GAS APPLIANCES N Warning Most LP gas appliances used in recreational vehicles are vented to the outside of the vehicle Check the exterior areas of your unit for clearance in these areas Turn all gas operated appliances off when parked close to a gasoline pump it is possible that gasoline fumes could enter these types of appliances and ignite from the burner flame or automatic igniters CAUSING A FIRE OR AN EXPLOSION AIR CONDITIONER Manufacturer Dometic Sales Corporation 2320 Industrial Parkway P O Box 490 Elkhart IN 46515 Phone 219 295 5228 Note Review the air conditioning literature supplied in your Owner s Packet before proceeding The roof air conditioner used on Airstream motorhomes is one of the most popular on the market today In your Owner s Packet is a set of literature covering all operating and maintenance instructions If the literature is misplaced please contact the air conditioner manufacturer or your Airstream dealer for replacement A detailed service guide may be ordered from the manufacturer Because of the amount of power drawn by the air conditioners it is only possible to operate one at a time when plugged into city power The Intellitec Automa
4. Swivel Chairs The chairs have two adjustments One lever will allow the chair to rotate The other lever lets the chair slide forward and back CAUTION Rotating the chair when it s slid back against the wall can damage the upholstery Position the chair so it isn t chafing when in transit CAUTION Never remove cushion cover for separate cleaning or washing Any tumble cleaning method can destroy the backing shrink or otherwise damage upholstery Shades The main door shade is operated in the same manner as most Venetian blinds Pulling down on the tab lowers the shade and it will catch on its own A slight pull downward will release the shade and it can slowly be returned to the open position Day Night shades are lowered and raised by the bars running across the shade Grasp in the center of the bottom bar or place hands evenly on the bar Pull the bottom bar down to the lower sill A center bar with small handles can be lowered night or raised day Rough roads and long trips may cause the pleated shades to come down slightly during travel Tensions on the strings at the sides of the shades adjust the ease of operation and their ability to stay up during travel Do not over tighten as this may cause the string to break requiring service A feather duster or the soft bristled brush often found as part of vacuum cleaner attachments are recommended for cleaning the blinds and pleated shades The longevity of the pleated shades wil
5. Approximately 16 gallons left Red Warning Filter life is deleted discard old filter and replace with a new Microtech 400 or 600 filter If fast red doesn t change to slow amber green after memory has been reset reset was not complete and needs to be redone Follow step 3 on the previous page A standard replaceable 3V lithium watch battery 2032 designed to last several years powers the electronic indicator Battery Replacement Follow filter replacement instructions to remove filter appliance Locate battery compartment drawer pull out and replace battery positive side up AIRSTREAM LAND YACHT GAS TROUBLESHOOTING PROBLEM Water flows from both outlets filter and unfiltered when the filter button is pushed SOLUTION No filter is installed Install a filter PROBLEM After installing a new filter the filter life indicator still flashes red SOLUTION Filter life indicator was not reset or the attempt to reset the indicator did not work Perform reset sequence PROBLEM Reversed Hot amp Cold positions SOLUTION HELPFUL HINTS IT IS NOT NECESSARY TO SHUT OFF WATER SUPPLIES HANDLE SCREW REQUIRES A 7 64 HEX KEY WRENCH br mu 1 Remove plug button 3 from the handle by prying the button upwards from the bottom center If a tool is required use something which will not scratch the handle NOTCHED Remove set screw 2 handle body 1 dome and pivot retainer assembly 4 cartridge mura pay screw 5
6. A Warning NEVER exceed the weight ratings of trailer hitch installed on a motorhome Failure to heed any part of this warning could result in loss of control of the motorhome and towed vehicle or trailer and may cause an accident serious and or fatal injury For specified towed vehicle braking requirements consult the chassis owner s manual that comes with this vehicle AIRSTREAM LAND YACHT GAS SPECIFICATIONS NOTE The weights and measurements in this manual are derived from the best information available at time of this manuals publishing Please refer to the weight information label placed in your unit and your chassis Owner s Manual for weights specific to your RV The Unit Base Weight UBW and the Net Carrying Capacity NCC is not the same as the Unloaded Vehicle Weight UVW and the Cargo Carrying Capacity CCC shown on the Weight Information tag in your vehicle The UBW and NCC weights are for the base unit with no options and fluids except for fuel on motorhomes The UVW and CCC on the Motorhome Weight Information tag are weights for the individual vehicle as built with its options and certain water capacities CHASSIS 26 Ft 30 Ft 30 Ft S O 33 Ft Wheel Base 158 5 190 190 208 NCC 2 300 Lbs 3 497 Lbs 3 048 Lbs 2 997 Lbs GVWR 15 000 Lbs 18 000 Lbs 18 000 Lbs 18 000 Lbs GCWR 19 000 Lbs 22 000 Lbs 22 000 Lbs 22 000 Lbs UBW 12 700 14 503 Lbs 14 942 15 023 Lbs Gross Axle Ratings Front 6 000 Lbs 6 000 Lbs
7. Do not hang wet clothes in the motorhome to dry In hot weather start the air conditioner early as it removes excess humidity from the air while lowering the temperature Keep the temperature as reasonably cool during cold weather as possible The warmer the vehicle the more cold exterior temperatures and warm interior temperatures will collide on wall surfaces thus creating condensation Use a fan to keep air circulating inside the vehicle so condensation and mildew cannot form in dead air spaces Allow air to circulate inside closets and cabinets leave doors partially open Please keep in mind that a closed cabinet full of stored goods prevents circulation and allows the exterior temperature to cause condensation D 10 AIRSTREAM LAND YACHT GAS TIPS TO CONTROLLING CONDENSATION continued The natural tendency would be to close the vehicle tightly during cold weather This will actually compound the problem Simply put you need to remove some of the warm air and allow some cool outside air to get inside the vehicle so the furnace will not recycle the humid interior air Use fluorescent ceiling lights and minimize prolonged use of incandescent lights which produce heat and contribute to condensation in the roof above the ceiling lights ABOUT MOLDS What are molds Molds are microscopic organisms that naturally occur in virtually every environment indoors and out Outdoors mold growth is important in the decomposition of pl
8. 1 BULB 10W BED READING LIGHTS 2 40 BULB CS WARDROBE LIGHT 1 44 5 BEDROOM FLUOR CEILING LIGHT 1 33 2 2 BULB WALL LAMPS 4 00 REAR TV 5 00 REAR A C FEED WIRE 1 00 TOTAL 15 17 AMPS FUSE POSITION 4 CIRCUIT 2 20 AMP 12 GA YELLOW FUSE POSITION 7 CIRCUIT 6 15 AMP 12 GA RED 8 COMPARTMENT LIGHTS 11 52 FUSE POSITION 8 CIRCUIT 16 20 AMP 12 BLACK 2 STEP LIGHTS 200 PATIO LIGHT 1 50 SHOWER FAN 150 2 BULB DINETTE LIGHT 3 00 1 2 3 AND 4 FLUOR CEILING LIGHTS 6 80 TOTAL 14 80 AMPS NO CIRCUIT 8 USED FUSE POSITION 9 CIRCUIT 9 20 AMP 12 GA GREEN RANGE VENT AND LIGHT 3 20 WATER PUMP 7 00 TOTAL 10 20 AMPS FUSE POSITION 10 CIRCUIT 23 20 12 GA PINK 4 HALOGEN DOCKING LIGHTS 18 33 AMPS FUSE POSITION 11 15 AMP SPARE FUSE POSITION 12 15 AMP SPARE BATTERY CHARGER 3 00 AMPS TOTAL DRAW 105 36 AMPS 15720 AMPS 100 20 00 AMPS 29 20 AMPS 50 10 00 AMPS 65 36 AMPS 25 16 34 AMPS 46 34 AMPS 46 34 POWER CONVERTER REQUIRED RY CALCULATION BATH FLUOR LIGHT 1 33 BATH CEILING FAN 2 00 FURNACE 9 80 WATER HEATER ELECTRONIC IGNITION 1 00 BULB SHOWER LIGHT 1 44 TOTAL 13 57 AMPS NO CIRCUIT 3 USED FUSE POSITION 5 CIRCUIT 4 15 AMP 12 BROWN 4 AISLE LIGHTS 1 00 UNDER HOOD LIGHT 1 44 GALLEY OVERHEAD LIGHT 1 33 TOTAL 4 37 AMPS FUSE POSITION 6 CIRCUIT 5 15 AMP 12 GA BLUE REFER LIGHT 1 00 2 10 W HAL LOUNGE LOCKER LTS 1 60 1 10 W C
9. 30 Sealant 31 Blade Spring 32 Blade 33 Blade Seal 34 Blade Track 35 Flapper 36 Overflow Tube 37 Nozzle Assy 38 Bowl 39 Reservoir Assy 40 Shroud Specify High or Low Hand Flush only t Foot Pedal Flush only USA 1 800 521 3032 Canada 1 888 215 5410 G 19 AIRSTREAM LAND YACHT GAS TROUBLE SHOOTING PROBLEM Water keeps running into bowl CAUSE The blade in the bottom of the bowl is not closing completely which in turn keeps the water control valve partially open The groove into which the blade seats when completely closed is clogged with foreign material REMEDY Insert the end of a coat hanger or similar object into the sealing groove and remove the foreign material Avoid damaging the rubber seal while cleaning PROBLEM Toilet leaks There is water on the floor Specify the problem Determine if water is leaking from CAUSE a Vacuum breaker b The water control valve c Bowl to mechanism seal If this is the problem the water would not stay in the bowl d Closet flange base seal REMEDY a The vacuum breaker If the vacuum breaker leaks when flushing the toilet replace vacuum breaker b If the vacuum breaker leaks when the toilet is not in operation replace the water control valve c Leaks at the bowl to mechanism seal Remove mechanism and replace seal d Leaks at closet flange area Check front and rear closet flange nuts for tightness If leak continues remove the toilet check the c
10. MEK Damage to the lamp assembly by these chemicals is not cover under Kaper II s warranty program C 19 AIRSTREAM LAND YACHT GAS Replacement of the halogen bulb e When replacing the halogen bulb do not touch the glass portion of the bulb with your bare hands since even small amounts of impurities burn into the surface and reduce the service life of the bulb Use a clean cloth paper napkin or similar material to hold the bulb during installation With most bulbs you will not need to touch the glass part to install the bulb e Whenever working on any electrical system switch off the electrical accessory you are working on or refer to the electrical system section of your owner s manual Failure to do this could result in short circuits e To prevent injuries and damage comply with any instructions provided by the bulb manufacturer Any questions or comments may be directed to Kaper II Inc at1 800 336 2011 C 20 AIRSTREAM LAND YACHT GAS CAMPING SAFETY As always safety should be one of your top priorities Make sure you and everyone traveling with you can operate the main door and exit window rapidly without light gt Warning The roadside rear window is designed as an escape window To escape pull in on the two red latches at the bottom The complete window sash will swing out to allow easy exit The pleated shade is opened by sliding straight up The window operation should be checked each trip and ex
11. Open shut off valve to drain the icemaker at the same time you drain your motorhome If the motorhome is to be used in freezing weather do not open valve and use the icemaker G 29 AIRSTREAM LAND YACHT GAS For additional winterizing protection add non toxic antifreeze approved for drinking water systems to your water lines using the following procedure 1 Reconnect all lines except the hose to the pump inlet port Close all drain valves See Step 3 2 Turn bypass valves to bypass position 3 Attach a length of hose to the pump inlet port This piece of hose should be long enough for the free end to be inserted into and reach the bottom of the antifreeze container 4 Dilute the antifreeze solution in accordance with the manufacturer s instructions 5 Open all water faucets 6 Insert hose length into the antifreeze container turn the pump switch on and run the water pump until the antifreeze solution fills all water lines Flush toilet Work shower hand spray while holding down in tub 7 Shut off the pump and close all faucets 8 Disconnect the hose length from pump inlet fitting and reconnect water system inlet line The by pass valves are located under the lavatory cabinet in the 33 model accessed by removing the lower shelf vertical WATER HEATER close out under the wardrobe in the 30 model pull off the BY PASS VALVES small raised panel door held on by pressure latches below the wardrobe door and under
12. The microwave is simply captured in its cabinet Usually you will be able to move the microwave around in the cabinet but it won t come out J 4 AIRSTREAM LAND YACHT GAS WATER HEATER See warning at top of page J 1 Manufacturer Atwood Mobile Products 4750 Hiawatha Drive P O Box 1205 Rockford Illinois 61105 Phone 815 877 7461 Note Review the water heater literature supplied in your Owner s Packet before proceeding A Warning e Hydrogen gas can be produced in hot water system served by this heater that has not been used for a long period of time generally two weeks or more Hydrogen gas is extremely flammable To reduce the risk of injury under these conditions it is recommended that the hot water faucet be opened for several minutes at the kitchen sink before using any electrical appliance connected to the hot water system If hydrogen is present there will probably be an unusual sound such as air escaping through the pipe as the water begins to flow There should be no smoking or open flame near the faucet at the time it is open Electronic Ignition The switches used to operate your electronic ignition water heater are located in the bathroom above the lavatory top Atwood When the switch marked gas is turned on the red light will come on indicating the try mode is in effect Normally d the burner will ignite in just a few seconds and the light will go out If your LP system hasn t been used for some t
13. shrink or otherwise damage upholstery Free Standing Dinette Your unit may be equipped with a freestanding dinette The dinette tabletop pulls away from the wall on a slide and a leaf is provided to extend the top Hold on to the end of the table and give it a slight tug to release the top from its wall catches Once free from its catches the table can be extended into its full length The chairs have straps to stabilize them during travel F 4 AIRSTREAM LAND YACHT GAS PLUMBING LPG SYSTEM Your motorhome is equipped with a permanently mounted tank for LPG Liquid Petroleum Gas LPG burns with a clean blue flame There are two basic types of LPG in common usage Butane and Propane Butane is widely used where temperatures are normally above freezing the year round and Propane is used where subfreezing temperatures are common since Butane freezes at 32 F as compared to 40 F for Propane ALL OF THE ORIFICES IN THE LPG APPLIANCES ARE OF THE UNIVERSAL TYPE THAT WILL BURN EITHER FUEL How long a full tank of gas will last is dependent on usage In cold weather when you are using the furnace large amounts of hot water and cooking extensively you will naturally use more than you will in warm weather when you may do limited cooking On the average with normal cooking and other appliance use you can probably count on one month of usage from the tank If you have allowed the tank to run out air may have gotten into the lines In this even
14. 110 Volt Wiring Diagrams APPLIANCES Air Conditioner Furnace Refrigerator Range Oven Microwave Oven Water Heater Power Roof Vent Satellite System SPECIFICATIONS Coach Chassis AIRSTREAM LAND YACHT GAS AIRSTREAM INC LIMITED WARRANTY WARRANTY COVERAGE When you buy a new Airstream Land Yacht Motorhome from an authorized Airstream dealer Airstream Inc warrants the motorhome from defects in material and workmanship as follows BASIC WARRANTY PERIOD This warranty is for 30 000 miles 40 000 Kilometers or two years whichever comes first beginning when the vehicle is delivered to the first retail customer or first placed into demonstrator service This warranty must have started prior to the accumulation of 4 000 miles in order to be valid ITEMS COVERED Any part of the motorhome or any component equipment installed by the factory is covered by the basic warranty except the following items which are not covered e House Batteries e Automotive Chassis e Generator The above items will be handled by their respective service points and according to their written policy This limited warranty does not include failure caused by accident abuse normal wear overload or any cause not attributable to a defect in original material or workmanship of the motorhome or component equipment as installed by the factory LIMITATION OF IMPLIED WARRANTIES All warranties of merchantability and fitness for a particular purpose whe
15. 5 E rings Tumbler Installation Lock assembly as viewed from inside of door with cover plate removed Access to the linkage mechanism of the lock is gained by removing the two screws holding the lock handle and the center panel of the inside door skin This will expose the door lock assembly as shown in the illustration The tumbler is replaced by removing the inside lock handle and the center panel of the inside door skin so the lock assembly is exposed Insert key into tumbler then remove the E ring item 5 on Illus being careful it is not lost LOCK ASSEMBLY MAIN DOOR 1 Outside housing assembly 2 Inside plate 3 Striker bolt 4 Caged nut 5 Rotary latch E 2 AIRSTREAM LAND YACHT GAS KEYLESS DOOR LOCK Operation The dead bolt portion of your motorhome may be controlled by radio signals produced by the key fob shown below One characteristic of this system is the one second delay after a pad has been depressed NOTE When you use the keypad to turn the patio lights ON you must also use the keypad to turn them OFF The same goes for the switch inside the door if you turn the lights on with this switch you must use the same switch to turn them off You cannot turn the lights on with the keypad and off with the switch TouchTronics Keyfolo Operating Instructions Battery Indicator light Press once to Press once to lock all doors unlock all doors Press once to No function activate patio
16. 5 AMP MAX T POWER uc 10 AMP MAX AP RADIO PWR wana 10 AMP MAX F lt O SOLAR PANEL 192 5 5 SPARE 15 RADIO 5 D LP DETECT 3 AMP MAX AUX START 5 AMP MAX DOOR LOCK 15 AMP MAX BD RELAY SW AP Ma 5 AMP MAX THESE TERMINALS FOR TEST ONLY SEE SERVICE H 3 START SWITCH ISOLATOR RELAY SHOULD CLICK CONNECTION V CHASSIS BD 00 00777 000 F9 F8 F7 F6 F5 10 F11 MANUAL AAA CHAS BD LED 5 AMP MAX STEP MOTOR 25 AMP MAX STEP SW 5 AMP MAX SPARE CHAS 5 AMP MAX IGN SIGNAL 7 5 AMP MAX POWER SEAT 20 AMP MAX REAR HEAT 15 AMP MAX POWER WIND 29 AMP MAX JACKS MIRR 15 AMP MAX 15 AMP MAX HEATER AC FAN 45 AMP MAX SPARE IGN 2 15 AMP MAX SPARE IGN 1 15 AMP MAX CIR PURPLE 12 G VIRE AIRSTREAM LAND YACHT GAS Fuse Panel Coach Front Roadside Exterior Compartment 12 VOLT FUSE PANEL 32 G VIRE Black 14 ga CIRCUIT COLOR MAX AMP DESCRIPTION Spare 15 41 Gray 15 Power Awning 1 Purple 15 Bedroom lights Television Fan 2 Yellow 20 Bath amp vanity lights furnace water heater 4 Brown 15 Aisle galley under hood lights 5 Blue 15 Bath fan refrigerator TV booster RS reading lights Fan 6 Red 15 Storage compartment lights 16 Black 20 Step patio dinette and 1 2 3 ceiling lights 9 Green 20
17. 6 000 Lbs 6 000 Lbs Gross Axle Ratings Rear 10 000 Lbs 12 000 Lbs 12 000 Lbs 12 000 Lbs Fuel Tank 60 Gal 75 Gal 75 Gal 75 Gal Gross Vehicular Weight Rating GVWR is the maximum permissible weight of this fully loaded motorhome Unit Base Weight UBW is the dry weight of the base unit with the bedroom group full fuel and w o options or fluids Net Carrying Capacity NCC is equal to GVWR minus UBW Gross Combination Weight Rating GCWR means the maximum allowable loaded weight of this motorhome and any towed trailer or towed vehicle Sleeping Capacity Weight Rating SCWR is the manufacturer s designated number of sleeping positions multiplied by 154 pounds 70 kilograms Gross Axle Weight Rating GA WR is the value specified as the load carrying capacity of a single axle system as measured at the tire ground interfaces WARNING The towing vehicle s braking system is rated for operation at GVWR GROSS VEHICLE WEIGHT RATING NOT at the GCWR GROSS COMBINED WEIGHT RATING A separate functioning brake system is required for any towed vehicles or trailers weighing more than 1000 Ibs 450 kg when fully loaded NEVER exceed the GVWR GROSS VEHICLE WEIGHT RATING or the GAWR GROSS AXLE WEIGHT RATING specified on a motorhome certification label WARNING Do not exceed the Gross Axle Weight Ratings the Gross Vehicle Weight Rating or the Gross Combined Weight Rating when loading your vehicle Failure to heed any part of
18. G 28 AIRSTREAM LAND YACHT GAS STORAGE AND WINTERIZING When storing your motorhome for a short or long period use the same precautions as you would in your own home in regard to perishables ventilation and rain protection In addition for prolonged storage periods flush out all the drain lines and the holding tanks Also drain the entire water system including the water heater and the water storage tank Instructions for draining the water system are explained in the following paragraphs on winterizing Twice a year or after a long storage period we suggest you take your unit into your Airstream dealer for a check up and cleaning of the gas operated appliances Living Area The main consideration in winterizing is to guard against freezing damage to the hot and cold water systems the waste drain system including the traps the waste holding tanks the water heater and the batteries To completely winterize your motorhome follow this procedure 1 Level the motorhome from side to side and front to rear Open all faucets 2 Turn the water pump switch to the OFF position 3 Open all drain valves See Drain and High Pressure Water Valves in this section 4 Follow winterizing instructions for your toilet in the toilet section of this manual 5 While the water is draining from the system depress hand spray thumb button on the telephone showerhead and drain all the water Unscrew the head on spray unit and store 6 After the water
19. LAND YACHT GAS Moen Two Handle Lavatory Faucet Moen Model 4720 USA Canada Moen Inc Moen Inc 25300 AL Moen Dr 2816 Route Bristol Oakville North Olmstead OH 44070 8022 Ontario L6H5S7 1 800 Buy Moen 289 6636 1 800 465 6130 Toronto 905 829 3400 Care Instructions for the Non Tarnish Finish As with any fine polished surface your faucet will retain its shine for years to come with proper care The LifeShine TM finish on this faucet does not require the extraordinary work needed to maintain most fine polished brass finishes Be sure to read and follow usage instructions enclosed with any scour pad or scrub sponge before use e Caution Do not use pads or sponges that specifically do not recommend use for cleaning polished surfaces e Caution Many pads or sponges with green fibrous surface such as Scotch Brite TM heavy duty scrub sponges contain microscopic mineral particles that can scratch nearly all polished surfaces including this faucet finish The LifeShine TM finish can be cleaned with most household cleaners including mild abrasives when used according to their manufacturers instructions for use e Rinse any strong cleaners off immediately after use to maintain the LifeShine TM finish luster Mild scrubbing with fine steel wool 0000 grade can remove built up dirt or water stains Visible water spots on this highly lustrous and reflective finish can be easily wiped off with a cloth dampened with water or with gl
20. TUBING COPPER 3 800 7 22 600000 TUBING COPPER 3 800 25 10 601407 0 i eSCHM40 BLPIPE 200 LG 9 601407 23 1 45 BLPIPE 2300 LG 8 601407 22 1 P SCH 4g BLPIPE 93 25 LG 71600435 FORGED FLARE NUTS BIN _ 6 601412 08 CONMECTDR M 50 PIPE TO 38 TUBE 31601409 uve TEES s 3 varer RANGE rer war amv fun cs Airstream er E GAS SYSTEM ines heme 242422 BIG Typical Plumbing Diagram G 17 AIRSTREAM LAND YACHT GAS DRAIN AND HIGH PRESSURE WATER VALVES Your Land Yacht motorhome has several water line and tank drain and shut off valves Drain Valves On the 30 and 33 models 3 valves are located under the double bed behind the hinged door If you have a twin bed model these 3 valves would be located under the curbside twin bed behind the lower access door at the front edge of the bed base The 26 model has 3 valves located in the roadside rear lower compartment One each for draining hot and cold water lines and the third drains the water tank 1 drain valve or plug on all models is located on the water heater exterior and is accessible through the water heater access door Hot Water heater Bypass 3 more valves are for the water heater by pass system Access 26 foot 30 foot pull off panel below wardrobe 33 foot ope
21. The electronic indicator will signal when filter replacement is necessary e Use only MicroTech 400 or 600 filter cartridges with the PureTouch Classic Filtering Faucet System e Filter flow rate 4 5 gpm at rated pressure 20 psi min 125 psi max Water Temperature Minimum Maximum faucet operating temperature 40 degrees 150 degrees e CAUTION Do not filter water above 100degrees F MicroTech Filter Flushing Instructions e New MicroTech Filter Cartridge Allow cold water to run through a new filter for 5 minutes to flush out any loose carbon particles Once these small black specks are washed out the filter is ready for use e Daily Use Allow cold water to run through the filter for 10 15 seconds prior to first use If the filter has not been used for two days run cold water through the filter for 60 seconds prior to use Questions Ifyou have any questions please call Moen s toll free help lines 1 877 DRINK H20 Monday through Friday 8 00 a m to 8 00 P M 1 877 374 6542 Saturday 8 00 a m to 6 30 p m G 1 1 AIRSTREAM LAND YACHT GAS PARTS DESCRIPTION Solid Handle Body Set Screw Plug Button Dome amp Pivot Retainer Assembly Cartridge Screw Handle Adapter amp Connector Assembly 2 Ver Pivot Stop Spout Retaining Nut Bearing Washer O S BA 0 D Washer 11 Retainer Clip 12 1225 Cartridge 13 Filter Cartridge Uc WY
22. WATER READY FOR FULL READY FOR EMPTY SELECT TANK DIAGNOSTICS MONITOR DISPLAY IG FRESH WATER G GRAY WATER 1 GRAY WATER 2 BLACK WATER READY FOR FULL READY FOR EMPTY SELECT TANK DIAGNOSTICS AIRSTREAM LAND YACHT GAS STEP 5 Action Fill all tanks to the level that you want the monitor to report full Maximum suggested is liquid about I inch below the top of the tank and the maximum is 4 inches above the empty level When all tanks are set to the desired level press and release the status button I time Result Display will go blank for a few moments while the full values are being read When the system has completed reading the full values Fresh Water Gray Water 1 Gray Water 2 Black Water and LP Gas will light All other LED s will turn off If a system has passed calibration the LED beside it will light Green If a system was not installed the LED beside it will light yellow and that system will not be reported in normal operation If a system fails calibration the LED beside it MONITOR DISPLAY will light red and that system will not be reported in normal operation In the event that a system fails calibration turn off G FRESH WATER the monitor and repeat calibration procedure The most likely cause for a failure is that the full level was not set the G GRAY WATER 1 minimum of 4 inches above the empty level If all installed GRAY WATER 2 systems display a green LED proceed to
23. White LPG Sensor 90 ohm Fresh Fresh Tank Sensor Gray 1 Gray 1 Sensor Gray 2 Gray 2 Sensor Black Black Sensor AIRSTREAM LAND YACHT GAS MICROPULSE SYSTEMS MONITOR OPERATION INSTRUCTIONS This example shows the monitor reporting the following MONITOR DISPLAY Fresh Water 1 8 to Empty Gray Water 1 Empty to 5 8 IR FRESH WATER Gray Water 2 3 4 IG GRAY WATER 1 Black Water Empty to 5 8 LP Gas 1 4 GRAY WATER 2 Battery Empty to 5 8 G BLACK WATER On all diagrams the Letters R Red Y Yellow G Green Blank no LED lit NORMAL OPERATION The MicroPulse Monitor will display the condition of each system at all times The tri color LED beside the system will indicate the condition of the system using the following color code Fresh Water LP Gas Battery are as follows Green LED 3 8 to Full Yellow LED 1 4 Red LED 1 8 to Empty Gray Water Black Water are as follows Green LED Empty to 5 8 Yellow LED 3 4 Red LED 7 8 to Full TO OBTAIN EXACT READING To obtain an exact reading of all systems press and release the status button one time The monitor will flash the LED beside the system it is about to report It will than display the exact condition of that system by lighting the bar graph from Empty to Full The monitor will display the exact condition of each system and then return to normal operation mode To obtain an exact reading of an individual system press and release the status button un
24. a reference disconnect outlet boxes one it a time starting at the box furthest from the distribution panel After disconnecting each box check for continuity between the black wire and ground or common white wire on the distribution panel side of the circuit When a continuity light or ohmmeter indicates no continuity the short is either in the receptacle just removed or the section of Romex wire between this receptacle and the previous receptacle removed 4 Examples of a short are A The black wire of the 120V system contacting the white wire bare wire or grounded surface B B An internal short in a 120V appliance AIRSTREAM LAND YACHT GAS Locating Shorts and Opens Cont Any damaged wire must be replaced The National Electric Code does not permit splicing 120V wiring outside an outlet box or junction box Also the wire must not be exposed to an area such as a sharp metal edge that may damage the wire OPENS 1 Check all receptacles and components for voltage on the circuit that has the open 2 If all receptacles and components of the circuit are without power begin to look for the open in the distribution panel 3 Inspect for loose or corroded connections and a faulty circuit breaker 4 Check for power on both ends of circuit breaker If there is no power on the inlet side of the circuit breaker the open is between the power cord s male connector and the distribution panel 5 The open can be isolated by noting the o
25. and ammonia gas or in severe cases completely block it resulting in a loss of cooling Any time the vehicle is parked for several hours with the refrigerator operating the vehicle should be leveled to prevent this loss of cooling The vehicle needs to be leveled only so it is comfortable to live in no noticeable sloping of floor or walls When the vehicle is moving the leveling is not critical as the rolling and pitching movement of the vehicle will pass to either side of level keeping the liquid ammonia from accumulating in the evaporator tubing OPERATION The refrigerator requires 12 volt current to operate even if running on LP or 110 volt modes The 12 volt is used to power the circuit board that directs the refrigerator functions When running in a mode such as LP it means the heat source by far the largest power requirement to evaporate the ammonia is being provided by an LP Gas burner J 3 AIRSTREAM LAND YACHT GAS RANGE Manufacturer Magic Chef 28812 Phillips Street Elkhart Indiana 46514 219 264 9578 People using gas ranges in their home will find little difference in the operation of the range in the motorhome Other customers used to electric ranges may be a little apprehensive at first but will quickly gain confidence The basic operation of the gas ranges have been the same for many years but please be sure to read all the directions furnished by the manufacturer and located in the Owner s Packet Excellent
26. and sealant used in external seams and joints such as window frames light bezels beltline and rub rail molding etc be checked regularly If this material has dried out and becomes cracked or checked or if a portion has fallen out it should be replaced with fresh material to prevent possible rain leaks Caulking and sealing material is available from your motorhome dealer Main Door Lock The door lock on your motorhome operates in the same manner as the locks used on most automobiles Locking the latch actually disengages the linkage between the handles and the latch This prevents forced entry by using large pliers on the lock handle We urge you to keep an extra set of keys for both the door lock and the ignition hidden somewhere on the exterior of the coach We probably receive a dozen calls a year from people who have lost keys or locked them in the coach Your keys will overcome the keyless lock system used on the dead bolt E 1 AIRSTREAM LAND YACHT GAS Occasionally you might find the latch catch item 3 in the diagram below out of time This simply means it has been bumped and has flipped to the closed position when the door is still open To re time hold the door handle in the open position then pull out and down on the latch catch It should flip to the open position as shown in the illustration LOCK ASSEMBLY DRIVERS DOOR 1 Mounting plate Door Lock 2 Lock Handle Inside 3 Latch Catch 4 Keeper Rod Linkage
27. can wear differently depending on the types of roads driven your driving habits etc To obtain the longest tire life you should INSPECT AND ROTATE your tires regularly See Tire Rotation Illustration below Many automotive dealers and tire dealers will perform a free tire inspection to look for uneven or abnormal tire wear Tires should be rotated every 6 000 to 8 000 miles For the longest tire life any time irregular wear is seen have the tires checked alignment checked and tires rotated by your truck or tire dealer Have the cause of uneven wear corrected The outer tire of a pair in dual wheel installations generally wears faster than the inner tire When vehicles are driven continuously on high crown roads an increase in air pressure of 5 psi on the outside tire of each dual produces maximum tire life Be sure to return to recommended pressure when no longer driving under these conditions After rotation be sure to check wheel nut tightness and to adjust the tire pressures front and rear See tire inflation warning on page C 13 AN Warning Wheel nuts should be tightened at certain intervals See Lug Nut Tightening on previous page of this manual and read your chassis manual on this subject FOR SAME BRAND LOAD RANGE AND TREAD PATTERN ON ALL TIRES n FRONT AND REAR FRONT REAR AND SPARE C 10 AIRSTREAM LAND YACHT GAS TIRE SUPPORT Since motorhomes may sit for long periods of time it is i
28. damage AIRSTREAM LAND YACHT GAS TIRE INFLATION INFORMATION AN Warning Your vehicle is equipped with a tire that is an all steel radial All steel radial tires utilize steel cords in the sidewalls and also require increased inflation pressures Has such they cannot be treated like normal light truck tires Personnel trained supervised and equipped according to Federal Occupational Safety and Health Administration OSHA regulations must perform tire service including adjusting tire pressure For example during a procedure involving tire inflation the technician or individual must utilize a remote inflation device and insure that all persons are clear of the trajectory area An inflated tire and rim can be very dangerous if improperly used serviced or maintained To avoid serious injury never attempt to re inflate a tire which has been run flat or seriously under inflated without first removing a tire from the wheel assembly for inspection Do not attempt to add air to tires or replace tires or wheels without first taking precautions to protect persons and property C 13 AIRSTREAM LAND YACHT GAS ELECTRIC STEP KWIKEE STEP SERIES 28 Manufacturer Kwikee Products Company Division of Ashton Corporation P O Box 638 Drain Oregon 97435 Phone 503 836 2126 The step is easy and convenient to operate Just inside the main door is a wall switch for the step When traveling leave the switch in the ON position the st
29. detector and it should be returned for service FALSE ALARMS Smoke detectors are designed to minimize false alarms Cigarette smoke will not normally set off the alarm unless the smoke is blown directly into the detector Combustion particles from cooking may set off the alarm if the detector is located close to the cooking area Large quantities of combustible particles are generated from spills or when broiling Using the fan on a range hood which vents to the outside non recirculating type will also help remove these combustible products from the kitchen MODEL 0916 HAS A HUSH CONTROL that is extremely useful in a kitchen area or other areas prone to nuisance alarms For more information refer to OPERATION AND TESTING If the detector does alarm check for fires first If a fire is discovered get out and call the fire department If no fire is present check to see if other reasons may have caused the alarm MAINTENANCE BATTERY REPLACEMENT To replace the battery remove the detector from the mounting plate by rotating the detector in the direction of the OFF ar AIRSTREAM LAND YACHT GAS CLEANING YOUR DETECTOR To clean your detector remove it from the mounting bracket as outlined in the beginning of this section You can clean the interior of your detector sensing chamber by using your vacuum cleaner hose and vacuuming through the openings around the perimeter of the detector The outside of the detector can be wiped wit
30. fill fresh water tank water pump pump filter hot and cold water lines water heater drain valves and faucets To operate the system WATER HEATER BY PASS VALVES Turn the water heater by pass valves to normal flow position The by pass valves are located under the lavatory cabinet in the 33 model accessed by removing the lower shelf vertical close out under the wardrobe in the 30 model pull off the small raised panel door held on by pressure latches below the wardrobe door and under the bedroom wardrobe in the 26 open the lower door For normal operation open valves A and C and close valve B Reverse the valves and drain the water heater for winterization Check all drain valves and turn them to the closed position as needed Fill the water tank by opening the exterior door marked water fill remove screw cap and pull the vent plug A garden hose can now be inserted It s a good idea to let the water run through the hose for a short time to flush it out RVers sometimes fill their tanks with home water to avoid strange water that may be distasteful to them on short outings Remember the more water you carry in the fresh water tank the less cargo carrying capacity you have for other items The amount of water in the tank may be checked on the Monitor Panel or you may fill the tank until water overflows out of the fill Open the hot side of the galley or lavatory faucet and fill the water heater by turning on
31. for complete instructions and cautions Parts Ordering Please contact Sealand at 1 800 321 9886 Monday through Friday from 8 00 a m to 5 00 p m for the location of the Sealand Authorized Service Center nearest you or e mail Sealand Sealandtechnology com Have toilet model number serial number and the part you need number and description ready to speed up the ordering process G 22 AIRSTREAM LAND YACHT GAS Sealand Toilet Traveler Lite Series Model 111 1 344089 Seat assembly Bone 2 310791 Chins bowl kit Bone 3 310048 Ring and half clamp kit Bone 4 316140 Teflon amp Rubber seal kit 5 310802 Base kit Bone includes 3 4 6 7 9 10 11 12 13 and 17 6 381162 Ball shaft and cartridge kit 7 341549 Floor flange seal 8 Floor flange see drain plumbing section of this book 9 310064 Floor bolt mounting kit 10 310118 Pedal cover kit 11 314349 Water valve kit 13 340825 Flush lever 14 340177 Supply hose Bone 15 310687 Vacuum breaker kit 15a 319054 Vacuum breaker kit w spray 15b 340683 Hand spray white 15c 230335 Vacuum breaker used w spray 17 16 310796 Vacuum breaker cover kit Bone 17 310109 Pedestal cover kit Bone Sealand Technology is ready to assist you in the event service is required Before calling please have the following information available 1 Toilet Model Number 2 Serial Number 3 Part Number Description and Quantity For the name of the nearest autho
32. handle adapter and handle connector assembly 6 2 Turn cartridge stem around so that the notch is turned one half turn or 180 degrees 3 Reinstall as follows Be sure retainer clip 11 is present on cartridge stem and raised edge of pivot stop 7 faces front Note orientation of handle adapter amp connector assembly 6 in the exploded view Completely tighten cartridge screw 5 to prevent unwanted closure of faucet Thread on dome clockwise until hand tight Reinstall handle body 1 set screw 2 and plug button 3 PROBLEM Faucet head is loose and water flows freely from between the head and spout SOLUTION The head was not locked in place correctly Reinstall the head and filter assembly PROBLEM Slow or uneven water flow in filtered mode SOLUTION Filter outlet may be clogged 1 Remove filter outlet nut flush out carbon particles 2 Filter cartridge may be clogged with captured contaminants Replace filter cartridge If problem persists call Moen Help line at 1 877 DRINK H20 1 877 374 6542 PROBLEM Electronic display doesn t function SOLUTION Replace battery CARE AND MAINTENANCE All that is needed to clean your faucet is a soft damp cloth Moen does not recommend the use of scour pads cleansers or chemicals The abrasive nature of these substances could damage the faucet s finish A non abrasive car wax will help to protect the finish DO NOT SUBMERGE OR PLACE FAUCET HEAD IN DISHWASHER AIRSTREAM
33. in When all READY FOR FULL installed systems are displaying a green LED proceed to step 3 ll READY FOR EMPTY TANK Display after completion of step 2 G DIAGNOSTICS On all diagrams the Letters R Red G Green Y Yellow Blank no LED lit AIRSTREAM LAND YACHT GAS STEP 3 Action Press and release the status switch 1 time Display will light Fresh Water Gray Water 1 Gray Water 2 Black Water and Select Tank LED s green After 2 seconds the Select Tank LED will turn off and the ready for empty LED will turn light green Proceed to step 4 On all diagrams the Letters R Red Y Yellow Blank no LED lit Display after completion of step 3 On all diagrams the Letters R Red G Green Y Yellow Blank no LED lit STEP 4 Action Fill all water holding tanks to the level that you want the monitor to report empty Minimum suggested is liquid just covering the sensor When all tanks are set to the desired level press and release the status button 1 time Result Display will go blank for a few moments while the empty values are being read When the system has completed reading the empty values Fresh Water Gray Water 1 Gray Water 2 Black Water and the Ready For Full LED s will light green Proceed to step 5 Display after completion of step 4 On all diagrams the Letters R Red G Green Y Yellow Blank no LED lit MONITOR DISPLAY FRESH WATER GRAY WATER 1 GRAY WATER 2 BLACK
34. inflation on page 13 Turn off LPG valve on LPG tank Check that sewer connections city water hookup TV cable and all exterior components are unhooked and properly stowed away Check that all external compartments and filler openings are properly closed and or locked Check that items stored on exterior of vehicle are securely tied down Would any items stored on exterior of vehicle present a clearance problem Lower and secure awnings TV antenna satellite dish Follow all chassis manufacturers recommendations on checking and filling chassis fluid levels INTERIOR CHECK LIST BEFORE DRIVING OFF 1 Den 12 It is important that main door and cab door be completely closed and locked during travel As an added precaution we recommend the dead bolt also be locked on the main door Turn off living area water pump Check that refrigerator door is fastened Check that nothing heavy is stored in overhead or high cabinets which could fall out and cause injury Heavy items should be stored in low cabinets Stow folding and pedestal tables Check that counter tops range top credenza tops and shelves are clear of even small items that could become projectiles in an accident Do not cook while under way Hot food or liquid could scald due to a sudden stop or accident Be sure all LPG controls on furnace range oven and gas electric refrigerator are turned Off Check that any internal stowage i
35. intended for everyday use But if you re going to be away from your coach for more than 3 or 4 days and it s not plugged into 110 volt current just flip the switches off on the way out and you re assured of fresh batteries when you return The converter is located in the roadside front exterior compartment in the 30 FT and 33 FT Models Remove the front inside panel for access It is under the front dinette seat in the 26 FT Model remove the seat top for access The hydraulic pump for the leveling jacks is located under the front hood There are two sets of fuses controlling circuits of Airstream installed equipment in the roadside front exterior compartment see page H 4 The main interior circuits are fused in the 12 volt distribution panel in and beside the Battery Control Center The brightly colored fuses pull straight out from the face of the panel Replacement fuses are available at automotive stores and most service stations There are diagrams on the lids of both fuse panels Another fuse panel for the chassis fuses is located to the left of the steering column The functions of these fuses are marked directly on the face of the fuse block See your Chassis Drivers Manual for further information on chassis items A diagram is in this section shows where Airstream picks up power for automotive accessories The diagrams for these fuse panels are shown later in this section AIRSTREAM LAND YACHT GAS 12 Volt Operation The only thing y
36. must be placed in the proper order to achieve safe storage as you travel The cable and support system must be free from defects and in good working order The complete system should be checked before each trip and every 1000 miles during a trip for any signs of wear or possible failure Please contact your dealer or Airstream Customer Service if you have any questions on the use of this equipment C 8 AIRSTREAM LAND YACHT GAS TIRE CHANGING cont When removing a steel wheel rim to change a tire loosen all wheel nuts approximately flush with end of stud then tap clamp ring to loosen rim Do not remove nuts until clamp rings are free or clamp ring may fly off of stud When installing rim be sure pins on clamp ring face outboard Then tighten attaching nuts alternately and evenly to avoid excessive wheel run out See torque values and sequence diagram See tire inflation warning on page C 13 LUG NUT TIGHTENING A Warning WHEN A UNIT IS NEW OR WHEN EVER A WHEEL WHEEL BOLT OR WHEEL NUT IS REPLACED THE WHEEL NUT TORQUE MUST BE CHECKED AT 100 1 000 AND 6 000 MILES AND EVERY 6 000 MILES THEREAFTER TIGHTENING SEQUENCE Torque 175 ft Ibs JACK PLACEMENT Place the jack under the control arm to change front tires Place the jack under the dual wheeled axle close to the tires being changed for rear tires on dual wheeled axles C 9 AIRSTREAM LAND YACHT GAS TIRE ROTATION Front and rear tires perform different jobs and
37. program is available at no charge to you to settle unresolved warranty disputes for recreational vehicles This dispute resolution program reviews eligible product and service related complaints involving warranty covered components To find out more about this program or to request an application brochure please call the Arbitration Administration office toll free 800 279 5343 For recreational vehicles purchased in the State of California The CAP RV program operates as a certified mechanism under the review of the California Arbitration Certification Program You must utilize the arbitration program before claiming rights conferred by 15 USC section 2310 Uniform Commercial Code or Civil Code section 1793 22 b Son Beverly Warranty Act You are not required to use the program if you choose to seek redress by pursuing rights and remedies not created by those laws CHANGES IN DESIGN Airstream Inc reserves the right to make changes in design and improvements upon its product without imposing my obligation upon itself to install the same upon its products theretofore manufactured This warranty gives you specific legal rights and you may also have other rights which vary from state to state WARRANTY EXPLANATION Along with your new Airstream motorhome you have purchased the Airstream Limited Warranty Read your Limited Warranty carefully It contains the entire agreement with respect to Airstream s obligation on the Limited Warranty o
38. recreational vehicle The use of this equipment inside the recreational vehicle may cause fires or asphyxiation gt Warning A Warning Label has been located near the LP gas container This label reads DO NOT FILL CONTAINER S TO MORE THAN 80 PERCENT OF CAPACITY Overfilling the LP gas container can result in uncontrolled gas flow that can cause fire or explosion A properly filled container will contain approximately 80 percent of its volume as liquid LP gas Warning Do not bring or store LP gas containers gasoline or other flammable liquids ide the vehicle because a fire or explosion may result E Warning e If you smell gas Extinguish any open flames pilot lights and all smoking materials Do not touch electrical switches Shut off the gas supply at the tank valve s or gas supply connection Open doors and other ventilating openings Leave the area until odor clears PX Have the gas system checked and leakage source corrected before using again A Warning LP gas regulators must always be installed with the diaphragm vent facing downward Regulators that are not in compartments have been equipped with a protective cover Make sure that regulator vent faces downward and that cover is kept in place to minimize vent blockage that could result in excessive gas pressure causing fire or explosion AIRSTREAM LAND YACHT GAS LP TANK INSTALLATION The regulator at the L P tank is under a black plastic cover The
39. reduces the pressure build up significantly For fun watch the sequence of events your family goes through when you park the motorhome and ignite the water heater More than likely someone will run water and relieve the pressure without even realizing it J 5 AIRSTREAM LAND YACHT GAS HIGH VOLUME ROOF VENT OPTIONAL Manufacturer FAN TASTIC VENT CORP 4349 S Dort Hwy Burton MI 48529 1 313 742 0330 1 800 521 0298 The optional high volume roof vent system is designed to quickly exhaust stale hot air and draw in fresh air It s great to use when the outside temperature really doesn t call for air conditioning but heat has built up in your coach OPERATING INSTRUCTIONS 1 Rotate 3 speed switch to desired position 0 off 1 2 and 3 The 3 speed switch must be set at 1 2 or 3 to activate appliance 2 Rotate thermostat knob toward 40 cooler until dome begins operating 3 When equipped with reverse switch there is a neutral off position Fan motor will not operate when in out switch is in its center off position The dome will however operate up and down automatically as long as the 3 speed switch remains on 4 To determine desired temperature setting a Use the wall thermometer on furnace thermostat or any interior temperature indicator b Operate fan until interior comfort level is achieved Rotate thermostat knob toward 110 symbol on label until dome begins closing You now have the location for normal se
40. smoke from cooking activates the alarm The smoke detector is desensitized by pushing the HUSH button on the smoke detector cover If the smoke is not too dense the alarm will silence immediately and Chirp every 30 40 seconds for approximately 7 minutes This indicates that the alarm is in a temporarily desensitized condition The smoke alarm will automatically reset after approximately 7 minutes and sound the alarm if particles of combustion are still present The HUSH feature can be used repeatedly until the air has been cleared of the condition causing the alarm NOTE DENSE SMOKE WILL OVERRIDE THE HUSH CONTROL FEATURE AND SOUND A CONTINUOUS ALARM AIRSTREAM LAND YACHT GAS CAUTION BEFORE USING THE ALARM HUSH FEATURE IDENTIFY THE SOURCE OF THE SMOKE AND BE CERTAIN A SAFE CONDITION EXISTS FLASHING L E D LIGHT This smoke detector is equipped with a flashing red indicator light The light is located under the test button and will flash every 30 40 seconds to indicate that the smoke detector is receiving power TESTING Test by pushing the test button on the cover and holding it down for a minimum of 2 seconds This will sound the alarm if all the electronic circuitry horn and battery are working If no alarm sounds the unit has defective batteries or other failure You can also test the alarm by blowing smoke into it TEST THE ALARM WEEKLY TO ENSURE PROPER OPERATION Erratic or low sound coming from your alarm may indicate a defective
41. step 155 SERVICE There are four major components operating the door locks control module receiver dash switch relay and drive motors The control module is mounted on the inside wall just behind the main door The relay operates in conjunction with the dash switch and is located up under the left hand side of the dash The drive motors located at each lock are polarity sensitive When testing you ll find the wires at the drive motors will switch from positive to negative and vice versus as the key fob or dash switch is being operated When using the dash switch the relay under the dash performs the polarity switching functions and the control module receiver serves the same function when the key fob is used A detailed wire layout is provided in the electrical section of this manual E 3 AIRSTREAM LAND YACHT GAS ROOF LADDER Lifting up on the bottom section of the ladder AIRSTREAM LAND YACHT GAS INTERIOR The luxurious interior of your Airstream motorhome has been designed for comfort convenience durability and appearance An understanding of the operational procedures and maintenance techniques of the interior appointments will add to your pleasures as well as to the long life of your motorhome Lounges To convert the Deluxe Sofa into a bed pull straight up and remove armrest grasp the front edge of the seat raise and pull it toward the aisle of the motorhome The backrest will slide down into place automatically
42. the bedroom wardrobe in the 26 open the lower door For normal operation open valves A and C and close valve B Reverse the valves and drain the water heater for winterization G 30 AIRSTREAM LAND YACHT GAS DRAIN AND WASTE SYSTEM The drain and waste system of your motorhome includes waste holding tanks made from molded plastic The MAIN HOLDING TANK enables you to use the toilet for several days away from disposal facilities The wastewater from the sink shower and bath and lavatory drain into the AUXILIARY HOLDING TANK Each tank has its own dump valve however both tanks drain through a common outlet Therefore you need to make only one connection when hooking up in a motorhome park with sewer facilities Monitor Panel Check your monitor panel frequently When the MAIN HOLDING TANK is completely full sewage cannot be emptied from the toilet bowl If the AUXILIARY HOLDING TANK is overfilled drain water will backup into the tub and cause an unpleasant cleaning job Tank one on the monitor panel is the black tank and tank two is the auxiliary or gray tank Never drain the tanks at any place other than an approved dumping station To empty both tanks attach the sewer hose by pressing the bayonet fitting onto the outlet adapter and rotate clockwise until it feels solid and secure Attach the outlet end of the hose to the sewage outlet making sure that the hose is placed so that it will drain completely The dump valve
43. with lubricating qualities will help ease the slide valve operation The only cleaning agents that can be used without causing harm to the system are household ammonia and tri sodium phosphate in small quantities Do not use any product that contains any portion of petroleum distillates This attacks the rubber seals of your toilet and dump valve Also do not use any dish detergent or abrasive cleaners All products should be marked approved for ABS drainage systems When winterizing the drains use only recreational vehicle plumbing type antifreeze These are sold through your dealer G 32 AIRSTREAM LAND YACHT GAS ELECTRICAL SYSTEM BATTERY CONTROL CENTER The Intellitec Battery Control Center is a centralized power switching fusing and distribution center Power from both the chassis and the coach batteries are feed into the control center box All servicing with in this box should be done only by a qualified Service Technician Page H 3 has a drawing of the 12 volt chassis wiring system used in your motor home Your motorhome is equipped with three batteries One battery will be for the engine and the other two batteries coach for the interior 12 volt circuits All batteries are located under the front hood The Engine battery is used for starting the engine and operating the headlights taillights running lights instrument panel lighting automotive air conditioning and other accessories The alternator charges all the batteries wh
44. 3LV3H NYYOVIG H 8 AIRSTREAM LAND YACHT GAS MONITOR PANEL Micropulse Systems Monitor CATCON PRODUCTS INC 817 921 2188 techsupport O catconproducts com SYSTEMS ESMEE MONITOR FRESH WATER GRAY WATER 1 GRAY WATER 2 e BLACK WATER a gt LP GAS BATTERY Ld The MicroPulse System makes use of a single solid state sensor per tank The MicroPulse sensor measures the static head pressure at the bottom of the tank and transmits this information to the MicroPulse System Monitor Knowing this pressure value after a one time calibration has been performed the MicroPulse System will calculate and accurately display the tank level in 1 8 increment A single sensor is installed on the sidewall of each tank near the bottom via a 3 4 female NPT spin in thread The sensor is solid state there are no moving parts to wear or maintain Because the principle of operation does not involve any electrical current flow through the tanks contents conducted or induced the nature of the fluid in the tank is unimportant The monitor system has been calibrated at the factory and should never need another calibration If you feel the system is not operating correctly please contact CATCON Products or a local Airstream dealer The following instructions are provided for qualified service technicians MONITOR WIRE CONNECTIONS Red 12VDC Battery Only Black Ground Battery Only Purple Water Pump 15A 12VDC
45. 4 Water teet G 14 Water Heater eese J 5 Water Hookup D 9 G 10 Water Pump G 7 H 2 Water Strainer G 5 G 6 Water System G 5 G 29 Water Valves neninn G 18 Weighing uen een B 1 B 6 Wheel eae K 2 Winterizing 2 22 0 G 29 Winter Traveling D 7 Wiring 110 Volt a I 1 Airstream Land Yacht Gas Owner s Manual O Airstream Inc 2004
46. 8 600155 601263 600538 600308 601305 601440 601199 _ 601202 600027 600030 601198 601308 601160 01 Continuous Waste I 1 2 P Trap ABS 1 1 2 In Adapt Swivel Strainer 1 25 62691 Tee Bi Directional Cleanout I 1 2 Plug Cleanout 1 1 2 Bushing 1 5 x 1 25 ABS Vent V 200 Automatic Adapter ABS Female Sloan 2891 1 25 45 Wye 1 25 90 Degree XLT St Ell 1 25 90 XLT P Trap W Union 1 25 62615 1 25 45 St 1 25 45 1 5 x 1 25 Reducing Female Adapter Sanitary Tee 1 25 All Hub 61508 1 25 90 Vent Ell Pipe ABS DVW 1 25 G 27 AIRSTREAM LAND YACHT GAS PLUMBING DRAIN WATER 26 FT 943570 NOTES COMMON VENT 1 SLOPE TRAP ARMS 1 4 PER THRU ROOF EDOT 2 SLOPE DRAIN LINES 1 8 PER 1 FOOT MINIMUM Ab Un 3 SECURE LINES MIN DF EVERY 3 FEET WITH RUBBER LINED VENTS CUNNECTED CLAMPS PUE E 4 ATTACH AUTO VENTS HAND LEVAL OF THE TIGHT ONLY HIGHEST FICTURE BLACK TANK VENT 5 ALL OTHER FITTINGS AND PIPE ARE ABS OF C TE oo 0 ca d GREY TANK VENT TU BE INSTALLED FLOOR SET 1 60160 02 TEM PART NUME 1 3 1 9 1 4 DLERANCES NEXT ASS Y d FIR 16 601160 04 PIPE ABS DVW 3 time 15 601482 DUMP VALVE ROTATING ASSY AB 14 60005 7 FLANGE FLOOR THREADED SCALE n 13600094 wre wea te NTS 042 10 0
47. AIRSTREAM AN AMERICAN LEGEND LAND YACHT MOTORHOME OWNERS MANUAL AIRSTREAM LAND YACHT GAS OWNERS MANUAL To place the great wide world at your doorstep for you who yearn to travel with all the comforts of home To provide a more satisfying meaningful way of travel that offers complete travel independence wherever and whenever you choose to go or stay To keep alive and make real an enduring promise of high adventure and faraway lands of rediscovering old places and new interests To open a whole world of new experiences a new dimension in enjoyment where travel adventure and good fellowship are your constant companions To encourage clubs and rallies that provide an endless source of friendship travel fun and personal expression To lead caravans wherever the four winds blow over twinkling boulevards across trackless deserts to the traveled and untraveled corners of the earth To play some part in promoting international goodwill and understanding among the peoples of the world through person to person contact To refine and perfect our product by continuous travel testing over the highways and byways of the world To strive endlessly to stir the venturesome spirit that moves you to follow a rainbow to its end and thus make your travel dreams come true INTRODUCTION AIRSTREAM LAND YACHT GAS OWNERS MANUAL The Owners Manual for your new Airstream Motorhome is designed to respond to the mos
48. ATER HOOKUP Use a high pressure hose of at least V diameter It should be one that is tasteless odorless and non toxic designed for RV use The city water inlet is a standard garden hose thread We suggest you carry two lengths of hose This way you have the ability to reach 1 Water tank fill 3 Hose door hookups further away 2 City water hook up than normal plus you have a spare hose should one fail or become damaged unexpectedly Turn the water heater bypass to the normal flow position as described under self contained After hooking up the hose and turning on the city water valve provided in the park slowly open a faucet There will be a lot of spurts and sputtering until all the air is expelled from the motorhome system If the water heater is empty it will take some time before all the air is expelled and you get a steady flow of water at the faucet Once a steady flow is achieved at one faucet the others should be opened long enough to expel the air in the lines going to them Water pressure at some campgrounds may be low The water pump can be turned on to assist the city water pressure Be sure there is water in the fresh water tank It is not necessary to fill the tank the pump will only use the water that is needed out of the tank to bring the pressure up to the usual standard The water pump should be turned off when the motorhome is left unattended Your plumbing system has a built in pressure regulator to protec
49. Brilliance cleaner If you cannot find Brilliance in your area contact Sealand or your nearest dealer If Brilliance is not available you can also use Bar Keepers Friend cleanser It is not necessary to vigorously scrub with either product Please follow label instructions SEAL CLEANING after an extended time mineral deposits from hard water can build up under the edge of the rubber bow seal resulting in a slow leak down of water from the bowl To be event this mineral buildup periodically clean under the bowl seal with Brilliance cleanser WINTERIZING At the end of the season the Traveler or Traveler Lite toilet should winterized for storage by either draining or using potable water safe antifreeze and the system To drain 1 Thoroughly flush system with fresh water 2 Empty the holding tank 3 Shutoff water supply to go to sleep have the toilet and remove inlet waterline Do not remove brass camp on bottom of the valve 4 Press flush lever until all air is drained from the toilet To use antifreeze 1 Drain potable water tank 2 Add fresh water antifreeze to potable water tank 3 Flush potable water antifreeze and water makes cheer through toilet into the waste holding tank Each installation is different so amounts may vary User discretion is required to assure adequate protection 4 Empty holding tank Note use non toxic antifreeze designated for potable water systems See the Sealand toilet owner s manual
50. Center please contact the service manager for an appointment and kindly inform him if you are unable to keep the appointment date or wish to change it Service may be arranged at the Factory Service Center by contacting the Service Coordinator at Airstream Factory Service Center P O Box 629 419 W Pike Street Jackson Center Ohio 45334 0629 Phone 937 596 6111 Fax 937 596 6802 REPORTING SAFETY DEFECTS If you believe that your vehicle has a defect which could cause a crash or could cause injury or death you should immediately inform the National Highway Traffic Safety Administration NHTSA in addition to notifying Airstream Inc If NHTSA receives similar complaints it may open an investigation and if it finds that a safety defect exists in a group of vehicles it may order a recall and remedy campaign However NHTSA cannot become involved in individual problems between you your dealer or Airstream Inc To contact NHTSA you may either call the Auto Safety Hotline toll free at 1 800 424 9393 or 366 0123 in Washington D C area or write to NHTSA U S Department of Transportation Washington D C 20590 You can also obtain other information about motor vehicle safety from the Hotline A 5 AIRSTREAM LAND YACHT GAS MAINTENANCE SCHEDULE Warning FAILURE TO MAINTAIN YOUR COACH CAN CAUSE PREMATURE AND UNEXPECTED PARTS BREAKAGE AND OR ERRATIC OPERATION THAT MAY BE HAZARDOUS SERIOUS INJURY COULD RESULT FROM FAILURE TO HEED
51. In the kitchen area of your unit approximately six inches above the floor is the LP gas detector LP gas is a mixture of gases produced and sold commercially as a fuel for heating and cooking appliances LP gas is highly flammable and as a result can be explosive if ignited under certain circumstances LP gas is heavier than air and if confined in a closed space will accumulate close to the floor When the LP gas concentration in your unit exceeds 2000 PPM the detector will provide a visual and audible alarm by sounding a buzzer and flashing the red LED two times per second Warning Activation of this detector indicates the presence of LP gas which can cause an explosion and or fire This normally indicates a leak in the LP gas installation or a LP gas appliance Extinguish all open flames open your windows and door and evacuate the unit immediately Do not activate any electrical switch Turn off the LP at your gas bottle s DO NOT RE ENTER YOUR UNIT UNTIL A QUALIFIED REPAIR TECHNICIAN HAS CORRECTED THE PROBLEM OPERATION Your LP gas detector is wired directly to your vehicle battery and incorporates a 1 amp in line fuse When the device is operating normally the green LED will be lit CAUTION It is not recommended that the detector be disconnected from the battery during periods of storage There is a small heater on the sensor of the device which burns away impurities in the air during periods of normal use During periods when power is
52. LEEPING CAPACITY WEIGHT RATING IS THE MANUFACTURER S DESIGNATED NUMBER OF SLEEPING POSITIONS MULTIPLIED BY 154 POUNDS 70 KILOGRAMS CCC CARGO CARRYING CAPACITY IS EQUAL TO GVWR MINUS EACH OF THE FOLLOWING UVW FULL FRESH POTABLE WATER WEIGHT INCLUDING WATER HEATER FULL LP GAS WEIGHT AND SCWR CARGO CARRYING CAPACITY CCC COMPUTATION POUNDS KILOGRAMS EEE Eee duet bu MINUS 0 4 00 MINUS FRESH WATER WEIGHT OF GALLONS 8 3 LB GAL MINUS LP GAS WEIGHT OF GALLONS 4 5 LB GAL MINUS SCWR OF PERSONS 154 LB PERSON FOR THIS MOTORHOME itte DEALER INSTALLED EQUIPMENT AND TOWED VEHICLE TONGUE WEIGHT WILL REDUCE CCC CONSULT OWNER MANUAL S FOR SPECIFIC WEIGHING INSTRUCTIONS AND TOWING GUIDELINES CD 130 See specification section in this manual for weights and term definitions WEIGHT DISTRIBUTION The motorhomes have large fluid tanks and lots of storage areas It gives you great flexibility in loading With flexibility comes responsibility If you want to load down all the storage compartments the amount of fluids will have to be reduced Distribute your additional cargo as evenly as possible with the heaviest objects located as low as possible Do you really want to carry 750 pounds of water to a RV park 1 000 miles away and then hook up to a city water supply Even if you re going to the boondocks you can usually fill your water tank shortly before enter
53. NOT COVERED Airstream Inc does not accept any responsibility in connection with any of its motorhomes for additional equipment or accessories installed at any dealership or other place of business or by any other party Such installation of equipment or accessories by any other party will not be covered by the terms of this warranty IF REPAIRS ARE NEEDED If your motorhome needs repairs under the terms of the basic Airstream Limited Warranty you should 1 Take your motorhome to your selling dealer or other Authorized Airstream Dealer 2 If the dealer is incapable of making the repair request that he contact the Service Administration Department at Airstream Inc for technical assistance 3 If repairs are still not made the customer should contact AIRSTREAM INC 419 W Pike Street P O Box 629 Jackson Center Ohio 45334 0629 Attention Owner Relations Department Furnish the following information e The complete serial number of the motorhome e Mileage e Date of original purchase e Selling dealer e Nature of service problem and steps or service which have been performed The owner may be directed to another dealer at the owner s expense 4 If after taking the above steps repairs are still not complete the Airstream owner may request the motorhome be allowed to be brought to the Factory Service Center at the owner s expense DEALER REPRESENTATION EXCLUDED The full extent of the basic Airstream Limited Warranty is
54. RCUIT CIRCUIT CIRCUIT CIRCUIT CIRCUIT rao mz rom 7 O0 Q O m CIRCUIT 1 15 HACK BREAKER 12 2 RONEX W GROUND LEG 1 BEDROOM CONVERTER LIVING AREA CIRCUIT 2 20 ANP BREAKER 12 2 RONEX W GROUND LEG 1 FRONT A C CIRCUIT 3 15 BREAKER 12 2 ROMEX W GROUND LEG E MICROWAVE CIRCUIT 4 20 BREAKER 12 2 ROMEX W GROUND LEG 2 REAR A C CIRCUIT 5 15 AMP GFI BREAKER 12 2 ROMEX W GROUND LEG 1 BATH OUTSIDE REFER AND FRONT TY RECEPT CIRCUIT 6 15 BREAKER 12 2 ROMEX W GROUND LEG GALLEY RECEPT CIRCUIT 7 15 HACR BREAKER 12 2 ROMEX W GROUND LEG 2 GALLEY RECEPT AIRSTREAM LAND YACHT GAS Automatic Energy Select Switch AESS Located in the trunk area Front a c is priority Rear a c will cool if cool mode is selected when front a c has finished its cooling process Front a c will come back on as its thermostat detects the need to cool and the rear a c will shut off A C fan powered by 12 volt on both units will run even if the other is cooling on the 120 volt circuit Turn front a c to fan or off to run rear a c only 5 Aa 3 e 3 3 u 5 ha 3 e vH I RE sa BS 55 lt 3 gt Gg aS M 3 Gr ey RT RB 2 gt Q 2 8 gt 35 Q iS BA E SER Q j 3 o a 3 2 3k 5 KAI ava 5574
55. S MOTOR TYPE LEADS TEMP LIMITS DUTY CYCLE m SPEED CONTROLLER PUMP DESIGN TYPICAL APPLICATION MATERIALS PUMP HOUSINGS CONTROLLER HOUSING VALVES DIAPHRAGM FASTENERS LIQUID TEMPERATURE W PUMP CERTIFICATIONS m PRIMING CAPABILITIES FITTINGS Aquatec Water Systems Inc BASEPLATE AS SHOWN 8 2 25 X 3 18 FOOTPRINT 12VDC MOTOR DOUBLE BALL BEARING MOTOR FOR RV AND MARINE APPLICATIONS TASTE FREE MATERIALS SEE BELOW 65 PSI SHUT OFF SAFETY SWITCH 12VDC SPEED CONTROLLER 3 5 DEGREE CAM QUICK DISCONNECT PORTS 3 4 DIAMETER SERIES 550 PUMP 12 VDC Permanent Magnet Totally Enclosed Non Ventilated 14 AWG 12 Lang Black Negative Red Positive DO NOT REVERSE Safe to 150 F 66 C See Heat Rise Graph Factory Set to Approximately 10 An ps Max Thermally Protected to Avoid Component Damage CAUTION Exterior Surfaces heat s Ink May Exceed 150 F After Only 5 Min ites of Operation 5 Chamber Diaphragm Pump Self Friming Capable of Being Run Dry Water Pressurization for RV and rine Polypropylene Nylon EPDM Santoprene Stalnless Steel 140 F 60 C Max IAPMO NSF 13 Feet TYPE HOSE BARB H SE BARB THREADED FOR USE WITH PRE FILTER www aquatec com 17422 Pullman Irvine CA 92614 Sales 949 225 2200 Fax 949 225 2222 DOCUMENT ISSUED REVISED 055503 4 15 6636 3 3 00 3 2 00 AIRSTREAM LAND YACHT GAS CITY W
56. S LOUNGE LOCKER LIGHT 0 80 FANTASTIC 3 2 BOOSTER 0 00 FRONT A C FEED WIRE 1 00 TIYT AT AMIDE MAGNETEC 7455 55 AMP CONVERTER USED AIRSTREAM LAND YACHT GAS EXTERIOR WORKHORSE FUSE BLOCK The 10 amp ALT START must be a circuit breaker JACKS ALARM STEP ALARM LPS ERT PARK 15 1 25A TURN B U RADIO ACC WIPER 20A ZI L IL IL IL Ne a AUX PWR LTA RADIO BAT 30 AMP 30 AMP ACCY 1 PWR 2 Airstream functions only see Workhorse manual for all chassis protections NAME SIZE CIRCUITS PROTECTED HORN 20A Horn CTSY 20A Dome lights GAGES 20A See Workhorse manual AUX PWR 20A PK LPS 20A Head lamp switch TURN BACK UP 15A Reverse view for camera JACKS ALARM SA CIG LTR 20A Dash 12 Volt outlet ILLUM 10A Dash switch lights RADIO ACC 15A Monitor Step ign Step MKR LPS 10A Clearance lights RADIO BATT 10A WIPER 25A Wiper FRT PARK SA Front park lights STEP ALARM SA PWR ACCY 1 30A PWR ACCY 2 30A H 7 AIRSTREAM LAND YACHT GAS 3016 man 901 N E 4 x WINOZISOH WANN Lu ANIMLSNPOV WILY Va s SONISNOH 21519 OLNI SJAM ONILYJSN N3HA 53015 1331 H108 304 AVYDVIG 38M 3INVS 3SN ILON 3LIHM IXM MOTI3A TOMLNOO 310W39 Q
57. TERIES FOR CO DETECTOR REPLACEMENT Alkaline type EVEREADY522 DURACELL MN1604 GOLD PEAK 1604A Lithium type ULTRALIFE U9VL NOTE REGULAR TESTING IS RECOMMENDED Warning USE ONLY THE BATTERIES SPECIFIED USE OF DIFFERENT BATTERIES MAY HAVE DETRIMENTAL EFFECT ON THE CO DETECTOR CLEANING YOUR DETECTOR To clean your detector remove it from the mounting bracket as outlined in the beginning of this section You can clean the interior of your detector by using your vacuum cleaner hose and vacuuming through the openings around the perimeter of the detector The outside can be wiped with a damp cloth AFTER CLEANING REINSTALL YOUR DETECTOR TEST YOUR DETECTOR BY USING THE TEST BUTTON Test detector weekly for proper operation by pushing the test button until the YELLOW L E D lights and a short beep is heard approximately three seconds Release the button The detector will then test itself for proper operation At completion of the self test the alarm will sound and both L E D s will light for 3 4 of a second The detector then resumes normal operation AIRSTREAM LAND YACHT GAS SERVICE AND WARRANTY If after reviewing this manual you feel that your CO Detector is defective in any way do not tamper with the unit Return it for servicing to Quantum Group Inc 11211 Sorrento Valley Road Suite Valley Road Suite V San Diego CA 92121 Or call us toll free 800 432 5599 E mail address mktsls qginc com LP GAS DETECTOR
58. THIS WARNING Note See chassis and appliance manufacturer s literature for further information EVERY 1 000 MILES OR 60 DAYS Escape Window Check operation of latches and upper hinge Smoke Alarm Test and replace battery as required Tires Check tire pressure See inflation warning on page C 13 GFI Circuit Breaker Test and record Spare Tire System 30 amp 33 only Check tightness and operation of winch Check for worn and defective cable washer or yoke EVERY 5 000 MILES OR 90 DAYS Exterior Door locks Lubricate with dry graphite Exterior Hinges Lubricate with light household oil LPG Regulator Check bottom vent for obstructions Main Door Striker Pocket Coat with paraffin Wheel Lugs Torque to chassis owner s manual specificationnfiffin AIRSTREAM LAND YACHT GAS MAINTENANCE RECORDS DATE DEALER SERVICE PERFORMED A 7 AIRSTREAM LAND YACHT GAS NOTES A 8 AIRSTREAM LAND YACHT GAS DRIVING LOADING Below is a sample of the weight information chart provided in all Airstream vehicles This information can be found in your vehicle on the back of a wardrobe door MOTORHOME WEIGHT INFORMATION VIN OR SERIAL NUMBER GVWR GROSS VEHICLE WEIGHT RATING IS THE MAXIMUM PERMISSIBLE WEIGHT OF THIS FULLY LOADED MOTORHOME UVW UNLOADED VEHICLE WEIGHT IS THE WEIGHT OF THIS MOTORHOME AS MANUFACTURED AT THE FACTORY WITH FULL FUEL ENGINE OIL AND COOLANTS SCWR S
59. TOR COIL 12 071 00143 SHIELD 17 04500125 O RING SAE 012 C 3 AIRSTREAM LAND YACHT GAS SCS Frigette MOTORHOME HVAC SYSTEMS 1 9030 00109 BLOWER MOTOR 5 030 00025 VACUUM MOTOR 9 062 00113 BLOWER HOUSING 2 051 00034 VENT HOSE 6 071 00763 HOUSING ASSEMBLY 10 060 00135 INLET GUIDE 3 062 00010 ELOWER WHEEL 7 030 00068 VACUUM MOTOR 11 060 00497 HEATER BOK 4 0790 00234 VAC MOTOR BRACKET 071 00762 BACK PANEL 12 071 00645 DIVIDER C 4 AIRSTREAM LAND YACHT GAS SCS Frigette MOTORHOME HVAC SYSTEMS e e LAMPS BLK CONTROL ba op ew LT BLUANHT THERMOSTAT 19 LF 25 FUSE DIAGNOSTIC WIRE HARNESS CHASSIS WIRING r TO COMP ESSOR TO BATTERY TO PANEL LIGHT CIRCUIT 5 TO 12 VDC HOT IN HUN 6 C 5 AIRSTREAM LAND YACHT GAS SCS Frigette CONTROL HEAD WHITE MODES MAX AC OFF ALL De FRESH RECIRC DOOR ON EVAPORATOR ASSEMBLY GREEN MOTORHOME HVAC SYSTEMS BLACK ___ gt TO VACUUM SOURCE RED ALL OTHER MODES MIX DEFROST ld DEFROST DOOR ON PLENUM ASSEMBLY YELLOW MAX AC NORM AC VENT ALL OTHER MODES DASH FLOOR DOOR ON PLENUM ASSEMBLY AIRSTREAM LAND YACHT GAS AUXILIARY HEATER Option 26 Ft The auxiliary heater located under the coach near the step is plumbed into the radiator system Two t
60. Water pump range vent and light 23 Pink 20 Docking lights F 11 Black 30 S O Motor AIRSTREAM LAND YACHT GAS GIO TS AALUYAANOD UAMOU 6897 SANV 68 91 STO SANV 95 LI SANV 00 0T 0 84 0C SAINV00 07 99001 SANY OG sI SAWY 9S LOT MVUG TVLOL SANV 00 Josey Goncq 4 dWV SI CI NOLLISOd ASNA 46 div SI TI NOLLISOd ASNA SdWV E ST syr duro V9 0562 LINDI OF NOLLISOd ASNA SdWV OT ET TEL 00 OT dund 1EM 05 6 pue 9 das 8 LINDYID ON SANV 081 oL ors 94811 SUNO von pue Z TH OS r 1817 noura qmg c OS TI 1991 oped 00 51481 dais MOVIE V5 dAV 0c 8 8 NOLLISOd ASNA SdNV 8001 51317 Jusuruedulo L SANV 098 BIOL 001 arm OV 10014 SNOLLVINOTVO L IOA CI UNOHYUOLON LHOVA ANVI 4 9C 0070 00 091 914817 Ta 001 002 ue anid VI cl dV SI S LIN LET mor m tr 091 NMOUY VI ZI dV SI S LI SdAV 9 ST ROL OSE y 001 ug 086 1431 SANV STLI 00 88 00 007 d 19817 817 sir Surpeoy AVAD AV OG THIN di H 5 AIRSTREAM LAND YACHT GAS 30 amp 33 LAND YACHT XL MOTORHOME 12V CALCULATIONS FUSE POSITION 1 15 AMP SPARE FUSE POSITION 2 CIRCUIT 41 15 AMP 12 GA GREY OPT POWER AWNING 5 00 AMPS FUSE POSITION 3 CIRCUIT 1 20 AMP 12 GA PURPLE 3
61. ace it replacement parts can be acquired from your RV Dealer C 18 AIRSTREAM LAND YACHT GAS v Cleaning is the most effective maintenance that you can perform on your lights dirt and road grime build up can cut light output by 40 or more When cleaning your headlamps please observe the following do not rub them dry and never use abrasives or strong solvents Remove dirt and contamination such as insects by soaking with shampoo and then rinsing with plenty of water Always use a deicer spray to remove accumulated ice and snow never use a scraper Headlamp seals should not be directly sprayed with high pressure home or industrial wash systems Damage to the seal can occur causing the housing to leak water Chemicals Composite headlamps have a polycarbonate lens which is very sensitive to a variety of chemicals Contact with certain chemicals can cause crazing softening or cracking of the lens which would require replacement of the entire lamp housing The following chemicals are suspected to cause similar results Mild soap and water is recommended for the cleaning of your lamps Acetone Gasoline Oils Agitene Kleenol Plastics Pink Lux phosphate free Ajax Lemon Joy phosphate free Stanisol Naphtha Benzyl Lestoil amp Texiz 8006 8129 8757 Carbon Tetrachloride Liquid Cleaner 8211 Toluol Chlorinated Liquid Detergents Tricholor Citrus Orange Cleaners Lysol amp Triclene amp Diversol Methyl Ethyl Keyton
62. ance with an outside temperature of zero degrees and the wind velocity of 10 miles per hour the equivalent chill temperature is minus 20 F The exterior water faucet has an in line valve inside the motorhome In below freezing temperatures shut off the valve inside and open the exterior brass valve so it will drain See the valve section in this book for locations AIRSTREAM LAND YACHT GAS EXTENDED STAY Making a long trip is not very different from making a weekend excursion Since everything you need is right at hand you are at home wherever you go When packing for an extended trip take everything you need but only what you need Some models are equipped with Hydraulic Leveling Jacks that can be deployed Complete instructions are included with the Owners Packet Be sure to read the directions completely prior to operating the jacks When you plan to stay in the same place for several days weeks or months you will want your motorhome to be as level as possible Check the attitude with a small spirit level set on the inside work counter If a correction is necessary then you must first level from side to side This can be done most easily by driving up a small ramp consisting of 2 x 6 boards tapered at both ends WE DO NOT RECOMMEND PLACING TIRES IN A HOLE FOR LEVELING Check the tire section of the chassis portion of this manual for information on tire support Hook Up to Water by attaching 1 2 minimum high pressure water ho
63. ants Indoors mold growth is unfavorable Left unchecked molds break down natural materials such as wood products and fabrics Knowing the potential risks is important for any type of homeowner to protect their investment What factors contribute to mold growth For mold growth to occur temperatures indoor or outdoors must be between 40 degrees and 100 degrees Fahrenheit and also have a source of moisture such as humidity standing water damp materials etc Indoors the most rapid growth occurs with warm and humid conditions How can mold growth be inhibited By controlling relative humidity the growth of mold and mildew can be inhibited In warm climates use of the air conditioner will reduce the relative humidity Vents are located in the bathing and cooking areas and constant use is advised during food preparation and bathing even during colder weather Additionally opening a window during these activities will assist in ventilation In extremely humid conditions the use of a dehumidifier can be helpful Frequent use of your RV or cleaning regularly is an important preventive measure Further any spills should be wiped up quickly and dried as soon as possible Avoid leaving damp items lying about On safe surfaces use mold or mildew killing cleaning products Check sealants regularly and reseal when necessary to avoid water leaks Proper preventive maintenance to the RV and its accessories as described both in this manual and i
64. ass cleaner Moen Cartridge Removal CAUTION Always turn water OFF before removing or disassembling the valve Open valve handles to relieve water pressure to insure that complete water shut off has been achieved 1 Holding the handle 2 or 18 with one hand 3 NA unscrew the handle hub 9 counterclockwise and set aside e pe ij FAUCET BODY 2 Unscrew the cartridge nut 11 counterclockwise 3 Grasp the cartridge stem with pliers being careful not to damage stem and pull straight up 4 To reassemble reverse the previous steps Turn the cartridge stem to ON position so that the hole in the piston lines up with the hole in the outer shell Plush the cartridge straight down into the body making sure the key on the cartridge fits into the notch in the body This will correctly position the cartridge Replace the cartridge nut start by hand DO NOT CROSS THREAD and tighten firmly In the US call Moen s toll free Help line number 1 800 Buy Moen 289 6636 for answers to any product warranty or installation questions In Canada call 1 800 465 6130 Toronto 905 829 3400 G 16 AIRSTREAM LAND YACHT GAS 943433 LET DATE REVISION RECORD BY a PRODUCTION RELEASE DN VAPOR LINE Chassis SIDE VIEW INSTALLED NOTE INSTALL BLACK PIPE AND CONNECTORS CHASSIS LINE 14 600008 TUBING COPPER 3 80D self 13 600008 TUBING COPPER 37800 50 600008
65. capacity by 0 13 the result is the ounces of bleach needed to sanitize the tank B Multiply Liters of tank capacity by 1 0 the result is the milliliters of bleach needed to sanitize the tank 2 Mix into solution the proper amount of bleach within a container of water 3 Pour the solution water bleach into the tank and fill the tank with potable water 4 Open all faucets Hot amp Cold allowing the water to run until the distinct odor of chlorine is detected 5 The standard solution must have four 4 hours of contact time to disinfect completely Doubling the solution concentration will allow for contact time of one 1 hour 6 When the contact time is completed drain the tank Refill with potable water and purge the plumbing of all sanitizing solution NOTE The sanitizing procedure outlined above is in conformance with the approved procedures of RVIA ANSI A 119 2 and the U S Public Health Service AIRSTREAM LAND YACHT GAS WATER PUMP Manufacturer Aquatec 17422 Pullman Street Irvine CA 92614 Phone 800 975 9995 Phone 949 225 2200 Fax 949 225 2222 Web site www aquatec com Aquajet RV Series This revolutionary pump employs state of the art electronics to automatically control motor speed the pump actually adjusts its speed as you open and close water fixtures The Aquajet RVs exclusive soft start feature eliminates annoying rapid cycling and its exclusive 5 valve design can deliver twice the flow and pressu
66. control them The second cluster of switches is in the bathroom They control the bath lights water heater and water pump The water pump switch operates in conjunction with the pump switch on the monitor panel The pump can be turned on or off at either location The water heater switch marked gas supplies power to the igniter and gas valve When turned on it will flash red until flame is sensed then the red light will be extinguished A second switch operates the water heater on 110 volt power The bulbs in the interior lights are all easily replaced if they burn out Round exposed bulbs such as those around the bathroom mirror and reading lights are replaced by depressing them into their base then turning to the left about turn This will allow them to pop out part way so they can be removed A Warning If they are difficult to turn use a folded rag to protect your hand when grasping the bulb in me it should unexpectedly shatter A WARNING Always replace the light bulb on an interior or exterior light fixture with the correct bulb for that light Failure to heed this warning could cause fire property damage personal injury or death F17 F24 F25 F26 F27 F16 F15 14 F18 F19 AIRSTREAM LAND YACHT GAS Primary Battery Control Center Circuit Locations Front Driver s Side Exterior Compartment x 2 lt 0 2 t eek ie Bo ix Z 0 Foutoun z 32 998 30 0 lt 2E AUX BD LED
67. e to run into the bowl for a short time after the pedals are released When you wish to conserve water hold the hand spray head over the bowl and hold down the thumb operated lever Now when you depress the pedal all the water is routed through the hand spray CAUTION When you dump the bowl of the toilet make sure all paper and solids have cleared the slide mechanism before you allow it to close Failure to do so can cause the groove for the slide to become jammed and the slide will no longer close completely If the problem should occur a small nail or bent clothes hanger can be used to pick the material out of the groove Bravura 2 55 16 13 17 11 Product ID Label md 12 27 40 For Thetford service centers Before ordering parts record the Product ID information No Description Hinge Pins 2 Seat Cover Vacuum Breaker Flush Tube Flush Nozzle Assy Overflow Trap Water Supply Tube Hand Spray Kit Water Saver Option Only 9 Side Access Covers 2 10 Water Valve 11 Lower Mechanisn Assy 12 Closet Flange Seal amp Bolt Pkg 13 Seat 14 Hinge Post Kit 15 Upper Mechanism Assy 16 Pod 17 Water Module 18 Water Valve Link 19 Lever Assy 20 Wire Replacement Pkg 21 Mechanism Cover CO NO No Description 22 Bracket amp 2 Screws 23 Float Assy 24 Actuator Assy 25 Base to Bowl Screws 9 26 Closet Bolt Pkg 27 Pedal Pkg 28 Base 29 Retainer amp Screw
68. e windows s are identified by their red release handles Pull red handle toward window center Push out on the glass and it will swing clear The window operation should be checked each trip and the latches lubricated with WD 40 or equivalent every six months Do not parked in a manner that would prevent the escape windows from opening or block an emergency exit route D 9 AIRSTREAM LAND YACHT GAS EFFECTS OF PROLONGED OCCUPANCY Your motorhome was designed primarily for recreational use and short term occupancy If you expect to occupy the motorhome for an extended period be prepared to deal with condensation and the humid conditions that may be encountered The relatively small volume and tight compact construction of modern recreation vehicles mean that the normal living activities of even a few occupants will lead to rapid moisture saturation of the air contained in the motorhome and the appearance of visible moisture especially in cold weather Just as moisture collects on the outside of a glass of cold water during humid weather moisture can condense on the inside surfaces of the motorhome during cold weather when relative humidity of the interior air is high This condition is increased because the insulated walls of a recreation vehicle are much thinner than house walls Estimates indicate that a family of four can vaporize up to three gallons of water daily through breathing cooking bathing and washing Unless the water vapor is carri
69. ed outside by ventilation or condensed by a dehumidifier it will condense on the inside of the windows and walls as moisture or in cold weather as frost or ice It may also condense out of sight within the walls or the ceiling where it will manifest itself as warped or stained panels Appearance of these conditions may indicate a serious condensation problem When you recognize the signs of excessive moisture and condensation in the motorhome action should be taken to minimize their effects For tips on controlling condensation see the Tips To Controlling Condensation section Note Your motorhome is not designed nor intended for permanent housing Use of this product for long term or permanent occupancy may lead to premature deterioration of structure interior finishes fabrics carpeting and drapes Damage or deterioration due to long term occupancy may not be considered normal and may under the terms of the warranty constitute misuse abuse or neglect and may therefore reduce the warranty protection TIPS TO CONTROLLING CONDENSATION To avoid condensation problems try to follow these tips to help alleviate excess moisture Allow excess moisture to escape to the outside when bathing washing dishes hair drying laundering and using appliances and non vented gas burners Always use the vent hood when cooking Keep the bathroom door closed and the vent or window open when bathing and for a period of time after you have finished
70. ees are located between the engine and the front heater The water lines to the heater are routed under the floor By using the two speed dash fan the temperature output can be varied TIRES Your chassis Owner s Manual contains important cautions and information on tires and should be reviewed and followed for your safety The tires installed on your Airstream motorhome are engineered to provide a proper balance of performance characteristics for normal vehicle operation This section contains some tips on how you can obtain the most benefit from these tires Don t let anyone tell you that underinflation or over inflation is all right It s not If you re tires don t have enough air underinflation you can get tire flexing heat build up tire overloading bad handling bad fuel economy and bad wear Too high an air pressure over inflation can result in abnormal wear bad handling harsh ride and also increase the chance of damage from road hazards Tire inflation pressures should be checked at least monthly and when significantly changing the load you plan to carry in your motorhome Always check tire inflation pressures when the tires are cold See tire inflation on page C 13 Standard inflation pressures for tires are listed in the Cold Inflation Pressure chart Front and rear pressures are shown for each model and GVWR and are based on the GVWR and front and rear axle ratings GAWRs printed on your vehicle VIN plate and Cer
71. el cover in place is easily removed TIRE CHANGING Caution Changing a tire on a heavy duty motorhome chassis is a physically demanding procedure It requires specialized tools and knowledge of safety procedures Only you can determine your knowledge base and physical ability Don t take any unnecessary risks You could turn an inconvenience into a tragedy Please find a safe area to park your unit call a tire service center and supply them with the information below if you have any doubts about changing a tire The spare tire is located in the trunk storage compartment on the 26 Ft model and tucked up under the trunk storage area against the bottom of the floor on the 30 amp 33 Ft models Remove the spare from the 26 coach by sliding it out the rear trunk door The 30 amp 33 models use a winch to lower and raise the spare tire The winch is accessed inside the trunk storage area To remove the spare tire use a ratchet or speed wrench with a socket to lower the spare to the ground Block the tire up to remove the weight from the washer remove the washer from the yoke slide the yoke through the rim and slide the tire from under the motorhome To store a spare tire reverse the removal instructions Warning Defective spare tire equipment or an improperly stored spare tire could damage your equipment and or cause serious injuries to people inside your motorhome other motorists and pedestrians The yoke washer and spare tire
72. enses unsafe levels of CO the RED L E D will light up and the alarm will sound The alarm condition will be signified by a repetitive alarm sounding pattern of approximately 4 5 seconds on 1 5 second off Immediate evacuation is required Pushing the test button will silence the alarm once for approximately 4 minutes After approximately 4 minutes the alarm will once again sound until the unsafe CO concentration is removed FAULT CONDITION Periodically the detector s measurement circuit is tested If an error is detected the detector will sound twice and the YELLOW L E D will flash twice every 30 seconds This is an indication of circuit malfunction and that the detector requires immediate servicing MAINTENANCE Battery Replacement If tamper resistant pin has been used refer to tamper resistant locking pin for removal instructions To replace the battery remove the detector from the mounting plate by rotating the detector in the direction of the OFF arrow on the cover The Model 9L 1 CO Detector uses one 1 9 volt battery The CO DETECTOR is powered by a 9V alkaline battery A fresh battery should last for one year under normal operating conditions This detector has a low battery monitor circuit which will cause the detector to chirp and the red LED to flash approximately every 30 40 seconds for a minimum of seven 7 days when the battery gets low Replace the battery when this condition occurs USE ONLY THE FOLLOWING 9 VOLT BAT
73. ep will lower when the door is opened and retract when the door is closed When parked open the door so the step is lowered then shut the switch off The step will remain in the lowered position and the step light on the dash will be extinguished If you forget and leave the switch off as you leave No Problem When the ignition is ON the wall switch is by passed and the step will retract when the door is closed A Warning If the wall switch is turned off and the step is in the retracted position when the ignition is turned off the step will not lower when the door is opened Keep your passengers informed C 14 AIRSTREAM LAND YACHT GAS DOOR SWITCH INSTALLATION Wiring Diagram for Step wiring Steps Equipped Understep light not available on with the 909506 SED 909507 or 909508 Control Unit 12 AWG green ground to step top 12 AWG green ground wire must be securely attached to the chassis for step to operate Fuse block IMPORTANT e acce The yellow wire must go to SD a terminal marked IGN ignition or to another terminal that is 16 AWG purple hot when the ignition optional step light switch is turned on 5 amp maximum tuse or circuit breaker required 16 AWG brown 16 AWG yellow 12 AWG red 16 AWG white Vehicle wiring 20 amp tuse or circuit breaker required Chassis ground Chassis ground Normally Open magnetic If the switch Is Off the 5 amp maximum fuse or step w
74. er Areas F 2 C rtairis unas uta a F 4 Dash Air Conditioner C 2 Dash Instruments B 4 Dimensions K 1 Dinette ERR ar alesse ts F 4 Door Eock eee B 4 E 1 Drain Hose D 9 G 30 Drain Lines G 29 G 29 Drain Valves G 18 Dr p s aasan ay tede dren F 4 Driving inh ret mee B 1 Electrical System H 1 Step eee C 14 Escape Windows D 1 Extended Stay sss D 9 Exterior eet E 1 INDEX hone Mee EE G 11 Fabrics Cleaning F 3 Filter G 14 2 Eurnace kratere ae J 2 BUSES 2usesnesnee D 9 I 1 H 1Thru H 6 Gas DP aee ete tents D 6 G 1 Gauges 4 Generator B 4 D 9 I 1 Ground Fault Interrupter I 1 GVWR B 1 B 5 C 7 K 2 GCWR iacit B 1 B 5 K 2 Hardwood Flooring F 2 Heater Automotive C 2 Hitch Load B 5 K 1 Holding Tanks G 10 G 24 G 32 K 1 Humidity D 8 Inflat
75. filter life indicator because the filter button will remain depressed with the first push as it switches to filter mode The filter life indicator has been correctly reset if a short series of rapidly flashing green light occurs indicating that the new filter flushing period has begun 4 Flush the filter for 5 minutes before initial use Your new Moen faucet is now ready for normal use To replace filter 1 Turn off the faucet Remove the faucet head by twisting it approximately turn counter clockwise to unlock it Gently pull the faucet head away from the spout and twist it approximately another turn to get the faucet head past the safety catch The faucet head and depleted filter Gf one is installed can now be pulled completely out of the spout 2 The filter is held to the faucet head by two outlet ports which connect into the head Remove the old filter by simply pulling it straight off Discard the old filter and install a new MicroTech 400 or 600 filter Note The faucet will function correctly in unfiltered stream mode with or without a filter installed The Fittering Appliance Faucet head o ring seal 2 XM Outlet Ports faucet will not function correctly in filter mode without a filter If a filter is not installed and the filter button in depressed unfiltered water will flow from both the filtered water outlet and the stream outlet aerator and the filter button will not automatically stay depressed U
76. ght your Airstream motorhome can be safely parked in any spot that is relatively level and where the ground is firm Your facilities are with you You are self contained Try to pick as level a parking spot as possible Hydraulic Leveling Jacks Some models are equipped with hydraulic leveling jacks that can be deployed Complete instructions are included with the Owners Packet Be sure to read the directions completely prior to operating the jacks The jacks will be able to level your unit in most modern campgrounds However their capabilities are limited and in some situations you will have to use planks to level the coach TV Backing Monitor Option on 26 The TV backing monitor can be extremely helpful especially when traveling alone The Owners Packet includes complete instructions on use Practicing with the monitor in a safe place will make it much easier for you to use when it is really needed WINTER TRAVELING Traveling in your motorhome during the cold winter months can be a most exhilarating experience There are of course certain precautions that must be taken as you would in your home in low temperatures A Warning 2 Always shut off the LP gas when gasoline is added to the fuel tank D 7 AIRSTREAM LAND YACHT GAS WINTER TRAVELING Cont Some states do not allow LPG to be turned on while moving While traveling in these states you must use your common sense How cold is it How long will it be before you can turn
77. gulators does not become plugged by mud insects snow ice paint etc Vents must remain open Replace any regulator that has had water in the spring case or shows evidence of external corrosion or corrosion inside the spring case Closely examine regulators directly connected to the container valve by means of a solid POL adapter horizontal mounting for signs of corrosion An Airstream Service Center is recommended for this service AIRSTREAM LAND YACHT GAS BASIC RULES FOR SAFETY gt Warning DO NOT store LP containers within vehicle LP containers are equipped with safety devices that vent gas should the pressure become excessive Warning DO NOT use cooking appliances for comfort heating Cooking appliances need fresh air for safe operation Before operation open overhead vent or turn on exhaust fan and open window warning label has been located in the cooking area to remind you to provide an adequate supply of fresh air for combustion Unlike homes the amount of oxygen supply is limited due to the size of the recreational vehicle and proper ventilation when using the cooking appliances will avoid dangers of asphyxiation It is especially important that cooking appliances not be used for comfort heating as the danger of asphyxiation is greater when the appliance is used for long periods of time gt Warning e Portable fuel burning equipment including wood and charcoal grills and stoves shall not be used inside the
78. h a damp cloth AFTER CLEANING REINSTALL YOUR DETECTOR TEST YOUR DETECTOR BY USING THE TEST BUTTON LIMITATIONS OF SMOKE ALARMS WARNING Smoke detectors are devices that can provide early warning of possible fires at a reasonable cost however detectors have sensing limitations Ionization type detectors offer a broad range of fire sensing capability but are better at detecting fast flaming fires than slow smoldering fires Photoelectric detectors sense smoldering fires better than flaming fires Home fires develop in different ways and are often unpredictable Neither type of detector photoelectric or ionization is always best and a given detector may not always provide warning of a fire Also smoke detectors do have limitations For a battery powered detector the battery must be of the specified type in good condition and installed properly AC powered detectors will not operate if AC power has been cut off such as by an electrical fire or an open fuse Smoke detectors must be tested regularly to make sure the batteries and the detector circuits are in good operating condition Smoke detectors cannot provide an alarm if smoke does not reach the detector Therefore smoke detectors may not sense fires starting in chimneys walls on roofs on the other side of a closed door or on a different floor If the detector is located outside the bedroom or on a different floor it may not wake up a sound sleeper The use of alcohol or drugs may also
79. h one side of vehicle as shown In Individual Wheel Position Weight 4 Calculate other side as shown in Last Information for line 1 is located in the specification section in this manual Front Axle GAWR GVWR Rear Axle GAWR GCWR GVW SCALE WEIGHT Optional Tow Weight STEP 1 STEP 2 STEP 3 STEP 3a Front Axle GAW GVW Rear Axle GAW Tow Weight minus Weight of Trailer or Vehicle Towed INDIVIDUAL WHEEL POSITION WEIGHT STEP 4 STEP 5 STEP 6 Left Front Wheel Left Side Left Rear Wheel Position Total LF LR Position Calculated Calculated Calculated Right Front Wheel Right Front Right Rear Position Total RF RR Wheel Position Step 1 minus Step 4 Step 2 minus Step 5 Step 3 minus Step 6 GAWR Gross Axle Weight Rating GVWR Gross Vehicle Weight Rating GCWR Gross Combination Weight Rating B 6 AIRSTREAM LAND YACHT GAS CHASSIS The Airstream motorhome is built on a chassis designed for motorhomes Operation of the engine and other related components is discussed in the Chassis Owners and Drivers Manual supplied with each coach If repairs are needed it can be difficult to determine which parts are the chassis and which are Airstream s responsibility The following list shows the major components of the chassis and the company responsible for their servicing Motorhome Chassis Serviced By Work Horse Custom Chassis Roadside Assistance 1 877 946 7731 24 7 See Chassis Owner s Manual Engine Turn Signals Transmission Sus
80. has stopped running from the drain lines apply at least 60 Ibs of air pressure at the city water inlet Be sure the toilet valve and all drain valves and faucets are open and pump outlet hose is disconnected This can be accomplished at a service station and will force any remaining water from the water heater and remove any water which may be trapped in low areas 7 Pour a cup of non toxic antifreeze into the lavatory sink and tub drains to prevent freezing water in traps 8 Be sure to open the waste holding tank drain valves and drain and flush the tanks thoroughly This is very important as the frozen sewage could seriously damage the tank 9 Remove water filter canister and dump 10 Remove the batteries from your motorhome and store in a cool dry place where there is no danger of freezing It is very important for optimum life of your battery to check it periodically and to keep it fully charged This is especially true in winter months when the temperature may drop below freezing If the period of storage is for 30 days or less you may turn off the kill switch rather than remove the batteries Please refer to the battery section for more information on battery maintenance 11 Remove any items food cosmetics etc from the interior that might be damaged by freezing or might damage the motorhome if containers break 12 If you have an optional icemaker read and follow the winterizing directions in the manufacturer s owner manual
81. he strong hipbone structure instead of around the soft abdominal area Two people should never try to use the same seat belt AN Warning Children must be secured in a Federally Approved Child Restraint Device Failure to use proper restraints while in transit can result in severe or fatal injuries Child restraint devices are designed to be secured with lap or lap shoulder belts All instructions supplied by the restraint manufacturer must be followed Statistics have shown children are safer when properly restrained in a rear seating position than in a front seating position Often the children traveling in motorhomes are grandchildren There are times when our love for grandchildren makes us hesitate to properly supervise their actions Don t hesitate when it comes to their safety Make sure they are properly restrained CHILDREN HAVE LOVED ONES TOO IF YOU WON T BUCKLE UP FOR YOURSELF BUCKLE UP FOR THEM B 3 AIRSTREAM LAND YACHT GAS DASH SWITCHES e Door Lock The main door can be locked or unlocked from the drivers seat Remember to hide an extra door key on the exterior in case of unexpected battery failure e Auxiliary Start The auxiliary start switch is intended to be used if the engine battery becomes too discharged to turn the engine over To operate hold the switch in the start position and then use the ignition switch in a normal fashion Operating the auxiliary start switch closes the points on a large solenoid tying a
82. htening AIRSTREAM LAND YACHT GAS PARTS DESCRIPTION N D QI 8 9 10 2 22 23 27 30 31 LM 300 Leveling Mount Boot Coax Cable Pin Headed Grooved Ring Retaining Snap Grommet Plastic Antenna Head Spacer Plastic EG 87 Elevating Gear Tube Square Elevator Elevating Shaft Assy Housing Rotating Gear Ring Quad Seal Bearing Nylon AS COMPLETE ASSEMBLY Housing Base Plate Bearing Nylon Plate Ceiling Screw Handle Directional Spring Handle Decal Crank Cover Bearing Nylon Elevating Crank Set Screw Boot Gear Housing Bumper Rubber Screw AIRSTREAM LAND YACHT GAS SOLAR POWER The 5 watt system installed in your motorhome primarily function is as a battery maintainer Memory functions in radios locks and the circuit boards in some safety devices each draw power in the milliamp range If a charge source is not available even these miniscule power drains will run your chassis batteries down in a few days Barring an unusual number of cloudy days the solar system will keep your chassis batteries in pretty good condition Turning your auxiliary battery switch off at the dash will help maintain the charge in both the chassis and coach batteries AIRSTREAM LAND YACHT GAS 110 VOLT POWER The 110 volt system works very much like your home When you re plugged into city power or start your ge
83. ile the engine is running The converter charges all the batteries when the unit is plugged into shoreline The Coach batteries are used for interior lighting exhaust fans generator water pump central control panel entertainment center optional 12 volt convenience outlets and the refrigerator when it is switched to 12 volt power The Intellitec Battery Control Center manual is also in your packet It has trouble shooting and wiring information The Intellitec Primary Battery Control Center is located in the driver s side front exterior lower compartment along with the interior 12 volt fuse panel 12 volt power is distributed to each of the 12 volt interior circuits of the motorhome from this fuse panel The Battery Disconnect switches on the panel just inside the main door acts as master switches When the coach switch is turned to use it opens the circuit between the coach batteries and the twelve volt distribution panel in the primary Battery Control Center The chassis switch disconnects the chassis battery from the chassis systems except for a few items such as ignition The coach and chassis batteries are charged by the converter whether the battery disconnect switches are in the use or store position The generator also charges all batteries when it is running through the 120 volt city power system that powers the converter NOTE The chassis disconnect switch will not operate with the ignition key on The disconnect switches are not
84. ill not Circuit breaker required operate C 15 AIRSTREAM LAND YACHT GAS STEP MOTOR ASSEMBLY DIAGRAM Parts shown in this illustration are only available in kit form and cannot be obtained individually refer to the illustration below and use the Step Motor Parts Key on the preceding page fo select the kit that contains the necessary part Linkage assemblies extension length 2 7 16 Part Description 10x 1 3 4 selt tapping hex washer head screw Motor bearing bracket Bearing Motor Motor high torque for use with 23 Series steps Adaptor gear Adaptor gear shaft Linkage assy for motor assys 909502 amp 909503 Linkage assembly for motor assembly 909501 Linkage assembly for motor assembly 909504 Cotter pin Clevis pin Gear case Gear Gear case cover Motor mounting plate 1 4 20 x 1 1 4 tri lobal thread forming screw 6 x 3 4 self tapping washer head screw Motor lead weather seal upper plate Motor lead connector rubber seal Motor lead weather seal lower plate C 16 AIRSTREAM LAND YACHT GAS MAINTENANCE AND LUBRICATION Clean all mud salt and road grime from step before lubricating Lubricate all moving parts bearings pivot points slides clevis pin and drive linkage ball every 30 days with a good quality moisture and heat resistant penetrating grease Kwik Lube Spray Grease is specially formulated to lubricate Kwikee Electric Steps and is recommended for lubricating all moving parts Refer
85. ill probably not function if the current drops below 105 volts Low voltage is usually associated with older or poorly maintained motorhome parks but many people have found their homes built only twenty or thirty years ago may not be capable of operating the air conditioner on some receptacles Parking your motorhome so the power cord can be plugged into a receptacle close to the fuse or circuit breaker box can alleviate the problem Avoid extension cords and adapters whenever possible If an extension cord must be used it should be as short and heavy as possible to provide the most current to the air conditioner If high temperatures are expected you should make an effort to park in a shaded area Starting the air conditioner early in the morning also helps It is much easier to hold a comfortable temperature than it is to lower the temperature after the interior of the motorhome is already hot J 1 AIRSTREAM LAND YACHT GAS FURNACE See warning at top of page J 1 Manufacturer Hydro Flame Corporation 1874 South Pioneer Road Salt Lake City UT 84104 Phone 801 972 4621 The manufacturer of the furnace in your motorhome has been well known in the RV industry for many years The furnace burns LP gas and is powered by 12 volt current from the battery when there is no shoreline hookup or power converter when plugged into 120 volt shoreline Operating instructions are located in your Owners Packet If they should become misplaced new litera
86. ime the system may go into safety lockout about 20 110 Volt seconds before the air is all expelled from the lines Turning the switch off for 30 seconds then back on reinstates the try mode as The second switch is used to operate the water heater on 110 volt power This provides power to the heating element CAUTION DO NOT use the water heater system unless you are sure there is water in the water heater Open a faucet and see if there is a full stream of water on the hot side Be sure the water heater by pass valves are in the normal use position The water heater may be damaged if you disregard this caution The 110 volt element may be operated at the same time as the gas burner To operate the 110 volt by itself simply turn the electronic gas igniter switch off The heating element is 1500 watts so if breakers start to kick out when the air conditioner cycles you may want to turn the switch off the heating element and return to LP gas operation SAFETY If your water system is full and cold and the water heater is ignited the system can produce pressures as high as 120 psi before the relief valve starts to open Since the water system normally operates in the 40 psi range the water expansion does put unusual stress on the system This normally does not cause any problems but the stress is easily alleviated As the water is heating just open any faucet and run as little as a cup of water Just removing this small amount of water
87. impair ones ability to hear the smoke alarm For maximum protection a smoke detector should be installed in each sleeping area on every level of a home Although smoke detectors can help save lives by providing an early warning of a fire they are not a substitute for an insurance policy Homeowners and renters should have adequate insurance to protect their lives and property GOOD SAFETY HABITS DEVELOP AND PRACTICE A PLAN OF ESCAPE Make a floor plan indicating all doors and windows and at least two 2 escape routes from each room Second story windows may need a rope or chain ladder e Have a family meeting and discuss your escape plan showing everyone what to do in case of fire e Determine a place outside your home where you all can meet if a fire occurs e Familiarize everyone with the sound of the Smoke Alarm and train him or her to leave your home when they hear it e Practice a fire drill at least every six months Practice allows you to test your plan before an emergency you may not be able to reach your children It is important they know what to do AIRSTREAM LAND YACHT GAS WHAT TO DO WHEN THE ALARM SOUNDS e Leave immediately by your escape plan Every second counts so don t waste time getting dressed or picking up valuables Jn leaving don t open any inside door without first feeling its surface If hot or if you see smoke seeping through cracks AIRSTREAM LAND YACHT GAS ALARM CONDITION If the COSTAR s
88. in the exterior caulking and sealer of your unit Itis the responsibility of the owner to use reasonable prudent care to prevent foreseeable secondary damage from rain plumbing leaks and the natural accumulation of moisture in your unit such as a delaminated floor stained upholstery carpeting or drapes mold formation and growth furniture damage etc Mold is a natural growth given certain environmental conditions and is not covered by the terms of the Limited Warranty Deterioration by sunlight is possible to such items as tires curtains or upholstery Steel or metal surfaces are subject to the elements causing rust and corrosion that is normal and beyond the control and responsibility of Airstream AIRSTREAM LAND YACHT GAS OVERLOAD Overload Damage due to loading beyond capacity or to cause improper balance is not covered by the Airstream Limited Warranty The Airstream motorhome body is engineered to properly handle any normal load There are limits to the amount of load that can be safely transported depending upon speed and road conditions If these limits have been exceeded the Airstream Limited Warranty will not cover resulting damage For additional information on the load capacity of your motorhome consult your Owner s Manual or gross vehicle weight rating plate Each motorhome is aligned during the last quality inspection These tolerances will only change if the motorhome is subjected to abuse such as dropping off a sharp berm s
89. ing ambient temperature range is 32 to 115 F The pump will only prime if all pressure is relieved from the outlet port AIRSTREAM LAND YACHT GAS ELECTRICAL A The Aquajet RV pump has a motor speed controller that is factory pre set to operate at a minimum current of 10 amps while operating on a 12 VDC system A 15 amp fuse must protect the electrical system B The motor speed controller has a built in heat sink The temperature of this exposed aluminum surface may reach 200 after extended running C Care must be taken to insure proper connection of the positive wires red to red and negative black wires Reversing these lead wires will damage the electrical circuit board D The built in pressure sensing demand switch is factory preset to turn off the pump automatically at 65 PSI Trouble Shooting MOTOR DOES NOT OPERATE battery discharged Are any wires disconnected Are terminals corroded Is switch in ON position fuse good water frozen in pump head MOTOR RUNS BUT NO WATER FLOWS Is water tank empty Are there kinks in the inlet hose 3 air leaking into inlet hose fittings inlet line or in line filter plugged Tf using a filter check the line just before the filter Is outlet hose kinked WEIGHT 8 Ibs AIRSTREAM LAND YACHT GAS AQUAJET RV Pump Model 5503 4V15 B636 Identifying The Part Number 5503 4 V15 B 63 6 SPECIFICATION
90. ing the area Just reducing your load by 10 gallons of water lets you carry an awful lot of fishing and camping gear WEIGHING The unloaded vehicle weight UVW listed on the chart in your coach is the weight of the motorhome with the options as ordered and installed at the factory It includes all weight at the axles with full generator fluids including fuel engine oil and coolants To determine the actual weight of your vehicle with personal cargo water and LP it must be weighed on scales The most common scales are those used by states to weigh trucks used along the highway In rural areas grain elevators are a good source and another would be a gravel pit Note Weighing instructions for this motorhome are explained later in this section If you have trouble locating scales a call to your State Highway Patrol will usually find them very cooperative in assisting you B 1 AIRSTREAM LAND YACHT GAS SAFETY CHECK LIST Your Airstream motorhome should be given a thorough safety check before a trip Regular use of the following list will provide safe operation of your motorhome and will help you spot any malfunctioning equipment and correct the problem as soon as possible The list is to help you and may not be all inclusive Failure to heed the following items may cause damage to the vehicle or personal injury EXTERIOR CHECK LIST BEFORE ENTERING VEHICLE 1 2 8 Check condition of tires for inflation See tire
91. interrupted impurities can build up on the sensor When power is returned to the detector the detector alarm may activate until the impurities are burned off This could take a number of hours during which time the alarm will be constantly on DETECTOR TEST Press the test button for 5 to 6 seconds until the alarm sounds then release the test button The red LED should flash and the alarm sound for approximately 4 minutes This test should be performed at least once a week during normal vehicle operation and after periods of storage and before each trip LOW VOLTAGE Below 10 VDC the detector will continue to operate but will blink alternately green and orange Below 8 VDC the unit will behave erratically and will eventually shut off To ensure proper operation do not operate the unit below 10 VDC COMPONENT FAILURE The failure of any circuit component will cause the detector to display a continuous orange LED fault light and a short beep indicating failure If this occurs immediately contact your dealer or Airstream Customer Service for the name of the nearest detector service center Please read the operating instructions for your detector which have been supplied with the paper work of your unit Warning Have a professional technician check all safety related systems yearly or whenever any doubts of their ability to function properly arise AIRSTREAM LAND YACHT GAS OVERNIGHT STOP In time you will develop a knack for spotti
92. ion Pressure C 7 C 13 K 2 Interlr F 1 Inverter P B 4 Keyless Entry E 3 H 24 Lavatory Cleaning F 2 l veling i kossen D 7 D 9 Leveling Jacks D 7 H 1 Lights Interior B 4 H 2 121015 uskadde aros E 1 E 3 Loading u an asus B 1 K 2 Lounge iskrem reke isse 1 LP Gas Detector D 6 eter es G 1 Lug Nuts iiti entes C 8 C 9 Maintenance Schedule A 6 Microwave Ovens J 4 NG bl 4 8 Mold Prevention D 12 Monitor Panel G 30 H 9 Overnight D 7 AIRSTREAM LAND YACHT GAS Plumbing uet ote G 1 Power Seats oan eate tue ttes B 5 Range Oven x eee J 4 Refrigerator J 3 Roof Ladder E 4 Roof Vent J 6 Safety Defects Reporting A 5 Safety ispa B 2 D 1 G 2 G 6 Seat Belts s B 3 Servicers te A 5 Sewer Hose D 9 G 31 1 Shorts and Opens I 2 Shower Stall eet F 3 Slide Out room D 12 Smoke Alarm
93. irror very useful 3 Depress pedal and remove nut located in pedal recess 4 Reach behind toilet and remove nut on opposite side of base from pedals In some situations you may want to remove the plug in top of the seat designed to give access from above to this nut NOTE Always replace flange seal when toilet has been removed Winterizing Draining Method Disconnect water supply line at water valve Completely drain the water supply line before winter storage CAUTIQN To avoid damage when using air pressure to blow water from the lines be sure toilet valve is in the open position CAUTION If water is frozen in the toilet do not attempt to flush until with the ice thaws CAUTION Never use automotive type antifreeze G 21 AIRSTREAM LAND YACHT GAS Toilet 26 Ft Model Sealand Traveler Lite Model 111 Sealand Technology Inc P O Box 38 13128 State RT 226 Big Prairie Ohio 44611 800 321 9886 The Traveler toilet should be cleaned regularly for maximum sanitation and operational efficiency You can clean that just as you would a household toilet Do not use caustic chemicals such as drain opening types as they will damage the seals BOWL CLEANING for stubborn stains ease Brilliance liquid or toilet bowl cleaner Sealand manufactures it especially for use with Traveler and Traveler Lite toilets In certain locations where water is hard a buildup of the lime may dull the toilet bowl finish Restore the shine with
94. ision Turn the switch on when you want to watch the front television and you re not plugged into 110 volt power e Rear Monitor option 26 Ft when the ignition key is turned to the accessory or ON position the power will be supplied and the monitor will be in the standby condition When you set the gear lever to the R reverse position with the POWER switch released STANDBY the monitor will be automatically turned on and the picture will be displayed on the monitor To see rearview when not in reverse depress the power button to ON Please review the rearview monitor manual placed in your Silver Key notebook ARMREST SWITCHES e Exterior Mirrors Move center switch to R or L The four perimeter switches will then move the right or left mirror in the direction indicated Toggle switch operates heat e Power Window Located above the armrest operates the driver s window AIRSTREAM LAND YACHT GAS CAB SEATS Besides the normal power seat control there are two additional finger levers One allows the seat to recline and the other will let the seat rotate CAUTION Revolving the power seat completely around will pull the wiring apart The seats should only be swiveled to AIRSTREAM LAND YACHT GAS Procedure for Weighing A RV Vehicle should be weigh loaded as you normally travel 1 Fill in first row from Specification Section of this manual 2 Weigh vehicle as shown in row 2 Scale Weight and fill in blanks 3 Weig
95. l be increased if the shades are in the up position when your vehicle is stored F 1 AIRSTREAM LAND YACHT GAS INTERIOR cont Carpet The carpet can be cleaned with any good commercial carpet cleaner or with a detergent and water HOWEVER BE CAREFUL NOT TO SOAK THE CARPET WITH WATER Hardwood Flooring Daily care for the planked hardwood floor is by vacuuming Occasionally waxing with a non water base wax will help extend the life of the floor CAUTION Warn occupants of the vehicle when fresh wax has been applied just like a home the floor will be slippery Counter areas The counter areas around the sink are of a high pressure laminate or Corian and can be cleaned with soap and water or you can use a common solvent on tough spots Be sure no abrasive cleaner is used as there is the possibility it could scratch the surface protective pad should always be placed under hot utensils Sanding minor damaged areas can repair Corian counters The color of the material is constant and not just a surface coat Wall cabinets The vinyl walls of the motorhome can be wiped with any mild household cleaner The wood grain panel also has a vinyl covering for easy care The cabinet doors and framework are hardwood so any good furniture polish can be used CAUTION Do not use any abrasive material on the vinyl covered walls Bathroom The counter areas around the lavatory sink are of a high pressure laminate or Corian and can be c
96. leaned with soap and water or you can use a common solvent on tough spots Be sure no abrasive cleaner is used as there is the possibility it could scratch the surface Sanding minor damaged areas can repair Corian counters The color of the material is constant and not just a surface coat Shower Stall To clean your ULTRA GLAS shower stall unit use warm water and one of the stronger liquid detergents Do not use abrasive cleaners they may scratch and dull the surface of your ULTRA GLAS unit Stubborn stains can be removed with solvents such as turpentine paint thinner or acetone Restore dulled areas by rubbing with an automotive type liquid cleaner and then put the soft glow back into your ULTRA GLAS unit with a light application of liquid wax F 2 AIRSTREAM LAND YACHT GAS INTERIOR cont Vinyl Floor The vinyl floor in your unit can be cleaned with liquid floor cleaning solutions recommended for vinyl floors and warm water Fabric Cleaning A Warning Keep your furniture and family safe from fires caused by careless smoking Do not smoke when drowsy Remove immediately any flowing ash or a lighted cigarette that falls on furniture Smoldering smoking material can cause upholstered furniture fires All material should be professionally dry cleaned to remove any overall soiled condition These materials may be spot cleaned however using the cleanability code instructions as listed Sample swatches are furnished to our dealer
97. ll three vehicle batteries together for increased starting power e Generator Switch The remote generator switch on the dash allows the driver to start or stop the generator without leaving the driver s seat It should be noted a built in time delay allows the generator to reach full operating speed before 120 volt current is provided to the coach e Rear Heat 30 ft amp 33 Ft only this switch is two speeds and controls the fan on the rear engine heater by the door The heat source is from the radiator so heat will only be available when driving Rear Camera option 26 Ft the rear view monitoring camera has two positions One will show the rear bumper and operating the switch tilts the camera to view further back e Auxiliary Head Lights To operate the auxiliary lights the regular headlights must be turned on first e Defrost Fans option In cool damp weather these fans really help to clear the large windshields This switch turns them on and off and each fan has its own switch to operate the oscillating feature e Aisle Lights The low aisle lights will allow passengers to converse without using overhead lights that could be bothersome to a driver at night e Docking Lights option 26 Ft the docking lights illuminate the area at the side of the motorhome and are intended for use when parking in a campground at night e Inverter option This switch controls a relatively small Inverter wired into the front telev
98. loset flange height The height should be between 1 4 and 7 16 above the floor Adjust closet flange height accordingly and replace closet flange seal PROBLEM Foot pedal operates harder than normal or the blade sticks REMEDY a Apply a light film of Silicone spray to blade b Check closet bolt tightness If closet bolts are over tightened the mechanism may be distorted PROBLEM Bowl will not hold water i e water leaks from bowl down into the holding tank REMEDY Using a bent screwdriver or similar object scrape the groove in front of the mechanism blade Generally paper or other foreign material is lodged in this groove causing the leak CAUTION Use care not to damage the blade seal Always make certain that the tool is under the lip of the seal not above it The tool can easily be made by bending coat hanger or screwdriver over about 7 8 G 20 AIRSTREAM LAND YACHT GAS MAINTENANCE If the bowl sealing blade does not operate freely after extended use it may be restored to its original smooth operating condition by applying a light film of silicone spray to the blade To clean the toilet use Thetford Aqua Bowl or any other high grade non abrasive cleaner Do not use highly concentrated or high acid content household cleaners They may damage the rubber seals REMOVAL 1 Shut off water valve behind toilet or main water supply 2 Disconnect water supply line from toilet You will probably find a small m
99. lure to observe CAUTION can cause equipment damage if not observed Failure to observe A WARNING can lead to damaged equipment serious personal injury and or death if not observed Please read and follow all cautions and warnings If any questions arise contact your dealer or the factory customer service department Airstream Inc 2004 AIRSTREAM LAND YACHT GAS TABLE OF CONTENTS WARRANTY AND SERVICE G PLUMBING Warranty LP Liquid Petroleum Gas Warranty Explanation Water System Service Water Pump Reporting Safety Defects City Water Hookup Maintenance Schedule Black Tank Flush DRIVING Loading Weighing Safety Check List Airstream Dash Controls Motorhome Towing amp Driving Tips Weighing the Motorhome CHASSIS Component Identification Dash Air Conditioner Heater Tire Wheels Electric Step CAMPING Camping Safety Smoke Alarm LP Gas Alarm Overnight Stop Winter Traveling Extended Stay Slide Out Room EXTERIOR Cleaning Doors Locks Keyless Entry Roof Ladder Power Awning INTERIOR FURNISHINGS AND ACCESSORIES Lounge Chair Dinette Shades Flooring Counters Walls Cabinets Bathroom Fabric Care and Cleaning Drapes Exterior Water Service Faucets Toilet Storage and Winterizing Drainage System ELECTRICAL Battery Control Center 12 volt system 12 Volt Wiring Diagrams Monitor Panel TV Antenna Solar Panel 110 Volt System 110 Volt Power Switch over Box Shorts and Opens
100. mperfections should be brought to the attention of your dealer at the time of delivery and during pre delivery inspection Normal deterioration by use and exposure Is not covered by the Airstream Limited Warranty Damage to enameled or porcelain surfaces resulting from abrasion collision or impact and broken window glass is not covered by the Airstream Limited Warranty The Airstream Limited Warranty Excludes Normal Wear Items such as water purifier packs curtains upholstery floor coverings window door and vent seals may show wear within the one year Limited Warranty period depending upon the amount of usage weather and atmospheric conditions Accident Damage caused by accident is usually visible and we strongly urge our dealers and customers to inspect the motorhome upon delivery for any damage caused by accident while being delivered to the dealer or while it is on the dealer s lot Damage of this nature becomes the dealer s or your responsibility upon acceptance of the motorhome GLASS BREAKAGE whether obviously struck or mysterious is always accidental and covered by most insurance policies Abuse Lack of customer care and or improper maintenance including failure to comply with the terms of the Owner s Manual or failure to heed proper vehicle operation shown by the dash instruments is not covered by warranty Exposure It is the responsibility of the owner to take such preventative measures as are necessary to mainta
101. mportant to properly support the tires if blocks are used for leveling The following information is provided by the Michelin Technical Group Extreme caution must be taken to ensure that the tires are fully supported when using blocks to level motorhomes and or RV s The load on the tire should be evenly distributed on the block and in the case of duals evenly distributed on blocks for both tires If not property done the steel cables in the sidewall of the tires may be damaged and could lead to premature fatigue of the sidewall The CORRECT methods are shown in Figure 1 Please note that the blocks are wider than the tread and longer than the tire s footprint This provides maximum support to the tires and assures that the load is evenly distributed throughout the tire s footprint area Tire Foot Print Singles C 11 FFIGURE I CORRECT Dual Tire Foot Print AIRSTREAM LAND YACHT GAS INCORRECT One tire or a portion of one tire is supporting the full load Portion of two tires are supporting the full load Singles CAUTION Tires incorrectly supported as shown above may be damaged which could lead to casing failure resulting in serious injury or property damage If on previous occasions the tires have been incorrectly supported a hidden damage may be present Please contact your local Michelin dealer and request an inspection and a determination of possible
102. n accompanying literature will provide the best protection to the RV For more information of controlling moisture in the RV please read Tips to Controlling Condensation located in this manual Tf using a dehumidifier please read and follow all manufacturer instructions and recommendations to the use and cleaning of the dehumidifier AIRSTREAM LAND YACHT GAS SLIDE OUT OPERATION The slide out room on the Land Yacht Low Profile models is designed for easy deploy ment momentary switch located on the microwave cabinet operates the room To extend or retract the room push and release the switch The room will slide into position and stop automatically It is not necessary and could be harmful to hold the switch down during room operation To stop the room while it is in motion push and release the switch The room automatically reverses itself the next time the switch is pushed NOTE Before a slide out room can be deployed the ignition switch must be off We also recommend leveling the coach prior to deploying the slide out CAUTION 1 Level and stabilize unit before operating slide out room Failure to level unit may cause the room to operate improperly or cause damage 2 Check for adequate clearance to outside and inside objects before extending or retracting room Check that the driver s seat is forward enough to clear the room Before retracting room look at the exterior awning cover for the room and clear any debris
103. n lavatory cabinet and pull out vertical panel 1 valve is the brass exterior service valve Access 26 foot 30 foot On the side of the coach inside Exterior Water Service compartment 33 foot Roadside rear utility compartment Shut Off Valves 1 shut off valve will be inside the coach on the exterior water service line During cold weather usage you ll want to close the valve and open the brass exterior valve to drain the water so it won t freeze and burst Access 26 foot under rear roadside dinette seat 30 foot under lavatory just above shelf vertical backer 33 foot open lavatory cabinet and pull out vertical panel 1 shut off valve will be at the base of the toilet to shut off the water supply to the toilet for service or winterizing 1 shut off valve is for the optional icemaker Access 26 amp 30 Remove drawer under refrigerator 30 foot under lavatory 33 foot under galley against wall AIRSTREAM LAND YACHT GAS TOILET 30 amp 33 Models Manufacturer Thetford Corporation 7101 Jackson Road Ann Arbor MI 48103 313 769 6000 Canada Thetford Sanitation Ltd 2710 Slough Street Mississauga Ontario Canada L4T 163 The RV toilet in your Airstream is a design that has been used for many years In normal use when you are hooked up to city water both pedals are depressed together This dumps the sewage and fresh water and flushes down the side of the bowl Water will continu
104. n your new vehicle The terms of the Limited Warranty and only those terms will define Airstream s responsibility When you receive your Limited Warranty file it for safekeeping Upon proof of purchase date to any Airstream Dealer Service Center defects in materials or workmanship will be repaired or replaced without cost to the owner for a period of twenty four 24 months from the original purchase date or 30 000 miles whichever occurs first Written warranties of some manufacturers of components of the motorhome will be honored by Airstream for the duration on that manufacturer s warranty AIRSTREAM LAND YACHT GAS Items such as motorhome chassis engine tires batteries and generator are serviced by their respective manufacturers and will be handled by their service centers according to the terms of their written policy Any warranty forms from these manufacturers should be completed promptly preferably at time of purchase Your motorhome chassis is pre checked by its manufacturer before delivery to Airstream All service to the chassis must be performed by the manufacturer according to the manufacturer s warranty and service policies Literature is supplied with each Airstream motorhome that gives important information concerning its warranty coverage however the Airstream Limited Warranty covers the chassis heater defrosters windshield wiper blade motor washer LP gas bottle and gas regulator Paint and appearance items that show i
105. ndition is reached The manufacturer of the fabric designed the above code F 3 AIRSTREAM LAND YACHT GAS Drapes Use the following procedures to remove drapery panels for cleaning Front Wrap Around Drapes 1 Remove screws securing rear end of drapery track bracket to wall both roadside and curbside 2 Remove the plastic end cap 3 Slide draperies to the rear until they are clear of track 4 After reinstalling drapes replace the caps and refasten the track CAUTION All drapery materials and mattress covers must be professionally dry cleaned To prevent excessive wear to drapery linings blinds must be secured at the bottom and slats turned vertically when driving long distances Bench Dinette The dinette is hinged to the wall and is supported by one folding table leg To make into a bed the front of the table is lifted slightly and the leg is then folded up against the bottom of the tabletop The pressurized piston will hold it into place Raising the front of the table leaf further allows it to be unhooked from the wall The leaf will then swing out and down onto the support ledges on the front of the dinette seat The backrests are then laid on the table leaf to complete the bed On units with a freestanding dinette be sure to secure the dinette chairs to the dinette table support using the fabric straps CAUTION Never remove cushion cover for separate cleaning or washing Any tumble cleaning method can destroy the backing
106. nerator power is supplied to the 110 volt circuit breakers The circuit breakers are located under the front of the rear bed in the 30 amp 33 and in the top of the roadside wardrobe in the 26 If a circuit is over loaded or a short circuit occurs the breakers will kick out To reactivate the circuits turn the breaker to off reduce the load or correct the short and turn the breaker back to on One of the easiest and least disturbing way to reduce the 110 volt load is to turn off the water heater switch in the bathroom The water heater element draws about 12 amps One of the breakers is a GFI Ground Fault Interrupter breaker The intent of this breaker is to sense any loss of ground before a harmful shock could occur and kick the breaker out These sensitive breakers are installed in the circuit feeding the outside receptacle and galley area These are the areas where the use of water or the wet ground could put a person in danger of shock Since the GFI breaker is so sensitive it is not unusual to have it kick out for no apparent reason 110 VOLT SWITCHOVER BOX To protect linemen from an unexpected shock the generator must be wired through a switchover box Two automatic switch over boxes are located in the trunk storage area behind a false panel on the roadside of the area Generator City Power A To 110 volt circuit breakers B To generator 30 amp circuit C To city power When plugged into city power the current pa
107. ng gear SOLD ONLY housing and the base plate can restore normal operation AS COMPLETE Any spray type silicone lubricant may be used ASSEMBLY Elevate antenna and remove setscrew from rotating gear housing as shown Spray lubricant into hole and around edges of gear housing Rotate gear housing until lubricant coats bearing surfaces and antenna rotates freely Elevating Shaft Worm Gear Assembly Replacement Procedure NOTE It is not necessary to remove the rotating gear housing 11 from the base plate 14 or remove the antenna from the roof to replace the shaft and gear assembly STEP 1 Lower antenna to travel position Loosen set screw on elevating crank 23 remove crank spring 20 and directional handle 19 STEP 2 Remove top retaining ring 5 from top pin 4 holding top elevating tube in rotating gear housing and remove pin STEP 3 Remove plug from top of rotating gear housing elevating gear 8 and remove elevating shaft assembly 10 STEP 4 Cut new shaft to same length as one removed STEP 5 Lubricate worm gear on new elevating shaft assembly with spray silicone lubricant make sure wave washer flat washer and quad ring are on lower bearing and insert assembly in housing STEP 6 Install plastic plug in top of housing re engage elevating gear in worm gear replace pin and retaining ring STEP 7 Replace directional handle spring and elevating crank Make sure setscrew contacts flat on shaft before tig
108. ng wonderful little roadside locations by turning off the main highway and exploring There are many modern recreational vehicle parks including State County and Federal parks with good facilities where you may obtain hookups of electrical water and sewer connections Directories are published which describe in detail these parks and tell what is available in the way of services and hookups All you need to do to enjoy the self contained luxury is to 1 Turn on LP gas supply and light appliance pilots if required 2 Turn on water pump and open faucets until air is expelled from the system Before moving on turn off the LP gas and water pump check your campsite both for cleanliness and also to be sure you haven t left anything behind Make sure everything is properly stowed Overnight or Weekend Trips On overnight or weekend trips chances are you will not use up the capacity of the sewage holding tank deplete the water supply or run down the batteries which supply the living area 12 volt current Longer Trip On a longer trip when you have stayed where sewer connections and utility hookups were not available it will be necessary for you to stop from time to time to dispose of the waste in the holding tank and replenish the water supply Many gas stations chain and individually owned have installed sanitary dumping stations for just this purpose Booklets are available which list these dumping stations When you stop for the ni
109. oap amp water solution and reinstall J 6 AIRSTREAM LAND YACHT GAS AUTOMATIC SATELLITE SYSTEM Option The satellite system comes with an owner s manual The manufacturer requests that technical and warranty questions be directed to them KING DOME SATELLITE SYSTEMS Technical Support 1 800 SPECIFICATIONS Coach AIRSTREAM LAND YACHT GAS NOTE The weights and measurements in this manual are derived from the best information available at time of this manuals publishing Please refer to the weight information label placed in your unit and your chassis Owner s Manual for weights specific to your RV DIMENSIONS Exterior Height with Air Conditioner Interior Head Room Interior Width Exterior Length Exterior Width Exterior Width S O extended CAPACITIES LPG Tank Fresh Water Tank Grey Water Holding Tank Black Water Holding Tank Seating Capacity Seating Capacity Ibs Sleeping Capacity Sleeping Capacity Ibs Hitch Rating 26 FT 122 79 90 26 96 82 lbs 44 Gal 23 Gal 24 Gal 6 924 4 616 30 FT 122 79 90 31 2 96 90 Ibs 60 Gal 36 Gal 34 Gal 6 924 5 770 30 ft S O 122 79 90 31 2 96 118 82 lbs 60 Gal 36 Gal 34 Gal 5 770 4 616 33 FT 122 79 90 33 5 96 N A 105 lbs 60 Gal 36 Gal 29 Gal 6 924 5 770 4000 Lbs Gross Vehicular Weight 400 Lbs Hitch Weight
110. ou should wax it immediately or have your dealer wax it just prior to delivery In industrial areas cleaning and waxing should be done on a more frequent schedule Some areas may be fiberglass that is custom painted by Carrera Designs with an automotive finish As a general rule of thumb we recommend the motorhome be washed about every four weeks and waxed in the spring and fall also ALWAYS CLEAN YOUR MOTORHOME IN THE SHADE OR ON A CLOUDY DAY WHEN THE SKIN IS COOL Oil grease dust and dirt may be removed by washing with any mild non abrasive soap or detergent Cleaning should be followed by a thorough clean water rinse Spots and streaks may be prevented by drying the unit with a chamois or a soft cloth After cleaning and drying a good grade of nonabrasive automotive paste or liquid wax will increase the life of the finish especially in coastal areas where the finish is exposed to salt air or in polluted industrial areas It will also protect the shell from minor scratches and make subsequent cleaning easier It is important to remove sap gum resin asphalt etc as soon as possible after they appear by washing and re waxing Sunlight and time will bake harden these materials making them almost impossible to remove without heavy buffing If asphalt remains on the motorhome after washing use a small amount of kerosene on a rag and wipe the spots individually being careful not to scratch the finish It is recommended that the caulking
111. ou have to do is make sure the two coach batteries and engine battery does not run down In normal usage there isn t any problem since you would normally drive part of the day and be plugged into a campground at night The alternator charges the batteries when you drive When you re plugged into city power the converter charges the batteries and carries much of the load Some nights you may not find a place to plug into city power No problem the batteries total about 210 amp hours so you can comfortably run your lights and vents in a normal fashion without depleting the batteries If you are not plugged into city power and you re not driving you ll want to conserve your coach batteries by using as few lights and appliances as possible The Battery Control Center isolates the engine battery and coach batteries from each other preventing the coach 12 volt system from drawing down the engine battery If you notice the lights becoming dim it s much easier on the batteries if you go ahead and start the engine or generator before the batteries run down Interior Lights Many interior lights have been included in your motorhome to give you almost infinite variable light intensity There are two main clusters of light switches Just inside the main door on the galley end panel are switches for the step patio light and forward ceiling lights The forward ceiling lights must have their switches on before the remote switch on the galley end panel will
112. pension including Front Air Cylinders Brakes Drive Axle and Hubs Steering Assembly Rear Shocks Front Spindle Bearings Automotive Fuse Panel Steel Wheels Parking Brake Alternator Electric Fuel Pump Cruise Control Engine Battery Instrument Panel Cluster Engine Cooling System Tires see tire manufacturer service center Airstream Auxiliary Heater Leveling Jacks Dash Air Conditioner Heater Coach Batteries Windshield Wipers Battery Control Center Intellitec Hitch REESE Windshield Wipers The warranty on the dash air conditioner heater can be confusing The chassis manufacturer provides and installs the air conditioning compressor condenser dryer dual cooling fans and associated plumbing Airstream provides and installs the blower evaporator dash control heater core and heater hoses All venting and duct work is Airstreams The above list covers almost all of the chassis components If you need further clarification or information contact the Airstream Customer Relations Department at 937 596 6111 If you wish to write the address is Airstream Inc 419 W Pike Street P O Box 629 Jackson Center Ohio 45334 C 1 AIRSTREAM LAND YACHT GAS DASH AIR CONDITIONER HEATER Specific Climate Systems Inc 1200 West Risinger Road Fort Worth Texas Technical Assistance 1 800 275 7524 OPERATION The dash heater control is very similar to many automobiles The center rotary switch marked cold hot controls the amoun
113. plained to all traveling companions gt Warning At each campsite make sure you have not parked in such a manner as to block the operation of the escape window by being too close to trees fences or other impediments Scenic views are one reason for traveling but don t park so the beautiful lake or steep cliff is just outside your escape window gt Warning Read the directions carefully on the fire extinguisher If there is ally doubt on the operation you and your family should practice then replace or recharge the extinguisher You will find your local fire department will be happy to assist you and answer any questions gt Warning DON T SMOKE IN BED KEEP MATCHES OUT OF REACH OF SMALL CHILDREN DON T CLEAN WITH FLAMMABLE MATERIAL KEEP FLAMMABLE MATERIAL AWAY FROM OPEN FLAME We have all heard these warnings many times but they are still among the leading causes of fires Other safety information on the LPG system of your motorhome is located in the Plumbing Section of this manual SMOKE ALARM OPERATION TESTING OPERATION The smoke detector is operating once a fresh battery is installed and testing is complete When products of combustion are sensed the unit sounds a loud 85 db pulsating alarm until the air is cleared HUSH CONTROL The HUSH feature has the capability of temporarily desensitizing the alarm circuit for approximately 7 minutes This feature is to be used only when a known alarm condition such as
114. protective cover certainly helps to keep the vent on the regulator Fili valve Valve LP Tank from getting clogged by wasps or ice but should still be checked regularly to make sure the vent remains clear Regulator Cover A WARNING Do not attempt to seal regulator cover A WARNING Check vent each time tank is filled to make sure it is clear of obstructions Gas Regulator Removal Replacement 1 Shut off main gas supply at the tank Remove the plastic protective cover from the regulator assembly 3 Using two wrenches one to hold the line fitting and one to turn the flare nut disconnect the regulator from the flexible rubber line Disconnect the regulator from the tank fitting Remove regulator 5 Toreplace reverse the removal procedures G 3 AIRSTREAM LAND YACHT GAS TYPICAL LP GAS SYSTEM 1 2 3 4 5 6 7 8 9 601412 12 601410 601408 601409 601412 08 600435 601407 22 RANGE TOP WTR HTR REFRIG FURNACE HYDROFLAME Hose LP Tank to Regulator Connector M 50 Pipe to 62 Tube 1 2 Coupling Black Pipe 1 2 90 Degree Elbow 1 2 Tees Connector M 50 Pipe to 38 Tube Forged Flare Nuts 3 8 1 2 Sch 440 Bl Pipe 93 25 Lg 1 2 Sch 440 Bl Pipe 23 00 Lg 1 2 Sch 440 Bl Pipe 2 00 Lg Tubing Copper 3 80D Tubing Copper 3 80D Tubing Copper 3 80D Tubing Copper 3 80D G 4 AIRSTREAM LAND YACHT GAS WATER SYSTEM SELF CONTAINED The fresh water system consists of a water
115. re conventional RV industry pumps OPERATIONAL AND INSTALLATION GUIDELINES AQUAJET RV PUMP Partial Reprint Please contact Aquatec for complete instructions Please read these Operational and Installation Guidelines before installing or operating the AQUAJET RV PUMP If additional help is needed please consult the Factory CAUTIONS A The pump is equipped with an electrical speed controller please insure that electrical connections are made in accordance with these instructions B The pump is equipped with a pressure sensing demand switch which controls the maximum operating pressure as set at the Factory Never subject the pump to pressures above 125 PST 9 5 bars C Never operate the pump in a harsh environment or hazardous atmosphere since motor brush and switch may cause electrical arcing D Pump head materials are designed for use with water only Do not use with petroleum products As long as there is inlet water pressure the pump will not stop forward flow of water even if the motor is turned off Be sure the system has a positive means of shutting off water supply F Always consider electrical shock hazards when working with and handling electrical equipment If uncertain consult an Electrician Electrical wiring should be done by a qualified electrician only and all local and State Electrical Codes must be followed Do not subject the pump to extreme high or low freezing temperatures while in operation Operat
116. rized service center please call 1 800 321 9886 between the hours of 8 00 AM and 5 00 PM Eastern Time G 23 AIRSTREAM LAND YACHT GAS DRAIN LINES BELOW FLOOR 33 FOOT A 601493 Black Tank B 601492 Grey Tank C 601251 Bayonet Ring 0 D 601250 Bayonet Cap E 601432 Adapter F 600866 3 Way Elbow G 600289 3 Coupler H 601160 04 3 Diax 3 J 601160 04 3 Dia x 10 K 601266 4 x 3 Closet Flange L 601430 3 Gate Valve 30 Ft Drain 1 601567 Black holding tank 2 601492 Gray water tank 3 601843 Dump valve assembly rotating w cap 4 601846 3 pipe adaptor sensor 601160 04 Pipe ABS DVW 3 601160 02 Pipe ABS DVW 1 5 G 24 AIRSTREAM LAND YACHT GAS PLUMBING DRAIN WATER 26 FT 1 601794 Gray water tank 2 601795 Black water tank 3 601160 02 Pipe 1 ABS DVW 4 63 long 4 601482 Dump valve rotating assembly 5 601160 04 Pipe 3 ABS DVW 4 63 long 453810 Bracket holding tank 453981 Support holding tank 601441 System tank flush 601786 Water fill tank flush 914189 PAN ASSY BLACK TANK 914196 PAN ASSY GRAY TANK G 25 AIRSTREAM LAND YACHT GAS 33 FT DRAIN LINE ABOVE FLOOR REVISION RECORD BY PRODUCTION RELEASE mn Tea 22 600030 ELL ABS 45 DEGREES LG TURN 7 EE EE ELL ABS LONG SWEEP 1 172 ed Airs tream me GREY VENT G 26 AIRSTREAM LAND YACHT GAS 30 Above Floor Drain System GREY VENT 600378 600144 601201 60131
117. s The dealer will be able to give you the cleaning code and part number for the fabrics used in your particular motorhome The following are the cleanability code instructions for the various fabrics used in the Airstream motorhomes Cleanability Codes CODE W S Fabric care Spot clean this fabric either with a mild solvent or a water based cleaning agent When using a solvent or dry cleaning product follow instructions carefully and clean only in a well ventilated room Avoid any product that contains highly toxic carbon tetrachloride You may also use an upholstery shampoo product or the foam from a mild detergent With either method pretest a small area before proceeding Use professional furniture cleaner when an overall soiled condition is reached CODE S Fabric care Spot clean using a mild water free solvent or dry cleaning product Carefully follow instructions on such product Clean only in a well ventilated room Avoid any product containing carbon tetrachloride which is highly toxic Pretest small area before proceeding Use professional furniture cleaner when an overall soiled condition is reached CODE W Fabric care Spot clean using the foam only from a water based cleaning agent such as mild detergent or non solvent upholstery shampoo product Apply foam with a soft brush in a circular motion Vacuum the area its when dry Pretest small area before proceeding Use professional furniture cleaner when an overall soiled co
118. s are located on the lower rear roadside corner of the motorhome Pull the dump valve handle out as far as it will go and wait until the tank is drained If the auxiliary tank is drained after the waste tank the soapy water will help keep the sewer hose and outlet clean The main holding tank must be flushed out until all paper and waste material is removed Close the dump valve and refill the tank with 5 to 10 gallons of clean water and repeat until clean G 31 AIRSTREAM LAND YACHT GAS When Parked and Connected to Sewer Outlet When you are in a park and connected to a sewer outlet keep the main holding tank dump valve closed and empty the tank every few days or whenever it becomes almost full ONLY BY SENDING A LARGE VOLUME OF LIQUID THROUGH THE MAIN HOLDING TANK AT A TIME WILL TOILET PAPER AND OTHER SOLIDS COMPLETELY WASH AWAY This practice will avoid the accumulation of solids in the main holding tank which could lead to an unpleasant cleaning job Should solids accumulate close the dump valve fill the tank about half full with water then drive the motorhome for a few miles The turbulence and surging of the water will usually dissolve the solids into suspension so the tank can be drained Keep the auxiliary tank valve open when connected to a sewer outlet Draining the tanks as described will protect them from freezing during storage When traveling in sub freezing temperatures use a winterizing solution designed for RV use Follo
119. s securely held in place Check that lights and switches are set in positions safe for travel Adjust the driver s seat so that you can easily reach and operate all controls Make sure seat is locked in position Do not adjust driver s seat swivel or fore and aft mechanism while vehicle is moving The seat could move unexpectedly causing loss of control Check that front passenger s seat is locked in position both fore and aft adjustment and swivel mechanism AIRSTREAM LAND YACHT GAS INTERIOR CHECK LIST BEFORE DRIVING OFF 13 Check rear view mirror adjustment inside and outside Adjust curtains if necessary for maximum visibility 14 Secure children in a Federally Approved Child Restraint Device 15 Fasten your lap belts 16 Check that step light goes out and that electric step has retracted SAFETY SEAT BELTS In the forward driver s area of the motorhome safety seat belts are provided for the use of the driver and the right front passenger Safety belts are available for other seats It is strongly recommended that all occupants remain seated with their safety belts firmly attached while the motorhome is in transit The driver should adjust his seat so that he is able to reach all controls easily with the belt on especially able to use all the travel on the foot brake The belt should be placed as low as possible around the hips to prevent sliding out from under them in case of accident This places the load of the body on t
120. se only Microtech 400 or 600 filter cartridges with the PureTouch Classic Filtering Faucet system The Microtech filters are high performance carbon block filters developed specifically for the PureTouch system AIRSTREAM LAND YACHT GAS OPERATING INSTRUCTIONS Controlling The Water The PureTouch system has two options for water delivery unfiltered stream and filtered water STREAM MODE Unfiltered water in regular stream flow When the water is turned on at the faucet the spout will always begin operating in the regular stream mode FILTERED WATER MODE Filtered water dispensed though the separate filtered water outlet Pressing the front filtered water button will divert water through the filter and dispense filtered water from a separate outlet To exit the filter mode shut off the faucet CAUTION Only filter cold water Do not filter water above 100 degrees F Electronic Indicator The flashing light on the electronic filter life indicator provides information regarding the performance of the filter The indicator provides you with information throughout the life of the filter to help communicate the level at which it is performing Indicate Color Performance Amber amp Green A new filter must be flushed with cold water for 5 minutes after it is installed This procedure helps clean the filter of loose carbon particles Green Filter performing at optimum efficiency Amber Warning Filter is ready for replacement
121. se to the city water service or the hose from the water reel if so equipped Plug the Electrical Cable into the City Power Service Be sure you have the wire grounded and have the proper polarity See Electrical Section for technical details Cable TV Telephone Hookup is located on the roadside rear corner of the motorhome The television booster must be turned off for the cable system to operate properly To use the Generator you simply start it All switching is done automatically The generator can be started either from your interior monitor panel dash switch or the switch on the generator itself It is easier on your generator and appliances if you ll allow the generator to reach its normal operating speed about a minute prior to applying heavy current loads Hook your Waste Drain Hose into the Sewer Disposal Facility and attach to the drain outlet in your motorhome For details on this procedure see Drain and Waste System Section Turn on the gas supply and light the oven pilot Lighting a top range burner to bleed any air from the system will make it easier to start other appliances When you stay for extended periods where electric or water hookups are not available you must make regular checks on the condition of your 12 volt battery and the contents of your water tank Carry drinking water in a clean bucket to refill your tank When your waste tank nears capacity move your motorhome to a dumping location A WARNING The escap
122. service and parts manuals are available from the manufacturer A Warning The operation manual for the range is titled Maytag RV Cooking Appliances If this has not been provided with your motorhome contact the manufacturer listed at the top of the page to obtain Their manual contains specialized warnings and cautions that should be reviewed prior to operating the appliance MICROWAVE OVENS Only federally certified technicians are permitted to service microwave ovens For this reason the only service instructions contained in this manual are for removal of the complete oven If you have a microwave problem please contact the appropriate manufacturer Dometic Sales Corporation Sharp Electronics Corporation 2320 Industrial Parkway 10 Sharp Plaza P O Box 490 Paramus New Jersey 07652 Elkhart IN 46515 201 5112 0055 219 295 5228 Airstream has used two different methods of holding the ovens in place The most common is a setscrew configuration where two bolts apply downward pressure on top of the range The bolts can be found in the cabinet directly above the oven and out toward the front Back them out a few turns and the front of the oven can be lifted up and out over the lower ledge The second method was to slide a piece of 3 4 pine board under the microwave in front of the rear supports Once in place screws were run up through the bottom shelf into the 3 4 pine You will note neither method makes any holes in the microwave cabinet
123. set forth in detail in the folder and in the explanation of the basic Airstream Limited Warranty covered in the Airstream Motorhome Owner s Manual Airstream Inc will not be responsible for additional representations or implied warranties made by any of its dealers to the extent those representations are not a part of or are contrary to the terms and conditions of the basic Airstream Limited Warranty AIRSTREAM LAND YACHT GAS CONSEQUENTIAL AND INCIDENTAL DAMAGES Airstream Inc will not be responsible for any consequential or incidental expenses or damages resulting from a defect Incidental expenses include but are not limited to travel expenses gasoline oil lodging meals telephone tolls and loss of work and loss of use of the motorhome Some examples of consequential damages would be stained curtains due to rain leaks or delaminated floor caused by a plumbing leak Some states do not allow the exclusion or limitation of incidental or consequential damages so the above limitation or exclusion may not apply to you WARRANTY TRANSFER The basic Airstream Limited Warranty is transferable to subsequent owners for the duration of the warranty period Warranty transfer application forms are available from your dealer or the Airstream Inc Service Administration Department CONSUMER ARBITRATION PROGRAM Airstream Inc participates in the consumer Arbitration Program for Recreational Vehicle CAP RV This third party dispute resolution
124. side the lamp assembly through atmospheric changes reaches the dew point When this takes place the moisture in the air within the lamp assembly condenses creating a fine mist or white fog on the inside surface of the lamp lens or chrome reflector surfaces The headlamps are designed to remove accumulated moisture vapor by expelling it through a vent system as the light warms up The vent system operates at all times however it is most effective when the lamps are on and the vehicle is in motion Since most RV s are parked for long periods of time they have a greater chance of condensation build up e Check headlamp regularly for condensed water drops daily in high humidity areas e If small drops of condensed water are noted drive your RV with headlamps ON or just turn ON the headlamps This will evaporate the condensed water drops and will avoid water being accumulated Depending on the size shape and location of the lamp on the RV and the atmospheric conditions occurring the amount of time required to clear the lamp may vary from 2 to 6 hours e Check your vent tubes this will be a small rubber hose or plastic cap located on the back of the light make sure that they are free of dirt and the rubber is not cracked and dried out If the vent tubes are clogged or cracked and dried out the vent system will not work correctly allowing condensation to build up in the lamp If the tube is cracked or dried out please repl
125. step 6 G BLACK WATER In this example Fresh Gray 1 and Black have passed calibration Gray Water 2 and LP Gas were not installed and E READY FOR FULL therefore they will not be reported in normal operation B READY FOR EMPTY Display after completion of step 5 On all diagrams the Letters R Red G Green Y Yellow SELECT TANK Blank no LED lit DIAGNOSTICS STEP 6 Action Remove the calibration decal on the lower 4 LED s Press and release status button 1 time Result Display will turn red from empty to full 1 time turn green from empty to full I time and all flash green I time Power on greeting will be played and installed tank levels will be displayed Calibration is complete AIRSTREAM LAND YACHT GAS TV ANTENNA Manufacturer Winegard Company 3000 Kirkwood Street Burlington Iowa 52601 Phone 800 843 4741 Raising Antenna to Operating Position Kaising Antenna Turn elevating crank in UP direction until some resistance to turning is noted Antenna is now in operating position Check to make sure switch on front TV jack is on Rotating Antenna Make sure antenna is in UP position Pull down on directional handle with both hands until it disengages ceiling plate and rotate for best picture and sound on television set Lowering Antenna to Travel Position Rotate antenna until pointer on directional handle aligns with pointer on ceiling plate CAUTION Antenna must be in down position while
126. t frequent inquiries regarding the operation function and care of the many systems that make modern motor homing a joy Airstream realizes our customers possess varying degrees of expertise in the area of repairing and maintaining the appliances in their motorhome For this reason the service and trouble shooting information found in this manual is directed toward those with average mechanical skills We also realize you may be more familiar in one area than you are in another Only you know your capabilities and limitations We want you to use this manual and hope you will find the information contained in it useful however should you ever feel you may be getting in over your head please see your dealer to have the repairs made The operation and care of component parts such as chassis refrigerator furnace water heater and others are briefly explained in this manual However you will also find the complete manufacturer s information supplied in a packet included with this manual Note All information illustrations and specifications contained in the literature are based on the latest product information available at the time of publication approval Airstream reserves the right to make changes if and when new materials and or production techniques are developed that can improve the quality of its product or when material substitutions are necessary due to availability Throughout this manual CAUTION and Aae notations are used Fai
127. t of hot water flowing through the heater core When the maximum air conditioner is engaged inside air is circulated through the evaporator to obtain the utmost in cooling The two positions marked vent and norm draw outside air through the evaporator SERVICE Automotive Air conditioning has become a very specialized business requiring specific training and refrigerant disposal certifications SCS has requested you to contact them on the toll free number listed above should you experience any service problems Please contact SCS immediately if a warranty situation develops that your local dealer is unable to solve They will authorize repairs and assist the dealer and if necessary aid you in obtaining service at an authorized air conditioner repair facility close to your location This service locater assistance can be especially helpful if you are traveling and an Airstream dealer is unavailable or a considerable distance away The following pages include wiring diagrams and vacuum line diagrams C 2 AIRSTREAM LAND YACHT GAS SCS Frigette MOTORHOME HVAC SYSTEMS 1 087 00219 DOOR ASSEMBLY 7 034 00029 EXPANSION VALVE 2 062 00605 CASE 8 045 00521 INSULATION 13 05100362 10 HOSE ASSY L29 3 030 00046 VACUUM MOTOR 9 071 00680 BACK PANEL 14 03400049 SERVICE VALVE 4 042 00044 HEATER COIL 10 033 00003 THERMOSTAT 15 085 0466 6 HOSE ASSY 5 062 00623 BUSHING 11 035 00006 RESISTOR 16 05000120 Q C COUPLING FM 6 041 00157 EVAPORA
128. t the air must be forced out through the lines by gas pressure before you can light the pilots Hold a match to the pilot of the appliance closest to the tanks until it lights and stays lit Then move to the next closest etc A Warning e All pilot lights and appliances must be turned off during refueling of motorhome fuel tank and permanently mounted LPG tank Gas lines should be checked periodically for leaks with ammonia free soapy water Do not use open flame A Warning If gas can be smelled appliance pilots fail to stay on or any other abnormal situation occurs shut off tank valve immediately and call on a qualified LPG service center or Airstream Service Center CAUTION Moisture in the LPG tank will cause a malfunction of the regulator in controlling proper pressure This may result in the flame lifting off the burner or the flame may go out frequently Many refueling stations will add approximately to gallon of alcohol to lower the moisture temperature Moisture will then pass through the regulator without the formation of ice crystals LPG Regulator The LPG regulators used on Airstream motorhomes are designed for low pressure service with a normal outlet pressure setting of 11 5 inches water column Only personnel trained in the proper procedures codes standards etc should service regulators Have the regulator inspected each time the tank is refilled Make sure the regulator vent opening on both first and second stage re
129. t your lines and faucets from extremely high pressures on some city water systems An after market external regulator could lower the water pressure at the inlet and thus to your faucets and shower BLACK TANK FLUSH BLACK TANK FLUSH ASSEMBLY On the side of the 26 and 30 motorhomes is a large utility compartment with a keyed door A spigot and garden hose female connector is inside On the 33 model in the Water hose connector Check valve is Elbow roadside rear utility compartment on the left Vacuum breaker rear lower side 1s a water hose connector 1 2 tubing marked black tank flush and the exterior Spray head water spigot Hook up a 1 2 or larger water hose and turn it on full force Within the tank a multiple holed plastic water line will spray the interior surface of the tank The gate valve should be closed for the first SEXTERIOR RV WALL HOLDING TANK WALL couple of minutes to let some water accumulate in the tank and then opened to let the water out in a rush Repeat as needed AIRSTREAM LAND YACHT GAS EXTERIOR WATER SERVICE On the side of the 26 and 30 motorhomes is a large utility compartment with a keyed door A spigot and garden hose female connector is inside On the 33 model in the roadside rear utility compartment on the left rear lower side is a water hose connector marked black tank flush and the exterior water spigot The spigot is plumbed into the fresh water system of
130. th is from C to A When you start your generator and unplug from city power the points switch and the power flow is from B to A If you re plugged into city and you start the generator city power has the priority so the current flow is C to A Rear Air Conditioner A To rear air conditioner B Generator 20 amp circuit C To front rear air conditioner Automatic Energy Select Switch AIRSTREAM LAND YACHT GAS SWITCHOVER BOX cont When you have the optional 50 amp service the red wire shown on the following diagram will be providing power to the rear air conditioner whether you are plugged into city power or operating the generator SWITCH OVER BOX 50 AMP PS 260 2 POWER SWITCH ELECTRICAL CONNECTIONS BN iW p M s zi NVE 8 GA BARE COPPER 6 3 W GRN ROME X 6 3W GRN Locating Shorts and Opens The key in locating shorts and opens is isolation The first step to isolate the circuit with the short or open The second step is to then isolate the section of the circuit with the fault Once the section is identified the specific problem can be located The cause may be a loose or corroded connection cut wire worn insulation or defective component The following procedure is one method for isolating shorts and opens SHORTS 1 Isolate the circuit that has the short by noting which circuit has tripped 2 Disconnect the power inlet cord from the power source 3 Using the 120V schematic as
131. that may have fallen onto it 3 Read and follow all warning labels in the coach A WARNING To prevent accidental injury stand clear of room while it is in motion Check interior and exterior of motorhome for people that may be struck or pinned by the room Never attempt to move the motorhome with the room extended The motor for the slide out mechanism has an emergency retraction expansion feature The motor is located under the lounge bolted to the floor It is accessible by removing the lounge s front panel The end of the motor has a nut that can be turned with a wrench or a socket and ratchet The slide out mechanism manufacturer also provides a flexible socket extension that can be mounted to an electric drill chuck for easier operation of this emergency procedure Turn the nut until the room is returned to its storage position AIRSTREAM LAND YACHT GAS EXTERIOR The sidewalls and roof of your Airstream Land Yacht motorhome are laminated fiberglass with a gel coat exterior finish No paint means the small mars and scratches can be polished out or repaired using gel coat We recommend this be done professionally since excessive polishing can remove the gel coat There is no magic to caring for your motorhome The finish is the same as non painted fiberglass boats As a general rule of thumb we recommend the motorhome be washed about every four weeks and waxed in the spring and fall To make sure your new unit is always protected y
132. the heat back on Is the temperature dropping or rising Remember the wind chill factor when driving 50 MPH will cause the interior of the motorhome to cool much faster than when it is parked 1 You must have a plentiful supply of propane gas 2 If your stay is longer than overnight you should endeavor to have 120 volt electricity available The batteries fully charged will not last more than about 15 hours in freezing weather Of course you can run your generator to recharge the batteries or even use the generator continually Since the generator starts off the same battery as the engine it is recommended to start the generator prior to shutting off the engine This will prevent running the engine battery down should there be a difficulty in starting the generator in the cold temperatures 3 Minimize use of electricity if 120 volt power source is not available 4 Leave cabinet doors bed doors and wardrobe doors slightly open at flight to allow circulation of air in and around all furniture components 5 Use propylene glycol type antifreeze in waste and drain water tanks to prevent freezing Quantity of antifreeze needed will vary with ambient temperature and the amount of liquids in tank 6 For extended stays in cold weather insulate the water line outside the motorhome You should remember that low temperatures in combination with high winds cause an equivalent chill temperature much below what your thermometer is reading For inst
133. the motorhome This is an ideal place to rinse the sand off your feet after going to the beach cleaning mud off your boots and hundreds of other messy jobs that are better done outside of your motorhome GALLEY FAUCET MOEN PURETOUCH CLASSIC WATER FILTRATION SAFEGUARDS Your Moen PureTouch Classic Filtering Faucet System integrates carbon block filtration technology designed by Culligan International into a faucet spout This technology is fast and effective at reducing contaminants commonly found in water and is certified by NSF International The PureTouch Filtering Faucet System and installation must comply with State and Local laws and regulations To ensure optimal operation of your new Moen faucet please read the following safeguards carefully MicroTech Filter Cartridges MicroTech filter cartridges will reduce Chlorine Taste and Odor MicroTech 400 600 Lead MicroTech 400 600 Cysts Cryptosporidium Giardia MicroTech 600 The contaminants removed or reduced by this filter are not necessarily in your water e Do not use with water that is microbiologically unsafe or of unknown quality without adequate disinfections before or after the system Systems certified for cyst reduction may be used on disinfected waters that may contain filterable cysts MicroTech filter cartridges are designed for replacement after dispensing 200 gallons of filtered water Water conditions and usage may affect filter life and water taste e
134. the water pump switch located on the monitor panel or connecting to an exterior city water source For some time the open faucet will only sputter This is because the water heater is being filled and air is being pushed out through the lines Once the water heater is full a steady stream of water will come from the faucet Now open a cold faucet It will sputter for a short time but will soon expel a steady stream All other faucets can now be opened until all air is expelled Once the system is filled with water and the faucets are closed the water pump will shut off To prevent equipment damage the water heater should only be started after the water system is primed and ready for use When a faucet is opened the pump will come back on automatically If the faucet is just barely open it is normal for the pump to cycle on and off rapidly It is normal for a pump to occasionally cycle when all faucets are off to keep the water pressure at the set point however if it cycles frequently more than a few times an hour the plumbing system and pump should be checked to be sure it is not loosing pressure through a slow water leak or back through the pump Note Water pressure at some campgrounds may be low The water pump can be turned on to assist the city water pressure Be sure there is water in the fresh water tank The pump will only use the water that is needed out of the tank to bring the pressure up to the usual standard Caution Turn the
135. ther written or oral express or implied shall extend only for a period of two years from the date of original purchase or 30 000 miles whichever comes first There are no other warranties which extend beyond those described on the face hereof and which expressly excludes conditions resulting from normal wear accident abuse exposure or overload Some states do not allow limitation on how long an implied warranty lasts so the above limitations may not apply to you AIRSTREAM S RESPONSIBILITY The basic Airstream Limited Warranty applies for a period of two years from the date of original purchase or 30 000 miles whichever comes first and the application date of all warranties is that indicated on the owner s Limited Warranty Defects in items covered under this Warranty will be corrected without cost upon the return at the owner s expense of the motorhome or defective part to an authorized Airstream dealer AIRSTREAM LAND YACHT GAS CARE AND MAINTENANCE This warranty covers only defective material and or workmanship adjustments are made at the factory prior to shipment and rechecked by the dealer prior to delivery to the customer Adjustments thereafter become a customer responsibility The owner is also responsible for following all recommendations instructions and precautions contained in the Airstream Motorhome Owner s Manual and the individual manuals furnished by the chassis appliance and other manufacturers INSTALLATIONS
136. this warning could result in loss of control of the motorhome and towed vehicle or trailer and may cause an accident and serious injury WARNING READ AND FOLLOW ALL WARNINGS IN THE FUEL SECTION OF YOUR CHASSIS OWNER S MANUAL BEFORE FUELING YOUR VEHICLE K 2 AIRSTREAM LAND YACHT GAS Air Conditioner C 2 J 1 200 roni C 8 AMEN aS amtata H 14 J 1 Automotive Fuses H 3 Auxiliary seen C 7 Auxiliary Start Switch B 4 B throom enini F 2 Battery Control Center H 1 Black Tank Flush G 10 G 32 Bottled Gas cem G 1 Breaker Panel 110 Volt I 5 Cab Se ts B 5 Cabinets eine F 2 Camping getestet ore D 1 Capacities K 1 K 2 Carbon Monoxide Alarm D 4 Carpet deat eine F 2 Caution eese ect Introduction Chairs mysen eee F 1 CHASSIS u aasan qa sq C 1 K 2 Circuit Breakers 12 Volt H 4 Circuit Breakers 110 volt I 1 1 5 I 6 City Hook Up G 10 Cleaning Codes sese F 3 Cleaning Exterior sese E 1 Condensation D 10 Control Panel H 9 Count
137. tic Energy Selector Switch shown on the previous page controls this function Front a c is priority The rear a c will cool when the cool mode is selected on it and when the front a c has finished its cooling process and the thermostat shuts it down The front a c will come back on as its thermostat detects the need to cool and the rear a c will shut off The A C fan powered by 12 volt on both units will run even if the other is cooling on the 120 volt circuit Turn the front a c to fan or off to run the rear a c only Another appliance drawing a lot of current is the microwave Operating the microwave and an air conditioner at the same time will put your electrical system at the edge of maximum draw If the air conditioner goes into a start up cycle the additional current will probably cause your main circuit breaker to kick out If this situation occurs it is best to leave the air conditioner off for the few minutes the microwave is normally operated Both air conditioners may be operated when the generator is running or if you have optional 50 amp service When the generator is running the front air conditioner is powered through the normal shoreline circuit on the generator 30 amp circuit The generator powers the rear air conditioner through its 20 amp circuit at the same time The voltage to the air conditioner is critical We commonly refer to 110 or 120 volts but a check with a volt meter may find voltage much lower Your air conditioner w
138. tification label Tires must be inflated to these pressures when the vehicle is fully loaded or an axle GAWR is reached Cold Inflation Pressure PSI Model Tire Size Front Rear Duals 26 ft 15 000 GVWR 225 70R x 19 5F 80 psi 90 psi 30 ft 18 000 GVWR 225 70R x 19 5F 80 psi 90 psi 33 ft 18 000 GVWR 225 70R x 19 5F 80 psi 90 psi C 7 AIRSTREAM LAND YACHT GAS Proper FRONT END ALIGNMENT improves tire tread mileage Your front end suspension parts should be inspected periodically and aligned when needed Improper alignment may not cause the vehicle to vibrate However improper toe alignment will cause front tires to roll at an angle which will result in faster tire wear Incorrect caster or camber alignment will cause your front tires to wear unevenly and can cause the vehicle to pull to the left or right The chassis front air bags should be inflated as instructed in chassis owner s manual and checked monthly Caution Chassis manufacturer urges each owner to have the front end alignment checked after they have loaded the motorhome as they would on a trip WHEEL COVER The new wheel covers on our motorhomes are removed by pulling off two of the lug nut covers The two of ten loose ones are identified by indentations on three sides to hold them on the nut and there are no flanges You will have to look close the first time to find them Once the nut covers are pulled off the lug nut extension holding the whe
139. til the LED beside the system that you want the condition of is lit Release the status button and the monitor will display the exact condition of that system by lighting the bar graph from Empty AIRSTREAM LAND YACHT GAS MICROPULSE SYSTEMS MONITOR CALIBRATION PROCEDURE STEP 1 MONITOR DISPLAY Action Turn the power on 3 FRESH WATER Result Display will flash all yellow 1 time flash all green 5 G GRAY WATER 1 times and then display all green This confirms that the monitor Gi GRAY WATER 2 is in the calibration mode Proceed to step two G BLACK WATER GAS READY FOR FULL G READY FOR EMPTY SELECT TANK G DIAGNOSTICS Display after completion of step one On all diagrams the Letters R Red G Green Y Yellow Blank no LED lit STEP 2 Action Press and release the status button one time MONITOR DISPLAY Result This enters the monitor into diagnostics Display will light the Fresh Water Gray Water 1 Gray Water 2 Black Water and LP Gas The Diagnostic LED will light green If a sensor is G FRESH WATER installed and is working correctly the LED beside the system will G GRAY WATER 1 light green If a sensor is not installed or is not connected the GRAY WATER 2 LED beside the system will display yellow If a system LED displays yellow it will not be included in the calibration 6 BEACK WATER routine The most likely cause is the RJ11 connectors are not installed correctly or the sensor is not plugged
140. to the figures below for lubrication locations Clevis pin Figure 7 NOTE Figures are to be used as a general reference only Some may not pertain to your particular step model Views are typical to both ends of the steps 1 Figures 1 amp 3 square shaft bearing lubricate around outside and under head of bearing 2 Figure 4 on step models equipped with plastic cover this cover will have to be removed to lubricate center bearings Lubricate bearings under cover every 90 days 3 Figure 4 1 O D tube bearing lubricate around drive tube and between head of bearing and drive leg NOTE We recommend that penetrating oils and silicone lubricants not be used on the step as they do not last C 17 AIRSTREAM LAND YACHT GAS Composite Headlamp Your new Motor Home is equipped with a composite headlamp system Composite headlamps are designed much differently than the sealed beam units of the 70 80s they are a plastic lens and chrome plated reflector assembly designed around a replaceable halogen bulb Composite lamps produce significantly greater light offering better visibility and safety for the driver Composite lamps also offer the convenience of a low cost replaceable bulb making the maintenance of the headlamp an easy task Seeing at night is what it is all about with that in mind we have a few maintenance tips to keep your headlamps functioning properly e Maintenance Condensation occurs when the air in
141. traveling to prevent damage Turn elevating crank in the Down direction until resistance is noted Antenna is now locked in travel position Checking Operation 1 Tune TV receiver to nearest station and rotate antenna for best picture and sound 2 Turn off switch on power supply Picture on TV receiver should be considerably degraded with the power off Lowering Antenna DO S 1 Do check parking location for obstructions before raising Y antenna 2 Do carefully raise lower and rotate if difficult check for cause 3 Do rotate slowly when selecting station and check fine HOR tuning on TV set to make sure it is properly adjusted 4 Do lower antenna before moving vehicle DON TS 1 Don t force elevating crank up or down Check for cause of trouble 2 Don t rotate directional handle hard against stops 3 Don t travel with lift in up position 4 Don t leave lift part way up or down 5 Don t apply sealing compound or paint over top of base plate or anywhere on lift H 14 AIRSTREAM LAND YACHT GAS Maintenance LUBRICATE HERE Lubrication To lubricate the elevating gear apply a liberal amount of silicone spray lubricant to the elevating gear with the lift in the down position then run the lift up and down a few times to distribute lubricant over gears Lubricating Rotating Gear Housing In the event that rotating the antenna becomes difficult lubricating the bearing surface between the rotati
142. triking a curb or hitting a deep hole in the road Such damage would be considered as resulting from an accident which risks are not covered under the warranty Abnormal tire wear and or wheel alignment resulting from such damage is not covered under the terms of the warranty SERVICE The Airstream Silver Key Delivery Program is an exclusive Airstream program Before leaving the factory each and every vital part of the motorhome is tested for performance Each test is signed and certified by an inspector After the motorhome arrives on your dealer s lot all of these vital parts and systems are again tested When you take delivery of your new motorhome you will receive a complete checkout Please contact your dealer if you need service Major service under your Airstream Limited Warranty is available through our nationwide network of Airstream Dealer Service Centers An up to date list of Dealer Service Centers has been provided with your new motorhome This list is current as of the date of publication Occasionally dealerships change or new dealers are added who may not appear on this list For this reason it is suggested that you contact your local dealer from time to time and bring your list up to date He can also provide you with additional copies if you need them ALL SERVICE CENTERS OPERATE ON AN APPOINTMENT BASIS FOR THE UTMOST EFFICIENCY When you require service from the Airstream Factory Service Center or a Certified Dealer Service
143. tting The thermostat sensor is calibrated approximately 4 This minimizes rapid recycling of the unit once desired temperature level is achieved 5 The rain sensor built into your fan will prevent excessive rain from entering coach through the open dome Maintain a setting above to the right of rain override zone and the dome will close when the sensor becomes wet CAUTION Do not leave coach unattended with thermostat knob set in the rain override zone 6 A rain sensor override is built into this system so you can operate your fan during light to moderate rains When sensor is wet rotate fan thermostat knob to coolest position to override sensor Dome will open and fan motor will start When sensor has completely dried rotate thermostat knob back to desired setting for automatic operation 7 close dome in extremely hot conditions rotate thermostat knob right past 110 symbol to off Dome will come down 8 Always allow dome to completely cycle up and down If dome hangs up in partially open close position rotate thermostat knob to extreme right and then left position allowing complete cycles down and up Now reset to original comfort level 9 When vehicle is in storage rotate thermostat knob to right off after dome closes turn 3 speed switch to O off CLEANING INSTRUCTIONS 1 Turn fan motor OFF 2 Remove 8 painted flathead Philips screws around perimeter of screen insert only 3 Clean screen with s
144. ture can be ordered direct from the manufacturer or your Airstream dealer The manufacturer also offers a detailed service guide for your furnace A Warning Carefully read all the manufacturer s instructions prior to operating NEVER store flammable material next to the furnace or around its exhaust vent on the side of the motorhome If warranty service is required use only a service location recommended by the furnace manufacturer or your Airstream dealer J 2 AIRSTREAM LAND YACHT GAS REFRIGERATOR See warning at top of page J 1 Manufacturer Dometic Sales Corporation 2320 Industrial Parkway P O Box 490 Elkhart Indiana 46514 Phone 219 295 5228 Review all Dometic Literature supplied in your Owner s Packet or stored in the refrigerator prior to operating In an absorption refrigerant system ammonia is liquefied in the finned condenser coil at the top rear of the refrigerator The liquid ammonia then flows into the evaporator inside the freezer section and is exposed to a circulating flow of hydrogen gas which causes the ammonia to evaporate creating a cold condition in the freezer The tubing in the evaporator section is specifically sloped to provide a continuous movement of liquid ammonia flowing downward by gravity through this section If the refrigerator is operated out of level when the vehicle is not moving liquid ammonia will accumulate in portions of the evaporator tubing This will slow the circulation of hydrogen
145. utlets that do not have power Example If the bath outlet in the rear bath model has power and the converter has no power the open is between the bath outlet and converter outlet 6 Examples of an open are A Loose or corroded connections B A wire disconnected from a terminal C Contacts in the circuit breaker that do not like contact D A broken wire AIRSTREAM LAND YACHT GAS 120 VOLT WIRING DIAGRAMS e 120 volt 30 amp Breaker Panel e 120 volt 50 amp Breaker Panel e Wiring Diagram Automatic Energy Select Switch e System Layout Automatic Energy Select Switch 1 4 AIRSTREAM LAND YACHT GAS 30 120V PANEL dus 2020 2020 20 Le e Boo od NEUTRAL BUSS GROUND BUSS gt gt Soo O 264 BARE CIRCUIT 5 CIRCUIT 4 CIRCUIT 3 CIRCUIT 2 CIRCUIT 1 MAIN MAIN CIRCUIT 1 20 BREAKER 12 2 ROMEX W GROUND AIR CONDITIONER CIRCUIT 2 20 BREAKER 12 2 ROMEX W GROUND BEDROOM AND CONVERTER CIRCUIT 2 15 AMP HACR BREAKER 12 2 ROMEX W GROUND MICROWAVE OVEN CIRCUIT 4 20 AMP BREAKER 12 2 ROMEX W GROUND WATER HEATER CIRCUIT 5 20 AMP GFI BREAKER 12 2 ROMEX W GROUND GALLEY BATH OUTSIDE DINETTE AND LIVING AREA NOTE CHECK 110 LAYOUT DRAWINGS FOR SPECIFIC RECEPTS ON EACH CIRCUIT 5 AIRSTREAM LAND YACHT GAS 110 BRKR PANEL 50 AMP G GREEN GROUND BUSS GGA BARE COPPER CIRCUIT CIRCUIT CI
146. w the directions on the container As this is being written heated tanks are being considered and may be on your motorhome CAUTION Never put wet strength paper towels or tissues in your holding tank since they won t dissolve and can catch in the mechanism of the dump valve Colored toilet tissue is slower to dissolve than white Most RV accessory stores offer tissue designed for RVs that will completely dissolve BLACK TANK FLUSH BLACK TANK FLUSH ASSEMBLY On the side of the motorhome is a large utility compartment with a keyed door A spigot and garden hose female connector is inside In the utility compartment on the left Water hose connector Check valve MN Elbow rear lower side is a water hose connector Vacuum breaker marked black tank flush Don t mistake 1 2 tubing it for the exterior water spigot Spray head Hook up a 1 2 or larger water hose and turn it on full force Within the tank a multiple holed plastic water line will spray the interior surface of the tank The gate valve should be closed for the first couple of minutes to let some water accumulate in the tank and then opened to EXTERIOR RV WALL HOLDING TANK WALL let the water out in a rush Repeat as needed Drain Systems Cleaning There are many deodorizers on the market in tablet liquid and powder form These not only combat odor but also stimulate the bacteria that works to dissolve the solids in your tank Picking a deodorizer
147. water pump off when the motorhome is left unattended AIRSTREAM LAND YACHT GAS WATER PUMP AND STRAINER The water pump and strainer are located under the rear bed and can be accessed by opening the door at the bed footboard The strainer should be visually checked for accumulation of sand or debris that could affect water flow To clean the strainer screen first remove the inlet connection from the pump side of strainer This will allow the intake side of the strainer to be rotated about 1 8 turn counter clockwise and be removed The screen part of the strainer will now be accessible for cleaning Aqautec Pump When reassembling only rotate the inlet side of the strainer until the stops are felt The O ring performs the sealing and too much pressure will only break the strainer Sureflo gt Strainer i I Qo llc pe SANITIZING Potable water systems require periodic maintenance to deliver a consistent flow of fresh water Depending on use and the environment the system is subject to sanitizing is recommended prior to storing and before using the water system after a period of storage Systems with new components or ones that have been subjected to contamination should also be disinfected as follows 1 Use one of the following methods to determine the amount of common household bleach needed to sanitize the tank A Multiply gallons of tank

Airstream LAND YACHT MOTORHOME User's Manual

Contents

Download Pdf Manuals

Related Search

Related Contents