Weed Eater 530087060 Blower User Manual
Contents
1. e Air filter dirty e Spark plug fouled e Carburetor requires adjustment Engine smokes excessively e Air filter dirty e Too much oil mixed with gasoline e Carburetor requires adjustment CLEAN UNIT amp LABELS Clean the unit using a damp cloth and a mild detergent Wipe off the unit with a clean dry cloth SPARK PLUG Replace spark plug yearly with a Champion CJ 8Y plug Spark plug gap is 025 in IGNITION TIMING Ignition timing is fixed non adjustable CARBURETOR ADJUSTMENT Your carburetor is equipped with limiter caps Damage will occur if you turn the needles be yond the limiter caps Carburetor adjustment is a complicated task We recommend that you take your unit to an Authorized Service Dealer NEED ASSISTANCE Call 1 800 554 6723 for assistance NEED SERVICE PART Contact your dealer or call 1 800 554 6723 LIMITED WARRANTY ELECTROLUX HOME PRODUCTS NORTH er predelivery setup or normal adjustments ex AMERICA Division of WCI Outdoor Prod plained in the operator s manual ucts Inc warrants to the original purchaser that THIS WARRANTY GIVES YOU SPECIFIC LE each new Weed Eater brand gasoline tool or GAL RIGHTS AND YOU MAY HAVE OTHER attachment is free from defects in material and RIGHTS WHICH VARY FROM STATE TO workmanship and agrees to repair or replace un STATE der this warranty any defective gasoline product NO CLAIMS FOR CONSEQUENTIAL OR or attachment as follows from the ori2. fuel in a closed area where fuel vapors can reach sparks or an open flame from hot water heaters electric motors or switches furnaces etc e Store in a dry area out of reach of children SPECIAL NOTICE For users on U S For est Land and in some states including Califor nia Public Resources Codes 4442 and 4443 Idaho Maine Minnesota New Jersey Ore gon and Washington Certain internal com bustion engines operated on forest brush and or grass covered land in the above areas are required to be equipped with a spark arres tor maintained in effective working order or the engine must be constructed equipped and maintained for the prevention of fire Check with your state or local authorities for regulations pertaining to these requirements Failure to follow these requirements is a viola tion of the law This unit is not factory equipped with a spark arrestor however a spark arres tor is available as an optional part If a spark ar restor is required in your area contact an Au thorized Service Dealer for the correct kit The spark arrestor blower tubes and nozzles must be assembled to unit to be in full com pliance with regulations SPECIAL NOTICE Exposure to vibrations through prolonged use of gasoline powered hand tools could cause blood vessel or nerve damage in the fingers hands and joints of people prone to circulation disorders or abnor mal swelling Prolonged use in cold weather has been linked to
3. or performing maintenance on unit Wearing eye protection will help to prevent rocks or debris from being blown or ricocheting into eyes and face which can result in blind ness and or serious injury Always wear respirator or face mask when working with unit in dusty environments Secure hair above shoulder length Secure or remove jewelry loose clothing or clothing with loosely hanging straps ties tassels etc They can be caught in moving parts Do not operate unit when you are tired ill up set or if you are under the influence of alcohol drugs or medication Keep children bystanders and animals away from work area a minimum of 50 feet 15 m when starting or operating unit Inspect the area before starting the unit Re move all debris and hard objects such as rocks glass wire etc that can ricochet be thrown or otherwise cause injury or damage during operation HANDLE FUEL WITH CAUTION e Eliminate all sources of sparks or flame in cluding smoking open flames or work that can cause sparks in the areas where fuel is mixed poured or stored e Mix and pour fuel in an outdoor area store fuel in a cool dry well ventilated place use an ap proved marked container for all fuel purposes Do not smoke while handling fuel or while op erating the unit Do not fill fuel tank while engine is running e Wipe up fuel spills before starting engine e Move at least 10 feet 3 meters away from fuel and fueling site befo
4. warranty rights and responsibilities you should contact your near est authorized service center or call POULAN 6 1 800 554 6723 WARRANTY PERIOD Any warranted part which is not scheduled for replacement as required maintenance or which is scheduled only for regular inspection to the effect of repair or replace as necessary shall be warranted for 2 years Any warranted part which is scheduled for replacement as re quired maintenance shall be warranted for the period of time up to the first scheduled replace ment point for that part DIAGNOSIS The owner shall not be charged for diagnostic labor which leads to the determination that a war ranted part is defective if the diagnostic work is performed at an approved POULAN WEED EATER servicing center CONSEQUENTIAL DAMAGES POULAN WEED EATER may be liable for damages to other engine compo nents caused by the failure of a warranted part still under warranty WHAT IS NOT COV ERED All failures caused by abuse neglect or improper maintenance are not covered ADD ON OR MODIFIED PARTS The use of add on or modified parts can be grounds for dis allowing a warranty claim POULAN WEED EATER is not liable to cover failures of war ranted parts caused by the use of add on or modified parts HOW TO FILE A CLAIM If you have any questions regarding your warranty rights and responsibilities you should contact your nearest authorized service center or call POULAN WEED EATER at 1 800 5
5. 54 6723 WHERE TO GET WAR RANTY SERVICE Warranty services or repairs shall be provided at all POULAN WEED EATER service centers call 1 800 554 6723 MAINTE NANCE REPLACEMENT AND REPAIR OF EMISSION RELATED PARTS Any POULAN WEED EATER approved replacement part used in the performance of any warranty main tenance or repair on emission related parts will be provided without charge to the owner if the part is under warranty EMISSION CONTROL WARRANTY PARTS LIST Carburetor Igni tion System Spark Plug covered up to main tenance schedule Ignition Module MAINTE NANCE STATEMENT The owner is responsi ble for the performance of all required mainte nance as defined in the owner s manual
6. HSIMSNA Trademark Por favor no devuelva el aparato al lugar de compra Veuillez ne pas retourner l outil au d taillant 1 800 554 6723 www weedeater com P Please do not return unit to retailer Operator s Manual Manual del Operador Manuel de L utilisateur FL1500 TONVdS43 For Household Use Only WARNING Read and follow all Safety Rules and Operating Instructions before using this product Failure to do so can result in serious injury ADVERTENCIA Lea el manual del operador y siga todas las advertencias e instruc ciones de seguridad El no hacerlo puede resultar en lesiones graves AVERTISSEMENT Lire le manuel de l utilisateur et bien respecter tous les avertisse ments et toutes les instructions de s curit Tout d faut de le faire pourrait entrainer des blessures graves Electrolux Home Products North America Div of WCI Outdoor Products Inc Augusta GA 30907 Copyright 1999 WCI Outdoor Products Inc 530087060 03 02 99 SIVONVHA SAFETY RULES WARNING Failure to follow all Safety Rules and Precautions can result in serious injury KNOW YOUR UNIT e Read your Operator s Manual carefully until you completely understand and can follow all warnings and safety rules before operat ing the unit e Restrict unit to users who understand and will follow all warnings and safety rules in this manual PLAN AHEAD e Always wear eye protection when operating servicing
7. ble Conserve water by using power blowers instead of hoses for many lawn and garden ap plications including areas such as gutters screens patios grills porches and gardens Use the full blower nozzle extension so the air stream can work close to the ground After using blowers and other equipment CLEAN UP Dispose of debris in trash re ceptacles BEFORE STARTING ENGINE WARNING Be sure to read the fuel information in the safety rules before you begin If you do not understand the safety rules do not attempt to fuel your unit Call 1 800 554 6723 FUELING ENGINE This engine is certified to operate on unleaded gasoline Gasoline must be mixed with a good quality 2 cycle air cooled engine oil designed to be mixed at a ratio of 40 1 Poulan Weed Eater brand oil is recommended A 40 1 ratio is ob tained by mixing 3 2 ounces of oil with 1 gallon of unleaded gasoline When mixing fuel follow the instructions printed on the container Always read and follow the safety rules under FUEL SAFETY Fuel stabilizer is an acceptable alternative in minimizing the formation of fuel gum deposits during storage Poulan Weed Eater brand oil is already blended with fuel stabilizer na Eye Protection STOPPING YOUR ENGINE e Move the throttle lever 3 to the STOP position e If engine does not stop move the choke lever 1 to Full Choke Starting Position STARTING YOUR ENGINE You MUST mak
8. blood vessel damage in oth erwise healthy people If symptoms occur such as numbness pain loss of strength change in skin color or texture or loss of feel ing in the fingers hands or joints discontinue the use of this tool and seek medical attention An anti vibration system does not guarantee the avoidance of these problems Users who operate power tools on acontinual and regular basis must monitor closely their physical con dition and the condition of this tool ASSEMBLY NOTE It is normal for the fuel filter to rattle in the empty fuel tank ASSEMBLY WARNING If received assembled repeat all steps to ensure your unit is properly assembled and all fasteners are secure e No tools are required for assembly BLOWER TUBE e Push the blower tube into the blower outlet until it snaps into place Blower Outlet Blower Tube OPERATION OPERATING TIPS e Operate power equipment only at reasonable hours not early in the morning or late at night when people might be disturbed Comply with times listed in local ordinances Usual recom mendations are 9 00 a m to 5 00 p m Monday though Saturday To reduce noise levels limit the number of pieces of equipment used at any one time To reduce noise levels operate power blow ers at the lowest possible throttle speed to do the job Use rakes and brooms to loosen debris be fore blowing In dusty conditions slightly dampen sur faces when water is availa
9. e sure the tube is secure be fore using the unit e Fuel engine Move at least 10 feet 3 meters away from the fueling site e Hold the unit in the starting position as shown Make sure the blower end is directed away from people animals glass and solid objects WARNING When starting engine STARTING A COLD ENGINE OR A WARM ENGINE THAT HAS RUN OUT OF FUEL Move choke lever 1 to FULL CHOKE e Slowly press the primer bulb 6 times e Move throttle lever 3 to the position e Sharply pull starter handle until engine at tempts to run NO MORE THAN 5 PULLS Move choke lever 1 to 1 2 CHOKE Pull starter rope sharply until engine runs NOTE If engine has not started after 5 pulls repeat all of the above steps e After a 10 second warm up move the choke lever 1 to CHOKE OFF e Move throttle lever to for low speed e To stop engine move the throttle lever 3 to the STOP position NOTE If engine does not stop move choke lever to FULL CHOKE STARTING A WARM ENGINE THAT HAS NOT RUN OUT OF FUEL e Move the choke lever 1 to the CHOKE OFF position Move throttle lever 3 to the position e Pull starter handle sharply until engine runs NOTE If engine does not run after 5 pulls follow information provided under Starting a cold engine or a warm engine that has run out of fuel DIFFICULT STARTING OR STARTING A FLOODED ENGINE Flooded engines can be started by placing the choke leve
10. es e Check air intake opening and blower tubes frequently always with engine stopped and spark plug disconnected Keep vents and discharge tubes free from debris which can accumulate and restrict proper air flow and cause damage to the unit Never use for spreading chemicals fertiliz ers or other substances which may contain toxic materials e To avoid spreading fire do not use near leaf or brush fires fireplaces barbecue pits ash trays etc e To reduce the risk of hearing loss associated with sound level s hearing protection is re quired e To reduce the risk of injury associated with contacting rotating parts stop the engine be fore installing or removing attachments Do not operate without guard s in place e Use only for jobs explained in this manual MAINTAIN YOUR UNIT PROPERLY e Have all maintenance other than the recom mended procedures described in the Opera tor s Manual performed by an Authorized Service Dealer e Disconnect spark plug before performing maintenance except for carburetor adjust ments e Use only recommended replacement parts use of any other parts may void your warran ty and cause damage to your unit e Empty the fuel tank before storing the unit Use up fuel left in carburetor by starting the engine and letting it run until it stops e Do not use any accessory or attachment other than those recommended by the man ufacturer for use with your unit e Do not store the unit or
11. ginal date of OTHER DAMAGES WILL BE ALLOWED purchase AND THERE ARE NO OTHER EXPRESS 2 YEARS Parts and Labor when used for WARRANTIES EXCEPT THOSE EX household purposes PRESSLY STIPULATED HEREIN 90 DAYS Parts and Labor when used for SOME STATES DO NOT ALLOW LIMITA commercial professional or income produc TIONS ON HOW LONG AN IMPLIED WAR ing purposes RANTY LASTS OR THE EXCLUSION OR 30 DAYS Parts and Labor if used for rental LIMITATIONS OF INCIDENTAL OR CONSE purposes QUENTIAL DAMAGES SO THE ABOVE This warranty is not transferable and does not LIMITATIONS OR EXCLUSION MAY NOT cover damage or liability caused by improper APPLY TO YOU handling improper maintenance or the use of ELECTROLUX HOME PRODUCTS NORTH accessories and or attachments not specifically AMERICA S policy is to continuously improve its recommended by ELECTROLUX HOME products Therefore ELECTROLUX HOME PRODUCTS NORTH AMERICA for this tool PRODUCTS NORTH AMERICA reserves the Additionally this warranty does not cover tune right to change modify or discontinue models ups spark plugs filters etc that will wear and designs specifications and accessories of all require replacement with reasonable use during products at any time without notice or obligation the warranty period This warranty does not cov to any purchaser U S EPA CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT YOUR WARRANTY RIGHTS AND OBLIGA TIONS The U S Environmental P
12. r 1 in the CHOKE OFF position and the throttle lever 3 in the position then pull the starter handle sharply to clear the engine of excess fuel This could require hold the unit as illustrated Do not set unit on pulling the starter handle many times depend any surface except a clean hard area when starting engine or while engine is running De bris such as gravel sand dust grass etc could be picked up by the air intake and thrown out through the discharge opening damaging the unit or property or causing serious injury to bystanders or the operator lt Primer Bulb Throttle Lever 3 Choke Lever 1 ing on how badly the unit is flooded If the unit still does not start refer to TROUBLESHOOTING TABLE or call 1 800 554 6723 MAINTENANCE e Keep all nuts bolts and screws tight e Never store the machine with fuel in the fuel tank inside a building where fumes may reach an open flame or sparks or in a con fined space such as a car trunk e Always refer to the Operator s Manual for im portant details if the product is to be stored for an extended period TROUBLESHOOTING TABLE Engine will not start e Fuel tank empty e Engine flooded e Spark plug not firing e Fuel not reaching carburetor e Carburetor requires adjustment Engine will not idle properly e Carburetor requires adjustment e Throttle problem Engine will not accelerate lacks power or dies under a load
13. re starting engine OPERATE YOUR UNIT SAFELY e Inspect unit before each use for worn loose missing or damaged parts Do not use until unit is in proper working order Keep outside surfaces free from oil and fuel Never start or run engine inside a closed room or building Breathing exhaust fumes can kill e To avoid static electricity shock do not wear rubber gloves or any other insulated gloves while operating unit e Do not set unit on any surface except a clean hard area while engine is running Debris such as gravel sand dust grass etc could be picked up by the air intake and 2 thrown out through discharge opening dam aging unit property or causing serious in jury to bystanders or operator Avoid dangerous environments Do not use in unventilated areas or where explosive va pors or carbon monoxide build up could be present e Do not overreach or use from unstable sur faces such as ladders trees steep slopes rooftops etc Keep firm footing and balance at all times e Never place objects inside the blower tubes always direct the blowing debris away from people animals glass and solid objects such as trees automobiles walls etc The force of air can cause rocks dirt or sticks to be thrown or to ricochet which can hurt peo ple or animals break glass or cause other damage Never run unit without the proper equipment attached When using your unit as a blower always install blower tub
14. rotection Agency California Air Resources Board and POULAN WEED EATER DIVISION OF WCI OUTDOOR PRODUCTS are pleased to ex plain the emissions control system warranty on your lawn and garden equipment engine All new utility and lawn and garden equipment en WEED EATER at 1 800 554 6723 WAR RANTY COMMENCEMENT DATE The war ranty period begins on the date the lawn and garden equipment engine is purchased LENGTH OF COVERAGE This warranty shall be for a period of two years from the initial date of purchase WHAT IS COVERED RE PAIR OR REPLACEMENT OF PARTS Re pair or replacement of any warranted part will be performed at no charge to the owner at an approved POULAN WEED EATER servicing center If you have any questions regarding your warranty rights and responsibilities you should contact your nearest authorized ser gines must be designed built and equipped to vice center or call POULAN WEED EATER at meet the stringent anti smog standards POULAN WEED EATER must warrant the emission control system on your lawn and gar den equipment engine for the periods of time listed below provided there has been no abuse neglect or improper maintenance of your lawn and garden equipment engine Your emission control system includes parts such as the carburetor and the ignition system Where a warrantable condition exits POU LAN WEED EATER will repair your lawn and garden equipment engine at no cost to you Ex penses covered under warran
15. ty include diag nosis parts and labor MANUFACTURER S WARRANTY COVERAGE If any emissions related part on your engine as listed under Emissions Control Warranty Parts List is de fective or a defect in the materials or workman ship of the engine causes the failure of such an emission related part the part will be repaired or replaced by POULAN WEED EATER OWNER S WARRANTY RESPONSIBILI TIES As the lawn and garden equipment en gine owner you are responsible for the perfor mance of the required maintenance listed in your Owner s Manual POULAN WEED EAT ER recommends that you retain all receipts covering maintenance on your lawn and gar den equipment engine but POULAN WEED EATER cannot deny warranty solely for the lack of receipts or for your failure to ensure the performance of all scheduled maintenance As the lawn and garden equipment engine owner you should be aware that POULAN WEED EATER may deny you warranty cover age if your lawn and garden equipment engine or a part of it has failed due to abuse neglect improper maintenance unapproved modifica tions or the use of parts not made or approved by the original equipment manufacturer You are responsible for presenting your lawn and garden equipment engine to a POULAN WEED EATER authorized repair center as soon as a problem exists Warranty repairs should be completed in a reasonable amount of time not to exceed 30 days If you have any questions regarding your
Download Pdf Manuals
Related Search