Home

Lenovo IdeaPad G505S

1. Send the victim to get medical aid Safety information Safety inspection guide inspection guide The purpose of this inspection guide is to assist you in identifying potential unsafe conditions As each machine was designed and built required safety items were installed to protect users and service personnel from injury This guide addresses only those items You should use good judgment to identify potential safety hazards due to attachment of non Lenovo features or options not covered by this inspection guide If any unsafe conditions are present you must determine how serious the apparent hazard could be and whether you can continue without first correcting the problem Consider these conditions and the safety hazards they present Electrical hazards especially primary power primary voltage on the frame can cause serious or fatal electrical shock Explosive hazards such as a damaged CRT face or a bulging capacitor Mechanical hazards such as loose or missing hardware To determine whether there are any potential unsafe conditions use the following checklist at the beginning of every service task Begin the checks with the power off and the power cord disconnected Checklist 1 Check exterior covers for damage loose broken or sharp edges 2 Turn off the computer Disconnect the power cord 3 Check the power cord for a A third wire ground connector in good condition Use a meter to measure third wir
2. IROLCD unitaria 1130 Heat Sink assembly 7 AE O E DE 1150 Base cover speakers USB and power assembly 65 1160 LCD front bezel 70 1170 LCD panel LCD cable and hinges 71 1180 Integrated camera 1190 Antenna assembly and LCD cover 7A Loca te E E 75 rer 75 Right side view 77 Bottom and Left side view LO Parts list ecce 79 Overall iii lloras 80 LCD FRUS eene 86 Keyboard 89 Miscellaneous parts 93 AC adapters SCE nr Power cords NOTICES e 99 LKE 100 iti iv This manual contains service and reference information for the following Lenovo product G400s G405s G400s Touch G500s G505s G500s Touch Use this manual to troubleshoot problems The manual is divided into the following sections The common sections provide general information guidelines and safety information required for servicing computers The product specific section includes service reference and product specific parts information Important This manual is intended only for trained servicers who are familiar with Lenovo products Use this manual to troubleshoot problems effectively Before servicing a Lenovo product make sure to read all the information under Safety information on page 1 and Important service information on page 16 Safety information This chapter presents the following safety information that you need to get familiar with before you service a Lenovo comput
3. Stand on suitable rubber mats obtained locally if necessary to insulate you from grounds such as metal floor strips and machine frames Observe the special safety precautions when you work with very high voltages instructions for these precautions are in the safety sections of maintenance information Be extremely careful when you measure the high voltages Regularly inspect and maintain your electrical hand tools for safe operational condition Do not use worn or broken tools and testers Never assume that power has been disconnected from a circuit First check it to make sure that it has been powered off I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Always look carefully for possible hazards in your work area Examples of these hazards are moist floors nongrounded power extension cables power surges and missing safety grounds Do not touch live electrical circuits with the reflective surface of a plastic dental mirror The surface is conductive such touching can cause personal injury and machine damage Do not service the following parts with the power on when they are removed from their normal operating places in a machine Power supply units Pumps Blowers and fans Motor generators and similar units This practice ensures correct grounding of the units If an electrical accident occurs Use caution do not become a victim yourself Switch off the power
4. Akkus enthalten geringe Mengen von Nickel Sie d rfen nicht zerlegt wiederaufgeladen kurzgeschlossen oder Feuer oder Wasser ausgesetzt werden Bei der Entsorgung die rtlichen Bestimmungen f r Sondermiill beachten Beim Ersetzen der Batterie nur Batterien des Typs verwenden der in der Ersatzteilliste aufgef hrt ist Der Einsatz falscher Batterien kann zu Entz ndung oder Explosion f hren 5p 9 nog NM In NIINON INI pownd Addon TINA DN p5235 PN OVIT DN DO V INN ISPI IN 0999 IN UNI IMIN mann zm 59 WINI ASADA AION INA 19902 p VANUNI v 0 5172n tpm NINA PRI AANA DIPINN nav 3 NDA 2129 MINIMA NI NINDI VIV INON INI AINON 5v MIVINA IN ANSNI DIVI La batteria contiene piccole quantit di nichel Non smontarla gettarla nel fuoco o nell acqua n cortocircuitarla Smaltirla secondo la normativa in vigore DPR 915 82 successive disposizioni e disposizioni locali Quando si sostituisce la batteria utilizzare soltanto i tipi inseriti nell appropriato Catalogo parti L impiego di una batteria non adatta potrebbe determinare l incendio o l esplosione della batteria stessa Ry7TY_ AyFRPED ITABEENTWET NYT Y RVD VAMUIEU KERO HIRE va RS HAUTS ESV SITI Ry ADRECH CH HBB KORE LAI HES C CREW NYT D e NYT ER SLE ARY gt VX RTS RYT UR SEAL TSC EE Rolky I EATE ST Y BREKUEO RELIEVTSIERSVET Las bater as contienen peque as cantidades de n quel No las desmonte ni recargue ni las eche al fuego o al agua ni las cortocircuite Des
5. DANGER Before removing any FRU turn off the computer unplug all power cords from electrical outlets remove the battery pack and then disconnect any interconnecting cables Avant de retirer une unit remplacable en client le mettez le syst me hors tension d branchez tous les cordons d alimentation des socles de prise de courant retirez la batterie et d connectez tous les cordons d interface Die Stromzufuhr muf abgeschaltet alle Stromkabel aus der Steckdose gezogen der Akku entfernt und alle Verbindungskabel abgenommen sein bevor eine FRU entfernt wird AUNAN NN 335 v mud FRU pv van NOMA WN un TINA 9929 99 NN PMII DIAN 55355 5532 PMI TN ADDON 152 NN MINI V ON Prima di rimuovere qualsiasi FRU spegnere il sistema scollegare dalle prese elettriche tutti i cavi di alimentazione rimuovere la batteria e poi scollegare i cavi di interconnessione FRU 0 SF BNC ThinkPad ORE WoC 3 COS FEL VYRBOALTC HEV RIT TU y 7 EL MAr 7 v BALTC HEV Antes de quitar una FRU apague el sistema desenchufe todos los cables de las tomas de corriente el ctrica quite la baterfa y a continuaci n desconecte cualquier cable de conexi n entre dispositivos 13 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Laser compliance statement compliance statement Some models of Lenovo computer are equipped from the factory with an optical storage device such as a CD ROM drive or
6. on page 44 1080 Fan assembly on page 46 1090 Keyboard on page 47 1100 Keyboard bezel on page 52 55 7 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Figure 11 Removal steps of system board G500s Loosen the screws FJ Detach the LCD connector Ej optical disk drive board connector IO board and LED board connector in the direction shown by arrows EJ EJ unplug the speakers and DC IN cable connector in the direction shown by arrows DD Step Screw quantity Color Torque H M25x3mm flat head nylok coated 4 Black 1 5 2 0 kgfcm 56 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Figure 11 Removal steps of system board G400s Loosen two screws Ef Detach LCD connector in the direction shown by arrow A USB board connector in the direction shown by arrow Unplug the DC IN cable and speakers connectors in the direction shown by arrows When installing Make sure that all the connectors are attached firmly Step Screw quantity Color Torque H M25 x3 mm flat head nylok coated 2 Black 2 38 2 48 kgfcm 57 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Figure 11 Removal steps of system board continued Remove the system board in the direction shown by arrow D When installing When attaching the system board to the base cover adjust the placement of the ports as shown in EJ and make sur
7. G400s Touch G500s Touch VILG1 SCREW 2 2 0D 2L K 7D ZK NL CR3 G400s G500s G400s Touch G500s Touch VILG1 SCREW 2 0D 3 5L K 3 7D BNI NL 0 5T G400s G500s G400s Touch G500s Touch VILG1 SCREW 2 5D 3L K 4 5D 0 5T ZK NL G400s G500s G400s Touch G500s Touch VILG1 SCREW 3 0D 3 0L K 4 9D NI G400s G500s G400s Touch G500s Touch VILG2 SCREW 2 5D 3 0L K 5 3D NI NL G400s G400s Touch VILG2 SCREW 1 98D 9 0L K 5 3D ZK NL CR3 G400s G400s Touch VILG2 SCREW 2 5D 4 0L K 4 6D NI NL G400s G400s Touch VILG2 SCREW 2D 5L K 4 6D NI NL G400s G400s Touch VILG1 SCREW 2D 3L K 8D ZK NL G500s G500s Touch VILG1 SCREW 2D SL K 4 6D ZK NL CR3 G500s G500s Touch VILG1 SCREW 2 5D 3 5L K 5 3D NI NL 0 5T G500s G500s Touch VILG1 SCREW 2 5D 5 0L K 4 6D ZK NL CR3 G400s G500s G500s Touch P N 36200249 36200251 36200253 36200250 36200252 36200254 P N 90202913 90202914 90202915 90202916 90202919 90202921 90202922 90202924 90202925 90202926 90202927 90202917 90202918 90202920 90202923 CRU CRU ID ID Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Power cords A Lenovo power cord for a specific country or region is usually available only in that country or region Table 12 Parts list 3 pin power cords Region P N CRU ID CCC 145000600 LINETEK PC323 RVV300 300 LS15 1m Argentina 145000599 LINETEK LS15 H03VV F LP39 1m Danmark 145000598 e
8. VILG2 MB UMA HM70 TS G400s Touch VILG2 MB UMA HM76 TS G400s Touch VILG2 MB W8P DIS HM76 GE 2G TS G400s Touch FRU no 90202867 90003103 90003104 90003105 90003106 90003110 90003111 90003113 90003114 90003115 90003116 90003120 90003121 90003123 90003124 90003125 90003126 90003130 90003131 90003073 90003074 90003075 90003076 90003078 90003079 90003080 90003082 90003083 90003084 90003085 90003087 90003088 90003089 90003091 90003092 90003093 90003094 90003096 90003097 90003098 90003107 90003108 90003109 90003112 90003117 CRU ID N Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Table 5 Parts list Overall continued No FRU FRU no CRUID 1 VILG2 MB W8P DIS HM76 GE 1G TS G400s Touch 90003118 N 1 VILG2 MB W8P UMA HM70 TS G400s Touch 90003119 N 1 VILG2 MB W8P UMA HM76 TS G400s Touch 90003122 N 1 VILG2 MB W8S DIS HM76 GE 2G TS G400s Touch 90003127 N 1 VILG2 MB W8S DIS HM76 GE 1G TS G400s Touch 90003128 N 1 VILG2 MB W8S UMA HM70 TS G400s Touch 90003129 N 1 VILG2 MB W8S UMA HM76 TS G400s Touch 90003132 N 1 VILG1 MB DIS HM76 GE 2G TS G500s Touch 90003077 N 1 VILG1 MB UMA HM76 TS G500s Touch 90003081 N 1 VILG1 MB W8P DIS HM76 GE 2G TS G500s Touch 90003086 N 1 VILG1 MB W8P UMA HM76 TS G500s Touch 90003090 N 1 VILG1 MB
9. International English Czechoslovakian Bulgarian Indian English U K English Italian Spanish Turkish Thai Portuguese Latin Canadian English amp French Korean Traditional Chinese Russian French German Arabic Brazilian Japanese Dutch P N 25211110 25211111 25211112 25211113 25211114 25211115 25211116 25211117 25211118 25211119 25211120 25211121 25211 25211 25211 25211125 25211126 25211127 25211 25211 28 29 25211130 25211131 25211 32 25211133 25211134 25211135 25211136 25211137 25211138 25211139 25211140 25211141 25211142 25211143 25211144 25211145 25211146 25211147 25211148 25211149 25211150 25211151 25211152 25211153 25211154 25211155 25211156 25211157 CRU ID Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z Z oo Ko I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Table 8 Parts list Keyboard Language Sunrex continued G400s Darfon 90 Greek Hebrew Hungarian Four Nordic countries Belgian Icelandic Slovenian Swiss International English Czechoslovakian Bulgarian Indian English U K English Italian Spanish Turkish Thai Portuguese Latin Canadian English amp French Korean Traditional Chinese Russian French German Arabic Brazilian Japanese Dutch Greek Hebrew Hungarian Four
10. Other company products or service names may be trademarks or service marks of others
11. You can also turn off the LCD backlight by pressing Fn F2 To end screen blank mode and resume normal operation press any key Putting your computer to sleep If you will be away from your computer for only a short time put the computer to sleep When the computer is in sleep mode you can quickly wake it to resume use bypassing the startup process To put the computer to sleep do one of the following Close the display panel Press the power button Open the charms and then select Settings fel Power Sleep Note Wait until the power indicator light starts blinking indicating that the computer is in sleep mode before you move your computer Moving your computer while the hard disk is spinning can damage the hard disk causing loss of data To wake the computer do one of the following Press any key on the keyboard Note If the computer does not awaken after pressing a key on the keyboard this means that the computer has entered an enhanced power saving mode Press the power button 25 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Shutting down the computer If you are not going to use your computer for a long time shut it down To shut down your computer 1 Open the charms select Settings E 26 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Lenovo G400s G405s G400s Touch G500s G505s _G500s Touch This chapter presents the following p
12. small conductive fibers to decrease electrostatic discharges Do not use such kind of mat to protect yourself from electrical shock Find the room emergency power off EPO switch disconnecting switch or electrical outlet If an electrical accident occurs you can then operate the switch or unplug the power cord quickly Do not work alone under hazardous conditions or near the equipment that has hazardous voltages Disconnect all power before Performing a mechanical inspection Working near power supplies Removing or installing main units Before you start to work on the machine unplug the power cord If you cannot unplug it ask the customer to power off the wall box that supplies power to the machine and to lock the wall box in the off position If you need to work on a machine that has exposed electrical circuits observe the following precautions Ensure that another person familiar with the power off controls is near you Attention Another person must be there to switch off the power if necessary Use only one hand when working with powered on electrical equipment keep the other hand in your pocket or behind your back Attention An electrical shock can occur only when there is a complete circuit By observing the above rule you may prevent a current from passing through your body When using testers set the controls correctly and use the approved probe leads and accessories for that tester
13. FOTWERSUCOSZZATyZ STES ROT EEN Para evitar descargas no quite la cubierta de pl stico que rodea la parte baja de la tarjeta invertida Safety notice 7 DANGER Though the main batteries have low voltage a shorted or grounded battery can produce enough current to burn personnel or combustible materials Bien que le voltage des batteries principales soit peu lev le court circuit ou la mise la masse d une batterie peut produire suffisamment de courant pour br ler des mat riaux combustibles ou causer des br lures corporelles graves Obwohl Hauptbatterien eine niedrige Spannung haben k nnen sie doch bei Kurzschluf oder Erdung genug Strom abgeben um brennbare Materialien zu entz nden oder Verletzungen bei Personen hervorzurufen AINO TWA nia MIYA YN NPUNIN MddOAY QN Nd PION 09 PINI NDIY NINA IN NASP PIT BAIN nnsn5 IN DNI Sebbene le batterie di alimentazione siano a basso voltaggio una batteria in corto circuito o a massa pu fornire corrente sufficiente da bruciare materiali combustibili o provocare ustioni ai tecnici di manutenzione ub Ay TY DEERE C Va bled EMULE YT UA Mgr PERDEZ VU UN WASH EI O TEE E ECKE Aunque las baterfas principales tienen un voltaje bajo una bateria cortocircuitada o con contacto a tierra puede producir la corriente suficiente como para quemar material combustible o provocar quemaduras en el personal Safety information Safety notice 8
14. LINETEK LS15 H03VV F LP 38 1m Switzerland 145000597 LINETEK LS15 H03VV F LP 37 1m Brazil 145000596 LINETEK LS15 H03VV F LP26A 1m Israel 145000595 f e LINETEK LS15 H03VV F LP 41 1m UL 145000594 LINETEK LP 30B SPT 2 LS15 1m UK 145000593 LINETEK LP 61L HO3VV F LS15 1m Indian 145000592 e LINETEK PE 361 HO5VV F LS15 1m Italy 145000591 ji LINETEK LS15 H03VV F PE 336 1m Korea 145000590 e LINETEK LS15 H05VV F LP E04A 1m Australia 145000589 LINETEK LS15 H03VV F LP 23A 1m Taiwan 145000588 LINETEK LS15 VCTF LP 53 1m Japan 145000587 e LINETEK LS15 VCTF LP 54 1m Africa 145000586 e LINETEK LS15 H03VV F PE 364 1m CE 145000585 LINETEK LP 34 H03VV F LS15 1m CCC 145000568 Longwell LSG 31 RVV300 300 LS 18 1m Argentina 145000567 i e Longwell LP 24 H03VV F LS 18 1m Danmark 145000566 e Longwell LP 40 H03VV F LS 18 1m Switzerland 145000565 e Longwell LP 37 H03VV F LS 18 1m 95 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual 96 Table 12 Parts list 3 pin power cords continued Region Brazil e Longwell LP 46 H03VV F LS 18 1m Israel e Longwell LP 41 H03VV F LS 18 1m UL e Longwell LP 30B SPT 2 18AWG LS 18 1m UK Longwell LP 61L H03VV F LS 18 1m Indian Longwell LP 67 BIS LS 18 1m Italy e Longwell LP 22 H03VV F LS 18 1m Korea e Longwell LP 486 KTLHO3VV F LS 5 1m Australia e Longwell LP 23A LFC 3R LS 18 1m Taiw
15. Nordic countries Belgian Icelandic Slovenian Swiss International English Czechoslovakian Bulgarian Indian P N 25211158 25211159 25211160 25211161 25211162 25211163 25211164 25211165 25211166 25211167 25211168 25211169 25211170 25211171 25211172 25211173 25211174 25211175 25211176 25211177 25211178 25211179 25211180 25211181 25211182 25211183 25211184 25211185 25211186 25211187 25211188 25211189 25211190 25211191 25211192 25211193 25211194 25211195 25211196 25211197 25211198 25211199 CRU ID ZZZZZZZZZZZZZZZZZZZZZZZZZZZZZZZZZZZZZZZZZZ Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Table 8 Parts list Keyboard Language P N CRU ID English 25211020 N U K English 25211021 N Italian 25211022 N Spanish 25211023 N Turkish 25211024 N Thai 25211025 N Portuguese 25211026 N Latin 25211027 N Canadian English amp French 25211028 N Korean 25211029 N Traditional Chinese 25211030 N Russian 25211031 N French 25211032 N German 25211033 N Chicony Arabic 25211034 N Brazilian 25211035 N Japanese 25211036 N Dutch 25211037 N Greek 25211038 N Hebrew 25211039 N Hungarian 25211040 N Four Nordic countries 25211041 N Belgian 25211042 N Icelandic 25211043 N rey Slovenian 25211044 N Swiss 25211045 N International English 25211046 N Czechoslovakian 25211047 N Bulgarian 25211048 N Indian 25211049 N English 25211050 N U K English 25211051 N Italian 25211052 N Spanish 25211053 N T
16. a DVD ROM drive Such devices are also sold separately as options If one of these drives is installed it is certified in the U S to conform to the requirements of the Department of Health and Human Services 21 Code of Federal Regulations DHHS 21 CFR Subchapter J for Class 1 laser products Elsewhere the drive is certified to conform to the requirements of the International Electrotechnical Commission IEC 825 and CENELEC EN 60 825 for Class 1 laser products Ifa CD ROM drive a DVD ROM drive or another laser device is installed note the following CAUTION Use of controls or adjustments or performance of procedures other than those specified herein might result in hazardous radiation exposure O uso de controles ajustes ou desempenho de procedimentos diferentes daqueles aqui especificados pode resultar em perigosa exposi o radia o RATES NEAT AA WE 174 ASSP RGR Pour viter tout risque d exposition au rayon laser respectez les consignes de r glage et d utilisation des commandes ainsi que les proc dures d crites Werden Steuer und Einstellelemente anders als hier festgesetzt verwendet kann gefahrliche Laserstrahlung auftreten Az itt el rt elj r sokt l be ll t sokt l s vez rl sekt l elt rni a l zersug rz s vesz lye miatt kock zatos L utilizzo di controlli regolazioni o l esecuzione di procedure diverse da quelle specificate possono provocare l esposizione a Ucnonb30BaHue an
17. au rayon Laserstrahlung bei ge ffnetem Ger t Nicht direkt oder ber optische Instrumente in den Laserstrahl sehen und den Strahlungsbereich meiden Kinyit skor l zersug r Ne n zzen bele se szabad szemmel se optikai eszk z kkel Ker lje a sug rnyal bbal val rintkez st Aprendo l unit vengono emesse radiazioni laser Non fissare il fascio non guardarlo direttamente con strumenti ottici e evitare l esposizione diretta al fascio OrkpbiBas Geperwrecb nasepHoro usnyyeHna He cmotpute Ha nyy He pasrnagbiBaXite ero C NOMOLLIbIO ONTUYECKUX UHCTPYMEHTOB a TAKKE na6era te npamoro Bo3AelicrBus nasepHoro nyYa Ked je laserov jednotka otvoren Vyhnite sa priamemu poh adu a nehladte priamo s optick mi n strojmi do l ta a vyhnite sa priamemu vystaveniu l ov EI NEE WE LOW T 0 CARRE TE CDe C42 SV Radiaci n l ser al abrir No mire fijamente ni examine con instrumental ptico el haz de luz Evite la exposici n directa al haz 15 7 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Important service information This chapter presents the following important service information Strategy for replacing FRUs on page 16 Strategy for replacing a hard disk drive on page 17 Important notice for replacing a system board on page 17 Important information about replacing RoHS compliant FRUs on page 18 Important BIOS and device driver fixes are custom
18. chelas tal como dispone la normativa local Utilice s lo bater as que se encuentren en la lista de piezas al sustituir la bater a La utilizaci n de una bater a no apropiada puede provocar la ignici n o explosi n de la misma I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch 10 Hardware Maintenance Manual Safety notice 4 N DANGER The lithium battery can cause a fire an explosion or a severe burn Do not recharge it remove its polarized connector disassemble it heat it above 100 C 212 F incinerate it or expose its cell contents to water Dispose of the battery as required by local ordinances or regulations Use only the battery in the appropriate parts listing Use of an incorrect battery can result in ignition or explosion of the battery La pile de sauvegarde contient du lithium Elle pr sente des risques d incendie d explosion ou de br lures graves Ne la rechargez pas ne retirez pas son connecteur polaris et ne la d montez pas Ne l exposez pas une temperature sup rieure 100 C ne la faites pas br ler et n en exposez pas le contenu l eau Mettez la pile au rebut conform ment la r glementation en vigueur Une pile inappropri e risque de prendre feu ou d exploser Die Systembatterie ist eine Lithiumbatterie Sie kann sich entz nden explodieren oder schwere Verbrennungen hervorrufen Batterien dieses Typs d rfen nicht aufgeladen zerlegt ber 100 C erhitzt oder verbrann
19. do first Power system checkout Checking the AC adapter Checking operational charging SEN Checking the battery pack Related service information 23 Restoring the factory contents by using Recovery Disc Set Start Recovery Disc one disc Operating System Recovery Disc one or more ISCS israel 23 Applications and Drivers Recovery Disc one or more discs Supplemental Recovery Disc Passwords Power on password Hard disk password Supervisor password Power management Screen blank mode 25 Putting your computer to sleep 25 Shutting down the computer 26 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch 27 Specifications Status indicators adi Fn key combinations sss 32 FRU replacement notices Screw notices e Removing and replacing an FRU 34 1010 Battery pack 35 1020 Dummy card 36 1030 Hard disk drive HDD Memory Mini PCI Express Card slot compartment COVER ductos aiii da 37 1040 Hard disk drive ooocccininninncinnonccno 38 1050 Optical drive 41 1060 DIMM Esa 43 1070 PCI Express Mini Card for wireless LAN WAN 1080 Fan assembly 5 1090 Keyboard 1100 Keyboard bezel 1110 System board
20. e prestando attenzione ad eventuali rumori eventuali parti o pezzetti metallici possono provocare cortocircuiti pericolosi FRU DZMH IVE A NRZ ANDANT AU A LOMO x7 HOST CIEUVMlEIZdS 0 Era ADANE TIRA TOOT l ARL TLES INERAT LH AV ea REIT WF WF LELRO E Te RAR EE ORATI ENEU ET Antes de encender el sistema despues de sustituir una FRU compruebe que todos los tornillos muelles y dem s piezas peque as se encuentran en su sitio y no se encuentran sueltas dentro del sistema Compru belo agitando el sistema y escuchando los posibles ruidos que provocar an Las piezas met licas pueden causar cortocircuitos el ctricos I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Safety notice 2 N DANGER Some standby batteries contain a small amount of nickel and cadmium Do not disassemble a standby battery recharge it throw it into fire or water or short circuit it Dispose of the battery as required by local ordinances or regulations Use only the battery in the appropriate parts listing Use of an incorrect battery can result in ignition or explosion of the battery Certaines batteries de secours contiennent du nickel et du cadmium Ne les d montez pas ne les rechargez pas ne les exposez ni au feu ni l eau Ne les mettez pas en court circuit Pour les mettre au rebut conformez vous la r glementation en vigueur Lorsque vous remplacez la pile de sauve
21. the parts in protective packages until they are inserted into the product Avoid contact with other people Wear a grounded wrist strap against your skin to eliminate static on your body Prevent the part from touching your clothing Most clothing is insulative and retains a charge even when you are wearing a wrist strap Use the black side of a grounded work mat to provide a static free work surface The mat is especially useful when handling ESD sensitive devices Select a grounding system such as those listed below to provide protection that meets the specific service requirement Notes The use of a grounding system to guard against ESD damage is desirable but not necessary Attach the ESD ground clip to any frame ground ground braid or green wire ground When working on a double insulated or battery operated system use an ESD common ground or reference point You can use coax or connector outside shells on these systems Use the round ground prong of the ac plug on ac operated computers Grounding requirements requirements Electrical grounding of the computer is required for operator safety and correct system function Proper grounding of the electrical outlet can be verified by a certified electrician Safety information Safety notices multilingual translations The safety notices in this section are provided in English French German Hebrew Italian Japanese and Spanish 7 Safety no
22. verify the operation of any other product program or service Lenovo may have patents or pending patent applications covering subject matter described in this document The furnishing of this document does not give you any license to these patents LENOVO GROUP LTD PROVIDES THIS PUBLICATION AS IS WITHOUT WARRANTY OF ANY KIND EITHER EXPRESS OR IMPLIED INCLUDING BUT NOT LIMITED TO THE IMPLIED WARRANTIES OF NON INFRINGEMENT MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE Some jurisdictions do not allow disclaimer of express or implied warranties in certain transactions therefore this statement may not apply to you This information could include technical inaccuracies or typographical errors Changes are periodically made to the information herein these changes will be incorporated in new editions of the publication Lenovo may make improvements and or changes in the product s and or the program s described in this publication at any time without notice The products described in this document are not intended for use in implantation or other life support applications where malfunction may result in injury or death to persons The information contained in this document does not affect or change Lenovo product specifications or warranties Nothing in this document shall operate as an express or implied license or indemnity under the intellectual property rights of Lenovo or third parties All information contained in this docu
23. 00000000000000 OC JO Ol ggi VO zana JO Ol J J U OL sel 000 E E Ul 10 J J CC OC Ol 69 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual 70 1160 LCD front bezel For access remove these FRUs in order 1010 Battery pack on page 35 1020 Dummy card on page 36 1030 Hard disk drive HDD Memory Mini PCI Express Card slot compartment cover on page 37 1040 Hard disk drive on page 38 1050 Optical drive on page 41 1060 DIMM on page 43 1070 PCI Express Mini Card for wireless LAN WAN on page 44 1080 Fan assembly on page 46 1090 Keyboard on page 47 1100 Keyboard bezel on page 52 1110 System board on page 55 Figure 16 Removal steps of LCD front bezel Remove the LCD front bezel in the directi
24. 0s Touch G500s G505s G500s Touch 84 Hardware Maintenance Manual Table 5 Parts list Overall continued No 16 16 16 16 16 17 17 17 17 17 17 17 17 17 17 17 17 17 17 17 17 17 17 17 17 FRU DDR3 1600 4GB RMT3170EB68F9W 1600 4GB DDR3L 1600 DDR3 1600 4GB SM321NQ08ICF 4GB DDR3L 1600 DDR3 1600 4GB MT8KTF51264HZ 1G6J1 4GB DDR3L 1600 DDR3 1600 8GB M471B1G73BH0 YK0 8GB DDR3L 1600 DDR3 1600 8GB HMT41GS6AFR8A PB 8GB DDR3L 1600 HDD 320G 5400rpm ST320LT012 7mm 5 4K 320G HDD HDD 320G 5400rpm HTS545032A7E380 RV 7mm 5 4K 320G HDD HDD 320G 5400rpm MQ01ABF032 7mm 5 4K 320G HDD HDD 320G 5400rpm MQ01ABD032 9 5mm 5 4K 320G HDD HDD 320G 5400rpm WD3200BPVT 9 5mm 5 4K 320G HDD HDD 500G 5400rpm ST500LM012 9 5mm 5 4K 500G HDD HDD 500G 5400rpm HTS545050A7E380 RV 7mm 5 4K 500G HDD HDD 500G 5400rpm ST500LT012 7mm 5 4K 500G HDD HDD 500G 5400rpm MQ01ABF050 7mm 5 4K 500G HDD HDD 500G 5400rpm MQ01ABD050 9 5mm 5 4K 500G HDD HDD 500G 5400rpm WD5000LPVT 08G33T1 7mm 5 4K 500G HDD HDD 750G 5400rpm ST750LM022 9 5mm 5 4K 750G HDD HDD 750G 5400rpm HTS541075A9E680 9 5mm 5 4K 750G HDD HDD 750G 5400rpm MQ01ABD075 9 5mm 5 4K HDD HDD 750G 5400rpm WD7500BPVT 24HXZ 9 5mm 5 4K 750G HDD HDD 1TB 5400rpm ST1000LM024 9 5mm 5 4K 1T HDD HDD 1TB 5400rpm HTS541010A9E680 9 5mm 5 4K 1T HDD HDD 1TB 5400rpm MQ01ABD100 9 5mm 5 4K 1T hDD HDD 1TB 5
25. 3 H03VV F 0 75 3C 0011 1m US e lux 0014 SPT 2 60 C 18 3C 0016 1m China lux 0036 RVV 300 300 0 75 3C 0002 1m Indian e lux 0046 IS694 0 75 3C 0011 1m Japan lux 0018 E VCTF 0 75 3C 0021 1m Australia e lux 0038 H03VV F 0 75 3C 0011 1m Taiwan lux 0019 VCTF 0 75 3C 0021 1m Korea lux 0033 H03VV F 0 75 3C 0011 1m Italy e lux 0029 H03VV F 0 75 3C 0011 1m South Africa e lux 0044 H03VV F 0 75 3C 0011 1m Brazil lux 0034 H03VV F 0 75 3C 0011 1m Israel e lux 0041 H03VV F 0 75 3C 0011 1m Switzerland e lux 0027 H03VV F 0 75 3C 0011 1m Denmark lux 0048 H03VV F 0 75 3C 0011 1m Argentina e lux 0040 H03VV F 0 75 3C 0011 1m P N 145500000 145500001 145500002 145500003 145500004 145500005 145500006 145500007 145500008 145500009 145500010 145500011 145500012 145500013 145500014 145500015 CRU ID Notices Notices Lenovo may not offer the products services or features discussed in this document in all countries Consult your local Lenovo representative for information on the products and services currently available in your area Any reference to a Lenovo product program or service is not intended to state or imply that only that Lenovo product program or service may be used Any functionally equivalent product program or service that does not infringe any Lenovo intellectual property right may be used instead However it is the user s responsibility to evaluate and
26. 3 VILG1 Power Board W Cable G500s G500s Touch 90003100 N 4 VILG1 LED Board W Cable G500s G500s Touch 90003072 N 5 VILG2 ODD Dummy Black G400s G400s Touch 90202912 N 5 VILG1 ODD Dummy Black G500s G500s Touch 90202888 N 6 VILG2 Upper Case W TP G400s G400s Touch 90202898 N 6 VILG1 Upper Case W TP G500s G500s Touch 90202873 N 7 VILG2 USB Board W Cable G400s G400s Touch 90003133 N 7 VILG1 USB Board W Cable G500s G500s Touch 90003070 N 8 Ivy bridge core dual core 35W Intel 15 3230M 2 6G 3M 102500486 N 2cPGA processor 8 Ivy bridge core dual core 35W Intel I3 3130M 2 6G 3M 102500487 N 2cPGA processor 8 sandy bridge dual core Intel 2030M 2 5G 2M 2cPGA 102500482 N processor 8 sandy bridge dual core Intel 2020M 2 4G L12M 2cPGA 102500433 N processor 8 sandy bridge dual core Intel 1000M 1 5G 2M 2cPGA 102500483 N processor 8 Ivy bridge core dual core 35W Intel I3 3120M 2 5G L1 102500435 N 3M 2cPGA processor 8 sandy bridge dual core Intel 13 2348M 2 3G J1 3M 102500517 N 2cPGA processor 8 sandy bridge dual core Intel B980 2 4G Q0 2M 2cPGA 102500362 N OS processor 8 sandy bridge dual core Intel B960 2 20G 2M 35W SNB 102500133 N PGA processor 9 VILG1 ODD Board W Cable G500s G500s Touch 90003071 N 81 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch 82 Hardware Maintenance Manual Table 5 Parts list Overall continued No 10 11 PRP RP ba ba RP RP RP ba eB bai Re ee
27. 400rpm WD10JPVT 24A1YTO0 9 5mm 5 4K 1T HDD HDD 1T Hybrid ST1000LM014 6G 9 5mm 1T SSHD G500s FRU no 11201512 11201834 11201342 11200504 11201301 16200212 16200296 16200274 16200222 16200022 16200323 16200297 16200211 16200273 16200221 16200264 16200322 16200192 16200220 16004848 16200321 16200193 16200219 16200071 16200389 CRU ID ES EE ES ES EE EE ES ES ES ES 4 E ES EE ES ES Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Table 5 Parts list Overall continued No 17 18 18 18 18 18 19 19 20 20 20 20 20 21 21 21 21 FRU HDD 500G Hybrid ST500LM000 6G 7mm 500G SSHD G500s WLAN WiFi 1x1 BGN Cbt BCM94313HMG 1x1BGN HMC WLAN WLAN WiFi 1x1 BGN Liteon HB125 1x1BGN HMC WLAN WLAN WiFi 1x1 BGN BT4 0 Cbt BCM943142HM 1x1BGN BT4 0 HMC WLAN WLAN WiFi 1x1 BGN BT4 0 Liteon WB225 1x1BGN BT4 0 HMC WLAN WLAN Intel 135 1x1BGN BT Intel 135 1x1BGN BT PCIE HMC WLAN VILG2 Thermal Door Black G400s G400s Touch VILG1 Thermal Door Black G500s G500s Touch ODD 9 5 Rambo Tray in HLDS GU70N 9 5 Rambo ODD ODD 9 5 Rambo Tray in PLDS DU 8A5SH 9 5 Rambo ODD ODD 9 5 Rambo Tray in Panasonic UJ8C2 9 5 Rambo ODD ODD 9 5 Blueray Rambo HLDS BU10N 9 5 BD Rambo ODD ODD 9 5 Blueray Rambo Panasonic UJ262 9 5 BD Rambo ODD VILG2 ODD Bezel Bla
28. 5 Removal steps of optical drive continued 42 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch 1060 DIMM For access remove these FRUs in order 1010 Battery pack on page 35 e 1030 Hard disk drive HDD Memory Mini PCI Express Card slot compartment cover on page 37 Figure 6 Removal steps of DIMM Release the two latches on both edges of the socket at the same time in the direction shown by arrows Kl and then unplug the DIMM in the direction shown by arrow BJ Note If only one DIMM is used on the computer you are servicing the card must be installed in SLOT 0 l lower slot but not in SLOT 1 F upper slot es When installing Insert the notched end of the DIMM into the socket Push the DIMM firmly and pivot it until it snaps into the place Make sure that it is firmly fixed in the slot and difficult to be moved 43 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual 1070 PCI Express Mini Card for wireless LAN WAN For access remove these FRUs in order 1010 Battery pack on page 35 e 1030 Hard disk drive HDD Memory Mini PCI Express Card slot compartment cover on page 37 Figure 7 Removal steps of PCI Express Mini Card for wireless LAN WAN Disconnect the two wireless LAN cables Efl and then remove the screw EX In step El unplug the ja
29. 500s G505s G500s Touch 1030 Hard disk drive HDD Memory Mini PCI Express Card slot compartment cover For access remove this FRU 1010 Battery pack on page 35 Figure 3 Removal steps of HDD Memory Mini PCI Express Card slot compartment cover Loosen the screws H that secure the compartment cover Remove the compartment cover in the direction shown by arrow PJ Step Screw quantity Color Torque H M2 5 x 6mm flat head nylok coated Black 2 38 2 48 kgfcm 3 G500s M2 5 x 8 mm flat head nylok coated Black 2 38 2 45 kgfcm 2 G400s 37 7 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch 38 Hardware Maintenance Manual 1040 Hard disk drive For access remove these FRUs in order 1010 Battery pack on page 35 e 1030 Hard disk drive HDD Memory Mini PCI Express Card slot compartment cover on page 37 Attention Do not drop the hard disk drive or apply any physical shock to it The hard disk drive is sensitive to physical shock Improper handling can cause damages and permanent loss of data Before removing the drive suggest the customer to backup all the information on it if possible Never remove the drive while the system is operating or is in suspend mode 7 a Figure 4 Removal steps of hard disk drive Remove the frame fixing screws JJ Step Screw quantity Color Torque H M2 x 5 mm flat head nylok coated 4 Black 2 0 2 5 kgfcm G500s
30. DIMM on page 43 1070 PCI Express Mini Card for wireless LAN WAN on page 44 1080 Fan assembly on page 46 1090 Keyboard on page 47 1110 System board on page 55 1100 Keyboard bezel on page 52 Figure 15 Removal steps of base cover speakers USB and power assembly Loosen four screws Ell Remove the speakers in the direction shown by arrows G500s Step Screw quantity Color Torque i M 2 5 x 3 mm flat head nylok coated 4 Black 65 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Figure 15 Removal steps of base cover speakers USB and power assembly continued G400s Step Screw quantity Color Torque M2 5 x 2 mm 5 7 flat head nylok coated Black 2 38 2 48 kgfcm 4 G500s Loosen the screw A then remove the USB board in the direction shown by arrow El When installing Make sure that the USB board connector is attached firmly Step Screw quantity Color Torque E M2 5 x 3 mm flat head nylok coated 1 Black G500s M2 5 x 4 mm flat head nylok coated 1 Black 2 38 2 5 kgfcm G400s 66 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Figure 15 Removal steps of base cover speakers USB and power assembly continued G500s Remove the power assembly in the direction shown by arrow J G500s Remove two screws H and remove the optical disk drive board in the direction shown by arrow BJ Step Sc
31. IN D y DY DINA DPMON ON MNI nmi 2395 M9 mno mp 15 DOWN INNI DIVINI Drun OY MINNA Nel caso che caso l LCD si dovesse rompere ed il liquido in esso contenuto entrasse in contatto con gli occhi o le mani lavare immediatamente le parti interessate con acqua corrente per almeno 15 minuti poi consultare un medico se i sintomi dovessero permanere LCD PAL LCD OP ORAM AIA DTD FIRE Y LIA W ARDS ARAL TE BD Zeb IRA ES 15 DELL TS EU BEVEL ERIC Viet IC d o Cfi 5 ION AAA MORAN CA TES VS Sila LCD se rompe y el fluido de su interior entra en contacto con sus ojos o sus manos lave inmediatamente las reas afectadas con agua durante 15 minutos como m nimo Obtenga atenci n medica si se presenta algun Ns J 11 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch 12 Hardware Maintenance Manual Safety notice 6 DANGER To avoid shock do not remove the plastic cover that protects the lower part of the inverter card Afin d viter tout risque de choc lectrique ne retirez pas le cache en plastique prot geant la partie inf rieure de la carte d alimentation Aus Sicherheitsgr nden die Kunststoffabdeckung die den unteren Teil der Spannungswandlerplatine umgibt nicht entfernen POVINN NOIA NN VONNI N monunnn YI 72 Pann 990997 90 ANNA IPIN DN yan Per evitare scosse elettriche non rimuovere la copertura in plastica che avvolge la parte inferiore della scheda invertitore MBE CID 4 34 A
32. M2 x 5 mm flat head nylok coated 4 Black 1 89 1 89 kgfcm G400s Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Figure 4 Removal steps of hard disk drive continued Pull the tab in the direction shown by arrow EJ Take out the hard disk drive secured in a metal fr 39 40 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Figure 4 Removal steps of hard disk drive continued Remove four screws D and detach the metal frame from the hard disk drive 6 Step Screw quantity Color Torque D M3 x 3 mm flat head nylok coated 4 White 2 88 2 95 kgfcm When installing Make sure that the HDD connector is attached firmly Lenovo G400s G405s G400s Touch G500s G505s G500s Touch 1050 Optical drive For access remove these FRUs in order 1010 Battery pack on page 35 e 1030 Hard disk drive HDD Memory Mini PCI Express Card slot compartment cover on page 37 Figure 5 Removal steps of optical drive Remove the screw O insert a screw driver into the screw hole and push the optical drive in the direction shown by arrow J Pull the optical drive out in the direction shown by arrow E Step Screw quantity Color Torque H M2 5 x 3 mm flat head nylok coated Black 1 5 2 0 kgfcm 1 G500s M2 x 9 mm flat head nylok coated 1 Black G400s 41 7 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Figure
33. W8S DIS HM76 GE 2G TS G500s Touch 90003095 N 1 VILG1 MB W8S UMA HM76 TS G500s Touch 90003099 N 12 VILG1 HeatSink DIS G400s G500s G400s Touch 90202868 N G500s Touch 12 VILG1 HeatSink UMA G400s G500s G400s Touch 90202869 N G500s Touch 13 Battery 4 cell 2800mAh SY L1254E01 14 4V41Wh 4cell 121500171 ii bty 13 Battery 4 cell 2800mAh SP L L12M4E01 14 88V41Wh 121500172 4cell bty 13 Battery 4cell 2800mAh LG L12L4E01 14 8V41Wh 4cell 121500173 S bty 13 Battery 4 cell 2200mAh SY L1254A02 14 4V32Wh 4cell 121500174 b bty 13 Battery 4 cell 2200mAh SP L L12M4A02 14 4V32Wh 121500175 4 4cell bty 13 Battery 4 cell 2200mAh LG L12L4A02 14 4V32Wh 4cell 121500176 S bty 14 VILG2 Speaker L R G400s G400s Touch 90202894 N 14 VILGI Speaker G500s G500s Touch 90202870 N 15 VILG2 Lower Case Black G400s G400s Touch 90202895 N 15 VILGI Lower Case Black G500s G500s Touch 90202858 N 16 DDR3 1600 2GB M471B5773DH0 YK0 2GB DDR3L 11200502 di 1600 16 DDR3 1600 8GB SM322NWOSIAF 8GB DDR3L 1600 11201514 16 DDR3 1600 8GB MT16KTF1G64HZ 1G6E1 8GB 11201304 i DDR3L 1600 16 DDR3 1600 2GB HMT425S6AFR6A PB 2GB DDR3L 11201299 bi 1600 16 DDR3 1600 2GB RMT3170ED58F8W 1600 2GB DDR3L 11201835 1600 16 DDR3 1600 2GB MT8KTF25664HZ 1G6M1 2GB 11200346 DDR3L 1600 16 DDR3 1600 4GB M471B5273DH0 YK0 4GB DDR3L 11200503 KR 1600 16 DDR3 1600 4GB HMT451S6AFR8A PB 4GB DDR3L 11201300 1600 83 I Lenovo G400s G405s G40
34. an Longwell LP 71 VCTF LS 33 1m Japan Longwell LP 54 VCTF LS 18 1m Africa e Longwell LP 39 H03VV F LS 18 1m CE e Longwell LP 34A H03VV F LS 18 1m CCC e VOLEX GB10S3 RVV 300 500 VAC5S 1m Argentina e VOLEX VA2073 H03VV F VAC5S 1m Denmark VOLEX MP233D H03VV F VAC5S 1m Switzerland VOLEX MP232 H03VV F VAC5S 1m Brazil e VOLEX CH10S3 H03VV F VAC5S 1m Israel e VOLEX SI1653 H03VV F VAC5S 1m UL e Volex US1553 SPT 2 VAC5S 1m UK VOLEX MP5004 H03VV F VAC5S 1m Indian e VOLEX IA6A3 IS694 VAC5S 1m Italy e VOLEX IT1053 HO3VV F VAC5S 1m P N 145000564 145000563 145000562 145000561 145000560 145000559 145000558 145000557 145000556 145000555 145000554 145000553 145000538 145000528 145000534 145000524 145000527 145000526 145000537 145000605 145000536 145000535 CRU ID Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Table 12 Parts list 3 pin power cords continued Region Korea e VOLEX M2511 KETI IEC VAC5S 1m Australia VOLEX AU10S3 H03VV F VAC5S 1m Taiwan e VOLEX TW15CS3 VCTF VAC5S 1m Japan VOLEX VAC5S VCTF M755 1m CE VOLEX M2511 HO3VV F VAC5S 1m P N 145000533 145000532 145000531 145000530 145000525 CRU ID 97 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual 98 Table 13 Parts list power cords Region UK lux 0031 H03VV F 0 75 3C 0011 1m Europe e lux 003
35. ber Slow blinking amber Slow blinking white Meaning The computer is powered on The computer is in sleep mode The computer is powered off The battery has more than 20 charge The battery has between 5 and 20 charge There is a problem with the battery or the battery connection The battery is being charged When battery charge reaches 20 the blinking color changes to white The battery has between 20 and 80 charge and is still charging When the battery reaches 80 charge the light will stop blinking but charging will continue until the battery is fully charged 31 M Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Fn key combinations key combinations 32 The following table shows the function of each combination of Fn with a function key Table 4 Fn key combinations Fn Home Activate the pause function Fn End Activate the break function Fn PgUp Enable Disable the scroll lock Fn PgDn G400s Activate the insert function G405s G400s Touch Fn PgDn G500s Activate the system request G505s G500s Touch Lenovo G400s G405s G400s Touch G500s G505s G500s Touch FRU replacement notices replacement notices This section presents notices related to removing and replacing parts Read this section carefully before replacing any FRU Screw notices Loose screws can cause a reliability problem In the Lenovo computer this problem is addresse
36. cess 6 If you have a Supplemental Recovery Disc insert it when prompted and click Yes If you do not have a Supplemental Recovery Disc click No 23 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual 7 When all of the data has been copied from the last disc in the set remove the disc and restart the computer Note The remainder of the recovery process is fully automated and no action is required by you The computer will restart into the Windows desktop several times and you might experience periods when no activity is apparent on the screen for several minutes at a time This is normal 8 When the recovery process is complete the Welcome to the Microsoft Windows screen is displayed Follow the instructions on the screen to complete the Windows setup Passwords 24 As many as three passwords may be needed for any Lenovo computer the power on password POP the hard disk password HDP and the supervisor password SVP If any of these passwords has been set a prompt for it appears on the screen whenever the computer is turned on The computer does not start until the password is entered Exception If only an SVP is installed the password prompt does not appear when the operating system is booted Power on password A power on password POP protects the system from being powered on by an unauthorized person The password must be entered before an operating system can b
37. ch G500s G505s G500s Touch Hardware Maintenance Manual Figure 9 Removal steps of keyboard continued G400s Push the back of the keyboard in the direction shown by arrow PJ 50 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Figure 9 Removal steps of keyboard continued G400s Lift the keyboard a little EY and then detach the connector in the direction shown by arrows D D 51 7 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual 1100 Keyboard bezel For access remove these FRUs in order 1010 Battery pack on page 35 e 1030 Hard disk drive HDD Memory Mini PCI Express Card slot compartment cover on page 37 1040 Hard disk drive on page 38 1050 Optical drive on page 41 1070 PCI Express Mini Card for wireless LAN WAN on page 44 1080 Fan assembly on page 46 1090 Keyboard on page 47 Figure 10 Removal steps of keyboard bezel G500s Remove eight screws H and two screws EX on the bottom ET Step Screw quantity Color Torque H M2 5 x 6 mm flat head nylok coated 8 Black 2 38 2 48 kgfcm H M2 5 x 3 mm flat head nylok coated 2 Black 1 0 1 5 kgfcm 52 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Figure 10 Removal steps of keyboard continued G400s Remove six screws EX and three screws J on the bottom e M a Y Step Screw quantity Color Torque H M2 5 x 6 mm flat head n
38. ck Rambo G400s G400s Touch VILG2 ODD Bezel Black BD G400s G400s Touch VILG1 ODD Bezel Black Rambo G500s G500s Touch VILG1 ODD Bezel Black BD G500s G500s Touch FRU no 16200391 20200102 20200223 20200222 20200224 20200486 90202889 90202862 25205807 25205806 25210793 25209260 25209259 90202892 90202893 90202863 90202864 CRU ID za N Z Z Z Z Z 85 7 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual LCD FRUs In Lenovo G400s G405s G400s Touch G500s G505s G500s Touch there are following types of LCDs e 14 0 in HD TFT G400s G405s G400s Touch e 15 6 in HD TFT G500s G505s G500s Touch 1 i 86 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch 14 0 in HD TFT G400s G405s G400s Touch Table 6 Parts list 14 0 in HD TFT VILG2 LCD Module TS G400s Touch VILG2 LCD Bezel Cap L R TS G400s Touch VILG2 LCD Bezel G400s VILG2 LCD Bracket L R G400s VILG2 LCD Bracket L R TS G400s Touch are White LED 3 6mm fla type LVDS HD F AUO B140XTN03 0 9A HD G F LED1 NB LCD are White LED 3 6mm fla type LVDS HD F LGD LP140WH2 TLS1 HD G F LED1 NB LCD are White LED 3 6mm fla type LVDS HD F SDC LTN140AT28 L01 HD GF LED1 NB LCD are White LED 3 6mm fla HD F CMI N140BGE L43 HD G F LED1 are White LED 3 6mm fla type LVDS NB LCD type LVDS HD F BOE HB140WX1 300 HD G F LED1 NB LCD Pa
39. cket L R TS G500s Touch VILG1 LCD Bracket L R G500s Panel 15 0 Glare White LED 3 8mm flat type LVDS AUO B156XW04 V5 HD G F LED1 NB LCD Panel 15 0 Glare White LED 3 8mm flat type LVDS SEC LTN156AT30 L01 HD G F LED1 NB LCD Panel 15 0 Glare White LED 3 8mm flat type LVDS LGD LP156WH3 TLS1 HD G F LED1 NB LCD LCD Cable DIS TS G500s Touch LCD Cable UMA TS G500s Touch LCD Cable DIS G500s LCD Cable UMA G500s Touch LCD Cable G500s Touch Camera 0 3M G500s G500s Touch Camera 1M G500s G500s Touch Antenna G500s VILG1 Antenna TS G500s Touch No FRU 1 2 3 4 4 5 5 5 6 VILG 6 VILG 6 VILG 6 VILG 6 VILG 7 VILG 7 VILG 8 VILG 8 9 VILG 9 VILG LCD Cover Black G500s LCD Cover TS G500s Touch FRU no 90400134 90202887 90202875 90202877 90202876 18200433 18200896 18200897 90202880 90202881 90202878 90202879 90202886 90003101 90003102 90202884 90202885 90202882 90202883 CRU ID Z Z Z Z Z Z Z E Z Z Z Z Z Z Z Z Z Z Z Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Keyboard Table 8 Parts list Keyboard Language G400s Chicony Sunrex English U K English Italian Spanish Turkish Thai Portuguese Latin Canadian English amp French Korean Traditional Chinese Russian French German Arabic Brazilian Japanese Dutch Greek Hebrew Hungarian Four Nordic countries Belgian Icelandic Slovenian Swiss
40. cks by using the removal tool antenna RF connector P N 08K7159 or pick up the connectors with your fingers and gently unplug them in the direction shown by arrows Notes wireless LAN card has 2 cables in step Jj Wireless LAN card in some models may have 3 cables in step Jj Step Screw quantity Color Torque Aa M2 x 3 5 mm flat head nylok coated Black 1 0 1 5 kgfcm 1 G500s M2 x 5 mm flat head nylok coated 1 Black 1 89 1 96 kgfcm G400s Remove the card in the direction shown by arrow E O Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Figure 7 Removal steps of PCI Express Mini Card for wireless LAN WAN continued When installing e In models with a wireless LAN card that has two antenna connectors plug the black cable 1st MAIN into the jack labeled 1 and the white cable 2nd AUX into jack labeled 2 on the card e In models with a wireless LAN card that has three antenna connectors plug the black cable 1st MAIN into the jack labeled 1 the grey cable 3rd into jack labeled 3 and the white cable 2nd AUX into jack labeled 2 on the card 45 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual 1080 Fan assembly For access remove these FRUs in order 1010 Battery pack on page 35 e 1030 Hard disk drive HDD Memory Mini PCI Express Card slot compartment cover on page 37 Figure 8 Removal steps of fan assembly Remove two
41. d with special nylon coated screws that have the following characteristics They maintain tight connections They do not easily come loose even with shock or vibration They are harder to tighten Each one should be used only once Do the following when you service this machine Keep the screw kit in your tool bag Remove screws carefully for reuse Usea torque screwdriver if you have one Tighten screws as follows Plastic to plastic Turn an additional 90 after the screw head touches the surface of the plastic part more than 90 Z Cross section Logic card to plastic Turn an additional 180 after the screw head touches the surface of the logic card more than 180 JE 7777 Cross section e Torque driver If you have a torque screwdriver refer to the Torque column for each step Make sure that you use the correct screws If you have a torque screwdriver tighten all screws firmly to the torque shown in the table Never use a screw that you removed Use a new one Make sure that all screws are tightened firmly Ensure torque screwdrivers are calibrated correctly following country specifications 33 A Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Removing and replacing an FRU This section presents exploded figures with the instructions to indicate how to remove and replace the FRU Make sure to observe t
42. dio Video Ethernet on the system board PCI Express Mini Card slot WLAN WWAN Bluetooth wireless Touch pad Description 320GB 5400rpm 500GB 5400rpm 750GB 5400rpm e 1TB 5400rpm 500G 8G Hybrid HDD 1T 8G Hybrid HDD e 95mm RAMBO Blueray RAMBO e HDMI x 1 Combo audio jack x1 e RJA5 x 1 e USB 2 0 x 1 USB 3 0 x 2 2 inl card reader SD MMC N A 1 8 Stereo Headphone and Microphone combo jack e Input Jack Microphone Built in stereo speakers Built in microphone e CRT port x 1 HDMI port x 1 VGAx1 e IGLAN Wimax WIFI x 1 e SSDx1 Intel 11gn 1x1 Intel 11gn BT combo card N A combined in combo card One piece multi touch touch pad Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Table 1 Specifications continued Feature Finger Print Reader Integrated camera Battery AC adapter Pre installed operating system Description N A 640 x 480 pixels 1280 x 720 pixels 4cells 2800mAh Li Cyllinder 65W 90W Linpus lite DOS Win 8 29 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Status indicators indicators The system status indicators below show the computer status 30 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Table 2 Status indicators Symbol o Indicator status On solid white Blinking Off On solid white Solid amber Fast blinking am
43. e booted Hard disk password There are two hard disk passwords HDPs User HDP for the user Master HDP for the system administrator who can use it to get access to the hard disk drive even if the user has changed the user HDP Attention If the user HDP has been forgotten check whether a master HDP has been set If it has it can be used for access to the hard disk drive If no master HDP is available neither Lenovo nor Lenovo authorized service technicians provide any services to reset either the user or the master HDP or to recover data from the hard disk drive The hard disk drive can be replaced for a scheduled fee Supervisor password A supervisor password SVP protects the system information stored in the BIOS Setup Utility The user must enter the SVP in order to get access to the BIOS Setup Utility and change the system configuration Attention If the SVP has been forgotten and cannot be made available to the servicer there is no service procedure to reset the password The system board must be replaced for a scheduled fee Related service information Power management management Note Power management modes are not supported for APM operating system To reduce power consumption the computer has three power management modes screen blank sleep standby and hibernation Screen blank mode If the time set on the Turn off monitor timer in the operating system expires the LCD backlight turns off
44. e ground continuity for 0 1 ohm or less between the external ground pin and the frame ground b The power cord should be the type specified in the parts list c Insulation must not be frayed or worn 4 Check for cracked or bulging batteries Remove the cover 6 Check for any obvious non Lenovo alterations Use good judgment as to the safety of any non Lenovo alterations 7 Check inside the unit for any obvious unsafe conditions such as metal filings contamination water or other liquids or signs of fire or smoke damage 8 Check for worn frayed or pinched cables 9 Check that the power supply cover fasteners screws or rivets have not been removed or tampered with a M Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Handling devices that are sensitive to electrostatic discharge Any computer part containing transistors or integrated circuits ICs should be considered sensitive to electrostatic discharge ESD ESD damage can occur when there is a difference in charge between objects Protect against ESD damage by equalizing the charge so that the machine the part the work mat and the person handling the part are all at the same charge Notes 1 Use product specific ESD procedures when they exceed the requirements noted here 2 Make sure that the ESD protective devices you use have been certified ISO 9000 as fully effective When handling ESD sensitive parts Keep
45. e that both of the USB ports are attached to the holes on the base cover as shown in El Improper placement of the ports or those jacks might cause a damage 58 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch 1120 LCD unit For access remove these FRUs in order 1010 Battery pack on page 35 1020 Dummy card on page 36 e 1030 Hard disk drive HDD Memory Mini PCI Express Card slot compartment cover on page 37 1040 Hard disk drive on page 38 1050 Optical drive on page 41 1060 DIMM on page 43 1070 PCI Express Mini Card for wireless LAN WAN on page 44 1080 Fan assembly on page 46 1090 Keyboard on page 47 1100 Keyboard bezel on page 52 1110 System board on page 55 Figure 12 Removal steps of LCD unit G500s Release the antenna cables from the cable guides Remove four screws Step Screw quantity Color Torque H M25x5flat head nylok coated 4 White 2 38 2 5 kgfcm 59 7 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Figure 12 Removal steps of LCD unit continued G400s Release the antenna cables from the cable guides Remove four screws Step Screw quantity Color Torque H M2 5 x 4 mm flat head nylok coated Black 2 38 2 5 kgfem 4 When installing Route the antenna cables along the cable guides As you route the cables make sure that they are not subjected to any tension Tensi
46. eB ba ra bai eB ee FRU VILG1 FAN G400s G500s G400s Touch G500s Touch VILG2 MB DIS HM76 GE 2G G400s VILG2 MB DIS HM76 GE 1G G400s VILG2 MB DIS HM70 GE 2G G400s VILG2 MB DIS HM70 GE 1G G400s VILG2 MB UMA HM70 G400s VILG2 MB UMA HM76 G400s VILG2 MB W8P DIS HM76 GE 2G G400s VILG2 MB W8P DIS HM76 GE 1G G400s VILG2 MB W8P DIS HM70 GE 2G G400s VILG2 MB W8P DIS HM70 GE 1G G400s VILG2 MB W8P UMA HM70 G400s VILG2 MB W8P UMA HM76 G400s VILG2 MB W8S DIS HM76 GE 2G G400s VILG2 MB W8S DIS HM76 GE 1G G400s VILG2 MB W8S DIS HM70 GE 2G G400s VILG2 MB W8S DIS HM70 GE 1G G400s VILG2 MB W8S UMA HM70 G400s VILG2 MB W8S UMA HM76 G400s VILG1 MB DIS HM76 GE 2G G500s VILG1 MB DIS HM76 GE 1G G500s VILG1 MB DIS HM70 GE 2G G500s VILG1 MB DIS HM70 GE 1G G500s VILG1 MB DIS HM76 GV2 2G G500s VILG1 MB UMA HM70 G500s VILG1 MB UMA HM76 G500s VILG1 MB W8P DIS HM76 GE 2G G500s VILG1 MB W8P DIS HM76 GE 1G G500s VILG1 MB W8P DIS HM70 GE 2G G500s VILG1 MB W8P DIS HM70 GE 1G G500s VILG1 MB W8P DIS HM76 GV2 2G G500s VILG1 MB W8P UMA HM70 G500s VILG1 MB W8P UMA HM76 G500s VILG1 MB W8S DIS HM76 GE 2G G500s VILG1 MB W8S DIS HM76 GE 1G G500s VILG1 MB W8S DIS HM70 GE 2G G500s VILG1 MB W8S DIS HM70 GE 1G G500s VILG1 MB W8S DIS HM76 GV2 2G G500s VILG1 MB W8S UMA HM70 G500s VILG1 MB W8S UMA HM76 G500s VILG2 MB DIS HM76 GE 2G TS G400s Touch VILG2 MB DIS HM76 GE 1G TS G400s Touch
47. eMeHTOB HACTPO KU N BbINONHeHue Npoueayp UHEIX HEM yKa3aHO 3AeCb MOXET MPUuBECTU K ONACHOMY pagmaumoHHomy O NyyeHnto Pou itie kontr l prav alebo in ch vykonan od in ch v robcov ako je v tomto pecifikovan mohlo by ma za n sledok nebezpe enstvo vystavenia sa vy iarovaniu AGE CHAE SNE NAUISD SARRIA E EI FIRE IO AR LO BUR DER EU ET El uso de controles o ajustes o la ejecuci n de procedimientos distintos de los aqu especificados puede provocar la exposici n a radiaciones peligrosas Opening the CD ROM drive the DVD ROM drive or any other optical storage device could result in exposure to hazardous laser radiation There are no serviceable parts inside those drives Do not open 14 Safety information A CD ROM drive a DVD ROM drive or any other storage device installed may contain an embedded Class 3A or Class 3B laser diode Note the following la N DANGER Emits visible and invisible laser radiation when open Do not stare into the beam do not view directly with optical instruments and avoid direct exposure to the beam Radiac o por raio laser ao abrir Nao olhe fixo no feixe de luz nao olhe diretamente por meio de instrumentos ticos e evite exposi o direta com o feixe de luz ZER ep EN BZIITUMONE BOERS DES FE BRE BOWER rh Rayonnement laser si carter ouvert Evitez de fixer le faisceau de le regarder directement avec des instruments optiques ou de vous exposer
48. eas so that other people will not trip it over Do not wear loose clothing that can be trapped in the moving parts of the machine Make sure that your sleeves are fastened or rolled up above your elbows If your hair is long fasten it Insert the ends of your necktie or scarf inside clothing or fasten it with the nonconductive clip about 8 centimeters 3 inches from the end Do not wear jewelry chains metal frame eyeglasses or metal fasteners for your clothing Attention Metal objects are good electrical conductors Wear safety glasses when you are hammering drilling soldering cutting wire attaching springs using solvents or working in any other conditions that may be hazardous to your eyes After service reinstall all safety shields guards labels and ground wires Replace any safety device that is worn or defective Reinstall all covers correctly before returning the machine to the customer Fan louvers on the machine help to prevent the overheating of internal components Do not obstruct fan louvers or cover them with labels or stickers Safety information Electrical safety safety Observe the following rules when working on electrical equipments Important Use only approved tools and test equipments Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents Many customers have rubber floor mats near their machines that contain
49. eplacement Current or Replacement original part FRU original part FRU Non RoHS Can be Non RoHS Non RoHS Can be RoHS Must be RoHS Must be RoHS Non RoHS Can sub to RoHS RoHS Must be RoHS Note A direct substitution is a part with a different FRU part number that is automatically shipped by the distribution center at the time of the order 18 General checkout General checkout This chapter presents the following information What to do first on page 20 Power system checkout on page 21 Before you go to the checkout make sure to read the following important notes 7 Important notes Only certified trained personnel can service the computer Before replacing any FRU read the entire page on removing and replacing FRUs When you replace FRUs use new nylon coated screws Be extremely careful during such write operations as copying saving or formatting Drives in the computer that you are servicing sequence might have been altered If you select an incorrect drive data or programs might be overwritten Replace an FRU only with another FRU of the correct model When you replace an FRU make sure that the machine model and the FRU part number are correct by referring to the FRU parts list An FRU should not be replaced just because of a single unreproducible failure Single failures can occur for a variety of reasons that have nothing to do with a hardware defect such as cosmic radiation electrostatic di
50. er General safety on page 2 Electrical safety on page 3 Safety inspection guide on page 5 Handling devices that are sensitive to electrostatic discharge on page 6 Grounding requirements on page 6 Safety notices multilingual translations on page 7 Laser compliance statement on page 14 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual General safety safety Follow these rules below to ensure general safety Observe a good housekeeping in the area where the machines are put during and after the maintenance When lifting any heavy object 1 Make sure that you can stand safely without slipping 2 Distribute the weight of the object equally between your feet 3 Use a slow lifting force Never move suddenly or twist when you attempt to lift it 4 Lift it by standing or pushing up with your leg muscles this action could avoid the strain from the muscles in your back Do not attempt to lift any object that weighs more than 16 kg 35 Ib or that you think is too heavy for you Do not perform any action that causes hazards to the customer or that makes the machine unsafe Before you start the machine make sure that other service representatives and the customer are not in a hazardous position Please remove covers and other parts in a safe place away from all personnel while you are servicing the machine Keep your toolcase away from walk ar
51. er installable The BIOS and device drivers are posted on the customer support site http consumersupport lenovo com Strategy for replacing FRUs for replacing FRUs Before replacing parts Make sure that all software fixes drivers and BIOS downloads are installed before replacing any FRUs listed in this manual After a system board is replaced ensure that the latest BIOS is loaded to the system board before completing the service action To download software fixes drivers and BIOS follow the steps below 1 Go to http consumersupport lenovo com 2 Enter the serial number or select a product or use Lenovo smart downloading 3 Select the BIOS Driver Applications and download 4 Follow the directions on the screen and install the necessary software 16 Important service information Use the following strategy to prevent unnecessary expense for replacing and servicing FRUs If you are instructed to replace an FRU but the replacement does not solve the problem reinstall the original FRU before you continue Some computers have both a processor board and a system board If you are instructed to replace either of them and replacing one of them does not solve the problem reinstall that board and then replace the other one e If an adapter or a device consists of more than one FRU any of the FRUs may be the cause of the error Before replacing the adapter or device remove the FRUS one by one
52. es una bateria de litio y puede provocar incendios explosiones o quemaduras graves No la recargue ni quite el conector polarizado ni la desmonte ni caliente por encima de los 100 C 212 F ni la incinere ni exponga el contenido de sus celdas al agua Des chela tal como dispone la normativa local y Safety information 3 N Safety notice 5 If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands immediately wash the affected areas with water at least for 15 minutes Seek medical care if any symptoms caused by the fluid are present after washing Si le panneau d affichage a cristaux liquides se brise et que vous recevez dans les yeux ou sur les mains une partie du fluide rincez les abondamment pendant au moins quinze minutes Consultez un m decin si des sympt mes persistent apr s le lavage Die Leuchtstoffr hre im LCD Bildschirm enth lt Quecksilber Bei der Entsorgung die rtlichen Bestimmungen f r Sonderm ll beachten Der LCD Bildschirm besteht aus Glas und kann zerbrechen wenn er unsachgema amp behandelt wird oder der Computer auf den Boden f llt Wenn der Bildschirm besch digt ist und die darin befindliche Fl ssigkeit in Kontakt mit Haut und Augen ger t sollten die betroffenen Stellen mindestens 15 Minuten mit Wasser abgesp lt und bei Beschwerden anschlie end ein Arzt aufgesucht werden 3992 N2 TON Tinn 21m 12 LCD nmn Wan TOM ON TUAL DINI PN DYDIN DYNINN NN VW DPT
53. garde ou celle de l horloge temps r el veillez n utiliser que les mod les cit s dans la liste de pi ces d tach es ad quate Une batterie ou une pile inappropri e risque de prendre feu ou d exploser Die Bereitschaftsbatterie die sich unter dem Diskettenlaufwerk befindet kann geringe Mengen Nickel und Cadmium enthalten Sie darf nicht zerlegt wiederaufgeladen kurzgeschlossen oder Feuer oder Wasser ausgesetzt werden Bei der Entsorgung die rtlichen Bestimmungen f r Sonderm ll beachten Beim Ersetzen der Bereitschafts oder Systembatterie nur Batterien des Typs verwenden der in der Ersatzteilliste aufgef hrt ist Der Einsatz falscher Batterien kann zu Entz ndung oder Explosion f hren mop Nyaa NIN MIO nnn MID INN DINO p525 yx OMITA 9999 SW IN UNI AMIN PIN WIND ANN TOP IDIOT DN PIVI v AMN INP IN 055 V DIAM PAIN INNI mpnn n DN WINI PINA VIA WINN NINDI PI VANVAS DIY DION NI NINDI UVP V ANNA MINOR 5v MININA IN nns DIVI Alcune batterie di riserva contengono una piccola quantita di nichel e cadmio Non smontarle ricaricarle gettarle nel fuoco o nell acqua n cortocircuitarle Smaltirle secondo la normativa in vigore DPR 915 82 successive disposizioni e disposizioni locali Quando si sostituisce la batteria dell RTC real time clock o la batteria di supporto utilizzare soltanto i tipi inseriti nell appropriato Catalogo parti L impiego di una batteria non adatta potrebbe determinare l incendio o l esplosio
54. he following general rules 1 Do not attempt to service any computer unless you have been trained and certified An untrained person runs the risk of damaging parts 2 Before replacing any FRU review FRU replacement notices on page 33 3 Begin by removing any FRUs that have to be removed before the failing FRU Any of such FRUs are listed at the top of the page Remove them in the order in which they are listed 4 Follow the correct sequence in the steps to remove the FRU as given in the figures by the numbers in square callouts 5 When turning a screw to replace an FRU turn it in the direction as given by the arrow in the figure 6 When removing the FRU move it in the direction as given by the arrow in the figure 7 To put the new FRU in place reverse the removal procedures and follow any of the notes that pertain to replacement For information about connecting and arranging internal cables see Locations on page 75 8 When replacing an FRU use the correct screw as shown in the procedures DANGER Before removing any FRU turn off the computer unplug all power cords from electrical outlets remove the battery pack and then disconnect any of the interconnecting cables Attention After replacing an FRU do not turn on the computer until you have made sure that all screws springs and other small parts are in place and none are loose inside the computer Verify this by shaking the computer gently and l
55. install the charged battery pack Make sure that the battery pack supplies power when you turn on the computer Tono DE If you suspect a power problem see the appropriate one of the following power supply checkouts Checking the AC adapter on page 21 Checking operational charging on page 21 Checking the battery pack on page 22 Checking the AC adapter You are here because the computer fails only when the AC adapter is used If the power on indicator does not turn on check the power cord of the AC adapter for correct continuity and installation If the computer does not charge during operation go to Checking operational charging To check the AC adapter follow the steps below 1 Unplug the AC adapter cable from the computer 2 Measure the output voltage at the plug of the AC adapter cable See the following figure Pin Voltage V DC 1 20 2 0 Note Output voltage for the AC adapter pin No 2 may differ from the one you are servicing 3 If the voltage is not correct replace the AC adapter 4 If the voltage is acceptable do the following Replace the system board If the problem persists go to Lenovo G400s G405s G400s Touch G500s G505s G500s Touch on page 27 Note Noise from the AC adapter does not always indicate a defect Checking operational charging To check whether the battery charges properly during operation use a discharged battery pac
56. isk drive HDD Memory Mini PCI Express Card slot compartment cover on page 37 1040 Hard disk drive on page 38 1050 Optical drive on page 41 1060 DIMM on page 43 1070 PCI Express Mini Card for wireless LAN WAN on page 44 1080 Fan assembly on page 46 1090 Keyboard on page 47 1100 Keyboard bezel on page 52 1110 System board on page 55 1150 Base cover speakers USB and power assembly on page 65 1160 LCD front bezel on page 70 Figure 19 Removal steps of antenna assembly and LCD cover Peel off the adhesive tapes securing the antenna boards release the cables from the cable guide and then remove the antenna assembly in the direction shown by arrows Efl When installing Route the antenna cables along the cable guides and secure the antenna boards with adhesive tapes As you route the cables make sure that they are not subjected to any tension Tension could cause the cables to be damaged by the cable guides or a wire to be broken Lenovo G400s G405s G400s Touch G500s G505s G500s Touch ES Front view H Integrated camera BH Wireless antennas EJ Computer display Multi touch display on select models El Power button H Novo button D System status indicators Built in microphone D Touch pad E Numeric keypad G500s G505s G500s Touch G400s G405s G400s Touch a LEZ CS 75 7 Lenovo G400s G405s G400s Touch G500s G505
57. istening for rattling sounds Metallic parts or metal flakes can cause electrical short circuits Attention The system board is sensitive to and can be damaged by electrostatic discharge Before touching it establish personal grounding by touching a ground point with one hand or using an electrostatic discharge ESD strap P N 6405959 to remove potential shock reasons Note The illustrations used in this section are of the Lenovo G500s unless otherwise stated 34 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch 1010 Battery pack DANGER Only use the battery specified in the parts list for your computer Any other battery could ignite or explode Figure 1 Removal steps of battery pack Unlock the manual latch BR Slide the spring loaded latch to the unlocked position EJ to eject the battery pack Lift up the inner edge EJ of the battery pack pivoting it on the outer edge Slide the battery pack in the indicated direction to remove it When installing Install the battery pack along the slide rails of the slot Then make sure that the battery release lever is in the locked position 35 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual 1020 Dummy card For access remove this FRU 1010 Battery pack on page 35 Figure 2 Removal steps of dummy cards Remove the dummy card in the direction shown by arrows H PJ 36 Lenovo G400s G405s G400s Touch G
58. k or a battery pack that has less than 50 of the total power remaining when installed in the computer 21 M Lenovo G400s G405s G400s Touch G500s G505s G500s Touch 22 Hardware Maintenance Manual Perform operational charging If the battery status indicator or icon does not light on remove the battery pack and let it return to room temperature Reinstall the battery pack If the charge indicator or icon is still off replace the battery pack If the charge indicator still does not light on replace the system board Then reinstall the battery pack If it is still not charged go to the next section Checking the battery pack Battery charging does not start until the Power Meter shows that less than 95 of the total power remains under this condition the battery pack can charge to 100 of its capacity This protects the battery pack from being overcharged or from having a shortened life To check your battery move your cursor to the Power Meter icon in the icon tray of the Windows taskbar and wait for a moment but do not click it and the percentage of battery power remaining is displayed To get detailed information about the battery double click the Power Meter icon Note If the battery pack becomes hot it may not be able to be charged Remove it from the computer and leave it at room temperature for a while After it cools down reinstall and recharge it To check the battery pack follow the steps below 1 Turn off
59. lenovo Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Note Before using this information and the product it supports be sure to read the general information under Notices on page 99 First Edition April 2013 Copyright Lenovo 2013 All rights reserved LENOVO products data computer software and services have been developed exclusively at private expense and are sold to governmental entities as commercial items as defined by 48 C F R 2 101 with limited and restricted rights to use reproduction and disclosure LIMITED AND RESTRICTED RIGHTS NOTICE If products data computer software or services are delivered pursuant a General Services Administration GSA contract use reproduction or disclo sure is subject to restrictions set forth in Contract No GS 35F 05925 2013 Lenovo Contents About this manual Safety information General safety Electrical safety Safety inspection guide Handling devices that are sensitive to electrostatic discharge Grounding requirements Safety notices multilingual translations 7 Laser compliance statement 14 Important service information Strategy for replacing FRUs Strategy for replacing a hard disk CIEL Vene dicano a 17 board Important information about replacing RoHS compliant FRUS in 18 General checkout What to
60. ment was obtained in specific environments and is presented as an illustration The result obtained in other operating environments may vary Lenovo may use or distribute any of the information you supply in any way it believes appropriate without incurring any obligation to you Any references in this publication to non Lenovo Web sites are provided for convenience only and do not in any manner serve as an endorsement of those Web sites The materials at those Web sites are not part of the materials for this Lenovo product and use of those Web sites is at your own risk 99 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Any performance data contained herein was determined in a controlled environment Therefore the result obtained in other operating environments may vary significantly Some measurements may have been made on development level systems and there is no guarantee that these measurements will be the same on generally available systems Furthermore some measurements may have been estimated through extrapolation Actual results may vary Users of this document should verify the applicable data for their specific environment Trademarks 100 The following terms are trademarks or registered trademarks of Lenovo in the United States other countries or both Lenovo OneKey Microsoft and Windows are trademarks of Microsoft Corporation in the United States other countries or both
61. ne della batteria stessa Fio TY OMCD ROH TWEED FR VARFENTWS D ONE V ET LEBST FAST IO IH RETIRO SO RSE EY a RADO EIR UTTDRW CS EUX AY TY ABRES S pa BRROFBNTA ES CA REV HORNY VARIA YT erer LTST SW Bok Ay FY REED Ny TY BH KIEV MHBLIEVTSCERHVET Algunas baterias de reserva contienen una peque a cantidad de niquel y cadmio No las desmonte ni recargue ni las eche al fuego o al agua ni las cortocircuite Des chelas tal como dispone la normativa local Utilice s lo bater as que se encuentren en la lista de piezas La utilizaci n de una bater a no apropiada puede provocar la ignici n o explosi n de la misma Safety information Safety notice 3 DANGER The battery pack contains small amounts of nickel Do not disassemble it throw it into fire or water or short circuit it Dispose of the battery pack as required by local ordinances or regulations Use only the battery in the appropriate parts listing when replacing the battery pack Use of an incorrect battery can result in ignition or explosion of the battery La batterie contient du nickel Ne la d montez pas ne l exposez ni au feu ni l eau Ne la mettez pas en court circuit Pour la mettre au rebut conformez vous la r glementation en vigueur Lorsque vous remplacez la batterie veillez n utiliser que les mod les cit s dans la liste de pi ces d tach es ad quate En effet une batterie inappropri e risque de prendre feu ou d exploser
62. nel HD S AG LVDS 3 0t For Touch SDC 140AT27 401 HD AG S LED1 NB LCD Panel HD S AG LVDS 3 0t For Touch AUO B140XTN02 5 HW1A AG S LED1 NB LCD Panel HD S AG LVDS 3 0t For Touch CMI N140BGE LA3 HD AG S LED1 NB LCD Panel HD S AG LVDS 3 0t For Touch LGD LP140WHU TLA1 HD G S LED1 NB LCD VILG2 LCD Cable DIS G400s VILG2 LCD Cable UMA G400s VILG2 LCD Cable DIS TS G400s Touch VILG2 LCD Cable UMA TS G400s Touch VILG2 Touch LCD Cable G400s Touch VILG1 Camera 0 3M G400s G400s Touch VILG1 Camera 1M G400s G400s Touch VILG2 Antenna G400s VILG2 Antenna TS G400s Touch VILG2 LCD Cover Black G400s No FRU 1 2 3 4 4 5 Panel 14 0 G 5 Panel 14 0 G 5 Panel 14 0 G 5 Panel 14 0 G 5 Panel 14 0 G 5 5 5 5 6 6 6 6 6 7 7 8 8 9 9 VILG2 LCD Cover TS G400s Touch FRU no 90400135 90202911 90202899 90202900 90202901 18200625 18200820 18200895 18200960 18200761 18200824 18200998 18200981 18200984 90202902 90202903 90202904 90202905 90202910 90003101 90003102 90202907 90202906 90202908 90202909 CRU Z Z Z Z Z Z Z E ZZZZZZZZZZZ ID 87 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch 88 Hardware Maintenance Manual 15 6 in HD TFT G500s G505s G500s Touch Table 7 Parts list 15 6 in HD TFT VILG1 LCD Module TS G500s Touch VILG1 Hinge Cover L R TS G500s Touch VILG1 LCD Bezel G500s VILGI LCD Bra
63. on could cause the cables to be damaged by the cable guides or a wire to be broken e Make sure that the LCD connector is attached firmly and make sure that you do not pinch the antenna cables when you attach the LCD assembly Route the LCD cable along the cable guides 60 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Figure 12 Removal steps of LCD unit continued Remove the LCD unit in the direction shown by arrows EJ 61 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual 62 1130 Heat Sink assembly For access remove these FRUs in order 1010 Battery pack on page 35 1020 Dummy card on page 36 1030 Hard disk drive HDD Memory Mini PCI Express Card slot compartment cover on page 37 1040 Hard disk drive on page 38 1050 Optical drive on page 41 1060 DIMM on page 43 1070 PCI Express Mini Card for wireless LAN WAN on page 44 1080 Fan assembly on page 46 1090 Keyboard on page 47 1100 Keyboard bezel on page 52 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Figure 13 Removal steps of heat sink assembly Loosen three screws H and two screws BJ to lift the heat sink assembly Step Screw quantity Color Torque i M2 0 x 3 2 mm flat head nylok coated 3 Black 1 0 1 5 kgfcm M2 0 x 3 5 mm flat head nylok coated 2 Black 1 0 1 5 kgfcm 63 7 Lenovo G400s G405s G400s Touch G500s G505s G500s T
64. on shown by arrows Hu Lenovo G400s G405s G400s Touch G500s G505s G500s Touch 1170 LCD panel LCD cable and hinges For access remove these FRUs in order 1010 Battery pack on page 35 1020 Dummy card on page 36 e 1030 Hard disk drive HDD Memory Mini PCI Express Card slot compartment cover on page 37 1040 Hard disk drive on page 38 1050 Optical drive on page 41 1060 DIMM on page 43 1070 PCI Express Mini Card for wireless LAN WAN on page 44 1080 Fan assembly on page 46 1090 Keyboard on page 47 1100 Keyboard bezel on page 52 1110 System board on page 55 1150 Base cover speakers USB and power assembly on page 65 Figure 17 Removal steps of LCD panel LCD cable and hinges G500s Remove four screws H Lift the LCD panel in the direction shown by arrows EJ H 9 Step Screw quantity Color Torque i M2 x 3 5 mm flat head nylok coated 4 Black kgfcm 71 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch 72 Hardware Maintenance Manual Figure 17 Removal steps of LCD panel LCD cable and hinges continued G500s Remove four screws EJ and the hinges in the direction shown by arrows Step Screw quantity Color Torque Aa M2 5 x 3 mm flat head nylok coated 4 Black kgfcm Note The LCD cables are attached to the LCD panel by a metal connector Peel off the adhesive tape and detach the connector in the direction shown by ar
65. ouch Hardware Maintenance Manual 1140 CPU For access remove these FRUs in order 1010 Battery pack on page 35 1020 Dummy card on page 36 e 1030 Hard disk drive HDD Memory Mini PCI Express Card slot compartment cover on page 37 1040 Hard disk drive on page 38 1050 Optical drive on page 41 1060 DIMM on page 43 1070 PCI Express Mini Card for wireless LAN WAN on page 44 1080 Fan assembly on page 46 1090 Keyboard on page 47 1100 Keyboard bezel on page 52 1120 LCD unit on page 59 Attention CPU is extremely sensitive When you service the CPU avoid any kind of rough handling Figure 14 Removal steps of CPU Rotate the head of the screw in the direction shown by arrow H to release the lock then remove the CPU in the direction shown by arrow H When installing Place the CPU on the CPU socket in the direction shown by arrow E and then rotate the head of the screw in the direction shown by arrow 9 to secure the CPU Lenovo G400s G405s G400s Touch G500s G505s G500s Touch 1150 Base cover speakers USB and power assembly F or access remove these FRUs in order 1010 Battery pack on page 35 1020 Dummy card on page 36 1030 Hard disk drive HDD Memory Mini PCI Express Card slot compartment cover on page 37 1040 Hard disk drive on page 38 1050 Optical drive on page 41 1060
66. r warranty LCD panel cracked from the application of excessive force or from being dropped Scratched cosmetic parts Distortion deformation or discoloration of the cosmetic parts Plastic parts latches pins or connectors that have been cracked or broken by excessive force Damage caused by liquid spilled into the system Damage caused by the improper insertion of a PC Card or the installation of an incompatible card Improper disk insertion or use of an optical drive Diskette drive damage caused by pressure on the diskette drive cover foreign material in the drive or the insertion of a diskette with multiple labels Damaged or bent diskette eject button Fuses blown by attachment of a nonsupported device Forgotten computer password making the computer unusable Sticky keys caused by spilling a liquid onto the keyboard Use of an incorrect AC adapter on laptop products The following symptoms might indicate damage caused by nonwarranted activities Missing parts might be a symptom of unauthorized service or modification If the spindle of a hard disk drive becomes noisy it may have been subjected to excessive force or dropped General checkout Power system checkout system checkout To verify a symptom follow the steps below Turn off the computer Remove the battery pack Connect the AC adapter Make sure that power is supplied when you turn on the computer Turn off the computer Disconnect the AC adapter and
67. rew quantity Color Torque i M2 5 x 3 mm flat head nylok coated 2 Black 67 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Figure 15 Removal steps of base cover speakers USB and power assembly continued Remove screw i then remove LED board in the direction shown by arrow A Step Screw quantity Color Torque H M2 5 x 3 mm flat head nylok coated 1 Black 68 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Note Applying labels to the base cover The new base cover FRU is shipped with a kit containing labels of several kinds When you replace the base cover you need to apply the following label The following labels need to be peeled off from the old base cover and need to be put on the new base cover El Palm rest Label mnm Rating Label Rating label print El BT Label for US CA TW or Indonesia Label for BT or Israel Label for BT or Malaysia Label for BT B Malaysia WLAN Label Indonesia D SIDE LABEL or WLAN Label for US CA TW or WLAN Label for ISRAEL El WLAN Label for Indonesia GML Label For some models you also need to apply one or two FCC labels Check the old base cover if it has one or two FCC labels find duplicates of them in the label kit and apply them to the new base cover For the location of each label refer to the following figure G400s G500s C SSS SSS ee ee ge ge pe gere OO00000
68. roduct specific service references and product specific parts information Specifications on page 27 Status indicators on page 30 FRU tests on page 31 Fn key combinations on page 32 FRU replacement notices on page 33 Removing and replacing an FRU on page 34 Locations on page 75 Parts list on page 79 Specifications The following table lists the specifications of the Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Table 1 Specifications Feature Description Processor See the system properties of your computer you can do this as follows Click Control Panel then click Hardware and Sound click Device Manager under Devices and Printers and double click Processors Core Chipset Intel HM76 HM70 Bus architecture e 1600MHz DDR3 SDRAM PCI Express bus SMBus DMI FDI Graphic Chipset nvidia N14M GE Display 14 0 16 9 Glare White LED 3 6mm flat type LVDS Glare White LED 3 0mm ultra slim type LVDS touch support option 1366x768 pixels HD 200nit 15 6 16 9 Glare White LED 3 8mm flat type LVDS Glare White LED 3 2mm flat type LVDS for touch option 1366x768 pixels HD 200nit Standard DDR3L 1600 support DDR3 memory SODIMM x2 CMOS RAM 256 bytes 27 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Table 1 Specifications continued Feature Hard disk drive Solid state drive Optical drive 1 0 port MODEM slot Au
69. row E When installing Make sure that the metal connector is attached firmly Lenovo G400s G405s G400s Touch G500s G505s G500s Touch 1180 Integrated camera For access remove these FRUs in order 1010 Battery pack on page 35 1020 Dummy card on page 36 e 1030 Hard disk drive HDD Memory Mini PCI Express Card slot compartment cover on page 37 1040 Hard disk drive on page 38 1050 Optical drive on page 41 1060 DIMM on page 43 1070 PCI Express Mini Card for wireless LAN WAN on page 44 1080 Fan assembly on page 46 1090 Keyboard on page 47 1100 Keyboard bezel on page 52 1110 System board on page 55 1150 Base cover speakers USB and power assembly on page 65 1160 LCD front bezel on page 70 Figure 18 Removal steps of integrated camera Note The integrated camera is stuck on the top center of the LCD cover Unplug the integrated camera connector in the direction shown by arrow H Remove the integrated camera from the LCD cover FJ When installing Stick the integrated camera to the top center of the LCD cover and adjust the placement of it to make sure the connector is attached firmly 73 7 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual 74 1190 Antenna assembly and LCD cover For access remove these FRUs in order 1010 Battery pack on page 35 1020 Dummy card on page 36 1030 Hard d
70. rtant information about replacing RoHS compliant FRUs RoHS The Restriction of Hazardous Substances in Electrical and Electronic Equipment Directive 2002 95 EC is a European Union legal requirement affecting the global electronics industry RoHS requirements must be implemented on Lenovo products placed on the market after June 2006 Products on the market before June 2006 are not required to have RoHS compliant parts If the original FRU parts are non compliant replacement parts can also be non compliant In all cases if the original FRU parts are RoHS compliant the replacement part must also be RoHS compliant Note RoHS and non RoHS FRU part numbers with the same fit and function are identified with unique FRU part numbers Lenovo plans to transit to RoHS compliance well before the implementation date and expects its suppliers to be ready to support Lenovo s requirements and schedule in the EU Products sold in 2005 and 2006 will contain some RoHS compliant FRUs The following statement pertains to these products and any product Lenovo produces containing RoHS compliant FRUs RoHS compliant FRUs have unique FRU part numbers Before or after the RoHS implementation date failed RoHS compliant parts must always be replaced with RoHS compliant ones so only the FRUs identified as compliant in the system HMM or direct substitutions for those FRUs may be used Products marketed before June 2006 Products marketed after June 2006 Current or R
71. s G500s Touch Hardware Maintenance Manual G500s G505s CIS DJ ES G500s Touch CIS Ei ES 76 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Right side view H Kensington slot El Optical disc drive El USB port D Memory card slot H Combo audio jack 7 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Bottom and Left side view H AC power adapter jack EJ Ventilation slots E VGA port El 8 45 port D HDMI port 3 USB ports Battery latch manual D Battery pack E Battery latch spring loaded HI Louvers E Hard disk drive HDD Memory Mini PCI Express Card slot compartment Speakers 78 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch ESES 1 This section presents the following service parts Overall on page 80 LCD FRUs on page 86 Keyboard on page 89 Miscellaneous parts on page 93 AC adapters on page 94 Power cords on page 95 Notes Each FRU is available for all types or models unless specific types or models are specified 79 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Overall 80 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Table 5 Parts list Overall No FRU FRU no CRU ID 1 LCD unit see LCD FRUs on page 86 2 Keyboard see Keyboard on page 89 3 VILG2 Power Board W Cable G400s G400s Touch 90003134 N
72. scharge or software errors Consider replacing an FRU only when a problem recurs If you suspect that an FRU is defective clear the error logs and run the test again If the error does not recur do not replace the FRU Be careful not to replace a nondefective FRU 19 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual What to do first to do first When you do return an FRU you must include the following information in the parts exchange form or parts return form that you attach to it 20 1 9e NI m ag Pe Name and phone number of servicer Date of service Date on which the machine failed Date of purchase Procedure index and page number in which the failing FRU was detected Failing FRU name and part number Machine type model number and serial number Customer s name and address Note for warranty During the warranty period the customer may be responsible for repair costs if the computer damage was caused by misuse accident modification unsuitable physical or operating environment or improper maintenance by the customer The following is a list of some common items that are not covered under warranty and some symptoms that might indicate that the system was subjected to stress beyond normal use Before checking problems with the computer determine whether the damage is covered under the warranty by referring to the following list The following are not covered unde
73. screws H unplug the fan connector in the direction shown by arrow El When installing Make sure that the fan connector is attached firmly to the system board Step Screw quantity Color Torque i M2 x 3 5 mm flat head nylok coated 2 Black 46 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch 1090 Keyboard For access remove these FRUs in order 1010 Battery pack on page 35 e 1030 Hard disk drive HDD Memory Mini PCI Express Card slot compartment cover on page 37 1080 Fan assembly on page 46 Figure 9 Removal steps of keyboard G500s Remove screws Ell Step Screw quantity Color Torque M2 x 5 mm flat head nylok coated 3 Black 1 5 2 0 kgfcm G500s M2 x 9 mm flat head nylok coated 3 Black 1 89 1 98 kgfcm G400s 47 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Figure 9 Removal steps of keyboard continued Push the back of the keyboard in the direction shown by arrow J G500s Loosen the keyboard with fingers in the direction shown by arrow E Lift the keyboard a little D and then detach the connector in the direction shown by arrows DD 48 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Figure 9 Removal steps of keyboard continued Step Screw quantity Color Torque i M2 x 9 mm flat head nylok coated 2 Black 1 89 1 98 kgfcm G400s 49 I Lenovo G400s G405s G400s Tou
74. t werden Auch darf ihr Inhalt nicht mit Wasser in Verbindung gebracht oder der zur richtigen Polung angebrachte Verbindungsstecker entfernt werden Bei der Entsorgung die rtlichen Bestimmungen f r Sonderm ll beachten Beim Ersetzen der Batterie nur Batterien des Typs verwenden der in der Ersatzteilliste aufgef hrt ist Der Einsatz falscher Batterien kann zu Entz ndung oder Explosion f hren IN mssonnb 099799 01535 n515y ov noo JANDA DN PID WAN AMIN POT PN nup aan AMVIIAOS AMIN DINI IN ANN P4999 09 AIPA PRI DIJON NN PIWI PR PTT MIYA 100 99 n5yn VINI ASDC NN PIDI v 099 xnn 1n nx UNI IDNA g VANWAI v DY AIPA D DP DPN NINDI UY INNI DPINA nma v a NIDI In IN MD 3295 0175 5125 NINN La batteria di supporto e una batteria al litio e puo incendiarsi esplodere o procurare gravi ustioni Evitare di ricaricarla smontarne il connettore polarizzato smontarla riscaldarla ad una temperatura superiore ai 100 gradi centigradi incendiarla o gettarla in acqua Smaltirla secondo la normativa in vigore DPR 915 82 successive disposizioni e disposizioni locali L impiego di una batteria non adatta potrebbe determinare l incendio o l esplosione della batteria stessa YF OL No TY a KR BH ETICO VU Carla ET IE WET aha Ry7TI DkE COMETAS ODER BYT VAIO 100 C 212 F LLESOM A HA SERO DA IKE TL LLAT Ei Wo 77 Y ERES SRAM RARO RMN TIE ABD AY DARIA YT ERA UI RE MOR AYT YE BATSL NYT U RBBKLICV BPBLIEVTSILBHSVET La bateria de repuesto
75. ter to the original factory configuration Start Recovery Disc one disc This disc is used to format the hard disk drive and initiate the recovery process Operating System Recovery Disc one or more discs This disc restores the Microsoft Windows operating system Applications and Drivers Recovery Disc one or more discs This disc restores the pre installed applications and drivers on the computer Supplemental Recovery Disc This disc contains additional content such as software for specific models and updates to the software that was preloaded on the computer Not all recovery disc sets come with a Supplemental Recovery Disc To restore the computer to the original factory configuration using the recovery disc set do the following 1 Insert the bootable Start Recovery Disc into the optical drive 2 Start the computer When the Lenovo logo comes up immediately press F12 on the boot sequence menu select the optical drive as the first boot up device The computer will boot from the Start Recovery Disc Follow the on screen instructions to begin the recovery process 3 Read the license If you agree with the terms select I accept these terms and conditions and then click Next 4 Insert the Operating System Recovery Disc when prompted and click Yes to begin the operating system recovery process 5 Insert the Applications and Drivers Recovery Disc when prompted and then click OK to begin the applications and drivers recovery pro
76. the computer 2 Remove the battery pack and measure the voltage between battery terminals 1 and 7 See the following figure Terminal Voltage V DC 1 0 to 14 7 Ground 3 If the voltage is less than 11 0 V DC the battery pack has been discharged Note Recharging will be continued for at least 3 hours even though the indicator does not light on If the voltage is still less than 11 0 V DC after recharging replace the battery 4 Ifthe voltage is more than 11 0 V DC measure the resistance between battery terminals 5 and 7 The resistance must be 4 to 30 KQ If the resistance is not correct replace the battery pack If the resistance is correct replace the system board Related service information Related service information This chapter presents the following information Restoring the factory contents by using Recovery Disc Set on page 23 Passwords on page 24 Power management on page 25 Restoring the factory contents by using Recovery Disc Set When the hard disk drive or solid state drive is replaced because of a failure no product recovery program is on the new drive In this case you must use the Recovery Disc Set for the computer Order the Recovery Disc Set and the drive at the same time so that you can recover the new drive with the pre installed software when they arrive The Recovery Disc Set consists of the following set of DVDs to restore the compu
77. tice 1 Before the computer is powered on after FRU replacement make sure all screws springs and other small parts are in place and are not left loose inside the computer Verify this by shaking the computer and listening for rattling sounds Metallic parts or metal flakes can cause electrical shorts Avant de remettre l ordinateur sous tension apr s remplacement d une unit P P en client le v rifiez que tous les ressorts vis et autres pi ces sont bien en place et bien fix es Pour ce faire secouez l unit et assurez vous qu aucun bruit suspect ne se produit Des pi ces m talliques ou des copeaux de m tal pourraient causer un court circuit Bevor nach einem FRU Austausch der Computer wieder angeschlossen wird muf sichergestellt werden daf keine Schrauben Federn oder andere Kleinteile fehlen oder im Geh use vergessen wurden Der Computer mu gesch ttelt und auf Klapperger usche gepr ft werden Metallteile oder splitter k nnen Kurzschl sse erzeugen NTN W FRU NINN INNI awnyan NIYIN NI DNS DANN DIOP DPIN O vsgn 0n 55V NT T2 AYNA TINI MI BYW9IN DYN DNPH pup MDP 199 YPN AUNAN NN 20205 W nt DIN 091899 ON DDI NINN aav IN OPIN Prima di accendere l elaboratore dopo che stata effettuata la sostituzione di una FRU accertarsi che tutte le viti le molle e tutte le altri parti di piccole dimensioni siano nella corretta posizione e non siano sparse all interno dell elaboratore Verificare ci scuotendo l elaboratore
78. to see if the symptoms change Replace only the FRU that changed the symptoms Attention The setup configuration on the computer you are servicing may have been customized Running Automatic Configuration may alter the settings Note the current configuration settings using the View Configuration option then when service has been completed verify that those settings remain in effect Strategy for replacing a hard disk drive Always try to run a low level format before replacing a hard disk drive This will cause all customer data on the hard disk to be lost Make sure that the customer has a current backup of the data before performing this action Attention The drive startup sequence in the computer you are servicing may have been changed Be extremely careful during write operations such as copying saving or formatting If you select an incorrect drive data or programs can be overwritten Important notice for replacing a system board Some components mounted on a system board are very sensitive Improper handling can cause damage to those components and may cause a system malfunction Attention When handling a system board Do not drop the system board or apply any excessive force to it Avoid rough handling of any kind Avoid bending the system board and hard pushing to prevent cracking at each BGA Ball Grid Array chipset 17 M Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Impo
79. urkish 25211054 N Thai 25211055 N Portuguese 25211056 N Latin 25211057 N Sinto Canadian English amp French 25211058 N Korean 25211059 N Traditional Chinese 25211060 N Russian 25211061 N French 25211062 N German 25211063 N Arabic 25211064 N Brazilian 25211065 N Japanese 25211066 N Dutch 25211067 N 91 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Table 8 Parts list Keyboard Language P N CRU ID Greek 25211068 N Hebrew 25211069 N Hungarian 25211070 N Four Nordic countries 25211071 N Belgian 25211072 N Sunrex Icelandic 25211073 N continued Slovenian 25211074 N Swiss 25211075 N International English 25211076 N Czechoslovakian 25211077 N Bulgarian 25211078 N Indian 25211079 N English 25211080 N U K English 25211081 N Italian 25211082 N Spanish 25211083 N Turkish 25211084 N Thai 25211085 N Portuguese 25211086 N Latin 25211087 N 500s Canadian English amp French 25211088 N Korean 25211089 N Traditional Chinese 25211090 N Russian 25211091 N French 25211092 N German 25211093 N Darfon Arabic 25211094 N Brazilian 25211095 N Japanese 25211096 N Dutch 25211097 N Greek 25211098 N Hebrew 25211099 N Hungarian 25211100 N Four Nordic countries 25211101 N Belgian 25211102 N Icelandic 25211103 N Slovenian 25211104 N Swiss 25211105 N International English 25211106 N Czechoslovakian 25211107 N Bulgarian 25211108 N Indian 25211109 N 92 Leno
80. vo G400s G405s G400s Touch G500s G505s G500s Touch Miscellaneous parts Table 9 Parts list Miscellaneous parts FRU P N CRU ID System miscellaneous parts N e a VILG1 HDD Bracket G400s G500s G400s Touch 90202866 G500s Touch b VILG1 ODD Bracket G500s G500s Touch 90202865 c VILG2 Rubber Foot Black G400s G400s Touch 90202890 e c VILG1 Rubber Foot Black G500s G500s Touch 90202860 Cable miscellaneous parts N d VILG2 TP Cable G400s G400s Touch 90202897 d VILG1 TP Cable G500s G500s Touch 90202874 e VILG1 DC IN Cable DIS G400s G500s G400s 90202871 Touch G500s Touch e e VILG1 DC IN Cable UMA G400s G500s G400s 90202872 Touch G500s Touch Note Italicized letters in parentheses are references to the exploded view in Overall on page 71 93 I Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual 94 AC adapters Table 10 Parts list 3 pin AC adapters FRU 65W Delta ADLX65NDC3A 20V3 25A adapter 65W Liteon ADLX65NLC3A 20V3 25A adapter 65W Chicony ADLX65NCC3A 20V3 25A adapter 90W Delta ADLX90NDC3A 20V4 5A adapter 90W Liteon ADLX90NLC3A 20V4 5A adapter 90W Chicony ADLX90NCC3A 20V4 5A adapter Screws Table 11 Parts list screws FRU VILG1 SCREW JAT10_THML_SPRING_ASSY G400s G500s G400s Touch G500s Touch VILG1 SCREW 2 48D 6 0L K 5 5D 0 8T ZKNL G400s G500s G400s Touch G500s Touch VILG1 SCREW 2D 2L K 4 6D ZK NL CR3 G400s G500s
81. ylok coated 6 Black 2 38 2 5 kgfcm H M2 x 3 mm flat head nylok coated 3 Black 1 0 1 5 kgfcm G500s Detach the power board connector and touch pad cable in the direction shown by arrow E When installing Make sure that the power board connector and touch pad cable are attached firmly 53 7 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch Hardware Maintenance Manual Figure 10 Removal steps of keyboard bezel continued Remove the keyboard bezel in the direction shown by arrow Ej 54 Lenovo G400s G405s G400s Touch G500s G505s G500s Touch 1110 System board Important notices for handling the system board When handling the system board bear the following in mind Be careful not to drop the system board on a bench top that has a hard surface such as metal wood or composite Avoid rough handling of any kind In the whole process make sure not to drop or stack the system board If you put a system board down make sure to put it only on a padded surface such as an ESD mat or conductive corrugated material M Bi For access remove these FRUs in order 1010 Battery pack on page 35 1020 Dummy card on page 36 1030 Hard disk drive HDD Memory Mini PCI Express Card slot compartment cover on page 37 1040 Hard disk drive on page 38 1050 Optical drive on page 41 1060 DIMM on page 43 1070 PCI Express Mini Card for wireless LAN WAN

Lenovo IdeaPad G505S

Contents

Download Pdf Manuals

Related Search

Related Contents