Hz-200 DMX hazer user manual
Contents
1. Open the screw cap of the liquid container and fill in the fog fluid Make sure that no fluid is spilled or gets into the device The easiest way is using a funnel Fill the fluid container up to the upper level indicator FULL Screw the cap firmly back on Hz 200 DMX th mann MUSIC IS OUR PASSION 25 Operation Turning the unit on Operation Stop the device themann MUSIC IS OUR PASSION NOTICE Fire hazard Do not operate the machine unattended Connect the device to the mains and switch the device on with the main switch The appliance heats up the red LED on the rear panel lights up As soon as the required operating temperature is reached the red LED on the rear panel goes out The device is now operational When operating always ensure that there is sufficient fog fluid in the liquid container to avoid no load running Disconnect the device from the mains Transport the device only when it is completely cooled down To avoid leaking fog fluid during transport you should transport the device only with empty fluid container Remove the condensate collector pad from the haze air outlet to dry Put the pad back into the haze air outlet before using the device next time 26 Operation 7 1 DIP switch operation If you want to control the device only via the DIP switches on the rear panel first set the ON switches 1 to 9 to OFF and switch 10 to ON The unit then operates continuously and2. NOTICE Possible damages caused by unsuitable cleaning agents Cleaners not approved by the manufacturer may permanently damage the unit Only use the fog machine cleaners listed on www thomann de and follow their instructions for use Clean the appliance after every 30 operating hours or if it was not in use for a longer period of time Procedure Make sure that the device is turned off disconnected from the mains and completely cooled down Position the unit in a well ventilated place Insert the suction hose of the haze machine into the bottle with the fog machine cleaner e eE g Connect the device to the mains and switch it on with the main switch Hz 200 DMX th mann MUSIC IS OUR PASSION 35 Cleaning 5 As soon as the required operating temperature is reached the red LED on the rear panel goes out The device is now operational Let the device produce haze with maximum output volume for about 20 seconds 6 Insert the suction hose of the haze machine back into the fog fluid container and let the device again produce haze for about 20 seconds This will rinse the lines The cleaning is completed themann MUSIC IS OUR PASSION 36 Protecting the environment 12 Protecting the environment Disposal of the packaging mate rial For the transport and protective packaging environmentally friendly materials have been chosen that can be supplied to normal recycling Ensure that plastic bag
3. 10 Safety instructions DANGER Electric shock caused by high voltages inside Within the device there are areas where high voltages may be present Never remove any covers There are no user serviceable parts inside DANGER Electric shock caused by short circuit Always use proper ready made insulated mains cabling power cord with a pro tective contact plug Do not modify the mains cable or the plug Failure to do so could result in electric shock death or fire If in doubt seek advice from a regis tered electrician Hz 200 DMX th mann MUSIC IS OUR PASSION 11 Safety instructions themann MUSIC IS OUR PASSION WARNING Risk of burns from flammable liquids The use of flammable liquids in this appliance can cause serious burns and prop erty damages Use only approved hazer fluids Never fill flammable liquids into the container of the device WARNING Danger of slipping from condensate Hazers can produce condensate Do not point the haze on floors Floors and sur faces can become slippery by condensed haze Check regularly that all floors can be accessed without slipping and remove the condensate if necessary 12 Safety instructions WARNING Health hazard when handling hazer fluid Hazer fluid contains glycols which meet the requirements for food products Nev ertheless fluid is harmful if swallowed Do not induce vomiting Get immediate medical attention Keep hazer fluid in a
4. safe place Rinse the eyes upon contact with hazer fluid thoroughly with water CAUTION Possible respiratory problems The device can only be operated safely when using approved hazer fluids Using other fluids can generate toxic gases Any claims for compensation for damages caused by using non approved fluids are excluded Do not let the device produce haze in poorly ventilated areas Do not expose people with health problems such as allergy related respiratory symptoms asthma to artificial haze Hz 200 DMX th mann MUSIC IS OUR PASSION 13 Safety instructions NOTICE Risk of fire Do not cover the device nor any ventilation slots Do not place the device near any direct heat source Keep the device away from naked flames NOTICE Operating conditions This device has been designed for indoor use only To prevent damage never expose the device to any liquid or moisture Avoid direct sunlight heavy dirt and strong vibrations themann MUSIC IS OUR PASSION 14 Safety instructions NOTICE Power supply Before connecting the device ensure that the input voltage AC outlet matches the voltage rating of the device and that the AC outlet is protected by a residual current circuit breaker Failure to do so could result in damage to the device and possibly injure the user Unplug the device before electrical storms occur and when it is unused for long periods of time to reduce the risk of electric shoc
5. does not respond to DMX commands nor the remote control The following table lists the possible settings OFF sw9 sw8 SW7 SW6 SW4 sw3 sw2 sw Function 0 0 0 0 0 0 0 1 25 haze output 0 0 0 0 0 0 1 0 50 haze output 0 0 0 0 0 1 0 0 75 haze output 0 0 0 0 1 0 0 0 100 haze output 0 0 0 1 0 0 0 0 25 air output Hz 200 DMX th mann MUSIC IS OUR PASSION 27 Operation sw9 sw8 SW7 SW6 SW4 sw3 sw2 sw Function 0 0 1 0 0 0 0 0 50 air output 0 1 0 0 0 0 0 0 75 air output 1 0 0 0 0 0 0 0 100 air output 0 DIP switch is in OFF position 1 DIP switch is in ON position 7 2 Remote control operation If you want to control the device via the DIP switches first set the switches 1 to 9 to ON and ON switch 10 to OFF 2 Set the amount of haze or air as well as the interval between two pulses using the rotary con trols and enable the desired function by a keystroke see Chapter 6 Connections and controls OFF on page 20 1 3 4567 8 9 10 themann MUSIC IS OUR PASSION 28 Operation 7 3 DMX mode Setting up the DMX address The value of the DIP switches 1 9 is binary coded To set the desired DMX address set the DIP switches so that the sum of the resulting numbers yields the desired DMX address Please orient yourself by the following table sw9 sw8 SW7 SW6 Sw5 SW4 sw3 sw2 SW1 DMX address 0 0 0 0 0 0 0 0 1 1 0 0 0 0 0 0 0 1 0 2 0 0 0 0 0 0 1 0 0 4 0 0 0 0 0 1 0 0 0 8
6. 0 0 0 0 1 0 0 0 0 16 0 0 0 1 0 0 0 0 0 32 0 0 1 0 0 0 0 0 0 64 Hz 200 DMX th mann MUSIC IS OUR PASSION 29 Operation sw9 sws SW7 SW6 Sw5 SW4 sw3 sw2 sw DMX address 0 1 0 0 0 0 0 0 0 128 1 0 0 0 0 0 0 0 0 256 0 DIP switch is in OFF position 1 DIP switch is in ON position Example To set the DMX address 10 set DIP switches 2 and 4 to ON all others to OFF The highest possible DMX address is 511 all DIP switches to ON DIP switch 10 has no function in this mode DMX functions Channe Value Function l 1 0 255 Amount of haze 0 100 2 0 255 Fan speed 0 100 th mann MUSIC IS OUR PASSION 30 8 Technical data Heater power Haze output Haze fluid container capacity Warm up time Mains power supply Fuse Dimensions W x D Height of housing incl filling port incl bracket Weight Technical data 615 W approx 34 m min 1 21 approx 1 5 min 230 V AC 50 Hz 4A 250V fast blow 5 mm x 20 mm 233 mm x 280 mm 280 mm 330 mm 380 mm 7 5 kg Hz 200 DMX th mann MUSIC IS OUR PASSION 31 Plug and connection assignments 9 Plug and connection assignments Introduction This chapter will help you select the right cables and plugs to connect your valuable equip ment so that a perfect light experience is guaranteed Please take our tips because especially in Sound amp Light caution is indicated Even if a plug fits
7. S TeV Hz 200 DMX hazer th mann user manual MUSIC IS OUR PASSION Musikhaus Thomann e K Treppendorf 30 96138 Burgebrach Germany Telephone 49 0 9546 9223 0 E mail info thomann de Internet www thomann de 09 02 2015 ID 326263 V2 Table of contents na wu A A WUN Table of contents General OCS 5 ciiisca icckcclccecaccccadcacssacexsscszasceatiusesdesccsascesstsacstusouteastesass0e5ssckecs evasscraiesos odeachsousoseteadbeectasestion 5 1 1 Further information 1 2 Notational conventions 7 1 3 Symbols and signal WOrdsS sssssssscsssecssecsssecsnssessssesseesssecsssessescessseesasecssseceseeesacecsneessneeesneeesaeentes 7 Safety instructions n sseiienkniisheheneniehseendee nad ehneteehenetnne nteeinndee det 10 Features un ieienmeilehiiebeiiienssehreeineihssnnret 16 Installation Pa E ER SEEE EE E EEEE E pede svacrase EEES 17 Starting UP pearsa aenea Aaea sa Eee Erea Esa SNEEN eanestcespeedeasesseesta 18 Connections and controls BR NN REN O ERT RAD SRIERHOHERUN 20 Operation E E E E 25 7 1 DIP switch Operation n cccsscsssssssssssssessssssssssssssscsssesssssssessscssssssscssscssscsssessscsssccsscesscssscsssessscesseesees 27 7 2 Remote control OPErAatiON eccesssessssssecssessesssecsecssssessessesssecsecssscsuecsssssesssesssesssessessssessessseeseesees 28 7 3 DMX mode Technical data aan Hz 200 DMX th mann MUSIC IS OUR PASSION Table of content
8. e A i customer service will gladly assist you themann MUSIC IS OUR PASSION General notes 1 2 Notational conventions This manual uses the following notational conventions Letterings The letterings for connectors and controls are marked by square brackets and italics Examples VOLUME control Mono button Cross references References to other locations in this manual are identified by an arrow and the specified page number In the electronic version of the manual you can click the cross reference to jump to the specified location Example See Cross references on page 7 1 3 Symbols and signal words In this section you will find an overview of the meaning of symbols and signal words that are used in this manual Hz 200 DMX th mann MUSIC IS OUR PASSION General notes Signal word DANGER WARNING CAUTION NOTICE Warning signs A themann MUSIC IS OUR PASSION Meaning This combination of symbol and signal word indicates an immediate dangerous situation that will result in death or serious injury if it is not avoided This combination of symbol and signal word indicates a pos sible dangerous situation that can result in death or serious injury if it is not avoided This combination of symbol and signal word indicates a pos sible dangerous situation that can result in minor injury if it is not avoided This combination of symbol and signal word indicates a pos sible dange
9. into a socket the result of an incorrect connection may be a destroyed DMX controller a short circuit or just a not working light show DMX connections The unit offers a 3 pin XLR socket for DMX output and a 3 pin XLR plug for DMX input Please refer to the drawing and table below for the pin assignment of a suitable XLR plug Pin Configuration 1 Ground shielding 2 Signal inverted DMX cold signal 3 Signal DMX hot signal themann MUSIC IS OUR PASSION 32 Troubleshooting 10 Troubleshooting In the following we list a few common problems that may occur during operation We give you some suggestions for easy troubleshooting Symptom Remedy The unit does not work Check the mains connection and the main fuse No haze output 1 Check the fluid level of the hazer fluid 2 Switch the device off and check the hose that leads into the fluid container for flow No response to the DMX controller 1 Check the address settings and the DMX polarity 2 Try using another DMX controller 3 Check to see if the DMX cables run near or alongside to high voltage cables that may cause damage or interference to DMX interface circuits Hz 200 DMX th mann MUSIC IS OUR PASSION 33 Troubleshooting If the procedures recommended above do not succeed please contact our Service Center You can find the contact information at www thomann de themann MUSIC IS OUR PASSION 34 Cleaning 11 Cleaning
10. k or fire Hz 200 DMX th mann MUSIC IS OUR PASSION 15 Features 3 Features This hazer is suitable to be used in clubs bars discotheques and on stages Special features of the device Control via DMX integrated DIP switches or via the supplied remote control Suitable for mobile use due to compact design themann MUSIC IS OUR PASSION 16 Installation 4 Installation Unpack and carefully check that there is no transportation damage before using the unit Keep the equipment packaging To fully protect the device against vibration dust and moisture during transportation or storage use the original packaging or your own packaging material suitable for transport or storage respectively WARNING Risk of injury caused by falling objects Make sure that the installation complies with the standards and rules that apply in your country Always secure the device with a secondary safety attachment such as a safety cable or a safety chain You can install the device on the wall the ceiling or on the floor The device must not be posi tioned with more than 15 inclination during operation The unit requires 20 cm clearance on the sides and above Hz 200 DMX th mann MUSIC IS OUR PASSION 17 Starting up 5 Starting up Establish all connections as long as the unit is switched off Use the shortest possible high quality cables for all connections NOTICE Possible data transmission errors For err
11. or free operation make use of dedicated DMX cables and do not use ordi nary microphone cables Never connect the DMX input or output to audio devices such as mixers or ampli fiers themann MUSIC IS OUR PASSION 18 Starting up Connections in DMX mode Connect the DMX input of the device to the DMX output of a DMX controller or another DMX device Connect the output of the first DMX device to the input of the second one and so on to form a daisy chain Always ensure that the output of the last DMX device in the daisy chain is terminated with a resistor 1100 1 4 W 2 cco n Hz 200 DMX th mann MUSIC IS OUR PASSION 19 Connections and controls 6 Connections and controls Front and rear side CE 2 Ge GB a th mann hazer MUSIC IS OUR PASSION 20 KR WwW N on Connections and controls Main switch to turn the device on off Plug for mains cable with fuse holder Socket for connecting the remote control included in delivery DMX IN OUT DMX input and output Locking screws for the mounting bracket Locking screw for adjusting and fixing the exhaust port Indicator LED red This LED is lit while the device is warming up Once the required operating temperature is reached the LED goes out DIP switch for setting the DMX address and the haze or air output Power LED green The Power LED is permanently lit during operation Mounting bracket Fog fluid container with sc
12. rew cap Hz 200 DMX th mann MUSIC IS OUR PASSION 21 Connections and controls 12 Liquid level indicator 13 Haze air nozzle themann MUSIC IS OUR PASSION 22 Connections and controls Remote control 14 TIMER Button for activating and deactivating the timer function In this mode the set amount of haze air is output in certain intervals The corresponding LED lights while the function is enabled 15 CONT Press this button to turn continuous operation on or off In this mode the set amount of haze air is output continuously The corresponding LED lights while the function is enabled 16 MANUAL Push this button for maximum haze output use WIND SET to control the amount of air The corresponding LED lights while the function is enabled 17 OUTPUT Rotary control to set the amount of haze to be output Hz 200 DMX th mann MUSIC IS OUR PASSION 23 Connections and controls 18 INTERVAL Rotary control to set the interval between two haze blasts 19 WIND SET Rotary control to set the amount of air to be output themann MUSIC IS OUR PASSION 24 7 Operation Filling the unit Operation NOTICE Possible damages caused by unsuitable hazer fluid Hazer fluids not approved by the manufacturer may permanently damage the unit Only use the hazer fluids listed on www thomann de and follow their instructions for use Ensure that the unit is switched off
13. rous situation that can result in material and environmental damage if it is not avoided Type of danger Warning high voltage General notes Warning signs Type of danger Warning flammable substances Warning suspended load Warning harmful or irritating substances Warning danger zone gt eepe Hz 200 DMX th mann MUSIC IS OUR PASSION Safety instructions 2 Safety instructions Intended use This device is intended to be used to produce fine haze by vaporising hazer fluid Use the device only as described in this user manual Any other use or use under other operating con ditions is considered to be improper and may result in personal injury or property damage No liability will be assumed for damages resulting from improper use This device may be used only by persons with sufficient physical sensorial and intellectual abilities and having corresponding knowledge and experience Other persons may use this device only if they are supervised or instructed by a person who is responsible for their safety DANGER Danger for children Ensure that plastic bags packaging etc are disposed of properly and are not within reach of babies and young children Choking hazard Safety Ensure that children do not detach any small parts e g knobs or the like from the unit They could swallow the pieces and choke Never let children unattended use electrical devices themann MUSIC IS OUR PASSION
14. s themann MUSIC IS OUR PASSION 10 11 12 Plug and connection assignMent cccssssssscsssecssecsscecsscceseecssecesecssscesseessscesateessceesneceseeesees 32 Troublesho0ting 2400 ana nen a nennen 33 Cleaning re ER HEINE 35 Protecting the environment usneseenssennseunssennssnnssensssnnsssnnsennnssunssensennssenssnnnssnnnssenne 37 1 General notes General notes This manual contains important instructions for the safe operation of the unit Read and follow the safety instructions and all other instructions Keep the manual for future reference Make sure that it is available to all those using the device If you sell the unit please make sure that the buyer also receives this manual Our products are subject to a process of continuous development Thus they are subject to change Hz 200 DMX th mann MUSIC IS OUR PASSION General notes 1 1 Further information On our website www thomann de you will find lots of further information and details on the following points Download This manual is also available as PDF file for you to download Use the search function in the electronic version to find the topics of Keyword search interest for you quickly Our online guides provide detailed information on technical basics Online guides and terms Personal consultation For personal consultation please contact our technical hotline If you have any problems with the device the Servic
15. s packaging etc are properly disposed of Do not just dispose of these materials with your normal household waste but make sure that they are collected for recycling Please follow the notes and markings on the packaging Disposal of your old device This product is subject to the European Waste Electrical and Electronic Equipment Directive WEEE Do not dispose with your normal household waste Dispose of this device through an approved waste disposal firm or through your local waste facility When discarding the device comply with the rules and regulations that apply in your country If in doubt consult your local waste disposal facility Hz 200 DMX th mann MUSIC IS OUR PASSION 37 Notes th mann hazer MUSIC IS OUR PASSION 38 Musikhaus Thomann e K Treppendorf 30 96138 Burgebrach Germany www thomann de
Download Pdf Manuals
Related Search