Invacare IRC9LXO2AWQ Oxygen Equipment User Manual
Contents
1. 5LXO2AW 9LXO2AWQ models Stated concentration levels achieved after initial warm up period approximately 30 minutes Maximum Outlet Pressure Flow Range Low Flow Alarm Average Power Consumption IRCSLXAW IRC5LXO2AW and IRCSLXO2AWQ 93 minimum at to 3 L min 91 minimum at 4 L min 87 minimum at 5 L min maximum recommended flow IRCILKO2AWQ 92 minimum at to 2 L min 91 minimum at 8 L min 87 minimum at 9 L min 93 minimum at 3 to 7 L min IRCSLXAW IRC5LXO2AW IRC5LXO2AWQ 34 5 3 45 kPa 5 0 5 psi IRCOLXO2AWQ 62 0 kPa 3 45 kPa 9 0 5 psi IRCSLXAW IRCSLXO2AW IRCSLXO2AWQ 0 5 to 5 L min Flowrates less than L min are not recommend 2 I L min to 9 L min Flowrates less than I L min are not recommended 0 L min to 0 5 L min Rapid Audible Alarm Beeping No Accessories Connected IRCSLXO2AWQ 300 W 280 W 0 3 L min IRCSLXO2AW 365 W 340 0 lt 3 L min 380 W IRCSLXAW 475 W IRCILKO2ZAWQ Pressure Relief Mechanism 241 kPa 24 1 kPa 35 psi 3 5 psi Operational at Part No 1134866 15 Platinum SECTION 4 TYPICAL PRODUCT PARAMETERS Change in maximum 0 7 L min recommended flow when back pressure of 7k Pa is applied Cabinet 2 Outlet HEPA and Compressor Inlet Safety System Current overload or line surge shutdown High temperature compressor shutdown High Pressure Alarm w compressor shutdown Low2. 200 Suhong Road SIP Suzhou Industrial Park Suzhou Jiangsu PRC 215021 Tel 86 512 62586192 Fax 86 512 62586072 rights reserved Trademarks are identified by All trademarks are owned by or licensed to Invacare Corporation or its subsidiaries unless otherwise noted 9 2009 Invacare Corporation Rev E 04 09
3. IRC5LXAW IRC5LXO2AW IRC5LXO2AWQ 0 5 L min to 5 L min Flow rates less than L min are not recommended IRCILKO2AWQ L min to 9L min Flow rates less than L min are not recommended NOTE Ensure that your concentrator is at least 7 5 cm 3 in away from walls draperies or furniture to assure sufficient air flow Avoid deep pile carpets and heaters radiators or hot air registers Plug in Power Cord 1 Plug in power cord to an electrical outlet Platinum 20 Part No 1134866 SECTION 5 OPERATING INSTRUCTIONS Connect Humidifier If So Prescribed NOTE For this procedure refer to FIGURE 5 1 FIGURE 5 2 FIGURE 5 3 on page 22 and FIGURE 5 4 on page 23 1 Fill humidifier with distilled water to the level indicated by the manufacturer Please contact Invacare for recommendations A WARNING DO NOT overfill humidifier Replace the humidifier cap and securely tighten DO NOT reverse the oxygen input and output connections Water from the humidifier bottle will travel through the cannula back to the patient Humidifier Bottle NN FIGURE 5 1 Filling the Humidifier 2 Place the humidifier bottle in the humidifier compartment Humidifier Bottle E FIGURE 5 2 Humidifier Compartment Part No 1134866 21 Platinum SECTION 5 OPERATING INSTRUCTIONS 3 Remove the filter access door located on the side of the concentrator Insert a flathead screwdriver in the plate groove on the top ed
4. Pressure Alarm w compressor shutdown Battery Free Power Loss Alarm SensO Oxygen System SensO Model Low Flow Alarm 46 7 cm 18 3 8 in 3 8 in 67 0 cm I 6 3 8 in 3 8 in 36 5 cm cm 14 3 8 in 3 8 in Weight IRCSLXO2AW IRC5LKO2AWQ 23 6 kg kg 52 Ibs 2 Ibs IRCOLXO2AWQ 24 0 kg kg 53 Ibs 2 Ibs Shipping Weight IRCSLXAW IRC5LXO2AW IRC5LKO2AWQ 26 8 kg kg 59 Ibs 2 Ibs IRCILKO2AWQ 27 2 kg kg 60 Ibs 2 Ibs Operating Ambient 10 C 35 C 50 F 95 F at 20 60 relative Temperature humidity Less than Ambient 19 C 35 F Oxygen Output Less than Ambient 2 C 4 F Cabinet Impact Resistant flame retardant plastic cabinet that conforms to UL 94 0 Platinum 16 Part No 1134866 SECTION 4 TYPICAL PRODUCT PARAMETERS Regulatory Listing IRC5LXAW IRC5LXO2AW IRC5LXO2AWQ IRCYLXO2AWQ ETL tested as complying with EN5501 I EN61000 3 2 EN61000 3 3 IEC 60601 AI A2 IEC 60601 1 2 IRC5LXO2AW IRC5LXO2AWQ IRCILKO2ZAWQ Models Only 1508359 marked models IRC5LXO2AW IRC5LXO2AWQ IRCOLXO2AWQ Electrical No extension cords Placement No closer than 7 5 cm 3 inches from any wall furniture draperies or similar surfaces Tubing IRC5LXAW IRC5LXO2AW IRC5LXO2AWQ 2 1 m 7 ft cannula with maximum 15 2 m 50 ft of Crush Proof Tubing DO NOT pinch IRCOLXO2AWQ Recommended use up to 15 2 M 50 ft
5. inserted into the outlet fitting For more information about the HomeFill contact Invacare Power Cord Outlet Fitting ACCESSORIES NOT SHOWN HomeFill home oxygen compressor Contact your local Invacare representative for available accessory information VIEW Part 1134866 HI Platinum SECTION 3 SHIPPING AND HANDLING SECTION 3 SHIPPING AND HANDLING NOTE For this procedure refer to FIGURE 3 1 on page 13 Before you install and operate the concentrator please refer to Platinum Series Owner s Manual The Platinum concentrator should ALWAYS be kept in the upright position to prevent cabinet damage while being transported The shipping container has been designed to assure maximum protection of the concentrator If the concentrator is to be reshipped by common carrier it should be packed in a new carton Additional cartons are available from Invacare The air compressor suspension system has been engineered to withstand severe motion and orientation Unpacking 1 Check for any obvious damage to the carton or its contents If damage is evident notify the carrier or Invacare 2 Remove all loose packing from the carton 3 Carefully remove all the components from the carton NOTE Retain carton and packing materials for storage of the Platinum Inspection 1 Examine exterior of the oxygen concentrator for nicks dents
6. 5 01 norway invacare com island invacare com Osterreich Mobitec Mobilitatshilfen GmbH Herzog Odilostrasse 101 A 5310 Mondsee Tel 43 6232 5535 0 Fax 43 6232 5535 4 office mobitec austria com austria invacare com Portugal Invacare Lda Rua Estrada Velha 949 P 4465 784 Leca do Balio Tel 351 0 225 1059 46 47 Fax 351 0 225 1057 39 portugal invacare com Sverige amp Suomi Invacare AB Fagerstagatan 9 S 163 91 Spanga Tel 46 0 8 761 70 90 Fax 46 0 8 761 81 08 sweden invacare com finland invacare com Platinum 34 Part No 1134866 LIMITED WARRANTY Switzerland Mobitec Rehab AG Benkenstrasse 260 CH 4108 Witterswil Tel 41 0 61 487 70 80 Fax 41 0 61 487 70 81 office mobitec rehab ch switzerland invacare com United Kingdom Invacare Ltd South Road Bridgend Industrial Estate UK Bridgend CF31 3PY Tel 44 0 1656 664 321 Fax 44 0 1656 667 532 UK invacare com Part No 1134866 35 Platinum gt Yes you can Invacare Corporation www invacare com USA One Invacare Way Elyria Ohio USA 44036 2125 440 329 6000 800 333 6900 Technical Services 440 329 6593 800 832 4707 x CY EU Representative NI Invacare International Sarl Route de Cit Ouest 2 1196 Gland Switzerland Tel 41 22 354 60 10 Fax 41 223546011 Part No 1134866 Manufacturer Invacare Medical Equipment Suzhou Co Ltd Unit 2B Export Processing Zone No
7. LVH INSONOO N39AXO WANILW1d 3HVOVANI FUVOVANI Qquooau 39NVN3LNIVIA IALLNIAIYd FIGURE 6 2 Preventive Maintenance Record Part No 1134866 30 Platinum GUIDE SECTION 7 TROUBLESHOOTING GUIDE SECTION 7 TROUBLESHOOTING SYMPTOM Alarm PROBABLE CAUSE Main Power Loss SOLUTION Short beeps long pause Power cord NOT plugged in I Insert plug into outlet Concentrator not operating power switch On 2 No power at outlet 2 Inspect house circuit breakers or fuses If problem recurs use a different outlet Concentrator not operating Power Switch On Beeeeeeeep to blocked air intake 2 Insufficient power at outlet 3 Internal repairs required Beep Beep 3 Tripped circuit 3 Call Service Provider breaker Alarm System Failure la Remove and clean Continuous I Unit overheating due cabinet filters Ib Move oxygen concentrator at least 7 5 cm 3 in away from walls draperies or furniture 2 DO NOT use extension cords Move to another electrical outlet or circuit 3 Call Service Provider Part No 1134866 3l Platinum SECTION 7 TROUBLESHOOTING GUIDE SYMPTOM YELLOW or RED light illuminated Alarm Continuous On red light only Only applies to SensO models PROBABLE CAUSE I Low oxygen purity 2 Kinked or blocked tubi
8. Operator s Manual Platinum Oxygen Concentrators Standard h SensO and Model IRCSLXAW Model IRC5LXO2AW Model IRCSLXO2AWQ Model IRC9LXO2AWQ Dealer This manual must be given to the end user st User Before using this concentrator read T this manual and save for future reference C For more information regarding ERES Invacare products parts and services INVACARE please visit www invacare com CE Yes you can WARNING WARNING DO NOT USE THIS PRODUCT OR ANY AVAILABLE OPTIONAL EQUIPMENT WITHOUT FIRST COMPLETELY READING AND UNDERSTANDING THESE INSTRUCTIONS AND ANY ADDITIONAL INSTRUCTIONAL MATERIAL SUCH AS OWNER S MANUALS SERVICE MANUALS OR INSTRUCTION SHEETS SUPPLIED WITH THIS PRODUCT OR OPTIONAL EQUIPMENT IF YOU ARE UNABLE TO UNDERSTAND THE WARNINGS CAUTIONS OR INSTRUCTIONS CONTACT A HEALTHCARE PROFESSIONAL DEALER OR TECHNICAL PERSONNELBEFORE ATTEMPTING TO USE THIS EQUIPMENT OTHERWISE INJURY OR DAMAGE MAY OCCUR ACCESSORIES There are many different types of humidifiers oxygen tubing cannulas and masks that can be used with this device You should contact your local home care provider for recommendations on which of these devices will be best for you They should also give you advice on the proper usage maintenance and cleaning ACCESSORIES WARNING Invacare products are specifically designed and manufactured for use in conjunction with Invacare accessories Accessories de
9. ate LO ues iir a ros ri qt 24 SensO Oxygen Purity Indicators LX Sensor Model 25 Indicators EX Model tunica rite pinta 26 Main Power Loss Alarm System sse 26 Elapsed Time Meter Hour 26 SECTION 6 MAINTENANCE 27 Part 1134866 3 Platinum TABLE OF 5 Routine Maintenance seseeseeseesessesseesesessesscssessessescesessessessesseses 27 SECTION 7 TROUBLESHOOTING GUIDE 31 LIMITED WARRANTY 3 3 Platinum 4 Part No 1134866 SPECIAL NOTES SPECIAL NOTES Signal words are used in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage Refer to the following table for definitions of the signal words SIGNAL WORD MEANING Danger indicates an imminently hazardous situation which if not avoided will result in death or serious DANGER injury Warning indicates a potentially hazardous situation which if not avoided could result in death or WARNING serious injury Caution indicates a potentially hazardous situation which if not avoided may result in property CAUTION damage or minor injury or both NOTICE The information contained in this document i
10. ax 32 0 50 83 10 11 belgium invacare com Danmark Invacare A S Sdr Ringvej 37 DK 2605 Brendby Tel 45 0 36 90 00 00 Fax 45 0 36 90 00 01 denmark invacare com Deutschland Invacare Aquatec GmbH Alemannenstrafse 10 D 88316 Isny Tel 49 0 75 62 7 00 0 Fax 49 0 75 62 7 00 66 info invacare aquatec com European Distributor Organisation Invacare Kleiststrafse 49 D 32457 Porta Westfalica Tel 49 0 57 31 754 540 Fax 49 0 57 31 754 541 edo invacare com Espana Invacare SA c Areny s n Poligon Industrial de Celra E 17460 Celra Girona Tel 34 0 972 49 32 00 Fax 34 0 972 49 32 20 contactsp invacare com France Invacare Poirier SAS Route de St Roch F 37230 Fondettes Tel 33 0 2 47 62 64 66 Fax 33 0 2 47 42 12 24 contactfr invacare com Ireland Invacare Ireland Ltd Unit 5 Seatown Business Campus Seatown Road Swords County Dublin Ireland Tel 353 1 810 7084 fax 353 1 810 7085 ireland invacare com Part No 1134866 33 Platinum LIMITED WARRANTY Italia Invacare Mecc San s r l Via dei Pini 62 1 36016 Thiene VI Tel 39 0445 38 00 59 Fax 39 0445 38 00 34 italia invacare com Nederland Invacare BV Celsiusstraat 46 NL 6716 BZ Ede Tel 31 0 318 695 757 Fax 31 0 318 695 758 nederland invacare com csede invacare com Norge Invacare AS Grensesvingen 9 Postboks 6230 Etterstad N 0603 Oslo Tel 47 0 22 57 95 00 Fax 47 0 22 57 9
11. e refer to FIGURE 5 5 on page 24 1 Press power switch to on position All the panel lights and the audible alarm will come on for one second indicating that the unit is functioning properly Part No 1134866 23 Platinum SECTION 5 OPERATING INSTRUCTIONS R On Off VO 2 Power Switch FIGURE 5 5 Power Switch Flowrate NOTE For this procedure refer to FIGURE 5 6 on page 25 1 Turn the flowrate knob to the setting prescribed by your physician or therapist A WARNING DO NOT change the L min setting on the flowmeter unless a change has been prescribed by your physician or therapist NOTE To properly read the flowmeter locate the prescribed flowrate line on the flowmeter Next turn the flow knob until the ball rises to the line Now center the ball on the L min line prescribed 2 Iftheflowrate on the flowmeter ever falls below 0 5 L min for more than about one minute the LOW FLOW alarm will be triggered This is a rapid beeping of the audible alarm Check your tubing or accessories for blocked or kinked tubing or a defective humidifier bottle After rated flow is restored more than 0 5 L min the LOW FLOW audible alarm will go off Platinum 24 Part No 1134866 SECTION 5 OPERATING INSTRUCTIONS NOTE The use of some accessories such as the pediatric flowstand and the HomeFill compressor will deactivate the Low Flow Alarm E tue Ball FIGU R 5 6 Flowrate SensO Oxygen Purity Ind
12. e oxygen concentrator Radio Frequency Interference Most electronic equipment is influenced by Radio Frequency Interference RFI Caution should be exercised with regard to the use of portable communications equipment in the area around such equipment To Reduce The Risk Of Burns Electrocution Fire Or Injury To Persons Avoid using while bathing If continuous usage is required by the physician s prescription The concentrator must be located in another room at least 2 1 m 7 ft from the bath DO NOT come in contact with the concentrator while wet A product should NEVER be left unattended when plugged in DO NOT place or store product where it can drop into water or other liquid Part No 1134866 9 Platinum SECTION GENERAL GUIDELINES DO NOT reach for product that has fallen into water Unplug IMMEDIATELY This device is to be used only in accordance with the prescription of a physician and this Owners Manual If at any time the patient or attendant conclude that the patient is receiving an insufficient amount of oxygen the supplier and or physician should be contacted IMMEDIATELY No adjustments should be made to the flowrate unless prescribed by a physician Close supervision is necessary when this product is used near children or physically challenged individuals Use this product for only intended use as described in this manual DO NOT connect the concentrator in parallel or series with other oxygen c
13. entrator has a damaged cord or plug if it is not working properly if it has been dropped or damaged or dropped into water call Qualified Service Personnel for examination and repair Keep the oxygen tubing cord and unit away from heated or hot surfaces including space heaters blankets stoves and similar electrical appliances DO NOT move or relocate concentrator by pulling on the cord NEVER drop or insert any object into any opening NEVER block the air openings of the product or place it on a soft surface such as a bed or couch where the air opening may be blocked Keep the openings free from lint hair and the like Platinum 8 Part No 1134866 SECTION GENERAL GUIDELINES Fill humidifier with water to the level shown by the manufacturer DO NOT overfill Keep unit at least 7 5 cm 3 in away from walls draperies furniture and the like Invacare recommends that Crushproof oxygen tubing supplied by Invacare be used with this product and NOT exceed 15 2 m 50 ft in length Recommended use for Platinum 9 is up to 15 2 m 50 ft in length of high flow tubing Maintenance The Invacare Oxygen Concentrator was specifically designed to minimize routine preventive maintenance at intervals of once per year Only professionals of the healthcare field or persons fully conversant with this process such as authorized or factory trained personnel should perform preventive maintenance or performance adjustments on th
14. ge of the filter access door and gently pry the filter access door open Refer to Detail A in FIGURE 5 3 4 The humidifier adapter is next to the inlet filter Pull up and remove the humidifier bottle adapter Refer to Detail B in FIGURE 5 3 5 Attach it to the humidifier by turning the wing nut on the humidifier bottle counterclockwise until it is securely fastened Refer to Detail C in FIGURE 5 3 DETAIL Plate Groove Insert Flat Head Screwdriver Here Filter Access Door DETAIL DETAIL C Humidifier Bottle Adapter Humidifier Bottle Adapter c FIGURE 5 3 Attaching the Humidifier Bottle Adapter Platinum 22 Part No 1134866 SECTION 5 OPERATING INSTRUCTIONS 6 Attach oxygen tubing from the humidifier bottle to oxygen outlet connector on the oxygen concentrator 7 Attach the cannula patient supply tubing to the humidifier bottle outlet 8 After assembly ensure that oxygen is flowing through the cannula 9 Replace the filter access door on the side of concentrator by snapping it back into the plate groove Oxygen Outlet Connector Oxygen Tubing Humidifier Outlet FIGURE 5 4 Attaching the Oxygen Tubing A WARNING For optimum performance Invacare recommends that each concentrator be on and running for a minimum of 30 minutes at a time Shorter periods of operation may reduce maximum product life Power Switch NOTE For this procedur
15. high flow tubing with high flow cannula at all flow rates Relative Humidity 20 to 60 Time of Operation Up to 24 hours per day Recommended Storage and 29 C to 65 C 20 F to 150 F 15 95 Shipping Temperature relative humidity Part No 1134866 17 Platinum SECTION 4 TYPICAL PRODUCT PARAMETERS LABEL SYMBOL SENSO INDICATORS STATUS INDICATOR LIGHTS LED 02 5 5 85 2 GREEN Indicator Light Between 73 3 to 85 2 YELLOW Indicator light A YELLOW Solid B YELLOW Flashing Sensor Failure Call a qualified technician LABEL SYMBOL SYSTEM FAILURE Below 73 376 RED Indicator Light Refer to Troubleshooting Guide on page 3l LX INDICATORS STATUS SYSTEM OKAY INDICATOR LIGHTS LED GREEN Indicator Light Platinum SYSTEM FAILURE RED Indicator light Continuous Audible Alarm Sieve GARD Compressor Shutdown Call a qualified technician Part 1134866 SECTION 5 OPERATING INSTRUCTIONS SECTION 5 OPERATING INSTRUCTIONS Introduction Your oxygen concentrator is intended for individual use in the home It is an electronically operated device that separates oxygen from room air It provides high concentration of oxygen directly to you through a nasal cannula Clinical studies have documented that oxygen concentrators are therapeutically equivalent to other types of o
16. icators LX O Sensor Model This feature monitors the purity of oxygen generated by the oxygen concentrator If purity falls below factory preset standards indicator lights on the control panel will illuminate Initial Startup of the Concentrator NOTE Concentrator may be used during the initial start warm up time approximately 30 min while waiting for the O purity to reach maximum When the unit is turned on the GREEN light will come on SYSTEM OK O greater than 85 After five minutes the oxygen sensor will be operating normally and will control the indicator lights depending on oxygen concentration values Explanation of Oxygen Purity Indicator Lights NOTE For this procedure refer to FIGURE 5 7 Part No 1134866 25 Platinum SECTION 5 OPERATING INSTRUCTIONS OXYGEN PURITY Auto Shut Down Use Backup a N Below VA TT Call Supplier 4 RED Norm A YELLOW Normal 0 9 GREEN FIGURE 5 7 SensO Oxygen Purity Indicators LX O Sensor Model GREEN light O Normal Operation YELLOW light A Call supplier IMMEDIATELY You may continue to use the concentrator unless instructed otherwise by your supplier Be certain that backup oxygen is nearby RED light Q Total unit shutdown Switch IMMEDIATELY to backup oxygen supply Call supplier IMMEDIATELY FIGURE 5 7 GREEN light with YELLOW light flashing Call supplier IMMEDIATELY Oxygen sensor malfunctioning you may conti
17. mbly and operation of the Platinum concentrator these instructions MUST be followed CAUTION Caution Federal law restricts this device to sale or rental by or on order of a physician or any other practitioner licensed by the law of the governmental agency in which he she practices to use or order the use of this device DANGER Risk of electric shock DO NOT disassemble Refer servicing to qualified service personnel Part No 1134866 7 Platinum SECTION GENERAL GUIDELINES A WARNINGS The use of oxygen therapy requires that special care be taken to reduce the risk of fire Any materials that will burn in air and some that will not are easily ignited and burn rapidly in high concentrations of oxygen For safety concerns it is necessary that all sources of ignition be kept away from the product and preferably out of the room in which it is being used NO SMOKING signs should be prominently displayed A spontaneous and violent ignition may occur if oil grease or greasy substances come in contact with oxygen under pressure These substances MUST be kept away from the oxygen concentrator tubing and connections and all other oxygen equipment DO NOT use any lubricants unless expressly recommended by Invacare For optimum performance Invacare recommends that each concentrator be on and running for a minimum of 30 minutes ata time Shorter periods of operation may reduce maximum product life If the conc
18. ng cannula or humidifier 3 Flowmeter set at 0 5 L min or less 4 Unit overheating due to blocked air intake 5 Insufficient power at outlet 6 Internal repairs required SOLUTION Clean or Replace filters 2 Inspect for kinks or blockages Correct clean or replace item Once corrected turn power OFF for 60 seconds and then turn power back ON 3 Check flowmeter is set to 1 0 L min or more Refer to Recommended Guidelines for Optimum Performance on page 20 4 a Remove and clean cabinet filters 4b Move concentrator at least 7 5 cm 3 in from walls draperies and furniture 5 DO NOT use extension cords Move to another electrical outlet or circuit 6 Call Service Provider GREEN light YELLOW Light Flashing Internal repairs required I Call Service Provider Alarm RAPID Beep Beep Beep Beep Low Flow Alarm la Kinked or blocked tubing cannula or humidifier Ib Flowmeter set at 0 5 L min or less la Inspect for kinks or blockages Correct clean or replace item Once corrected turn power OFF for 60 seconds and then turn power back ON Ib Reset flowmeter to prescribed flowrate Flowrates less than L min are not recommended Platinum 32 Part No 1134866 LIMITED WARRANTY LIMITED WARRANTY Available At Belgium amp Luxemburg Invacare nv Autobaan 22 B 8210 Loppem Tel 32 0 50 83 10 10 F
19. ntive Maintenance Record on page 30 Routine Maintenance NOTE The following routine maintenance should be performed more frequently See recommended intervals in each section and preventive maintenance record Cleaning the Cabinet Filter NOTE For this procedure refer to FIGURE 6 1 on page 29 CAUTION DO NOT operate the concentrator without the filters installed NOTE There are two cabinet filters One filter located on each side of the cabinet 1 Remove each filter and clean at least once a week depending on environmental conditions NOTE Environmental conditions that may require more frequent cleaning of the filters include but are not limited to high dust smoking air pollutants etc 2 Clean the cabinet filters with a vacuum cleaner or wash in warm soapy water and rinse thoroughly Platinum 28 Part No 1134866 SECTION 6 MAINTENANCE 3 Dry the filters thoroughly before reinstallation Cabinet Filter located on both sides of concentrator Cabinet WARNING Unplug the concentrator when cleaning To avoid electrical shock DO NOT remove cabinet 1 Clean the cabinet with a mild household cleaner and non abrasive cloth or sponge Humidifier NOTE To clean the oxygen humidifier follow the instructions provided by the manufacturer If none are provided follow these steps 1 Clean the humidifier every day 2 Wash it in soapy water and rinse it with a s
20. nue to use the concentrator FIGURE 5 7 Indicators LX Model NOTE For this procedure refer to FIGURE 5 8 Explanation of LX models Indicator Lights RED light Total Unit Shut Down Switch IMMEDIATELY to a back up oxygen supply Call supplier IMMEDIATELY GREEN light I O On Off System okay Platinum 26 Part No 1134866 SECTION 5 OPERATING INSTRUCTIONS Auto Shut Down a e a RED TT Call Supplier Use Backup Normal e GREEN FIGURE 5 8 Indicators LX Model Main Power Loss Alarm System The alarm system contains no battery and is thereby maintenance free The alarm system is powered by a capacitor that is continuously charged and ready to trigger the alarm in the event of main power loss Elapsed Time Meter Hour Meter The hour meter displays the cumulative number of hours the unit has operated Part No 1134866 27 Platinum SECTION 6 MAINTENANCE SECTION 6 MAINTENANCE NOTE The Invacare concentrators are specifically designed to minimize routine preventive maintenance In places with high dust or soot levels maintenance may need to be performed more often Only authorized or factory trained personnel should perform preventive maintenance on the concentrator Power should be disconnected before beginning preventive maintenance on the Invacare concentrator NOTE At a minimum preventive maintenance MUST be performed according to the maintenance record guidelines Refer to Preve
21. olution of ten parts water and one part vinegar 3 Rinse thoroughly with hot water and refill with distilled water to the level shown on the humidifier A WARNING DO NOT overfill humidifier bottle Part No 1134866 29 Platinum SECTION 6 MAINTENANCE SERIAL NO IRC MODEL NO sipak 10 sad sad pz 01 34D 51 08797 syQuow 9 40 S DP sunoy pz Juajpainba sanoy 096 S DP 06 40 sunoy pz o1 1UaJDAINba 910 sunoy Q9 Z ALON JonupW 2 Jo uon2es 01 31 Jossaiduuo gt jo pug do pjngay e ejdey aauin au sv ULIe V SSO 2940 19914 IJU JosseJduio 5 Vd3H 19PNO peu 5 4 3eutqe e ejdey ues 39NVN3 LNIVH IALLNIAIYUd Osues SLINN uoneue2uo 2949 SIWO u3A3HOIHA SuV3A 6 HO SYUNOH 087 97 AUIAI osues LNOHLIM SLINN UONE IU3IUOD UBB XO AA VX 1S2UI SYNOH 086 AUIAI SY ul u peqi2saJd H294 6 JUIGeD Jara JNOH snop Jo Iq UD2 NOLLO3dSNI HOV3 NO HO
22. oncentrators or oxygen therapy devices Use of some administration accessories or certain humidifiers not specified for use with oxygen concentrator may impair the performance In certain circumstances oxygen therapy can be hazardous Invacare recommends that you seek medical advice before using this machine This equipment is to be used as an oxygen supplement and is not considered life supporting or life sustaining Avoid creation of any spark near medical oxygen equipment This includes sparks from static electricity created by any type of friction Oxygen Concentration Take care not to set the flow above RED ring An oxygen flow greater than 5 L min IRC5LXO2AW IRCSLXAW IRCSLXO2AWO and 9 L min IRCOLXO2AWO will decrease the oxygen concentration Platinum 10 Part 1134866 SECTION 2 FEATURES SECTION 2 FEATURES FRONT VIEW Oxygen Outlet Oxygen Purity and Fault Indicator Lights SensO model Fault and Power Indicator Lights LX model Flowmeter Power Switch Circuit Breaker Elapsed Time Meter Hour Meter Cabinet Filter one of two shown NOTE This outlet fitting is to be used only for filling oxygen cylinders with the HomeFill home oxygen compressor The outlet fitting does not affect concentrator performance Refer to the HomeFill owner s manual part number 1145804 for connection and operating instructions When not in use the plug provided with the concentrator should be
23. s subject to change without notice DANGER DO NOT SMOKE while using this device Keep all matches lit cigarettes or other sources of ignition out of the room in which this product is located and away from where oxygen is being delivered NO SMOKING signs should be prominently displayed Textiles and other materials that normally would not burn are easily ignited and burn with great intensity in oxygen enriched air Failure to observe this warning can result in severe fire property damage and cause physical injury or death Part No 1134866 5 Platinum RECYCLING INFORMATION RECYCLING INFORMATION This product has been supplied from an environmentally aware manufacturer that complies with the Waste Electrical and Electronic Equipment WEEE Directive 2002 96 This product may contain substances that could be harmful to the environment if disposed of in places landfills that are not appropriate according to legislation The crossed out wheelie bin symbol is placed on this product to encourage you to recycle wherever possible Please be environmentally responsible and recycle this product through your recycling facility at its end of life Platinum 6 Part No 1134866 SECTION GENERAL GUIDELINES SECTION GENERAL GUIDELINES A WARNING SECTION I GENERAL GUIDELINES contains important information for the safe operation and use of this product In order to ensure the safe installation asse
24. scratches or other damages Inspect all components Storage 1 Store the repackaged oxygen concentrator in a dry area 2 DO NOT place other objects on top of the repackaged concentrator Platinum 12 Part 1134866 SECTION 3 SHIPPING AND HANDLING FIGURE 3 1 Unpacking Platinum 13 Part No 1134866 SECTION 4 TYPICAL PRODUCT PARAMETERS SECTION 4 TYPICAL PRODUCT PARAMETERS Regulatory EN IEC 60601 1 Listing Alternating Current Type BF equipment Unit running Unit not running Attention Consider Accompanying Documents DO NOT smoke Class Double Insulation Electrical Requirements 230 VAC x 10 253 207 VAC 50 Hz Rated Current Input 1 4 IRCSLXO2AWQ 2 0 A IRC5LXAW IRC5LXO2AW 2 1 A IRCOLXO2AWQ Sound Level 39 5 dB Average IRC5LXO2AWQ 44 dB Average IRC5LXAW IRC5LXO2AW 50 dB Average IRCOLXO2AWQ Altitude Up to 1828 meters 6 000 ft above sea level without degradation of concentration levels NOT RECOMMENDED FOR USE ABOVE 1828 meters 6 000 ft For IRC9LXO2AWQ Up to 4 000 ft 1230 meters above sea level without degradation of concentration levels For 4 000 ft 1230 meters to 13 129 ft 4000 meters below 9076 efficiency Platinum M part No 1134866 14 1134866 SECTION 4 TYPICAL PRODUCT PARAMETERS Oxygen Output Concentration Levels All
25. signed by other manufacturers have not been tested by Invacare and are not recommended for use with Invacare products NOTE Updated versions of this manual are available on www invacare com Platinum 2 Part No 1134866 TABLE OF 5 TABLE OF CONTENTS SPECIAL NOTES 5 RECYCLING INFORMATION 6 SECTION I GENERAL GUIDELINES 7 9 Radio Frequency Interference eene 9 To Reduce The Risk Of Burns Electrocution Fire Or Injury To ORUM rA d i 9 Oxygen Concentration 10 SECTION 2 FEATURES SNE PD I SECTION 3 SHIPPING AND HANDLING 12 Unpacking Redi Ban PRAEDA ELE 12 spect 12 12 SECTION 4 TYPICAL PRODUCT PARAMETERS 14 SECTION 5 OPERATING INSTRUCTIONS 19 mene 19 Selecta gt eee 19 Recommended Guidelines for Optimum Performance 20 Plug in Power Cord se parens paca elite debi US QS 20 Connect Humidifier If So Prescribed 21 POWEr SWIEG as ege baberi qa d irc te edi addi toni 23 Fowr
26. xygen delivery systems Your provider will show you how to use your oxygen concentrator He She should be contacted with any questions or problems regarding your oxygen concentrator This owner s manual will tell you about your concentrator and will serve as a reference as you use your concentrator Select a Location You may select a room in your house where using your oxygen concentrator would be most convenient Your concentrator can be easily rolled from room to room on its casters Your oxygen concentrator will perform best when operated under the following conditions Usage in environments other than those described may result in the need for increased equipment maintenance The air intake of the unit should be located in a well ventilated area to avoid airborne pollutants and or fumes Part No 1134866 19 Platinum SECTION 5 OPERATING INSTRUCTIONS Recommended Guidelines for Optimum Performance Placement No closer than 7 5 cm 3 in from the wall furniture draperies or similar surfaces Tubing and Cannula IRC5LXAW IRC5LXO2AW 2 1 m 7 ft with a maximum 15 2 m 50 ft of Crush Proof Tubing DO NOT pinch IRCOLXO2AWQ Recommended use up to 15 2 m 50 ft high flow tubing with high flow cannula at all flow rates Environment Smoke and soot free No confined spaces Example No closets Relative Humidity 20 to 60 Time of Operation Up to 24 hours per day Flow Rate
Download Pdf Manuals
Related Search