Home

Breville ESP8XL Espresso Maker User Manual

image

Contents

1. MAINTENANCE AIR CLEANER CAUTION Do not use pressurized air or solvents to clean cartridge Pressurized air can damage cartridge solvents will dissolve cartridge FLAT AIR CLEANER REMOVAL INSTALLATION 1 Pull up on air cleaner cover handle and rotate toward engine 2 Remove air cleaner cover 3 Carefully lift air cleaner cartridge and pre cleaner if equipped from blower housing Note To clean pre cleaner wash in soapy water Squeeze dry in aclean cloth DO NOT OIL 4 Clean base of air cleaner cartridge area carefully to prevent debris from entering engine 5 Place air cleaner pre cleaner if equipped and cartridge into blower housing Cartridge must fit securely in base 6 Align tabs on cover with slots of blower housing and replace cover 7 Hook handle and close cover PRE CLEANER if equipped CARTRIDGE EXTENDED LIFE SERIES CARTRIDGE ONLY This filter IF STAMPED WASH ABLE can be washed with warm water and mild soap IMPORTANT Rinse in tap water with SCREEN side up allowing dirt and debris to filter out Leave filter to dry overnight before reinstalling 12 OVAL AIR CLEANER REMOVAL INSTALLATION 1 2 3 Remove cover knob and cover Remove cartridge knob Carefully lift air cleaner assembly pre cleaner if equipped and cartridge from base over stud Note To clean pre cleaner if equipped separate it from cartridg
2. WARNING Engine parts should be kept clean to reduce the risk of overheating and ignition of accumulated debris This is especially important if cutting tall grass CAUTION Do not use water to clean engine parts Water could contaminate fuel system Use a brush or dry cloth CLEAN Finger Guard Rotating Screen 14 If you perform any maintenance on the engine first disconnect the spark plug wire from the spark plug and disconnect the battery at the negative terminal electric starter engines only to prevent unintentional sparking Unintentional sparking can result in fire or electric shock Unintentional start up can result in entanglement traumatic amputation or laceration Use only correct tools e Do not strike the flywheel with a hammer or hard object because the flywheel may later shatter during operation e Do not tamper with governor spring links or other parts to increase engine speed REPLACE FUEL FILTER if equipped EXTENDED LIFE SERIES FUEL FILTER PART NO 695666 OR 5070 j WITH FUEL PUMP Drain fuel tank or close fuel shut off valve before replacing fuel filter Otherwise fuel can leak out creating a fire ex STANDARD FUEL FILTER PART NO 394358 WITH FUEL PUMP PART NO 298090 OR 5018 f WITHOUT FUEL PUMP plosion hazard ue HOSE AIR COOLING SYSTEM CLEAN OUT CHAFF AND DEBRIS Debris may clog the en gine s air cooling syste
3. Operating amp Maintenance Instructions BRIGGS amp STRATTON Model Series Covered in This Manual 210000 280000 310000 gt Month Day Year Note General Model Series numbers noted above are inclusive of the specific model number found on your engine To get replacement parts or technical assistance in the future write your engine Model Type Code and date of purchase here TABLE OF CONTENTS Briggs amp Stratton does not approve or authorize the use of Engine Information these engines on 3 wheel All Terrain Vehicles ATVs motor bikes aircraft products or vehicles intended for use in competitive events Use of these engines in such applications could result in property damage serious injury including paralysis or even death Fuel and Starting Information Starting and Stopping Maintenance Need assistance Go to www briggsandstratton com Adjustments for detailed information regarding Parts and Service amp Storage Briggs amp Stratton engines Warranty Information Or call 1 800 233 3723 U S A and Canada to hear a menu of pre recorded messages offering engine maintenance information PRINTED IN U S A Copyright 2003 by Briggs amp Stratton Corporation FORM NO 275038 8 03 BRIGGS amp STRATTON The Power That Works For You Look For Relevant Emissions Durability Period and Air Index Information On Your Engine Emissions Label Engines that are certified to meet the Cal
4. on site power This difference is due to a variety of factors including but not limited to the following BRIGGS amp STRATTON BRIGGS amp STRATTON Unintentional sparking can result in fire or electric shock Unintentional start up can result in en tanglement traumatic amputation or lac eration BEFORE PERFORMING ADJUSTMENTS OR REPAIRS e Disconnect spark plug wire and keep it away from spark plug e Disconnect battery at negative terminal only engines with electric start WHEN TESTING FOR SPARK e Use approved spark plug tester e Do not check for spark with spark plug removed ENGINE INFORMATION differences in altitude temperature barometric pressure humidity fuel engine lubrication maximum governed engine speed individual engine to engine variability design of the particular piece of power equipment the manner in which the engine is operated engine run in to reduce friction and clean out of combustion chambers adjustments to the valves and carburetor and other factors The power ratings may also be adjusted based on comparisons to other similar engines utilized in similar applications and will therefore not necessarily match the values derived using the foregoing codes ENGINE INFORMATION Oil drain Oil fill Dipstick Rotating screen Blower housing Muffler Muffler guard if equipped Spark arrester if equipped 12 V electric starter
5. DES 356 951 DES 361 771 DES 375 963 Cette page ne s applique que pour le Canada et les Etats Unis La Corporation Briggs amp Stratton B amp S le California Air Resources Board CARB et le Bureau de protection environnementale des Etats Unis US EPA Garantie sur le systeme d chappement Garantie contre les d fectuosit s droits et obligations du propri taire LA GARANTIE SUR LE SYST ME D CHAPPEMENT EST APPLICABLE SUR LES MOTEURS VANTES QUI ONT ETE ACHETES ET UTILISES AILLEURS AUX ETATS UNIS ET APRES LE 1ER CERTIFIES ACHETES EN CALIFORNIE EN 1995 ET LES ANNEES SUIVANTES ET QUI SONT UTI JANVIER 2001 AU CANADA LISES EN CALIFORNIE AINSI QU AUX MOD LES CERTIFI S DE 1997 ET LES ANN ES SUI D claration de garantie sur le syst me d chappement pour la Californie les Etats Unis Le California Air Resources Board CARB le Bureau am ricain de protection environnementale pement de votre moteur pour la p riode de temps mentionn e ci contre sauf s il a fait l objet U S EPA et B amp S sont heureux d expliquer la garantie sur le syst me d chappement des petits d abus de n gligence ou d un entretien inappropri moteurs hors route de votre mod le 2000 et des ann es ult rieures SORE En Californie les Votre syst me de contr le d chappement comprend des pi ces telles que le carburateur le filtre nouveaux petits moteurs hors route doivent tre con us construits et quip s pour rencontrer les air
6. ont t modifi es ou de pi ces qui ne sont pas des pi ces B amp S d origine e Bougies d allumage e Syst me d allumage lectromagn tique 5 Entretien d Syst me catalyseur Toute pi ce sous garantie qui n est pas remplac e au moment requis selon le manuel d entre e Convertisseur catalytique tien ou qui est planifi e seulement pour une inspection r guli re sous la mention r parer ou e Collecteur d chappement remplacer si n cessaire est garantie contre toute d fectuosit pour la p riode de garantie Toute pi ce sous garantie qui est planifi e pour un remplacement tel que requis dans l entre e Syst me d injection d air ou pulsion AN tien est garantie contre toute d fectuosit seulement pour la p riode de temps qui va jusqu au e Autres pi ces utilis es dans les syst mes ci haut mentionn s premier remplacement pr vu pour cette pi ce Toute pi ce de remplacement quivalente en e Soupapes et interrupteurs de d pression de temp rature de position performance et durabilit peut tre utilis e pour l entretien ou la r paration Le propri taire est e Connecteurs et assemblages responsable de l ex cution de tout entretien requis tel que d fini dans le manuel d instruction 2 Dur e de la couverture B amp S sur l entretien et la r paration B amp S garantit le propri taire initial et tous les acheteurs subs quents que les pi ces sous ga 6 Couverture indirecte rantie sont exemptes de vice de mati
7. 679 5 320 795 5 271 363 5 269 713 5 265 700 5 243 878 5 235 943 5 197 425 5 197 422 5 191 864 5 188 069 5 186 142 5 138 996 5 086 890 5 070 829 5 058 544 5 040 644 5 009 208 4 996 956 4 977 879 4 971 219 4 895 119 4 819 593 4 719 682 set forth in the B amp S Engine Warranty Policy B amp S is not liable to cover failures of War ranted Parts caused by the use of add on non original or modified parts 5 Maintenance Any Warranted Part which is not scheduled for replacement as required maintenance or which is scheduled only for regular inspec tion to the effect of repair or replace as nec essary shall be warranted as to defects for the warranty period Any Warranted Part which is scheduled for replacement as re quired maintenance shall be warranted as to defects only for the period of time up to the first scheduled replacement for that part Any replacement part that is equivalent in perfor mance and durability may be used in the per formance of any maintenance or repairs The owner is responsible for the perfor mance of all required maintenance as de fined in the B amp S Operating and Maintenance Instructions 6 Consequential Coverage Coverage hereunder shall extend to the fail ure of any engine components caused by the failure of any Warranted Part still under warranty 4 633 556 4 630 498 4 522 080 4 520 288 4 512 499 4 453 507 4 430 984 DES 308 871 DES 308 872 DES 309 457
8. COMPLIANCE PERIOD CATEGORY C 275038 A Li BEFORE OPERATING ENGINE e Read entire Operating amp Maintenance Instructions AND the instructions for the equipment this engine powers e Failure to follow instructions could result in serious injury or death THE OPERATING amp MAINTENANCE INSTRUCTIONS CONTAIN SAFETY INFORMATION TO e Make you aware of hazards associated with engines e Inform you of the risk of injury associated with those hazards and e Tell you how to avoid or reduce the risk of injury The safety alert symbol is used to identify safety HAZARD SYMBOLS AND MEANINGS information about hazards that can result in personal injury A signal word DANGER WARNING or CAUTION is W used with the alert symbol to indicate the likelihood and the potential severity of injury In addition a hazard symbol Explosion Moving Parts may be used to represent the type of hazard A DANGER indicates a hazard which if not ponm avoided will result in death or serious injury Toxic Fumes fat Surace Shock A WARNING indicates a hazard which if not Nc avoided could result in death or serious injury Kickback A CAUTION indicates a hazard which if not avoided might result in minor or moderate injury THE INTERNATIONAL SYMBOLS USED ON THE ENGINE OR CAUTION when used without the alert symbol IN THIS MANUAL INCLUDE indicates a situation that could result in damage to the engine The engine
9. caught Engines give off carbon monoxide an odorless colorless poison gas Breathing carbon monoxide can cause nausea fainting or death e Start and run engine outdoors e Do not start or run engine in enclosed area even if doors or windows are open Running engines produce heat Engine parts especially muffler become extremely hot Severe thermal burns can occur on contact ai Combustible debris such as leaves grass brush etc can catch fire e Allow muffler engine cylinder and fins to cool before touching e Remove accumulated combustibles from muffler area and cylinder area e Install and maintain in working order a spark arrester before using equipment on forest covered grass covered brush covered unimproved land The state of California requires this Section 4442 of the California Public Resources Code Other states may have similar laws Federal laws apply on federal land TECHNICAL INFORMATION POWER RATINGS The power ratings for an individual engine model are initially developed by starting with SAE Society of Automotive Engineers code J1940 Small Engine Power amp Torque Rating Procedure Revision 2002 05 Given both the wide array of products on which our engines are placed and the variety of environmental issues applicable to operating the equipment it may be that the engine you have purchased will not develop the rated horsepower when used in a piece of power equipment actual
10. exhaust from this prod Safety Alert Read Owner s On Off Manual N MN BP Oil Stop Fuel Shutoff Choke Fuel uct contains chemicals known to the State of California to cause cancer birth defects or other reproductive harm Briggs amp Stratton does not necessarily know what equipment this engine will power For that reason you should carefully read and understand the operating instructions for the equipment on which your engine is placed Gasoline and its vapors are extremely flammable and explosive Fire or explosion can cause severe burns or death WHEN ADDING FUEL e Turn engine OFF and let engine cool at least 2 minutes before removing gas cap e Fill fuel tank outdoors or in well ventilated area e Do not overfill fuel tank Fill tank to approximately 1 1 2 inches below top of neck to allow for fuel expansion e Keep gasoline away from sparks open flames pilot lights heat and other ignition sources e Check fuel lines tank cap and fittings frequently for cracks or leaks Replace if necessary WHEN STARTING ENGINE e Make sure spark plug muffler fuel cap and air cleaner are in place e Do not crank engine with spark plug removed e If fuel spills wait until it evaporates before starting engine e If engine floods set choke to OPEN RUN position place throttle in FAST and crank until engine starts WHEN OPERATING EQUIPMENT e Do not tip engine or equipment at angle which causes ga
11. o akhonND GENERAL INFORMATION ENGINE MODEL This is a single cylinder overhead valve OHV air cooled engine It is a low emissions engine In the state of California OHV Model Series 210000 280000 and 310000 engines are certified by the California Air Resources Board to meet emissions standards for 250 hours Such certification does not grant the purchaser owner or operator of this engine any additional warranties with respect to the performance or operational life of this engine This engine is warranted solely according to the product and emissions warranties stated elsewhere in this manual TUNE UP SPECIFICATIONS Armature air gap 0 010 0 014 in 0 25 0 36 mm Spark plug gap 0 030 in 0 76 mm Valve clearance with valve springs installed and piston 1 4 in 6 mm past top dead center check when engine is cold See Repair Manual P N 272147 Intake 0 003 0 005 in 0 08 0 13 mm Exhaust 0 005 0 007 in 0 13 0 18 mm BRIGGS amp STRATTON 7 Air cleaner 8 In line fuel filter if equipped 9 Carburetor 10 Oil filter if equipped 11 Spark plug wire 12 Engine Model Type Code XXXXX XXXX XX XXXXXXXX MODEL SERIES 210000 BOO int siens tie ya eed 3 7 16 in 87 31 mm Soke san Boia Si ede its 2 17 64 in 77 78 mm Displacement 21 00 cu in 344 1
12. re ou de fabrication qui pourraient causer des d fectuosi La couverture ci contre s tend toute d fectuosit des composantes du moteur caus e par t s des pi ces sous garantie pour une p riode de deux ans a partir de la date a laquelle le mo la d fectuosit de n importe quelle pi ce couverte par la garantie et dontla garantie est encore teur a t livr l acheteur en vigueur Consultez les informations sur la p riode de durabilit d mission et l INDICE d air sur l tiquette d mission de votre moteur Les moteurs qui sont certifi s conformes aux normes standards d mission du California Air Resources Board CARB Tier 2 doivent afficher l information concernant la p riode de durabilit du syst me d mission etl INDICE d air Cette information est indiqu e sur les tiquettes appos es sur les moteurs par Briggs amp Stratton L tiquette du moteur indiquera les renseignements concernant la certification La p riode de durabilit d mission indique le nombre d heures d utilisation normale pour lequel le moteur est certifi conforme aux normes d mission sous r serve d un entretien appropri tel qu indiqu dans le manuel d op ration et d entretien Les cat gories suivantes sont utilis es Mod r le moteur est certifi conforme pour 125 heures d utilisation normale Interm diaire le moteur est certifi conforme pour 250 heures d utilisation normale Prolong le moteur est certifi conforme po
13. the initial owner and each subsequent purchaser that the Warranted Parts shall be free from defects in materials and workmanship which caused the failure of the Warranted Parts for a period of two years from the date the engine is delivered to a retail purchaser 3 No Charge Repair or replacement of any Warranted Part will be performed at no charge to the owner including diagnostic labor which leads to the determination that a Warranted Part is defective if the diagnostic work is performed at an Authorized B amp S Service Dealer For emissions warranty service contact your nearest Authorized B amp S Ser vice Dealer as listed in the Yellow Pages under Engines Gasoline Gasoline En gines Lawn Mowers or similar category 4 Claims and Coverage Exclusions Warranty claims shall be filed in accordance with the provisions of the B amp S Engine War ranty Policy Warranty coverage shall be ex cluded for failures of Warranted Parts which are not original B amp S parts or because of abuse neglect or improper maintenance as Briggs amp Stratton Engines Are Made Under One Or More Of The Following Patents Design D 247 177 Other Patents Pending 6 325 036 6 284 123 6 260 529 6 077 063 6 064 027 6 014 808 5 894 715 5 852 951 5 823 153 5 819 513 5 813 384 5 765 713 5 645 025 5 642 701 5 619 845 5 606 948 5 606 851 5 548 955 5 546 901 5 503 125 5 501 203 6 230 678 6 202 616 6 116 212 5 497
14. warranty periods 2 years for Classic engines in the European Union and Eastern European countries for all consumer products in the European Union and for emission control systems on engines certified by EPA and CARB 5 years for consumer use 90 days for commercial use of Touch N Mow starter on Quantum and Intek engines Engines used in competitive racing or on commercial or rental tracks are not warrantied The warranty period begins on the date of purchase by the first retail consumer or commercial end user and continues for the period of time stated in the table above Consumer use means personal residential household use by a retail consumer Commercial use means all other uses including use for commercial income producing or rental purposes Once an engine has experienced commercial use it shall thereafter be considered as a commercial use engine for pur poses of this warranty NO WARRANTY REGISTRATION IS NECESSARY TO OBTAIN WARRANTY ON BRIGGS amp STRATTON PRODUCTS SAVE YOUR PROOF OF PURCHASE RECEIPT IF YOU DO NOT PROVIDE PROOF OF THE INITIAL PURCHASE DATE AT THE TIME WARRANTY SERVICE IS REQUESTED THE MANUFACTURING DATE OF THE PRODUCT WILL BE USED TO DETERMINE THE WARRANTY PERIOD ABOUT YOUR ENGINE WARRANTY Briggs amp Stratton welcomes warranty repair and apologizes to you for being inconvenienced Any Authorized Service Dealer may perform warranty repairs Most warranty repairs are handled routinely but somet
15. 274826 L INDICE D AIR DE CE MOTEUR EST Q 6 6 Ceci est une repr sentation des tiquettes d mission que vous retrouverez sur les moteurs certifi s CIMODEREE X INTERM DIAIRE C PROLONG E CE MOTEUR EST CONFORME AUX NORMES earns 2006 DE CALIFORNIE POUR PETITS MOTEURS HORS ROUTE fan KNOR AMES ENVIRONNEMENTALES AMERICAINES EPA PHASE Pi ITS MOTEURS HORS ROUTE CONSULTEZ LE MANUEL DU PROPRETARE POUR LES SPECIFICATIONS L ENTRETIEN ET LES AJUSTEMENTS CONFORME LA P RIODE D EMISSION EPA CATEGORIE C BRIGGS amp STRATTON
16. 30 days need special attention 1 Part No 272147 To prevent gum from forming in fuel system or on essential carburetor parts a if fuel tank contains oxygenated or reformulated gasoline gasoline blended with an alcohol or an ether run engine until it stops from lack of fuel or b if fuel tank contains gasoline either run engine until it stops from lack of fuel or add a gasoline additive to the gas in the tank See parts list Single use pouches of gas additive are available from your service dealer If you use a gas additive run the engine for several minutes to circulate the additive through the carburetor Then engine and fuel can be stored up to 24 months While engine is still warm change oil 3 Remove spark plug and pour about 1 oz 30 ml of engine oil into cylinder Replace spark plug and crank slowly to distribute oil 4 Clean engine of surface debris chaff or grass 5 Store in a clean dry area Do not store in same area as a stove furnace water heater or other appliance that uses a pilot light or has a device that can create a spark AX WARNING BRIGGS amp STRATTON ENGINE OWNER WARRANTY POLICY Effective January 1 2003 replaces all undated Warranties and all Warranties dated before January 1 2003 LIMITED WARRANTY Briggs amp Stratton Corporation will repair or replace free of charge any part s of the engine that is defective in material or workmanship or both Transpor
17. 5089D to re oil the filter 5 6 7 OIL FILTER IF EQUIPPED Replace oil filter after every 100 hours of operation 1 Drain engine oil and remove oil filter 2 Before installing new filter lightly oil filter gasket with fresh clean engine oil 3 Screw filter on by hand until gasket contacts oil filter adapter Tighten 1 2 to 3 4 turn more 4 Add fresh oil Fill to FULL line on dipstick 5 Start and run engine at idle to check for oil leaks 6 Stop engine Recheck oil level and add oil if required 13 BRIGGS amp STRATTON MAINTENANCE WARNING Never use motor oil transmission fluid WD40 or other oils Failure to follow instructions can cause fires resulting in death or serious injury Use only air filter oil designed specifically for air filters 7 Spray the filter with oil or pour small amount onto each pleat and allow filter to stand for 20 minutes The filter is correctly oiled when the cotton changes from white to the color of the oil CAUTION DO NOT over oil air filter it will interfere with engine performance and may cause engine damage If the filter is placed on cardboard for 10 minutes and leaves a stain it is over oiled Wash clean and re oil per above instructions 8 CARBURETOR Re install air filter HIGH FLOW AIR FILTER FILTER P N 698973 OIL PRESSURE If oil pressure drops too low an oil pres
18. TART TO STOP ENGINE 1 4 TURN 1 With throttle in FAST turn key to OFF 2 Close fuel shut off valve Remove key and store out of reach of children if equipped 10 MAINTENANCE Regular maintenance will improve the performance and extend the life of the engine See any Authorized Briggs amp Stratton Dealer for service Use only genuine Briggs amp Stratton parts Other parts may not perform as well may damage the engine and may result in injury In addition use of other parts may void your warranty Task Perform task at hourly or calendar interval whichever comes first 25 Hours or Every Season 50 Hours or Every Season 100 Hours or Every Season 200 Hours or Every Season Change Oil Change oil filter if equipped Service air cleaner pre cleaner if equipped Replace air cleaner cartridge if not equipped with pre cleaner Replace air cleaner cartridge if equipped with pre cleaner Clean Extended Life Series air cleaner cartridge Replace Extended Life Series air cleaner cartridge Jf Inspect spark arrester S if equipped Replace spark plug Replace in line fuel fil Vv ter if equipped Clean cooling system f Check valve clear ance Change oil after first 5 to 8 hours of use then every 50 hours or every season Change oil every 25 hours when operating the engine under heavy load or in high temperatures Clean more oft
19. cc MODEL SERIES 280000 POPO nn rs nice 3 7 16 in 87 31 mm STORE sararak araa ia S 3 1 16 in 77 78 mm Displacement 28 42 cu in 465 7 cc MODEL SERIES 310000 BOTE noa EETA ESITAR RIO ne 3 9 16 in 90 60 mm Stroke 3 1 16 in 77 78 mm Displacement 30 59 cu in 501 2 cc Note For practical operation the horsepower loading should not exceed 85 of rated horsepower Engine power will decrease 3 1 2 for each 1 000 feet 300 meters above sea level and 1 for each 10 F 5 6 C above 77 F 25 Engine will operate satisfactorily at an angle up to 15 275038 CAUTION This engine is shipped from Briggs amp Stratton without oil Check oil level before starting engine If you start the engine without oil the engine will be damaged beyond repair and will not be covered under warranty OIL CAPACITY Engine without oil filter holds approximately 1 1 2 quarts 48 ounces 1 4 liters TYPE OF OIL TO USE e Use a high quality detergent oil classified For Service SF SG SH SJ or higher such as Briggs amp Stratton 30W Part Number 100005 20 oz or 100028 48 oz e Do not use special additives e Choose a viscosity according to the table opposite Note Synthetic oil meeting ILSAC GF 2 API certification mark and API service symbol shown at left with SJ CF ENERGY CON SERVING or higher is an acceptable oil at all temperatures Use of s
20. e and throttle controls are separate move choke control to BRIGGS amp STRATTON a Choke STARTING AND STOPPING gt SLOW Throttle CHOKE Move throttle to FAST Grasp rope handle Pull slowly until resistance is felt then pull rapidly to start engine and avoid kickback 1 With throttle in FAST turn key to OFF Remove key and store out of reach of children Choke throttle control If choke and throttle are on the same control move control to CHOKE or START 7 Let engine warm up If choke equipped Slowly adjust toward RUN position Wait until engine runs smoothly before each choke adjustment oy 1 4 TURN 2 Close fuel shut off valve if equipped STARTING AND STOPPING ELECTRIC KEY STARTER if equipped TO START ENGINE SLOW TE Choke Throttle Choke throttle control 2 If choke and throttle controls are sepa 3 If choke and throttle are on the 1 Check oil level rate move choke control to CHOKE same control move control to Move throttle to FAST CHOKE or START CAUTION 1 4 TURN To prolong starter life Sion 6 na use short starting N F cycles 5 seconds max CN See ae imum then wait one SS jor po re minute Follow equip CL ts smoothi A zach ment manufacturers y recommendations for 4 Open fuel shut off 5 Insert key and choke adjustment charging banery valve if equipped turn to S
21. e and wash soapy water Squeeze dry in a clean cloth Saturate in engine oil Squeeze in clean absorbent cloth to remove all EXCESS oil 4 Clean base carefully to prevent debris from entering carburetor 5 Reassemble pre cleaner on cartridge and place assembly over stud Air cleaner must fit securely in base 6 Tighten cartridge knob securely 7 Replace cover and tighten cover knob securely COVER KNOB COVER HIGH FLOW AIR CLEANER MAINTENANCE Perform this maintenance every 25 hours or every season clean more often under dusty conditions or when airborne debris is present This filter is made of cotton which is different from a standard paper filter therefore it MUST be oiled 1 Remove clamp and pull air cleaner from intake manifold 2 Remove as much dirt from the filter as possible 3 Using the High Flow Air Filter Cleaner Kit Briggs amp Stratton part no 5089D spray the filter with cleaner Allow the solution to soak in to the filter for about 15 minutes CAUTION Never use strong detergents high pressure water or gasoline to clean this filter 4 Rinse the filter with warm water inside first and then outside Let the water run from the clean side to the dirty side Allow the filter to dry completely It is best to allow the filter to dry naturally Don t use heat this might shrink the cotton Use only air filter oil such as the oil included in the cleaning kit P N
22. e doivent tre compl t es dans un mande de conserver tous les re us couvrant les travaux d entretien de votre petit moteur hors rou d lai raisonnable ne devant pas exc der 30 jours te mais B amp S ne peut refuser la garantie en raison d absence de re us ou pour d faut d avoir suivi Si vous avez des questions relativement votre garantie vos droits et responsabilit s veuillez tout ch ancier du programme d entretien communiquer avec un repr sentant de service B amp S au num ro 1 414 259 5262 En tant que propri taire d un petit moteur hors route vous devez tre inform que B amp S peut refuser La garantie du syst me d chappement est une garantie contre les d fectuosit s Les d fectuosi d honorer cette garantie si la d fectuosit de votre moteur ou d une partie de votre moteur est due t s sont jug es en fonction d une utilisation normale du moteur La garantie n est pas reli e un un emploi abusif une n gligence un entretien incorrect ou une modification non approuv e test d chappement effectu l int rieur Dispositions de la garantie du syst me d chappement Briggs amp Stratton Ce qui suit concerne les dispositions sp cifiques relativement votre garantie sur le syst me de contr le d chappement C est une addition la garantie B amp S pour les moteurs non r glement s contenue dans le manuel d entretien et d utilisation 1 Pi ces sous garantie 3 Aucuns Frais La couverture de c
23. en under dusty conditions or when airborne debris is present Replace air cleaner parts if very dirty MAINTENANCE EMISSION CONTROL Maintenance replacement or repair of the emission control devices and systems may be performed by any nonroad engine repair establishment or individual However to obtain no charge repairs under the terms and provisions of the Briggs amp Stratton warranty statement any service or emission control part repair or replacement must be performed by a factory authorized dealer 7 CHANGING OIL TO REMOVE 5 16 HEX 3 8 SQUARE 7 16 PIPE Typical drain plugs CL A OIL DRAIN PLUG Place engine level Disconnect spark plug wire and keep away from spark plug Disconnect battery if equipped with electric starter at nega tive terminal With engine OFF but still warm remove oil drain plug and drain oil into appropriate receptacle 3 4 5 Reinstall drain plug Remove dipstick Fill to FULL mark on dipstick with new oil Do not overfill Note Engine without oil filter holds approximately 1 1 2 quarts 48 ounces 1 4 liters Engine equipped with filter holds approximately 1 3 4 quarts 56 ounces 1 7 liters 6 Replace dipstick CAUTION Used oil is a hazardous waste product Dispose of used oil properly Do not discard with household waste Check with your local authorities service center or dealer for safe disposal recycling facilities
24. ette garantie ne s applique que sur les pi ces list es ci contre les parties La r paration ou le remplacement de toute pi ce sous garantie sera effectu e sans aucuns du syst me de contr le d chappement dans la mesure o ces pi ces taient pr sentes sur le frais pour le propri taire incluant les frais de main d uvre pour le diagnostic afin de d termi moteur au moment de l achat ner si la pi ce sous garantie est d fectueuse conditionnel ce que le diagnostic soit effectu a Syst me de dosage du carburant chez un d taillant autoris B amp S Pour la garantie relative au syst me d chappement commu e Syst me d enrichissement de d marrage froid niquez avec le d taillant autoris B amp S le plus proche tel que list dans les pages jaunes de e Carburateur et parties internes votre localit sous la rubrique moteur a essence tondeuse ou autre cat gorie similaire e Pompe essence 4 R clamations et exclusions de la couverture b Syst me d induction d air Les r clamations de garantie doivent tre compl t es en accord avec les dispositions de la e Filtre air politique de garantie B amp S La garantie ne couvre pas les d fectuosit s de pi ces qui ne sont e Tubulure d admission pas des pi ces d origine B amp S ou dans le cas d abus n gligence ou d un entretien inappropri La garantie B amp S ne couvre pas les d fectuosit s de pi ces sous garantie qui ont fait l objet Ge Sienne d ignition dajouts
25. ifornia Air Resources Board CARB Tier 2 Emission Standards must display information regard ing the Emissions Durability Period and the Air Index Briggs amp Stratton makes this information available to the consumer on our emission labels The Emissions Durability Period describes the number of hours of actual running time for which the engine is certified to be emissions compliant assuming proper maintenance in accordance with the Operating amp Maintenance Instructions The following categories are used Moderate Engine is certified to be emission compliant for 125 hours of actual engine running time Intermediate Engine is certified to be emission compliant for 250 hours of actual engine running time Extended Engine is certified to be emission compliant for 500 hours of actual engine running time For example a typical walk behind lawn mower is used 20 to 25 hours per year Therefore the Emissions Durability Period of an en gine with an intermediate rating would equate to 10 to 12 years The Air Index is a calculated number describing the relative level of emissions for a specific engine family The lower the Air Index the cleaner the engine This information is displayed in graphical form on the emissions label After July 1 2000 Look For Emissions Compliance Period On Engine Emissions Compliance Label After July 1 2000 certain Briggs amp Stratton engines will be certified to meet the United States Environmental Protection Age
26. imes requests for warranty service may not be appropriate For example warranty would not apply if engine damage occurred because of misuse lack of routine maintenance shipping handling warehousing or improper installation Similarly warranty is void if the serial number of the engine has been removed or the engine has been altered or modified Ifa customer differs with the decision of the Service Dealer an investigation will be made to determine whether the warranty applies Ask the Service Dealer to submit all supporting facts to his Distributor or the Factory for review If the Distributor or the Factory decides that the claim is justified the customer will be fully reimbursed for those items that are defective To avoid misunderstanding which might occur between the customer and the Dealer listed below are some of the causes of engine failure that the warranty does not cover Normal wear Engines like all mechanical devices need periodic parts service and replacement to perform well Warranty will not cover repair when normal use has exhausted the life of a part or an engine Improper maintenance The life of an engine depends upon the conditions under which it operates and the care it receives Some applications such as tillers pumps and rotary mowers are very often used in dusty or dirty conditions which can cause what appears to be premature wear Such wear when caused by dirt dust spark plug cleaning grit or other ab
27. le syst me d ignition le silencieux et le convertisseur catalytique II peut aussi comprendre les standards rigoureux d antipollution Ailleurs aux Etats Unis les nouveaux moteurs hors route connecteurs et autres pi ces reli es l mission bougie d allumage certifi s pour les mod les de 1997 et plus doivent rencontrer des normes simi Lorsqu il y a condition garantie B amp S r parera gratuitement votre petit moteur hors route incluant laires mises de l avant par le U S EPA Briggs amp Stratton garantit le syst me de contr le d chap le diagnostic les pi ces et la main d uvre Couverture de garantie Briggs amp Stratton contre toute d fectuosit du syst me de contr le d chappement Les petits moteurs hors route sont garantis contre la d fectuosit des pi ces du syst me de contr te quelle pi ce de votre moteur couverte par cette garantie est d fectueuse elle sera r par e ou le d chappement pour une p riode de 2 ans sujette aux conditions stipul es ci contre Sin impor remplac e par B amp S Responsabilit s du propri taire En tant que propri taire d un petit moteur hors route vous tes responsable de veiller l ex cution Vous avez la responsabilit d apporter votre petit moteur hors route un d taillant autoris B amp S de l entretien requis tel que stipul dans votre manuel d op ration et d entretien B amp S vous recom aussit t que survient un probl me Les r parations sous garanti
28. lems If any undesirable operating symptoms occur use gasoline with a lower percentage of alcohol or ether 1 Remove cap Fill tank to approximately 1 1 2 inches below top of neck to allow for fuel expansion Be careful not to overfill Briggs amp Stratton Smart fill fuel can fills to the correct level and automatically shuts off reduc ing spills and emissions 2 Replace cap before starting OIL PRESSURE SWITCH If engine is equipped with an oil pressure switch the switch will either activate a warning light or stop the engine when the engine runs low on oil Read the operating instructions supplied by the equipment manufacturer to determine which way your engine is equipped because the equipment manufacturer supplies the oil pressure gauge See OIL PRESSURE on page 12 for oil filling instructions Periodically remove grass buildup under mower deck See Maintenance After engine has started let it warm up several seconds to several minutes depending on outside temperature For maximum performance and life operate engine with choke in RUN and throttle in FAST REWIND MANUAL STARTER auxiliary TO START ENGINE 1 4 TURN S 1 Check oil level see p 7 2 Open fuel shut off valve if equipped 1 4 turn 5 Insert key and 6 turn to RUN TO STOP ENGINE CAUTION Do not stop engine by moving choke control to CHOKE Backfire fire or engine damage could occur 3 If chok
29. m Remove blower housing and clean area shown to prevent overheating and engine damage Daily or before every use clean grass chaff or accumu lated debris from engine Keep linkage spring and controls clean Keep area around and behind muffler free of any combustible debris CLEAN 4 A V e hele Linkage Springs Muffler Controls Spark Arrester TUNE UP SPECIFICATIONS Armature air gap 0 010 0 014 in 0 25 0 36 mm Spark plug gap 0 030 in 0 76 mm Valve clearance with valve springs installed and piston 1 4 in 6 mm past top dead center check when engine is cold See Repair Manual P N 272147 Intake 0 003 0 005 in 0 08 0 13 mm Exhaust 0 005 0 007 in 0 13 0 18 mm CONTROL ADJUSTMENTS TO ADJUST REMOTE THROTTLE If the engine does not start or if it runs roughly the remote throttle control may need adjustment See your authorized Briggs amp Stratton dealer or follow the instructions below NES De CONTROL F PLATE Ye GOVERNOR CONTROL RACK Move remote throttle control to FAST position OVERNOR we LEVER D CASING CLAMP SCREW Hole in governor control lever located just behind governor control plate must align with hole in governor control plate as illustrated above If holes do not line up loosen ca
30. ncy USEPA Phase 2 emission standards For Phase 2 certified engines the Emissions Compliance Period referred to on the Emissions Compliance label indicates the number of operating hours for which the engine has been shown to meet Federal emission requirements For engines less than 225 cc displacement Category C 125 hours B 250 hours and A 500 hours For engines of 225 cc or more Category C 250 hours B 500 hours and A 1000 hours The displacement engines of Model Series 210000 is 344 cc 280000 is 465 cc 310000 engines is 501 cc This is a generic representation z H H BRIGGS amp STRATTON CORPORATION IMPORTANT ENGINE INFORMATION of the emission label typically NT FAMILY YBSXS SO12VP 274626 HH i THE AIR INDEX OF THIS ENGINE IS_ found on a certified engine oO 6 THIS ENGINE CONFORMS TO 2000 2001 OWER INDEX CALIFORNIA EMISSION REGULATIONS mE HENNI THELESS POLLUTION THS NONE S CEFTIED FOR SMALL OFFROAD ENGINES AND IN CALIFORNIA TO BE EMISSIONS COMPLIANT FOR THE FOLLOWING USE EPA PHASE 2 REGULATIONS FOR SMALL MODERATE INTERMEDIATE L EXTENDED NON ROAD ENGINES REFER TO OWNER S THIS ENGINE CONFORMS TO 2006 CA EMISSION REGS FOR SMALL MANUAL FOR MAINTENANCE OFF ROAD ENGINES amp EPA PH 2 REGS FOR SMALL NON ROAD SPECIFICATIONS AND ADJUSTMENTS ENGINES REFER TO OWNER S MANUAL FOR MAINTENANCE SPECS EPA EMISSIONS COMPLIANCE PERIOD ADJUSTMENTS amp EMISSION DURABILITY INFORMATION CATEGORY C EPA EMISSIONS
31. ne because of improper air cleaner maintenance re assembly or use of a non original air cleaner element or cartridge At recommended 17 intervals clean and re oil the Oil Foam element or the foam pre cleaner and replace the cartridge Read Operating amp Maintenance Instructions 7 Parts damaged by over speeding or overheating caused by grass debris or dirt which plugs or clogs the cooling fins or flywheel area or damage caused by operating the engine in a confined area without sufficient ventilation Clean fins on the cylinder cylinder head and flywheel at recommended intervals Read Operating amp Maintenance Instructions 8 Engine or equipment parts broken by excessive vibration caused by a loose engine mounting loose cutter blades unbalanced blades or loose or unbalanced impellers improper attachment of equipment to engine crankshaft over speeding or other abuse in operation 9 A bent or broken crankshaft caused by striking a solid object with the cutter blade of a rotary lawn mower or excessive v belt tightness 10 Routine tune up or adjustment of the engine 11 Engine or engine component failure i e combustion chamber valves valve seats valve guides or burned starter motor windings caused by the use of alternate fuels such as liquified petroleum natural gas altered gasolines etc Warranty is available only through service dealers which have been authorized by Briggs amp Stratton Corpora
32. prevents gum from forming in the fuel system or on essential carburetor parts Purchase fuel in quantity that can be used within 30 days e Do not use gasoline which contains Methanol e Do not mix oil with gasoline e For engine protection use Briggs amp Stratton Gasoline Additive available from your Authorized Briggs amp Stratton Dealer P N 5041 or single use pouch ADDING FUEL a e Turn engine OFF and let engine cool at least 2 minutes before removing gas cap e Fill fuel tank outdoors or in well ventilated area e Keep gasoline away from sparks open flames pilot lights heat and other ignition sources e f fuel spills wait until it evaporates before starting engine STARTING e Do not use pressurized starting fluids e Vapors are flammable BRIGGS amp STRATTON STARTING AND OPERATING TIPS Store and fuel equipment in level position Use fresh fuel See Fuel Use correct type of oil for expected starting temperature See Oil Remove external equipment engine loads equipment operating instructions Start lawn mower on hard surface or over previously cut grass See e This engine is certified to operate on gasoline Exhaust Emission Control System EM Engine Modifications CAUTION Some fuels called oxygenated or reformu lated gasoline are gasoline blended with alcohols or ethers Excessive amounts of these blends can damage the fuel system or cause performance prob
33. r cleaner cartridge 698413 Flat air cleaner pre cleaner 697292 Maintenance Kit 5126 Includes oil A C filter spark plug gas additive ee Oval air cleaner cartridge and pre cleaner kit 5053 Oval air cleaner cartridge 496894 Oval air cleaner pre cleaner 272403 High Flow Air Filter cylinder 698973 High Flow Air Filter Cleaning Kit 5089D Synthetic Oil 32 oZ 100074 OI 20 02 elecs eisai bbe tice gaia cles 100005 Oil 48 02 5e Gea eihe r Aaa 100028 Oil filter 3 1 2 in long 491056 Oil filter 2 1 4 in long 492932 Fuel filter 298090 or 5018 for engines without fuel pump installed Extended Life Series fuel filter for engines equipped with fuel pump 695666 or 5070 Fuel filter 394358 for engines equipped with fuel pump Gas additive 5041 Resistor spark plug 491055 Long life platinum spark plug 5066 used on most OHV engines Spark plug wrench Spark tester 19368 Oil pump kit 5056 uses standard electric drill to remove oil from engine quickly SERVICE See an Authorized Briggs amp Stratton Service Dealer Each one carries a stock of Genuine Briggs amp Stratton Parts and is equipped with
34. r improper maintenance of your small off road engine Your emission control system includes parts such as the carburetor air cleaner ignition sys tem muffler and catalytic converter Also in cluded may be connectors and other emission related assemblies Where a warrantable condition exists B amp S will repair your small off road engine at no cost to you including diagnosis parts and labor Briggs amp Stratton Emission Control Defects Warranty Coverage Small off road engines are warranted relative to emission control parts defects for a period of two years subject to provisions set forth below If any covered part on your engine is defective the part will be repaired or replaced by B amp S As the small off road engine owner you are re sponsible for the performance of the required maintenance listed in your Operating and Main tenance Instructions B amp S recommends that you retain all your receipts covering mainte nance on your small off road engine but B amp S cannot deny warranty solely for the lack of re ceipts or for your failure to ensure the perfor mance of all scheduled maintenance Owner s Warranty Responsibilities As the small off road engine owner you should however be aware that B amp S may deny you war ranty coverage if your small off road engine or a part has failed due to abuse neglect improper maintenance or unapproved modifications You are responsible for presenting your small off road engine
35. rasive material that has entered the engine because of improper maintenance is not covered by warranty This warranty covers engine related defective material and or workmanship only and not replacement or refund of the equipment to which the engine may be mounted Mor does the warranty extend to repairs required because of 1 PROBLEMS CAUSED BY PARTS THAT ARE NOT ORIGINAL BRIGGS amp STRATTON PARTS 2 Equipment controls or installations that prevent starting cause unsatisfactory engine performance or shorten engine life Contact equipment manufacturer 3 Leaking carburetors clogged fuel pipes sticking valves or other damage caused by using contaminated or stale fuel Use clean fresh lead free gasoline and Briggs amp Stratton Fuel Stabilizer Part No 5041 4 Parts which are scored or broken because an engine was operated with insufficient or contaminated lubricating oil or an incorrect grade of lubricating oil check oil level daily or after every 8 hours of operation Refill when necessary and change at recommended intervals OIL GARD may not shut down running engine Engine damage may occur if oil level is not properly maintained Read Operating amp Maintenance Instructions 5 Repair or adjustment of associated parts or assemblies such as clutches transmissions remote controls etc which are not manufactured by Briggs amp Stratton 6 Damage or wear to parts caused by dirt which entered the engi
36. sing clamp screw and then move governor control rack until it does Tighten casing clamp screw Check operation of throttle Move throttle control to STOP position Governor control lever must make good contact with stop switch if equipped Readjust if necessary 15 ADJUSTMENTS TO ADJUST REMOTE CHOKE CASING CLAMP SCREW Hold choke control to CHOKE or START position Loosen casing clamp screw Pull casing wire and choke lever in direction of arrow to end of travel Tighten casing clamp screw CARBURETOR ADJUSTMENT The manufacturer of the equipment on which this engine is installed specifies top speed at which the engine will be operated DO NOT EXCEED this speed Differences in fuel temperature altitude or load may require minor carburetor adjustment Air cleaner and its cover must be assembled to carburetor before starting engine The carburetor on this engine is equipped with an idle mixture valve with a limiter see inset which allows some adjustment and an idle speed adjustment screw TO ADJUST CARBURETOR CARBURETOR gt I THROTTLE 7 IDLE MIXTURE De VALVE ese LIMITER AAEN SPEED SCREW To adjust idle speed start engine and warm up about 5 minutes With engine running place equipment throttle control in SLOW position Rotate carburetor throttle lever against the idle speed screw and hold it Turn idle speed scre
37. soline to spill e Do not choke carburetor to stop engine WHEN TRANSPORTING EQUIPMENT e Transport with fuel tank EMPTY or with fuel shut off valve OFF WHEN STORING GASOLINE OR EQUIPMENT WITH FUEL IN TANK e Store away from furnaces stoves water heaters or other appliances that have pilot light or other ignition source because they can ignite gasoline vapors Starting engine creates sparking Sparking can ignite nearby flammable gases Explosion and fire could result e If there is natural or LP gas leakage in area do not start engine e Do not use pressurized starting fluids because vapors are flammable Rapid retraction of starter cord kickback will pull hand and arm toward engine faster than you can let go Broken bones fractures bruises or sprains could result e When starting engine pull cord slowly until resistance is felt then pull rapidly e Remove all external equipment engine loads before starting engine e Direct coupled equipment components such as but not limited to blades impellors pulleys sprockets etc must be securely attached Rotating parts can contact or entangle hands feet hair clothing or accessories Traumatic amputation or severe laceration can result e Operate equipment with guards in place e Keep hands and feet away from rotating parts e Tie up long hair and remove jewelry eDo not wear loose fitting clothing dangling drawstrings or items that could become
38. special service tools Trained mechanics assure expert repair service on all Briggs amp Stratton engines Only dealers advertising as Authorized Briggs amp Stratton are required to meet Briggs amp Stratton standards When you purchase equipment powered by a Briggs amp Stratton engine you are assured of KG highly skilled reliable service at more than NZ 30 000 Authorized Service Dealers worldwide including more than 5 000 Master Service Technicians Look for these signs CLO x x BRIGGS amp STRATTON wherever Briggs amp Stratton service is offered 7 BRIGGS amp STRATTON 16 You may locate your nearest Authorized Briggs amp Stratton Service Dealer in our dealer locator map on our web site www briggsandstratton com or in the Yellow Pages directory under Engines Gasoline or Gasoline lt m Engines or Lawn Mowers or similar category Note Walking fingers logo and Yellow Pages are regis tered trademarks in various jurisdictions An illustrated shop manual includes common specifications and detailed information covering adjustment tune up and repair of Briggs amp Strat ton single cylinder OHV 4 cycle engines It is available for purchase from an Authorized Briggs amp Stratton Service Dealer or you can order it from the factory Write Briggs amp Stratton Corporation Attn Service Division P O Box 1144 Milwaukee WI 53201 STORAGE Engines stored over
39. sure switch if engine is equipped will either activate a warning light or stop the engine Check oil level with dipstick If oil level is between ADD and FULL mark on dipstick Do not try to restart engine Contact an Authorized Briggs amp Stratton Service Dealer Do not operate engine until oil pressure is corrected If oil level is below ADD mark on dipstick add oil to bring level to FULL mark Restart engine and check oil pressure If pressure is normal continue to operate engine Note Oil pressure gauge if engine is equipped is supplied by manufacturer of equipment MAINTENANCE ENGINE AND ENGINE PARTS We recommend that you see an authorized Briggs amp Stratton Service Dealer for all maintenance and service of the engine and engine parts Use only genuine Briggs amp Stratton parts MUFFLER Replacement parts for the muffler must be the same and installed in the same position as the original parts otherwise fire can occur If muffler is equipped with spark arrester screen remove screen for inspection Replace screen if damaged or plugged SPARK PLUG Use only Briggs amp Stratton Spark Tester part number 19368 to check for spark Note In some areas local law requires using resistor spark plug to suppress igni tion signals If this engine was originally equipped with resistor spark plug use same type for replace ment 030 0 76 mm WIRE GAGE a CLEANING DEBRIS
40. tation charges on parts submitted for repair or replacement under this warranty must be borne by purchaser This warranty is effective for the time periods and subject to the conditions stated below For warranty service find the nearest Authorized Service Dealer in our dealer locator map at www briggsandstratton com or by calling 1 800 233 3723 or as listed in the Yellow Pages THERE IS NO OTHER EXPRESS WARRANTY IMPLIED WARRANTIES INCLUDING THOSE OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED TO ONE YEAR FROM PURCHASE OR TO THE EXTENT PERMITTED BY LAW ANY AND ALL IMPLIED WARRANTIES ARE EXCLUDED LIABILITY FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES ARE EXCLUDED TO THE EXTENT EXCLUSION IS PERMITTED BY LAW Some states or countries do not allow limitations on how long an implied warranty lasts and some states or countries do not allow the exclusion or limitation of incidental or consequential damages so the above limitation and exclusion may not apply to you This warranty gives you specific legal rights and you may also have other rights which vary from state to state and country to country OUR PRODUCT Vanguard ELS Fource Classic Etek vce Intek Industrial Plus Kool Bore Intek Power Built OHV Sleeve Bore Quantum Quattro Q45 Sprint WARRANTY PERIOD Consumer Use 2 years 2 years 1 year 2 years 1 year Commercial Use 1 year 90 days 90 days Note the following special
41. tion your nearest Authorized Service Dealer is listed in the Yellow Pages of your telephone directory under Engines Gasoline or Gasoline Engines Lawn Mowers or similar category Briggs amp Stratton Corporation B amp S the California Air Resources Board CARB and the United States Environmental Protection Agency U S EPA Emission Control System Warranty Statement Owner s Defect Warranty Rights and Obligations EMISSION CONTROL WARRANTY COVERAGE IS APPLICABLE TO CERTIFIED ENGINES PURCHASED IN CALIFORNIA IN 1995 AND THERE AFTER WHICH ARE USED IN CALIFORNIA AND TO CERTIFIED MODEL YEAR 1997 AND LATER ENGINES WHICH ARE PURCHASED AND USED ELSEWHERE IN THE UNITED STATES AND AFTER JANUARY 1 2001 IN CANADA California and United States Emission Control Defects Warranty Statement The California Air Resources Board CARB U S EPA and B amp S are pleased to explain the Emission Control System Warranty on your model year 2002 and later small off road engine SORE In California new small off road engines must be de signed built and equipped to meet the State s stringent anti smog standards Elsewhere in the United States new non road spark ignition engines certified for model year 1997 and later must meet similar standards set forth by the U S EPA B amp S must warrant the emis sion control system on your engine for the periods of time listed below provided there has been no abuse neglect o
42. to an Authorized B amp S Service Dealer as soon as a problem exists The undisputed warranty repairs should be completed in a reasonable amount of time not to exceed 30 days If you have any questions regarding your war ranty rights and responsibilities you should con tact a B amp S Service Representative at 1 414 259 5262 The emission warranty is a defects warranty Defects are judged on normal engine perfor mance The warranty is not related to an in use emission test Briggs amp Stratton Emission Control Defects Warranty Provisions The following are specific provisions relative to your Emission Control Defects Warranty Coverage It is in addition to the B amp S engine warranty for non regulated engines found in the Operating and Maintenance Instructions 1 Warranted Parts Coverage under this warranty extends only to the parts listed below the emission con trol systems parts to the extent these parts were present on the engine purchased a Fuel Metering System e Cold start enrichment system e Carburetor and internal parts e Fuel Pump b Air Induction System e Air cleaner e Intake manifold c Ignition System e Spark plug s e Magneto ignition system d Catalyst System e Catalytic converter e Exhaust manifold e Air injection system Pulse valve e Miscellaneous Items e Vacuum temperature position time sensitive valves and switches Connectors and assemblies 2 Length of Coverage B amp S warrants to
43. ur 500 heures d utilisation normale Par exemple une tondeuse de mod le standard est utilis e environ 20 25 heures par ann e Par cons quent la p riode de durabilit d mission d un moteur dans la cat gorie interm diaire pour ce type de tondeuse quivaut 10 12 ans L indice d air est un nombre qui d crit le niveau relatif d mission pour une cat gorie sp cifique de moteur Plus l indice d air est bas plus le moteur est cologique Cette information est indiqu e sous une forme graphique sur l tiquette d mission compter du 1 juillet 2000 surveillez la p riode de conformit d mission sur les tiquettes Apr s le 1 juillet 2000 certains moteurs B amp S seront certifi s conformes aux normes environnementales d mission standard du United States Environmental Protection Agency US EPA Phase 2 Pour les moteurs certifi s pour la Phase 2 la p riode de conformit d mission mentionn e sur les tiquettes indique le nombre d heures d utilisation pour lequel le moteur rencontre les normes f d rales Pour les moteurs de force moindre que 225 cc la cat gorie C 125 heures B 250 heures et A 500 heures Pour les moteurs de 225 cc et plus la cat gorie C 250 heures B 500 heures et A 1000 heures Le remplacement du moteur portant le mod le de s rie 210000 est 344 cc 280000 est 465 cc et 310000 est 501 cc CORPORATION BRIGGS amp STRATTON INFORMATIONS IMPORTANTES FAMILLE YBSXS 5012VP
44. w to obtain 1750 rpm use a tachometer Then rotate idle mixture valve full travel clockwise and then counterclockwise Note DO NOT remove limiter caps DO NOT force beyond limits Then position idle mixture valve in middle of travel Check idle speed Re adjust to 1750 rpm if needed Move throttle control to FAST position Engine should accelerate smoothly If it does not adjust idle mixture valve counterclockwise 1 8 turn 0H IDLE Note Engines operated at approximately 3000 to 5000 feet 900 to 1500 meters above sea level may require a high altitude carburetor nozzle If erratic performance is observed contact a Briggs amp Stratton Authorized Service Dealer for cost to install purchase a high altitude carburetor nozzle SERVICE amp STORAGE PARTIAL LIST OF BRIGGS amp STRATTON PARTS Models 280000 310000 AVS series Extended Life Series flat air cleaner cartridge 697153 washable no pre cleaner required Extended Life Series Maintenance Kit 5128 Includes oil A C filter spark plug gas additive Flat air cleaner cartridge and pre cleaner kit 5077 Flat air cleaner cartridge 698083 Flat air cleaner pre cleaner 697015 Maintenance Kit 5127 Includes oil A C filter spark plug gas additive Model 210000 AVS series Flat air cleaner cartridge and pre cleaner kit 5079 Flat ai
45. ynthetic oil does not alter required oil change intervals CHECKING AND ADDING OIL e Check oil level before starting the engine e Check level daily or after every eight 8 hours R 1 Place engine level and 2 Remove dipstick and wipe clean with cloth clean around oil fill area SAE Viscosity Grades Synthetic 5w 30 10w 30 A f i 1 E Op 20 20 32 40 c 30 0 10 20 30 STARTING TEMPERATURE RANGE ANTICIPATED BEFORE NEXT OIL CHANGE CAUTION Air cooled engines run hotter than automotive engines The use of non synthetic multi viscosity oils 5W 30 10W 30 etc in temperatures above 40 F 4 C will result in higher than normal oil consumption When using a multi viscosity oil check oil level more frequently CAUTION SAE 30 oil if used below 40 F 4 C will result in hard starting and possible engine bore damage due to inadequate lubrication e Keep oil level at FULL e Do not overfill 3 Replace and tighten dip stick Remove and check oil level 4 Oil level should be at 5 If needed add oil slowly 6 Replace and tighten dip FULL line on dipstick recheck Do not over fill stick lm FUEL 5 9 TYPE OF FUEL TO USE e Use clean fresh regular unleaded gasoline with a minimum of 85 octane Fresh fuel

Download Pdf Manuals

image

Related Search

Related Contents

ディスプレイ付電 ポスター  Sony computer Personal Computer User Manual  取扱説明書 保証書付き    HIAB Service Manual Electronics    Bedienungsanleitung SMA Sunny Island 6.0H / 8.0H  Inventaire tests  STAZIONE METEOROLOGICA WIRELESS A 868 MHz    

Copyright © All rights reserved.
Failed to retrieve file