Intex 28145EG above ground pool
Contents
1. 5 X 10 3 PANTONE 295U 06 21 2013 English SETUP INSTRUCTIONS continued A WARNING Position this product away from the pool so as to prevent children from climbing on it and accessing the pool UPPER PROTRUDING WATER LEVEL HOSE CONNECTION POOL INLET NOZZLE o REMOVE AIR RELEASE VALVE THREADED COVER B lt PLUG HOSE FILTER CARTRIDGE INSIDE STRAINER GRID REMOVE SS WATER DIRE UPPER PUMP CONNECTION INSIDE OF POOL LOWER PUMP CONNECTION HOSE CLAMP e ILLUSTRATION NOT TO SCALE CLEANING OR REPLACING FILTER CARTRIDGES Make sure filter pump is not operating Disconnect line cord To prevent water from escaping the pool unscrew the pool inlet nozzle 10 and strainer grid 11 from the strainer connectors and insert the hat like plugs into the strainer connectors In a counter clockwise motion remove threaded cover 3 and cover seal 4 Be careful not to lose the cover seal 4 Remove filter cartridge 5 to clean it The filter may be cleaned from the spray from a water hose Use judgement as to whether cartridge needs to be replaced Return cartridge to filtering position Return the seal 4 and threaded cover 3 to their original positions Tighten the threaded cover 3 by hand only twisting it in a clock wise direction After service open the air release valve remove the plugs allow any air to escape through the valve before tighte2. 57 MODEL 603 FILTER PUMP ENGLISH 7 5 X 10 3 PANTONE 295U 06 21 2013 English 57 IMPORTANT SAFETY RULES Read understand and follow all instructions carefully before installing and using this product Krystal Clear Model 603 Filter Pump lI UNTEX IMPORTANT DO NOT RETURN PRODUCT TO STORE To purchase parts and accessories or to obtain non technical assistance Visit www intexcorp com For technical assistance and missing parts call us toll free for U S and Canadian Residents 1 800 234 6839 Monday through Friday 8 30am to 5 00pm Pacific Time 057 R0 1406 57 MODEL 603 FILTER PUMP ENGLISH 7 5 X 10 3 PANTONE 295U 06 21 2013 English TABLE OF CONTENTS Warnings Parts Reference Setup Instructions Maintenance Pool Care and Chemicals Long Term Storage Troubleshooting Guide Common Pool Problems General Aquatic Safety Limited Warranty Operation is subject to the following two conditions 1 this device may not cause interference and 2 this device must accept any interference including interference that may cause undesired operation of the device Changes or modifications not expressly approved by the party responsible for compliance could void the user s authority to operate the equipment This equipment has been tested and found to comply with the limits for Class B digital device pursuant to part 15 of the FCC Rules These limits are designed to provide reasonable protection a
3. PANTONE 295U 06 21 2013 English COMMON POOL PROBLEMS PROBLEM DESCRIPTION SOLUTION ALGAE Greenish water Chlorine and pH levels Super chlorinate with shock Green or black need adjustment treatment Correct pH to your spots on pool liner pool store s recommended level Pool liner is slippery Vacuum pool bottom and or has a bad Maintain proper chlorine odor level COLORED Water turns blue Copper iron or Adjust pH level to the WATER brown or black when manganese in water being recommended level first treated with oxidized by the added Run filter until water is clear chlorine chlorine This is common Clean cartridge frequently FLOATING Water is cloudy or Hard water caused by a Correct the pH level Check with MATTER IN milky too high pH level your pool dealer for advice WATER Chlorine content is low Adjust the chlorine level Foreign matter in water Clean or replace your filter CHRONIC LOW e Level is lower than on Rip or hole in pool liner or Repair with a patch kit WATER LEVEL previous day hoses Finger tighten all caps The drain valves are loose SEDIMENT Dirt or sand on pool Heavy use getting in and Use Intex pool vacuum to clean ON POOL floor out of pool bottom of pool BOTTOM SURFACE e Pool too close to trees Use Intex pool skimmer DEBRIS IMPORTANT If you continue to experience difficulty please contact our Consumer Service Department for
4. assistance See separate Authorized Service Centers sheet SAVE THESE INSTRUCTIONS 57 MODEL 603 FILTER PUMP ENGLISH 7 5 X 10 3 PANTONE 295U 06 21 2013 English GENERAL AQUATIC SAFETY Water recreation is both fun and therapeutic However it involves inherent risks of injury and death To reduce your risk of injury read and follow all product package and package insert warnings and instructions Remember however that product warnings instructions and safety guidelines cover some common risks of water recreation but do not cover all risks and dangers For additional safeguards also familiarize yourself with the following general guidelines as well as guidelines provided by nationally recognized Safety Organizations Demand constant supervision A competent adult should be appointed as a lifeguard or water watcher especially when children are in and around the pool Learn to swim Take the time to learn CPR and first aid Instruct anyone who is supervising pool users about potential pool hazards and about the use of protective devices such as locked doors barriers etc Instruct all pool users including children what to do in case of an emergency Always use common sense and good judgement when enjoying any water activity Supervise supervise supervise For additional information on safety please visit The Association of Pool and Spa Professionals The Sensible Way to Enjoy Your Abo
5. products are subject to negligence abnormal use or operation accident improper operation improper voltage or current contrary to operating instructions or to damage by circumstances beyond Intex s control including but not limited to ordinary wear and tear and damage caused by exposure to fire flood freezing rain or other external environmental forces This Limited Warranty applies only to those parts and components sold by Intex The Limited Warranty does not cover unauthorized alterations repairs or disassembly by anyone other than Intex Service Center personnel DO NOT GO BACK TO THE PLACE OF PURCHASE FOR RETURN OR REPLACEMENT IF YOU ARE MISSING PARTS OR NEED ASSISTANCE PLEASE CALL US TOLL FREE FOR U S AND CANADIAN RESIDENTS 1 800 234 6839 OR VISIT OUR WEBSITE WWW INTEXSTORE COM Proof of Purchase must accompany all returns or the warranty claim will be invalid SAVE THESE INSTRUCTIONS
6. F NO DESCRIPTION QTY SPARE PART NO 1 ARRELEASEVALVE 1 10460 2 VAVEORNG 1 1064 3 THREADEDCOVER 1 1049 pense em I m 5 FILTER CARTRIDGE 59900 DENEN DENEN 6 HOSESEAL 2 101834 7 rosone 4 e s moe 2 s s smameRcomwEcrn 2 moo When ordering parts be sure to quote the model number and part numbers p io a NO N SAVE THESE INSTRUCTIONS 57 MODEL 603 FILTER PUMP ENGLISH 7 5 X 10 3 PANTONE 295U 06 21 2013 English SETUP INSTRUCTIONS Be sure you have access to water to fill the pool and chemicals for the water IMPORTANT This filter pump is shipped with the air release valve 1 open open the air release valve if necessary DO NOT replace the air release valve until you reach STEP 8 Failure to follow these instructions will result in air trapped inside filter housing the motor will run dry be noisy and malfunction 1 Assemble above ground pool first Carefully follow the pool s installation instructions 2 Place the filter pump the length of the hose away from the pool wall where the lower black protruding hose connection is sticking out 3 Insert the nozzle union 9 amp 10 into the upper protruding hose connections Then insert the strainer union 9 amp 11 into the lower protruding hose connections The hoses 8 fit over the stra
7. cle this product is provided with a ground fault circuit interrupter If replacement of the plug or cord is needed use only identical replacement parts Always unplug this product from the electrical outlet before removing cleaning servicing or making any adjustment to the product The unit is provided with a ground fault circuit interrupter GFCI To test the GFCI push the test button The GFCI should interrupt power Push the reset button power should be restored If the GFCI fails to operate in this manner The GFCI is defective If the GFCI interrupts power to the pump without the test button being pushed a ground current is flowing indicating the possibility of an electric shock Do not use this pump Disconnect the pump and have the problem corrected by a qualified service representative before using Do not bury the electrical cord Locate the cord where it will not be damaged by lawn mowers hedge trimmers and other equipment To reduce the risk of electric shock the supply cord cannot be replaced If the cord is damaged the appliance should be replaced immediately To reduce the risk of electric shock do not use extension cords timers plug adaptors or converter plugs to connect unit to electric supply provide a properly located outlet Do not attempt to plug in or unplug this product while standing in water or when your hands are wet Do not use an appliance leakage current interrupter ALCI in place of a GFCI s
8. erneath the pool liner will be destroyed Note that some types of grass may grow through the liner Filter run time depends on pool size weather and usage level Experiment with various run times so as to produce clean clear water A CAUTION Concentrated chlorine solutions may damage the pool liner Always follow the chemical manufacturer s directions and the health and hazard warnings LONG TERM STORAGE 1 Before emptying your pool for long term storage or relocation be sure the water is directed towards an acceptable drain water receptacle away from the house Check local regulations for specific directions regarding disposal of swimming pool water Now drain the pool When the pool is empty disconnect all pool hoses 8 from the pool and filter pump simply reverse the set up instructions Remove the filter cartridge as shown in the Filter Cartridge Cleaning section steps 2 thru 4 Remove the nozzle and strainer unions from the pool wall Place the wall plugs into the hose connections Loosen clamps 7 securing the strainer connectors 9 before removal Drain water from the filter pump housing Leave filter pump pieces and hoses outside to thoroughly air dry Depending on the cartridge b usage a new cartridge may be needed for next season keep a spare available Cover the seal 4 air release valve O ring 2 and hose seals 6 with petroleum jelly to preserve its resilience during storage Store the unit and access
9. gainst harmful interference in a residential installation This equipment generates uses and can radiate radio frequency energy and if not installed and used in accordance with the instructions may cause harmful interference to radio communications However there is no guarantee that interference will not occur in a particular installation If this equipment does cause harmful interference to radio or television reception which can be determined by turning the equipment off and on the user is encouraged to try to correct the interference by one or more of the following measures Reorient or relocate the receiving antenna Increase the separation between the equipment and the receiver Connect the equipment into an outlet on a circuit different from that to which the receiver is connected Consult the dealer or an experienced radio TV technician for help SAVE THESE INSTRUCTIONS 57 MODEL 603 FILTER PUMP ENGLISH 7 5 X 10 3 PANTONE 295U 06 21 2013 English IMPORTANT SAFETY RULES Read Understand and Follow All Instructions Carefully Before Installing and Using this Product READ AND FOLLOW ALL INSTRUCTIONS A WARNING To reduce the risk of injury do not permit children to use this product Always supervise children and those with disabilities Children must stay away from this product and electrical cord s Assembly and disassembly by adults only Risk of electric shock Connect only to a grounding type recepta
10. ilter cord must be plugged into a 3 wire outlet that is protected by a Class A Ground Fault Circuit Interrupter Reset circuit breaker If circuit breaker trips repeatedly your electrical system may have a defect Turn off circuit breaker and call an electrician to correct the problem Let motor cool down Adjust the chlorine and pH level Consult your local swimming pool supply stores Clean or replace cartridge Check the cartridge for holes Replace if damaged Operate the filter for longer periods Clean the strainer screen at the inlet Clear any obstructions in the intake hose by discharging it inside pool wall Tighten hose clamps check hoses for damage check pool water level Replace cartridge Clean cartridge more often Install the nozzle at the upper position of the pool inlet and the strainer at the lower position of the pool outlet Fill pool to correct water level Clean strainer screens at pool inlet Tighten hose clamps check hose for damage Clear any sticks or leaves in the intake hose Open the release valve at top of pump Remove cover amp check for O ring Tighten cover or valve Manually Tighten or reinstall hose clamps Put the o ring back into the groove Replacea new hose Open air release valve lift and lower the inlet hose until water starts to flow out of air release valve close air release valve SAVE THESE INSTRUCTIONS 57 MODEL 603 FILTER PUMP ENGLISH 7 5 X 10 3
11. ince the ALCI will not protect people Position this product away from the pool so as to prevent children from climbing on it and accessing the pool Do not operate this product when the pool is occupied This product is intended to be used only for the purposes described in the manual FAILURE TO FOLLOW THESE WARNINGS MAY RESULT IN PROPERTY DAMAGE ELECTRIC SHOCK ENTANGLEMENT OR OTHER SERIOUS INJURY OR DEATH A CAUTION This product is for use with storable pools only Do not use with permanenily installed pools A storable pool is constructed so that it is capable of being readily disassembled for storage and reassembled to its original integrity A permanently installed pool is constructed in or on the ground or in a building such that it cannot be readily disassembled for storage These product warnings instructions and safety rules provided with the product represent some common risks of water recreation devices and do not cover all instances of risk and danger Please use common sense and good judgement when enjoying any water activity SAVE THESE INSTRUCTIONS 57 MODEL 603 FILTER PUMP ENGLISH 7 5 X 10 3 PANTONE 295U 06 21 2013 English PARTS REFERENCE Before assembling your product please take a few minutes to check the contents and become familiar with all the parts NOTE Drawings for illustration purpose only May not reflect actual product Not to scale RE
12. iners inserted into the connections There are two hoses to be connected to the filter pump hose connections With hose clamps 7 fasten one of the hoses 8 to the lower protruding hose connection marked on the pool liner and to the upper pump connection marked Connect the second hose to the remaining upper protruding hose connection and to the lower pump connection Make sure all the hose clamps 7 are tight Twist the filter pump s threaded cover 3 in a clock wise direction to be sure it is on tight Use only your hands to tighten the top Do not tighten with tools such as pliers Fill the pool to a level of at least 1 2 inches above the top connection The water will automatically flow down into the pump When water starts flowing out of the air release valve hole screw in the air release valve back into the filter housing cover Do not over tighten the valve NOTE Venting the system is necessary for air to escape as the filter housing fills with water Connect the filter pump to the power outlet The filter pump is now filtering the water A WARNING Risk of electric shock Connect this product only to a grounding type receptacle protected by a ground fault circuit interrupter GFCI Contact a qualified electrician if you cannot verify that the receptacle is protected by a GFCI 10 Operate the filter pump until the desired water clarity is obtained SAVE THESE INSTRUCTIONS 57 MODEL 603 FILTER PUMP ENGLISH 7
13. ning the valve again and replace the pool inlet nozzle 10 and strainer grid 11 The pump is now primed with water again and may be turned on SAVE THESE INSTRUCTIONS 57 MODEL 603 FILTER PUMP ENGLISH 7 5 X 10 3 PANTONE 295U 06 21 2013 English POOL CARE AND CHEMICALS All pools require care to keep the water clear and hygienically clean With proper chemical control your filter will help attain this objective Consult your pool supply dealer for instructions regarding the proper use of chlorine algaecide and other chemical agents required for sparkling clear water Keep pool chemicals away from children Do not replenish chemicals in pool while pool is occupied Skin or eye irritations could occur Daily pH checking and chemical treatment of the water is very important and can not be overemphasized Chlorine algaecide and maintenance of proper pH levels are required when filling the pool as well as during the season Consult your local swimming pool supply store for instructions The season s first filling of the pool may have brackish water requiring extra water additives and extra filter changes Do not allow swimming in pool until the pH level is balanced Consult your local swimming pool supply store for instructions Keep spare filter cartridges on hand Replace cartridges every two weeks Chlorinated water may damage lawns gardens or shrubbery as children play in the pool and splash water outside the pool Lawn areas und
14. ories in a dry place The storage s temperature should be controlled between 32 degrees Fahrenheit 0 degrees Celsius and 104 degrees Fahrenheit 40 degrees Celsius storage location 11 The original packing can be used for storage o euo GP WN e SAVE THESE INSTRUCTIONS TROUBLE FILTER MOTOR FAILS TO START FILTER DOESN T CLEAN POOL FILTER DOESN T PUMP WATER OR FLOW IS VERY SLOW PUMP DOESN T WORK TOP COVER LEAKING HOSE LEAKING AIR LOCK 57 MODEL 603 FILTER PUMP ENGLISH 7 5 X 10 3 PANTONE 295U 06 21 2013 English TROUBLESHOOTING GUIDE The motor is not plugged in The GFCI circuit breaker is tripped Motor too hot and overload protection is shut off Improper chlorine or pH levels Filter cartridge is dirty Damaged cartridge Excessively dirty pool The strainer screen is restricting the water flow Clogged inlet or discharge An air leak on the intake line Scale or buildup on cartridge Excessively dirty pool Dirty filter cartridge Nozzle and strainer connection are reversed Low water level Strainer screen plugged up An air leak on the intake hose Faulty motor or the impeller is jammed An air lock inside the cartridge chamber O ring missing Cover or air release valve are not tight Hose clamps are not well fitted Hose o ring dislodged when connecting the hose Hose broken There s air trapped in the pump housing and inlet hose SOLUTION F
15. veground Onground Swimming Pool www nspi org American Academy of Pediatrics Pool Safety for Children www aap org e Red Cross www redcross org Safe Kids www safekids org Home Safety Council Safety Guide www homesafetycouncil org Toy Industry Association Toy Safety www toy tia org SAFETY IN YOUR POOL Safe swimming depends on constant attention to the rules The NO DIVING sign within this manual can be posted near your pool to help keep everyone alert to the danger You may also wish to copy and laminate the sign for protection from the elements SAVE THESE INSTRUCTIONS 57 MODEL 603 FILTER PUMP ENGLISH 7 5 X 10 3 PANTONE 295U 06 21 2013 English LIMITED WARRANTY Your Krystal Clear Filter Pump has been manufactured using the highest quality materials and workmanship All Intex products have been inspected and found free of defects prior to leaving the factory This Limited Warranty applies only to the Krystal Clear Filter Pump and accessories listed below The provisions of this Limited Warranty apply only to the original purchaser and is not transferable This Limited Warranty is valid for the period noted below from the date of the initial retail purchase Keep your original sales receipt with this manual as proof of purchase will be required and must accompany warranty claims or the Limited Warranty is invalid Krystal Clear Filter Pump Warranty 1 Year Hoses Plunger Valves amp Fittings Warrant
16. y 180 days If a manufacturing defect is found within the periods noted above please contact the appropriate Intex Service Center listed in the separate Authorized Service Centers sheet The Service Center will determine the validity of the claim If the Service Center directs you to return the product please carefully package the product and send with shipping and insurance prepaid to the Service Center Upon receipt of the returned product the Intex Service Center will inspect the item and determine the validity of the claim If the provisions of this warranty cover the item the item will be repaired or replaced at no charge Any and all disputes regarding the provisions of this Limited Warranty shall be brought before an informal dispute settlement board and unless and until the provisions of these paragraphs are carried forth no civil action may be instituted The methods and procedures of this settlement board shall be subject to the rules and regulations set forth by the Federal Trade Commission F T C IMPLIED WARRANTIES ARE LIMITED TO THE TERMS OF THIS WARRANTY AND IN NO EVENT SHALL INTEX THEIR AUTHORIZED AGENTS OR EMPLOYEES BE LIABLE TO THE BUYER OR ANY OTHER PARTY FOR DIRECT OR CONSEQUENTIAL DAMAGES OR LIABILITIES Some states or jurisdictions do not allow the exclusion or limitation of incidental or consequential damages so the above limitation or exclusion may not apply to you This Limited Warranty does not apply if the
Download Pdf Manuals
Related Search