Home

Supra Manual 2003

1. NOTICE If accessories fail to operate press the circuit breaker Blower Switch The blower switch activates the blower motor The primary function of the blower fan is to remove any fumes from the bilge area The blower also draws fresh air into the engine compartment Never depend solely on the blower to eliminate dangerous fumes Before starting the engine always open the motor box to check if fumes are present Switch on the blower fan a minimum of four minutes before starting the engine NOTICE If the blower fails to operate reset the circuit breaker If the blower still does not operate notify your Supra dealer N DANGER Failure to operate the blower in accordance with the Coast Guard Recommendation could result in an explosion EX SUPRA Ignition Switch Horn Switch Located on the port side of the dashboard the ignition switch has three positions In the vertical position the ignition is OFF With the key in turn the ignition switch one notch to the right to check all electrical equipment including blower pump and lights Turn the ignition all the way to the right to operate the starter NOTE All electrical equipment should be turned off when the boat is in storage Tilt Steering Tilt steering may be adjusted up or down in five different locking positions To adjust depress the tilt lever located beneath the bezel and move the steering wheel to the desired position Release the lever t
2. It may result in fire or explosion It is the owner s responsibility to check tightness of the Rad A Cage Tower bolts BEFORE each use The Rad A Cage Tower is designed to pull a single 1 individual DO NOT climb or sit on the Rad A Cage Tower Rope may loop on inverted tricks DO NOT sit behind the pulling point of the Rad A Cage Tower DANGER To avoid serious personal injury DO NOT be on or about the swim platform while engine is running and keep away from rear of boat while engine is running To avoid serious personal injury DO NOT operate engine while anyone is on or about the swim platform or in the water near the boat 2002 Skier s Choice Inc General Safety Precautions continued Skiing Safety CAUTION Skiers are obligated to be as aware of the fundamental safety rules as well as the boat operator If you are new to water skiing seek certified training before starting You will find it especially helpful to join a local ski club USA Waterski or similar organization when possible The tow bar is not designed for vertical extensions Any modifications to the tow bar or its mountings may result in damage to the boat and injury to the user Always remember that the majority of water skiing injuries are the result of impacts with other objects so always look where you are going and be aware of what is going on around Rear storage area is located above the gas tank and is not designed for ballast Weig
3. You should keep the other vessel on your port left side This rule doesn t apply if both of you can clear each other by continuing your set course and speed MD lt c gt EA SUPRA When two power driven vessels are crossing each other s path close enough to run the risk of collision the vessel that views the crossing vessel to the starboard right side must give way If the other vessel is to the port left side maintain your course and direction provided the other vessel gives you the right of way as it should If you are passing another vessel you are the give way vessel This means that the other vessel is expected to maintain its course and speed You must stay out of its way as you clear it altering course and speed as necessary Conversely if you are being passed by another vessel you should maintain your speed and direction so that the other vessel can steer itself around you Dern 7 There are three other rules to always remember when driving your boat around other vessels When navigating in narrow channels you should keep to the right when it is safe and practical to do so If the operator of a power driven vessel is preparing to go around a bend that may obstruct the view of other water vessels the operator should sound a prolonged blast on the whistle or horn four to six seconds If another vessel is around the bend it too should sound the whistle or horn Even if no re
4. from flowing into the cockpit area Optional Tonneau Cover The optional tonneau cover is designed to snap over the bow of the boat Its purpose is to minimize air flow into the cockpit area when the boat is in use and as a storage cover when used in combination with the optional cockpit cover CAUTION DO NOT trailer the boat with the tonneau cover installed The tonneau cover is not designed as a trailer cover and may come unsnapped or rip This type of damage IS NOT covered by your boat warranty Optional Cockpit Cover The optional cockpit cover is a snap down storage cover designed to help protect the interior of your boat To install the cover start at the windshield and work towards the transom Be sure to install the cover poles to prevent water pocketing CAUTION DO NOT trailer the boat with the cockpit cover installed The cockpit cover is not designed as a trailer cover and may come unsnapped or rip This type of damage IS NOT covered by your boat warranty 2002 Skier s Choice Inc Optional Stereo Amp The stereo amplifier is an optional piece of stereo equipment that is designed to increase the wattage of the signal going to the speakers while minimizing distortion of this signal Please see stereo amplifier owner s manual for more information CAUTION Using a stereo amplifier without boat engine running may drain the battery to the point where the boat will not restart This condition may ha
5. including other boats piers rafts mooring and navigational buoys pilings abutments or any other items Always have an experienced driver and observer in the boat when skiing Never ski in shallow water close to shore or in water where you do not know the depth or what is beneath the surface Never put your arm head or any other part of your body through the handle bridle of the ski line nor wrap the line around any part of the body at any time Never ski at night or directly in front of other boats Never jump from a boat that is moving at any speed nor enter or exit the water when the engine 1 running ON Make sure that everyone knows and uses approved skiing hand signals and common skiing courtesy Ski Pylon Extensions The use of a ski pylon extension or extensions in excess of 7 feet vertical is not recommended by Supra on our products If you elect to use merchandise such as these be aware that they could create excessive stress on your boat and subjectively cause damages not covered by the warranty EA SUPRA Warning Plates and Labels Read and note ALL warning plates and labels from bow to stern that appear on the boat including these Labels apply to Sunsport Inboard Launch SL amp Launch SS only REAR STORAGE AREA NOT DESIGNED FOR BALLAST WEIGHT LIMIT FOR REAR STORAGE AREA 150 LBS EQUALLY DISTRIBUTED Labels apply to all models BOATMAN S CHECK LIST DANGER AVOID SERIOUS INJUR
6. 8 Weight Boat Only 3 450 Ibs Weight Boat amp Trailer 4 705 lbs Capacity Passenger 13 Capacity Weight 1 775 lbs Capacity Weight 1 500 Ibs Capacity Fuel 37 gals Capacity Fuel 34 gals Engine 320 HP V 8 Engine 320 HP V 8 GA 2002 Skier s Choice Inc 15 SUPRA Launch SSV Ai Flers Bare ar Paper d Vit Lied ma frs be sail P i arri ird ile slg T ies S Curs M TE yr Le CD Mayer A 1 Depi Finder EX j aire Cocker Urchar R Tee Carr Sl TE kn Na 1 ME 4 ed CERT Ving rur pall Ala mvp Auten O indrsar 722 KP VEEngkba 7 big Penal Ehra Linder The Barrissabig j Fiburplase Boat Specifications Overall Length w o Platform Overall Length w Platform Overall Length w Trailer Width Beam Draft 21 8 23 10 25 8 95 24 3 250 lbs 4 350 Ibs 11 1 500 lbs 40 gals 320 HP V 8 Weight Boat Only Weight Boat amp Trailer Capacity Passenger Capacity Weight Capacity Fuel Engine EA SUPRA 16 2002 Skier s Choice Inc Break In Period Taking care to properly break in your new engine will pay off in the long run In our years of field testing we have proven that an Indmar engine when properly broken in according to our simple procedures will last longer run bett
7. dealer for its first oil and filter change as well as an engine checkup Remember to keep a sharp eye on all gauges and warning lights during these first hours of operation Report anything unusual to your dealer After the break in procedure is over your boat may be operated continuously at any speed N CAUTION Do not exceed maximum RPM recommended for your engine Exceeding the maximum RPM may result in damage to the engine N CAUTION Before starting your engine you must open the engine box and check engine compartment and bilge for gasoline and oil vapors 2002 Skier s Choice Inc Section V Operating Infomation Starting amp Operation A standard pre starting procedure should be always be followed before the first start up of the day 1 Check the engine oil level 2 Check for gasoline fumes in bilge or engine compartment 3 Operate engine blower for 4 minutes to remove any fumes 4 Check manual operation of bilge pump Make sure bilge areas are empty Other items might also be inspected depending on the boat and its use It is advisable to formulate a check list particular to the equipment and operation of your boat REFER TO THE BOATMAN S CHECKLIST OF THIS MANUAL Consult the local Coast Guard Auxiliary or Power Squadron for full details on boating safety NOTE Add on electrical accessories should never be connected to the ignition terminal or ignition circuit IMPORTANT DO NOT continue to
8. mineral oil should be applied Oil should be applied 3 to 4 times per year If teak has been allowed to become gray and dry sand with fine grit paper and reapply teak oil N CAUTION Damage caused by improper care cleaning agents conditioner oils waxes gasoline etc IS NOT covered under your boat s warranty Use only the recommended vinyl cleaner as listed on the Vinyl Care Instruction Sheet Please refer to www marinespecialtiesgroup com for more information regarding vinyl care 2002 Skier s Choice Inc Section XI Winterization amp Dry Storage When the boating and ski season comes to a close it is important to have your boat professionally winterized If your boat is exposed to temperatures below 32 degrees 0 degrees C it is possible for water in the engine ballast system heater core etc to freeze As this water freezes it expands and can crack pumps valves heat exchangers engine blocks etc This type of damage usually requires the replacement of the cracked item and can be very expensive to repair CAUTION It is extremely important to follow the proper winterizing procedure The engine must be correctly winterized for safe storage in your climate This should be done by a professional Your Moomba dealer will know exactly what must be done to ensure the longest possible life for your boat In addition to having your boat professionally winterized the following tasks should be done to
9. obligation with respect to the following 1 Defects in or damage caused by or relating to the engine or any part thereof Note The engine may be covered by warranty of the engine manufacturer Please see engine manufacturer warranty for details 2 Defects in or damage caused by or relating to the trailer or any part thereof Note The trailer may be covered by warranty of the trailer manufacturer Please see trailer manufacturer warranty for details 3 Covered Components of a boat that has been sold or transferred by the First Owner unless this Warranty is properly transferred through a Supra Dealer to the subsequent purchaser s within two years of the Original Purchase Date 4 Damage caused by related to or resulting from failure of components or parts which are not manufactured by Skier s Choice including but not limited to bilge pump failure 5 The Limited Lifetime Warranty on the deck hull floor excluding carpet and stringers does not include hardware or other components fastened or adhered to the hull deck floor or stringers 6 Normal maintenance and upkeep relating to the boat or any part thereof including but not limited to alignment adjustments connectors tune ups and wear items such EA SUPRA as shaft packing belts hoses filters seals gaskets strut bushing etc Damage to or malfunction of a boat or any component thereof resulting from owner use lack of maintenance improper maint
10. operate the starter for more than 30 seconds at a time without pausing to allow the starter motor to cool down for at least 2 minutes This will also allow the battery to recover between starting attempts PLEASE REFER TO ENGINE OWNER S MANUAL FOR ADDITIONAL DETAILS BEFORE STARTING ENGINE BE SURE THAT THE SHIFT SELECTOR IS IN NEUTRAL The correct starting procedure depends upon the type of engine Please refer to the engine manual before starting EX SUPRA Canvas Cover Your Supra boat cover is made from the finest canvas and webbing to insure that your boat will be protected in the off season The cover has been designed to fit securely around each boat If you new cover does not seem to be snug a shrinkage allowance has been sized in Use the following procedure when covering the boat 1 Be sure that the cover fits snugly at the bow then unfold from front to back 2 Be sure to install cover pole s and adjust to proper height using set screw on pole s This will keep water from gathering in the center which can damage the cover 3 Secure all fastening straps around the trailer frame 4 Pull the draw cord equally from both sides and tie off to the lifting eyes on the stern in accordance with the illustration Folding Cover When folding the cover for storage be sure the cover is dry Take care not to scratch the canvas finish against rough surfaces Store in a dry location Cover Repair If the cover becomes damage
11. organizations that offer safety training or information American Red Cross National HQ 17th amp D Streets NW Washington DC 20006 202 639 3686 www redcross org USA Waterski 799 Overlook Drive Winter Haven FL 33884 941 324 4341 www usawaterski org Boat Owners Association of the United States BOAT US 880 South Pickett Street Alexandria VA 22304 703 823 9550 www boatus com National Safe Boating Council 2550 M Street NW Suite 425 Washington DC 20037 202 296 4588 www safeboatingcouncil org U S Coast Guard Auxiliary Commandant G NAB 2100 Second Street SW Washington DC 20593 0001 800 336 2628 WWW Cgaux org U S Power Squadron www usps org On Line Basic Boating Safety Course available at www boatsafe com Federal law requires certain safety equipment to be on board at all times In addition responsible boaters carry other equipment in case of emergency Check with the local boating authorities for any additional requirements over and above the federal stipulations EA SUPRA Safety Equipment Your Supra has been equipped at the factory with most of the federally required safety equipment for inland waters Class 1 16 to 26 This equipment includes UL approved Marine Fire Extinguisher Type A BC 2 16 good for solids liquids and electrical fire ABYC approved Marine Mufflers with water injection USCG approved Marine Flame Arrestor USCG approved Engine Box Ve
12. permanent discoloration if used Household detergents containing ammonia or chlorine should not be used on gelcoat Never use acetone or ketone solvents to clean your boat finish Washing Your Boat Section X Cleaning Care amp Storage Rub Rail Care Use a sponge or other soft material to wash and wax the rub rail To wax use a commercial automotive bumper wax NOTICE When tying up to a dock or another boat always use cushioned fenders dock bumpers to protect your boat from hard surfaces Windshield Care The easiest way to preserve the beauty of your boat is to keep it clean by frequent washing Wash the boat with luke warm or cold water Wipe the boat down immediately after washing to avoid water spots Avoid using hot water or washing your boat in direct sunlight Avoid using strong soaps or chemical detergents To avoid spotting all cleaning agents should be thoroughly rinsed from the surface promptly and not allowed to dry on the finish 2002 Skier s Choice Inc All Supra windshields are constructed of tempered safety glass to ensure passenger safety The glass surfaces should be cleaned regularly to ensure that visibility is not obstructed Use a commercial glass cleaner to remove any spotting or stubborn stains that develop on the windshield Never use abrasive cleaners on glass surfaces EX SUPRA Upholstery Care All upholstery items on your Supra are made of tough marine grade vin
13. release rubber hold downs and stainless steel brackets for easy removal N WARNING Never open the Motor Box while the boat is moving CAUTION Some Supra models DO NOT have mechanical devices to hold the motor box cover in the open position Please use caution to prevent accidental closing V Drive Engine Compartment To access the engine compartment turn latch and pull to raise the center sun deck lid When the ski lockers and engine compartment lids are closed the upholstered lids double as a cushioned sun deck 2002 Skier s Choice Inc Fire Extinguisher A standard United States Coast Guard approved fire extinguisher is provided with your Supra boat The fire extinguisher is located under the observer s seat cushion NOTICE Refer to the instructions on the fire extinguisher for proper use Flame Precautions V Drive Ski Pylon The ski pylon is to be used to pull skiers DO NOT use ski pylon to hoist boat Only use the lifting rings for this purpose N WARNING DO NOT mount any Pylon Extension on the rear pylon located at the rear sundeck Inboard Ski Pylon N WARNING Sparks while fueling can cause explosion Extreme caution should be taken when an open flame is present on board Fumes from the engine and fumes from the battery are highly flammable No flame or spark should come near these areas 2002 Skier s Choice Inc The ski pylon is located in the center portion of th
14. tank at a slow rate to avoid any spillage Fuel Cap amp Key The fuel cap is located on the rear deck near the stern A special fuel key is provided to open the cap NOTE The cap is sealed by a rubber O ring Please do not over tighten 2002 Skier s Choice Inc Section VIl Instrument Panel amp Controls Speed Calibration Speed may be checked using a stopwatch and a standard slalom course Adjust the speedometer needle by turning the adjuster buttons Location of the adjuster buttons vary on location On some models they can be found on the dash while on other models they can be found to the left of the hour meter gauge on the inside of the panel as shown below Slalom Course Speeds MPH Seconds Allowable or 1 2 MPH Times Secs 32 19 32 0 32 6 28 97 28 0 28 6 19 31 19 0 19 6 18 11 17 9 18 3 16 95 16 8 17 2 16 08 19 9 16 3 Times are from start gate to end gate GA 2002 Skier s Choice Inc 23 UPR Speedometer Engine Hours The speedometer indicates the water speed of the boat in miles per hour It is recommended that the soeedometer be checked for accuracy periodically Tachometer Engine Hours are shown on the gauge located to the right of the dash panel The engine hour gauge acts as an odometer for the engine Engine hours should always be noted and documented so that required maintenance and lubricant changes may be performed at the proper i
15. the Tank NOTICE Pay careful attention when filling the fuel tank DO NOT overfill the tank Fuel may empty through the fuel vent and damage the outside finish If fuel is spilled on stripes or decals apply a common bath cleaner and wipe with a damp cloth Rinse spill area with clean water V Drive Fuel Tank The fuel cap is located in the middle of the rear of the boat A specially designed fuel key is provided to open the cap NOTE The cap is sealed by a rubber o ring Please do not overtighten The fuel cap is located on the starboard side of the boat near the stern A specially designed fuel key is provided to open the cap NOTE The cap is sealed by a rubber o ring Please do not overtighten Fuel Vent The fuel vent is a part of the gas filler neck This vent is connected to the fuel tank via the vent hose which releases gasoline fumes from the fuel tank N CAUTION Gasoline vapors are highly explosive SUPRA 46 2002 Skier s Choice Inc Section IX Service amp Maintenance Sier Eyman Inboard Model Slower ER Pum Tank Ski Pyinn Bdge Arcee Mii F rizn Pump ir urat V Drive Model Service amp Maintenance For your convenience a maintenance schedule has been included in this manual The items listed outline when to perform safety checks lubrication and general service to your boat Engine hours or elapsed time determine when service is necessary It is recommen
16. the left and then carefully raise the light to a vertical postion Re tighten the knob Always lower the light after use and before trailering to avoid hitting low overhangs 2002 Skier s Choice Inc Courtesy Lights Courtesy lights are installed at several locations in the interior of the boat The courtesy light switch is located on the instrument panel and is marked CTSY Bow Light The bow light is located on the bow of the deck at the front of the boat To alert other boaters to your position and direction The light is green on the starboard side and red on the port side Stern Light The stern light is located at the center of the transom below the rub rail This white light alerts other boaters when they are approaching your boat from behind EX SUPRA Lifting Rings The forward bow eye is located just aft of the bow light Two lifting rings are located on the transom The bow eye is located at the front of the hull below the rub rail It is the point of the attachment to lead the boat onto the trailer and to secure the boat to the trailer or to tie off when docking CN SUPRA Ski Platform The transom mounted ski platform allows easy access to and from the water for skiers and swimmers lt is recommended that entries to and exits from the water be made from the platform to avoid accidents The fiberglass deck can become slippery when wet DANGER Shut off the engine
17. when people are on the platform or in the water near the platform DANGER Exhaust fumes contain carbon monoxide Direct or prolonged exposure to carbon monoxide will cause brain damage or death NOTICE Do not use the bow eye ONLY to hoist the boat 977 You must use a Sling with the bow eye when hoisting the boat See Hoisting Instructions 2002 Skier s Choice Inc Detachable Bracket The ski platform is attached to the boat with detachable brackets The platform may be removed from the boat pulling the retaining pins from the brackets and lifting up and out Ski Locker Ski storage depending on the model of Supra you own is located either between the observer s seat and driver s console on most v drives or can be found under the sun deck of inboard models On storage found between the driver and oberserver s console simply unsnap the strap and lift to open Models with ski storage at the rear of the boat can be accessed by grasping the strap and pulling up and forward 2002 Skier s Choice Inc Bilge Inspection Plate The fuel tank inspection plate bilge inspection plate is located on the floor Open the inspection plate by unscrewing it to check the condition of the fuel tank and wire harness or for water in the bilge NOTICE Keep this area clean and free of dirt and debris ERX SUPRA Sundeck Wake Plate When the ski locker is closed the upholstered lid doubles as a cushio
18. 0 motor oil NOTE Only a trained and qualified technician should perform the oil change on your V drive unit Change Frequency The oil should be changed in the V drive transmission after the first 100 hours of operation then each year at the end of your boating season Maintaining Fluid Level Transmission fluid level should be checked regularly and fluid added if necessary Maintain fluid levels as follows Boat must be at rest Engine should be at operating temperature but turned off while checking level Remove transmisson fluid dipstick Wipe fluid clean from dipstick and replace Remove dipstick and note level indicated by the upper and lower marks If required add fluid to bring the level to the upper mark 2002 Skier s Choice Inc Shaft Log Packing Nut Shaft Log Packing Nut Jam Nut The Shaft Log Packing Nut should be checked periodically and adjusted if needed Adjust as follows Loosen the jam nut a few turns Tighten the shaft log packing nut by hand DO NOT over tighten Tighten the jam nut against the packing nut Check for leaks NOTICE It is normal for the Packing Log to drip water at a slow rate of one drop every 15 to 30 seconds Battery Cable Installation amp Precautions Your Supra electrical system is a negative ground type The negative battery cable is grounded to the engine block The positive battery cable is connecte
19. 00 lbs 40 gals 320 HP V 8 2002 Skier s Choice Inc Launch Paap ADEST Arg Geter jm elie Vrarrar s Traps E _ Baath Suh inan hie up cD Pape i ais Tl Depth i Curr Driant Ian HP Eipre Agd 4 Cage C UET Core Fa Mara T Rar Varese ai Far 2 Bed Es Cie iD gs C arpur Rinmi Frari Lie leni amp Dabasi Pha Lora Huge Maer Tri rahe ZpreMzh Launch SS Prae tela Desbr Care Panty zl Kuna hiures Tara of ir Cubilia Boandag litre inimar 122 EP bris Ciumizmi C berais 4 ar Ca SLs or Ania Fm Lass Les ben A Lilebres Liiu led Miiri ig PLA pr i Dash ith mgri Fia inpr Canis Th teer g Sel Beg For 2 Fae Freel Meer Dalani Hoge Bij Dena irr The Boat Specifications Overall Length w o Platform 20 11 Overall Length w Platform 22 7 Overall Length w Platform 23 10 Overall Length w Trailer 24 9 Overall Length w Trailer 25 8 Width Beam 98 Width Beam 95 Draft 24 Draft 22 Weight Boat Only 3 050 Ibs Weight Boat amp Trailer 4 150 lbs Capacity Passenger 11 Boat Specifications Overall Length w o Platform 21
20. ED SUPRA DEALER DURING A PERIOD OF TWO YEARS FROM THE ORIGINAL PURCHASE DATE SKIER S CHOICE RESERVES THE RIGHT TO NOT TRANSFER THE WARRANTY ON ANY BOAT THAT HAS BEEN DAMAGED OR MISUSED THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE THIS WARRANTY IS EXPRESSLY IN LIEU OF ANY CONTRACTUAL LIABILITIES INCLUDING PRODUCT LIABILITIES THE DEALER IS NOT THE AGENT OF SKIER S CHOICE AND SKIER S CHOICE DOES NOT AUTHORIZE THE DEALER OR ANY OTHER PERSON TO ASSUME ON BEHALF OF SKIER S CHOICE ANY LIABILITY OR EXPENSE INCURRED IN THE COURSE OF REPAIRING ITS PRODUCTS OTHER THAN THOSE EXPRESSLY AUTHORIZED IN THIS LIMITED WARRANTY THE DEALER MAY NOT EXTEND OR IN ANY WAY CHANGE OR AMEND THIS LIMITED WARRANTY Owner s Responsibility Before operating your Supra it is necessary to read and fully understand this Owner s Manual and all other information delivered with the boat It is the owner s responsibility to take the boat to an authorized Supra dealer to obtain warranty service It is the owner s responsibility to properly operate and maintain the boat in accordance with this manual and all other information delivered with boat The owner should keep maintenance records should it be necessary to show that required maintenance has been performed on the boat 2002 Skier s Choice Inc Dealer s Responsibility 1 The Dealer should provide the buyer with an ade
21. FAILURE TO FOLLOW THIS RULE COULD RESULT IN THE BOAT CAPSIZING ETA SUPRA 8 2002 Skier s Choice Inc Basic Boating Rules You should be aware of these rules and follow them whenever you encounter another vessel on the water The rules presented in this manual are condensed and have been provided as a convenience only Consult your local U S Coast Guard Auxiliary USCGA or Department of Motor Vehicles DMV for a complete set of rules governing the waters in which you will be using your boat If you plan to travel even for a short trip you would be well served to contact the regional USCGA or DMV in the area where you will be boating Review and understand all local and state laws Any time two vessels on the water meet one another one vessel has the right of way It is called the stand on vessel The vessel which does NOT have the right of way is called the give way or burdened vessel These rules determine which vessel has the right of way and accordingly what each vessel should do The vessel with the right of way has the duty to continue its course and speed except to avoid an immediate collision When you maintain your direction and speed the other vessel will be able to determine how best to avoid you The vessel which does not have the right of way has the duty to take positive and timely action to stay out of the way of the stand on vessel Normally the give way vessel should not cross in front of the
22. LA ME Ea EDAM mE zi c BE _ z EHEHEHE This in amp perctinn and mailnienmance schedule necormnmiencdecd for average operaling conddians in normal Service Under severe operaling oonmdilions or service intervals should be shonened Cooling Systems FRESH WATER COOLING SYSTEM The standard cooling system for Supra boats is an open circulation cooling system with intake water This is preferred for lakes and reservoirs with low salt content If the engine is occasionally operated in salt water the cooling system should be flushed with fresh water periodically and always before storage If your boat is regularly operated in salt water it should be equipped with the optional salt water package SALT WATER COOLING SYSTEM The optional cooling system for use on salt water is a closed system with a solution of 50 antifreeze and 50 fresh water The coolant is left in the closed system and replaced once a year EA SUPRA Body Lubrication Normal use of your Supra causes metal to metal movement at some parts in the boat Driver seat track should be lubricated with a water resistant chassis lubricant such as silicon grease Lubricate rudder grease fitting located below the engine once annually 2002 Skier s Choice Inc Engine Oil and Filter The oil filter is located below the engine The engine manufacturer recommends that you change the oil and oi
23. Period from the original date of purchase by the First Owner the Original Purchase Date This Limited Warranty applies to the deck hull floor excluding carpet and stringers for the lifetime of the boat the Lifetime Warranty Period This Limited Warranty may be transferred for a minimal fee to subsequent owner s only through a Supra Dealer during a period of two 2 years from the Original Purchase Date Subject to the terms of this Limited Warranty Skier s Choice will repair or replace at its sole option any Covered Component which is returned during the applicable Warranty Period to the Skier s Choice factory or to any other Supra authorized repair facility an Authorized Supra Facility provided that Only the Covered Components that are declared defective upon examination by Skier s Choice will be repaired or replaced under this Limited Warranty Transportation of the boat parts or components to and from the Skier s Choice factory or the Authorized Supra Facility must be pre paid by the owner Notice of any claim under this Limited Warranty must be provided to Skier s Choice by the Authorized Supra Facility no later than sixty 60 days after the owner becomes aware of the defect Notification of a claim or defect must be properly made directly to an Authorized Supra Facility who subsequently must submit the claim information to Skier s Choice at 5820 US 411 South Maryville Tennessee 37801 Informa
24. SUPRA IPIE BOATS 2003 Owner Manual SKIER 101CE Ine 5820 Hwy 411 South Maryville Tennessee 37801 865 856 3035 www supraboats com Section Section Section III Section IV Section V Section VI Section VII Sectioin VIII Sectiion IX Section X Section XI Section Section XIII Section XIV Section XV Table of Contents Introduction Boating Safety Boating Rules Boat Specificatioins Operating Information Starting amp Operation Instrument Panel Equipment amp Options Service amp Maintenance Cleaning Care amp Storage Winterization amp Dry Storage Technical Information Trailer Your Boat Supra Warranty Index Boat Information Hull Identification Number Date of Purchase Dealer s Phone Number Registration Number Engine Serial Number Trailer Serial Number EEA SUPRA EA SUPRA Revised 9 27 02 EH 2 2003 Skier s Choice Inc Section Introduction Introduction Supra inboard ski boats are manufactured by Skier s Choice Inc in Maryville Tennessee and distributed throughout the United States and the world This manual provides an overview for operating your Supra boat It should be considered a permanent part of your Supra boat and contains important information on Safety Boating Rules Proper Operation and Maintenance of your boat Should the boat be sold this manual will provide the same important information to the next o
25. Skier s Choice Inc T T1 ca d L TW AT he zu pir Section XIII Trailering Your Boat AM Li ss wa ORA Wn fm se rb p eT es 5 du ck er EAT ra iro Ex enn Lis pr e des Trailer amp Towing The trailer supplied with your Supra was designed especially for the boat with your convenience in mind Please be sure that you have an appropriate tow vehicle before attempting to trailer your boat Your vehicle must be capable of towing 5 000 lbs and must be fitted with no less than a Class III 5 000 Ib max trailer hitch CAUTION Read the trailer towing section of your vehicle owner s manual before towing your trailer All Supra trailers require a 2 ball and a five 5 pin marine grade trailer wiring connector The standard height from the ground to the top of the hitch ball should be about 20 inches With the trailer attached to the tow vehicle the trailer should stand approximately level Trailer Plug Wire Schematic White Ground Green Right Brake Yellow Left Turn Brake Brown Running Lights Blue Reverse Lights NOTE Supra trailers feature disk brakes The 5th wire blue on the wire connector needs to be connected to your vehicles reverse lights to be operative This wire blue provides power to a solenoid which deactivates the brakes while in reverse You may still tow your trailer without the blue wire con
26. Y For maximum enjoyment and safety check each of these items T DO NOT BE ON OR ABOUT PLATFORM BEFORE you start your engine DRAIN PLUG Securely in place WHEN MOTOR IS RUNNING LIFE SAVING DEVICES One for every person on board STEERING SYSTEM Working smoothly and properly FUEL SYSTEM Adequate fuel Leaks Fumes BATTERY Fully charged Cable terminals clean and tight WARN N G ENGINE I tral you overloaded or overpowered LEAKING FUEL IS A FIRE AND EXPLOSION WEATHER CONDITIONS Safe t ELECTRICAL EQUIPMENT ene oe ao etc HAZARD INSPECT SYSTEM REGULARLY EMERGENCY GEAR Fire extinguisher bailer paddle anchor EXAMINE FUEL TANKS FOR LEAKS OR amp line si ling device tool kit etc alles ate prior to operation of CORROSION AT LEAST ANNUALLY boat to ensure water is exiting boat and pump is free of debris S SSSSSSSSCNS Labels apply to models with RAD A CAGES WARNING IT IS THE OWNER S RESPONSIBILITY TO CHECK THE TIGHTNESS OF THE RAD A CAGE BOLTS BEFORE EACH USE WARNING THE RAD A CAGE IS DESIGNED TO PULL A SINGLE 1 WAKEBOARDER TRICK SKIER OR KNEE BOARDER DO NOT CLIMB OR SIT ON THIS RAD A CAGE ROPE MAY LOOP ON INVERTED TRICKS DO NOT SIT BEHIND THE PULLING POINT OF THE TOWER CAUTION THIS TOWER MAY STRIKE LOW OBJECTS CHECK CLEARANCE HEIGHT AROUND DOCKS SHORE OVERHANGING OBJECTS BRIDGES AND POWERLINES CAUTION DO NOT PULL PAST 45 DEGREES OF THE CENTERLINE OF THE BOAT
27. ans Ser Fiber aun care Boat Specifications Overall Length w o Platform Overall Length w Platform Overall Length w Trailer Width Beam Draft Weight Boat Only Weight Boat amp Trailer Capacity Passenger Capacity Weight Capacity Fuel Engine EA SUPRA P Bh 5 Arp GD Paper Firin Color ha ens inimar Fei w Fan ol id eade LORS Ek rrip 21 8 23 10 25 8 95 22 3 050 Ibs 4 150 Ibs 11 1 500 16 34 gals 320 HP V 8 14 Bi thet Po pees Sunsport V eus ae Pete Deubis Lip GET Virgie b 40 ar arra Tinan bei Rubin Farmers Pasa Prior Boat Specifications Overall Length w o Platform Overall Length w Platform Overall Length w Trailer Width Beam Draft Weight Boat Only Weight Boat amp Trailer Capacity Passenger Capacity Weight Capacity Fuel Engine in 5 Bib Limi are Brgy reed Orph Aih CO Purper 4 Orah Fhader HA Urera Sa keam Eaa bry Haar Far ire is belle 10 HB Fen ae 21 8 23 10 25 8 95 24 3 250 lbs 4 350 lbs 11 1 5
28. ated directlybelow the shifter mechanism and the 1 osition system is operated from a switch on the dash Each switch allows independent filling and draining of each ballast container by simply hitting the fill or drain switch If the system fails to fill or drain you may check the resettable breaker on the switch panel or the separate ballast fuse block located under the dash area The ballast bags or tanks can be found in the front ski locker under the rear seat or in the rear v drive storage areas depending on the the model and ballast system EX SUPRA Care should be taken that the ballast bags are situated properly with the fill hose on top and drain hose on bottom and that all fittings are installed securely The bags should not be twisted and the bags should be free to expand and drain completely Care should be taken to prevent sharp objects from coming in contact with the bags Cuts and punctures to the bags are not warrantable Each Bertha Ballast system also includes a manual shut off valve in case of emergencies If closed the valve will prevent any water from entering the system and 1 only used in emergency situations Under normal use the valve should remain open to allow full flow of water into system Priming the System To allow water into the system the Bertha Ballast system utilizes a scooped intake stainer to force water into the system This allows the ballast system to be filled while running or sitting st
29. ated in any open position forward of neutral or back of neutral upright position Return the throttle to idle position and the transmission lockout will automatically reengage the transmission in neutral position 2002 Skier s Choice Inc Bilge Area Drain Plug The bilge area drain plug is located at the front of the motor well directly under the engine It is extremely important that the drain plug is always checked before starting the engine The drain plug should be secured in place using a wrench N WARNING DO NOT start engine until center drain plug is checked and secured in place DO NOT try to install center drain plug while engine is running CAUTION Some Supra models DO NOT have mechanical devices to hold the motor box cover in the open position Please use caution to prevent accidental closing Rear Drain Plug The rear drain plug is located at the back of the boat near the bottom of the transom See photo It is extremely important that the drain plug is always checked before starting the engine The drain plug should be secured in place using a wrench CAUTION DO NOT start the engine until the drain plug is checked and secured in place DO NOT try to install the drain plug while the engine is running EFI Phased Warm Up Always let engine warm up to normal operating temperature before accelerating EFI engines are programmed with a phased warm up to ensure that the engine is wa
30. ays be followed before the first start up of the day 1 Check the engine oil level 2 Check for gasoline fumes in bilge or engine compartment 3 Operate engine blower for 4 minutes to remove any fumes 4 Check manual operation of bilge pump Make sure bilge areas are empty Other items might also be inspected depending on the boat and its use It is advisable to formulate a check list particular to the equipment and operation of your boat REFER TO THE BOATMAN S CHECKLIST OF THIS MANUAL Consult the local Coast Guard Auxiliary or Power Squadron for full details on boating safety NOTE Add on electrical accessories should never be connected to the ignition terminal or ignition circuit IMPORTANT DO NOT continue to operate the starter for more than 30 seconds at a time without pausing to allow the starter motor to cool down for at least 2 minutes This will also allow the battery to recover between starting attempts PLEASE REFER TO ENGINE OWNER S MANUAL FOR ADDITIONAL DETAILS DANGER BEFORE STARTING ENGINE BE SURE THAT THE SHIFT SELECTOR IS IN NEUTRAL The correct starting procedure depends upon the type of engine Please refer to the engine manual before starting To Start Electronic Fuel Injection EFI Engine 1 Place shift selector in Neutral with the throttle in the upright zero position If throttle is not in the idle position the throttle position sensor will not allow the engine computer to proceed with a norma
31. ble Brackets Ski Pylon Inboard amp V Drive Slalom Course Speeds Speedometer Speed Calibration Speedometer Paddle Wheel Starting amp Operation Stereo Stereo Amp Optional Stern Light Subwoofer Optional Sundeck T Tachometer Teak Wood Care Temperature Gauge Throttle Lever Tonneau Cover Optional Tower Pole Light Tower Speakers Optional Tilt Steering Trailer Boat Connecting Loading Procedure Trailer Alignment Unloading Procedure Transmission Fluid Check Fluid Specifications Lockout Trim Switch and Gauge U Upholstery Care V V Drive Battery Box Engine Compartment Fluid Check Fuel Tank Warning Light Voltmeter CN SUPRA 17 19 54 42 34 46 31 25 68 W Wakeboard Racks Optional Wake Plate Wake Plate Hydraulic Walk Thru Curtain Optional Walk Thru Windshield Warning Labels Warranty Washing Your Boat Water Strainer Optional Windshield Care Winterization 2002 Skier s Choice Inc
32. d immediately patch and reseal the area Use a tent seam sealer to reseal any new stitches Spray fabric guard on scraped or worn surfaces Canvas tears should be repaired professionally and stitches sealed to prevent leakage CN SUPRA CAUTION Your mooring cover is not designed for trailering Trailering with your cover installed may cause premature cover failure and boat damage This damage is not warrantable Coast Guard Regulations The United States Coast Guard boating regulations prescribe minimum standards of safety to be met and maintained by all watercraft It is necessary that your boat remain in compliance with these regulations The staff at Skier s Choice Inc recommend that all boat operators complete a Coast Guard approved boating safety course Maximum Capacities MAXIMUM re 5 ry PERSONS XX 77 NS A se iE AITH USCG SAFET ETAHDAACS ah Pe far oF COATFICANON MAN ee In compliance with United States Coast Guard Regulations Supra Boats meet or exceed all safety standards designed for recreational boats To ensure safe handling and performance each Supra boat displays a maximum capacity sticker See sample stating the maximum passenger weight load allowable NOTICE Refer to the Maximum Capacity Sticker on your boat for allowable loading 2002 Skier s Choice Inc Section VI Starting amp Operation A standard pre starting procedure should be alw
33. d to the starter solenoid Connect the positive battery cable to the positive post on the battery Connect the negative battery cable to the post on the battery CAUTION Failure to connect battery cables as outlined will damage the system and void the warranty N WARNING Sulfuric acid in the battery can cause serious burns If spilled on skin or in eyes flush with clean water immediately then seek medical attention 2002 Skier s Choice Inc N WARNING Hydrogen and oxygen gases are produced during normal battery operation and charging Sparks or flames near the battery vent openings can cause the mixture to ignite and explode EX SUPRA ETA SUPRA 52 2002 Skier s Choice Inc Fiberglass Care Washing and waxing the boat hull and deck regularly will extend the life and beauty of your Supra It is a good routine to rinse your boat with fresh water after each day s use It is recommended that the hull land deck be cleaned and waxed after every 25 hours of use This will decrease water friction and lesson the potential for staining or spotting on the gelcoat surface When the original gelcoat shine cannot be restored by waxing the shine may be restored by hand buffing with a commercial polishing compound Be sure to apply a new coat of wax containing Carnauba over the area that has been polished IMPORTANT Porcelain cleaning powders are too abrasive for use on gelcoat and may cause
34. ded that any replacement parts used during maintenance or for repair be supplied by an authorized Supra dealer NOTICE You are responsible for keeping records of all maintenance on your boat To maintain your new boat warranty you may be required to prove that required maintenance was performed GWA 2002 Skier s Choice Inc 47 Revised9 27 02 EH SUPRA Maintenance Chart _ Change Engine Oil Replace Oil Filler Clean Oil Filler Gap Check Transmission fluid Level Change Transmission fluid Check Water Sirainar if Clean Flame Arrestor Clean Crankcase Ventilating System _ Check Water Pump amp Alfternator Belt Tension Change Fue Check Fuel Lines amp Connecbons for Leaks Clean Carburetor Fi Fuel Inlet Filter Clean Transmission Cil Strainer Screen Lubricate Distributor Cam ShaltPackng Log Check Condition of Spark Plugs Check Balten Electrolyte Level Check All Electrical Connections Check Cooling System Hoses for Leaks Tighten Engine Mount Fasteners Lubricate Throttle and Shift Linkage Pivot Points _ Chack for Loose Damaged or Missing Parts _ Check ack Engine to Pr Propeller aller Shaft Alignment _ Lubricate Rudder Port Check V Drive Fluid Level Change v Drive amp Transmission Fluid os CN EMI MEL ME NEG ee If engine overheats visually check If clogged remove debs Pertains io V Drrves only Maintenance Intervals Engine Hours LES E
35. ding from open water into port and black buoys are to port left side When navigating out of port your position to the buoys should be reversed red buoys to port and black buoys to starboard Many boating bodies of water are entirely within the boundaries of a single state The Uniform State Waterway Marking Systems has been devised for these waters This system uses buoys and signs with distinctive shapes and colors to show regulatory or advisory information These markers are white with black letters and orange borders The information signifies soeed zones restricted areas danger areas and general information Remember Markings may vary by geographic location Always consult local boating authorities before driving your boat in unfamiliar waters See examples of buoys and markers next page 2002 Skier s Choice Inc 2002 Skier s Choice Inc COLOR CODE ENN sack Emm EN t GHP m Zr me m Peery ire Prec rer on Bes ZCONBAHTY CHAMKEL TANTI PERTH CAN BUY Odd rumba Lecree To port Ever MCE 10 SOC 11 UGHED Peut Hore Cod number incnaceinmg howord heard of merge non Lecme To port Det proceeding Leonem WEHE Shared Hand Even nurmtobar incnecsing h2wum Rec of namo tian Lace to starboard ribi proceeding Liteon LEXSHTED SAFE WATER Bay Ho ru
36. e boat directly in front of the motor box The ski pylon is to be used to pull skiers DO NOT use ski pylon to hoist boat Only use the lifting rings for this purpose NOTICE The use of pylon extensions may cause the pylon to loosen Please see your dealer for proper tightening procedures N WARNING The use of pylon extensions can severely effect the overall handling of the boat Follow pylon extension manufacturers directions for mounting N WARNING DO NOT mount any Pylon Extension on the rear pylon located at the rear sundeck of v drive models EX SUPRA Rad A Cage If your Supra model has been equipped with an optional RAD A CAGE towing tower please review this section for details on it s usage maintenance and storage The cage 1 designed as stable tower to enhance wakeboarding It is NOT intended to be used to tow skiers barefoot skiers or multiple wakeboarders Such use will void any warranties written or implied N WARNING Before use be sure that all mounting bolts are properly tightened in place N WARNING Be aware of and avoid low overhead objects such as bridges power lines overhanging trees etc N WARNING DO NOT stick fingers or other objects into logo cutouts EK SUPRA To Lower Cage For Storage Tools Required 5 16 Allen Wrench 1 Loosen but do not remove the front 5 16 18 x 1 1 4 allen head bolts that connect the front legs to the foot 2 Remove the hand k
37. e downs Do place straps around fenders or lights 2 Always verify that the winch hook is securely in the bow eye the strap is tight and the winch handle locked in place before trailering 3 Check the recommended pressure displayed on the side of the tires and assure that it is maintained Under inflated tires could cause trailer sway and excessive tire wear 4 Before use please read all information supplied with the trailer by the manufacturer Bearing Buddy Boat Buddy and hydraulic brake actuator Check wheel bearing grease 5 Before operating Boat Buddy check trigger setting and latch pin location After loading check latch pin and confirm that it is properly seated in the eye hook before pulling trailer out of water Wash Boat Buddy moving parts with high pressure water 6 Check wheel bearing lube 7 See Trailer Owner Manual for Maintenance Schedule CAUTION Inadvertent release of latch pin could result in injury Connecting the Trailer When connecting the trailer to your tow vehicle use the following procedure 1 Raise the tongue with the trailer jack position the trailer tongue directly over the 2 ball and lower the jack until the tongue goes all the way down over the ball 2 Press down on the latch until it locks on the ball with a click NOTICE If your hitch ball has an excessive flat spot on top the latch may not engage properly If the latch does not catch check with your dealer o
38. e middle of the spring toward the rear of the glove box with one hand as you guide the lid closed with the other EX SUPRA Battery Box The battery is mounted inside the observer s seat storage compartment Location may vary slightly depending on the model NOTICE It is recommended that the battery cables be disconnected from the battery when the boat is placed in storage Optional Boat Heater The boat heater is a forced air heater that uses hot engine water as a heat source To use the heater simply turn the heater switch to the selected fan speed In order for the heater to work the engine must be at operating temperature One of the features of the heater are the snorkel vents which can be pulled out direct heat to specific areas EA SUPRA Walk Thru Windshield The movable center windshield panel allows access to and from the bow deck To open turn safety latches to vertical and push Lay the center windshield panel gently against the fixed side panel The bimini top is designed as a sunshade Please see the mooring cover section forinstructions oncleaning and caring for your bimini top When opening and latching the strtaps to the eye hooks twist the strap one to two times to prevent them from vibrating in the wine CAUTION DO NOT operate the boat above 45 MPH with the bimini top open Do not trailer the boat with the bimini top open 2002 Skier s Choice Inc Optional Shower The h
39. enance impact misuse negligence collision delay in repair improper hoisting or cradling of the boat Any and all consequential damages including but not limited to costs incurred for haul out launching towing and storage charges telephone or rental charges of any type inconveniences loss of use or loss of time or income Equipment installed by anyone other than authorized factory personnel at the Company s production facility Equipment replaced at an Authorized Supra Facility pursuant to this warranty agreement remains under warranty until the expiration of the Limited Warranty period Any boat which is a used for rental or other commercial military or industrial purposes b used in boat racing demonstrations ski school or similar events c altered modified repaired or replaced so as to increase the cubic inch capacity or horsepower output of the engine and boat as originally manufactured d not properly stored or maintained Speeds fuel consumption and other performance characteristics because they are estimated and may vary Damage to or defects in paints varnishes gelcoat surfaces and colors finish distortions chrome plated or anodized finishes floor covers and any other surface coatings Gelcoat discoloration cracks blisters or bubbles including but not limited to those which may result from a boat being left in the water for long periods of time Upholstery cracks mi
40. er and have fewer repairs over its lifetime Your new engine does not require an elaborate break in procedure Just follow these simple instructions and you are off to a great start The three 3 most important aspects of new engine break in are 1 Avoid running engine at high speeds 2 Do not carry a heavy load passengers gear etc 3 Vary your boat speed during break in don t run at the same RPM for a long period of time BREAK IN STEPS For the first hour do not exceed 2 000 RPM For the second hour do not exceed 3 000 RPM For the next five hours do not exceed 4 000 RPM BREAK IN TIPS Avoid fast accelerations and don t carry or pull a heavy load during this period Always let engine warm up gradually before acceleration Check oil frequently During the first 50 to 100 hours an engine can use more oil than usual Maintain oil at a proper level at all times do not overfill Monitor transmission fluid levels Report abnormal noises or vibrations to your dealer Keep an eye out for loose mountings fittings nuts bolts and clamps During the BREAK IN process engine temperature should be carefully monitored and speed should be reduced if overheating is evident ALSO PLEASE REFER TO ENGINE OWNER S MANUAL FOR BREAK IN INFORMATION NOTICE PLEASE REFER TO ENGINE OWNER S MANUAL for maximum RPM and engine break in procedure After the first 20 hours of operation take your boat to the
41. f the reading is more than 19 9 ft all readings will be in whole numbers 2 The depth finder has an audible and LCD displayed depth alarm with adjustable shallow and deep limits and a depth below keel offset feature The settings once made are stored in memory and will remain even if the battery is disconnected Operation 1 Power On The depth sounder will activate automatically when the power to it is initially turned on You do not have to press the combination ON OFF MODE keypad The LCD will illuminate showing the depth and will also show the type of units selected feet FT meters M or fathoms F To turn the depth sounder off press and hold the ON OFF MODE keypad for 4 seconds Pressing the ON OFF MODE keypad again will reactivate the unit NOTE The instrument is designed to have the internal LED lighting remain on as long as power is supplied even if the unit is turned OFF at the keypad 2 Depth Alarm Shallow mode Pressing the ON OFF MODE keypad again displays the SH shallow depth alarm setting This is the shallowest water that will activate the alarm Press and hold the up or down arrow keypads to adjust the reading to the desired depth Deep mode Pressing the ON OFF MODE keypad again displays the DP deep depth alarm setting This is the deepest water that will activate the alarm Press and hold the up or down arrow keypads to adjust the reading to the desired depth When the shallow dep
42. for extra rear and forward facing seating To use this i houl E SUCI ES AREE PAM DNE the wea seating lift and pull the seat back into the locked position Be to exceed manufacturer s recommended sure that the metal arms are locked straight before applying jubes pressure To lay seat back down simply push down on the middle section of the metal support arm SUPRA 40 2002 Skier s Choice Inc Hydraulic Wake Plate The hydraulic wake plate allows the driver to control the running attitude of the boat It can be controlled by the switch on the dashboard Trim Switch amp Gauge TRIM Tag 100 FLECTION EMMETT This switch controls the optional hydraulic wake plate The gauge indicates the position of the plate The gauge will only read from 0 degree to 50 degrees due to limited hydraulic motion 2002 Skier s Choice Inc Optional Perfect Pass Perfect Pass is a marine approved cruise control system It is an accurate and simple way to ensure consistent speed It is controlled by the driver via a gauge onthe dash CAUTION Be sure to read and understand the Perfect Pass Owner s Manual before using this feature If you did not receive a Perfect Pass Owner s Manual please contact your selling dealer Glove Box To open the glove box press the black round cylinder down while lifting the black finger tab Once open the lid is supported by a spring To close the lid push th
43. gnition Type Alternator Output Thermostat Firing Order Initial Timing Oil Filter Oil Capacity Oil Type Spark Plugs Gap RPM Range WOT 2002 Skier s Choice Inc Multi Port Fuel Injection 370 HP 350 Cl 4 00 3 48 9 4 to 1 12 V Neg Ground Electronic Distributor 70 Amps 1 200 RPM 162 Degrees F 1 8 4 3 6 5 7 2 10 Degrees Service Mode Pennzoil PZ 3 5 Quarts Pennzoil 15W 40 Marine AC 41 932 MR43LTS 0 045 4 600 5 200 RPM Transmission Multi Port Fuel Injection 330 HP 350 Cl 4 00 3 48 9 4 to 1 12 V Neg Ground Electronic Distributor 70 Amps 1 200 RPM 162 Degrees F 1 8 4 3 6 5 7 2 10 Degrees Service Mode Pennzoil PZ 3 5 Quarts Pennzoil 15W 40 Marine AC 41 932 MR43LTS 0 045 4 600 5 200 RPM 57 ZF Hurth Throttle Body Fuel Injection 320 HP 350 Cl 4 00 3 48 9 4 to 1 12 V Neg Ground Electronic Distributor 70 Amps 1 200 RPM 162 Degrees F 1 8 4 3 6 5 7 2 10 Degrees Service Mode Pennzoil PZ 3 5 Quarts Pennzoil 15W 40 Marine AC 41 932 MR43LTS 0 045 4 400 4 800 RPM Transmission Holley Carb 310 HP 350 Cl 4 00 3 48 9 4 to 1 12 V Neg Ground Electronic Distributor 70 Amps 1 200 RPM 162 Degrees F 1 8 4 3 6 5 7 2 10 Degrees Timing Shunt Pennzoil PZ 3 5 Quarts Pennzoil 15W 40 Marine AC MR43LTS 0 028 4 400 4 800 RPM ZF Hurth ATF Dextron Ill EA SUPRA GA SUPRA Revised 9 27 02 EHJ 58 2003
44. ht limit is 150 lbs equally distributed The Rad A Cage Tower may strike low objects Check clearance height around docks shore overhanging objects bridges and power lines DO NOT pull past 45 degrees of the centerline of the boat Failure to follow this rule could result in the boat capsizing CAUTION It is the driver s responsibility to ensure all passengers are seated when boat is underway N WARNING Failure to adhere to these warnings may result in severe injury or death to you and or others This boat is a high performance boat and capable of quick and tight turns and changes in direction It is the driver s responsibility to operate the boat in a manner to ensure the safety of all passengers N WARNING Boaters must continuously be aware of weather conditions Sudden storms wind lightning etc can unexpectedly put boaters in grave danger Always check the local weather report before going boating N WARNING It is the driver s responsibility to determine if weather or other factors have created an unsafe boating environment The driver is solely responsible for the consequences of their actions 2002 Skier s Choice Inc you N WARNING Failure to adhere to these warnings may result in severe injury or death to you and or others Every skier must always wear a USCG approved personal flotation device Maintain a distance of at least 100 feet from all other objects
45. ift the boat by means of a cable sling from bow to stern lifting eyes Hoist operator should slowly and smoothly lift the boat without jerking to avoid damage to the lifting eyes N WARNING DO NOT use the bow eye to hoist boat Use only a proper sized sling in the designated lifting rings to hoist the boat Incorrect Hoisting see Hote use of rags behind hooks to protect gelcoat finish N WARNING DO NOT use the ski pylon to hoist the boat N CAUTION Incorrect hoisting may invalidate the warranty on the boat CSS SUPRA 56 2002 Skier s Choice Inc Section XII Technical Information Identification Number Battery Specifications 12 Volt Marine Type with Tapered Post Connectors Engine Size Cold Crank 0 F 18 C 650 Amps The hull identification number is located on the upper right hand side of the transom below the rub rail A WARNING Hydrogen and oxygen gases are produced during normal battery operation or charging Sparks or flames can cause this mixture to ignite and explode if it comes near the vent openings Sulfuric acid in the battery can cause serious burns if spilled on skin or in eyes Flush with clear water immediately Engine amp Transmission Data Engine Model Indmar Assault MPI HO Indmar Assault MPI Indmar Assault TBI Indmar Assault Carb Fuel Delivery Horsepower Displacement Bore in Stroke in Compression Ratio Electrical System I
46. ilering the boat DO NOT trailer boat with ballast full Er 2002 Skier s Choice Inc 31 SUPRA ETA SUPRA 32 2002 Skier s Choice Inc Section VIII Equipment amp Options Ignition Keys Fuel Cap Ke Two ignition keys are provided with the boat Key entry into the ignition may be difficult due to the boot protector Please do not unduly force the key into the ignition Key tumblers are located vertically thus the key should be vertical when placed into the switch NOTE Always attach the ignition key and gas key to a floating key chain to prevent loss in the water To prevent tampering with fuel system your Supra 1 provided with a gas cap which may be opened only with a special key NOTICE The gas cap is sealed by a rubber O ring DO NOT over tighten CAUTION Always attach the ignition key and gas key to a floating key chain to prevent loss overboard Mirror The rear view mirror is installed as a standard item The mirror is adjustable and is not permanently placed so that it may be set for each driver Mirror should always be checked before driving Mirror angle will change with each new driver GA 2002 Skier s Choice Inc 33 Revised9 27 02 EHJ SUPRA Driver s Seat amp Seat Adjustment The Rise R Seat is a unique driver seat enhancement The front edge of the driver s seat cushion lifts up to give the driver a taller sightline To switch the seat to the raised po
47. ill If air becomes trapped in the system it may be necessary to run the boat at planing speeds to force water into the system and allows the fill pump to prime fully Once the pump has primed it is no longer necessary to run the boat for filling This situation may occur if the boat is trailered 2002 Skier s Choice Inc The Bertha Ballast system utilizes a manifold and a solenoid valve to independently fill each bag or tank The solenoid valves have a small toggle switch that can manually override the opening of the valve The manual toggle switch needs to be in the down position to allow the system to be controlled by the switches in the dash area If the manual toggle switch is turned to the up position the valve will be open all the time and cannot be controlled by switches in the dash area If the ballast system fills continuously while running the boat check to make sure the manual override toggle switch is in the down position If it continues to fill and the manual toggle switch is in the down position check for debris that may have clogged the solenoid valve forcing the valve to stay open If the valves continue to fill closing the manual emergency shut off valve will prevent any water from entering the system To fill the ballast system press the fill switch To empty press the empty switch With the ballast full the boat may porpoise at speeds above 25 mph N WARNING Empty ballast before tra
48. ing on the dipstick If the oil level is between the FULL and the ADD marks on the dipstick simply replace the dipstick When the oil level is at or below the ADD mark add oil to return the level to the FULL mark EA 2002 Skier s Choice Inc 49 SUPRA Transmission Level Check Transmission Fluid Chack V Drive Unit Use only automatic transmission fluid type A in transmissions with 1 1 drive train Refer to Engine Owners Manual Change Frequency Change transmission fluid every year using only Dextron lll Mercon automatic transmission fluid Maintaining Fluid Level Transmission fluid level should be checked regularly and fluid added if necessary Maintain fluid levels as follows Boat must be at rest Engine should be at operating temperature but turned off while checking level Remove transmisson fluid dipstick Wipe fluid clean from dipstick and replace Remove dipstick and note level indicated by the upper and lower marks If required add fluid to bring the level to the upper mark EA SUPRA V Drive Fluid Check The fluid level can be checked by using the oil level gauge which is located on top of the V Drive transmission This unit is located under the center cushion of the rear seat Pull out the cushion to access the transmission Pull the oil level gauge to check the fluid level If the level is low add fluid to the correct mark on the dipstick Use SAE 3
49. l filter after the first 10 20 hours use of your new boat Thereafter to maximize engine life change oil and filter after every 50 hours of use See Engine Engine Oil Manual amp Filter Crankcase oil should be selected to deliver the highest performance for your operating conditions and climate In general engine oils with lower viscosity ratings are used when temperatures remain low or when better fuel economy is desired Oils with higher viscosity ratings are used when temperatures remain higher and when higher performance is expected from the engine The Engine Manufacturer recommends Pennzoil 15W 40 Marine Oil Drain Motor Oil If this is unavailable a high grade with an A P I reti classification of SH SJ SG CD is acceptable REFER TO ENGINE MANUAL for more information Fuel Filter Water Separator 4 Water Sepa rators V Drive remote oil filter is mounted on the ski pylon bracket Depending on the model of your engine you will have either a water separator filter or a fuel filter If your engine has a water separator filter it will be located on the front of the engine If your engine has a fuel filter it will be located on the stringer under the engine Oil Level Check 5 A Hi LEVEL 0 Fu Engine oil level should be checked at regular intervals such as every 5 engine hours To obtain a true reading when the engine is at operating temperature and turned off check the oil level show
50. l starting procedure 2 Turn Ignition Key to Start Position to operate the starter 3 Release the Key when engine starts key will return to run position 4 Allow the engine to establish a good idle 30 to 60 seconds before getting underway 5 Shift slowly into forward or reverse allowing the transmission time to engage before powering up NOTE It is normal for the idle to speed up in cold start conditions N CAUTION DO NOT continue to operate the starter for more than 30 seconds at a time without pausing to allow the starter motor to cool down for at least 2 minutes This will also allow the battery to recover between starting attempts PLEASE REFER TO ENGINE OWNER S MANUAL FOR ADDITIONAL DETAILS NOTE Should the EFI engine become flooded use the following procedure to start 1 Place shift selector in Neutral and disengage the transmission by pushing the transmission lockout button located at the bottom of the lever 2002 Skier s Choice Inc 2 With the transmission disengaged push the lever forward to full throttle position This will cause the computer to shut off the fuel injectors which will allow the engine to clear of excess fuel during starting 3 Turn the Ignition Key to Start Position and operate the starter for no more than 15 seconds at a time until the engine starts 4 When the engine starts back off the throttle and allow the engine to establish a good idle 30 to 60 seconds 5 Re
51. ldew stains or tears resulting from owner use lack of maintenance improper maintenance impact misuse negligence delay in repair use of improper cleaners or conditioners Skier s Choice reserves the right to improve its products through changes in design or material without being obligated to incorporate such changes in products of prior manufacture OTHER LIMITATIONS THIS LIMITED WARRANTY LIMITS THE DURATION OF ANY IMPLIED WARRANTY OF MERCHANTABILITY OR IMPLIED WARRANTY OF FITNESS FORA PARTICULAR PURPOSE TO THE PERIODS SPECIFIED HEREIN Some states do not allow limitations on how long an Implied Warranty lasts so this limitation may not apply to you EA SUPRA P v m DM 79 P THE REMEDIES OF REPAIR OR REPLACEMENT AT THE OPTION OF SKIER S CHOICE AS SET FORTH HEREIN ARE THE ONLY REMEDIES AVAILABLE UNDER THIS WARRANTY SKIER S CHOICE DISCLAIMS ANY OBLIGATION OR LIABILITY FOR COSTS OR CHARGES DERIVED FROM INCONVENIENCE OF LOSS OF USE COMMERCIAL OR MONETARY LOSS DUE TO LOSS OF TIME INCONVENIENCE OR ANY OTHER CONSEQUENTIAL SPECIAL OR INCIDENTAL DAMAGES Some states do not allow the exclusion or limitation of incidental or consequential damages so the above limitations or exclusions may not apply to you THIS WARRANTY IS IN PLACE OF ANY OTHER EXPRESS WARRANTIES THIS WARRANTY APPLIES TO THE FIRST OWNER AND IS TRANSFERABLE TO SUBSEQUENT OWNER S ONLY THROUGH AN AUTHORIZ
52. lights fail to operate press the circuit breaker not operate notify your Supra dealer Bilge Pump Switch V Drive Warning Light WARNING DO NOT RUN V DRIVE IF LIGHT IS ON ABOVE 1200 RPM LOW OIL PRESSURE CHECK OIL LEVEL The V Drive transmission in your Supra is equipped with a The bilge pump switch operates in two positions The manual low pressure warning light This light is located by the position is used to verify that the pump is operational dash Do not operate your Supra if the warning light remains on whenever the engine speed is above 1 200 RPM The automatic pump function is engaged at all other times so 400 RPM This warning light should be on whenever the that any excess water in the bilge may automatically be engine speed is below 1 200 RPM 400 RPM If this pumped out light remains on during operation above idle shut your engine off immediately and check your v drive oil level and NOTICE If the Bilge Pump fails to operate in the manual see your dealer position press the circuit breaker reset button labeled BILGE If the bilge pump still does not operate notify your Supra dealer EA 2002 Skier s Choice Inc 29 SUPRA Optional Bertha Ballast System The optional Bertha Ballast System is an electronically controlled ballast system that can be operated from the driver s seat The Bertha system is available in a 1 2 or 3 position system The switch panel to the 2 and 3 position systems is loc
53. mal operation Stereo EX E EE a EF Remote Control Pad Please refer to your stereo owners manual for proper operation instruction NOTE Stereo unit is connected to the ACC switch on the dash The ACC switch must be in the ON position before the stereo can be turned on CAUTION _ the stereo cannot be turned off by the remote The SRC button on the stereo unit must be held down for 3 seconds to completely turn the stereo off Continue to hold the SRC button until display goes blank or turn off the ACC switch on the dash CAUTION face displays ALL OFF your stereo is in standby mode and drawing battery power which will drain the battery and may lead to a dead battery 2002 Skier s Choice Inc Navigation Lights Switch Accessory Switch The navigation light switch supplies power to the Bow Light the Stern Light and the Pole Light Operation When underway during night time operation set the switch in the NAV position to activate all of the running lights When docked or at anchor set the switch i the ANC position to activate only the pole light NOTICE If lights fail to operate press the circuit breaker under the dash NAV Lights ANC Lights TOWER Lights Wz A aji 2002 Skier s Choice Inc The accessory switch supplies power to an extra circuit for accessories that may be added such as heaters hot water showers etc
54. nected however you may experience difficulty backing the trailer 2003 Skier s Choice Inc Connecting the Trailer When connecting the trailer to your tow vehicle use the following procedure 1 Raise the tongue with the trailer jack position the trailer tongue directly over the 2 ball and lower the jack until the tongue goes all the way down over the ball 2 Press down on the latch until it locks on the ball with a click NOTICE If your hitch ball has an excessive flat spot on top the latch may not engage properly If the latch does not catch check with your dealer or hitch installer before trailering 3 Insert the locking pin into the tongue Lock pin hole is on the side of the tongue 4 When all weight is off the trailer jack pull the jack lock pin and rotate the jack to the horizontal position and lock the pin 5 Attach the safety chains to the tow vehicle hitch Cross the chains and wrap them around each other once or possibly twice allowing just enough slack to permit tight turns of the vehicle and trailer 6 Connect the trailer light plug to the tow vehicle connection to activate the lights 7 Connect the brake safety cable N CAUTION BEFORE USE READ ALL INFORMATION SUPPLIED WITH THE TRAILER BY THE MANUFACTURER GA Revised9 27 02 EHJ SUPRA Prolong Trailer Life The following guidelines will prolong the life of the boat and trailer 1 Always secure the boat to the trailer with ti
55. ned sun deck The wake plate is located on the stern at the bottom of the transom Proper adjustment of the wake plate will allow better control of the trim Propeller Adjustment is made by turning the turnbuckles to the desired osition moving the plate up or down Your dealer can help you with this Under normal conditions the abest overall plate position is between 1 8 above or below horizontal NOTICE DO NOT raise the wake plate above or below 1 4 the horizontal plane See also Optional Hydraulic Wake Plate The research and design team at Skier s Choice has carefully explored and tested many different propellers and pitch angles for use on our boats All tests indicate that the current propeller installed on your model is the best for the variety of boating performance required whether skiing competitively or for pleasure It is strongly recommended that your Supra dealer be notified before changing the propeller In general changing to a lower pitched propeller may increase acceleration but will decrease top speed Changing to a higher pitched propeller may achieve higher top speed with a light load while acceleration and power may decrease Propeller Precaution A moving propeller will cause injury E Some Supra models offer Double Up Seating This unique skiers or swimmers are in the water seating can be stored flat for easy access to the bow or flipped near the ski platform up
56. nobs of the rear feet 3 While standing in the bow area pull the cage forward gently placing it against the bow of the boat N CAUTION Place padding between the cage and the boat to protect the gel coat finish from scratches To Raise The Cage Lift and rock the tower back into place until the rear legs align with the rear feet Some manipulation of the cage may be required to get the legs to line up with the feet Install both bolts and tighten all bolts N CAUTION The threads in the aluminum foot could be damaged if the bolts are not aligned and threaded correctly N WARNING Rad A Cages are designed to pull one wakeboarder kneeboarder or trick skier 2002 Skier s Choice Inc Pole Light Receptacle The pole light receptacle is located on the starboard of the stern along side of the sun deck To install pole light slide open the weather cover and insert the pole light in the aligned position Pole Light On some models the removable pole light is stored on the side wall of the rear storage area Gently pull the pole light from the mounting and place into the pole light receptacle The pole light must always be in place and illuminated when visibility is limited The pole light must be displayed while underway from sunset to sunrise Boats equipped with factory installed towers the 360 White Pole Light is mounted on the tower To raise the light turn knob on front of light to
57. ntervals Temperature Gauge The tachometer registers the operating speed of the motor s shaft output and may be used as an alternative to speedometer if weight and water conditions permit DO NOT exceed the recommended RPM during break in and normal operation of your motor Exceeding the manufacturer s suggested RPM may cause damage to the engine EA SUPRA The temperature gauge indicates the engine coolant temperature while the coolant is circulating inside the engine Engine operating temperatures will vary depending on the weather conditions and engine load Normal operating temp range is between 160 degrees and 180 degrees NOTICE Refer to your Engine Owners Manual for additional details CAUTION Damage from overheating an engine IS NOT warrantable 2002 Skier s Choice Inc Fuel Gauge Voltmeter This gauge indicates the approximate quantity of fuel remaining in the tank when the ignition is in the position NOTICE DO NOT run the tank to empty To prevent condensation from forming in the tank it is recommended that the tank be filled when the gauge indicates 1 4 tank of fuel remaining The following conditions may be considered normal operation of the fuel gauge and fuel system Gas station pumps may shut off before the fuel gauge indicates FULL The amount of fuel required for fill up may not exactly correspond to the gauge The gauge needle may not move away from FULL u
58. ntil some time after fill up The gauge needle may move during turns stops and acceleration NOTICE Become familiar with engine hourly fuel consumption at various speeds and know when to check the fuel gauge Speedometer Paddle Wheel The Speedometer pickup is a paddle wheel located on the bottom of the boat Poor water conditions may cause the wheel to become clogged or give incorrect information 2002 Skier s Choice Inc The voltmeter indicates whether the battery is charging or discharging The needle should be located in the normal range while the engine is running If the voltmeter does not register in the normal range there may be a problem within the electrical system It is normal for the voltmeter needle to fall when starting the engine Normal range is 12 to 14 volts Oil Pressure Gauge The oil pressure gauge indicates the oil pressure in the engine while the engine is running If the oil pressure remains below the normal range of 20 to 40 psi stop the engine immediately If engine is allowed to run while oil pressure is too low permanent engine damage may occur CAUTION Running the engine with low oil pressure may cause severe engine damage ERX SUPRA Depth Sounder General Description The depth finder will read to 199 ft or the corresponding number of meters or fathoms If the reading is less than 19 9 ft meters or fathoms 1 10th increments will be displayed I
59. ntilation with spark less power blower ABYC approved Electric Horn sound warning device USCG approved inland lighting Federal law also requires at least a Type or Personal Flotation Device PFD for each person on board or being towed on water skis or other recreational equipment In addition one throwable Type IV PFD must also be on board As the owner obtaining the appropriate PFDs is your responsibility Your Supra dealer can and will be happy to assist you NOTE Requirements for coastal waters and inland waters differ Check with the local authorities for more information A responsible owner will avoid potential problems on an outing by having additional equipment on board Normally this equipment is dependent on the body of water and the length of the trip We suggest the following as a minimum Your Supra dealer can also assist you with additional recommendations An anchor with at least 75 feet of line A manual bailing device for removing water Acombination oar boat hook A day and night visual distress signal A first aid kit and manual An airway breathing tube A waterproof flashlight A set of local navigation charts Mooring lines and fenders Extra engine oil A tool kit A portable AM FM radio or weather radio Boating related accidents are generally caused by the operator s failure to follow basic safety rules or written precautions Most accidents can be avoided if the operator is com
60. o lock the wheel into place CN SUPRA The Horn Switch is located on the port dash panel near the ignition Sound the horn by depressing the button Horn Whistle Signals One Long Blast Warning Signal Coming out of slip One Short Blast Pass on my Port Side Two Short Blasts Pass on my Starboard Side Three Short Blasts Engines in Reverse Four or More Blasts Danger Signal 1 OVERTAKING PASSING Boat being passed has the right of way KEEP CLEAR 2 MEETING HEAD ON Keep to the right 3 CROSSING Boat on the right has the right of way slow down and permit him to pass DC Outlet For your convenience a DC outlet has been included in the dash area location varies by model 2002 Skier s Choice Inc Circuit Breaker Panel Courtesy Lights Switch NAV ANC CTSY LTS ACCY BILGE RADIO HORN RECEPT BLOWER EN EN EN a e e e e d 4 y r gt r A NAV ANC CTSY LTS BILGE ACCY 9 4 e e e e y y HORN BLOWER RECEPT RADIO h EN N e e e y d d y O The circuit breaker panel contains breakers for all electrical equipment The panel is located below the dashboard on the side wall nearest the driver s left knee The Courtesy Lights switch supplies power to the interior lights located to the rear of the helm If a switch fails to operate locate the corresponding circuit breaker and press the reset button If the equipment still does NOTICE If
61. o start position to operate starter 4B When the engine starts operate the throttle lever to establish an engine idle of 1200 to 1500 RPM 5B When the engine idle smooths out return the throttle to idle position and the transmission lockout will automatically reengage the transmission in neutral position 6B When ready to get underway shift slowly into forward or reverse allowing the transmission time to engage the gearing before powering up lf Carburetor Engine Still Does Not Start 1C Place shift selector in Neutral with the throttle in the upright zero position and push the transmission lockout button at the bottom of the lever to disengage the transmission 2C With the transmission disengaged move the throttle lever back and forth from one fourth to one third throttle 3C While moving the throttle lever turn the ignition key to Start Position to operate the starter NOTE Do not operate the starter for more than 15 seconds at atime Allow the starter to rest for a full minute before attempting this starting procedure again 4C When the engine starts operate the throttle lever to establish an engine idle of 1200 to 1500 RPM If Carburetor Engine Floods 1D Place shift selector in Neutral with the throttle in the upright zero position and push the transmission lockout button at the bottom of the lever to disengage the transmission 2D Push the throttle lever to the full throttle wide open position 3D Tu
62. ort V are registered trademarks of Skier s Choice Inc All other product names are copyright and registered trademarks trade names of their respective owners 2003 Skier s Choice Inc Wa 2003 Skier s Choice Inc 3 Revised9 27 02 EHJ SUPRA Daily Check List Drain Plugs Securely in place Life Saving Devices One for every person on board Steering System Working smoothly and properly Fuel System Adequate fuel Leaks Fumes Battery Fully charged Cable terminals clean and tight Engine In neutral Capacity Plate Are you overloaded or overpowered Weather Conditions Safe to go out Electrical Equipment Lights horn pump etc Emergency Gear Fire extinguisher bailer paddle anchor amp line signaling device tool kit etc Bilge Pump Working properly I IS I IX I I LR LR I I I NOTE Bilge pump should be checked prior to each use to ensure proper operation Check BEFORE Running where applicable M Engine Oil Level M Transmission Lubricant Level M Engine Drain Plug Transom Drain Plug and Center Drain Plug Leakage Fuel water lines and connections CAUTION DO NOT operate engine without cooling water flowing through water pump otherwise pump will sustain damage and subsequent engine damage may result Check WHILE Running M Oil Pressure Refer to Engine Owner s Manual M Water Temperature 160 degrees to 180 degrees for raw water systems water is not
63. ot water shower is a convenient way to warm wetsuits or wash down your boat It uses water from the lake and water that has been warmed by the engine as its water source The shower nozzle is located in the rear storage trunk The master ON OFF switch for the shower is located next to the shower nozzle The pump is controlled by a pressure switch and will shut off when the pump reaches proper pressure The master switch for the shower should be turned off after each use Cooler Some Supra models offer built in coolers They are foam insulated and have drain holes that drain water into the bilge Be sure to thoroughly clean the cooler and allow it to dry after each use to prevent mold and mldew 2002 Skier s Choice Inc Optional Cocktail Table Some Supra models offer an optional cocktail table To use the cocktail table place the aluminum tube into the receptacle mounted in the floor Place the cocktail table on top of the aluminum tube EX SUPRA Optional Tower Speakers Air Inflator The optional tower speakers are an additional set of soeakers designed to allow the rider to be able to hear the music The tower speakers require the addition of an amplifier to power the speakers CAUTION Some lakes have noise restriction ordinances The use of tower speakers may not be allowed in your area Please check all applicable laws in your area regarding noise level restrictions The Santera model comes standard wi
64. ous injury DANGER This symbol indicates an imminently hazardous situation which if not avoided will result in death or serious injury This is limited to the most extreme situations The precautions listed in this manual and on the boat are not all inclusive If a procedure method tool or part is not specifically recommended by Skier s Choice you must satisfy yourself that it is safe for you and others and that the boat will not be damaged or made unsafe as a result of your decision REMEMBER ALWAYS USE COMMON SENSE WHEN OPERATING SERVICING OR REPAIRING THE BOAT In addition to everyday safety failure to observe safety recommendations may result in severe personal injury or death to you or to others Use caution and common sense when operating your boat Don t take unnecessary chances Be certain that all boat passengers are aware of this information and conform to boat safety principles 2002 Skier s Choice Inc Section Boating Safety Boating Safety Boating Safety starts with a thorough understanding of your equipment and its proper operation In addition to careful review of this manual you should be aware as well that there are many sources of information available Skier s Choice urges you to pursue additional training such as safety and seamanship courses offered by the U S Coast Guard Auxiliary and the U S Power Squadron The following is a listing of just some of the agencies and
65. pletely familiar with the boat its operation and can recognize potentially hazardous situations before an accident occurs EA SUPRA General Safety Precautions Failure to adhere to these precautions may result in severe injury or death to you and or others N WARNING Improper operation is extremely dangerous Operators must read and understand all operating manuals supplied with the boat before operation On board equipment must always conform to the governing federal state and local regulations Children in the bow of the boat should be accompanied by an adult at all times Never stand or allow passengers to stand while the boat is moving You or others may be thrown from the boat Never operate the boat while under the influence of alcohol or other drugs Gasoline vapors can explode Before starting engine open engine box check engine compartment for gasoline vapors and operate blower for at least 4 minutes Run blower below cruising speed Leaking fuel is a fire and explosion hazard Inspect system regularly Examine fuel tanks for leaks or corrosion at least annually Never override or modify the engine safety shut off switch or engine neutral starting safety switch in any way Never remove or modify components of the fuel system in any way except for maintenance by qualified personnel Tampering with fuel components may cause a hazardous condition Never allow any type of spark or open flame on board
66. ply is heard however the vessel should still proceed around the bend with caution If you navigate these type of waters you should carry a portable air horn which are available from local marine supply stores CN SUPRA All vessels which are fishing with nets lines or trawls are considered under International Rules to be fishing vessels Boats with trolling lines are not considered fishing vessels Fishing vessels have the right of way regardless of position These vessels however cannot impede the passage of other vessels in narrow channels Sailing vessels should normally be given the right of way The exceptions to this are When the sailing vessel is overtaking the power driven vessel the power driven vessel has the right of way Sailing vessels should keep clear of any fishing vessel In a narrow channel a sailing vessel should not hamper the safe passage of a power driven vessel which can navigate only in such a channel The waters of the United States are marked for safe navigation by the lateral system of buoyage The markers and buoys you will encounter have an arrangement of shapes colors numbers and lights to show which side of the buoy a boater should pass when navigating ina particular direction The markings on these buoys are oriented from the perspective of being entered from seaward while the boater is going towards the port This means that red buoys are passed on the starboard right side when procee
67. ppen very quickly depending o the size of the batter Optional Subwoofer The optional subwoofer is designed to increase the sound level of the bass notes The 5 channel amplifier powers the subwoofer The bass level can be adjusted on the amplifier Please see stereo amplifier owner s manual for more information Optional CD Changer The optional 10 disk CD changer is mounted to the floor of the boat and is controlled using the stereo controls It can also be controlled by the stereo remote Please see CD changer owner s manual for more information Optional Satellite Radio The optional satellite radio option is designed to give the user music access anywhere they go in North America The system is a 100 channel system which is broken down into different music types such as oldies hard rock easy listening alternative 80 s jazz big bands etc This system does have a minimal subscription fee that must be paid annually to continue service Please see satellite radio owner s manual for more information NOTE Location of satellite antenna may vary EX SUPRA Fuel Precautions N WARNING Sparks while fueling could cause an explosion Before Fueling 1 Turn off engine 2 Turn off all electrical systems 3 Extinguish cigarettes or any open While Fueling 1 Keep fuel hose nozzle in contact with fill pipe to provide grounding 2 Fill tank at a slow rate to avoid spills Fuel Tank Filling
68. protect your boat during storage 1 Remove the center plug from the boat 2 Thoroughly clean the boat inside and out Inspect the hull for any residue or algae growth and remove if required 3 Clean the bilge area thoroughly and operate the bilge pump to remove any water from the bilge hose 4 Remove all seat cushions and open all storage areas to air circulation in the boat interior When thoroughly dry replace cushions and close storage areas 5 Top off fuel tank to prevent any condensation from accumulating in the fuel system Use a commercially available fuel stabilizer to remove water and prevent gumming 6 If the boat is stored on its trailer insure that the boat is properly positioned If possible lift the tongue so that the bow is slightly raised to promote drainage from the center drain hole 7 the canvas cover and secure the straps accordance with cover instructions NOTE During the winter months water is a boat s worst enemy Always store the boat when the interior is completely dry Periodically check on the condition of the stored boat CAUTION Damage due to improper winterization IS NOT covered under your boat s warranty Ga 2002 Skier s Choice Inc 55 SUPRA Hoisting Correct Hoisting If the boat ever needs to be hoisted special attention should be given to the following recommendations Hoist the boat using a horizontal lifting bar only Never attempt to l
69. quate orientation in the general operation of the boat and review all systems and accessories included with the boat The Dealer should deliver a complete owner s manual packet with the boat consisting of Owner s Manual Registration Engine Manual Stereo Manual Supra Warranty and all warranties for separately warranted items aboard the boat The Dealer should review all warranty information with the buyer and assist in filling out warranty cards if necessary The Dealer should insure that any information or obligation from either Skier s Choice Inc or from the dealership is clearly understood by the buyer The Dealer should instruct the buyer in obtaining local service and out of area service for a Supra boat 2002 Skier s Choice Inc 65 Customer Assistance The staff at Skier s Choice Inc is concerned with your complete satisfaction This includes the prompt resolution of any problems that may arise during the warranty period Normally problems encountered may be efficiently and effectively resolved by your Supra Dealer However if a problem cannot be handled by the Dealer or if a solution is not satisfactory to you as an Owner please follow these steps to get the matter resolved STEP ONE Discuss the problem with a member of your Supra Dealer s management staff It is most likely that the problem will be resolved at this level STEP TWO If the Dealer management does not resolve the problem to you
70. r hitch installer before trailering 3 Insert the locking pin into the tongue Lock pin hole is on the side of the tongue CN SUPRA Connecting the Trailer continued 4 When all weight is off the trailer jack pull the jack lock pin and rotate the jack to the horizontal position and re lock the pin 5 Attach the safety cables to the tow vehicle hitch Cross the cables and wrap them around each other once or possibly twice allowing just enough slack to permit tight turns of the vehicle and trailer 6 Plug the trailer lights connector to the vehicle harness 7 Clip the brake lockout cable to the vehicle hitch Trailer Alignment Correct Alignment When pulling the boat onto the trailer be sure that it is centered on the trailer The distance between the boat and the wheel runner board should be equal on both sides 2002 Skier s Choice Inc Unloading Procedure To unload the boat use the following procedure as a guide 1 Make sure that all drain plugs are securely in place 2 Unplug light cord before backing into the water 3 With Bow Eye Hook fastened retract Boat Buddy latch pin by pulling trigger into safety position If latch pin is bound tighten winch to relieve pressure then pull trigger into safety position 4 With Bow Eye Hook fastened back the trailer until the water level is approximately 1 inch below the top of the trailer fenders NOTICE Ramp slopes vary so actual level of
71. r satisfaction please have the problem and all action taken documented by the Dealer then contact the factory Customer Service Representative at Skier s Choice Inc Skier s Choice Inc 5820 Highway 411 South Maryville TN 37801 Tel 865 856 3035 Fax 865 856 3241 Describe the original problem in detail to the Customer Service Representative Be prepared to furnish appropriate documentation and the reasons why service by the Dealer was unsatisfactory If further action is required to resolve the problem the Customer Service Representative will dictate the appropriate action STEP THREE Finally if after following these steps and providing documentation and after obtaining necessary authorization from the Customer Service Representative to take additional action the problem is still not resolved to your satisfaction the President of Skier s Choice Inc will personally review the problem and make a determination concerning final resolution EA SUPRA ETA SUPRA 66 2002 Skier s Choice Inc A Accessory Power Switch Air Inflator Santera B Battery amp Cable Installation Battery Box Battery Specifications Bertha Ballast System Optional Bilge Area Drain Plug Bilge Inspection Plate Bilge Pump Switch Bimini Top Optional Blower Switch Boating Rules Boating Safety Boat Specifications Body Lubrication Bow Eye Bow Light Break In Period Canvas Cover CD Changer Optional Circui
72. recirculated 180 degrees to 200 degrees for closed cooling systems water is recirculated M Idle RPM 650 750 in gear M Maximum Forward RPM See Engine Owner s Manual M Shifting Linkage Forward Neutral and Reverse WARNING Gasoline Vapors Can Explode It is very important to check for fuel spillage or leaks prior to each use of your boat M Check engine compartment for gasoline vapors M Operate blower for 4 minutes Always operate blower below cruising speed NOTE Please refer to your Engine Owner s Manual for maximum RPM and engine break in procedure ETA SUPRA 4 2002 Skier s Choice Inc Important Safety Information Your safety as well as the safety of others with and around you 1 a direct result of how you operate and maintain your boat Read and comprehend this manual Make sure that you understand all the controls and operating instructions before attempting to operate the boat Improper operation is extremely dangerous The basic safety rules are outlined in this section of the manual Additional precautions throughout the manual are noted by the following symbols CAUTION This symbol indicates a potentially hazardous circumstance which if not avoided may result in minor or moderate injury It may also be used to alert against unsafe practices N WARNING This symbol indicates a potentially hazardous situation which if not avoided could result in death or seri
73. rectly positioned on the trailer switch off ignition DO NOT OVER POWER onto trailer or damage may occur to the boat and or the trailer N CAUTION The trailer must be positioned for the correct water depth for loading or you may damage the boat Varying ramp angles require different procedures In general the steeper the ramp the more shallow the trailer should be positioned in the water Your local dealer can help you understand this should you require additional assistance EX SUPRA ETA SUPRA 62 2002 Skier s Choice Inc Supra Limited Warranty Taking care of our product after it becomes yours has always been standard policy at Skier s Choice Inc the proud manufacturer of the Supra line of boats And to further prove our point we offer the following limited warranty TERMS OF WARRANTY During the applicable Warranty Period as defined below Skier s Choice Inc Skier s Choice or the Company warrants to the original retail purchaser the First Owner that the components and parts manufactured by Skier s Choice the Covered Components of each new Skier s Choice boat are free from any defects in material and workmanship under normal use and when operated and maintained according to boat s instructions Normal Use and Operation This Limited Warranty applies to all Covered Components other than the deck hull floor and stringers for a period of one year the One Year Warranty
74. rm before full RPM is possible refer to Table 1 1 Table 1 1 EFl Phased Warm Up TEMPERATURE 103 F 40 C or less TIME RPM LIMIT 3000 RPM 4200 RPM Full RPM 104 to 139 F 41 to 59 C 140 60 C and higher 10 seconds 10 seconds EA 2002 Skier s Choice Inc SUPRA Fuel Precautions INFORMATION Use a gasoline with a minimum octane rating of 89 N WARNING DO NOT use gasoline containing methyl alcohol methanol or ethyl alcohol ethanol Methanol and Ethanol can damage your boat s fuel system N CAUTION Gasoline Stabilizer should be added to the fuel tank when the boat is used infrequently or whenever your boat will not be used for two weeks or more During storage always add Gasoline Stabilizer to reduce gumming or tank sludge Filling the Tank N CAUTION Be especially careful when filling the fuel tank DO NOT over fill the tank Fuel may empty through the fuel vent and damage to finishes could result If fuel is spilled on stripes or decals apply a common bath cleaner nonabrasive and wipe with a damp cloth Rinse the spill area with clean water CN SUPRA Fueling N WARNING Sparks while fueling could cause an explosion Before Fueling 1 Turn off engine 2 Turn off ignition 3 Extinguish cigarettes or any open While Fueling 1 Keep hose nozzle in contact with fill pipe to provide a ground against static sparks 2 Fill
75. rn Ignition Key to operate starter NOTE Do not operate the starter for more than 15 seconds at atime Allow the starter to rest for a full minute before attempting this starting procedure again 4D When the engine starts back off the throttle but allow the engine to idle at 1500 RPM until it smooths out EA SUPRA Throttle Lever The throttle lever controls both the throttle and the transmission The idle position normally vertical is the zero throttle position and the neutral position for the transmission Asafety ring umbrella keeps the lever from being accidentally moved to engage the transmission To place the transmission into gear with your hand placed over the lever ball pull up on the safety ring umbrella and slowly push the lever into forward gear or slowly pull the lever back into reverse gear CAUTION Never shift the lever directly from the neutral vertical position into a speed position To prevent damage to the transmission always allow the transmission time to engage before accelerating the engine Once the transmissions engaged you may accelerate as quickly as you like Transmission Lockout The Transmission Lockout button allows the transmission to be disengaged while giving the throttle full operating range With the lever in the idle position normally vertical push the button located at the bottom of the lever to disengage the transmission The throttle may then be oper
76. rnber Merk mi channel Pass on ede Letter hos no leper sonifioonce ia Led fot and purpose PREFERED CHANNEL PORT Na number band mei prefamed chon is f fh of Tra bugy Letter hae no ated sonics NE hed Tor idanfificatian and COTE Colic ERX SUPRA GWA SUPRA Revised 9 27 02 EHJ 12 2003 Skier s Choice Inc 2003 Skier s Choice Inc Section IV Boat Specifications Santera ton BTE L delara Limr ing Tags Tru Dre eee Bape Dash CO Piya F i ea be Ewatnm Pias R LH n r Carpal _ Duit in mium race Cpricne Hck Zigni Bubraal Corr pater Gai ge hir iri CXGD HP 74 F e dcs Engra Fyrrarr as I Big FELT cit Overall Length w o Platform Overall Length w Platform Overall Length w Trailer Width Beam Draft Weight Boat Only 3 250 Ibs Weight Boat amp Trailer 4 350 Ibs Capacity Passenger 11 Capacity Weight 1 500 Ibs Capacity Fuel 40 gals Engine 320 HP V 8 GWA 13 Revised9 27 02 EH SUPRA Sunsport Bare Cr Tha Flapper Bara Haw 0 BO AMDA Apis Hal Baaarsari CET Vieyin 5 4E ar C
77. sition use two hands to lift and push the front edge of the seat cushion up and back until it is sitting on therear half of the driver s seat cushion To switch to the lower position use two hands to push the Rise R seat cushion forward and down CAUTION Be careful of the articulating hinge Do not place fingers or other objects in the hinge mechanism during use The driver s seat may be adjusted forward or backward by moving the lever below the front of the seat Lever A in the photo Use body pressure to move the seat to the desired position Release the lever then check to feel the seat lock into place CAUTION After adjusting the seat be sure that it has locked into place by pushing forward and backward until it has securely latched DO NOT attempt to adjust the driver s seat while the boat is moving Pulley amp Belt Warning Pulleys and belts can cause severe injury Never open the motor box while the engine is running or while the boat is underway Remember after running the engine is extremely hot and should not be touched or repaired until it has cooled CN SUPRA Inboard Motor Box The motor box encloses the inboard engine and quiets engine noise To open stand on either side of the engine toward the stern seat Grasp the handle and pull up at approximately a 45 degree angle If the engine requires maintenance open the box until it rests open The motor box base is fitted with quick
78. stand on vessel Slow down or change directions briefly and pass behind the other vessel You should always move in such a way that the stand on operator can see what you are doing This rule is called Rule 2 in the International Rules and says In obeying and construing these rules due regard shall be had to all dangers of navigation and collision and to any special circumstances which may render a departure from the above rules necessary in order to avoid immediate danger 2002 Skier s Choice Inc Section III Boating Rules Encountering Other Vessels There are three main situations in which you may encounter other vessels and you must observe the Steering Rules in order to avoid a collision These are Meeting you are approaching another vessel head on Crossing you are traveling across the other vessel s path Overtaking you are passing or being passed by another vessel Using the following illustration in which you are the boat in the center you should give right of way to all vessels shown in the white area In this instance you are the give way vessel All vessels in the shaded area must yield to you as you are the stand on vessel Both you and the meeting vessel must alter course to avoid each other If you are meeting another power vessel head on and you are close enough to run the risk of collision neither of you has the right of way Both of you should alter course to avoid an accident
79. t Breaker Panels Coast Guard Regulations Cockpit Cover Optional Cocktail Table Optional Cooler Cooling Systems Courtesy Lights Customer Assistance D Daily Check List DC Outlet Dealer s Responsibilities Depth Finder Double Up Seating Driver s Seat E EFI Phased Warm Up Engine Data Engine Hours and Gauge F Fiberglass Care Filling Fuel Tank Fire Extinguisher Foreign Material Deposits Fuel Fuel Cap Key Fuel Filter Fuel Gauge Fuel Information Fuel Precautions Fuel Tank Fuel Vent 2002 Skier s Choice Inc 29 37 Section XV Index G Glove Box 41 H Hoisting 56 Horn 28 Hull Identification Number 57 Hull Protection 54 Ignition 28 Ignition Key 33 Introduction 3 Instrument Panel amp Controls 23 K Kill Switch Optional 45 L Lifting Rings 38 M Maintenance Chart 48 Maximum Capacities 18 Mirror 33 Motor Box Inboard 34 N Navigation Lights 2 Neutral Lock Out 20 O Oil Dipstick 49 Oil amp Filter 49 Oil Level Check 49 Oil Pressure and Gauge 25 Operating Information 17 Pefect Pass Cruise Control Optional 41 Pole Light 37 Pole Light Receptacle 37 Propeller 40 Propeller Precaution 40 R Rad A Cage 36 Rear Drain Plug 21 Rub Rail 53 Continued Next Page EX SUPRA Index continued 5 Safety Equipment Satellite Radio Optional Seat Adjustment Service amp Maintenance Shaft Log Packing Nut Shower Optional Ski Locker Ski Platform Ski Platform Detacha
80. th an air inflator It is a high volume low pressure pump designed specifically for tubes air mattresses etc To use the pump pull the unit out of its storage compartment located to the rear of the walk Optional Wakeboard Racks through area and plug the cord into the 12 volt receptacle Connect the hose of the inflator to air input on inflatable object and turn on N CAUTION DO NOT leave air inflator running unattended Wakeboard racks are a convenient way to transport and store wakeboards while using your boat N CAUTION Check tightness of all mounting hardware before each use N CAUTION DO NOT trailer the boat with wakebords mounted in the racks CSS SUPRA 44 2002 Skier s Choice Inc Optional Kill Switch The optional kill switch is located by the throttle The lanyard must be in place for the engine to start and the lanyard must be attached to the driver The engine will shut off if the lanyard clip is detached from the kill switch Optional Water Strainer The optional water strainer is mounted in the bilge and designed to keep debris out of the engine The clear bowl should be checked before each use To remove debris unscrew the clear bowl and empty out the debris When reassembling be sure the rubber gasket and the screen are seated properly Optional Walk Through Curtain Some Supra models offer an optional Walk through curtain that snaps into the front walk through to help prevent cool air
81. th setting is read by the depth sounder the will flash on the LCD and the audible alarm will sound rapidly When the deep depth setting is read by the depth sounder the DP will flash on the LCD and the audible alarm will sound at 2 beeps per second CN SUPRA NOTE To fully deactivate an alarm reset it to zero Pressing the ON OFF MODE keypad temporarily deactivates the alarm To reactivate the alarm press the ON OFF MODE keypad until the depth reading appears 3 Keel Offset Pressing the ON OFF keypad again displays the KL keel offset setting This can be set so that the depth sounder either shows the depth below the keel or the depth below the transducer Press the up or down arrow keypads to adjust the reading to the desired depth no more than 19 9 ft For example if the bottom of the keel is 2 ft below the transducer and you want the depth sounder to read the depth below the keel the display should be adjusted to read 2 0 ft NOTE Once a keel offset is programmed the shallow and deep alarms will be activated by the depth below the keel 4 Units Pressing the ON OFF MODE keypad again displays Un on the LCD indicating the units mode Press either the up or down arrow keypads to set the units desired to feet FT meters M or fathoms F These units once set will remain the same for all modes Pressing the ON OFF MODE keypad again returns the depth sounder to nor
82. tion needed for processing a claim includes 1 Name and address of the owner 2 Serial number of the boat 3 Original retail purchase date 4 Detailed explanation of the defect and 5 Estimated repair cost 2002 Skier s Choice Inc Section XIV Supra Warranty Note Warranty repair or replacement cannot be made until this information is approved by Skier s Choice In case of defect of a Covered Component Skier s Choice will use its reasonable best efforts to repair or replace the Covered Component within ninety 90 days of receipt thereof at its factory or an Authorized Supra Facility Any warranty on replaced or repaired components pursuant to this Limited Warranty shall remain in effect only for the remainder of the original Warranty Period The repair or replacement of Covered Components will be made by Skier s Choice without charge to the owner for parts or labor The replacement or repair of the defective part or component as stated in this Limited Warranty shall be the sole remedy of the owner and the sole liability of the Company under this Warranty and any implied warranties There are no express or implied warranties on the parts and components manufactured or sold by Skier s Choice except as set forth in this Limited Warranty EXCLUSIONS Claims or assertions relating to the following are specifically excluded from coverage under this Limited Warranty and Skier s Choice disclaims any liability or
83. turn the throttle to idle position and the transmission lockout will automatically reengage the transmission in neutral position 6 When ready to get underway shift slowly into forward or reverse allowing the transmission time to engage the gearing before powering up To Start Carburetor Engine 1 Place shift selector in Neutral with the throttle in the upright zero position and push the transmission lockout button at the bottom of the lever to disengage the transmission 2 Turn the ignition key to the start position to operate the starter 3 When the engine starts release the key and it will return to the run position 4 With the transmission disengaged push the throttle lever forward to increase the engine idle to 1200 to 1500 RPM 5 When the engine idle smooths out return the throttle to idle position and the transmission lockout will automatically reengage the transmission in neutral position 6 When ready to get underway shift slowly into forward or reverse allowing the transmission time to engage the gearing before powering up QN SQ Revised9 27 02 EHJ SUPRA If Carburetor Engine Does Not Start 1B Place shift selector in Neutral with the throttle in the upright zero position and push the transmission lockout button at the bottom of the lever to disengage the transmission 2B With the transmission disengaged push the throttle lever forward about one fourth to slow run position 3B Turn ignition key t
84. water on trailer may be different NOTE Caution on this page 5 Follow the cold start procedure recommended in this manual 6 After starting the engine remove Bow Eye Hook 7 With engine idling center steering wheel engage transmission and slowly pull throttle into reverse Ease back on the throttle lever until the boat starts to move NOTE DO NOT attempt to use excessive power to free that boat from dry carpet runners Power off of the trailer only when the boat has floated free CAUTION If the trailer is not submerged to the correct depth the bow of the boat could drop when powering off incorrectly possibly damaging the boat NOTE Because your Supra is a direct drive inboard when backing up the stern will have a tendency to drift left or right depending on propeller rotation 2002 Skier s Choice Inc Loading Procedure To load the boat on the trailer position the trailer in the water with approximately 1 inch of the top of the fender showing 1 Set the Boat Buddy for loading by pulling trigger or latch mechanism into set position 2 ldle coast the boat onto the trailer using as little power as possible while keeping it centered between the guide poles 3 Power slowly forward until the bow eye solidly contacts the Boat Buddy and the latch is triggered 4 Winch hook must be attached to bow eye and tightened before trailering DO NOT Power onto the trailer during rough conditions Once cor
85. wner Be sure to read and understand all aspects of Boating Safety and Operation before using your boat If you have any questions your dealer can provide the information you need to have a safe and pleasurable boating experience All information illustrations and specifications in this manual are based on the latest product information available at the time of printing Supra may discontinue models and equipment or change specifications and designs without any notice and without incurring obligation This manual contains information about several Supra models Some information may not apply to your boat since standard and optional equipment may vary from model to model As you read through this manual you will find CAUTION WARNING and DANGER symbols which require special attention Please read them carefully They may tell you how to avoid problems and or endangering yourself your passengers and other boaters PLEASE REVIEW ALL SAFETY INFORMATION CAUTION N WARNING DANGER A maintenance schedule and accessory information are included to assure trouble free operation of your boat Should service problems arise remember that your Supra dealer knows your boat best and is interested in your total satisfaction Thank you for purchasing a Supra boat We hope your ownership results in an enjoyable and rewarding boating experience Be safe and enjoy the fun Trademarks Santera Launch Launch SS Launch SSV Sunsport and Sunsp
86. yl that is easily cleaned It is important to provide for the drying of all upholstery and carpet after each use of the boat Open all storage compartments and slide all removable cushions out about an inch to allow air to circulate behind CAUTION Strong detergents and cleaners may shorten the life of the vinyl PLEASE SEE VINYL MANUFACTURER S RECOMMENDED CARE GUIDE INCLUDED IN YOUR OWNER S MANUAL PACKAGE FAILURE TO FOLLOW CARE GUIDE MAY VOID VINYL WARRANTY Drying Upholstery It is important to provide for the drying of all upholstery and carpet after each use of the boat Open all storage compartments and slide all removable cushions out about an inch to allow air to circulate behind CN SUPRA Foreign Deposits Tree sap bird droppings air borne chemicals petroleum products and other foreign matter may damage the gelcoat surface if not removed promptly See Washing Instructions Boat Hull Protection If your Supra is to remain in the water for an extended period the hull below the water line should be painted with a marine bottom paint Boats left in the water for extended periods of time without bottom paint may experience blilstering or discolorization This type of damage is not covered by your boat s warranty Teakwood Care If teak wood has been installed on your Supra a small amount of maintenance will be required to retain the natural beauty Teak wood should not be varnished Instead teak oil or

Supra Manual 2003

Contents

Download Pdf Manuals

Related Search

Related Contents