IPC-BX720-AC Series
Contents
1.2. 242 W x 262 D x 115 H No protrusion About 5 6kg At the time of the HDD SDD uninstalling 512MB memory module is plugged 2 The interface can connect the PC to a CONTEC Panel Link input type display using an optional cable or an ordinary analog RGB input display using the bundled DVI analog RGB adapter 3 The interface is used for the CONTEC Panel Link or touch panel type display 4 This product contains a high precision RTC 1 minute per month beside the ICH4 integrated RTC You can use the RTC utility to synchronize the ICH4 integrated RTC with the high precision RTC For using the RTC utility refer to IPC SLIB 01 5 If an external device rapidly consumes current immediately after the power is turned on the BOX PC may not work normally even when the supply source capacity is within the specified range 6 The total supply capacity for 5V external devices must be within 3 A Installation Environment Requirements Specification Allowable Less than 20ms Power supply instantaneous specifications Operating 0 50 C Using the SDD 1 temperature 5 45 C Using the HDD 10 90 RH No condensation Corrosive gases _ gases Nop line 2kV Line noise Signal line 1kV IEC61000 4 4Level 3 N61000 4 4Level 3 Static Contact discharge 4kV IEC61000 4 2Level 2 electricity EN61000 4 2Level 2 Siaa Atmospheric discharge 8kV IEC61000 4 2Level 3 EN61000 4 2 Level 3 Vibration 10 57Hz semi amplitude 0 1
3. card 1 2 3 4 S The following sketches illustrate air flows of this product Before installing the product consider the air flows ventilation and installation conditions for its use 7 1 i i F PC HELPE Expansion ae bus adapter i i E i i 1 k 1 i CONTEC www contec com Expansion Slots Distances between the BOX PC and Its Vicinity 50mm or more Side view 50mm or more Side view This product has two PCI bus expansion slots to hold PCI bus aad boards Board Dimensions Allowed 190 00mm Max 100mm or more top view 50mm or more Back view 106 68mm Max Connector part j amp e A CAUTION A board that uses the back of the board edge connector the shaded area in the figure may not be mounted Installation Requirements The BOX PC can be installed in any orientation 1 through 3 Avoid orientation 4 through 6 since it might not adequately dissipate heat Similarly to maintain the ambient temperature within the range specified in the specifications ensure a clearance between the unit and surrounding equipment of at least 100mm for the top and rear and 50mm for the bottom and sides Installation Orientation D A
4. 485 general purpose 1ch SERIAL PORTE inside the RAS connector Baud rate SERIAL1 2 is 115 200bps SERIAL3 6 is 230 400bps LAN1 Ethernet 100BASE TX 10BASE T RJ 45 connector Controller Intel R ICH4 Built into the controller LAN2 Ethernet 1000BASE T 100BASE TX 10BASE T RJ 45 connector Controller Intel R 82541PI IDE Primary Ultra DMA 100 HDD One 2 5 inch IDE HDD or silicon disk drive mounted Primary IDE CONTEC www contec com lt 2 2 gt General purpose 3 opto isolated inputs and outputs purpose 3 opto isolated inputs and outputs 1 0 However one output also serves as an external WDT output and one input also serves as remote reset They become available when switched pe function WDT 1sec 255sec RESET interrupt or external output is allowed at pee lie expiration Remote reset External input signal PCI slot x 2 PCI Rev2 0 compliant slot Usable board dimension 190 00 L x 106 68 H mm Max RTC CMOS Lithium backup battery life 10 years or more The real time clock is accurate within 3 minutes at 25 C per sles ICH4 built in RTC 4 1 minute per month a high precision RTC Power 85 132VAC 170 264VAC 47 63Hz input automatic operation oat supply voltage Current 190VA Max consumption CF card slot 5V 500mA 6 USB I F 5V 2A 500mA x 4 6 Expansion board slot 5V 2A 1A x 2 slot 6 3 3V 2A 1A x 2 slot 5V unsupply 12V 0 5A 12V 80mA
5. 5mm 57 150Hz 2 0G Sweep ee en f sistance 40 min each in x y and z directions JIS C0040 compliant IEC68 2 6 compliant 10G half sine shock for 11 ms in x y and z directions JIS C0041 compliant IEC68 2 27 compliant Class D grounding previous class 3 grounding 1 When Windows OS operates Please consult about operation excluding Windows OS 2 When the HDD is not in use 3 CPU heat sink and the duct opening are excluded List of Options Memory for extension 184 pin DIMM PC MDD512 184A 184 Pin DDR Memory PC2700 512MB PC MDD1G 184A 184 Pin DDR Memory PC2700 1GB Silicon disk drive for extension IDE 2 5inch PC ESD Series Impact resistance 2 PC ESD500 512MB silicon disk drive PC ESD1000 1GB silicon disk drive PC ESD2000 2GB silicon disk drive PC ESD4000 4GB silicon disk drive PC ESD8000 8GB silicon disk drive PC ESD500 A 512MB silicon disk drive PC ESD1000 A PC ESD2000 A PC ESD4000 A PC ESD8000 A 1GB silicon disk drive 2GB silicon disk drive 4GB silicon disk drive 8GB silicon disk drive RP C 5X720 AC a PC ESD Series PC SDD64V 64MB silicon disk drive PC SDD128V 128MB silicon disk drive PC SDD192V 192MB silicon disk drive PC SDD320V 320MB silicon disk drive PC SDD500V 512MB silicon disk drive PC SDD1000V PC SDD2000V 1GB silicon disk drive 2GB silicon disk drive CF Card CF 1GB R 1GB CompactFlash for Fix Disk CF 2GB R 2GB CompactFlash for Fix Disk CF 4GB R 4GB Compact
6. Flash for Fix Disk CF 8GB R 8GB CompactFlash for Fix Disk CF 1GB A 1GB CompactFlash for Fix Disk CF 2GB A 2GB CompactFlash for Fix Disk CF 4GB A 4GB CompactFlash for Fix Disk CF 8GB A 8GB CompactFlash for Fix Disk Terminal block for connecting the RAS connector IPC PSD 20 Terminal block for connecting the RAS connector TFT color liquid crystal display lt Analog RGB types gt FPD H21XT AC 15 inch 1024 x 768 dots Panel mounted type FPD M21VT AC 12 1 inch 800 x 600 dots Panel mounted type FPD L21ST AC 10 4inch 640 x 480 dots Panel mounted type lt Panel Link types gt IPC DT H40X PC T 15 inch 1024 x 768 dots Panel mounted type IPC DT L40S PC T 12 1 inch 800 x 600 dots Panel mounted type IPC DT L440 PC TA 12 1 inch 800 x 600 dots Desktop wall mounted IPC DT L440 PC TB 12 1 inch 800 x 600 dots Desktop wall mounted anti glare type lt Analog RGB types gt IPC DT M20V PC T 10 4 inch 640 x 480 dots IPC DT L20S PC T 12 1 inch 800 x 600 dots IPC DT H20X PC T 15 inch 1024 x 768 dots Display cable only for DVI D IPC DVI D 020 DVI D type display cable 2m IPC DVI D 050 DVI D type display cable 5m Display cable only for PanelLink IPC DVIPL 020 DVI PanelLink conversion display cable 2m IPC DVIPL 050 DVI PanelLink conversion display cable 5m Touch panel cable for an analog RGB display IPC CBL3 2 AT host Touch panel COM cable 2m IPC CBL3 5 AT host Touch panel COM cable 5m CD ROM D
7. VD ROM drive IPC CDD 03 CD ROM DVD ROM drive CD ROM DVD ROM drive connection cable IPC CDC 04 CD ROM DVD ROM CABLE FAN FAN Filler IPC FAN9225S FAN for IPC Series 92 x 25mm IPC FAN4020S FAN for IPC Series 40 x 20mm IPC FLT92 FAN Filter 92 x 92mm 10pcs CONTEC www contec com Packing List Name BOX PC DVI Analog RGB Conversion Adapter The attachment fittings CF Card Lock Slot cover Power cable fixed clamp Power Cable Two point sems screw M3 x 5 Three point sems screw M3 x 6 Three point sems screw M4 x 8 IPC SLIB 01 1 User s manual Driver amp Utility Soft Set Recovery Media 2 Royalty consent contract 2 Setup procedure document 2 IPC Precaution List Product guide 1 Please confirm latest information on the CONTEC homepage though the user s manual is stored in IPC SLIB 01 2 Products with HDD less model don t include Component Life 1 Power supply When continuously operating at 40 C the estimated life expectancy is about five years The horizontal installation However it decreases according to the use temperature high temperature 2 Battery The internal calendar clock and CMOS RAM are backed by a Lithium primary battery The backup time at a temperature of 25 C with the power disconnected is 10 years or more 3 FAN When continuously operating at 40 C the estimated life expectancy is about six years However it decreases according to the use temperature high
8. WN 1PC Bx720 AC CONTEC www contec com Celeron 2GHz CPU loading BOX PC for High Speed Processings IPC BX720 AC Series Specifications color and design of the products are subject to change without notice Moco expansionsiot_ o IPC BX720 AC41G PCI slot x 2 Windows XP Professional PCI slot x 2 Windows XP Embedded IPC BX720 AC42F High performance Equipped with a high performance CPU of Intel R Celeron R processor 2 0 GHz 400 MHz FSB supporting high speed data acquisition arithmetic applications High power CPU based compact PC serviceable in a guaranteed operating range of ambient temperatures from 0 to 50 degrees centigrade 1 Assorted extension interfaces Coming standard with a variety of extensions such as two PCI slots five serial ports RS 232C x 4 RS 422 485 x 1 inside a RAS connector two LAN connectors 100BASE T x 1 100BASE TX x 1 a CF slot bootable and the RAS connector High maintainability The front panel with all the connectors and PCI slots and the slot in system facilitating the mounting and demounting of storage devices PCI slots in the riser unit structure removable from the system unit making it easy to plug and unplug PCI boards Long life fan life expectancy of six years 2 in an easily replaceable fan unit High reliability and secure design Duct cooling system with high cooling efficiency and dust resistance using the fan unit to dir
9. econdary IDE connector dedicated to 36 pin half pitch connector CF card slot secondary IDE connection Power ON display LED IDE disk access display LED General purpose LED Ethernet 100BASE TX 10BASE T RJ 45 connector Ethernet 1000BASE T 100BASE TX 10BASE T RJ 45 connector USB port connector erial port 1 connector 9 pin D SUB male rial port 2 connector 9 pin D SUB male rial port 3 connector 9 pin D SUB male erial port 4 connector 9 pin D SUB male eyboard connector 6 pin mini DIN PS 2 mouse connector 6 pin mini DIN VI DVI connector DVI I 29 pin A RAS function and RS 485 connector 15 pin D SUB female Power SW amp AC power input connector Expansion slot PCIx2 System Configuration LINE IN LINE OUT Cc RESET P IDE IDE POWER ACCESS TATUS AN1 AN2 am n wW ERIAL1 ERIAL2 ERIAL3 ERIAL4 B ojo n vjojojz Q O al D m Expansion slot Please use the ECH series additionally 1 when you increase the slot When using the Panel Link Main memory standard I F LCD i nm Toptional DVE Panel Link S PADIMM PCI half size board conversion cable LLU ECH series Display When using the general purpose analog input display DVI analog RGB adapter bundled Built in Mouse Z S LINE IN LINE OUT MIC 2 5 inch Hard silicon dise drive SERIAL port LAN 1 2 CF
10. ectly cool the CPU and the left and right ducts to exhaust the isolated air from heat sources Equipping with a falling off stopper clamp for the AC power cable a falling off stopper bracket for the CF slot and a strong falling off stopper clamp for the PCI slot EEPROM retaining the BIOS settings capable of booting even when the battery is dead Stable supply Long life design with handpicked components such as the CPU and chipset for embedded computing remaining in stable supply for an extended period of time as industrial equipment 1 The temperature range is for the silicon disk drive mounted model with a Windows OS preinstalled For the HDD mounted model the guaranteed operating range of temperatures is 5 to 45 degrees centigrade 2 The period of time is expected assuming the continuous operation at an ambient temperature of 40 degrees centigrade This product is the BOX PC 720 Series of embedded computers based on the Intel R Celeron R 2 0 GHz processor with a Windows OS preinstalled The 720 Series is a compact BOX PC with a high power CPU while clearing severe environment conditions for ambient temperatures based on its dust cooling system providing high cooling efficiency and dust resistance The BOX PC has a wealth of extension interfaces with all the connectors including the PCI slots concentrated on the front panel providing superb maintainability and other added values unique to CONTEC As the BOX PC
11. incorporates handpicked components such as the embedded types of CPU and chipset it excels in reliability and stable supply for an extended period of time offering usability without anxiety Supported OS Windows XP Professional Windows XP Embedded Functional Specification lt 1 2 gt Intel R 845GV Memory 256KB Main Standard 512MB 1 2GB 1GB x 2 Max memory 2 5V 184 pin DDR SDRAM PC2100 DIMM Socket x 2 BIOS 128KB E0000H FFFFFH Award ROM Video Controller_ Intel R 845GV Built into the controller Video Main memory shared RAM S Video 48KB C0000H CBFFF BIO Display I F DVI I 29 pin 2 System resolution 640 x 480 16 770 000 colors 800 x 600 16 770 000 colors 1 024 x 768 16 770 000 colors 1 280 x 1 024 16 770 000 colors 1 600 x 1 200 16 770 000 colors Audio AC97 compliant LINE IN 63 5 Stereo mini jack Full scale input level 1 3Vrms Typ LINE OUT 3 5 Stereo mini jack Full scale output level 1 0Vrms Typ Dual 250mW Amplifier MIKE IN 3 5 Monaural mini jack Full scale input level 1 3Vrms Typ VF Master Secondary Equipped with a dedicated 36pin half pitch connector for connection of an optional CD ROM DVD ROM drive Secondary IDE Master CF CARD Type II x 1 dedicated to memory card Secondary IDE Slave Serial I F RS 232C general purpose 4ch SERIAL PORT1 2 3 4 9 pin D SUB connector RS 232C touch panel 1ch SERIAL PORTS inside the DVI connector 3 RS 422
12. temperature Replacement of expendables is handled as a repair there will be a charge Physical Dimensions g e a 4 M4 TAP Containing it in facing Maximum tapping 264 length 5mm 282 Ag ij m lt o e ao 115 mm Component Locations SERIALI SERIAL3 UTP ACINLET Ethernet TOP COVER Expansion slot PCI x 2 n ji power fe 7 TEC pe I POWER SW e j _ Primary IDE r a Secondary IDE MOUSE have A itn gig pe a KEYBOARD oP ilo e e apf te ot LINE OUT cms Eee o MIC Dvi CE S aee o 7 sits T sB CompactFlash STATUS LED POWERLED ACCESSLED RESET RAS DVI U SERIAL2 SERIAL4 Name Function Line in 3 5 PHONE JACK Line out 63 5 PHONE JACK Mike in 3 5 PHONE JACK Hard reset push button Primary IDE connector dedicated to 44 pin socket S
Download Pdf Manuals
Related Search