Karcher 1750 Pressure Washer User Manual
Contents
1. Karcher Vehicle Wash apply to surface at low pressure For best results clean one side of vehicle at a time and always apply detergent from bottom to top do not allow detergent to dry on surface If needed use special wash brush attachment not included to remove stubborn dirt Rinse at high pressure in a sweeping motion keeping the spray nozzle approximately 6 8 inches from the cleaning surface distance should increase when rinsing pin striping or other sensitive surfaces Always clean from top to bottom and from left to right For best results wipe surface dry with a chamois or soft dry cloth Caution Do not use the rotary spray wand on vehicles as it may cause damage CLEANING TIPS continued Barbecue Grills Outdoor Power Equipment amp Gardening Tools with or without detergent Pre rinse cleaning surface with fresh water If using Karcher Pressure Wash or Degreaser apply detergent at low pressure Allow Pressure Wash to remain on surface 1 3 minutes Do not allow detergent to dry on surface Rinse at high pressure keeping the spray nozzle approximately 3 6 inches from the cleaning surface For removing extremely stubborn dirt it may be necessary to move the spray nozzle even closer to the surface for greater dirt cutting action Caution Do not use rotary spray wand on cloth plastic or other sensitive surfaces as it may cause damage Patio amp Lawn Furniture with or without detergent Pre rinse furni2. filter and will protect the internal parts of the pressure washer for a longer life For Karcher detergents check your retailer or call 1 800 465 4980 The following Karcher detergents are available e Pressure Wash Degreaser e Deck Fence Wash e Vehicle Wash A Caution Never use e Bleach Chlorine products and other cor rosive chemicals e Liquids containing solvents i e paint thinner gasoline oils e Trisodium phosphate products e Ammonia products e Acid based products These chemicals will harm the unit and will damage the surface being cleaned SHUTTING DOWN amp CLEAN UP S OFF O Step 1 Step 2 Step 3 Turn the switch to off O Turn off the water source Press trigger to release position and unplug cord from water pressure outlet A B i Step 5 Step 6 Disconnect the garden hose from Disconnect the high pressure hose Pull trigger down the water inlet on the unit from the high pressure outlet A and engage gun safety lock B TAKING A BREAK five minutes or more fi OFF O Step 1 Pull trigger down A and engage gun safety lock B Step 2 Turn pressure washer to off O position WINTERIZING AND LONG TERM STORAGE 1 Disconnect all water connections 4 Store the machine and accessories in 2 Turn on the machine for a few seconds a room which does not reach freezing until the water whi
3. for removing stubborn TO AVOID SERIOUS INJURY NEVER dirt and stains from finished surfaces Use POINT SPRAY NOZZLE AT YOUR with detergents only SELF OTHER PERSONS OR ANIMALS WORKING WITH DETERGE Step 1 Install the Wash brush or Quattro nozzle Turn Quattro Nozzle to Low pressure position Rotate the spray lance in the direction of af until reaching the stop Note No detergent in high pressure mode RM 1 RM 2 Step 3 Adjusting the detergent dosing valve to the desired dosage Turn to the left Meter detergent from container 1 Turn to the right Meter detergent from container 2 Step 2 a Fill the Detergent Tanks No 8a No 8b with the selected detergent ensuring it is the correct concentration read recom mended dosage on label or b Fill the Detergent Tank with Ready To Use detergent SF Step 4 Turn on the pressure washer Pull trigger to operate unit Liquid detergent is drawn into the unit and mixed with water Apply detergent to work area Do not allow detergent to dry on surface For best results see Cleaning Tips on pages 9 amp 10 for specific infor mation on how to clean different surfaces Always Use Karcher Detergents for Best Results Karcher biodegradable detergents are specially formulated to protect the environment and your pressure washer Special formula won t clog the suction tube
4. KARCHER Binford 1750 High Pressure Washer Operator Manual OVEWIEW aa a aiid 2 Pr CQULIONS ccscsccsecveassecsasreccessesees 3 4 Assembly Instructions 02 4 Operating Instructions 5 Using the accessories Working with Detergents 7 Shut Down and Clean Up 8 Taking a Break csccssssseseseeeeseees 8 Winterizing and Long Term SMOG A E 8 9 Cleaning Tips 0 0 eee eeeeeeeee 9 10 Optional Cleaning Accessories 10 Troubleshooting siisii 11 12 Specifications Working Pressure 10000 kPa Max Pressure ee 1750 PSI Max Water volume 1 5 GPM Voltage css Amp draw Please keep the original box packaging and receipt Before operating this unit please read this manual thoroughly and retain it for future reference Part No 1 423 607 0 Manual Part No 5 961 367 0 06 04EN For household use only 1 Power cord 7 Accessory compartment 2 Trigger gun 8a Detergent tank 1 3 Trigger gun safety lock 8b Detergent tank 2 4 High pressure hose 9 High pressure outlet 5 Water inlet with filter 10 On Off switch 6 Transport handle 11 Quattro nozzle 12 Washing brush THE BEST ANTI FREEZE PROTECTION IS PROVIDED BY USING AND STORING THE MACHINE IN SHELTERED SPACE IMPORTANT PRECAUTIONS Read First AN Safety Warnings When using this product basic precautions should always be fo
5. PA WORKING PRESSURE INCLUD ING BUT NOT LIMITED TO SPRAY GUNS HOSE AND HOSE CONNECTIONS BEFORE SERVICING CLEANING OR REMOVING ANY PARTS SHUT OFF POWER AND RELIEVE PRESSURE Extension Cords Use a sufficient gauge Up to 25 ft 12 3 AWG 25 to 50 ft 10 3 AWG Use only extension cords that are intended for outdoor use These extension cords are identified by a marking Acceptable for use with outdoor appliances store indoors while not in use Use only extension cords having an electrical rating not less than the rating of the product Do not use damaged extension cords Examine extension cord before using and replace if damaged Do not abuse exten sion cord and do not yank on any cord to dis connect Keep cord away from heat and sharp edges Always disconnect the extension cord from the receptacle before disconnecting the product from the extension cord If you are using an extension cord it should always be completely unwound from the cable drum Grounding Instructions This product must be grounded If it should malfunction or breakdown grounding provides a path of least resistance for electric current to reduce the risk of electric shock This product is equipped with a cord having an equipment grounding conductor and a grounding plug The plug must be plugged into an appropriate outlet that is properly installed and grounded in accor dance with all local codes and ordinances DANGER Improper connection of th
6. ch had remained in temperatures DO NOT store near the pump exits Turn off immediately furnance or other sources of heat as it 3 Do not allow high pressure hose to may dry out the pump seals become kinked Caution Failure to follow the above directions will result in damage to the pump assembly and accessories WINTERIZING AND LONG TERM STORAGE continued 5 Cleaning the water inlet filter pliers and rinse outin warm water Deck Cleaning with or without detergent Pre rinse deck and surrounding area with fresh water If using Karcher Deck Fence Wash apply to surface at low pressure For best results limit your work area to smaller sections of approximately 25 square feet Allow Deck Wash to remain on surface 1 3 minutes Do not allow detergent to dry on surface Rinse at high pressure in a long sweeping motion keeping the spray nozzle approximately 3 6 inches from the cleaning surface Always clean from top to bottom and from left to right When moving on to a new section of the cleaning surface be sure to overlap the previous section to eliminate stop marks and ensure a more even cleaning result Caution Do not use rotary spray wand on wood surfaces as it may cause damage House Siding with or without detergent Pre rinse cleaning surface with fresh water If using Karcher Pressure Wash apply to surface at low pressure for best results limit your work area to sections of approxi mately 6 feet an
7. d always apply detergent from bottom to top Allow Pressure Wash to remain on surface 1 3 minutes Do not allow detergent to dry on surface if surface appears to be drying simply wet down surface with fresh water If needed use special wash brush attachment not included to remove stubborn dirt Rinse at high pressure from top to bottom in an even sweeping motion keeping the spray nozzle approximately 6 inches from the cleaning surface Caution Do not use rotary spray wand on siding as it may cause damage Pull out the water in K let filter with flat nose 6 Cleaning the detergent inlet filter Pull it out and rinse out in warm water Maintenance The unitis maintenance free Cement Patios Brick and Stone with or without detergent Pre rinse cleaning surface with fresh water If using Karcher Pressure Wash or Degreaser apply to surface at low pressure For best results limit your work area to smaller sections of approximately 25 square feet Allow Pressure Wash or Degreaser to remain on surface 1 3 minutes Do not allow detergent to dry on surface Rinse at high pressure in a sweeping motion keeping the spray nozzle approximately 3 6 inches from the cleaning surface Always clean from top to bottom and from left to right For removing extremely stubborn stains use the rotary spray wand Cars Boats amp Motorcycles with or without detergent Pre rinse vehicle with fresh water If using
8. e equipment grounding conductor can result in a risk of electrocution Check with a qualified electrician or service personnel if you are in doubt as to whether the outlet is properly grounded Do not modify the plug provided with the product if it will not fit the outlet have a proper outlet installed by a qualified electrician Do not use any type of adapter with this product IN Caution Follow the maintenance instructions specified in the manual This machine has been designed for use with cleaning detergent supplied or recommended by the manufacturer The use of other cleaning detergents may affect the operation of the machine and void the warranty IMPORTANT PRECAUTIONS continued Water Supply Cold Water Only e Never use the pressure washer to draw in Water hose must be at least 1 2 inch or water contaminated with solvents e g 5 8 inch in diameter paint thinner gasoline oil etc Flow rate of water supply must not fall NOTE Dirt in the feed water will below 2 GPM gallons per minute damage the unit To avoid this risk Flow rate can be determined by running the We recommend fitting a water filter water for one minute into an empty Always prevent debris from being drawn 5 gallon container into the unit by using a clean water source e The water supply temperature must not and an accessory water filter if required exceed 104 F 40 C Save these instructions Step 6 Pull out t
9. eplace with a 1 2 inch or 5 8 inch garden hose Water supply is restricted Check garden hose for kinks leaks and blockage Not enough inlet water supply Open water source full force Water inlet filter is clogged Remove filter and rinse out in warm water Spray wand is on low pressure position Not enough inlet water supply Turn spray wand to high pressure position Turn water on full force Check garden hose for kinks leaks or blockage Pump is sucking air Check that hoses and fittings are air tight Turn off machine and purge pump by squeezing trigger gun until a steady flow of water emerges through the nozzle Water inlet filter is clogged Remove filter and rinse out in warm water Discharge nozzle is obstructed Blow out or remove debris with a fine needle Calcified gun hose or spray wand Run distilled vinegar through detergent tank TROUBLESHOOTING continued Symptom No detergent Spray wand leaks Pump is noisy Water leaks from pump up to 10 drops per minute is permissible Oil Drips Detergent is too thick Solution Dilute detergent Spray wand is in high pressure position Turn spray wand tip to low pressure position Discharge nozzle is obstructed Spray wand not properly attached Blow out or remove debris with a fine needle Insert the spray wand into the trig ger gun Carefully press in aga
10. he locking slide from the right side of the trigger gun handle A and insert the small end of the high pressure hose into place B Push the locking slide back into the trigger gun to lock the hose in position C OPERATING INSTRUCTIONS Step 1 Connect the high pressure hose to the high pressure outlet Step 3 Connect the garden hose to the water inlet Insert the quattro nozzle to the trigger gun Press in against the spring tension and twist into the locked position Step 4 Connect garden hose to the cold water source and turn water on completely Plug the power cord into the power outlet BA A Step 5 Unlock the lock of the trigger gun A Trigger the gun B to eliminate trapped air wait for a steady flow of water to emerge from the spray nozzle Step 6 Turn on the pressure washer l The motor starts only if the trigger of the gun is pulled and shuts off when the trigger is released USING THE ACCESSORIES Quattro Nozzle Selecting the jet Release the trigger of the handgun Rotate the nozzle head until the symbol is aligned with the marking on the spray lance Note The marking on the spray lance must be up during operation y n A High pressure High pressure Rotating jet for Low pressure pencil jet fan jet maximum dirt fan jet for cleaning cleaning cutting action detergent injection A Warning This brush is ideal
11. inst the spring tension and twist into the locked position Broken o ring or plastic insert Pump is sucking air Loose fittings Call Customer Service Check that hoses and fittings are air tight Turn off machine and purge pump by squeezing trigger gun until a steady flow of water emerges through the nozzle Check that all fittings are tight Water seals are damaged or worn Oil seals are damaged or worn Call Customer Service Call Customer Service If you encounter any additional difficulties not listed please call Customer Service at 1 800 465 4980 for help or visit www karcher ca
12. llowed Read all the instructions before using the product High pressure jets can be dangerous if subject to misuse The jet must not be directed at persons animals electrical devices or the machine itself To reduce the risk of injury do not operate the machine near children Learn how to stop the machine and release pressure quickly Be thoroughly familiar with the controls Stay alert watch what you are doing Wear safety goggles Do not use acids solvents or any other flammable material in this product These products can cause physical injuries to the operator and irreversible damage to the machine Do not operate the product when fatigued or under the influence of alcohol or drugs Do not stand on unstable surfaces Stand with both feet balanced at all times To reduce the risk of electrocution keep all connections dry and off the ground Do not touch plug with wet hands The Trigger Gun Safety Lock PREVENTS the trigger from accidentally being engaged This safety feature DOES NOT lock trigger in the on position WARNING DO NOT SPRAY ELECTRICAL APPARATUS AND WIRING INJECTION HAZARD EQUIPMENT CAN CAUSE SERIOUS INJURY IF THE SPRAY PEN ETRATES THE SKIN DO NOT POINT THE GUN AT ANYONE OR ANY PART OF THE BODY IN CASE OF PENETRATION SEEK MEDICAL AID IMMEDIATELY THIS SYSTEM IS CAPABLE OF PRODUCING 10000 KPA TO AVOID RUPTURE AND IN JURY DO NOT OPERATE THIS PUMP WITH COMPONENTS RATED LESS THAN 10000 K
13. ture and surrounding area with fresh water If using Pressure Wash apply to surface at low pressure Allow Pressure Wash to remain on surface 1 3 minutes Do not allow detergent to dry on surface If needed use special Wash Brush Attachment not included to remove stubborn dirt Rinse at high pressure in a sweeping motion keeping the spray nozzle approximately 3 6 inches from the cleaning surface For best results clean from top to bottom and from left to right Caution Do not use rotary spray wand on patio or lawn furniture as it may cause damage Recommendations e Before cleaning any surface an incon spicuous area should be cleaned to test spray pattern and distance for maximum cleaning results e f painted surfaces are peeling or chipping use extreme caution as pressure washer may remove the loose paint from the surface e When using on surfaces which might come in contact with food flush surfaces with plenty of drinking water OPTIONAL CLEANING ACCESSORIES Optional cleaning accessories are available to further enhance your cleaning capabilities For details call 1 800 465 4980 or visit www karcher ca e Rotating Wash Brush e Wash Brush e Underbody Wand e Pipe Drain Cleaner e Sandblasting Attachment e Extension wand e Water Siphon Kit 25 Extension Hose e T Racer KARCHER 2 YEAR WARRANTY KARCHER CANADA INC warrants to the original owner that this product shall be free from defects in material and
14. workmanship for two years from the date of its original purchase If such a defect appears during the warranty period upon presentation of proof of purchase K RCHER CANADA INC will repair or replace at its option your product without charge This warranty does not cover accidental damage unreasonable use normal wear and tear loss of use or other consequential damages nor does it cover repairs made or attempted by unauthorized persons Trigger gun hose spray wands and other accessories are warranted for 3 months Please note that no returns will be accepted without prior authorization from our customer service department It is the owner s responsibility to file claims for damage caused by public transportation carriers directly with the carrier concerned TROUBLESHOOTING Disconnect the machine from the power source before making any repair Symptom Motor will not start Unit does not reach high pressure Output pressure varies high and low On Off switch is in the OFF O position Solution Turn switch to the ON I position Power cord is not plugged in Plug in power cord Extension cord is too long Extension cord is not proper gauge Extension cord is damaged Replace extension cord with either a 25 ft 12 3 gauge cord or a 50 ft 10 3 gauge cord Electrical outlet does not supply adequate power Diameter of garden hose is too small Try a different outlet R
Download Pdf Manuals
Related Search