Multitech MultiModem Wireless Modem GSM/GPRS with GPS
Contents
1. 5 Safety Recommendations Tor an nio iaaii 6 Ship Kit Contents 6 Wireless Modem Speciation E 7 GPS SPeCifiCAlOMS 8 Key Feature cm 8 e e aa 8 NALE 8 The iore dirt 9 a 9 Modem etree aT c Mr 9 Chapter 2 Setup and Configuratio MM 10 Back Panel of the MultiModem with dead naa lanae aS ien E nana 10 91 92 iu cuu tmu Rp dM d d Ui 10 Configuring the Wireless Modem Side of the MultiModem eese 10 UP ESI E 10 2 OlM Card for GPRS Or EDGE aii noscitur ALL Eu 11 3 a Wireless a 11 Establish Iriteriet ADO2. 18 Serial Cable for MultiModemi GPS stas ceed qna aS erae aaa RE aAA 20 Fused Cable for MultiModem 5 ntes au ck nua nba sean eC nk rua kan SEN AR NES I EA 20 amp e DE LL DLL LT 21 Appendix A Multi Tech Systems Inc Warranty and Repair Policies 22 Multi Tech Warranty Statement 22 Appendix B Waste Electrical and Electronic Equipment eese 24 I c 25 Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS 80003764 3 Chapter 1 Introduction and Product Description Chapter 1 Introduction and Product Description This User Guide describes the MultiModem Wireless EDGE GPRS and CDMA modems with GPS functionality Your product choice depends on the technology cellular network available to you Product YourCellular Network MTCBA C GP Nx CDMA MTCBA E GP EDGE MTCBA G GP Fx GPRS GPS Interface The MultiModem EDGE GPRS or CDMA wireless modem with GPS incorporates an internal Trimble Lassen iQ
3. Rede 10 How to Remove 20 I WD POUUS okie icc UM 13 Internet ACCESS 11 IQ GAT P 13 I MONON aona eaaa a 13 L 9 Maintenance 5 Modem Identity Check sesiis 12 N Network Registration 12 NMEA Q183 C 4 Ordering Replacement 23 P port configurations iab ERR 13 Power source 10 14 R Rack Installation 6 Radio Charaeterstles eq aet 17 real time tracking Server 4 Receiver Performance 8 HOME 22 Replacement Parts 23 S S192 SWIICIIBSL eaa 10 5 Cables 20 Setup EXambples 4 preci 15 16 comi m T 6 Signal Quality 12 SIM AT CommaNdS s ide es be x HAIR weet 11 SIM mee 11 7 8 TAIR S uu ME LA aU 4 13 Trimble ASCII Interface Protoco
4. e Then type dialout serial s1 to start a dialout session Dialout serial s1 is used to initiate a dialout session to the modem You can now enter AT commands to test your modem 6 Using AT Commands to Test Your Modem 1 Check the signal quality This command determines the received signal strength indication lt rssi gt e Type AT CSQ Modem responds with the received signal strength lt rssi gt Response 0 means 113 dBm or less Response 1 means 111 dBm Response 2 to 30 means 109 to 53 dBm Response 31 means 51 dBm or greater Response 99 means not known or detectable 2 Check the identity of the modem Use this command ATI AT is followed by the capital letter i e Type ATIO The command ends in a zero Manufacturing data displays Wavecom Modem 800 1900 e Type ATI3 Software version displays Ex S W VER xxxxx e Type ATI6 Capability data displays Ex CGSM 1 707 3 Check the network registration and roaming status e Type AT CREG The modem will respond in one of the following ways 0 0 this tells you the modem is not registered on any network CREG 0 1 this tells you the modem is registered on the home network CREG 0 5 this tells you the modem is registered on a network but it is roaming Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS S000376A 12 Chapter 2 Setup and Configuration Configuring the GPS Side of the MultiModem 1 Port Configura
5. Chat exe and Adobe Acrobat Reader Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS 80003764 Chapter 1 Introduction and Product Description Wireless Modem Specifications Features EDGE Modem GPRS Modem CDMA Modem Performance EDGE E GPRS Class 10 GPRS Class 10 CDMA2000 1xRTT GPRS Class 12 Band Quad band GSM Dual band 850 1900 or 900 1800 Dual band 800 1900 MHz CDMA Frequency 850 900 1800 1900 MHz MHz GSM GPRS 800 MHz with R UIM support Packet Data EDGE E GPRS Up to 240K bps Coding scheme MCS 1 9 Mobile station Class B LLC layer 4 time slots GPRS GPRS Class 12 Full PBCCH support Coding scheme 1 4 Mobile station Class B Up to 85 5K bps PBCCH support Coding schemes CS1 to CS4 Up to 153 6K bps forward and reverse Circuit Switched Data Asynchronous transparent and non transparent up to 14 4K bps Asynchronous transparent and non transparent up to 14 4K bps IS 95A IS 95B up to 14 4K bps Fax Class 1 Group 3 GSM Class 1 and Class 2 Group 3 Class 2 0 Group 3 Short Message Services SMS Text amp PDU Point to Point MO amp MT cell broadcast Text amp PDU Point to Point cell broadcast ASCII Text amp UCS 2 Point to Point cell broadcast Internet Protocols Supported TCP UDP DNS FTP SMTP POP3 HTTP ARP Dial in PPP DNS Resolve FTP client ICMP IP IPCP LCP POP3 receive mail PPP SMTP s
6. EN 55022 EN 55024 Safety cUL UL 60950 EN 60950 Network PTCRB EMC FCC Part 2 15 Class A 22 24 EN 55022 EN 55024 Safety cUL UL 60950 EN 60950 Network PTCRB Miscellaneous AT Command Compatible Desktop or panel mounting Carrier approved Numerous LEDs provide status Embedded TCP IP stack AT Command Compatible Desktop or panel mounting Carrier approved Numerous LEDs provide status Embedded TCP IP stack AT Command Compatible Desktop or panel mounting Carrier approved Numerous LEDs provide status CDG 1 and 2 network certified CDMA IS 95A 15 95 backwards compatible Warranty Two years Two years Two years Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS S000376A Chapter 1 Introduction and Product Description GPS Specifications Key Features e 12 channel simultaneous operation Dual sensitivity modes with automatic switching Aided GPS through TSIP Antenna open and short circuit detection and protection Supports NMEA 0183 TSIP and TAIP DGPS protocols DGPS capable Performance L1 frequency 1575 42 MHz C A code Standard Positioning Service 12 channel continuous tracking receiver Update Rate TSIP 1 Hz NMEA Q 1 Hz TAIP Q Hz Update Rate TSIP 1 Hz NMEA 1 Hz TAIP 0 1Hz Accuracy Horizontal 5 meters 5096 8 meters 9096 Altitude 10 meters 50 16 meters 90 Velocity 0 06 m
7. 1 023MHz Gain 90 3 0dBi min 20 4 0dBi min mounted on the 65mm X 65mm square ground plane Polarization RHCP Axial Ratio 90 4 0dB max 10 6 0dB max mounted on the 65mm X 65mm square ground plane LNA Frequency Range 1 575 42 1 023MHz Gain 28 3 dB 40 C to 85 C Noise 1 max 25 C 5 2 2dB max 85 Out of band rejection fo 1 575 42MHz foX20MHz 7dB min foX30MHz 12dB fo 50MHz 20dB min fo 100MHz 30dB min Output Impedance 500 Output VSWR 2 0max Overall Specifications Frequency Range 1 575 42 1 023 2 Gain 27 3dBi 25 C 5 C 27 4dBi 40 C to 85 C mounted on the 65mm x 65mm square ground plane Output Impedance 500 VSWR 2 0MAX ESD Antenna surface 15KV Connector pin 8KV MTBF 5 13E 6Hr Storage Conditions Temperature and Humidity 20 C to 45 C humidity 80 max consumption at room temperature General Operating Temp 40 C to 85 C Storage Temp 40 C to 100 C Relative Humidity 20 to 95 Input voltage 3 0V 0 3V Power Cons 15mA max room temp Output connection MCX plug Cable 1 5DS QEHV Shikoku Cable Co black 5m Weight 20g TYP Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS 80003764 Ch
8. 9P DE 9S ON Oo Oi A o O Fused Cable for MultiModem GPS Recommended Replacement Fuses JJ fuse B 35 26 8 T Lus 1 Manufacturer Littelfuse Part Number 313 02 5 2 Manufacturer Sun Fuse Part Number 6S Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS 80003764 20 Chapter 4 Antennas and Cables Fused Cable Dimensions Includes How to Change the Fuse IN LINE WATER PROOF FUSE HOLDER 250 REF STRIP AND TIN 16 AWG x2 BLACK RED Tw IN LEAD BONDED WIRE PROOF SEAL RIBS FUSE HOLDER IS WATERPROOF TWIST AND PULL TO REMOVE FUSE FUSE REPLACEMENTS N LITTLEFUSEs 313 2 5 250V 2 SUN FUSE 6S 2 5 250V GENERAL SPECIFICATIONS SEE GLOBTEK INC DRAW ING PN LLPTIOSF TRB FSE WP FOR DETAIL Notice This drawing may contain proprietary and confidential information Tine e e OF 1 of Multi Tech Systems Inc It is loaned for limited purposes only and remains the property 4 Dog We T of Multi Tech Systems Inc It may not be reproduced in whole or part without written FUSED PW RECAEU 18502C consent The drawing 15 to be returned when requested 1 1 Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS 80003764 21 Appendix Multi Tech Systems Inc Warranty and Repair Policies Appendi
9. GPS module providing 12 channel GPS functionality It delivers complete position velocity and time PVT solutions making it ideal for real time vehicle tracking navigation and fleet management applications The GPS functionality supports four of the most popular protocols 0183 DGPS RTCM TSIP Trimble Standard Interface Protocol and TAIP Trimble ASCII Interface Protocol and provides dual sensitivity modes allowing it to automatically switch to higher sensitivity when satellite signals are weak The MultiModem EDGE GPRS or CDMA wireless modem with GPS utilizes an RS 232 interface The GPS information is received on a secondary serial port and can be used for in vehicle navigation In addition the data can be sent through the wireless modem to a central real time tracking server via SMS or GPRS The MultiModem EDGE GPRS or CDMA wireless modem provides flexibility to allow third party GPS applications and Application Service Providers ASPs the ability to customize their software to work with the wireless modem hardware MultiModem EDGE The MultiModem EDGE wireless modem delivers some of the fastest cellular wireless data speeds utilizing EDGE technology It allows users to connect to the Internet and send and receive data up to three times faster than possible with an ordinary GSM GPRS network making it ideal for highly data intensive multimedia applications The MultiModem EDGE wireless modem is equipped with quad band G
10. MCX connector This type of connector is suitable for the standard ranges of flexible and semi rigid cables The characteristic impedance of the MMCX coaxial connector is 50 ohm The antenna manufacturer must guarantee that the antenna will be working according to the radio characteristics presented in the table below EDGE and GSM Radio Characteristics GSM 850 E GSM 900 GSM 1800 GSM 1900 Frequency RX 869 to 894 MHz 925 to 960 MHz 1805 to 1880 MHz 1930 to 1990 MHz Frequency TX 824 to 849 MHz 880 to 915 MHz 1710 to 1785 MHz 1850 to 1910 MHz RF Power Stand 2W at 12 5 duty cycle 2W at 12 5 duty cycle 1W at 12 5 duty cycle 1W at 12 5 duty cycle Impedance 50 ohms VSWR lt 2 Typical Radiated Gain 0 dBi on azimuth plane CDMA Radio Characteristics CDMA 800 CDMA 1900 Frequency RX 869 to 894 MHz 1930 to 1990 MHz Frequency TX 824 to 849 MHz 1850 to 1910 MHz Impedance 50 ohms VSWR lt 2 Typical Radiated Gain 0 dBi in at least one direction GSM CDMA Antenna Example An antenna that meets the requirements for use with this product is included with your purchase Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS S000376A 17 Chapter 4 Antennas and Cables GPS Antenna Compact Magnetic Mount Antenna Antenna Frequency Range 1 575 42
11. abuse or user caused damages are billed on a time plus materials basis Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS 000376 22 Appendix Multi Tech Systems Inc Warranty and Repair Policies Repair Procedures for International Customers Outside U S A and Canada Your original point of purchase Reseller may offer the quickest and most economical repair option for your Multi Tech product You may also contact any Multi Tech sales office for information about the nearest distributor or other repair service for your Multi Tech product The Multi Tech sales office directory is available at http www multitech com COMPANY contact_us In the event that factory service is required products may be shipped freight prepaid to our Mounds View Minnesota factory Recommended international shipment methods are via Federal Express UPS or DHL courier services or by airmail parcel post shipments made by any other method will be refused Please include inside the shipping box a description of the problem a return shipping address must have street address not P O Box your telephone number and if the product is out of warranty a check in U S dollars drawn on a U S bank or your company s purchase order for repair charges Repaired units shall be shipped freight collect unless other arrangements are made in advance Please direct your questions regarding technical matters product confi
12. have not changed the switches previously then they will be in the default position Note that the switches are located behind a cover plate on the connector side of the modem The cover plate can be removed when you need to change the switch settings Connect to a power source for example to a cigarette outlet on a vehicle Run your software application that reads GPS data from the GPS serial port The wireless modem is available to the portable PC for transferring data Your central tracking station can then retrieve the data wirelessly from your CDMA GPRS or EDGE network provider connection Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS 80003764 15 Chapter 3 Setup Configuration Examples Application Example 2 GPRS Network 7 GPS Satellite Internet Gateways gi P GPS Antenna Cellular Antenna Central Tracking Location MultiModem GPRS Wireless Modem with GPS This example shows the MultiModem GRPS Wireless Modem with GPS mounted in a truck that can be tracked by a GPS satellite This configuration shows a MultiModem located in a vehicle and not connected to a portable PC The MultiModem in this example simply reads the GPS data as it is sent from GPS satellite and then it broadcasts the data to your central tracking system by way of your CDMA GPRS or EDGE network provider connection Note that in this example you cannot configure t
13. in the diagram above are located behind a cover plate that can be removed when you need to change the switch settings S1 Down puts the MultiModem in reset state Up runs the MultiModem properly Toggle the S1 switch down and back up to reset the MultiModem 2 Up keeps the GPS data signals separate from the wireless modem Down allows GPS data from Port 1 to flow to the wireless modem s data in signal Configuring the Wireless Modem Side of the MultiModem 1 Hardware Setup 1 Using an RS 232 cable connect a workstation to the GSM CDMA connector on the MultiModem 2 Attach both antennas The GPS antenna is a 50 ohm SMA antenna The GSM CDMA antenna is a standard SMA antenna 3 Switches S1 and S2 should be in the default positions both up 4 Plug one end of the power cord into the MultiModem and the other end into a live power outlet The PWR LED lights up Warning Do not connect your wireless modem directly to a vehicle s battery for your power source Doing so may cause power spikes If you wish to use the battery as a power source add a filtering device to the DC input Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS 80003764 10 Chapter 2 Setup and Configuration 2 SIM Card for GPRS or EDGE The wireless modem requires the power supply connection to begin operation It also requires a SIM card Subscriber Identity Module to operate on a GPRS or EDGE network To install
14. sec PPS static 50 nanoseconds Acquisition Autonomous Operation in Standard Sensitivity Mode Reacquisition 2 sec 9096 Hot Start 10 sec 5096 13 sec 9096 Warm Start 38 sec 5096 42 sec 9096 Cold Start 50 sec 50 84 sec 90 Cold Start requires no initialization Warm Start implies that the last position time and almanac are saved by backup power Hot start implies ephemeris also saved Optional COCOM Limits Altitude 18 000 m Velocity 515 m s Either limit may be exceeded but not both Interface 3 3 V CMOS compatible TTL level pulse Once per second Protocols Protocols TSIP TAIP NMEA 0183 v3 0 RTCM SC 104 GGA VTG GLL ZDA GSA GSV and Messages selectable by TSIP command selection stored in flash memory Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS 80003764 8 Chapter 1 Introduction and Product Description The Front Panel The MultiModem wireless EDGE modem with GPS functionality has 8 LEDs 5 of which are modem LEDs and a SIM card Multi EDGE Wireless Modem with GPS r Modem 3 PWR GPSTD TD RD CD TR LS IP OOO O The MultiModem wireless GPRS modem with GPS functionality has the same LEDs and SIM card as the EDGE modem GPRS Wireless Modem with GPS The MultiModem wireless CDMA modem with GPS functionality has the same L
15. that service is required products may be shipped freight prepaid to our Mounds View Minnesota factory Multi Tech Systems Inc 2205 Woodale Drive Mounds View MN 55112 Attn Repairs Serial A Returned Materials Authorization RMA is not required Return shipping charges surface will be paid by MTS to destinations in U S and Canada Please include inside the shipping box a description of the problem a return shipping address must have street address not P O Box your telephone number and if the product is out of warranty a check or purchase order for repair charges For out of warranty repair charges go to COMPANY Policies warranty Extended two year overnight replacement service agreements are available for selected products Please call MTS customer service at 888 288 5470 or visit our web site at http www multitech com PARTNERS Programs overnight replacement for details on rates and 5 Please direct your questions regarding technical matters product configuration verification that the product is defective etc to our Technical Support department at 800 972 2439 or email support multitech com Please direct your questions regarding repair expediting receiving shipping billing etc to our Repair Accounting department at 800 328 9717 or 763 717 5631 or email mtsrepair multitech com Repairs for damages caused by lightning storms water power surges incorrect installation physical
16. 00 972 2439 or 763 717 5863 4 Establish Internet Access Internet Access Using e GSM with GPRS CDMA 1x Data single DUN number is generally used by all of a wireless provider s subscribers throughout its area of coverage regional nationwide continental etc Rather than being a literal phone directory number as in conventional DUN this is a code that gives the modem Internet access Internet Access Using GSM without GPRS e CDMA Point to Point Data A circuit switched data connection is used Use the dial up network DUN to make a conventional V 32 modem connection to any terminating modem at the other end The phone number specified in the DUN can be one supplied by the wireless service provider or another phone number related to a different dialup modem service e g a dialup modem service phone number from any commercial or private dialup network Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS S000376A 11 Chapter 2 Setup and Configuration 5 Login Using TTY e Use TTY to configure your IP module for the first time Configure the host serial port using the defaults listed below Baud 115 2K Data 8 Parity N Stop 1 Flow Control None e Press the Enter key three times to get to the Login prompt e At the Login prompt type admin e At the Password prompt type admin Important User name and password are case sensitive They must be typed in lowercase letters
17. BSS 11 S Logimillsing UIDI LIE E ED LE EL 12 6 Using AT Commands to Test Your Modem s UE 12 Configuring the GPS Side of the trennen nnne 13 dis 13 2 HardWare SOU eM M 14 9 Veny GPS COMMOCHOM 14 Chapter 3 Setup Configuration 15 Application Example eiie 15 Application Example 2 aiina 16 Chapter 4 Antennas and Cables nn nnne tnn Ea ADEE EEE 17 I cipe 17 EDGE GSM 17 EDGE and anii eoria haarad irei iiia 17 CDMA TRAGIO C ARAGON EE 17 GSMs CDMA Antena Examples qf GPS Antenna Compact Magnetic Mount Antenna
18. EDs as the EDGE and GPRS modem but it does not however have a SIM card Multi Wireless Modem with GPS LEDs PWR POWER GPS GPS Blinks to show GPS is active IP IP FUNCTION This LED blinks when the IP function of the modem is operating normally It shows a steady light when powering up initializing or flashing the firmware Modem LEDs TD TRANSMIT DATA This LED blinks when the modem is transmitting data to your wireless carrier RD RECEIVE DATA This LED blinks when the modem is receiving data from your wireless carrier CD CARRIER DETECT This LED lights when the modem detects a valid carrier signal from a wireless carrier TR DATA TERMINAL READY This LED lights when the modem is trying to establish a wireless connection LS LINK STATUS This LED blinks when there is a valid wireless signal When it is on or off the wireless strength is low Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS 80003764 9 Chapter 2 Setup and Configuration Chapter 2 Setup and Configuration Back Panel of the MultiModem with GPS The back panel view is included to help you understand the MultiModem setup mu antenna 3 gt Antenna Antenna bsg Connector Handset GSM CDMA 51 52 Power GPS Connector RS 232 Switches Connector RS 232 Connector Connector MultiModem with GPS Interface Back Panel S1 S2 Switches Note The switches as shown
19. MultiModem Wireless Modems EDGE GPRS CDMA with GPS Functionality MTCBA E GP MTCBA G GP Fx MTCBA C GP Nx User Guide Multi lechi Systems Copyright and Technical Support User Guide MultiModem Wireless EDGE GPRS and CDMA Modems with GPS Functionality MTCBA E GP MTCBA G GP Fx MT CBA C GP Nx 000376 Revision A Copyright This publication may not be reproduced in whole or in part without prior expressed written permission from Multi Tech Systems Inc All rights reserved Copyright 2006 by Multi Tech Systems Inc Multi Tech Systems Inc makes no representations or warranty with respect to the contents hereof and specifically disclaims any implied warranties of merchantability or fitness for any particular purpose Furthermore Multi Tech Systems Inc reserves the right to revise this publication and to make changes from time to time in the content hereof without obligation of Multi Tech Systems Inc to notify any person or organization of such revisions or changes Record of Revisions Revision Date Description A 03 07 06 Initial release Includes the Waste Electrical and Electronic Equipment Statement Trademarks Trademarks and registered trademarks of Multi Tech Systems Inc include MultiModem the Multi Tech logo and Multi Tech Windows is a registered trademark of Microsoft Corporation in the United States and other countries All products or technologies mentioned in this guide are the tra
20. SM which means it can be used worldwide on all existing GSM networks AT Commands The MultiModem EDGE wireless modem is configured using the EDGE AT Commands These commands are documented in the Reference Guide for the MultiModem Wireless EDGE Modems document number S000371x located on the MultiModem CD included in your ship kit MultiModem GPRS The MultiModem GPRS wireless modem offers standards based multi band GSM GPRS Class 10 performance It supports GSM circuit switched cellular data connections offers SMS features and includes an embedded TCP IP protocol stack AT Commands The MultiModem GPRS wireless modem is configured using the GPRS AT Commands These commands are documented in the Reference Guide for the MultiModem Wireless GPRS Modems document number 5000293 and also the Reference Guide for the GSM IP Commands document number S000333x located on the MultiModem CD included in your ship kit MultiModem CDMA The MultiModem CDMA wireless modem offers standards based multi band CDMA200 1xRTT performance It supports CDMA IS 95A 1 95 circuit switched cellular data connections and offers SMS services AT Commands The MultiModem CDMA wireless modem is configured using the CDMA AT Commands These commands are documented in the Reference Guide for the MultiModem Wireless CDMA Modems document number 000294 located on the MultiModem CD included in your ship kit Multi Tech Systems Inc MultiModem Wire
21. The GPS antenna is a 50 ohm SMA antenna The GSM CDMA antenna is a standard SMA antenna 3 Plug one end of the power cord into the device and the other end into a live power outlet The PWR LED lights up Warning Do not connect your wireless modem directly to a vehicle s battery for your power source Doing so may cause power spikes If you wish to use the battery as a power source add a filtering device to the DC input 3 Verify the GPS Connection The workstation should be running a utility such as iQ Monitor to monitor GPS satellite signals iQ Monitor is included on the product CD with the MultiModem Developer s Kit Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS S000376A 14 Chapter 3 Setup Configuration Examples Chapter 3 Setup Configuration Examples Application Example 1 In this example the GPS side of the MultiModem is monitoring GPS locations and the wireless modem side of the MultiModem is waiting for incoming data A portable workstation such as a laptop or handheld PC is connected to this wireless modem to both serial ports the GSM CDMA port and the GPS port 1 2 3 4 Using an RS 232 cable connect the GPS connector jack to portable PC s serial port Using an RS 232 cable connect the GSM CDMA jack to the PC s other serial port Attach both antennas the GPS antenna and the GSM CDMA antenna Set both the 1 and S2 switches up the default If you
22. apter 4 Antennas and Cables Compact Magnetic Mount antenna with 5 m Cable and SMA Connector 80269266 13113 I 30 zwos 8 QV 26 c926 oae ON ON WOS4 325 0351039 YWS WS VNN3INV Sd9 eea e quir e ou 6 0 IN3NVWH3d HLIA 714 831 4 NO LYW 3 71 JHL 2 OS 38 01 73897 E 47104 VOILSAT3H NULLO31UBd AN 3AILISUd MOVIE 38 OL ONILNTYd CUWO TT 09 6666 Ny 1000 al gt WWG 2ED 19 NO LINN 30 JIWAN TNITSU AAAA 9 9661 791 NV3A Z 230 N AON D 120 6 1 3Hl 40 A HINUN JHL 30 AYO 3190 XX Z XX H 0 8 EFS 8 1 4 SY 03002 511917 8 38 01 N38WnN 7913 FIWW VAS 140123 4313 S Trimble Navigation Limited 15 AH38 SUS T 42918 314 92 Proprietary amp Confidential CUTE goro o 0597 0661 21434 9 0 6 6 23439 9 0 2 4 crouse ava Nowalyosaa nau SNOISIAJY CUUG OFS OS aan 19 Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS 80003764 Chapter 4 Antennas and Cables Serial Cable for MultiModem GPS 6 250 J DE
23. demarks or registered trademarks of their respective holders Technical Support Country By Email By Phone France support multitech fr 33 1 64 61 09 81 India support multitechindia com 91 124 2340780 Europe Asia Africa support multitech co uk 44 118 959 7774 U S Canada all others support multitech com 800 972 2439 or 763 785 3500 World Headquarters Multi Tech Systems Inc 2205 Woodale Drive Mounds View Minnesota 55112 763 785 3500 or 800 328 9717 Fax 763 785 9874 Internet Address http www multitech com Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS S000376A 2 Table of Contents Table of Contents Chapter 1 Introduction and Product Description 44 4 122044412 4 Emer 4 M ltiModem eres ec be ce 4 M ltiM odem GPRS 2 4 MultiModem 4 Safety Warnings 5 General Sale eee Et 5 meri ise 5 Mairitenance of ihe Wireless Multilvlo deris 5
24. end mail TCP socket Telnet client Telnet server UDP socket CHAP PAP Dial in PPP DNS FTP HTTP ICMP IP IPCP LCP POP3 PPP SMTP SNMP SNTP TCP Telnet TFTP amp UDP Voice Features Half rate HR Full rate FR Enhanced full rate EHR Adaptive multi rate AMR Basic hands free operation with echo cancellation and noise reduction NA NA Antenna RF Antenna 50 ohm SMA RF Antenna 50 ohm SMA RF Antenna 50 ohm SMA Connectors GPS Antenna 50 ohm SMA GPS Antenna 50 ohm SMA GPS Antenna 50 ohm SMA SIM Connector Standard 3V SIM receptacle Standard 3V SIM receptacle NA Interface 2 DB 9 2 DB 9 2 DB 9 Connectors Power 2 5mm miniature screw 2 5mm miniature screw 2 5mm miniature screw Connectors Voice RJ 9 4 pos modjack NA NA Connectors Power 5V to 32 VDC 5V to 32 VDC 5V to 32 VDC Requirements Physical 2 8 L x 6 4 W x 1 2 H 11 5 oz 2 8 L x 6 4 W x 1 2 H 11 5 oz 2 8 L x 6 4 W x 1 2 H 11 5 oz Description 7 1 cm x 16 3 cm x 3 0 3269 7 1 cm x 16 3 cm x 3 0 3269 7 1 cm x 16 3 cm x 3 0 cm 326g Operating 0 to 50 C 0 to 50 C 0 to 50 C Environment Humidity 20 to 90 non condensing 20 to 90 non condensing 20 to 90 non condensing Certifications CE Mark R amp TTE EMC FCC Part 2 15 Class A 22 24 EN 55022 EN 55024 Safety cUL UL 60950 EN 60950 Network PTCRB CE Mark R amp TTE EMC FCC Part 2 15 Class A 22 24
25. guration verification that the product is defective etc to our Technical Support department nearest you or email support multitech com When calling the U S please direct your questions regarding repair expediting receiving shipping billing etc to our Repair Accounting department at 763 717 5631 in the U S A or email mtsrepair multitech com Repairs for damages caused by lightning storms water power surges incorrect installation physical abuse or user caused damages are billed on a time plus materials basis Repair Procedures for International Distributors International distributors should contact their MTS International sales representative for information about the repairs for their Multi Tech product Please direct your questions regarding technical matters product configuration verification that the product is defective etc to our International Technical Support department at 763 717 5863 When calling the U S please direct your questions regarding repair expediting receiving shipping billing etc to our Repair Accounting department at 763 717 5631 in the U S A or email mtsrepair multitech com Repairs for damages caused by lightning storms water power surges incorrect installation physical abuse or user caused damages are billed on a time plus materials basis Replacement Parts SupplyNet Inc can supply you with replacement power supplies cables and connectors for selected Multi Tech prod
26. he GPS you can only receive data from port 1 of the GPS 1 2 3 4 Mount the MultiModem in a vehicle Attach both antennas the GPS antenna and the GSM CDMA antenna Verify the S1 switch up the default Set the S2 switch down This allows data from the GPS port 1 to flow to the wireless modem side of the MultiModem Then when you call into this modem from a remote location the GPS data is displayed on the remotely located workstation s screen Note that the workstation can be a laptop or a handheld device Connect to a power source for example to a cigarette outlet on a vehicle Your central tracking station can then retrieve the data wirelessly from your CDMA GPRS or EDGE network provider connection Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS 80003764 16 Chapter 4 Antennas and Cables Chapter 4 Antennas and Cables The Antenna The antenna sub system and integration in the application is a major issue Choice of antenna type length performances thermal resistance etc These elements could affect GSM performances such as sensitivity and emitted power EDGE GSM and CDMA Antenna The integrated modem antenna connector is a SMA connector The SMA connector incorporates a Screw on action in order to make the connection easier while providing an excellent RF performance An additional advantage is its small physical size which is 5096 of the standard
27. l 4 Trimble Standard Interface Protocol 4 Trimble Lassen iQ GPS module 4 M 4 FIY e 12 Vehicle battery 10 14 Sateby s corte E pr ret RR Oed 5 Verify the GPS Connection 14 AE 22 WEEE dlrecliVB 24 Wireless activation 1 11 Wireless Service Provider 11 Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS 80003764 25
28. less EDGE GPRS and CDMA Modems with GPS S000376A 4 Chapter 1 Introduction and Product Description Safety Warnings General Safety The modem is designed and intended to be used in either fixed or mobile applications In the Fixed application the device is physically secured at one location and not easily moved to another location In the Mobile application the device may be regularly moved to different locations Caution Maintain a separation distance of at least 20 cm 8 inches between the transmitter s antenna and the body of the user or nearby persons The modem is not designed for nor intended to be used in applications within 20 cm 8 inches of the body of the user Such uses are strictly prohibited Avoid possible radio frequency RF interference by carefully following the safety guidelines below e Switch OFF the MultiModem in the vicinity of gasoline or diesel fuel pumps or before filling a vehicle with fuel Switch OFF the MultiModem in hospitals and any other place where medical equipment may be in use e Respect restrictions on the use of radio equipment in fuel depots chemical plants or where blasting operations are in progress e There may be a hazard associated with the operation of your MultiModem in the vicinity of inadequately protected personal medical devices such as hearing aids and pacemakers Consult the manufacturers of the medical device to determine if it is adequately protected e Operatio
29. n of the MultiModem in the vicinity of other electronic equipment may cause interference if the equipment is inadequately protected Observe any warning signs and manufacturers recommendations Vehicle Safety Do not use your MultiModem while driving e Respect national regulations on the use of cellular telephones in vehicles Road safety always comes first e f incorrectly installed in a vehicle the operation of MultiModem telephone could interfere with the correct functioning of vehicle electronics To avoid such problems be sure that the installation has been performed by qualified personnel Verification of the protection of vehicle electronics should be part of the installation e The use of an alert device to operate a vehicle s lights or horn on public roads is not permitted Maintenance of the Wireless MultiModem Your wireless MultiModem is the product of advanced engineering design and craftsmanship and should be treated with care The suggestions below will help you to enjoy this product for many years Do not expose the MultiModem to any extreme environment where the temperature or humidity is high Do not attempt to disassemble the MultiModem There are no user serviceable parts inside Do not expose the MultiModem to water rain or spilled beverages It is not waterproof Do not abuse your MultiModem by dropping knocking or violently shaking it Rough handling can damage it Do not place the MultiModem along
30. onsibility to dispose of their waste equipment by handing it over to a designated collection point for the recycling of waste electrical and electronic equipment The separate collection and recycling of your waste equipment at the time of disposal will help to conserve natural resources and ensure that it is recycled in a manner that protects human health and the environment For more information about where you can drop off your waste equipment for recycling please contact your local city office your household waste disposal service or where you purchased the product July 2005 Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS 000376 24 Index Index A AMENNA S 17 18 AT C mmMaNd Sesera 4 B Back iem a a 10 C 4 CDMA2OD TERT T 4 Changing the FUSE 21 Compact Magnetic Mount 18 Customer Activation Notices 6 D DGPS RICM 4 diaout senal Si 12 E EDGE 4 F Front Panels 9 Fuse 20 Fused 20 G GPS Developer Kil 6 GPS functionality ssns 4 H Handling Precautions 5
31. r cord If a power strip is used ensure that the power strip also provides adequate grounding Ensure that the main supply circuit is capable of handling the load See the power label on the device for requirements Maximum ambient temperature is 70 degrees Celsius This device should be installed by properly qualified personnel Only connect like circuits e g connect SELV Secondary Extra Low Voltage circuits to SELV circuits and TN Telecommunications Network circuits to TN circuits Ship Kit Contents The single wireless modem is shipped with the following One MultiModem GPRS EDGE CDMA wireless modem with GPS functionality One fused DC power cable Four rubber feet for desktop placement Printed Activation Customer Notices for Cingular Sprint Verizon networks and general CDMA activation One printed Quick Start Guide One MultiModem CD that provides documentation two GPS utility programs iQ Monitor exe and iQ Chat exe and Adobe Acrobat Reader The GPS Developer Kit is shipped with the following Three power cords One fused DC power cable One universal power supply Two serial cables Some international kits may have three antennas two wireless antennas and one GPS antenna Printed Customer Activation Notices for Cingular Sprint Verizon networks and general CDMA activation One printed Quick Start Guide One MultiModem CD that provides documentation two GPS utility programs iQ Monitor exe and iQ
32. side computer discs credit or travel cards or other magnetic media The information contained on discs or cards may be affected by the phone e The use of accessories not authorized by Multi Tech or not compliant with Multi Tech s accessory specifications may invalidate the warranty of the MultiModem e In the unlikely event of a fault in the MultiModem contact Multi Tech Technical Support Handling Precautions All devices must be handled with certain precautions to avoid damage due to the accumulation of static charge Although input protection circuitry has been incorporated into the devices to minimize the effect of this static build up proper precautions should be taken to avoid exposure to electrostatic discharge during handling and mounting Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS 80003764 5 Chapter 1 Introduction and Product Description Safety Recommendations for Rack Installations Ensure proper installation in a closed or multi unit enclosure by following the recommended installation as defined by the enclosure manufacturer If installing the wireless modem in a closed or multi unit enclosure ensure adequate airflow so that the maximum recommended ambient temperature is not exceeded Do not place the device directly on top of other equipment or place other equipment directly on top of this device Ensure that the device is properly connected to earth ground via a grounded powe
33. the SIM card 1 Use small screwdriver to remove the screw closest to the outside edge of the modem Then swing the loosened SIM slot cover up and over to the left 2 Insert the SIM card into the SIM card slot The following graphic illustrates the correct SIM card orientation SIM AT Commands SIM Commands for GPRS SIM commands are included in the GPRS AT Commands Reference Guide SIM Commands for EDGE SIM commands are covered in a separate guide entitled SIM Application Toolkit AT Commands Reference Guide 3 Establish a Wireless Account Obtain a wireless account through a Wireless Service Provider This will allow you to use the service provider s network for example Cingular Sprint and Verizon Cingular and Sprint Contact Multi Tech a certified national activation agent for Cingular and Sprint to set up one of these accounts Verizon and Others For Verizon and other accounts contact their activation agents directly Activations Instructions See the Cingular Sprint Verizon and general Customer Activation Customer Notices included with your modem for a list of the information you must give to the activation agent You will receive depending upon your provider one or two phone numbers and a service programming code or lock code Write these numbers down as you will have to use them to configure the wireless modem If you have any questions or want to set up your account contact Multi Tech Systems Inc at 8
34. tion The GPS receiver module has two ports The table below provides the default protocols and port configurations for the receiver as delivered from the factory TSIP IN OUT is the default protocol on Port 1 and RTCM IN and NMEA OUT is the default protocol on Port 2 Default Protocols and Port Configurations Port Input Default Setup Output Default Setup Protocol Language 1 TSIP Baud Rate 9600 TSIP Baud Rate 9600 Data Bits 8 Parity Data Bits 8 Parity Odd Stop Bits 1 No Flow Control Odd Stop Bits 1 No Flow Control 2 Baud Rate 4800 NMEA Baud Rate 4800 Data Bits 8 Parity Data Bits 8 Parity None Stop Bits 1 No Flow Control None Stop Bits 1 No Flow Control The GPS Receiver can also be configured to output TAIP messages The standard port characteristics for TAIP are e Baud Rate 4800 Data Bits 8 Parity None Stop Bits 1 No Flow Control Pin 5 Pin 1 GPS DB 9 Pin 2 Port 1 Transmit Data from GPS Pin 3 Port 1 Receive Data into GPS Pin 6 Port 2 Transmit Data from GPS Pin 4 Port 2 Receive Data into GPS Pine Pin 5 GND Any standard serial communications program such as Windows Hyper Terminal or PROCOMM be used to view the NMEA or TAIP output messages TSIP is a binary protocol and outputs raw binary serial data that cannot be read when using Windows Terminal or PROCOMM To view the output of the TSIP protocol in text format use the iQ_CHAT or the iQ_Moni
35. tor program These programs are included the CD ROM as part of the MultiModem GPS Developer s Kit About iQ Monitor and iQ Chat Utilities The iQ Monitor exe and iQ Chat exe files plus a Developer s Guide entitled Developing a Software Interface for the GPS Module in the Multi Tech MultiModem are included on the CD as part of the MultiModem Developer s Kit iQ Monitor iQ Monitor is used to verify GPS is functioning The Developer Guide explains how to setup and use this utility It is a 32 bit Windows application that interfaces with a TSIP speaking receiver through the GPS serial port The program accepts TSIP reports and displays these fields in a window Position Velocity Time Receiver Status and Satellite Track Status The program allows you to exercise some basic TSIP commands and can also log a TSIP report in binary format for later translation iQ Chat iQ Chat is a 16 bit DOS based application that interfaces with the GPS receiver through a serial port It allows you to exercise TSIP commands configure the GPS receiver for NMEA or TAIP and view NMEA or TAIP output It also logs a TSIP report in binary format Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS 80003764 13 Chapter 2 Setup and Configuration 2 Hardware Setup 1 Using RS 232 cable connect a workstation to the GPS connector on the MultiModem 2 Attach both antennas included in your ship kit
36. ucts You can place an order with SupplyNet via mail phone fax or the Internet at the following addresses Mail SupplyNet Inc 614 Corporate Way Valley Cottage NY 10989 Phone 800 826 0279 Fax 914 267 2420 Email info thesupplynet com Internet http www thesupplynet com 2005 Multi Tech Systems Inc MultiModem Wireless EDGE GPRS and CDMA Modems with GPS S000376A 23 Appendix Waste Electrical and Electronic Equipment Appendix Waste Electrical and Electronic Equipment Waste Electrical and Electronic Equipment WEEE The WEEE directive places an obligation on EU based manufacturers distributors retailers and importers to take back electronics products at the end of their useful life A sister Directive ROHS Restriction of Hazardous Substances complements the WEEE Directive by banning the presence of specific hazardous substances in the products at the design phase The WEEE Directive covers all Multi Tech products imported into the EU as of August 13 2005 EU based manufacturers distributors retailers and importers are obliged to finance the costs of recovery from municipal collection points reuse and recycling of specified percentages per the WEEE requirements Instructions for Disposal of WEEE by Users in the European Union The symbol shown below is on the product or on its packaging which indicates that this product must not be disposed of with other waste Instead it is the user s resp
37. x A Multi Tech Systems Inc Warranty and Repair Policies Multi Tech Warranty Statement Multi Tech Systems Inc hereafter MTS warrants that its products will be free from defects in material or workmanship for a period of two five or ten years depending on model from date of purchase or if proof of purchase is not provided two five or ten years depending on model from date of shipment MTS MAKES NO OTHER WARRANTY EXPRESS OR IMPLIED AND ALL IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE HEREBY DISCLAIMED This warranty does not apply to any products which have been damaged by lightning storms water or power surges or which have been neglected altered abused used for a purpose other than the one for which they were manufactured repaired by Customer or any party without MTS s written authorization or used in any manner inconsistent with MTS s instructions MTS s entire obligation under this warranty shall be limited at MTS s option to repair or replacement of any products which prove to be defective within the warranty period or at MTS s option issuance of a refund of the purchase price Defective products must be returned by Customer to MTS s factory transportation prepaid MTS WILL NOT BE LIABLE FOR CONSEQUENTIAL DAMAGES AND UNDER NO CIRCUMSTANCES WILL ITS LIABILITY EXCEED THE PRICE FOR DEFECTIVE PRODUCTS Repair Procedures for U S and Canadian Customers In the event
Download Pdf Manuals
Related Search