Barbie K0451 Offroad Vehicle User Manual
Contents
1. warm during use It is normal for some batteries to make noise and swell slightly while charging and is not reason for concern SOLUTION Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery Check all connectors Make sure the battery connector is tightly plugged into the charger connector and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Be sure to charge the battery after each use Even with proper care a rechargeable battery does not last forever Average battery life is 1 to 3 years depending on vehicle use and use conditions Replace only with a Power Wheels 6 Volt 4 0 Amp Hr battery with built in thermal fuse Do not substitute parts Make sure you do not overload the vehicle by allowing more than one rider at one time exceeding the 40 Ib maximum weight capacity or by towing objects behind the vehicle If the vehicle is overloaded the built in thermal fuse in the battery may trip and automatically shut down operation of the vehicle for approximately 25 seconds Adjust the driving conditions to prevent repeated automatic shutdowns Use only on generally level ground Check all wires around the motors and all connectors to make sure they are tight Contact your local Power Wheels a2. Li Trall Rider ATV Please read this manual andsave it with yourforiginalisales Tools needed fornassembly Assembly toolk included and Phillips Screwdriver notiincluded Toolneededitojaccessibattery compartment Slotted screwdriver Useyonly withja Power Wheels 6 Volt 4 0yAmp Hr Rechargeable Battery with Built in Thermal Fuse and alPoweraWheels l6 Volt 4 0 Amp Hr Chargen bothjincluded Bee lt a u SEEN the pictureabove gt Owners Manual withyAssembly Instructions ae 3 For Model K0451 WHEELS TABLE OF CONTENTS Poran Imorn On a a a N A A E N E oat real nae ted T E E AA E E S 2 Warnings an UG O a E N 3 RS a a aa a e a a E E E E A tea E A A ea hehe E 4 PS PICOT a e E E E A E Sionctatae dete aie ae fa tate da 5 Balke By Gianni santea e See a a a a a a E E aks oad a E E E a gue ak abe eters 6 ASSE E A A E E A ea ag vt ae eae 8 DECANE ane aa E NN glo eM hh el Na VON De rea T here PRTC De Wr Peace Dah Er 10 BALCH MSTA Atl OMMyanveuea tran atdet hae nines a banana tances Nae a a a A a a rant peel eaat seinen natct 11 Batter Care and DI Sposa a feteeu te fee ereunsn outcome sae aart esis a thee area ae tere an agnete ieee Wate erent tsa renin einen ge nee a 13 Le oD INT INT CHIE EY Cll S e a a setts vin atead EE We tee E geet ee et ee eee eee 14 WeMGlOeO NG CARO Milt raina ts comet nts Ooea treat an tetanr nn eaten E teres E cn teak A ene nae E dasa tere ana eaten ca 15 Ve micle Caro aoa tae re
3. Mattel Inc 2009 Mattel Inc All Rights Reserved Fisher Price and Power Wheels are US trademarks of Mattel Inc Fisher Price Inc a subsidiary of Mattel Inc East Aurora New York 14052 U S A 2009 Mattel Inc All Rights Reserved PRINTED IN MEXICO K0451pr 0921
4. PARTS e f you experience a problem with this product or are missing a part please call us at 1 800 348 0751 rather than return this product to the store e Please identify all parts before assembly and save all packaging material until assembly is complete to ensure that no parts are discarded e Some parts were placed under the seat for shipment Turn the lock fastener 1 4 turn and lift to remove the seat e Metal parts have been coated with a lubricant to protect them during shipment Wipe all metal parts with a paper towel to remove any excess lubricant Steering Wheel Cap 6 Volt 4 0 Amp Hr Battery S 6 Volt 4 0 Amp Hr Charger O Assembly Tool J Handlebar Assembly TT 3 3 16 Lock Nut 1 Part Not Shown Label Sheet Fastener Shown Actual Size ra K0451pr 0921 PARTS PICTURE Vehicle Front Wheel Assembly 6 Volt 4 0 Amp Hr Battery Steering Wheel Cap K0451pr 0921 5 BATTERY CHARGING ELECTRICAL HAZARD A WARNING e Battery can fall out and injure a child if vehicle tips over Always use battery retainer e PREVENT FIRE Never modify the electrical system Alterations could cause a fire resulting in serious injury and could also ruin the electrical system Use of the wrong type battery or charger could cause a fire or explosion resulting in serious injury Use of Power Wheels components in products other than Power Wheels vehicles could cause overheating f
5. a Power Wheels 6 volt 4 0 Amp Hr charger 120 VAC 60 Hz with an output of 6 VDC to charge your Power Wheels 6 volt 4 0 Amp Hr battery Adults Note Regularly examine the charger for damage to the cord plug housing or other parts that may result in the risk of fire electric shock or injury In the event of any damage do not use the charger until the damage has been properly repaired Please call1 800 348 0751 e f your battery is old and will not accept a charge do not leave it in the vehicle Always remove a dead battery from the vehicle K0451 pr 0921 BATTERY INSTALLATION IMPORTANT The battery must be removed from your vehicle for the initial charge in order to complete assembly After assembly is complete you do not need to remove the battery from your vehicle to recharge it Unlocked Battery Connector Charger Connector Fastener e Locate the lock fastener in the back end of the seat e Fit the charger connector and the battery connector together Ly e Using a slotted screwdriver turn the lock fastener 1 4 turn to the Push firmly to make sure the connectors are completely joined unlocked position e Plug the charger into a standard wall outlet E e Lift the seat from the vehicle Notes f power flow to the wall outlet is controlled by a switch make sure the switch is ON Battery Use the charger only in a wall outlet Do not plug the charger Retainer into a ceiling outlet e Before fi
6. as mica ce tentacacea eww tad teagta vias A Sef Goetec a ag acne E monte E Seger Rees eel aust ainar ay arab aver ene de time oes vena 15 LE HITT CHE NAY AIG AN ME caer teeth Anta arti ne A E A E es moe ahd ripe rind eta cat Sten rth E T Nan eye teal 16 ProniemS and SOUtnon S Gudo Sa T tse cues pre ere arlOu ney ur ecg eye ny ene rena eee pene ee ee ule IMPORTANT INFORMATION e Your new vehicle requires adult assembly Please set aside at e f you have any questions about your Power Wheels vehicle least 20 minutes for assembly please call our toll free service lines at 1 800 348 0751 Trained e You must charge your battery for 18 30 hours before you use customer service representatives are available to take your your vehicle for the first time We recommend that you start call in English or French Habla Espa ol Si usted tiene alguna charging your battery before beginning assembly Please see pregunta necesita asistencia llame gratis 1 800 348 0759 para Battery Charging beginning on page 6 for detailed instructions los Estados Unidos Tenemos representantes que hablan espanol e Read this manual carefully for important safety information para atender su llamada a and operating instructions before using your vehicle Keep e For your convenience Power Wheels maintains an Authorized this manual for future reference as it contains important service Center Network with more than 300 independently information owned and operated authorized service cente
7. hillips screwdriver Do not over tighten e Loosen the screw in the battery retainer and remove it K0451pr 0921 11 BATTERY INSTALLATION I lt TSS 4 S a Locked Battery Connector y e Plug the battery connector into the motor connector Lock Fastener Hint If the battery connector will not plug into the motor connector turn it over and try again Do not force the battery connector into the motor connector e Using a slotted screwdriver turn the lock fastener 1 4 turn to the locked position IMPORTANT Always remember to keep the lock fastener locked at all times to prevent children from accessing the battery LMT e Insert the front tab on the seat into the slot in the vehicle 12 K0451pr 0921 BATTERY CARE AND DISPOSAL Care Disposal lt ped lf a battery leak develops avoid contact with the leaking acid e Your Power Wheels battery is a non spillable sealed lead acid and place the damaged battery in a plastic bag See information battery It must be recycled or disposed of in an environmentally below for proper disposal sound manner lf acid comes in contact with skin or eyes flush with cool water e Do not dispose of a lead acid battery in a fire The battery may for at least 15 minutes and call a physician explode or leak lf acid is internally ingested give water milk of magnesia or e Do not dispose of a lead acid battery in your regular household egg whites immediately Ne
8. ing anything behind the vehicle Avoid severe driving conditions such as driving up Slopes or running into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors lf a thermal fuse in a battery continually trips under normal driving conditions please contact your local Power Wheels Authorized Service Center For the location of the Authorized service Center nearest to you visit us on line at www powerwheels com or call 1 800 348 0751 Important Notes e Your new battery must be charged for at least 18 hours before you use it in your vehicle for the first time e We recommend that you start charging your battery before beginning assembly of your new vehicle e The battery must be upright while charging e The charger is not a toy e Do not short circuit the battery e You do not need to remove the battery from your vehicle to recharge it e Before charging the battery examine the battery case for cracks and other damage which may cause sulfuric acid electrolyte to leak during the charging process If damage is detected do not charge the battery or use it in your vehicle Battery acid is very corrosive and can cause severe damage to surfaces it contacts Do not charge the battery on a surface such as a kitchen counter top which could be damaged by the acid contained inside the battery Take precautions to protect the surface on which you charge your battery Use only
9. ire or explosion e The battery must be handled by adults only The battery is heavy and contains sulfuric acid electrolyte Dropping the battery could result in serious injury Never allow children to charge the battery Battery charging must be done by adults only A child could be injured by the elec tricity involved in charging the battery Never lift or carry the battery by the wires or connector This can damage the battery and possibly cause a fire resulting in serious injury Lift and carry the battery by the case only Read the safety instructions on the battery Examine the battery charger and their connectors for excessive wear or damage each time you charge the battery If damage or excessive wear is detected do not use the charger or the battery until you have replaced the worn or damaged part CAUTION Use the charger in dry locations only About Thermal Fuses Your Power Wheels 6 volt 4 0 Amp Hr battery is equipped with a built in thermal fuse The thermal fuse is a self resetting safety device which automatically trips and shuts down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped release the button on the handlebar and wait approximately 25 seconds before operating the vehicle again To avoid repeated automatic shut downs do not overload the vehicle by exceeding the 40 Ibs 18 kg maximum weight capacity or by tow
10. nce a fuse has tripped release the button on the handle and wait 25 seconds before operating the vehicle again To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 40 Ib maximum weight capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center K0451pr 0921 PROBLEMS AND SOLUTIONS GUIDE PROBLEM Vehicle runs sluggishly Sometimes the vehicle doesn t run but other times it does When the button is pressed the vehicle won t run without a push Battery s thermal fuse constantly trips but the vehicle is not overloaded nor the driving conditions too severe Loud clacking or grinding noise from a motor gearbox Charger gets warm during use Battery makes a sizzling or gurgling noise when charging POSSIBLE CAUSE Undercharged battery longer than 30 hours Battery needs charging Battery is old and will not accept full charge Vehicle is overloaded Driving conditions are too stressful Loose wire or connector Motor or electrical switch damage Loose wire or connector Dead Spot on motor Damaged battery Broken gears It is normal for some chargers to get warm during use and is not reason for concern Some chargers do not get
11. nt tipovers away from steps cars steep inclines roads and alleys Riding Rules Make sure children know and follow these rules for safe driving and riding Always sit on the seat Always wear shoes Only 1 one rider at a time Teach Safety Rules to Children While children can quickly develop the skill necessary to drive this vehicle it is important to remember that their judgment skills are still very immature Unsupervised driving by children can lead to serious injury Before children use this vehicle an adult should carefully evaluate the driving area as well as the children s skill level and ability to drive this vehicle safely Children are not always able to recognize or anticipate hazards even when they have been taught about them There is no acceptable substitute for direct adult supervision Teach appropriate safety rules to your child before allowing operation of this vehicle These rules should also be reviewed with neighborhood children or other playmates who want to drive this vehicle Riding Rules Make sure children know and follow these rules for safe driving 1 Always sit on the seat 2 Always wear shoes 3 Only 1 one rider at a time A child who is not sitting on the seat or who is standing on the vehicle could fall off cause a tip over or block the driver s view A child could be seriously injured 4 Do not allow any child to drive the vehicle in the street or near moving mot
12. o fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center Short run time Less than Undercharged battery Charge the battery A new battery should have been 1 3 hours per charge charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all wires and connectors Make sure the battery connector is tightly plugged into the charger connector and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Overcharged battery Do not charge the battery longer than 30 hours If you suspect that your battery is damaged as a result of overcharging contact your local Power Wheels authorized service center They can test the battery for you Battery is old and will not Even with proper care a rechargeable battery does not accept full charge last forever Average battery life is 1 to 3 years depending on vehicle use and use conditions Replace only with a Power Wheels 6 Volt 4 0 Amp Hr battery with built in thermal fuse Do not substitute parts Tripped thermal fuse The built in thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe O
13. olumn through the groove in the grille and then through the hole in the front axle REAR VIEW e Fit the steering column and the handlebar connector on the handlebar assembly down through the large round opening in the vehicle e Fit the handlebar connector back through the small square Opening in the vehicle S K0451pr 0921 ASSEMBLY Assembly Tool Lock Nut A Lle om V Steering Column Rounded Side Up SIDE VIEW e Turn the vehicle upright e Pull the handlebar up to be sure the steering column is secure e f you can remove the steering column you have not e Place the lock nut rounded side up on to the end of the assembled the steering column correctly Please refer back to steering column Assembly steps 3 and 4 e Tighten the lock nut firmly using the closed end of the assembly tool Steering Handlebar Connector fe y 1 a VOWS 2 J a a 4 x A MSO 7 e Snap the steering column cap over the cap nut Connector REAR VIEW e Plug the handlebar connector into the motor connector K0451pr 0921 9 DECORATION Proper label application will help to keep the labels looking their best When applying labels keep the following guidelines in mind e Wash your hands before applying the labels e Before applying the labels wipe the surface of the vehicle with a clean dry cloth to remove any dust or oils e Place the labels exactly as shown in the illustrations e For best results avoid
14. orized vehicles 9 Do not allow any child to drive near bodies of water Such as pools or creeks obstructions Such as furniture low tree limbs or play equipment or drop offs Such as stairs or decks 6 Do not allow any child to drive the vehicle in the dark A child could encounter unexpected obstacles and have an accident Operate the vehicle only in the daytime or a well lit area 7 Do not allow your child to drive on sloped or inclined surfaces Restrict your child s driving to generally level ground ONLY 8 Do not allow your child to drive down or across a steep slope The vehicle may gain unsafe speed even if the button is released to stop The vehicle may tilt and tip over The wheels could lose traction causing the vehicle to slip 9 Do not allow your child to drive up steep inclines The motor may stop and the vehicle could roll backwards at an unsafe speed 10 Never put anything near any moving parts Rotating parts such as motors gear boxes and wheels can snag fingers hair etc Causing serious injury Do not allow operation of the vehicle when it is on its side or in an upside down position Do not operate the vehicle near flammable vapors gasoline paint thinner acetone liquid wax etc The vehicle s electrical switches like most electrical switches emit an internal spark when first turned on or turned off The presence of flammable liquids or vapors could cause an explosion or a fire Kee
15. orkmanship Evidence of any attempt at consumer repair will void this warranty THIS WARRANTY DOES NOT COVER AND IS INTENDED TO EXCLUDE ANY LIABILITY ON THE PART OF POWER WHEELS WHETHER UNDER THIS WARRANTY OR IMPLIED BY LAW FOR ANY INDIRECT OR CONSEQUENTIAL DAMAGES FOR BREACH OF WARRANTY SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION SO THIS LIMITATION MAY NOT APPLY TO YOU Should you need service or assistance with your vehicle during the warranty period do not return the vehicle to the store Power Wheels has provided a nationwide network of authorized service centers If there is not an authorized service center in your area please visit us on line at www powerwheels com or call Consumer Relations for information 1 800 348 0751 This warranty gives you specific legal rights and you may also have other rights which may vary from state to state PLEASE SAVE YOUR ORIGINAL SALES RECEIPT 16 K0451pr 0921 PROBLEMS AND SOLUTIONS GUIDE IMPORTANT If you experience a problem with your vehicle first check the Problems and Solutions Guide below If you still experience a problem please contact Power Wheels Consumer Relations toll free at 1 800 348 0751 Or contact your local Power Wheels authorized service center For the location nearest you please visit us on line at www powerwheels com or call 1 800 348 0751 PROBLEM POSSIBLE CAUSE SOLUTION Vehicle does not run Undercharged battery Charge the battery A new battery sho
16. ower Wheels vehicles could cause overheating fire or explosion e The battery must be handled by adults only The battery is heavy and contains sulfuric acid electrolyte Dropping the battery could result in serious injury e Never allow children to charge the battery Battery charging must be done by adults only A child could be injured by the electricity involved in charging the battery e Never lift or carry the battery by the wires or connector This can damage the battery and possibly cause a fire resulting in serious injury Lift and carry the battery by the case only e Read the safety instructions on the battery e Examine the battery charger and their connectors for excessive wear or damage each time you Charge the battery If damage or excessive wear is detected do not use the charger or the battery until you have replaced the worn or damaged part e HOT motors Handle carefully RIDING HAZARD N WARNING e Prevent Injuries and Deaths e Direct Adult Supervision Required e Never Ride at Night e Keep Children Within Safe Riding Areas These areas must be away from swimming pools and other bodies of water to prevent drownings generally level to prevent tipovers away from steps steep inclines cars roads and alleys e Riding Rules Make sure children know and follow these rules for safe driving and riding Always sit on the seat Always wear shoes Only 1 one rider at a time K0451pr 0921 ac
17. p all flammable products in tightly sealed containers and away from the vehicle 1 h 12 Do not allow a child to operate the vehicle without direct adult supervision To preventunsupervised use ofthe vehicle disconnect the motor harness from the battery when the vehicle is not in use 14 K0451pr 0921 VEHICLE OPERATION VEHICLE CARE e Check all screws lock nuts and their protective coverings regularly and tighten as required Check plastic parts ona regular basis for cracks or broken pieces e During snowy or rainy weather the vehicle should be stored inside or under a protective cover Remember to charge the battery at least once per month while your vehicle is not in regular use e Avoid operating the vehicle in wet or snowy conditions and do not spray the vehicle with a hose Do not wash the vehicle with soap and water Water or moisture in the motors or electrical Switches can cause them to corrode and could cause switch or motor failure e Avoid operating the vehicle on sand loose dirt or gravel Sand loose dirt or gravel in the motors or electrical switches can cause them to jam and could cause switch or motor failure e The vehicle can be wiped down with a soft dry cloth For a shiny finish you can wipe plastic parts with a non wax furniture polish applied to a soft cloth Do not use automotive wax Do not use soap and water or spray the vehicle with a hose e To ensure that your vehicle stays in good o
18. perating order we recommend that you periodically have your vehicle checked by a Power Wheels authorized service center For the location of the authorized service center nearest you please visit us on line at www powerwheels com or call 1 800 348 0751 IMPORTANT Use this vehicle ONLY outdoors Most interior floor ing can be damaged by riding this vehicle indoors Fisher Price will not be responsible for damage to the floor if the vehicle is used indoors SS e Press and hold the button on the handlebar The vehicle drives forward at a maximum of 2 mph e Help your child practice steering to learn how far and how quickly to turn the handlebar when driving e Release the button to stop K0451pr 0921 15 LIMITED WARRANTY Bumper to Bumper Limited Warranty One year limited warranty from the date of purchase on the Power Wheels vehicle Six month limited warranty on the 6 volt battery For the original purchaser this one year limited warranty covers the Power Wheels ride on vehicle purchased from Power Wheels against defects in materials and workmanship The six month limited warranty applies only to the 6 volt battery included by Power Wheels with the original purchase of the vehicle This warranty covers normal use and does not cover the Power Wheels vehicle or battery if damaged by unreasonable use neglect accident abuse misuse improper service or other causes not arising out of defects in materials or w
19. plugged into the motor connector and that there are no loose wires around the motors Dead battery If your battery is old or if you have not followed Battery Care instructions your battery may be dead If you are unsure whether or not the battery is dead you can have it tested at your local Power Wheels authorized service center Electrical switch damage The electrical switches can become corroded due to exposure to water or moisture or can jam due to loose dirt sand or gravel Contact your local Power Wheels authorized service center for diagnosis and repair Motor damage Contact your local Power Wheels authorized service center for diagnosis and repair K0451 pr 0921 PROBLEMS AND SOLUTIONS GUIDE PROBLEM POSSIBLE CAUSE SOLUTION Vehicle was running but Loose wires or loose connectors Check all wires and connectors Make sure the battery suddenly stopped connector is tightly plugged into the motor connector and that there are no loose wires around the motors Tripped thermal fuse The built in thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped release the button on the handle and wait 25 seconds before operating the vehicle again To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 40 Ib maximum weight capacity or by towing anything behind the vehicle Do not drive up hills or run int
20. repositioning a label once it has been applied to the vehicle e After applying a label rub the label firmly with a clean dry cloth to make sure the label is adhered to your vehicle Start at the center of a label and smooth towards the outer edges to remove air bubbles FRONT VIEW MY SS ous X h we 10 K0451pr 0921 BATTERY INSTALLATION IMPORTANT Use only a Power Wheels 6 volt 4 0 Amp Hr battery and built in thermal fuse Use of any other battery will damage your vehicle Make sure that you charge the battery for Battery at least 18 hours using the enclosed Power Wheels 6 volt 4 0 Amp Hr charger before operating your vehicle for the first time Charge the battery for at least 14 hours after each use of the vehicle Never charge the battery longer than 30 hours Failure to follow these instructions may damage your battery and will void your warranty Unlocked Compartment Lock Fastener e Fit the Power Wheels 6 volt 4 0 Amp Hr battery inside the battery compartment with the wires facing towards the rear of the vehicle e Locate the lock fastener in the back end of the seat e Using a slotted screwdriver turn the lock fastener 1 4 turn to the unlocked position e Lift the seat from the vehicle Battery Battery Retainer e Place the battery retainer over the battery e Replace the screw through the end of the battery retainer and into the vehicle e Tighten the screw with a P
21. rs nationwide e This vehicle is designed for use on grass asphalt and other The authorized service centers will repair or replace parts under hard surfaces on generally level terrain and by children warranty at no extra charge and can perform non warranty 12 36 months of age repairs for a minimal charge a ice Thie venielccoNLy onidoor Meckintenartionnag can To find the authorized service center nearest you please visit us ee eee gean on line at www powerwheels com or call 1 800 348 0751 be damaged by riding this vehicle indoors Fisher Price will not be responsible for damage to the floor if the vehicle is e To register your vehicle please visit us on line at used indoors www powerwheels com e To prevent damaging the motors and gears do not tow anything behind the vehicle or overload it Do not exceed the maximum weight capacity of 40 Ibs 18 kg K0451pr 0921 IMPORTANT INFORMATION ELECTRICAL HAZARD N DANGER e To prevent electric shock do not immerse in water wipe clean with a damp cloth A WARNING e Battery can fall out and injure a child if vehicle tips over Always use battery retainer e PREVENT FIRE Never modify the electrical system Alterations could cause a fire resulting in serious injury and could also ruin the electrical system Use of the wrong type battery or charger could cause a fire or explosion resulting in serious injury Use of Power Wheels components in products other than P
22. rst time use charge the battery for at least 18 hours Never charge the battery longer than 30 hours e Recharge the battery after each use of your vehicle for at least 14 hours Do not charge the battery longer than 30 hours e Once the battery is charged disconnect the charger connector from the battery connector Unplug the charger from the wall outlet The battery is now ready to be installed in your vehicle If your battery is already installed in your vehicle simply re connect the battery connector and motor connector Replace the battery retainer and the seat Battery gt e Loosen the screw in the battery retainer and remove it e Lift the battery retainer and remove the battery from the battery compartment K0451pr 0921 7 ASSEMBLY WARNING oo Wheel Assembly ue Children can be harmed by small parts in Axle sharp edges and sharp points in the vehicle s unassembled state or by electrical items Care should be taken in unpacking and assembly of the vehicle Children should not handle parts including the battery or help in assembly of the vehicle gt in Grille Column Handlebar Tubes Large Round Opening FRONT BOTTOM VIEW e Turn the vehicle over so that it rests on the handlebar e Position the front wheel assembly so that the grille is toward Small the front end of the vehicle Fit the front wheel assembly onto Square the handlebar tubes Opening e Fit the end of the steering c
23. ted by law arge the battery at least once per month even It the vehicle for anyone to throw away lead acid batteries in the municipal has not been used waste stream e Leaving the battery in a discharged condition will ruin it e Always remove an exhausted battery from the vehicle Battery leakage and corrosion can damage the vehicle e Do not store the battery on a surface such as a kitchen counter top which could be damaged by the acid contained inside the battery Take precautions to protect the surface on which you store the battery e Do not store the battery in temperatures above 75 F or below 10 F e Use only a Power Wheels 6 volt 4 0 Amp Hr battery Remember to charge the new battery for at least 18 hours before first use e Prevent the battery from moving freely inside the battery compart ment Always use the battery retainer to secure the battery in the battery compartment e Examine the battery charger and their connectors for excessive wear or damage each time you charge the battery If damage is detected do not use the charger or the battery until you have replaced the worn or damaged part K0451pr 0921 13 SAFE DRIVING RULES RIDING HAZARD N WARNING e Prevent Injuries and Deaths e Direct Adult Supervision Required e Never Ride at Night e Keep Children Within Safe Riding Areas These areas must be away from swimming pools and other bodies of water to prevent drownings generally level to preve
24. uld have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all connectors Make sure the battery connector is tightly plugged into the charger connector and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Charger is not working There is no sure way to tell if your charger is working unless you have a volt meter If you suspect there is a problem with your charger contact your local Power Wheels authorized service center They can test your charger for you Tripped thermal fuse The built in thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped release the button on the handlebar and wait 25 seconds before operating the vehicle again To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 40 Ib maximum weight capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center Loose wires or loose connectors Check all wires and connectors Make sure the battery connector is tightly
25. uthorized service center for diagnosis and repair Check all wires around the motors and all connectors to make sure they are tight Contact your local Power Wheels authorized service center for diagnosis and repair Contact your local Power Wheels authorized service center for diagnosis and repair Contact your local Power Wheels authorized service center for diagnosis and repair No action required If your charger does not get warm during use it does not mean that it is not working properly No action required If your battery does not make noise or swell slightly during charging it does not mean that it is not accepting the charge lf after reviewing the Problems and Solutions Guide the vehicle still fails to operate please contact your nearest authorized service center K0451 pr 0921 Before first time use you must charge the battery 18 hours Charge the battery immediately after each use Charge the battery once a month even if the vehicle is not used or stored Do not return your vehicle to the store We re a toll free phone call away and we can help If you are missing parts or need assistance please call 1 800 348 0751 Or contact your local independently owned and operated Power Wheels Authorized Service Center For the location nearest you visit us on line at www powerwheels com BARBIE and associated trademarks and trade dress are owned by and used under license from
26. ver give emetics or induce vomiting trash The incineration landfilling or mixing of sealed lead acid Call a physician batteries with household trash is prohibited by law in most e Charge a new battery for at least 18 hours before first use areas Never charge the battery longer than 30 hours Overcharging or e Protect the environment by not disposing of this product with undercharging the battery may shorten battery life and decrease household waste 2002 96 EC Check your local authority for vehicle running time recycling advice and facilities Europe only e After the first charge recharge the battery for at least 14 hours e Return an exhausted battery to a federal or state approved after each use Never charge the battery longer than 30 hours lead acid battery recycler such as a Power Wheels authorized Charge the battery after each use regardless of how long the service center or a local seller of automotive batteries For vehicle was used the authorized service center location nearest to you please e The battery must be upright while charging visit us on line at www powerwheels com or call 1 800 348 e Do not allow the battery to run down completely before 0791 Contact your local waste management officials for other charging information regarding the environmentally sound collection recycling and disposal of lead acid batteries If you live in the i ri e td AN d pa Teni State of Florida or the State of Minnesota it is prohibi
Download Pdf Manuals
Related Search