GE AST05 Air Conditioner User Manual
Contents
1. b 5 Troubleshooting Tips Consumer Support Preparing to install the air conditioner Read these instructions completely and carefully vil Ys Before You Begin Pd N NOTE TO INSTALLER Leave these instructions with QN the air conditioner after installation Is completed NOTE TO CONSUMER Keep this Owner s Manual and Installation Instructions for future use IMPORTANT NOTES For personal safety this air conditioner must be properly grounded It is important to have the wall outlet and circuit checked by a qualified electrician if there is any doubt as to whether a proper ground exists Follow National Electric Codes NEC and or local codes and ordinances Flectrical Requirements The 3 prong grounding plug minimizes the possibility of electric shock hazard If the wall outlet you plan to use is only a 2 prong outlet itis your responsibility to have it replaced with a properly grounded 3 prong wall outlet Some models require 115 120 volt a c 60 Hz grounded outlet protected with a 15 amp time delay fuse or circuit breaker lools You Will Need Phillips head screwdriver Adjustable wrench Ruler or tape measure CAUTION A Do not under any circumstances cut or remove the third ground prong from the power cord Do not change the plug on the power cord of this air conditioner Aluminum house wiring may present special problems consult a qualified electrician2. 800 626 2224 for more information A I brands covered up to 20 years old in the continental U S Please place in envelope and mail to General Electric Company Warranty Registration Department P O Box 32150 Louisville KY 40232 2150 7 Consumer Product Ownership Registration Dear Customer Thank you for purchasing our product and thank you for placing your confidence in us We are proud to have you as a customer Follow these three steps to protect your new appliance investment Complete and mail your Consumer After mailing the registration below Read your Owner s Manual carefully Product Ownership store this document It will help you Registration today in a safe place It operate your new Have the peace of contains information appliance properly mind of knowing we you will need should can contact you in the you require service unlikely event of a Our service number is safety modification 800 GE CARES 800 432 2737 Model Number Serial Number 4 i d d CCL ee GZ Important If you did not get a registration card with your product detach and return the form below to ensure that your product is registered or register online at www GEA ppliances com Model Number Serial Number kt te et 3e UR et d oe 3 Lo LL LE yp yy d Mr Ms Mrs Miss First Last Name Name Street Address Apt
3. Some models require 230 208 volt a c protected with a time delay fuse or circuit breaker These models should be installed on their own single branch circuit for best performance and to prevent overloading house or apartment wiring circuits which could cause a possible fire hazard from overheating wires G CD Scissors or knife Pencil Level Window Installation Instructions Parts Included Top mounting rail Foam top window gasket 7 Top mounting rail seal strip Left accordion Air panel conditioner Type A 9 Type B 8 T Window sash seal L gt ye L a b i Wu D o gt ae etta i EJ so aor D Foy a Security bracket 3 accordion panel suon nnsuj Ajajes S 9 S a a cQ 2 S S N gt 2 D Q 2 Q N sdij Burjoousajqnoj yioddns sauinsuo4 Safety Instructions Operating Instructions t E z c b 5 Troubleshooting Tips Consumer Support Window Installation Instructions Read completely then follow step by step 10 7 Window Requirements These instructions are for a standard double hung window You will need to modify them for other types of windows The air conditioner can be installed without the accordion panels if needed to fit in a narrow window See the window opening dimensions below All supporting parts must be secured to firm wood masonry or meta
4. available while your warranty is still in effect You can purchase it on line anytime or call 800 626 2224 during normal business hours GE Consumer Home Services will still be there after your warranty expires Farts and Accessories www GEAppliances com Individuals qualified to service their own appliances can have parts or accessories sent directly to their homes VISA MasterCard and Discover cards are accepted Order on line today 24 hours every day or by phone at 800 626 2002 during normal business hours Instructions contained in this manual cover procedures to be performed by any user Other servicing generally should be referred to qualified service personnel Caution must be exercised since improper servicing may cause unsafe operation Contact Us www GEAppliances com If you are not satisfied with the service you receive from GE contact us on our Website with all the details including your phone number or write to General Manager Customer Relations GE Appliances Appliance Park Louisville KY 40225 Register Your Appliance www GEAppliances com Register your new appliance on line at your convenience Timely product registration will allow for enhanced communication and prompt service under the terms of your warranty should the need arise You may also mail in the pre printed registration card included in the packing material or detach and use the form in this Owner s Manual Printed in Korea
5. 3 4 min S mE b Caulking Trim molding if desired L Q 3 OUTSIDE S INSIDE Air louvers a must project on the outdoor side of the wall Bonon S Wood Filler and Caulking o above amp below the flashing b a WY Flashing Drip rail 3 Q e 13 Safety Instructions Operating Instructions t S S S p S c Troubleshooting Tips Consumer Support Before you call for service Troubleshooting Tips Save time and money Review the chart below first and you may not need to call for service Problem Possible Causes Air conditioner The air conditioner does not start is unplugged The fuse is blown circuit breaker is tripped Power failure Air conditioner does Airflow is restricted not cool as it should The temp control may not be set correctly The air filter is dirty The room may have been hot Cold air is escaping Cooling coils have iced up Air conditioner Ice blocks the air flow freezing up and stops the air conditioner from cooling the room Water drips outside Excessively hot and humid weather The air conditioner is not tilted to the outside Water drips indoors Moisture is removed from indoor air and drains into rear of a cabinet where a fan blows it against the outdoor condenser coil Water collects in base pan Normal Operating Sounds You may hear a pinging noise caused by water being picked up and th
6. Air Conditioners www GEAppliances com Safety Information Adapter PIUS cerer s coe E en eeaes 3 Connect Electricity enr there 2 Extension Cords cageeaserotseress 3 Safety Precautions 2 Operating Instructions Conlrols 2 22254 eiviesoustucs 4 5 Care and Cleaning AIDE svdedesceausseeseseeeas 6 Front Grille ceccccenwencesseecacee 7 Gillie andit ase ocu se ortas End 6 Outdoor Coils 1usesedensbtbrerstas 6 Installation Instructions Preparing to Install the Air Conditioner ce sper onesies 8 Through the Wall Installaaon Optional 13 Window Installation 9 12 Troubleshooting Tips 14 Normal Operating Oeo C 14 Consumer Support Consumer Support Dack Cover Product Registration 17 18 MODO cerastes rtn intr axes 19 Write the model and serial numbers here Find these numbers on a label on the side of the air conditioner Owner s Manual amp Installation Instructions ASPO5 ASTOS ASVO5 ASTO6 49 7399 1 JR 11 00 Safety Instructions Operating Instructions t S S S p S c Troubleshooting Tips Consumer Support IMPORTANT SAFETY INFORMATION READ ALL INSTRUCTIONS BEFORE USING ef _ A WARNING For your safety the information in this manual must be followed to minimize the risk of fire electric shock or personal injury SAFETY PRECAUTIONS Use this appliance only for its intended pur
7. COOL provide The temp control is used to maintain the S cooling with different fan speeds room temperature The compressor will cycle E RR l on and off to keep the room at the same level LOW FAN or HIGH FAN provides air circulation gt and filtering withouecooling of comfort When you turn the knob toa E higher number the indoor air will become S NOTE If you move the switch from a cool setting to OFF or to cooler Turn the knob to a lower number and a fan setting wait at least 3 minutes before switching back to the indoor air will become warmer v a cool setting Cooling Descriptions t For Normal Cooling Select HIGH COOL ox MED COOL with the temp control at midpoint For Maximum Cooling Select HIGH COOL with the temp control at the highest number available on your knob For Quieter amp Nighttime Cooling Select LOW COOL with the temp control at midpoint Consumer Support Safety Instructions MITTEN Installation Instructions Troubleshooting Tips Consumer Support i y ins www GEAppliances com t push it to the left To close i To open the vent push the lever to the right OR OR NAA RE ERR UAR ER Td A t WV Y mm nN I an z eae WW es A S zz only the air inside the room will AAA yy MYA Ed ES Fingertip pressure on the horizontal louvers adjusts Air Direction Up and
8. Company Louisville KY 40225 9 suon nnsuj Ajajes suo n nysuj bu neiado n A S S 3 m A S S o sdij Burjoousajqnoj yuoddng sauinsuo4 Consumer Support GE Appliances Website www GEAppliances com Have a question or need assistance with your appliance Try the GE Appliances Website 24 hours a day any day of the year For greater convenience and faster service you can now download Owner s Manuals order parts catalogs or even schedule service on line You can also Ask Our Team of Experts your questions and so much more Schedule Service www GEAppliances com Expert GE repair service is only one step away from your door Get on line and schedule your service at your convenience 24 hours any day of the year Or call 800 GE CARES 800 432 2737 during normal business hours Real Life Design Studio www GEAppliances com GE supports the Universal Design concept products services and environments that can be used by people of all ages sizes and capabilities We recognize the need to design for a wide range of physical and mental abilities and impairments For details of GE s Universal Design applications including kitchen design ideas for people with disabilities check out our Website today For the hearing impaired please call 800 TDD GEAC 800 833 4322 Extended Warranties www GEAppliances com Purchase a GE extended warranty and learn about special discounts that are
9. Down on some models the air direction up or down be circulated and conditioned When set at OPEN The vent control is located on the inside of the air some inside air is exhausted outside louvers in the lower right corner When set at CLOSE On some models the side to side air direction 1s adjusted by the louver levers or by grasping and Air Direction Side to Side moving the inner vertical louvers Vent Control on some models Additional controls and important information 2 Care and cleaning of the air conditioner S Q E Grille and Case e Turn the air conditioner off and remove the plug To clean use water and a mild detergent Do not m from the wall outlet before cleaning use bleach or abrasives ce Outdoor Coils The coils on the outdoor side of the air conditioner should be checked regularly If they are clogged with dirt or soot they may be professionally steam cleaned a service available through your GE service outlet Air Filter The air filter behind the front grille should be To remove on some models checked and cleaned at least every 30 days or more often if necessary Operating Instructions Clean the filter with warm soapy water Rinse and let the filter dry before replacing it CAUTION DO NOT operate the air conditioner without a filter because dirt and lint will clog it and reduce performance Grab the tabs on the filter and pull it up and out To rem
10. E mail Address Zip City LL LLL LL LL LL d d d State a Code MEME Date rara Phone Day i Year Number 1 jJ 7 NM n i01 1 1 i Occasionally we may allow selected companies to send you information L Check here if you do not want this information Month General Electric Company Louisville Kentucky www GEAppliances com GE Appliances Je Air Conditioner Warranty All warranty service provided by our Factory Service Centers Staple your receipt here a or an authorized Customer Care technician To schedule service Proof of the original purchase on line 24 hours a day contact us at www GEAppliances com or date is needed to obtain service call 800 GE CARES under the warranty For The Period Of We Will Replace One Year Any part of the air conditioner which fails due to a defect in materials or workmanship From the date of the During this full one year warranty we will also provide free of charge all labor original purchase and in home service to replace the defective part Five Years Any part of the sealed refrigerating system the compressor condenser evaporator From the date of the and all connecting tubing which fails due to a defect in materials or workmanship original purchase During this four year additional warranty we will also provide free of charge all labor and in home service to replace the defective part What Is Not Covered Service trips to your home to teac
11. e installed through the wall in both existing and new construction Read completely then follow step by step Through the wall installation is not appropriate if any of the side louvers in the case will be obstructed by the wall 7 IMPORTANT suoianisu Ajajes All side louvers in the case must project on the outdoor side of the wall The room side of the case must project into the room at least 134 from the finished wall The case must be installed level from side to side and with a slight tilt from front to rear Use a level about a 1 2 bubble will be the correct case slant to the outside Remove the air conditioner from the case For specific instruction refer to the Window suoianasu Guyesadg Installation Instructions Place the case in the wall opening and Make certain a wall receptacle is available secure with 12 1 long 10 wood screws close to the hole location or make NOTE Drill pilot holes if necessary for proper arrangements to install a receptacle installation If the frame is oversized use shims to prevent case distortion Finish the Wall Opening y Caulk all four sides on the outdoor side of the case to prevent moisture from getting through to the interior wall Use of flashing drip rail will further prevent water from dripping inside the wall and down the outside of the building mm a x gt S 3 m e z 3 o Plaster line Lintel angle if required 4 5 cm 1
12. h you how to use the Replacement of house fuses or resetting of circuit product breakers Improper installation If you have an installation problem Failure due to corrosion on models not corrosion or if the air conditioner is of improper cooling capacity protected for the intended use contact your dealer or installer You are responsible for providing adequate electrical connecting facilities Damage to the product caused by improper power supply voltage accident fire floods or acts of God Incidental or consequential damage caused by possible Failure of the product resulting from modifications to the defects with this air conditioner product or due to unreasonable use including failure to provide reasonable and necessary maintenance In commercial locations labor necessary to move the unit to a location where it is accessible for service by an individual technician This warranty is extended to the original purchaser and any succeeding owner for products purchased for home use within the USA In Alaska the warranty excludes the cost of shipping or service calls to your home Some states do not allow the exclusion or limitation of incidental or consequential damages This warranty gives you specific legal rights and you may also have other rights which vary from state to state To know what your legal rights are consult your local or state consumer affairs office or your state s Attorney General Warrantor General Electric
13. l The electrical outlet must be within reach of the power cord Storm Window Requirements A storm window frame will not allow the air conditioner to tilt towards the outside and will keep it from draining properly To adjust for this attach a piece ofwood to the stool 1 2 higher than frame A Storm window frame 22 to 36 With accordion panels 17348 min Without accordion panels WOOD PIECES WIDTH 2 LENGTH Long enough to fit inside the window frame THICKNESS To determine the thickness place a piece of wood on the stool to make it 1 2 higher than the top of the storm window frame Attach securely with nails or screws provided by the installer 3 Prepare the Air Conditioner suoianijsu Ajajes Al Remove the backing from the top mounting Loosen the lower screw on each side of the case rail seal strip and attach it to the bottom of the and hook a security bracket on each side top mounting rail Tighten the screws to secure the brackets in place CS Security bracket Install the top mounting rail with 3 type A screws from the outside of the case Security bracket Top mounting rail D Insert the frames of the accordion panels into the top and bottom mounting rails Attach the accordion panels to the side of the case using 6 type A screws e 9 S mE a cQ 2 S S N gt 2 D Q 2 Q N Bottom mounting rail To
14. ly to break with repeated use suomanasuj Buijeiad However if you must use an adapter where local codes permit a temporary connection may be made to a properly grounded 2 prong wall outlet by use of a UL listed adapter available at If the adapter ground terminal breaks most local hardware stores DO NOT USE the air conditioner until a The larger slot in the adapter must be aligned proper ground has been established with the larger slot in the wall outlet to provide Attaching the adapter ground terminal to a wall outlet proper polarity in the connection of the power cover screw does not ground the appliance unless the cord cover screw Is metal and not insulated and the wall outlet is grounded through the house wiring You should have the circuit checked by a qualified electrician to make sure the outlet Is properly grounded d al S S 3 m A S S o Vals NDA READ AND FOLLOW THIS SAFETY INFORMATION CAREFULLY CON SAVE THESE INSTRUCTIONS sdij Burjoousajqnoj yioddns sauinsuo4 About the controls on the air conditioner Features and appearance will vary Safety Instructions HI COOL MED COOL MODE CONTROLS Your model will have one of the above type controls Operating Instructions TEMP CONTROLS Your model will have one of the above type controls t S p S S c Controls Mode Controls Temp Controls HIGH COOL MED COOL and LOW
15. ove on some models Open the inlet grille upward by pulling out the bottom of the inlet grille t S p S c Grab the tab on the filter Using the tab pull up slightly on the filter to and pull it to the right release it and pull it down ES 1 Fein LC TES IRE ET mE TE H D m is Qs Y H3 Troubleshooting Tips Consumer Support Front Grille and Case Turn the air conditioner off and remove the plug from the wall outlet before cleaning To clean use water and a mild detergent Do not use bleach or abrasives To remove the front grille On some models remove the knobs and the screw behind the left knob E N On some models remove the knobs filter and screw behind the filter bottom www GEAppliances com Gently but firmly grasp the lower grille corners and pull forward to release C Lift the top of the grille up and off to release from the tabs To replace the grille Al Hook the front of the grille onto the tabs on the top of the case Snap the bottom sides of the grille into the case slots C Replace the screw and attach the knobs suon nnsuj Ajajes Q E S a a cQ A en lt Q o A Y D lt Q A A S lt Q sdij Burjousajqnoj yioddns sauinsuo4 Safety Instructions Operating Instructions t E z c
16. p mounting rail sdij Burjoousajqnoj Accordion panels yioddns sauinsuo4 11 Safety Instructions Operating Instructions V S z S B z S x 7 Troubleshooting Tips Consumer Support Window Installation Instructions 4 Install the Air Conditioner in the Window Cut the window sash seal to the window C Extend the left and right accordion panels width and stick the adhesive side to the to the vertical window sashes and attach bottom of the sash with 4 type B screws Attach the top N mounting rail to the sash with a type NM P screw vx Type Window sash seal Type B Screws B Place the air conditioner on the stool with the bottom mounting rail against its back edge Center it and close the window securely behind the top mounting rail It should be level or slightly tilted to the outside Use a level about a 1 3 bubble will be the correct case slant to the outside Attach the brackets to the stool on both sides using two type D screws 5 Install the Security Bracket and the Foam Top Window Gasket Al Attach a security bracket with a type B screw Cut the foam top window gasket to the window width IC Stuff the foam between the glass and the window to prevent air and insects from getting N PA into the room JAS The installation is now complete 2 Through the Wall Installation Instructions Optional The case may b
17. pose as described in this Owner s Manual This air conditioner must be properly installed in accordance with the Installation Instructions before it is used Never unplug your air conditioner by pulling on the power cord Always grip plug firmly and pull straight out from the receptacle Repair or replace immediately all electric service cords that have become frayed or otherwise damaged Do not use a cord that shows cracks or abrasion damage along its length or at either the plug or connector end HOW IO CONNECT ELECTRICITY Do not under any circumstances cut or remove the third ground prong from the power cord For personal safety this appliance must be properly grounded The power cord of this appliance is equipped with a 3 prong grounding plug which mates with a standard 3 prong grounding wall outlet to minimize the possibility of electric shock hazard from this appliance Have the wall outlet and circuit checked by a qualified electrician to make sure the outlet is properly grounded Where a 2 prong wall outlet is encountered it is your personal responsibility and obligation to have it replaced with a properly grounded 3 prong wall outlet Turn the mode control OFFand unplug your air conditioner before making any repairs or cleaning NOTE We strongly recommend that any servicing be performed by a qualified individual For your safety do not store or use combustible materials gasoline or othe
18. r flammable vapors or liquids in the vicinity of this or any other appliance The air conditioner should always be plugged into its own individual electrical outlet which has a voltage rating that matches the rating plate This provides the best performance and also prevents overloading house wiring circuits which could cause a fire hazard from overheated wires See the Installation Instructions Electrical Requirements section for specific electrical connection requirements www GEAppliances com A WARNING ec USE OF EXTENSION CORDS 115 Volt models only Because of potential safety hazards under certain A conditions we strongly recommend against the CAUTION use of an extension cord suoianijsu Ajajes DO NOT use an extension cord with any of the However if you must use an extension cord 230 208 volt models itis absolutely necessary that it be a UL listed 14 gauge 3 wire grounding type appliance extension cord having a grounding type plug and outlet and that the electrical rating of the cord be 15 amperes minimum and 125 volts 1 USE OF ADAPTER PLUGS 115 Volt models only p Because of potential safety hazards under certain When disconnecting the power cord from the conditions we strongly recommend against the use adapter always hold the adapter in place with of an adapter plug one hand while pulling the power cord plug with the other hand If this is not done the adapter ground terminal is very like
19. r on rainy days The water may overflow and drip from the outdoor side of the unit The fan may run even when the compressor does not Safety Instructions Operating Instructions Installation Instructions Troubleshooting Tips Consumer Support 15 Notes 16 pioddns 1awunsuog T E suononysuy Ajajeg suononysu Guyesadg suonannysuj uonesjeysuy sdi Buroousajqnoa GE Service Protection Plus GE a name recognized worldwide for quality and dependability offers you Service Protection Plus comprehensive protection on all your appliances No Matter What Brand Benefits Include We ll Cover Any Appliance Backed by GE e All brands covered Anywh ere Anyt IIne T Unlimited service calls All parts and labor costs included e No out of pocket expenses No hidden deductibles e One 800 number to call You will be completely satisfied with our service protection or you may request your money back on the remaining value of your contract No questions asked It s that simple Protect your refrigerator dishwasher washer and dryer range TV VCR and much more any brand Plus there s no extra charge for emergency service and low monthly financing is available Even icemaker coverage and food spoilage protection is offered You can rest easy knowing that all your valuable household products are protected against expensive repairs Place your confidence in GE and call us in the U S toll free at
20. rown against the condenser on rainy days or when the humidity is high This design feature helps remove moisture and improve efficiency You may hear the thermostat click when the compressor cycles on and off 14 What To Do e Make sure the air conditioner plug is pushed completely into the outlet e Check the house fuse circuit breaker box and replace the fuse or reset the breaker e If power failure occurs turn the air conditioner OFF When power is restored wait 3 minutes to restart the air conditioner to prevent tripping of the compressor overload e Make sure there are no curtains blinds or furniture blocking the front of the air conditioner e Turn the temperature knob to a higher number e Clean the filter at least every 30 days See the Operating Instructions section e When the air conditioner is first turned on you need to allow time for the room to cool down e Check for open furnace floor registers and cold air returns e Set the air conditioner s vent to the closed position e See Air conditioner freezing up below e Set the mode control at HIGH FAN or HIGH COOL with the temp at Tor 2 e This is normal e For proper water disposal make sure the air conditioner slants slightly from the case front to the rear e This is normal for a short period in areas with little humidity normal for a longer period in very humid areas Water will collect in the base pan during high humidity o
Download Pdf Manuals
Related Search