Kenmore 580.5145 Dehumidifier User Manual
Contents
1. hose or bend It should lie flat from are positioned correctly connection will continually the dehumidifier to the drain drain water from the bucket MAINTENANCE GRILLE AND CASE To clean the case Use water and a mild detergent Do not use bleach or an abrasive cleaner To clean the grille Use a vacuum with an attachment or brush AIR FILTER The air filter is on the back of the dehumidifier It should be checked and cleaned at least every 30 days or more often if necessary TO REMOVE Flex the filter at the lower right corner and slide the upper right side to the left Release ail of the tabs and remove the filter Wash it in warm soapy water Rinse and let the filter dry before replacing it m 2 a 7 CLEANING INSIDE THE UNIT After removing the air filter clean the coil on the inside with a soft brush to remove any soft and wet soil NOTE Do not allow water to enter the electrical machine compartment through the circular opening behind the coil Do not spray the coil with a hose GENERAL CLEANING Dust the front grille and the side panels with a soft brush or use the dusting attachment of your vacuum e If cabinet paint chips you can touch up the paint with a good grade enamel to prevent rust WATER BUCKET CLEANING Every few weeks rinse the inside of the water bucket with a mild detergent to prevent growth of mold mildew and bacteria A EEES SSA t CO oe ta Proble2. part number not the position number CYCLE PARTS POS NO PART NO DESCRIPTION 1 B 5900A20007A FAN 2 8 4999A10001A SHROUD ASSY 3 B 4681A20040A MOTOR ASSY SINGLE 4 B 4960A20009A MOUNT MOTOR 5 B 5403A10008B CONDENSER ASSY 6 8 5421A10009B EVAPORATOR ASSY 12 580 51450 CAUTION When ordering parts use the Kenmore part number not the position number ES 7 C 8 C 9 C POS NO 1 C 2 C 3 C 4 C 5 C 6 C 7 C 8 C 9 C 10 C 11 C 12 C COMPRESSOR PARTS i 12 C m a O E un T PART NO DESCRIPTION 4H00947A NUT TERMINAL COVER 3550 CL001D TERMINAL COVER 4970U L002A SPRING O L P 6750U LO35A O L P 4986U L001B GASKET _ 2520UABC2FA COMPRESSOR 1NHA0801206 NUT HEXAGON 1 4810AR4155A BRACKET WASHER 4830A30005A BUSHING 5211A20237A TUBE ASSY SUCTION 5211A10070B TUBE ASSY DISCHARGE 5211A10085B TUBE ASSY CAPILLARY z413
3. MMENDED GROUNDING METHOD For your personal safety this appliance must be grounded This appliance has a power supply cord with a 3 prong grounding plug To minimize possible shock hazard the cord must be plugged into a mating grounding type wall receptacle and grounded in accordance with the National Electrical Code ANSI NFPA 70 latest edition and all local codes and ordinances If a mating wail receptacle is not available it is the personal responsibility and obligation of the customer to have a properly grounded 3 prong wal receptacle installed by a qualified electrician ELECTRICAL REQUIREMENTS AWARNING Electrical Shock Hazard Plug into a grounded 3 prong outlet Do not remove ground prong Do not use an adapter Do not use an extension cord Failure to follow these instructions can result in death fire or electrical shock 3 prong din 3 prong grounding grounding type Er plug receptacle Ground Power prong supply cord OPERATION FEATURES AWARNING To reduce the risk of fire electric shock or injury to persons read the important SAFETY instructions section before operating this appliance 1 CONTROL PANEL 2 GRILLE FRONT 3 POWER CORD 4 CABINET 5 AIR FILTER 6 WATER BUCKET HSITDNA OPERATION A EA des e JIN High pei BUCKET HUMIDITY ER oe CONTROL SPEED 53H H r EX Low NERD CONTROL PANEL Your dehumidifier control pan
4. Owner s Manual Manual del Propietario Kenmore DEHUMIDIFIER DESHUMIDIFICADOR Model Modelo 580 51450 HSIMONA 3 TONWdS43 Sears Roebuck and Co Hoffman Estates IL 60179 U S A www sears com TABLE OF CONTENTS TABLE OF CONTENTS crrrrrrrcrcenonnnmenenana nacos 2 AUTOMATIC SHUT OFF cocoococccnnononcncccnnnninnns 8 WARRANTY correrorrconcnrononcnnrenarenanenrnnnennnecannnens 2 REMOVING AND EMPTYING A anise Oe Contig 3 THE WATER BUCKET ssseccsssssnessssnsences 8 fmipoHant Gately Instniclonsne e 3 MAINTENANCE ccececrserecceeeserestteeetenneeeneetneeees 9 ELECTRICAL REQUIREMENTS veer 4 Grille ANd CASE oooooconnconinonacanonancnnnnnananono 9 OPERATION c0rorrrorrroroconornncncanononaconanannanenc n oo 5 O E SA 9 Peat rss ai a R AiE 5 Cleaning inside the unite 9 Control Parla dd 6 General cleaning vrs rrr rrr 9 INSTALLING YOUR DEHUMIDIFIER 7 Water bucket cleaning c ce ceccseseeeees 9 Defrost COntrol o oocoornomsiosmrsmo 7 TROUBLESHOOTING irere 10 CHOOSING THE PROPER LOCATION 7 REPAIR PARTS cooororrorncnncnonacconccnnoncccnanionenos 41 ESPA OL 0rerrorrennccranonnonaconannnnannonononacanccanono 14 SERVICE NUMBERS evesen Back Cover WARRANTY FULL ONE YEAR WARRANTY ON DEHUMIDIFIER For one year from the date of purchase if the Dehumidifier is operated and maintained according to the owner s instructions furnished with the product Sears will repair the Dehumidifier free o
5. el contains a Bucket Full indicator a Humidity indicator a Power Control Humidity Control Fan Speed Control and Timer Control Bucket Full indicator This light glows when the water bucket is full and needs to be emptied Power Operation starts when this button is pressed and stops when the button is pressed again Humidity Control This controls the humidity in the room S To raise the humidity setting Z To lower the humidity setting The humidity can be set within a range of 30 RH 70 RH by 5 increments Fan Speed This controls the speed of the airflow High Fan speed is set to high Low Fan speed is set to low When Fan Speed button is pressed the fan speed mode is changed Timer Control Press the Timer button to set the amount of time you want the unit to run The Timer can be set for Constant 8 hour 4 hour or 2 hour When Timer button is pressed the Timer indicator lights shift as follows Constant gt 2 hr gt 4 hr gt 8 hr Constant TO OPERATE THE DEHUMIDIFIER 1 Plug the power cord into an electrical outlet Press the power button 2 Set the Humidity Control anywhere between 30 RH and 70 RH for normal operation If you need drier air press the 8 Humidity Control button If you need less moister air press the gt Humidity Control button 3 Press the Power button to stop the unit manually 4 Press the Timer button to set the amount of time you want the unit to ru
6. esume y CHOOSING THE PROPER LOCATION Use the dehumidifier in a basement to help prevent moisture damage Use the dehumidifier in cooking laundry bathing and dishwashing areas that have excessive moisture Use the dehumidifier to prevent moisture damage anywhere books or valuables are stored HSNONSA AUTOMATIC SHUT OFF When the bucket is full or when the bucket is not in the proper position the Bucket Full light turns on and the unit automatically shuts off Also when bucket is out of position the unit will beep 3 times The bucket must be replaced in the proper position for the dehumidifier to work The light will be on and the dehumidifier will not run if the bucket is not in the proper position REMOVING AND EMPTYING THE WATER BUCKET The water bucket can be emptied in one of three ways Empty the bucket manually Place the dehumidifier Attach a garden hose to the When the bucket is full directly over drain threaded bucket drain hose remove and empty it into a The bucket has a threaded connection to carry water to large sink or tub When hose connection which canbe the drain HAND TIGHTEN ONLY finished replace it properly left open Drill a 1 4 6 4mm When being attached to the NOTE To replace the bucket to 1 2 13mm hole in the bucket drain hose connection properly make sure the center of the hose connection be sure the hose doesn t kink slots on the back of bucket Once opened the
7. f charge if defective in materials or workmanship FULL FIVE YEAR WARRANTY ON SEALED REFRIGERATION SYSTEM Y For five years from the date of purchase when this Dehumidifier s operated and maintained according to owner s instructions fumished with the product Sears will repair the sealed refrigeration system consisting of refrigerant connecting tubing and compressor motor free of charge if defective in material or workmanship WARRANTY SERVICE IS AVAILABLE BY RETURNING UNIT TO THE NEAREST SEARS SERVICE CENTER IN THE UNITED STATES This warranty applies only while this Dehumidifier is used in the United States This warranty gives you specific legal rights and you may also have other rights which vary from state to state Sears Roebuck and Co D 817WA Hoffman Estates IL 60179 U S A SAFETY IMPORTANT SAFETY INSTRUCTIONS The safety instructions below will tell you how to use your dehumidifier to avoid harm to yourself or damage to your dehumidifier VG FOR YOUR SAFETY Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance Read product labels for flammability and other warnings WINE PREVENT ACCIDENTS To reduce the risk of fire electrical shock or injury to persons when using your dehumidifier follow basic precautions including the following Be sure the electrical service is adequate for the model you have chosen FNAN Avoid fire
8. hazard or electric shock Do not use an extension cord or an adapter plug Do not remove any prong from the power cord Grounding type wall receptacle Do not under any circumstances cut remove or bypass the grounding prong from this plug Power supply cord with 3 prong grounding plug rN Ne ELECTRICAL INFORMATION The complete electrical rating of your new dehumidifier is stated on the serial plate Refer to the rating when checking the electrical requirements Be sure the dehumidifier is properly grounded To minimize shock and fire hazards proper grounding is important The power cord is equipped with a three prong grounding plug for protection against shock hazards Your dehumidifier must be used in a properly grounded wali receptacle If the wall receptacte you intend to use is not adequately grounded or protected by a time delay fuse or circuit breaker have a qualified electrician install the proper receptacle Do not use an extension cord or an adapter plug m 2 O 77 T OBSERVE ALL LOCAL CODES AND ORDINANCES DO NOT UNDER ANY CIRCUMSTANCES REMOVE THE POWER SUPPLY CORD GROUND PRONG ELECTRICAL GROUND IS REQUIRED ON THIS APPLIANCE A 115 volt 60 Hz AC only 15A fused and properly grounded electrical supply is required A time delay fuse or time delay circuit breaker is recommended Use a dedicated circuit serving only this appliance DO NOT USE AN EXTENSION CORD RECO
9. jwis Rp OSSIE Gauges sy Dehumidifier does not start Dehumidifier does not dry the air as it should Dehumidifier runs too much Frost appears on the coils Fan noise Water on floor The dehumidifier power cord is unplugged The fuse is blown or circuit breaker is tripped Water bucket is full Bucket is not installed Did not allow enough time to remove the moisture Airflow is restricted The Humidity Control may not be set low Humidity Doors and windows may not be closed tightly Clothes dryer may be blowing moisture laden air into the room Room temperature is too low Area to be dehumidified is too large Doors and windows are open Dehumidifier has been recently turned on or room temperature is below 65 F 18 C Airis moving through the dehumidifier Bucket drain hose connection may be loose Water bucket is not all the way in 10 TROUBLESHOOTING AAA Make sure the dehumidifier plug is pushed completely into the outlet Check the house fuse or circuit breaker box and replace the fuse or reset the breaker The dehumidifier automatically turns off when this occurs Empty the bucket Make sure a bucket in the right place When first installed allow at least 3 or 4 days to maintain the desired dryness Make sure there are no curtains blinds or furniture blocking the front or back of the dehumidifier Press the Humidity Control button t
10. n At the end of that time the unit will shut off The Timer can be set for Constant 8 hours 4 hours or 2 hours 5 If you want to control the speed of airflow press Fan Speed button Each time that the Fan Speed button is pressed the fan speed mode is shifted High gt Low gt High Note Be careful not to lose the water bucket This dehumidifier doesn t run if the water bucket is not installed properly INSTALLING YOUR DEHUMIDIFIER e Install the dehumidifier on a level floor strong enough to support the unit with a full bucket of water For best performance allow at feast 12 18 inches of air space on all sides of the unit for good air circulation Keep all outside doors windows and other openings closed when operating the dehumidifier Humid outdoor air will add to the unit s work load install your dehumidifier in an area where the temperature will not fall below 65 F 18 C At temperatures below this the coils can become covered with frost NOTE If frost occurs the unit will cycle on and off This is normal Unplug the unit or turn the unit off until the frost melts and the room temperature rises DEFROST CONTROL When the defrost control senses frost build up on the evaporator coil it will automatically shut off the compressor The fan will continue to run to draw air across the coil and melt the frost When the coil is defrosted the compressor will automatically restart and dehumidifying r
11. o lower the humidity Check that all doors windows and other openings are securely closed Install the dehumidifier away from the dryer The dryer should be vented to the outside The unit will not operate satisfactorily if the room temperature is below 65 F 18 C Check with your dealer to see if the capacity is adequate Close all doors and windows to the outside e This is normal Frost will usually disappear within 60 minutes This is normal Check the hose If one is attached See the Removing and Emptying The Water Bucket Dehumidifier Model No 580 51450 POS NO PART NO 1 A 2 A 3 A 4 A 5 A 6 A 7 A 8 A 9 A 3041AD2007C 4791A10002A 6600A30003C 3090A10001J 6877A30013B 4994A20012A 6871A10016A 0CZZA200010 4H00442J REPAIR PARTS DESCRIPTION BASE ASSY WELD SINGLE 10 A BARRIER ASSY 11 A SWITCH ASSY MICRO 12 A CABINET 13 A LEAD WIRE ASSY 14 A CONTROL BOX SINGLE 15 A PWB ASSY MAIN CAPACITOR CLAMP CAPACITOR 14 To order Parts call Toll Free 1 800 4 MY HOME 1 800 469 4663 CAUTION Use the Kenmore part number on all orders not the illustration number OUTER CASE PARTS AND CONTROL PART POS NO PART NO 6631AQ3132U 5230AD3005A 3530A 10006F 4838A20005A 3831A20016A 3551A30030A DESCRIPTION CONNECTOR ASSY FILTER AIR GRILLE FRONT TANK BUCKET ESCUTION COVER ASSY DISPLAY HSIONGA 580 51450 CAUTION When ordering parts use the Kenmore
Download Pdf Manuals
Related Search