Poulan 33 Trimmer User Manual
Contents
1. run until it stops Store unit and fuel in an area where fuel va pors cannot reach sparks or open flames from water heaters electric motors or switches furnaces etc Store unit so line limiter blade cannot acci dentally cause injury Unit can be hung by the tube e Store the unit out of the reach of children If situations occur which are not covered in this manual use care and good judgment If you need assistance call 1 800 554 6723 SAFETY NOTICE Exposure to vibrations through prolonged use of gasoline powered hand tools could cause blood vessel or nerve damage in the fingers hands and joints of people prone to circulation disorders or ab normal swellings Prolonged use in cold weather has been linked to blood vessel dam age in otherwise healthy people If symptoms occur such as numbness pain loss of strength change in skin color or texture or loss of feeling in the fingers hands or joints discontinue the use of this tool and seek med ical attention An anti vibration system does not guarantee the avoidance of these prob lems Users who operate power tools on a continual and regular basis must monitor closely their physical condition and the condi tion of this tool SPECIAL NOTICE This unit is equipped with a temperature limiting muffler and spark arresting screen which meets the require ments of California Codes 4442 and 4443 All U S forest land and the states of California Idaho Maine Minne2. Choose the line size best suited for the job at hand Green colored line is designed for cut ting grass red colored line for grass and small weeds The black colored line is de signed for cutting larger weeds and light brush e Before inserting the line into the holes in the cutting head identify the proper holes When using green or red insert line into the holes marked small on the cutting head Black line should be inserted in the holes marked large e Insert both ends of your line through the proper holes in the side of the cutting head Positioning Tunnel A e Insert ends of the line one at a time through the positioning tunnels Line against the hub e Pull the line and make sure the line is against the hub and extended fully through the positioning tunnels e Correctly installed line will be the same length on both ends SERVICE We recommend all service and adjustments not listed in this manual be performed by an authorized service dealer CARBURETOR ADJUSTMENTS Your carburetor is equipped with limiter caps Carburetor adjustments is a complicated task We recommend that you take your unit to an authorized service dealer Damage will occur if you turn the needles beyond the limit er stops IGNITION TIMING The ignition timing is fixed non adjustable SPARK PLUG Replace the spark plug yearly using a Cham pion RCJ 8Y plug Spark plug gap is 0 025 NEED ASSISTANCE Need Assi
3. LIMITATIONS OF INCIDENTAL OR CON SEQUENTIAL DAMAGES SO THE ABOVE LIMITATIONS OR EXCLUSION MAY NOT APPLY TO YOU ELECTROLUX HOME PRODUCTS NORTH AMERICA S policy is to continu ously improve its products Therefore ELEC TROLUX HOME PRODUCTS NORTH AMERICA reserves the right to change mod ify or discontinue models designs specifica tions and accessories of all products at any time without notice or obligation to any pur chaser U S EPA EMISSION CONTROL WARRANTY STATEMENT YOUR WARRANTY RIGHTS AND OBLIGA TIONS The U S Environmental Protection Agency and POULAN WEED EATER DIVI SION OF WCI OUTDOOR PRODUCTS are pleased to explain the emissions control system warranty on your lawn and garden equipment engine All new utility and lawn and garden equipment engines must be designed built and equipped to meet the stringent anti smog stan dards POULAN WEED EATER must warrant the emission control system on your lawn and garden equipment engine for the periods of time listed below provided there has been no abuse neglect or improper maintenance of your lawn and garden equipment engine Your emission 6 control system includes parts such as the car buretor and the ignition system Where a war rantable condition exits POULAN WEED EAT ER will repair your lawn and garden equipment engine at no costto you Expenses covered un der warranty include diagnosis parts and labor MANUFACTURER S WARRANTY COVER A
4. tightening onto the arbor shaft e Tighten nut securely 10 12 ft lbs ATTACH THE SHIELD A WARNING The shield must be prop erly installed The shield provides partial protection from the risk of thrown objects to the operator and others and is equipped with a line limiter blade which cuts excess line to the proper length The line limiter blade on underside of shield is sharp and can cut you e Remove wing nut from shield e Insert bracket into slot as shown e Pivot shield until bolt passes through hole in bracket e Securely tighten wing nut onto bolt 3 Shield Wing Nut FUEL YOUR UNIT WARNING Remove fuel cap slowly when refueling This engine is certified to operate on un leaded gasoline Gasoline must be mixed with a good quality 2 cycle air cooled engine oil designed to be mixed at a ratio of 40 1 Poulan PRO brand oil is recommended A 40 1 ratio is obtained by mixing 3 2 ounces of oil with 1 gallon of unleaded gasoline When mixing fuel follow the instructions printed on the container Always read and follow the safety rules under FUEL SAFETY STARTING HOW TO STOP YOUR UNIT To stop the engine push and release the en gine STOP switch The switch will automati cally return to the ON position Wait 5 sec onds before attempting to restart unit to allow switch to reset HOW TO START YOUR UNIT Starting Position Muffler A WARNING The trimmer head will turn whil
5. to the original purchaser that each new Poulan PRO brand gasoline tool or attachment is free from defects in ma terial and workmanship and agrees to repair or replace under this warranty any defective gasoline product or attachment as follows from the original date of purchase 2 YEARS Parts and Labor when used for household purposes 60 DAYS Parts and Labor when used for commercial professional or income produc ing purposes 30 DAYS Parts and Labor if used for rental purposes This warranty is not transferable and does not cover damage or liability caused by improper handling improper maintenance or the use of accessories and or attachments not spe cifically recommended by ELECTROLUX HOME PRODUCTS NORTH AMERICA for this tool Additionally this warranty does not cover tune ups spark plugs filters starter ropes starter springs cutting line or rotating head parts that will wear and require replace ment with reasonable use during the warranty period This warranty does not cover prede livery setup or normal adjustments explained in the instruction manual THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE NO CLAIMS FOR CONSEQUENTIAL OR OTHER DAMAGES WILL BE ALLOWED AND THERE ARE NO OTHER EXPRESS WARRANTIES EXCEPT THOSE EX PRESSLY STIPULATED HEREIN SOME STATES DO NOT ALLOW LIMITA TIONS ON HOW LONG AN IMPLIED WAR RANTY LASTS OR THE EXCLUSION OR
6. GE If any emissions related part on your en gine as listed under Emissions Control Warran ty Parts List is defective or a defect in the materials or workmanship of the engine causes the failure of such an emission related part the part will be repaired or replaced by POULAN WEED EATER OWNER S WARRANTY RE SPONSIBILITIES As the lawn and garden equipment engine owner you are responsible for the performance of the required mainte nance listed in your instruction manual POU LAN WEED EATER recommends that you re tain all receipts covering maintenance on your lawn and garden equipment engine but POU LAN WEED EATER cannot deny warranty solely for the lack of receipts or for your failure to ensure the performance of all scheduled main tenance As the lawn and garden equipment engine owner you should be aware that POU LAN WEED EATER may deny you warranty coverage if your lawn and garden equipment engine or a part of it has failed due to abuse ne glect improper maintenance unapproved mod ifications or the use of parts not made or ap proved by the original equipment manufacturer You are responsible for presenting your lawn and garden equipment engine to a POULAN WEED EATER authorized repair center as soon as a problem exists Warranty repairs should be completed in a reasonable amount of time not to exceed 30 days If you have any questions regarding your warranty rights and re sponsibilities you should contact your neares
7. and service not ex plained in this manual performed by an au thorized service dealer FUEL SAFETY e Mix and pour fuel outdoors Keep away from sparks or flames Use a container approved for fuel Do not smoke or allow smoking near fuel or the unit Avoid spilling fuel or oil Wipe up all fuel spills Move atleast 10 feet 3 meters away from fueling site before starting engine Stop engine and allow to cool before re moving fuel cap Always store gasoline in a container ap proved for flammable liquids CUTTING SAFETY WARNING Inspect the area before each use Remove objects rocks broken glass nails wire etc which can be thrown by or become entangled in line Hard objects can damage trimmer head and be thrown causing serious injury e Use only for trimming mowing and sweep ing Do not use for edging pruning or hedge trimming Keep firm footing and balance Do not over reach Keep all parts of your body away from spin ning line and muffler Keep engine below waist level A hot muffler can cause serious burns Cutting with the line on right side of the shield will throw debris away from the oper ator Use only in daylight or good artificial light TRANSPORTING AND STORAGE Allow the engine to cool secure unit before storing or transporting in vehicle Empty the fuel tank before storing or trans porting the unit Use up fuel left in the car buretor by starting the engine and letting it
8. and warnings Never allow children to operate this unit INSTRUCTION SAFETY INFORMATION MANUAL ON THE UNIT 7 S es A DANGER Never use blades wire or flailing devices Unit is designed for line trim mer use only Use of any other accessories or attachments will increase the risk of injury BUQOQ WARNING Trimmer line throws ob jects violently You and others can be blinded injured Wear safety glasses and leg protec tion Keep body parts clear of rotating line Safety Glasses or similar eye protection Keep children bystanders and animals 50 feet 15 meters away If approached stop unit immediately If situations occur which are not covered in this manual use care and good judgement If you need assistance contact your authorized service dealer or call 1 800 554 6723 OPERATOR SAFETY e Dress properly Always wear safety glasses or similar eye protection when op erating or performing maintenance on your unit safety glasses are available Eye protection should be marked Z87 Always wear face or dust mask if operation is dusty e Always wear heavy long pants long sleeves boots and gloves Wearing safety leg guards is recommended e Always wear foot protection Do not go barefoot or wear sandals Stay clear of spinning line e Secure hair above shoulder length Secure or remove loose clothing or clothing with loosely hanging ties straps tassels etc They can be caught in moving par
9. e starting the engine Avoid any con tact with the muffler A hot muffler can cause serious burns STARTING A COLD ENGINE or a warm engine after running out of fuel e Rest engine and shield on ground e Slowly press the primer bulb 6 times e Move choke lever to FULL CHOKE by aligning arrow with position shown on decal see illustration below Arrow on choke lever Choke position decal NN Squeeze the throttle trigger fully and hold through all remaining steps Pull starter rope handle sharply until engine sounds as if it is trying to start but do not pull rope more than 6 times As soon as engine sounds as if it is trying to start move choke lever to HALF CHOKE by aligning arrow with position shown on decal see following illustration Arrow on choke Choke lo lever position decal 15M Pull starter rope sharply until engine runs but no more than 6 pulls If the engine doesn t start after 6 pulls at the HALF CHOKE position move the choke lever to the FULL CHOKE position and press the primer bulb 6 times Squeeze and hold the throttle trigger and pull the starter rope 2 more times Move the choke lever to the HALF CHOKE position and pull the starter rope until the engine runs but no more than 6 pulls If the engine doesn t start repeat procedure 2 additional times NOTE If engine still doesn t start it is probably flooded Proceed to STARTING A FLOODED ENGINE Once the engine sta
10. oulan PRO Instruction Manual Manual de Instrucciones Manuel d Instructions 033 For Occasional Use Only IMPORTANT MANUAL Do not throw away MANUAL IMPORTANTE No lo descarte MANUEL IMPORTANT Conserver WARNING Read and follow all Safety Rules and Operating Instructions before using this product Failure to do so can result in serious injury ADVERTENCIA Lea el manual de instrucciones y siga todas las advertencias e instrucciones de seguridad El no hacerlo puede resultar en lesiones graves AVERTISSEMENT Lire le manuel d instructions et bien respecter tous les avertisse ments et toutes les instructions de s curit Tout d faut de le faire pourrait entra ner des blessures graves Electrolux Home Products North America Div of WCI Outdoor Products Inc Augusta GA 30907 Copyright 2001 WCI Outdoor Products Inc 530086198 5 4 01 HSIMSNA TONVdS3 SIVONVHS SAFETY RULES WARNING When using gardening appliances basic safety precautions should always be followed to reduce the risk of fire and serious injury Read and follow all instructions This power unit can be dangerous Operator is responsible for following unit and manual instructions and warnings Read entire in struction manual before using unit Be thor oughly familiar with the controls and the prop er use of the unit Restrict the use of this unit to persons who read understand and follow unit and manual instructions
11. rts allow it to run 10 se conds then move the choke lever to OFF CHOKE by aligning arrow with position shown on decal see following illustration Allow the unit to run for 30 more seconds at OFF CHOKE before releasing the throttle trigger NOTE If engine dies with the choke lever in the OFF CHOKE position move the choke lever to the HALF CHOKE position and pull the rope until engine runs but no more than 6 pulls Arrow on choke lever Choke position decal STARTING A WARM ENGINE Move the choke lever to the HALF CHOKE position Squeeze and hold the throttle trigger Keep throttle trigger fully squeezed until the en gine runs smoothly e Pull starter rope sharply until engine runs but no more than 5 pulls e Allow engine to run 15 seconds then move the choke lever to the OFF CHOKE position NOTE If engine has not started pull starter rope 5 more pulls If engine still does not run it is probably flooded STARTING A FLOODED ENGINE Flooded engines can be started by placing the choke lever in the OFF CHOKE position then pull the rope to clear the engine of ex cess fuel This could require pulling the starter handle many times depending on how badly the unit is flooded If the unit still doesn t start refer to TROUBLESHOOTING TABLE or call 1 800 554 6723 USING YOUR UNIT OPERATING POSITION Long Pants El a y Heavy Shoes Ta A Cut from your left to your right REPLACING THE LINE
12. sota New Jersey Ore gon and Washington require by law that many internal combustion engines be equipped with a spark arresting screen If you operate in alocale where such regulations ex ist you are legally responsible for maintaining the operating condition of these parts Failure to do so is a violation of the law For normal homeowner use the muffler and spark arrest ing screen will not require any service After 50 hours of use we recommend that your muffler be serviced or replaced by your autho rized service dealer ASSEMBLY A WARNING If received assembled repeat all steps to ensure your unit is properly assembled and all fasteners are secure ADJUST THE ASSIST HANDLE A WARNING When ajdusting the han dle be sure it remains between the trigger and the safety label e Loosen wing nut or knob on handle e Rotate the handle on the tube to an upright position retighten wing nut INSTALLATION OF THE CUTTING HEAD if not already installed e Secure dust cup with wrench to keep shaft from turning e Slide the trimmer head onto the shaft NOTE It will be necessary to use a deep socket to tighten the hex nut NH Arbor shaft ES AS Hex nut Dust cup Alignment washer Trimmer head e Place the alignment washer over the hex nut e Install alignment washer and hex nut by threading nut onto the arbor shaft clock wise NOTE The hex nut must be centered in the hole of the cutting head before
13. stance Call 1 800 554 6723 Need Service Part Contact your dealer al TROUBLESHOOTING TABLE A WARNING Always stop unit and disconnect spark plug before performing any of the recommended remedies below other than remedies that require operation of the unit e Spark plug not firing TROUBLE CAUSE REMEDY Engine will not e Engine flooded See Starting start e Fuel tank empty Fill tank with correct fuel mixture e Fuel not reaching carburetor e Carburetor requires adjustment Install new spark plug Check for dirty fuel filter replace Check for kinked or split fuel line repair or replace See Carburetor Adjustments e Throttle trigger screw too idle properly penne tight Engine will not e Carburetor requires adjustment See Carburetor Adjustments Loosen screw Engine will not Air filter dirty e Clean or replace air filter accelerate e Spark plug fouled e Clean or replace spark plug re gap lacks power Carburetor requires adjustment e See Carburetor Adjustments or dies under a load Engine e Fuel mixture incorrect Empty fuel tank and refill with smokes correct fuel mixture excessively Air filter dirty e Clean or replace air filter e Carburetor requires adjustment See Carburetor Adjustments LIMITED WARRANTY ELECTROLUX HOME PRODUCTS NORTH AMERICA Division of WCI Outdoor Prod ucts Inc warrants
14. t authorized service center or call POULAN WEED EATER at 1 800 554 6723 WAR RANTY COMMENCEMENT DATE The war ranty period begins on the date the lawn and garden equipment engine is purchased LENGTH OF COVERAGE This warranty shall be for a period of two years from the initial date of purchase WHAT IS COVERED REPAIR OR REPLACEMENT OF PARTS Repair or re placement of any warranted part will be per formed at no charge to the owner at an ap proved POULAN WEED EATER servicing center If you have any questions regarding your warranty rights and responsibilities you should contact your nearest authorized service center or call POULAN WEED_ EATER at 1 800 554 6723 WARRANTY PERIOD Any warranted part which is not scheduled for re placement as required maintenance or which is scheduled only for regular inspection to the ef fect of repair or replace as necessary shall be warranted for 2 years Any warranted part which is scheduled for replacement as required main tenance shall be warranted for the period of time up to the first scheduled replacement point for that part DIAGNOSIS The owner shall not be charged for diagnostic labor which leads to the determination that a warranted part is defective if the diagnostic work is performed at an ap proved POULAN WEED EATER servicing cen ter CONSEQUENTIAL DAMAGES POU LAN WEED EATER may be liable for damages to other engine components caused by the fail ure of a warranted part s
15. till under warranty WHAT IS NOT COVERED All failures caused by abuse neglect or improper maintenance are not covered ADD ON OR MODIFIED PARTS The use of add on or modified parts can be grounds for disallowing a warranty claim POULAN WEED EATER is not liable to cover failures of warranted parts caused by the use of add on or modified parts HOW TO FILE A CLAIM If you have any questions regarding your warranty rights and responsibilities you should contact your nearest authorized service center or call POULAN WEED EATER at 1 800 554 6723 WHERE TO GET WAR RANTY SERVICE Warranty services or re pairs shall be provided at all POULAN WEED EATER service centers call 1 800 554 6723 MAINTENANCE REPLACEMENT AND RE PAIR OF EMISSION RELATED PARTS Any POULAN WEED EATER approved replace ment part used in the performance of any war ranty maintenance or repair on emission related parts will be provided without charge to the own er if the part is under warranty EMISSION CONTROL WARRANTY PARTS LIST Car buretor Ignition System Spark Plug covered up to maintenance schedule Ignition Module MAINTENANCE STATEMENT The owner is responsible for the performance of all required maintenance as defined in the instruction manu al
16. ts Being fully covered also helps protect you from debris and pieces of toxic plants thrown by spinning line Stay Alert Do not operate this unit when you are tired ill or under the influence of al cohol drugs or medication Watch what you are doing use common sense e Wear hearing protection Never start or run inside a closed room or building Breathing exhaust fumes can kill e Keep handles free of oil and fuel UNIT MAINTENANCE SAFETY e Disconnect the spark plug before perform ing maintenance except carburetor adjust ments Look for and replace damaged or loose parts before each use Look for and repair fuel leaks before use Keep in good work ing condition Replace trimmer head parts that are chipped cracked broken or damaged in any other way before using the unit Maintain unit according to recommended procedures Keep cutting line at proper length Use only 0 080 2 mm diameter Poulan PRO brand line Never use wire rope string etc Install required shield properly before using the unit Use only specified trimmer head make sure it is properly installed and se curely fastened Make sure unit is assembled correctly as shown in this manual Make carburetor adjustments with lower end supported to prevent line from contact ing any object Keep others away when making carburetor adjustments Use only recommended Poulan PRO ac cessories and replacement parts Have all maintenance
Download Pdf Manuals
Related Search