Millersville University Enhanced AV Classroom Specification
Contents
1. Spectrum Link Interior floor of lectern 4 Oo 9 9 Audience Side Front of Interconnect Plate M 190F Power Supply Top view Inside Link floor Back side of 3Com Device Presenter 3Com Y Power Supply Audience Side Front Link Cabinet Interconnect Plate m connector Interconnect Plate Back side Presenter Side Front Audience Side Ko Interconnect Plate Front Audience Side Presenter Side Rear View Rear Presenter Side Lectern Floor Wall Interface Plate 1 Shown with engraving and Colorized ID rings Grn Wht Wall Interface Plate 2 Populated with Neutrik Speakon and Neutrik 6 pin XLR connectors Speakers Projector SITES SAS XOT XE gt E Fender Washer C Green Blue Red qmm 285 e Horz Vert Red Wht Grn Wht Blu Wht Eye bolt 5 16 diameter HR 6 Plenum HR 2 Plenum Wh STP 20 Plenum Plenum Wiring Inside the Wall Control amp Speak On Connector Wall Plate2. A aa Al 22 128 02 MHR 6 Series RGBHV 8 Video Red Red Red BEN BNC 22 128 02 MHR 6 Series RGBHV amp Video 22 098 02 RG6 p up p WN A RS EEE CEE EEE 22 161 03 STP 20 Dual Red RS282Tx_ NC6MEZBPini NC6MEZBPint 22 161 03 STP 20 Dual Back RS232Rx NC6MEZBPin2 NC6MEZBPin2 22 161 03 STP 20 Dual Dan RS 32Grd NC6MEZBPing NC6MEZ BPin3 22 161 03 STP 20 Dual Green Spare NC6MEZBPin4 NC6MEZBPin4 22 161 03 STP 20 Dual White Spare NC6MEZBPin5 X NCGMEZBPin5 22 161 03 STP 20 Dual Dal TSP NCEA Ein NOBMEZBIFING E 5 WEE AAA A Beldon 8473 22 151 03 NLTAFX Pin 1 NLTAFX Pin 1 Red Beldon 8473 22 151 03 NLT4FX Pin 2 NLT4FX Pin 2 Beldon 8473 22 151 03 Red Audios NLT4FXPin3 NLT4FX Pin 3 Beldon 8473 22 151 03 Back Auger NLI4FxPINn4 NLI4FXPIn4 5 5 EEEN HRS Patch Prewired 5688 Green Network RJ 45 RJ 46 EE DEE EEN EEE EEE Crimp Thimble amp Snap Crimp Thimble amp Snap hook Hook or Gripple or Gripple Thimble amp Snap 1 8 Steel cable Tether Thimble amp Snap Hook hook DE KEES Outlets 1 P Item Power supply Gateway CPU GTCO Panel Monitor X Document Camera Cable Cubby DVD VCR Extron 5IP 3 Com device X Extron 190F X Notes Allow power supply to float Secure to lectren floor via 3M fastener Secure to lectren floor via 3M fastener
3. a BNC Connector Wall plate Red Red Green 4 Green Blue 4 Blue Yellow Yellow Black Black White Blue White Video Yellow C S Video it Red White Y S Video Green White Yellow MHR 2 Whit e Tether Cables 8 CATV a Network Patch Cable XLR XLR 2 XLR 3 XLR 4 XLR 5 Grd Drain XLR 6 Red Speak On 1 Black Speak On 2 Speak On 3 Red Tx Black Rx STP 20 Dual Grd Drain A Speak On 4 T Belden 8473 Umbilical Cord Umbilical Cord Expandable Sleeve Inside Link Connections BNC Connector Plate Cabinet i Red Green 4 Gas MHR 6 Blue Blue Yellow Yellow Umbilical Cord Black gt T E i 5 IP Expandable Sleeve Black o Extron White Blue White Video MHR 2 Yellow Green White C S Video To VCR Red White Y paz Tether Cables White S Video RF Connector CATV F feed through CATV To 3 Com Network NJ 220 Color Green Bog TX XLR 1 Black Rx To Extron 5 IP STP 20 Dual XLR 2 Grd Drain RS 232 Control XLR 3 XLR 4 XLR 5 Spare XLR 6 ES Speak On 1 Belden 8473 Speak On 2 To Extron 5 IP Speak On 3 Speaker Control Speak On 4 Control amp Speak On Connector Wall Plate Network Patch Cable igtdisrtiddrtua ttit
4. HR BNC Strain Reliefs Pg 488 Extron 2005 catalog 119 B 67 LT4FX eutrik Speakon cable end Markertek Video Supply U 7 16 RD Color Coded Wall ID Ring Color Red Markertek Video Supply TecNec U 7 16 BE Color Coded Wall ID Ring Color Blue Markertek Video Supply TecNec U 7 16 YW Color Coded Wall ID Ring Color Yellow Markertek Video Supply TecNec U 7 16 GN Color Coded Wall ID Ring Color Green Markertek Video Supply TecNec U 7 16 WE Color Coded Wall ID Ring Color White Markertek Video Supply TecNec U 7 16 Color Coded Wall ID Ring Color Black Markertek Video Supply TecNec 1 2 2 2 2 1 1 2 2 1 1 1 4 4 4 2 2 2 2 2 2 2 2 2 mbi 1 2 100 186 01 BNC Male MHR Compression connectors Bea Allied Electronics Pg 417 2005 Catalog A TY Grip fastner Fol 300 50 0 Thomas amp Betts gt KS AAA MR EEN 89 1 IU 7 16GN Joiortogdegd Wall ID Ring Color Green JMarkertek Video Supply TecNec 90 3 U 716WE Color Coded Wall ID Ring Color White Markertek Video Supply TecNec 1U 7 16 Color Coded Wall ID Ring Color Black Markertek Video Supply TecNec Canare BNC Female to BNC Female Chassis Mount 92 BCJ JR Connector TecNec 93 PP Chief Projector mounts 94 6 WBL Control 24 Speakers po I el Termination guide for umbilical cord Cable color Stran relief color Connector wall Connector Lectern S video Y 22 123 03 Mini HR 2 White Luminance BNC BNC video
5. MILLERSVILLE UNIVERSITY Millersville University Enhanced AV Classroom Specification Tony Jackson April 18 2006 Version 5 01 Millersville University Enhanced AV Classroom Specification The vendor shall follow all applicable National Electrical Codes State and County codes and local ordinances It is the vendor s responsibility to obtain the necessary permits The Data Video projector and AV lectern system must share the same electrical circuit or if this is not possible be on circuits of the leg at the electrical panel The vendor shall install only Plenum rated wire and cable inside of Millersville University building walls and ceilings The vendor shall terminate all of their plenum coax BNC compression connectors With respect to building wiring the vendor shall use the following wire cable electrical components and physical components or their electrical and physical equivalents Number Vendor Vendor Suggested of Part Description Vendor Where to Install Cables Number Manufacturer For use inside walls or ceilings One pair run from designated wall plate location to designated Smart 1 22 159 03 STP 20 Plenum Extron Board location for RS 232 control For use inside walls or ceilings One pair run from designated wall plate location to designated projector 1 22 159 03 STP 20 Plenum Extron location For use inside walls or ceilings One pair run from designated wall plate location to designated pr
6. The vendor shall certify that all ceiling speakers are tethered to an appropriate fixed ceiling structure Drop ceiling components are not acceptable as fixed structures The vendor will certify that the all the network connections are functioning CAT 5E specification The vendor will certify that the sound is evenly distributed by injecting an audio sweep generator signal operating between 20 Hz to 20 kHz into the system amplifier and measure the SPL in db throughout the room SPL levels shall not vary more than 2 db from speaker to speaker All speakers should reproduce sound of equal timbre Projection System Projector mounting systems shall be physically attached to the building via anchors driven into the cement or bolted to ceiling struts etc Drop ceiling components are not acceptable as fixed structures The data projector should power up and down via a button presses from either the lectern desktop key pad or the System 5 IP front panel The vendor shall inject a Crosshatch signal into the projection system preferably through the Guest Computer port the projector image of that signal shall be free of geometric distortion including keystone issues centering issues focus issues brightness amp contrast issues and clock phase and timing issues The image shall not overshoot the projection screen The projector should respond quickly to input changes via the lectern desktop and the System 5 front panel The RS 232 connectio
7. alog Computer interface Extron 2005 catalog AAA 60 496 02 U 0 496 02 SCP 150 AAP Black 4 gang Pg 204 Extron 2005 catalog Option A or B o 0 220 02 RCM DV Dual function IR control module Black _ Pg 135 Extron 2005 catalog DU Blank Panel Color Back Pg 110 Middle Atlantic 2005catalog B4 Ja Blank Panel Color Back Pg 110 Middle Atlantic 2005catalog FASHAAanfacurr Name amp Model OVONOR rack mount adapter Pg 98 Middle amic 2005 catalog kein RSH4A Manfacturer Name amp Model DVD VCR rack mount adapter Pg 98 Middle Atlantic 2005 catalog Device INLT4FP JNettrk Speakon Chassis mount connector Markertek Video Supply a U 7 16 BE Canare BNC Female to BNC Female Chassis Mount BCJ JR Connector TecNec 1U 7 16 RD Color Coded Wall ID Ring Color Red Markertek Video Supply TecNec MP 3541 42 3M Dual Lock MP 3541 42 EE E Female Bulkhead Connector Markertek Video Supply TecNec o 26 533 12 SY VGAM RGBHVM 3 7 0 91 m MPSRA MPSRA TO Stereo Cable 3 5RA 3 5RA 10 FT EX vender made BNC male to BNC male NGO 2635504 S Video SVHS Male BNC Male 6 6 7 8 9 26 529 02 Mini 59 SuperFle Pg 518 Extron 2005 catalog 5IP to Link plate 40 Cat 6 UTP RJ 45 to RJ 46 Stranded 598B Color 42 1 Green Anixter Comprehensive Wall to Switch UTP RJ 45 to RJ 46 568B H m 45 Anixter Comprehensive 5IP to 3Com NE Steunen i Wire cable Speaker to link pla
8. astkiitttii 568B Configuration X us gt Gateway E series CPU _ RNA LALALA RENAL ELLAS Extron BIP Gateway has 2 USB ports Gateway E series CPU GTCO Panel Strain Reliefs S Luminance Cable Color RED WHITE Video Cable Color BLUE WHITE S Chrominance Cable Color GREEN WHITE a a Umbilical cord lear Heat shrink CN Pad O 2 ES Ka x Hem Qty Partnumber 2 Description Findwhere Notes 1 55122 IDHD Special Less Privacy surround with Cubby cutout Spectrum Furniture 2 1 j 13D o J ieelbange Spectrum Fumiture TI 5140D JFlipupDocumentTaskShef SpecrumFumitre 5141 Custom Cut Door Logo jSpecrumFumitre 7502 GTCOMonior A OOOO CNJ220 CRM Ethernet 3 Com Intellijack NJ 220 Network switch CNJPSL US 3 Com Power Supply US O DVD VCR Combo Player Recorder AAA EN Pg 193 Extron 2005 catalog Po Ie A mi 7 0 397 02 Switcher w Front Panel Control amp Amp Pg 193 Extron 2005 catalog 1 BAR12ULRA 2 Qutlet Rackmount Surge Suppressor www alliedelec com 0 486 61 niversal An
9. deo with strain relief s as depicted in the drawing tilted Umbilical cord Color Codes Additionally the vendor shall install white heat shrink tubing per the schedule shown in the system drawings and the section titled Umbilical Cord Construction The vendor shall dress all the coax cable with strain relief s The vendor will dress signal bearing wire or cable away from AC power cords The vendor shall not over tighten nylon wire wrap used to secure wiring within the lectern cabinet If nylon tye wraps are used the seize tension of the tye wrap shall be so great as to inhibit the tye wrap from being rotated about the wire bundle that it secures The vendor shall not bundle by use of electrical tape or tie wrap any cable or wiring to be inside the expandable sleeve also known as the Umbilical cord The Umbilical cord shall be dressed through pre cut opening in the bottom of the lectern cabinet Additionally the main power cord shall be dressed through the same opening The vender shall use 3M Dual Lock Fastening system or its equivalent to affix all power supplies and other modules to the floor of the lectern Velco fastening systems consisting of felt are not acceptable Cable Cubby The cable cubby will have three cables that can be pulled from the user compartment The vendor must provide management that assists the return of these cables to the cubby compartment Umbilical cord construction Umbilical cord const
10. esignation filled with white paint The plates shall be configured as shown in the AV Smart Classroom Drawings Wall Interface Plate 1 and Wall Interface Plate 2 The Speaker and RS 232 cable connectors shall be a Neutrik Speak On Connector and a Neutrik 6 Pin XLR chassis connector shall be soldered according the schedule Each wire shall be dressed with Clear heat shrink tubing See the drawing for details about the XLR connector assembly The vendor shall not exceed the manufacturers maximum bend radius for any cable At the projector location The RGBHV coax will be terminated with a HD 15 D style connector Each wire in the connector housing shall be dressed with Clear heat shrink tubing The S Video cables will be terminated with compression BNC connectors and the Video cable will be terminated with either a BNC compression connector or RCA compression connector to match the video input connection on the data projector Internal lectern wiring and service connections to the wall plates The presence of electrical tape is unacceptable in the finished assembly of the lectern or its umbilical cord All solder connections shall be dressed with clear heat shrink tubing With respect to the lectern wiring and the Umbilical cord the interconnect cable that connects the lectern to the building wiring the vendor is urged to use the wire and cable specified in the accompanying list of materials If the vendor chooses to make substitutions those i
11. mber Insert a snap hook through the thimble eye Figure 1 Secure End with TyGrip fastener About 4 inches from end of sleeve Expandable d Expandable Sheath N Sheath E Wat N VA Wall Plate end L AA Fold expandable sleeve into itself 9 inches VI ANG AY M W e Remove the excess slack in the expandable sleeve The sleeve should hug the internal cables within it e Connect one umbilical cable tether to the eyebolt in the wall connect the opposing end to the eye bolt inside the lectern cabinet e The Umbilical cord cables that support Video S luminance S Chrominance signals shall have white heat shrink tubing installed behind the cable strain relief s of the aforementioned cables Please refer to the drawing titled Umbilical cord Color Codes Acceptance Testing Acceptance testing shall be based on the adherence of the aforementioned specifications and vendor craftsmanship The lecterns when assembled shall be free of construction dust and debris All visible surfaces shall clean and free of oils and other manufacturing compounds All indicator lamps must be working All panels should be in place All specified color designations and engraved markings should be clearly visible on the vendor installed wall plates All connections including the CATV network cables and tether cable should be in place All ceiling tiles should be in place and free of construction damage
12. n shall be tested by connecting a serial cable to the 5 IP controller and successfully reading the projector statistics through the 5 IP configuration program Device control The Desktop key pad e Function Room button number 2 shall be programmed to power on and power off lectern DVD VCR combo player when pressed e Function Room button number 4 shall be programmed to eject a DVD disk and or a VHS tape from the DVD VCR combo player when pressed e Shall mimic the functions of the DVD VCR remote control including Play Stop Skip forward Skip backward Fast forward Fast reverse Menu Chapter Track selection Enter Pause Channel selection etc e The sound from these devices should be clear and free of clipping distortion Acceptance is dependent on the successful demonstration of the aforementioned using a DVD disk and a VHS tape Guest Laptop and local CPU A laptop computer shall be connected to the desktop guest VGA Audio and Network cables emanating from the cubby The Ethernet cable Audio cable both USB ports and the AC power outlet are part of the acceptance test The laptop desktop image should be un cropped clear and the output audio should be clear and free of clipping distortion when playing through the speaker system As part of the acceptance test the lectern CPU will be activated the network should accessible Additionally its desktop should appear un cropped and properly centered on the viewing screen Sound fr
13. ojector BNC 6 Mini HR location 1 22 130 02 Plenum Extron For RGBHV and NTSC Video signals For use inside walls or ceilings One pair run from designated wall plate location to designated projector location BNC 2 Mini HR For S Video signals 1 22 129 02 Plenum Extron For use inside walls or ceilings 2 pair of cables run from a designated wall SPK 14 Plenum plate location to designated speaker 2 22 155 03 1 pair 14 AWG Extron location Qty per Suggested Vendor plate Part Description Manufacturer Canare Markertek Color Coded Wall ID Ring Color Video Supply T 1 IU 7 16 RD Red TecNec A Qu CO Color Coded Wall ID Ring Color Canare Markertek peo 1 IU 7 16 BE Blue Video Supply Color Coded Wall ID Ring Color Canare Markertek 1 IU 7 16 YW Yellow Video Supply Color Coded Wall ID Ring Color Canare Markertek 1 IU 7 16 GN Green Video Supply Color Coded Wall ID Ring Color Canare Markertek 3 lU 7 16 WE White Video Supply Color Coded Wall ID Ring Color Canare Markertek 1 IU 7 16 Black Video Supply A a DN e Canare BNC Female to BNC v Zu SCH 8 BCJ JR Female Chassis Mount Connector TecNec BCJ JR BNC male Mini HR Compression 8 100 186 01 connectors Extron The vendor shall fashion amp install 2 interface plates on the wall where their building wiring will be terminated The plates shall be double gang black colored steel or anodized aluminum with engraved d
14. om this device should be clear and undistorted when played through the sound system The desktop USB ports must be functional A USB device shall be inserted into each desktop USB port that device should be recognized by the lectern CPU Documentation The vendor will supply all user manuals in print and CD s containing PDF files for all the equipment in the classroom installation projector lectern etc The vendor will supply on CD all IR and serial drivers protocols software access codes source amp object code used in the install The vendor will supply an AS built on CD of the entire project including a parts list full schematics connector pin outs and related drawings Special Provisions The VHS recorder player must be compatible with VHS tapes recorded at SP Standard Play SLP Super Long Play and LP Long Play Inside wall Ceillng Cord CATV Jack Wall Interface Plates Network Jack Functional Block Document Camera Lectern DVD VCR Player GTCO I Panel Gateway E3400 CPU Block Extron 5 IP Port 5 RBG 190F VGA amp Audio Interface ee lt lt Ee e Link Lectern Top View Presenter Side Rear Cable Cubby Link Co
15. ruction shall consist of Expandable Braided Non Fraying Polyester sleeve Alpha GRP 110NF or equivalent The finished length of the Umbilical Cord shall be 20 feet The cord should be constructed such that it can easily and repeatedly coiled and uncoiled around the cable rungs inside of the Link cabinet without kinking of the cabling inside of the expandable sleeve Inside the sleeve the vender shall install 1 Extron Mini HR 6 RGBHV amp Video or its equivalent 1 Extron Mini HR 2 SVHS Chrominance amp Luminance or its equivalent 1 Extron RG6 HR1 RG 6 CATV or its equivalent 2 SPK 14 1 pair 14 AWG Belden 8473 or its equivalent 1 1 8 vinyl coated steel aircraft cable 1 Cat 6 Network Patch Cables Color Green configured for 568B Termination 1 Extron STP 20 DUAL cable or its equivalent After the above components have been pulled through the expandable sleeve the sleeve shall be terminated as follows e Leave cable tails of about 12 inches for connection to the building and the connection plate inside the Link cabinet wall plates Note The CATV and network cables may be longer to reach their respective connections e The 1 8 inch steel cable should be about 6 inches long after it has been terminated with a thimble and Gripple M e Fold the end of the Expandable sleeve back into itself about nine inches See figure 1 Secure with TY Grip fastener See spec sheet for fastener part nu
16. te Po Lap Bien 9610 5 conductor 24awg cable __ ooo A 48 1 22128 02 MHR 6Series RGBHVE8Video eooo S 49 1 2212803 0 J MHR2Sernes SVHS Top spool 1 22098020 IRGESHRI RG6CATV Pg494Exron2005catlogg 2 Belden 8473 SPK14 1pairl14awg Belden8473 Extron Cumberland Electronics TI Scott Electric Pittsburough Midstates 1 8 Gripple Spiral Philadelphia 1 8 Galvanized Aircraft Cable 7X19 Construction Lowes Home Depot EM Herr etc Eye bolt 1 1 2 to 2 5 16 x 24 owes Home Depot EM Herr etc o L 5 16 Lock nuts Lowes Home Depot EM Herr etc IIA L de gt ajajaja 00 NI OD on o lm oO 16 Fender washer owes Home Depot EM Herr etc Pre Manufacturered by Cat 6 Network Patch Cable Anixster Anixter 2 WN IL 2 mn RS 232 Rx Tx Grd Drain amp 22 161 03 STP 20 DUAL Pg 503 Extron catalog Spare 2 Pg 488 Extron 2005 catalog 2 2 E 2 2 2 2 2 2 2 6 2 gt 6 70 119 01 Pg 488 Extron 2005 catalog 0 per pkg 70 119 02 Pg 488 Extron 2005 catalog 0 per pkg 70 119 03 Pg 488 Extron 2005 catalog 0 per pkg 7 7 o o 0 119 05 lack MHR BNC Strain Reliefs Pg 488 Extron 2005 catalog 0 per pkg NC6MEZ B Neutrik 6 Pin Male Cable connector Markertek Video Supply N Neutri 54 59 64 119 0 119 04 Yellow M
17. tems shall be electrically and physically equivalent The vendor shall provide a support structure for wiring harness inside the lectern cabinet The vendor shall fashion and install an interface plate for the inside of the lectern cabinet This plate will provide termination point for the cabinet end of the Umbilical cord The plate shall be populated as shown in AV Smart Classroom Drawings Link Internal Interface Plate This plate will also provide a mounting point for a3 Com model NJ 220 Intellijack Note that the layout of the connectors clone those shown in AV Smart Classroom Drawings Wall Interface Plate 1 and Wall Interface Plate 2 The connector designations shall be engraved into the plate and filled with white paint The plates shall be black in color The vendor shall use non plenum rated cable for point to point connections inside the lectern and in the construction of the umbilical cord The vendor shall use pre manufactured VGA cables VGA break out cables Network cables and USB cables in the assembly of each lectern The Vendor is encouraged to field terminate all cables and wiring that will make up the umbilical cord which includes RGBHV cable S Video cable Video cable RS 232 cable s speaker cable tether cable CATV cable Additionally the vendor shall terminate control cables IR cables and audio cables internal to the lectern The vendor shall dress all the cable ends of the Mini HR S Video amp Vi
18. untertop 3 8 in N Rear Presenter Side Keyboard Shroud y RSS RRR AC Distribution Extron 5IP Front DVD VCR Gateway Ze DVD VCR Link Internal Interface Plate Flange side of panel should face presenter side of the lectern amp Audience Side Extron part number Cable Cubby 200 60 716 0A Cable Cubby 200 Top plate outer rim 8 000 W x 4 394 D 20 32 cm W x 11 16 cm D Surface cutout inside rim 7 185 0 0325 W x 3 155 20 0325 D 18 25 0 083 cm W x 8 01 0 083 cm D Box under surface 4 000 H x 7 120 W front rear of unit x 2974 D 10 16 cm H x 18 08 cm W x 7 55 cm D Interface Plate 3U Spectrum Link Rack layout Audience side of link Cabinet Front Se em e a JA E g amp e 2 c U Units 1U 1 75 inches Presenter Side Rear View Blank 1U Outlet strip 1U Extron 5IP 1U DVD VCR 2U Shelf 3U lt Blank 3U lt Blank 4U J Presenter Side Rear View 15 Units Extron Surface Mount Box SMB4 N SF A Neb
Download Pdf Manuals
Related Search