Dacor OBS36 Gas Grill User Manual
Contents
1. Thank you very much for your assistance The information you have provided will be extremely valuable in helping us plan for the future n i and giving you the support you deserve www Dacor com Corporate Phone 800 793 0093 la A a a a ee See ee cut here aut here2. In order for the U burners and burner box to remain clean the gas burners and the flame spreaders have to be hot enough to vaporize fats oils marinades as they drip upon them Without a proper preheat these materials will collect on both the flame spreader and the burner tubes resulting in partial or total loss of ignition or a decrease in burner performance Always light every burner to generate maximum heat output and to assure even heat distribution Using only one or two burners can eventually result in a buildup of unwanted material and could affect performance NOTE In colder climates the infrared burner may have to be used in order to achieve the preheat temperature Regardless of what you are barbecuing use every burner This assures even heat distribution and also improves grease fat management Using only one or two burners will eventually result in an unwanted buildup of material that might inhibit reliable performance After using the barbecue allow it to continue heating an additional five minutes This allows materials to move to the grease tray and away from the burner area This assures clean burners and a healthy ignition system NOTES 1 Advanced preparation Bring all food items to be grilled to thawed temperature Check to make sure the drip retrieval tray is in position Preheat the grill with the canopy closed to a minimum of 225 degrees or the applicable cooking temperature
3. Do not over fill the LP tank Never fill the tank beyond eighty percent 80 of its capacity Overfilling will cause the pressure relief valve on the tank to vent excess gas vapor This vapor is combustible and can ignite causing a fire When transporting an LP tank ensure it is in an upright position and away from any sources of high heat Do not store additional LP tanks inside the cart of the unit Tanks must be stored outdoors in a well ventilated area out of the direct sunlight and or sources of high heat and out of the reach of children e LP tank supply systems must be arranged for vapor withdrawal LP tank used must include a collar to protect the tank valve IMPORTANT For your safety the gas supply must be turned off at the LP gas supply tank when your grill is not in use The LP gas supply cylinder must be disconnected when this barbecuing appliance is not in use If storing the unit indoors you must detach the LP tank and leave it outdoors This appliance is for outdoor use only Do not store disconnected LP tanks near this or any other appliance Check for leaks after every tank change Grill Features Features OONOARWN gt 15 Rotisserie burner control knob Grill burner control knobs Drip tray Interior lights switch Porcelain grills stainless steel optional Halogen cooking lights Infrared rotisserie burner Canopy mounted temperature gauge Warm rack Rotis
4. THE DISTRICT OF COLUMBIA AND CANADA ALL IMPLIED WARRANTIES INCLUDING BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR USE OR PURPOSE ARE LIMITED IN DURATION TO ONE YEAR FROM THE DATE OF ORIGINAL PURCHASE IN NO EVENT SHALL DACOR BE LIABLE FOR INCIDENTAL EXPENSE OR CONSEQUENTIAL DAMAGES NO WARRANTIES EXPRESS OR IMPLIED ARE MADE TO ANY BUYER FOR RESALE Some states do not allow limitations on how long an implied warranty lasts or do not allow the exclusion or limitation of inconsequential damages so the above limitations or exclusions may not apply to you This warranty gives you specific legal rights and you may also have other rights that vary from state to state fold here NO POSTAGE NECESSARY IF MAILED IN THE UNITED STATES BUSINESS REPLY MAIL FIRST CLASS MAIL PERMIT NO 4507 DIAMOND BAR CA POSTAGE WLL BE PAID BY ADDRESSEE DACOR INC ATTN WARRANTY PROCESSING DEPT 1440 BRIDGE GATE DR STE 200 PO BOX 6532 DIAMOND BAR CA 91765 9861 Please visit www Dacor com to activate your warranty online dacor WARRANTY INFORMATION Web Site IMPORTANT Your warranty will not be activated until you activate it online or return this form to Dacor If you have purchased more than one Dacor product please return all forms in one envelope or activate the warranty for each product online Please rest assured that under no conditions will Dacor sell your name or any of
5. including the burners are warranted against rust through OUTSIDE THE FIFTY STATES OF THE U S A THE DISTRICT OF COLUMBIA AND CANADA LIMITED FIRST YEAR WARRANTY If your DACOR product fails to function within one year of the original date of purchase due to a defect in material or workmanship DACOR will furnish a new part F O B factory to replace the defective part All delivery installation and labor costs are the responsibility of the purchaser The owner must provide proof of purchase upon request and have the appliance accessible for service What is Not Covered Failure of the product caused by faulty installation improper usage or neglect of required maintenance Service calls to educate the customer in the proper use and care of the product Failure of the product when used for commercial business rental or any application other than for residential consumer use Replacement of house fuses or fuse boxes or resetting of circuit breakers Damage to the product caused by accident fire flood or other acts of God Breakage discoloration or damage to glass metal surfaces plastic components trim paint or other cosmetic finish caused by improper usage or care abuse or neglect THE REMEDIES PROVIDED FOR IN THE ABOVE EXPRESS WARRANTIES ARE THE SOLE AND EXCLUSIVE REMEDIES THEREFORE NO OTHER EXPRESS WARRANTIES ARE MADE AND OUTSIDE THE FIFTY STATES OF THE UNITED STATES
6. Ensure that the type of grill matches the gas supply natural gas or LP do not attempt to covert from one type to the other Check installation replace regulator or set regulator for proper gas type Contact gas company have incoming gas pressure tested Remove obstruction Check installation dimensions against installation instructions Brush U burner with a steel brush and clear blockage with a toothpick or metal object straightened paper clip needle or wire Have polarity corrected Dry ignitors or clean ignitors with a metal brush to remove any residue Contact gas company have incoming gas pressure tested The grill burners can be manually ignited with a match or the hand spark ignitor supplied with the unit Refer to Manual Lighting section on page 4 Product Maintenance No maintenance other than the CARE AND CLEANING INSTRUCTIONS identified in this Use amp Care Manual should be attempted by the owner operator All other maintenance and service must be performed by a qualified appliance technician If You Need Service First review the recommended checks listed in the Before You Call for Service section Then be certain that the appliance has been installed properly and is being operated correctly Familiarize yourself with the warranty terms and conditions listed in the PRODUCT WARRANTY section on the inside back cover If the above check
7. canopy to full open position Turn on the main tank valve Light one grill burner at a time by pressing in on the control knob and turning it counter clockwise until you hear the clicking ignition sound Your burner should ignite within 4 to 10 seconds Repeat the last step with all control locations Lighting Natural Gas Grills Al WARNING Open canopy before attempting to light the appliance Failure to open the canopy could allow gas to accumulate which could cause an explosion NOTES Reference your installation instructions for proper natural gas line connections to the Dacor regulator 2 Once you have confirmed that the electrical and gas are properly installed begin the following processes Open the canopy to full open position Light one grill burner at a time by pressing in on the control knob and turning it counter clockwise until you hear the clicking ignition sound Your burner should ignite within 4 to 10 seconds Repeat the last step with all control locations If ignition does not immediately take place turn the burner valve handle off wait 5 minutes and repeat the lighting procedure Manual Lighting P WARNINGS FOR YOUR SAFETY FOLLOW THESE STEPS BEFORE ATTEMPTING A MANUAL LIGHTING PROCESS 1 Turn all control knobs to OFF position 2 Raise the canopy to its full open position NOTES Remove all of the grills t
8. for the food you are preparing 2 Begin the cooking process Once you have achieved the appropriate temperature for your chosen recipe place the food product on the grill and begin the timing process 3 After completion of cooking Remove the food to serve and close the canopy for a safer environment Smoker Cooking A WARNINGS Smoker cooking is done with the canopy in the down position Smoke will be exhausting through the grill vents Do not block vents Blocking vents will damage the unit and may cause fire or injury 2 Smoker wood chips are soaked with liquids which create steam and smoke while barbecuing Proceed with caution during cooking This steam can be very hot and dangerous 3 Frequently the smoker box will need to be refilled during cooking It will be extremely hot Exercise caution during this process Steam and hot metal surfaces can cause personal injuries and possible fire NOTES Smoker cooking enhances the flavors of food during grilling or rotisserie cooking Your Dacor smoker box is a removable accessory that is shipped with your originally purchased grill product 3 The smoker should be filled with your choice of wood chips Once you have prepared the wood and smoker box for use while the grill is still cool select a direct or indirect cooking location then place the smoker box appropriately 5 To place the smoker box correctly Determi
9. off the gas at the main valve open the canopy and dissipate for at least five minutes Relight the burners and verify that they are operating properly If the burners fail to light or are not functioning properly shut off the main gas supply valve and call your local service agency for inspection Never block any of the vents located on the inside or outside of the appliance including the ones under the control panel Blocking any of these vents will result in damage to the unit and may cause a fire or injury Liquid Propane Tanks Dacor LP model grills are set at the factory for LP tank installations Use only the Dacor supplied regulator DO NOT ATTEMPT FIELD CONVERSIONS FROM LP TO NATURAL GAS OR FROM NATURAL GAS TO LP Dacor grills are approved for a maximum LP tank capacity of 20 pounds 5 gallons The tank must be constructed and marked in accordance with the specifications for LP gas tanks of the U S Department of Transportation DOT or the National Standard of Canada CAN CSA B339 tank Spheres and Tubes of the Transportation of Dangerous Goods To minimize the potential for fire or an explosion the following precautions should be observed when using filling or storing an LP tank Never use a dented or rusty LP tank If there is any question as to the soundness of the tank have it checked by your LP supplier Never use a tank with a damaged or defective shut off valve
10. use a damaged appliance NEVER cover any slots holes or passages on the appliance including the slots under the bottom of the control panel Doing so blocks air flow through the grill and may cause carbon monoxide poisoning Aluminum foil linings may also trap heat causing a fire hazard Keep all slots holes and passages clear of grease and grime A MINIMUM clearance of 10 inches 254mm must be maintained above the countertop material from all combustible vertical materials on the sides and behind the grill chassis and canopy On all models except OBSB162 a MINIMUM clearance of 1 1 4 inches 32mm must be maintained above the countertop material from all non combustible vertical materials on the sides and behind the grill chassis and canopy 12 13 14 15 16 17 18 19 20 21 22 23 24 25 On model OBSB162 a MINIMUM clearance of 2 inches 51mm must be maintained above the countertop material from all non combustible vertical materials on the sides and behind the appliance A MINIMUM clearance of 1 4 inch 6mm must be maintained inside the base enclosure below the countertop material from all vertical surfaces on the sides of the appliance except on model OBSB162 On OBSB162 1 4 inch minimum at the back 1 16 inch minimum clearance on the sides Do not locate this outdoor appliance under overhead unprotected combustible surfaces Keep the area a
11. No Date Purchased Purchased From Important Instructions cont Important Instructions cont 10 11 Do not store or use gasoline or other flammable liquids in the vicinity of the appliance Keep aerosol cans away from the appliance If you smell gas Shut off gas to the appliance Extinguish any open flame Open the grill lid If odor continues from a neighbor s phone immediately call your gas supplier If you cannot reach your gas supplier call the fire department Installation and service must be performed by a qualified installer service agency or the gas supplier This unit is for outdoor use only in a well ventilated area Not to be used in a building garage or any other enclosed area Tested in accordance with ANSI Z21 58 1998 standard for outdoor cooking gas appliances and CAN CGA 1 6 M98 standard for outdoor cooking gas appliances Check your local building codes for proper method of installation In the absence of local codes this unit should be installed in accordance with National Fuel Gas Code No Z223 1 Current Issue and National Electrical Code ANSI NFPA No 70 Current Issue or the CAN CGA B149 1 Natural Gas Installation Code or CAN CGA B149 2 Propane Gas Installation Code and C22 1 Canadian Electrical Code Part 1 If you received a damaged product immediately contact your dealer or builder Do not install or
12. Use amp Care Manual Epicure Outdoor Grill Covers Models OB36 OBS36 OB52 OBS52 OBSB162 gacor The Life of the Kitchen SAFETY IS EVERYONE S RESPONSIBILITY ALL DACOR APPLIANCES ARE DESIGNED IMPORTANT INFORMATION AND CONSTRUCTED TO GIVE YOU MANY YEARS OF SAFE OPERATION THE e Operating Instructions OPERATION WILL BE FURTHER ENHANCED IF PROPER CARE AND JUDGEMENT ARE e Care and Cleaning Instructions EXERCISED IN THE USE AND MAINTENANCE OF THIS APPLIANCE e Safety Tips WARNINGS Must be followed carefully to avoid personal injury or damage or Grill NOTES tdo ur Out Contains helpful hints and tips Vout e Using Read please Place Serial Number Label Here ey ees are eh eee E E ce ee ee ee ee ee E Part No 102033 Rev E The Life 0 To Our Valued Customer nique combination of features style and ur purchase of the very latest in Dacor products Our u Congratulations on yo our home performance make US The Life of the Kitchen and a great addition to Y ctive Appliance we urself with the controls functions and full potential of your new Distin n order to familiarize YO suggest that you thoroughly read this use amp care manual beginning with the Important Safety Instructions section manufactured with quality and pride while working within the framework of our All Dacor appliances are designed and Should you ever experience a problem with your
13. aners or Mild abrasive cleaners For stubborn areas use the Dacor Cooktop Cream supplied with the grill Liberally apply the cleaner to a wet sponge For best cleaning results thoroughly rinse off all residue 2 Porcelain grills etc Non abrasive cleaners Mild abrasive cleaners 3 Brass Burner Caps Mild abrasive cleaners Do not place burner caps in the dishwasher for cleaning 4 Plastic knobs Non abrasive cleaners warm water with dish soap Al IMPORTANT To assist in the removal of the halogen light lens Dacor has included a pry stick Gently slip the pry stick under the edge of the glass and pry away until the glass lifts Remove the remaining distance by hand NOTES To assist you please refer to the list below for the suggested cleaning procedures 1 Stainless Steel heat control channels burner box optional stainless grills Mild abrasive cleaners De greasors such as 409 Abrasive cleaners limited applications Dacor Cooktop Creme and wet sponge 2 Stainless Steel burners Mild abrasive cleaners Abrasive cleaners limited applications 3 Glass light lens Non abrasive cleaners Glass cleaners are acceptable Warm soapy water Dacor Cooktop Cleaning Creme Before You Call for Service Unnecessary service calls may be expensive frustrating and time consuming Before you call for service please review the potential problems possible ca
14. e allowed to crawl inside the grill cart Remember when in use the grill will get hot enough to cause severe burns 6 Avoid the potential for grease fires by frequently cleaning the grease tray Always allow the unit to completely cool down before removing the grease tray for cleaning 7 Keep hands and fingers away from all edges of the canopy while in the raised position 8 Never move the grill during cooking 9 Always keep the canopy closed when moving the grill cart 10 Spiders and insects can nest in the burners of this grill This can obstruct the proper flow of gas into the burner and cause improper operation fire hazard and potential damage to the unit Periodically inspect the burners If any of these symptoms occur immediately refer to service or the troubleshooting section of this manual 11 Your outdoor grill is equipped with a three prong grounding plug to protect animals against shock hazard This plug should be plugged directly into a properly grounded three prong receptacle Never cut or remove the grounding prong from this plug 12 The grill canopy should be closed during the pre heating period 13 14 Gas Smells If you smell gas when the unit is not in use immediately shut off the gas at the main valve open the canopy and call your local service agency to inspect the unit Finding a leak is not a do it yourself process If you smell gas when the unit is in use immediately shut
15. eheating Instructions oP Grill Cooking Smoker Cooking Rotisserie Cooking Side Burners 0 CARE AND CLEANING cc css Cleaning TIS dniiaen seis EXTERIOR SURFACEG cccccsssssssseseennees INTERIOR SURFACEG cccssssssssseeseesneens BEFORE YOU CALL FOR SERVICE Troubleshooting eee eeeeeeeeeeeeeeeeee Product Maintenance If You Need Service ccccccccccessceesseeeeeeee PRODUCT WARRANTY ccccsssssssseseesnees What Is Covered as What Is Not Covered cccccccccssccsesseeeesees Purpose of This Manual This Use amp Care Manual is designed to enable you to properly operate and maintain your new grill Please keep this manual handy for easy access and quick reference Additional information may be requested by e mailing writing or phoning the Dacor Customer Service Team The address and phone number of this department are listed on the inside front cover of this manual Important Instructions VN WARNING NEVER use this appliance as a space heater to heat or warm the room Doing so may result in carbon monoxide poisoning and overheating of the appliance 7N WARNING 1 If the information in this manual is not followed exactly a fire or explosion may result causing property damage personal injury or death Important Information Model
16. nd nylon pad for cleaning Avoid the use of abrasive cleaners such as steel wool 5 Always dry components completely before using the grill 6 The use of brand names is intended only to indicate a type of cleaning agent or cleaning implement All products listed by name must be used in accordance with the manufacturer s recommendations Use of a brand name does not constitute an endorsement nor does omission of a particular brand imply that a product is inferior 7 After the smoker box and the wood remnants inside are cool remove it for cleaning Dump out the wood remnants and wash the smoker box with warm water and dish soap Rinse the box well and dry it Do not dump the remnants until they are cool Exterior Surfaces Interior Surfaces Al IMPORTANT 1 Turn the knobs to the OFF position prior to removing them from the valve stems 2 The grill should never be operated without the knobs in place 3 Do not soak the knobs in water or place them in the dishwasher 4 Do not expose the knobs to direct flame hot utensils or other sources of heat 5 Do not use abrasive or corrosive cleaners or applicators as these could cause permanent damage NOTE Cleaning stainless steel varies with each part of the grill To assist you please refer to the list below for the suggested cleaning procedures 1 Stainless Steel canopy chassis Wipe with the grain Non abrasive cle
17. ne desired smoker location Remove one small grill and the even heat channel The grills 2 gt and even heat channels may be moved to create a smoker opening anywhere across the full width of the unit except over the sear burner Place smoker in the opening 6 Turn on the burner to maximum HI temperature Leave the burner on high until the chips begin smoking Then turn the heat down where the chips don t dry out or flame up 7 Recipes with long time duration will require the addition of wood and liquid to the smoker box Remember every additional time you open the grill canopy and smoker box you will extend your recipe cooking times Rotisserie Cooking P WARNING This unit is equipped with a 3 prong grounding plug for your protection against shock hazard and should be plugged directly into a properly grounded receptacle Do not cut or remove the grounding prong from this plug Do not allow the rotisserie electrical cord to touch any heated surface of your grill Al CAUTION 1 Cooking with the rotisserie burner is not recommended during high wind 2 If any flame is blown out during windy conditions and does not automatically re ignite within 5 to 7 seconds turn off the control and attempt a new ignition until you hear the constant clicking stop and you see flame ignition NOTES Rotisserie cooking utilizes the intense searing heat of the infrared burner and constan
18. o access the heat control channels 2 Find the hole in the front of the heat control channel located directly behind the front control panel 3 Use the match holder provided or a long stem match to light the grill burners manually 4 Push in on the control knob and turn counter clockwise while inserting the burning match into the access hole in the heat control channel This should immediately result in ignition If you do not experience immediate ignition turn the control back to the off position 5 After waiting for 2 to 3 minutes begin the process with step 4 6 If you cannot achieve ignition after two attempts turn off all gas to the product and immediately call your authorized Dacor Customer Service Team for a service call Access Hole for Manual Lighting Canopy Mounted Temp Gauge Grill Cooking NOTES Your Dacor grill is equipped with a canopy mounted thermometer to assist you in various grill functions Preheating is an important part of proper grilling preheat to approximately 225 degrees Smoking foods heat to a temperature range from 225 to 300 degrees Grilling all types of foods vary temperatures as needed from 225 to 500 degrees 2 We recommend these temperatures as approximations Preheating Instructions NOTE When preheating set burners on high Following preheat adjust burners to desired temperature setting
19. or future use This information will be required in the unlikely event that a service call becomes necessary Serial No Date Installed Safety Al IMPORTANT Your Dacor grill is designed to be safe when installed properly However care must be used as these grills can produce very high temperatures which increases the potential for injury or accidents We recommend you always follow the safety notes listed below NOTES Carefully read this manual before using the grill this will reduce the risk of injury due to fire or electric shock 2 Proper installation is extremely important Refer to the installation instructions included within the literature kit which shipped with your grill Your installer should show you the location of the gas shut off valve and the electrical connection You should also be familiar with the correct and easiest way to shut off these utilities in case of an emergency Minimum clearances to combustible materials should always be observed Reference the correct clearances in the installation instructions 3 For proper outdoor grill operation and drawer operation on units with a cart use the outdoor grill only on a level surface 4 Repair and replacement of any parts within this appliance should be referred to an authorized Dacor service technician 5 Children should never be allowed to sit stand or play around the grill at any time Children should never b
20. product please first check the Before You Call for provides useful suggestions and remedies prior to calling for service company value Service section of this manual for guidance Mt prove our products and services so please feel free to contact of your product support needs Valuable customer input helps us tio continuously im our Customer Service Team for assistance with any Dacor Customer Service 4440 Bridge Gate Drive Diamond Bar CA 91765 Telephone 800 793 0093 Fax 626 403 3130 Hours of Operation Monday through Friday 6 00 A M to 5 00 PM pacific Time Web Site www Dacor com Thank you for choosing Dacor for your home We are a company puilt by families for families and we are dedicated ur new Dacor product will deliver a nigh level of performance and to serving yours We are confident that yO enjoyment for many years to come sincerely Cheryl Crowe Director Customer Satisfaction TABLE OF CONTENTG cccescsssssteseeneeees IMPORTANT INSTRUCTIONS Purpose of this Manual eee IMPORTANT INFORMATION ccccsseseees Liquid Propane Tanks Grill Cart Features ee Install Liquid Propane Tank Lighting Liquid Propane Grills eee Lighting Natural Gas Grills aoe Manual Lighting 0 0 eee eeeeeeeees Canopy Mounted Temperature Gauge Pr
21. round the appliance clear and free from combustible materials gasoline and other flammable liquids This outdoor gas cooking appliance is not intended to be installed in or on a recreational vehicle or boat Do not leave the grill unattended while cooking Do not place any items in front of the unit while in use This could obstruct the proper flow of air needed for combustion and ventilation Keep the ventilation openings of the enclosure free and clear of obstructions and debris Always inspect the natural gas or LP gas hose assembly before each use of the appliance If you see evidence of abrasion wear or a cut gas connection hose then immediately replace the hose prior to operation of the appliance Keep any electrical supply cords and the fuel gas supply lines away from heating surfaces When the LP gas cylinder is enclosed it must be ventilated by openings on the sides back and floor of the enclosure Each opening must have a total area of no less than 10 square inches On models OB52 and OBS52 use only a two stage regulator on the gas supply line Do not install repair or replace any part of the range unless specifically recommended in the literature accompanying it A qualified service technician should perform all other service Before performing any type of service make sure that the gas supply and electrical power to the appliance is turned off Please enter the information in the spaces provided below f
22. s have been completed and the problem has not yet been remedied call your local authorized DACOR service representative Your dealer can normally provide the name and telephone number of the nearest service company DACOR works diligently to ensure your satisfaction when service is necessary However if you are not completely satisfied with the service provided contact the company that performed the service and express why you are not pleased Normally they will be willing and able to resolve the problem If the service agency is not able to respond effectively call or write the DACOR Customer Service Team The phone number and address of this department are listed on the inside front cover of this manual Please include your telephone number if you choose to write We will then do our utmost to assure your happiness and satisfaction What is Covered CERTIFICATE OF WARRANTIES DACOR EPICURE GRILLS WITHIN THE FIFTY STATES OF THE U S A THE DISTRICT OF COLUMBIA AND CANADA ONE YEAR FULL WARRANTY If your DACOR product fails to function within one year of the original date of purchase due to a defect in material or workmanship DACOR will remedy the defect without charge to you or subsequent users The owner must provide proof of purchase upon request and have the appliance accessible for service FIVE YEAR LIMITED WARRANTY Rotisserie burner LIFETIME WARRANTY All stainless steel components
23. serie rod and forks Rotisserie motor Rotisserie motor bracket Removable smoker box not shown U shaped burners under Heat control channels three on OB36 two on OBS36 Sear burner OBS36 and OBS52 only OB52 and OBS52 only 16 17 18 Side burner control knobs Side burners Side burner grate Roll out storage Drawers 2 lt a Roll out LP tank shelf A ot Locking wheel Freestanding Cart Locking Model OBC36 wheel Roll out storage Drawers 2 Roll out F Locking LP tank wheel Locking heel Freestanding Cart a Model OBC52 Warming Drawer Roll out storage drawers Locking wheel Freestanding Cart Model OBC W52 Install Liquid Propane LP Tank Gas Connection at Right Rear Corner Under Outdoor Grll Tank Gas Regulator included LP Tank Valve Flexible Gas Slideout LP Tank Line included Storage Self on Optional Cart LP Tank not included 5 Gal Max Shelf Capacity Installing the LP Tank Lighting Liquid Propane Grills Al WARNING Open canopy before attempting to light the appliance Failure to open the canopy could allow gas to accumulate which could cause an explosion NOTES 1 Reference your installation instructions for proper LP gas line connections to the Dacor regulator and the Main tank valve 2 Once the tank is properly installed Open the
24. ssive heat contact with the cover may cause permanent discoloration 1 Largest recommended pot for these burners is 14 inches in diameter Larger pots may contact the grill canopy during opening and closing 2 Automatic re ignition systems will ignite an extinguished flame 3 Do not operate the side burner in windy conditions 4 The porcelain burner grate is durable however continuous sliding of pots can remove surface material 5 A stainless steel side burner cover is made to cover the burner grate and burners when not in use Cleaning Tips P WARNING To avoid electric shock or burns turn off all controls and ensure the grill is cool before cleaning Do not store any type of cleaning products around the grill NOTES Read and follow the CARE AND CLEANING INSTRUCTIONS to ensure that proper grill operation and appearance will be maintained throughout the lifetime of the product Several materials and finishes are used in the grill Each material and finish must be properly cleaned according to the following recommendations Failure to follow these recommendations may result in permanent damage to the grill 2 To keep the grill looking it s best clean it after every use 3 Use the mildest cleaners or procedure available to perform the cleaning operation Do not use commercial cleaners to clean any part of the grill 4 Use only a sponge soft cloth fibrous or plastic brush a
25. t rotisserie rod rotation to cook many different types of meat 2 Rotisserie burner operation Rotisserie burner requires no pre heating Rotisserie burner can be used in conjunction with grill burners and smoker box Push control knob and rotate 1 4 turn to the left igniters will spark If ignition does not immediately take place within 4 10 seconds turn burner knob off wait 5 minutes and repeat lighting procedure 3 Rotisserie Motor and Rotisserie Rod Prepare the grill for rotisserie cooking by following these steps Install the motor mounting bracket and motor by slipping the edge of the bracket down into the slot at the right side edge of the grill frame as shown below Plug the motor power cord into 120 VAC grounded receptacle Keep the cord away from all heated surfaces Load your menu items on the rotisserie rod Insert one side of the loaded rotisserie rod into the rod drive hole on the side rotisserie motor Put the other side of the rod on the roller bearings on the left wall Double check all rotisserie forks and locking screws for tightness to assure items will not move during rotation Turn on the motor and observe several rotations to confirm the food is stable then close the canopy completely and you are cooking Rotisserie Installation Side Burners Select Models Only Al IMPORTANT Do not place the burner cover over the burners while hot Exce
26. the information on this form for mailing list purposes We are very grateful that you have chosen Dacor products for your home and do not consider the sale of such information to be a proper way of expressing our gratitude Owner s Name Last Please Print or Type First Middle Street City State Zip Purchase Date Email Telephone Dealer City State Zip Your willingness to take a few seconds to fill in the section below will be sincerely appreciated Thank you 1 How were you first exposed to Dacor products Please check one only QO A T V Cooking Show Q F Builder Q B Magazine a G Architect Designer QO C Appliance Dealer Showroom QC H Another Dacor Owner QO D Kitchen Dealer Showroom QO Model Home QO E Home Show QO J Other 2 Where did you buy your Dacor appliances QO A Appliance Dealer Q D Builder QO B Kitchen Dealer Q E Other Q C Builder Supplier 3 For what purpose was the product purchased QO A Replacement only C C New Home QO B Partofa Remodel OQ D Other 4 Whatis your household income CH A Under 75 000 QO D 150 000 200 000 QO B 75 000 100 000 Oh E 200 000 250 000 QO C 100 000 150 000 Qh F Over 250 000 5 What other brands of appliances do you have in your kitchen A Cooktop C Dishwasher B Oven D Refrigerator 6 Would you buy or recommend another Dacor product QO Yes Q No Comments
27. uses and remedies shown in the table below Problem 1 Nothing works 2 Ignitors do not spark 3 Sparking but no flame 4 Burners ignite but flame is extremely large distorted or yellow 5 Burner flame goes out at low setting 6 Ignitors spark continuously after flame ignition Possible Cause Grill is not connected to electrical power Power supply is not energized Circuit breaker is tripped House fuse is blown Gas shut off valve is in off position Ports on U burner are clogged or dirty Ports on U burner are clogged or dirty Grill is being operated on wrong type of gas Regulator is not installed is faulty or is set for the wrong type of gas Low gas pressure Air intake holes under the control panel are obstructed Incorrect installation Ports on U burner are clogged or dirty at ignition location Power supply polarity is reversed Ignitors are wet or dirty Low burner flame Have grill connected to the proper electrical supply by a qualified electrician or appliance installer Check circuit breaker wiring fuses plugs etc Reset circuit breaker Replace house fuse Turn shut off valve to on position Brush U burner with a steel brush and clear blockage with a toothpick or metal object straightened paper clip needle or wire Brush U burner with a steel brush and clear blockage with a toothpick or metal object straightened paper clip needle or wire
Download Pdf Manuals
Related Search