EdgeStar OR320SS Owner`s manual
Contents
1. In every case there must be adequate ventilation and access for service Free standing installation A free standing installation will allow you to install the outdoor refrigerator in almost any place you desire You must follow the stated instructions for electrical requirements and leveling the refrigerator Built in installation A recessed installation will allow you to install the beverage cooler under a counter or in a kitchen cabinet provided the required clearance space around the beverage cooler is followed It is necessary to allow adequate ventilation space around the unit make sure there is at least some ventilation room for the back of the unit The following additional items must be observed 1 Place the outdoor refrigerator in front of the installation location Adjust the feet and place the unit flat on the floor or on a platform depending on your installation requirements 2 If the electrical outlet for the outdoor refrigerator is behind the cabinet plug in the outdoor refrigerator 3 Push the outdoor refrigerator into position WARNING Do NOT install the outdoor refrigerator behind a closed cabinet door Important Notes e Choose a location that has ambient temperatures above 25 F and below 100 F Operation outside these temperatures may result in lowered efficiency or cause other adverse effects e In a rainy environment a water proof covering is recommended e Do not kink or pinch the po2. Remove the bottom hinge and place it on the opposite side at the bottom of the door Position the door on the bottom hinge Align the door on the bottom hinge and replace the top hinge and top hinge mat Replace top hinge cover and bottom louver sh the plug buttons into the spare screw holes on the top of the cabinet Note Whether your outdoor beverage cooler can reach the actual set temperature depends on the ambient environmental conditions Caution If you powered off the unit please wait at least 5 minutes before powering it back on OPERATION Installation Check List before Operation 1 Have all packing materials and tape been removed from the interior and exterior of the outdoor refrigerator 2 Have the installation instructions been followed including connecting the machine to electricity And has proper grounding been installed for the outdoor refrigerator 3 Has the machine been leveled 4 Is the outdoor refrigerator in a site where the ambient temperature is between 25 F and 100 F all year round 5 Is there a clearance of at least 1 2 at the rear 1 at the top and 1 4 at the sides for proper air circulation Removing the Shelves 1 Open the door completely 2 If necessary make sure you remove all the contents sitting on the shelf 3 Pull the shelf forward until the it stops 4 Lift up the front of the rack and remove it from the unit 5 Continue to pull the shelf forward unti
3. cut or remove the grounding plug Do not use extension cords or power strips with this unit You may need to contact your electrician if it is necessary to use a longer cord or if you do not have a grounded outlet Do not modify the power cord s length or share the outlet with other appliances Do not start or stop the unit by switching the circuit s power on and off If the power cord is damaged it must be replaced by the manufacturer or a qualified technician Never repair the unit while it is plugged in Immediately unplug the unit if it makes strange sounds emits smells or smoke comes out of it and contact customer service Do not remove any part of the casing unless instructed by an authorized technician You should never attempt to repair the unit yourself Contact customer service for service options if the unit needs service General Safety To prevent back and other types of injuries use at least two people to move and install the unit This appliance is not intended for use by persons including children with reduced physical sensory or mental capabilities unless they have been given supervision or instruction concerning the use of the appliance by the person s responsible for their safety Install the outdoor refrigerator in a well ventilated area where the ambient temperature is above 25 F and below 100 F The temperature range for this cooler is optimized for outdoor beverage storage Perishable food items ma
4. your outdoor refrigerator into its final location it is important to make sure you have the proper electrical connection A standard electrical supply 115 V 60Hz properly grounded in accordance with the National Electrical Code and local codes and ordinances is required It is recommended that a separate circuit serving only your outdoor refrigerator be provided Use receptacles that cannot be turned off by a switch or pull chain The fuse or circuit breaker size should be 15 Amps Recommended grounding method For your personal safety this appliance must be grounded It is equipped with a power supply cord having a 3 prong grounding plug To minimize possible shock hazard the cord must be plugged into a mating 3 pronged wall socket and grounded in accordance with the National Electrical Code and local codes and ordinances If a mating wall socket is not available it is the personal responsibility of the customer to have a properly grounded 3 prong wall receptacle installed by a qualified electrician Leveling the outdoor refrigerator It is important for the refrigerator to be leveled in order to work properly It can be raised or lowered by rotating the plastic sheaths around each of the feet on the bottom of the machine If you find that the surface is not level rotate the feet until the outdoor refrigerator becomes level You may need to make several adjustments to level it We recommend using a carpenter s level to che
5. NITIVE DAMAGES OF ANY NATURE INCLUDING WITHOUT LIMITATION LOST REVENUES OR PROFITS OR ANY OTHER DAMAGE WHETHER BASED IN CONTRACT TORT OR OTHERWISE SOME STATES DO NOT ALLOW THE EXCLUSION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES SO THE ABOVE EXCLUSION MAY NOT APPLY TO YOU THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS YOU MAY HAVE OTHER RIGHTS THAT VARY FROM STATE TO STATE SEdgeStar EdgeStar Products 500 N Capital of TX Hwy Bldg 5 Austin TX 78746 Toll Free 1 866 319 5473 Web http www edgestar com E mail service edgestar com Register your product download owner s manuals access additional troubleshooting resources and obtain more information on other great EdgeStar products on the web at http www edgestar com Product contents and specifications may change without notice Copyright 2011 Living Direct Inc All rights reserved
6. SEdgeStar Outdoor Refrigerator OR320SS Owner s Manual Important Safety Information Improper handling can cause serious damage to the EdgeStar outdoor refrigerator and or injury to the user This outdoor refrigerator is designed for domestic indoor use only Do not use the unit for industrial or commercial use Any other use may invalidate the warranty Please review the ratings label located on the rear panel of the unit for electrical and other technical data related to this unit The unit must be used in a properly grounded wall outlet Please read and follow the safety information listed below to reduce the risk of fire electric shock or injury Electrical Safety Do not exceed the power outlet ratings It is recommended the refrigerator be connected on its own circuit The unit must be installed in accordance with state and local electrical codes A standard electrical supply 115 V 60Hz that is properly grounded in accordance with the National Electrical Code and local codes and ordinances is required Use outlets that cannot be turned off by a switch or pull chain Always turn the unit off and unplug it from the outlet when cleaning Unplug the unit if it is not going to be used for an extended period of time Do not operate the unit with a power plug missing the ground plug a damaged cord or a loose socket Be sure the refrigerator is properly grounded Never plug or unplug the unit with wet hands Do not bypass
7. ce any part free of charge including labor that fails due to a defect in matenals or workmanship Labor will be performed free of charge atan authorized EdgeStar repair facility and EdgeStar will supply new rebuilt or refurbished parts free of charge EdgeStarmay request a defective part be retumed in exchange forthe replacement part All replacement parts or products will be new remanufactured or refurbished All products and parts replaced by EdgeStar under warranty service become the property of EdgeStar After the 12 month period EdgeStar will no longer be responsible for labor chargesincured or replacement parts All defective products and parts covered by this waranty will be repaired or replaced ona mail in basis to an EdgeStar authorized repair facility This warranty applies to the original purchaser only and only covers defects in workmanship experienced during operation of the product under nomal service maintenance and usage conditions This warranty appliesto the purchase and use of this product in residential settings within the United States of America Exc eptions Commercial or Rental Use Warranty 90 dayslaborand parts from date of original purchase No other waranty applies WHAT IS NOTC OVERED The following limitations apply to the coverage of this warranty This warranty does not cover Labor charges for installation setup or training to use the product Shipping damage and any damage caused by imp
8. ceceeeeececeeeeceaueeseceeeeeeeaueuueeeeeesueaueeseeeeeeuaeaneeseeeeess 9 TROUBLESHOOTING 4 oanneoreareoreoeerinssveanecanssansuvendeeeasadgeensdendenansdardienenac gaande 9 TROUBLESHOOTING CONTINUED cccccececceceeeeeeececeeceuaeeueeseceeeeesuaeeseeeeeeeeeananeess 10 SPECIFICATIONS aan anas enseneenunnsnsnsnnanunansnsnssnsnnnenunensensannannsensensannsnnsenssnn 11 EDGESTAR LIMITED WARRANTY nnnnennnnenenenenenenenenenenenenenenenenenenenenenen 12 First Time Operating Instructions Before use make sure all packaging labels and materials are all removed from the unit Be sure to keep track of all included parts and pieces before discarding packaging materials It is advised that you keep the original box and packaging materials in case you are ever to move or ship the appliance in the future Let the unit stand for at least 24 hours before you use it this allows the cooling components time to settle from transit The instruction manual should be read before use This owner s manual is provided for reference use only Specifications may change without prior notice Refer to the product label on the back of your outdoor refrigerator for the latest technical information EdgeStar Outdoor refrigerator ii Introduction Thank you for purchasing this EdgeStar outdoor refrigerator We are glad you chose us We believe that your purchase of this product opens a relationship between you and EdgeStar We will provide the customer s
9. ck the machine 1 Place a carpenter s level on top of the product to see if the refrigerator is level from front to back and side to side 2 Adjust the height of the feet as follows Turn the leveling feet to the right to lower that side of the refrigerator Turn the leveling feet to the left to raise that side of the refrigerator IMPORTANT Once you are ready to install it in a cabinet or directly on the floor you must adjust the feet to level the outdoor refrigerator EdgeStar Outdoor refrigerator Reversing the Door Swing cabinet To 1 2 3 6 To 1 2 3 4 5 Pu ao 2 _ Top hinge cover Plug buttons Top hinge mat Top hinge remove door from hinges Remove the top hinge cover and bottom louver Using a Phillips screwdriver remove the screws then remove top hinge mat and top hinge Keep the parts together and set them aside Lift the door off the bottom hinge and turn it upside down so that the handle is on the right Set the door aside Using a flat screwdriver remove the four plug buttons from the screw holes on the door Set aside Using a Phillips screwdriver remove the magnet baffle and door switch baffle then place them on the opposite side at the top of the door Push the four plug buttons into the spare screw holes replace door on hinges Using a flat screwdriver remove the plug buttons from the screw holes opposite the door hinges top and bottom Set aside
10. ents Rinse the inside surfaces with plain water and dry the chrome racks basket and shelving Avoid getting excess water inside the machine since it will flow into the water trap near the compressor and possibly overflow TROUBLESHOOTING Before Calling for Help If the unit appears to be malfunctioning read through the OPERATION section of this manual first If the problem persists check the Troubleshooting Guide below and on the following page The problem could be something that can easily be solved or explained Symptoms Possible causes Solutions The outdoor beverage cooler turns on and off frequently The temperature is higher than the recommended ambient environment Run the cooler at the appropriate ambient temperature The door is being opened often Minimize the number of times the door is opened The door is not completely closed Make sure the door is completely closed The door gasket is not sealing properly Make sure the door gasket is properly sealing The cooler does not have the suggested ventilation Read and follow the Installation Clearance Requirements section Troubleshooting continued Issue Possible cause Solution The outdoor beverage cooler does not turn on There is a power failure Ensure the cooler is plugged in and the power outlet has power The cooler is not plugged in Plug the unit in to a power outlet
11. il at service edgestar com or by telephone at 1 866 319 5473 Front View Tip Gather the model and serial number from the product label and write them down before installing the outdoor refrigerator EdgeStar Outdoor refrigerator Parts Identification Light switch Installing the outdoor refrigerator The outdoor refrigerator should be installed in accordance with local electrical code requirements The refrigerator should also be placed in a location that is strong enough to support its total weight keeping in mind that it will weigh substantially more when fully loaded than when empty Before you plug the outdoor refrigerator into a power supply be sure to let it stand upright for at least 24 hours to allow the compressor s oils to settle Unpacking the Outdoor refrigerator WARNING Use two more people to move and install the outdoor refrigerator Failure to do so can result in back or other injury Carefully remove the packaging materials Remove any shipping tape and glue from your outdoor refrigerator before using Do not use sharp instruments rubbing alcohol flammable fluids or abrasive cleaners to remove tape or glue These products can damage the surface of your outdoor refrigerator IMPORTANT Do not remove any safety warning or product information labels from your outdoor refrigerator Types of Installation This outdoor refrigerator has been designed for free standing or built in installation
12. l it is completely removed from the inner compartment Using the Temperature Control This unit has a compartment temperature range of 35 50 F This refrigerator has a rotary temperature control knob thermostat inside the unit which is marked with the settings OFF COLD COLDEST in order of increasing coldness In addition this model employs a heater inside the cabinet and is designed for outdoor use Allow at least 24 hours before storing your outdoor beverages and to allow the temperature to acclimate Note To prevent excessive strain on the compressor do not leave the unit at the COLDEST setting for more than an hour at a time Operating the Internal Light This appliance has an internal light to make it easier for you to see the foods you have stored When the door is open the light will be on and when it is closed the light will be off IMPORTANT e Do not touch the power plug when your hands are wet e Never unplug the unit by pulling on the plug EdgeStar Outdoor refrigerator Normal Sounds Your new outdoor refrigerator may make sounds that are not familiar to you Most of the new sounds are normal Hard surfaces like the floor walls can make the sounds seem louder than they actually are The following describes the kinds of sounds that might be new to you and what may be making them e Ratting noises may come from the flow of the refrigerant or the water line Items stored on top of the outdoor refrige
13. rator can also make noises e The high efficiency compressor may make a pulsating or high pitched sound e Water running from the evaporator to the water bin may make a splashing sound e As each cycle ends you may hear a gurgling sound due to the refrigerant flowing in your outdoor refrigerator e You may hear air being forced over the condenser by the condenser fan Preparing the Outdoor refrigerator for Storage If the outdoor refrigerator will not be used for a long time or is to be moved to another place it will be necessary to defrost the unit and dry the interior 1 Disconnect the cooler from the power supply by removing the power plug from the wall socket 2 Leave the door open to allow for air circulation and to prevent mold mildew and unpleasant smells CAUTION Store the unit out of the reach of children If you have children you may want to take additional precautions such as removing the door to prevent a child from being trapped inside the cooler CLEANING AND MAINTENANCE Periodic cleaning and proper maintenance will ensure efficiency top performance and long life Exterior Cleaning Unplug your Beverage Center Clean the outside with a cloth dampened in mild soapy water Dry thoroughly with a soft cloth To clean the door gasket use only mild soapy water Never use harsh cleansers or scouring pads to clean any part of your unit Interior Cleaning Unplug your Beverage Center and remove its cont
14. roper packaging for shipment to an authorized service center and any damaged caused by improper voltage orany other misuse including abnormal service handling or usage Cosmetic damage such as scratches and dents Normal wearand tearon parts or replacement of parts designed to be replaced e g filters cartridges batteries Service trips to deliver pick up or repair install the product orto instruct in proper usage of the product Damagesor operating problems resulting from misuse abuse operation outside environmental specifications uses contrary to instruc tions provided in the owners manual accidents acts of God vermin fire flood improperinstallation unauthorized service maintenance negligence unauthonzed installation or modification or commercial use Labor service transportation and shipping charges forthe removal and replacement of defective parts beyond the initial 12 month period Products that have been modified to perform outside of specifications without the prior written permission of EdgeStar Products lost in shipment or theft Products sold ASIS or from an unauthorized reseller Products that have had their serial numbers removed defaced or with serial numbers that have been invalidated Damage from other than nomal household use Replacement or repair of household fuses circuit breakers wiring or plumbing Damage to personal property from use of product Damage from service othe
15. rthan from an authorized EdgeStar repair facility Hoses knobs lint trays and all attachments accessories and disposable parts Any service charges not specifically identified as normal such as nomal service area or hours Any special or consequential damages arising out of the use of the product OBTAINING WARRANTY SERVICE If you believe your product is defective contact EdgeStar Customer Support for troubleshooting assistance and warranty service at www edgestar com or call 1 866 319 5473 Before contacting Customer Support you are required to have your model number serial number and proof of purchase available upon request Once an EdgeStar authorized representative has confirmed that your product is defective and eligible for warranty service the product must be retumed to an EdgeStar authorized repair facility EdgeStaris not responsible for damage resulting from shipper mishandling or improper packaging Do not retum a defective product to the place of purchase Products received without a retum authorization number will be refused THIS WARRANTY IS IN LIEU OF ANY OTHER WARRANTY EXPRESS OR IMPLIED INCLUDING WITHOUT LIMITATION ANY WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE TO THE EXTENT ANY IMPLIED WARRANTY IS REQUIRED BY LAW IT IS LIMITED IN DURATION TO THE EXPRESS WARRANTY PERIOD ABOVE NEITHER THE MANUFACTURER NOR ITS DISTRIBUTORS SHALL BE LIABLE FOR ANY INCIDENTAL CONSEQUENTIAL INDIRECT SPECIAL OR PU
16. snssnenunsnensnensennns 2 FRONT VIEW emrenin unsere oeh NA wet T E dewaele dennen 2 INSTALLING THE OUTDOOR REFRIGERATOR annen een enenen on enensenn 3 TYPES OF INSTALLATION 00c0cececcceeseeeeeececeeeseeeeeeseceeeeueuauaeeeseseeeesueaueueeseeseeuaneasess 3 Free standing installation nnen ennerennnenenne en ennenenneeneneenenneeenneenenenennnnn 3 Built in installation nennen eener nennen eneenerrnenenenvenerr nennen enen 3 INSTALLATION CLEARANCE REQUIREMENTS 0cccccccccseceeeeseceeeseceueeeceeeseeeauaneeeeees 4 ELECTRICAL REQUIREMENTS unne nennen eenene ennn anenun tukin nnen enenvever vennen 5 Recommended grounding method enne ennnenenne eer eneeennneereneenenenn 5 LEVELING THE OUTDOOR REFRIGERATOR nanne en enenenserenennenen versen evenaren 5 REVERSING THE DOOR SWING nennen enenene enen enenensens vennen enen vere rr venen 6 OPERA TION E E E E E A E E E E E E E 7 INSTALLATION CHECK LIST BEFORE OPERATION ccccccseceseesececeeeeeaueeeceeeeueeauaaeeeeess 7 USING THE TEMPERATURE CONTROL w 0seececeeceeceeeeeeececeeseaueeeeseeeeeesauaueeseeeeeeeeea 7 INO RIVALS SOUNDS tenerne ate dieren denke a ce eeeme ee geet eae deauve deter eee 8 PREPARING THE OUTDOOR REFRIGERATOR FOR STORAGE eececcsscseeeseeseeeeeeseeaueeeees 8 CLEANING AND MAINTENANGE aan oaeen nnen seeeanununsnonsenssunsnenensennens 9 EXTERIOR CLEANING nennen enen eeneneneneneneersrrsnenensnensers venen enensersne swennen 9 INTERIOR CLEANING cceecececece
17. that has sufficient amperage A house fuse has blown or the circuit breaker is tripped Replace the broken fuse in your fuse box or reset the breaker The outdoor beverage cooler will not reach the desired temperature The cooler is placed too close to a heat source The cooler does not have sufficient ventilation Keep the cooler away from other heat sources Read and follow the Installation Clearance Requirements section The door is opened too frequently or for a long period of time Close the door tightly and do not open the door too frequently or for a long period of time The outdoor beverage cooler is making strange noises Certain sounds are normal Read the Normal Sounds section The unit is not level or is touching another appliance Check to make sure that the cooler is level and that it is not in contact with another appliance or furniture The body of the outdoor refrigerator is electrified The unit is not grounded properly Contact your local electrician to test your electrical grounding system Frost is forming in the The environment is humid outdoor beverage cooler The ambient temperature is too low The door is being opened too frequently Though the unit uses an auto defrost system under certain conditions manual defrosting may be required If frost builds up you can try running the cooler on a warmer temperature set
18. ting minimizing the number of times you open the door or unplugging the unit to allow the frost to melt The door will not shut properly Your cooler is not level Make sure the cooler is on a level surface The door gasket is dirty Clean the door gasket The door gasket is not installed correctly Make sure the door gasket is properly installed The shelves are incorrectly installed Correctly install the shelves EdgeStar Outdoor refrigerator 10 Specifications Description of product Built in Outdoor refrigerator Model OR320SS Voltage Frequency AC 115V 60Hz Amperage 2 0A Color Stainless Cabinet Stainless Door Refrigerant R134a 2 47 oz High Low side pressure 190 90 psig Compartment Temperature 35 50 F Range Ambient Temperature Range 25 100 F Dimensions Height x Width x Depth 33 5 Xx 14 6 x 24 4 Weight 69 pounds Note Technical data and performance information is provided for reference only Specifications are subject to change Check the rating label on the outdoor refrigerator for the most accurate information EDGES TAR Limited Warranty Full One Year Parts and Labor This product is warranted by EdgeStar and is subject to any conditions set forth as follows WHATIS COVERED Fora period of ONE 1 YEAR from the date of original retail purchase EdgeStar will repair or repla
19. upport needed to nurture that relationship This manual contains important information regarding the proper installation use and maintenance of your outdoor refrigerator Following this manual will ensure that your product will work at its peak performance and efficiency Please save the original product packaging in case you need to safely transport your outdoor refrigerator For Your Records Please write down the model number and serial number below for future reference Both numbers are located on the ratings label on the back of your unit and are needed to obtain warranty service You may also want to staple your receipt to this manual as it is the proof of your purchase and is also needed for service under your warranty Model Number Serial Number Date of Purchase To better serve you please do the following before contacting customer service If you received a damaged product immediately contact the retailer or dealer that sold you the product Read and follow this instruction manual carefully to help you install use and maintain your outdoor refrigerator Read the troubleshooting section of this manual as it will help you diagnose and solve common issues Visit us on the web at http www edgestar com to register your product download product guides additional troubleshooting resources and up to date information If you need warranty service our friendly customer service representatives are available via ema
20. wer supply cord between the outdoor refrigerator and wall or cabinet EdgeStar Outdoor refrigerator Installation Clearance Requirements When installing the outdoor refrigerator under a counter follow the recommended spacing dimensions shown e To ensure proper service access and ventilation allow at least 1 2 clearance at the back 1 at top and 1 4 at sides The installation should allow the unit to be pulled forward for servicing if necessary Top View ve Back of unit 1 4 gt 1 4 H Door Hinge Side View rd 1 2 e The outdoor refrigerator should be installed on a firm and level surface that will be able to support the entire weight of a fully loaded unit It is important for the outdoor refrigerator to be level in order to work properly If needed you can adjust the height of the outdoor refrigerator by rotating the feet See the Leveling the Outdoor refrigerator section e A standard electrical supply 115 VAC only 60 Hz properly grounded in accordance with National Electrical Code and local codes and ordinances is required x d Electrical Requirements ELECTRIC SHOCK HAZARD e Plug into a grounded 3 prong outlet e Never remove the grounding prong from the plug e Never use an adapter to bypass the grounding prong e DONOT use an extension cord e Failure to follow these instructions can result in fire electrical shock or death Before you move
21. y require a different storage environment Do not place hot or warm items into the cooler before they cool down to room temperature In a rainy environment a water proof covering is recommended This unit is not intended to be used by children Children should be supervised to ensure that they do not play with this product Never allow children to crawl inside the appliance If disposing the unit remove the door Do not use this appliance near flammable gas or combustibles such as gasoline benzene thinner etc Only use in an upright position on a flat level surface and provide proper ventilation Do not pinch or kink the power supply line between the unit and cabinet Do not leave any cleaning solutions in the unit Do not use solvent based cleaning agents or abrasive solutions to clean the unit as they may damage the interior and exterior Do not place any other appliances on top of the unit Do not turn the unit upside down on its side or at an angle off level If your model appliance is equipped with a lock take care to keep the keys away from children Do not move the unit without emptying the contents and securing the door in a closed position Table of Contents IMPORTANT SAFETY INFORMATION ana ananas onse esananunsnensnsnnnnensnensens l INTRODUCTION 55055 sate csavec deceased eaaa aeaeaei akede maaana eataa nara aiarren aama danaa iani 1 PARTS IDENTIFICATION an aaan on onen sano onsesennunnsnenssennanunseun
Download Pdf Manuals
Related Search