Air King 9915A User's Manual
Contents
1. cleaned Hard water Iron in water Some humidifier additives can cause discoloration No water in Humidifier Hose not connected to water show Hose not connected to pump Key Part Number Description 2011930 Switch Knob Fe g 2011931 2091163 Screw 139 149 x 5 16 6 PTH Lens Reticulated Filter Foam Gasket Chassis Screw 139 149 x 1 2 6 PTH Blade Blade Clamp a ee ee ee j eS j Jo Screw 8 1 2 AB PPH Nozzle Clear Tubing 1 4 x 14 Filter Holder Back Filter 2011934 Filter Holder Front 2011935G Drip Shield 2011936 Base 2010415 Rubber Feet Included with 13 Motor Assembly Rev A 9 05 3 Rl fe SB Be be Ye Ja SS po Replace Filter Follow Instructions under CLEANING and FILTER CARE Follow Instructions under CLEANING and FILTER CARE Replace Filter Follow Instructions under CLEANING and FILTER CARE Use filtered or distilled water Fill with cool water Connect Hose to Water Show Connect Hose to Pump 20844742. though your Humidifier will produce approximately 3 gal lons in a 24 hour period the water capacity amount of water the Humidifier will hold at one time is 1 75 gallons 4 You may fill your Recirculating Evaporative Humidifier two different ways A Fill the Base with cool water to level indicated in Figure 2A B Replace the Upper Housing on the Base and push Water Lens down to pour water into the Humidifier Figure 2B until it reaches the level indicated in Figure 2A Figure 2A Figure 2B Water Lens Maximum Water Level Do not overfill and never use hot water CAUTION Do not pour water through the Ex haust Grill on the Upper Housing Doing so may cause damage and personal injury Do not overfill Overfilling the Unit may cause motor damage Always carry filled Humidifier carefully Never move water filled Humidifier while plugged in se 5 Take extra care to prevent water spillage that may damage furni ture or flooring The manufacturer will not accept responsibil ity for damage to property caused by water spillage 6 Always be sure that the Power Control Knob is in the OFF 0 position when plugging Humidifier into a grounded 120 volt AC wall outlet CAUTION Do not plug Humidifier into electrical outlet with wet hands or electrical shock may occur 7 Set Moisture Control Knob to regulate desired amount of humidity Figure 3 Figure 3 LY Calculations based on ambient conditions of 70 F an
3. FILLING OR Rev A 9 05 SERVICING THE HUMIDIFIER ALWAYS UNPLUG THE POWER CORD 6 This Humidifier is intended for general use ONLY It must NOT be used in potentially dangerous locations such as flammable explo sive chemical laden or wet atmospheres WARNING TO REDUCE THE RISK OF FIRE OR ELECTRIC SHOCK DO NOT USE THIS HUMIDIFIER WITH ANY SOLID STATE SPEED CONTROL DEVICE 7 Always place the Humidifier is on a stable flat level surface when operating to avoid the chance of the Humidifier overturning Locate the Power Cord so the Humidifier or other objects are not resting on it Keep the Power Cord away from room traffic 8 Always direct air flow away from walls and furniture Excessive moisture may cause damage 9 Completely reassemble Humidifier according to instructions before reconnecting to power supply 10 Humidifiers require regular cleaning to maintain proper operating condi tions Refer to the CLEANING section for proper cleaning procedures NOTE A few droplets of water may be present in your Humidifier as a result of our quality testing prior to packaging and shipment OPERATION INSTRUCTIONS 1 It is recommended that all Humidifiers be cleaned prior to use Please read CLEANING and FILTER CARE sec tion for Base cleaning 2 Remove the Upper Housing from the Base Make sure that the Evaporative Pad is properly placed in the Base Figure 1 Figure 1 2084474 MODEL 3LA80A 9915A 3 Even
4. MODEL 3LA80A 9915A Rev A 9 05 2084474 OPERATING INSTRUCTIONS amp PARTS MANUAL Ventilation Products RECIRCULATING HUMIDIFIER 3 GALLON MODEL 3LA80A 9915A READ AND SAVE THESE INSTRUCTIONS READ CAREFULLY BEFORE ATTEMPTING TO ASSEMBLE INSTALL OPERATE OR MAINTAIN THE PRODUCT DESCRIBED PROTECT YOURSELF AND OTHERS BY OBSERVING ALL SAFETY INFORMATION FAILURE TO COMPLY WITH INSTRUCTIONS COULD RESULT IN PERSONAL INJURY AND OR PROPERTY DAMAGE RETAIN INSTRUCTIONS FOR FUTURE REFERENCE DESCRIPTION The AirKing 3 Gallon 11 4 liter Humidifier features 3 Speed whisper quiet operation This unit is capable of humidifying up to 1500 sq ft 166 7 sq yards and features a 7 5 ft 2 3 m 18 3 cord set SPECIFICATIONS MOLON retete 120V 60Hz Blade diameter 6 15 24 cm Speeds 04 and Control Rotary Switch Approvals saanen UL CUL Listed SPEED mien MED Low GENERAL SAFETY INFORMATION 1 Make certain that the power source conforms to the electrical require ments of the Humidifier 2 The power cord is equipped with a three prong grounded plug that must be inserted into a matching receptacle Under no circum stances must the grounding prong be cut off the plug Where a two prong wall receptacle is encountered it must be replaced with a properly grounded three prong receptacle installed in accordance with the National Electrical Code NEC and all applicable local codes
5. and ordinances This work must be done only by a qualified electrician using copper wire only WARNING USE OF A THREE PRONG TO TWO PRONG ADAPTER IS NOT RECOMMENDED IMPROPER CONNECTION MAY CREATE THE RISK OF ELECTROCUTION USE OF SUCH ADAPTERS ARE NOT PERMITTED IN CANADA WARNING THIS PLUG IS A SAFETY FEATURE TO REDUCE THE RISK OF FIRE ELECTRIC SHOCK AND PERSONAL INJURY DO NOT REMOVE REPLACE REPAIR OR TAMPER WITH THE ORIGINALLY SUPPLIED PLUG IF THE FAN DOES NOT FUNCTION PROPERLY IT MAY BE DUE TO THE SAFETY DEVICE INCORPORATED IN THIS PLUG RETURN TO AN AUTHORIZED SERVICE CENTER OR CALL 800 233 0268 MONDAY FRIDAY BETWEEN 8 00 AM AND 5 00 PM EST IF THE PLUG WARNING LABEL IS MISSING OR DAMAGED CALL THE TOLL FREE NUMBER FOR A REPLACEMENT LABEL 3 Where possible avoid the use of extension cords If they must be used minimize the risk of overheating by ensuring that they are UL listed and of the proper gage and length Never use a single extension cord to operate more than one Humidifier 4 Do not insert fingers or foreign objects into the Humidifier Do not block or tamper with the Humidifier in any manner while it is in operation Do not touch the Humidifier while in operation or just after it has been turned off as some parts may be hot enough to cause injury 5 Unplug power cord before filling or servicing the Humidifier WARNING DO NOT DEPEND UPON THE ON OFF SWITCH AS THE SOLE MEANS OF DISCONNECTING POWER WHEN
6. d 30 relative humidity in a room of average insulation 8 Water usage will vary depending upon initial humidity level in the room If humidity is low the Unit will use water more rapidly until the humidity in the room is stabilized If the humidity is already near or above 50 relative humidity water consumption will be low CAUTION Be careful not to direct airflow towards walls or furniture as excessive moisture may cause damage 9 Refill Humidifier when water level in the Base is low 10 If you do not plan to use your Humidifier for several days empty all water from the Unit Standing water may provide an environ ment for the growth of algae HIGH 3 For fast humidification of a large room This setting will provide approxi mately 3 gallons of moisture output in a 24 hour period MED 2 For normal operation LOW 1 For quiet night time operation Rev A 9 05 CLEANING and FILTER CARE 1 Regular cleaning is necessary to ensure proper and efficient operation The frequency of cleaning depends on the amount of impurities which may be found in the water or how often the Humidifier is in operation In either instance it is recommended that the Humidifier be cleaned at least once a week CAUTION To prevent electric shock always turn Control Knob to OFF 0 position and unplug before cleaning 2 Remove Upper Housing from Base Be careful not to let ex cess water from pump spill onto furniture or flooring Fi
7. ed white vinegar with four parts warm tap water Let vinegar solution stand for 20 minutes then wipe away any scale buildup using a soft brush or cloth Do not use soap or detergents and never use an abrasive cleaner 8 TO DISINFECT BASE AND DRIP SHIELD Fill with 1 teaspoon of chlorine bleach and 1 gallon of water Let solution stand for 20 minutes Carefully empty Jug and rinse well with water until bleach smell is gone 2084474 MODEL 3LA80A 9915A 9 Use adry soft cloth to wipe the Chassis area which includes the motor area DO NOT use water to clean the Motor or Switch area Doing so may result in electrical shock or dam age to the Humidifier 10 Commercial Descalers and Bacteriostats are available at your local home improvement center 11 Do not operate Humidifier when there is still cleaner in the water OFF SEASON STORAGE 1 Clean and dry Humidifier thoroughly per the CLEANING and FILTER CARE section Do not leave any water in the Unit while storing 2 Dispose of the Evaporative Pad Do not store a used Evapora tive Pad in the Humidifier Do not dispose of Pad Holder 3 Place Humidifier back in its carton and store in a cool dry place TROUBLE SHOOTING GUIDE TROUBLE PROBABLE CAUSE SOLUTION _ _ o Whole humidifier needs cleaning Foul odor e Filters need to be replaced e Base reservoir needs to be cleaned Filter discoloration Water discoloration Mineral deposits in water Humidifier needs to be
8. gure 4 Filter 3 With water lens pushed down the filter may be re moved for cleaning or re placing Figure 4 4 Remove Evaporative Pad Holder from Base and inspect Small Waiter Drip Holes for any blockage Figure 5 It is important that these Drip Holes remain open at all times for proper water supply to Evaporative Pad Figure 5 Figure 6 Evaporative Pad Holder Drip Holes 5 To increase the life of your Evaporative Pad unsnap Holder remove Pad and flip over Figure 6 Evaporative Pad life may be extended by cleaning the Pad in a vinegar solution To clean Pad mix one part undiluted vin egar with four parts warm tap water Soak the Pad in this solution for 20 minutes rinse Pad thoroughly with warm wa ter to remove vinegar odor DO NOT FLATTEN SQUEEZE OR TWIST FILTER WHEN CLEANING 6 Discoloration of the Evaporative Pad is normal after extended use The discoloration is caused by mineral deposits in the wa ter and the degree of discoloration will vary depending upon the amount of mineral content in the water When the Pad sur face area is thoroughly discolored or you notice reduced wa ter usage itis a good indicator that the Evaporative Pad needs to be replaced The Evaporative Pad should be replaced at least once every season The Replacement Pad to be used in this unit is The Replacement Evaporative Pad Model 9932 Available Separately 7 TO DESCALE BASE AND DRIP SHIELD Mix one part undi lut
Download Pdf Manuals
Related Search