NA-DOW Nashbar Lil` Shadow Tandem Trailer
Contents
1. Shadow is intended to be pulled behind pedal powered bicycles only Never pull a tandem trailer with any motorized vehicle as the increased acceleration and speed may damage the tandem trailer or cause the tandem trailer to crash possibly causing injury Avoid Riding in Traffic It is recommended that you do not use the Lil Shadow tandem trailer while riding in traffic If you must ride in traffic do not pull your tandem trailer on highways busy streets or on streets unsafe for bicycling with children Never assume that you will be given the right of way even if it is legally yours The personal safety of you and your child should not be entrusted to a car driver whose attention or regard for bicyclists is unknown Use care when pulling your tandem trailer on bike routes or along bike lanes especially at intersections Ride on Clean Paved Surfaces Your Lil Shadow tandem trailer is not intended for off road use Off road cycling with a child can be especially dangerous The irregular surface of off road trails could cause you and your cycling partner to crash possibly resulting in serious injury Always cross railroad tracks grates curb cutouts and road grooves at a 90 degree angle Riding parallel to these road obstacles or crossing them at an angle of less than 90 degrees could result in a crash Riding On Slippery Surfaces Be especially careful in wet rainy icy or adverse conditions Your ability to control and stop your bicy2. build to longer trips as muscle strength and endurance increase ae LilShadowINST 4 23 04 3 42 PM Page 3 P Tip 2 Keep the child s feet on the pedals Your riding partner can t support the weight of the hinge Fully unfold the Lil Shadow s connector arm and push it into the extended you and your bike so they won t need to put a foot down except to get on and off Adults position Insert the quick release assembly though the hole in the hinge and install the should instruct them to keep their feet on the pedals at all times including stop signs and nut onto the end Tighten the nut almost securely then flip the quick release lever to lights This will allow you to get moving quicker and prevent injury and pedal strikes to the fully closed position to achieve proper tension Be sure that the tip of the quick the rear rider release lever is fully closed and positioned in a downward angle There should be no Tip 3 Adjust the child s seat height Since they don t need to put a foot down adjust the play or looseness at the Lil Shadow s folding hinge rear saddle high enough that they get good leg extension at the bottom of the pedal stroke Have someone watch as you practice and make handlebar and pedal adjustments 4 Locate the seatpost and saddle assembly Lightly apply bicycle specific grease the to make the young rider comfortable seatpost to prevent it from seizing inside the frame Insert the seatpost into the Lil
3. through the hole on the end of the connector arm Re install the nut onto the end of Tools needed the quick release assembly Tighten the nut almost securely then flip the quick release 6mm allen wrench lever to the fully closed position to achieve proper tension The hitch assembly s hinge 5mm allen wrench tension must be set securely enough to be safe but not so tight that the hinge cannot 15mm pedal wrench pivot sideways Be sure that the quick release lever is positioned in a downward position Bicycle grease Locked Quick Release 1 Remove the seatpost and saddle assembly from the box Carefully cut the plastic zip Unlocked ties securing the handlebar assembly to the frame Remove the Lil Shadow s frame Quick Release assembly from the box Remove any other accessories and smaller boxes from the main box and set them aside There may be packing materials or accessories in the bottom of the main box be sure to check for parts and accessories before discarding any packing materials 2 Tear the protective material off the frame Do not use a sharp instrument to remove the packing material as this may damage the paint surface Remove the plastic axle pro tectors from the rear wheel s axle 3 Locate the main folding hinge on the Lil Shadow s connector arm Unthread the nut from the quick release assembly and remove the entire quick release assembly from 4 5 a
4. LilShadowINST 4 23 04 3 42 PM Page 1 10 Assemble the safety flag by connecting the two halves of the flagpole and inserting it into the flag Then insert the end of the flagpole into the flagpole holder located on the left side of the frame near the wheel s hub Be sure all reflectors are securely attached and fully visible 11 Install the fender on the Lil Shadow s frame to reduce possible water spray from the adult bike s rear wheel 12 To attach the Lil Shadow to an adult sized bicycle remove the seatpost from the adult bike Slide the seatpost through the hitch assembly of the Lil Shadow Use an included shim of the appropriate size to achieve the correct fit between the adult bike s seatpost and the hitch assembly of the Lil Shadow Tighten the two 5mm pinch bolts so the Lil Shadow s hitch assembly is securely attached to the adult bike s seatpost 13 Always check entire the adult bike and the entire Nashbar Lil Shadow for safety before each use Carefully check all bolts brackets quick release connectors reflec tors tires etc Check all pivots for correct function Check the adult bike s brakes for proper function before and after attaching the Lil Shadow 14 Ride carefully and enjoy your Nashbar Lil Shadow Made in China www nashbar com NA DOW V1 April 2004 For technical support call 1 800 888 2710 M F 9am 6pm EST Bike Nashbar 6103 Rt 446 Canfield OH 44406 d
5. Tip 4 Keep them well hydrated and fed Frequent snack breaks and lots of fluid may Shadow s seat tube and tighten the quick release seatpost binder Adjust the seatpost be required to keep your riding partner in good spirits especially if it is hot height and seat angle to the position that will best fit the child Tip 5 Be positive enthusiastic and patient Set goals but don t push too hard to reach them And above all SAFETY FIRST 5 Locate the handlebar and handlebar bracket assembly Remove the two 6mm allen bolts on the bottom of the handlebar bracket Install the handlebar and handlebar Safety Checklist bracket onto the area of the Lil Snadow s connector arm where the scuff resistant Before every ride check the following material has been positioned The scuff resistant material helps to ensure a secure e Wheel securely attached interface between the handlebar bracket and the Lil Shadow frame Be sure that the e Hitch securely attached handlebar is straight and parallel to the ground Maximum load 75 lbs Tighten the two 6mm allen bolts to securely affix the handlebar bracket onto the frame e Adult bicycle brakes and tires in good condition and operating properly of the Lil Shadow e Helmets for both riders Safety flag and reflectors in place 6 Adjust the tilt angle of the handlebar by loosening the 5mm pinch bolt on top of the Quick releases at folding hinge hitch attachment and seatpost clamp fastene
6. cle when towing anything is greatly impaired In wet conditions gently apply your brakes periodically to be sure the brake pads and braking surfaces are clear of water Avoid forceful braking which can result in skidding Ride slowly and allow a greater margin of safety for starting stopping and turning Do not ride on surfaces where sand gravel ice oil or other slippery substances are present If you must cross a slippery sur face walk your bike and tandem trailer Navigating Curbs Stairs and Escalators Never ride your Lil Shadow tandem trailer over curbs or stairs Both riders should always dismount and walk over any curbs If you must traverse stairs disconnect the tandem trailer from the adult bike and carefully roll your tandem trailer and bike separately up or down the stairs Never take your bike or tandem trailer on escalators 2 Avoid Riding at Night It is not recommended that you use the Nashbar Lil Shadow Tandem Trailer at night Since your vehicle is longer and heavier you will be less able to react to unseen hazards Automobile drivers may not be accustomed to your longer vehicle and may not react to it appropriately If you must ride at night wear bright reflective clothing Use a bright head light and a red taillight on your bicycle and on the tandem trailer Do not use your tandem trailer without properly attached reflectors safety flags and adequate lighting Check your local laws regarding bicycle lighting a
7. d securely handlebar bracket Be sure to tighten the 5mm bolt securely after the handlebar posi e Check tire inflation pressure on Adult bike and Lil Shadow tion that will best fit the child has been achieved Check to be sure that the handlebar Tires should be inflated to the range indicated by the manufacturer on the sidewall of the tires grips are installed securely on the handlebars Monthly Checklist 7 Install the Velcro handlebar pad onto the top tube of the handlebar On a monthly basis check the following e Inspect hitch assembly and all pivot points for damage scratches or loose fasteners 8 Lightly apply bicycle specific grease to the threads of the pedals to prevent them from seizing Inspect frame tubing and hardware for cracks damage or loose parts Install the pedals into the crankarms using a 15mm pedal wrench Note that left bicycle e Inspect tires for wear or cracks worn tires should be replaced pedal is reverse threaded Be sure you install the left pedal into the left crankarm and e Inspect wheels for trueness and rims for cracks or other damage the right pedal into the right crankarm e Inspect chain for wear and apply bicycle chain lubricant 9 To install the hitch attachment assembly onto the end of the Lil Shadow s connector arm unthread the nut from the quick release skewer and remove the entire quick release ASSEMBLY assembly Insert the quick release assembly though the hole in the hitch assembly and then
8. e to motorists and other cyclists Always use the safety flag Follow the Rules of the Road Bicycles are vehicles and are required to observe all rules of the road Always signal turns and stops ride with both hands on the handlebars except when signaling Scan ahead for dangerous situations and anticipate turning traffic Watch for parked cars and opening car doors Obey all signals and never ride against oncoming traffic On bike paths give audible warning when passing pedestrians from behind If you are not aware of your local and state bicycle regulations contact your local police or motor vehicle office for more information Know Your Trailer Hitch Familiarize yourself with the Nashbar Lil Shadow hitch operation After you attach the hitch assembly securely to the bicycle check for correct attachment and function each time you use the tandem trailer See the Assembly section of this manual for details on proper installation and use of the hitch Keeping it Fun Getting the most from your Lil Shadow An outing with your child and the Lil Shadow can be a rewarding experience for both adult and child here are some tips to make sure everyone has a fun safe and positive experience Tip 1 Keep the first trips short As you are becoming accustomed to the added weight of pulling a tandem trailer your young riding partner is also experiencing fatigue Keep in mind the length of your ride and try to stick to shorter routes Then
9. hbar Lil Shadow Tandem Trailer Thank you for purchasing the Nashbar Lil Shadow This instruction manual contains impor tant information about your Lil Shadow s features and guidelines for its safe use Please read the entire manual carefully before assembling or using your new Lil Shadow Tandem Trailer If you require assistance contact Nashbar Tech Support at 800 888 2710 9am 10pm M F 12 6pm Sat Sun EST IT IS THE USER S RESPONSIBILITY TO ENSURE THE SAFE AND PROPER USE OF THIS PRODUCT Bicycling with a tandem trailer and bicycling in general can be hazardous Failure to observe these Safety Guidelines could result in an accident serious injury or death Safety Guidelines The maximum weight for the Nashbar Lil Shadow Tandem Trailer is 75 pounds The Lil Shadow is recommended for children ages 4 to 8 but only a parent can decide if the Lil Shadow is suitable for their child Check with your pediatrician if you are unsure about your child s ability to use this product safely Bicycling with a tandem trailer is different from bicycling without one in ways which aren t always obvious Using a bicycle to pull anything will substantially impact the handling and stopping of the bicycle Note that starting braking and turning are all affected It is essen tial that you read and understand the following safety guidelines prior to using the trailer The Lil Shadow is not intended for off road use A single
10. kickstand will not support a full sized bike with the Lil Shadow attached Use care when parking your bike and Lil Shadow as they can fall over more easily Before loaning your tandem trailer to others make sure they understand its proper and safe use Use a Well Maintained Bicycle and Tandem Trailer Be sure that the adult sized bicycle used to pull the Lil Shadow Tandem Trailer is in good work ing order and is equipped with good properly functioning brakes Inspect and maintain your Lil Shadow Tandem Trailer as outlined in this manual Have a qualified bicycle mechanic maintain and inspect your bicycle and Lil Shadow Tandem Trailer if you are not qualified to do so Starting and Stopping The additional weight of the Lil Shadow Tandem Trailer and its rider will require more time to start and stop The additional length of the tandem trailer requires more time when crossing intersecting streets or paths The bicycle and tandem trailer combination is heav ier and less responsive than a single bicycle You must think further ahead to anticipate stops and turns Remember it is the sole responsibility of the adult rider to stop and turn The tandem trailer extends farther behind you than a normal bicycle allow for this differ ence when turning passing pedestrians or approaching obstacles To familiarize yourself with the altered handling characteristics of your bicycle and tandem trailer attach the tan dem trailer to your bike a
11. nd practice in a safe area Do not use your Lil Shadow trailer with a child until you have become accustomed to how it affects your bicycle s handling a LilShadowINST 4 23 04 3 42 PM Page 2 Tips for Safe Riding As with automobile and motorcycle trailers any bicycle tandem trailer can tip over To avoid injury avoid potholes and do not pull your tandem trailer over curbs or other obstructions in the road Instruct children riding on the tandem trailer not to bounce rock or lean such weight shifts may cause the tandem trailer to tilt or flip Do not turn sharply or at high speed when pulling the trailer Always corner with caution at 5 mph or less Do not under any circumstances exceed 20mph high speeds adversely affect your ability to control the bicycle and to notice obstacles The Fit Alert Adult Pilot To safely pull a Lil Shadow tandem trailer you must be a fit experienced adult cyclist not under the influence of alcohol or drugs You must be alert and have good eyesight and hearing You must also have adequate strength in your legs arms and hands Never allow a child or adolescent to pull the tandem trailer because it is likely that they lack the necessary physical ability and proper judgment No Headphones or Other Distraction Do not bicycle with headphones radios or other distractions You must be able to hear surrounding traffic and concentrate on safe bicycling at all times No Motorized Vehicles Your Nashbar Lil
12. nd the use of bicycles at night Considerations for Cool Weather Use In temperatures below 70 degrees your pedaling effort may keep you warm but your child s smaller size coupled with a potential wind chill factor may result in them requiring additional clothing In cool weather check at regular intervals to ensure your cycling part ner is sufficiently warm Wear Your Helmets Numerous studies have demonstrated that head injuries sustained in a crash are the lead ing cause of bicycling fatalities and that helmets can prevent or reduce head injuries in the event of a crash For safety it is essential that all cyclists wear approved bicycling helmets at all times Many states and communities have laws requiring the use of bicycle helmets particularly for children under the age of 16 Check your local bicycle helmet laws Protect Your Child Make sure the child riding the Nashbar Lil Shadow uses a correctly fitted Consumer Product Safety Commission approved child s cycling helmet at all times Consider provid ing other protective gear to your child such as cycling glasses and gloves You and your child should always wear fully enclosed sneakers or cycling shoes when using the Lil Shadow Tandem Trailer Be aware that children will get thirsty and hungry when riding on tandem trailers Bring plenty of food and water especially on longer rides Use Your Flag The safety flag is an essential safety device which makes you more visibl
Download Pdf Manuals
Related Search