Home

CHAUVET DJ Hurricane 1101

1. Fuse 1 Disconnect the product from power Replacement With a Phillips 2 head screwdriver unscrew the fuse holder cap from the housing 3 Remove the blown fuse Replace with a fuse of the same type and rating 5 Screw the fuse holder cap back in place and reconnect power D Disconnect the product from power before replacing the fuse gt gt Always replace a blown fuse with another of the same type and rating Hurricane 1101 User Manual Rev 1 Page 7 of 7 Mounting Before mounting the product read and follow the safety recommendations indicated in the Safety Notes Orientation This product may not be tilted This product should only be mounted used on a level surface Rigging Before deciding on a location always make sure there is easy access to the product for maintenance and fluid replenishment Make sure that the structure or surface onto which you are mounting the product can support the product s weight see the Technical Specifications When mounting the product overhead always use a safety cable Mount the product securely to a rigging point such as an elevated platform or a truss When rigging the product onto a truss you should use a mounting clamp of appropriate weight capacity The bracket has 13 mm holes which are appropriate for this purpose The rubber feet also serve as floor supports and allow for surface mounting When mounting the product on the floor make sure that the product
2. is pressed Once the button is released the fog will stop outputting Ready Status LED FC M Manual Fog Overview Button The FC M has a magnetic back that can affix to most metal surfaces for easy placement while the unit is in use Fluid Tank Indicator LED on the back of the Hurricane 1101 shows the status of the fogger as R follows Indicator LED Orange pump is not detecting fluid Note The Hurricane 1101 may output fog for a short duration to allow for a self checking cycle Hurricane 1101 User Manual Rev 1 Page 9 of 9 5 TECHNICAL INFORMATION Fogger Do not allow the fogger to become clogged After every 40 hours of continuous Maintenance operation use CHAUVET Fog Cleaner Quart FCQ through the system to prevent the Page 10 of 10 0 E Storage O accumulation of particulate matter in the heating element The recommended cleaning procedure is as follows Unplug the product from power Empty all fog fluid from the machine Add cleaning solution to the tank Connect the product to power and allow it to warm up Run the unit in a well ventilated area until the tank is almost empty Do not allow the pump to run dry 6 Refill with fogger fluid to continue using the fogger Run the machine briefly to clear any remaining cleaning solution from the pump and heater Se E Do Not operate the machine without fluid at any time Fog Cleaner Quart FCQ was specifically developed
3. FCQ Fog Cleaner Quart was specifically developed by Chauvet to clean your Hurricane 1101 Make sure you use FCQ regularly no longer than 90 days between cleanings to increase the life of your fogger Hurricane M 1101 User Manual Rev 1 2 INTRODUCTION Overview M anual Fog Button Safety Loop Fog Fluid Tank Low Fluid Indicator Fluid Level Indicator M anual Controller Socket Wireless E Controller Socket Power In Fuse Holder Rear Panel View Hurricane 1101 User Manual Rev 1 Page 5 of 5 Dimensions Page 6 of 6 Hurricane M 1101 User Manual Rev 1 3 SETUP AC Power This Hurricane 1101 has a fixed voltage power supply and it can work with an input voltage of either 120 VAC 60 Hz or 230 VAC 50 Hz depending on the specific model To determine the products power requirements circuit breaker power outlet and wiring use the current value listed on the label affixed to the product s back panel or refer to the products specifications chart The listed current rating indicates the product s average current draw under normal conditions Always connect the product to a protected circuit circuit breaker or fuse Make sure the product has an appropriate electrical ground to avoid the risk of electrocution or fire i Never connect the product to a rheostat variable resistor or dimmer circuit even if the rheostat or dimmer channel serves only as a 0 to 100 switch
4. TM 1101 HURRICANE User Manual TABLE OF CONTENTS LA BCIOFS YOU BOIS mn 3 To eRe ee en ee 3 LIMO AGKING ASTUCIA ne Sd eae ns 3 AAA tiie east Uaam rib aled oe aust de E witb feast dea TE 3 TOXECONVE enti or Pe em ed tien en tie ie OE 3 SYDOST 3 BS SC Vet aea E a a E a E NNT 3 Proqlictata MO 1 En EL PR a 4 Dalely NOES dll taie nt ii teen les 4 Z INTTOQUCHONME 5 OMV WS as 5 DIMENSION Sit 6 SU o A A Pe 7 AC TOWEL 7 FUSE ReDIAC MENE sas nel e 7 A E anemuniaenicussdanteew stants 8 A ge statis PEE A 8 A A E O DO A eee aa eee aoe een eee eae 8 9 Remote or Manual Operation iiiisssiiiseeesssereeneesseeeeneeesseeeennnnnes 9 tati 9 FI Eanicindlicator LE D irrena ck PE 9 2 a aa ai 10 Fogger Mantenance sn nn 10 SL 0 ER 10 6 General Troubleshoo linia 11 7 Technical SDeCitiCAtiONS inst 12 RELU as a tea due Do A 13 O ONO 13 Contact 66 14 Page 2 of 2 Hurricane 1101 User Manual Rev 1 1 BEFORE YOU BEGIN What Is Hurricane 1101 Warranty Card Included Manual Fog Controller FC M Quick Reference Guide Hanging Bracket with Mounting Hardware Unpacking Carefully unpack the product immediately and check the container to make sure all the r parts are in the package and are in good condition Instructions Claims lf the box or the contents the product and included accessories appear damaged from shipping or show signs of mishandling notify the carrier immediately not Chauvet Failure t
5. and cables are away from people and vehicles Safety Cable Mounting Clamp fy such as apis an SFA pF p WIA works with CH 05 from Chauvet o dl Y from Chauvet Mounting 7 Fog Fluid Tank Bracket LAIA A Safety Loop Bracket Adjustment Knob x2 Nozzle Rubber Feet for Floor M ounting Mounting Diagram While operating the Hurricane 1101 make sure there is adequate fog fluid in the i machine to prevent pump and heater damage When the fog fluid level becomes low as a safety feature the heat sensor will make a very loud noise Simply add more fog fluid to continue using the Hurricane 1101 Page 8 of 8 Hurricane 1101 User Manual Rev 1 4 OPERATION Remote or The Hurricane 1101 can be operated manually or with the included manual fog M controller Two other optional remote controls are also available a timer remote FC T anua and a wireless remote FC W The Manual button is located on the rear of the unit Operation See the product Overview Manual Fog Connect the fog machine to power Controller 2 Plug the manual fog controller FC M into the Manual Controller socket on the rear of the fog machine FC M 3 Wait for the Status LED to turn green 4 Press the button located on the controller to trigger the fog output The FC M button is momentary which means that the fog machine will only output while the button
6. by Chauvet to clean your Hurricane 1101 Make sure you use FCQ regularly no longer than 90 days between cleanings to increase the life of your product Before storing the fogger run FCQ through the system as described in the cleaning procedure above however only follow steps 1 through 5 Do not refill the tank with fog fluid if storing the fogger Cleaning the system prior to storage will help prevent any particles from condensing inside the pump or heater while not in use Test run your Hurricane 1101 on a monthly basis to achieve the best performance Hurricane M 1101 User Manual Rev 1 6 GENERAL TROUBLESHOOTING Possible Indicator Cause Status Possible Action Symptom Make sure there is fluid in the tank Turn fog machine 45 to flatten out the bubble and allow the fog fluid to flow properly Line blockage or air in fluid Orange Prime by setting output to the highest setting line Turn off the product for 5 seconds and then turn it back on Repeat as necessary Note After more than 10 attempts contact Customer Service Clean thoroughly with CHAUVET FCO For full Incorrect fluid Off instructions see Fogger Maintenance Refill with CHAUVET water based haze fluid Clean thoroughly with CHAUVET FCO For full Incorrect fluid instructions see Fogger Maintenance Refill with Off CHAUVET water based haze fluid Blocked pipes Contact Customer Service Failing part Contact Customer Service Make sur
7. e that the total load does not exceed 80 of the breaker or fuse nominal current No output or short output No output or spitting fluid Excessive load on the circuit Fuse keeps blowing Short circuit along the power mes Check the power lines and power cords Check power outlet No energy on power outlet Change to another outlet Product does not power Loose or damaged power cord Check the power cord up Replace blown fuse with a good one of the same Blown fuse type and rating Internal problem Send product for repair Low No Fluid Refill product with fluid Product stops pumping Loud noise Pump protection system Release manual fog button and press it again to engaged reset pump protection system If you still experience problems after trying the solutions presented here contact Chauvet Technical Support See Contact Us Hurricane 1101 User Manual Rev 1 Page 11 of 11 7 TECHNICAL SPECIFICATIONS Dimensions and Length Width Height Weight Weight 9 9 in 252 mm 9 6 in 243 mm 8 8 in 222 mm 7 4 lb 3 4 kg Note Dimensions in inches rounded to the nearest decimal digit Power Power Supply Type Range Voltage Selection z 120 VAC 60 Hz or Model specific 230 VAC 50 Hz Fixed Parameter 120 V 60 Hz 230 V 50 Hz Consumption 612 W 716 W Operating Inrush current 5 1A 3 1A Fuse F 8A 250 V F 5A 250 V Power 1 0 US Worldwide UK Europe Power input connector Hard wired Hard wired Power Cord plug Edison US Local plu
8. er Chauvet will refuse any product returned without an RMA number Write the RMA number on a properly affixed label DO NOT write the RMA number Le directly on the box Before sending the product clearly write the following information on a piece of paper and place it inside the box Your name Your address Your phone number RMA number A brief description of the problem Be sure to pack the product properly Any shipping damage resulting from inadequate packaging will be your responsibility FedEx packing or double boxing are recommended Chauvet reserves the right to use its own discretion to repair or replace returned product s Hurricane 1101 User Manual Rev 1 Page 13 of 13 C 0 NTACT WORLD HEADQUARTERS Chauvet General Information Technical Support U Address 5200 NW 108th Avenue Voice 954 577 4455 Press 4 S Sunrise FL 33351 Fax 954 756 8015 Voice 954 577 4455 Email tech chauvetlighting com Fax 954 929 5560 Tollfree 800 762 1084 World Wide Web www chauvetlighting com UNITED KINGDOM AND IRELAND Chauvet Europe Ltd General Information Technical Support Address Unit 1C Email uktech chauvetlighting com Brookhill Road Industrial Estate Pinxton Nottingham UK World Wide Web www chauvetlighting co uk NG16 6NT Voice 44 0 1773 511115 Fax 44 0 1773 511110 MEXICO Chauvet Mexico General Information Technical Support Address Av Santa Ana 30 Email servicio chauvet com mx Parque Industrial L
9. er Slave Safety Notes Page 4 of 4 E D Auto Programs Fixed voltage 120 V or 230 V User Serviceable Duty Cycle X P P X X These notes include important information about the mounting usage and maintenance of this product read before using the product Always connect the product to a grounded circuit to avoid the risk of electrocution Always disconnect the product from the power source before cleaning or replacing the fuse Make sure the power cord is not crimped or damaged Never disconnect the product from power by pulling or tugging on the cord If mounting the product overhead always secure to a fastening device using a safety cable Make sure there are no flammable materials close to the product when operating Do not touch the products housing when operating because it may be very hot Do not mount the product on a flammable surface linoleum carpet wood paper carton plastic etc The product s nozzle is very hot during operation and it remains hot for a long time after operation has stopped The fog exits the nozzle at a very high temperature Keep a minimum distance of 6 5 ft 2 m from the nozzle to the nearest object Do not use the product as a space heater Do not drink or come in contact with the fog fluid If you do call your local emergency service 911 in the US for help Do not add perfume alcohol gasoline or any other flammables to the fog fluid Always make sure that t
10. erma Lerma Mexico C P 52000 World Wide Web www chauvet com mx Voice 52 728 285 5000 Outside the U S United Kingdom Ireland or Mexico contact your dealer Follow their instructions to request support or to return a product Visit our website for contact details Page 14 of 14 Hurricane 1101 User Manual Rev 1
11. g Operation Heat up Time Tank Capacity Fluid Consumption 5 min 0 3 gal 1 3 I 30 ml min Fog Output Output 8 000 cfm Thermal Maximum External Temp Cooling System 104 F 40 C Convection Ordering Product Name Item Code Item Number Hurricane 1101 120 V 05070794 781462211424 Hurricane 1101 230 V 05070797 781462211455 RoHS E CE Page 12 of 12 Hurricane 1101 User Manual Rev 1 To return a product or request support R E TU R N S In the U S contact Chauvet World Headquarters see Contact Us In the UK or Ireland contact Chauvet Europe Ltd see Contact Us In Mexico contact Chauvet Mexico see Contact Us In any other country DO NOT contact Chauvet Contact your distributor See www chauvetlighting com for distributors outside the U S United Kingdom Ireland or Mexico If you live outside the U S United Kingdom Ireland or Mexico contact your LE distributor of record and follow their instructions on how to return Chauvet products to them Visit our website for contact details RMA Call the corresponding Chauvet Technical Support office and request a Return Merchandise Authorization RMA number before shipping the product Be prepared to provide the model number serial number and a brief description of the cause for the return You must send the merchandise prepaid in its original box and with its original packing and accessories Chauvet will not issue call tags Clearly label the package with the RMA numb
12. he voltage of the outlet to which you are connecting the product is within the range stated on the decal or rear panel of the product The product is for indoor use only IP20 To prevent risk of fire or shock do not expose the product to rain or moisture Always install the product in a location with adequate ventilation at least 20 in 50 cm from adjacent surfaces Be sure that no ventilation slots on the product s housing are blocked Never connect the product to a dimmer Make sure to replace the fuse with another of the same type and rating Never carry the product from the power cord or any moving part Always use the hanging mounting bracket The maximum ambient temperature Ta is 104 F 40 C Do not operate the product at higher temperatures In the event of a serious operating problem stop using the product immediately Never try to repair the product Repairs carried out by unskilled people can lead to damage or malfunction Contact the nearest authorized technical assistance center This product is not intended for permanent installation Use only CHAUVET water based fog fluid Drain the tank before transporting the product To eliminate unnecessary wear and improve its lifespan during periods of non use completely disconnect the product from power via breaker or by unplugging it Keep this User Manual for future use If you sell the product to another user be sure to give this document to the next owner
13. o report damage to the carrier immediately may invalidate your claim In addition keep the box and contents for inspection For other issues such as missing components or parts damage not related to shipping or concealed damage file a claim with Chauvet within 7 days of delivery Text Convention Meaning Conventions 1 512 A range of values 50 60 A set of values Settings A menu option Menu gt Settings A sequence of menu options lt Enter gt A button Sym bols Symbol Meaning Critical installation configuration or operation information Not following these instructions may make the product not work cause damage to the product or cause harm to the operator Important installation or configuration information The product may not function correcily if this information is not used Useful information HQE Disclaimer The information and specifications contained in this User Manual are subject to change without notice Chauvet assumes no responsibility or liability for any errors or omissions and reserves the right to revise or recreate this manual at any time Download the latest version from www chauvetlighting com Copyright 2014 Chauvet All rights reserved Electronically published by Chauvet in the United States of America Author Date Editor Date M Trouard 06 23 2014 A Leon 10 23 14 Hurricane 1101 User Manual Rev 1 Page 3 of 3 Product ata Use on Dimmer Glance Outdoor Use Sound Activated DMX Mast

CHAUVET DJ Hurricane 1101

Contents

Download Pdf Manuals

Related Search

Related Contents