Installation manual
Contents
1. V 2 00 RD 140812 HC 4 FC 3 00 Volvo Tech EU manual EN installation iMIV frontmount v2 0 Contact details VolvoTech EU support volvotech eu VOLVOTECH EU INSTALLATION MANUAL IMIV WITH ANY HU FRONTMOUNT STEP 3 removing HU You can now remove the 2 Torx screws from the HU frame and remove the HU the same way as you just removed the temperature control unit Please put the HU carefully on a towel again on the gear shifter For HU X50 MY2005 2009 find instructions for making connections for ALL radio s further down this document STEP 1 removing gear shift cover Remove the gear shift cover preferably use a fishbone tool to just lift it gently Then tilt it and turn it so you can reach the bottom of the cover It might be required to put the shifter in D position if your Volvo is an automatic shifted car Note that the ignition position needs to be in position 2 before you can move the shift leaver Then press the 4 clips gently but firm so you can remove the whole panel Page 3 of 10 c ile ontact details Copyright 2014 VolvoTech EU Replication prohibited VolvoTech i C BE CD 140812 V 2 00 RD 140812 HC 4 FC 3 00 support volvotech eu Volvo Tech EU manual EN installation iMIV frontmount v2 0 VOLVOTECH EU INSTALLATION MANUAL IMIV WITH ANY HU FRONTMOUNT Now put the gear shifter back in to the P position or Neutral if your Volvo is manually shifted and remov2. 12V GND BROWN 12V GND on car harness The quick connects work as follows Insert Hot Wire 0 Tighten ee Strip Leads OHE Insert amp Tighten Sy byt Pin 12 12V BROWN Wire Pin 1 12V RED Page 5 of 10 c ile ontact details Copyright 2014 VolvoTech EU Replication prohibited VolvoTech EU C BE CD 140812 V 2 00 RD 140812 HC 4 FC 3 00 h Volvo Tech EU manual EN installation iMIV frontmount v2 0 support volvotech eu VOLVOTECH EU INSTALLATION MANUAL IMIV WITH ANY HU FRONTMOUNT STEP 5 connecting MelBus Now you can connect the MelBus cable to the MelBus port on the HU This is the most centered round connector on your HU STEP 6 Connections to the iMIV You now connect the other side of the MelBus cable to the iMIV Also now connect the blue connector power cable to the blue connector on the iMIV STEP 7 placing the iPod cable In your mid armrest you can now remove any rubber mats from the bottom and also remove any coin holders in case there is a phone handset inside the mid arm rest do the same remove both mats left and right to the handset If you can remove the bottom of the armrest as well older models up to 2003 You can do this by gently pulling the CD holder upwards You might need to unlock it from the clips at the front part of the bottom where you just removed any coin holder You can now drill a 16mm whole in th
3. VolvoTech EU MANUAL Kind Title Language Version Date Applicable to Contents Installation manual Installation manual iMIV with any HU front mount English 2 00 August 12 2014 IMIV in Volvo with any HU NO RTI installation in car Manual describes the installation of iMIV in combination with any HU front mount installation VOLVOTECH EU INSTALLATION MANUAL IMIV WITH ANY HU FRONTMOUNT Applicable to IMIV Classic iMIV LE iMIV LE all MFI versions Starting points The HU radio is working ok it at least allows you to select different sources Remove any CD from the unit There is NO need to remove battery connections if you do exactly what is stated in this manual In case the installation requires you to put the ignition key in position 2 please make sure you put your light switch in position 1 middle position or off only if your lights actually do switch off in that position to save your battery Obviously if you feel more comfortable you can remove the ground 12V black from the battery in your Volvo while installing Please make sure you put the key in ignition position 2 and leave it there until the battery is connected again Please read the FAQ section on the bottom of this document before installation Required tools Fishbone tool or similar Torx 20 Towel s for panel protection to avoid damages Decide mounting point for iPod and or aux cable Suggested options mid arm
4. an be that same iPod as before but undock from iPod cable first Connect the Auxiliary jack to the headphone jacket of the player and press play If you hear audio now and it sounds correctly you re ready Step 10 Finalizing Now just put anything back to its original place Still be careful not to scratch things please Remove towels used only once totally done Q My Volvo displays the message Battery low what should I do A Please start your car and leave it running for a while Battery was being drained by use of radio and lights during installation What position should the little switch on the iMIV be on A On position 2 generally only for emergency updates position 1 is used Q After starting my car it generally takes 15 seconds or longer before the IMIV source is visible selectable on the HU how come A Please make sure the little switch on the side of the iMIV is in position 2 Page 8 of 10 hn Copyright 2014 VolvoTech EU Replication prohibited a C BE CD 140812 V 2 00 RD 140812 HC 4 FC 3 00 h Volvo Tech EU manual EN installation iMIV frontmount v2 0 support volvotech eu VOLVOTECH EU INSTALLATION MANUAL IMIV WITH ANY HU FRONTMOUNT Q Can I use the iMIV in combination with the CFE CanBus Function Extender A Yes you can in any way The CFE uses CanBus the iMIV users MelBus There is no way the can or will be conflicting Q There is an airbag o
5. e bottom of the armrest Please take care here there might be other cables running below the bottom of the armrest in case there is a phone handset inside the mid arm rest you can either remove the whole handset or leave the handset out or drill the 16mm on the right of the handset Page 6 of 10 Contact details Copyright 2014 VolvoTech EU Replication prohibited VolvoTech EU C BE CD 140812 V 2 00 RD 140812 HC 4 FC 3 00 Volvo Tech EU manual EN installation iMIV frontmount v2 0 support volvotech eu VOLVOTECH EU INSTALLATION MANUAL IMIV WITH ANY HU FRONTMOUNT If you are connecting an iMIV with an iPod 30pin adapter cable most probably you are work from the armrest to the front If you only connect Aux you can work either way Put the round connector of the iPod cable from top to bottom through the whole you just drilled and gently work the cable to the front of the tunnel and pick it up there and connect it to the iMIV Step 8 placing the iMIV behind the HU Now once all cables are in put the iMIV with all cables connected behind the HU Slightly to the left in the direction of the steering Wheel You can use the original bubble bag to make sure the device is stored steady if you want The MelBus device should be positioned just about where the red circle is Please note that there might be a lot of cables stuffed behind the HU already Just tighten them carefully and
6. e the 2 pieces Torx 20 screws Tip put a towel below the Torx screws before you try to remove them to avoid losing them Once the Torx 20 screws are out tilt bottom part the whole unit towards you and pull down untill its free Now turn move the radio on top or in front towards you of the gear shifter so you can reach the back of the radio Put towels plenty on top of the gear shifter and panels to avoid damages Page 4 of 10 Copyright 2014 VolvoTech EU Replication prohibited C BE CD 140812 V 2 00 RD 140812 HC 4 FC 3 00 Volvo Tech EU manual EN installation iMIV frontmount v2 0 Contact details VolvoTech EU support volvotech eu VOLVOTECH EU INSTALLATION MANUAL IMIV WITH ANY HU FRONTMOUNT For ALL HU s STEP 4 Connecting power You can now connect the quick connects to the power source of the radio Find the BROWN 12V and the RED 12V of the original harness in the GREEN connector please note that the iMIV requires battery power power is always available to the iMIV The iMIV will switch on off it selves based on MelBus information please check if there s no harnesses in between the original harness and the radio some Bluetooth car kit Parrot or so might be connected in between and use different colors The supplied quick connect connectors are labeled accordingly IMIV harness RED wire 12V RED 12V 30 VCC on car harness iMIV harness GREEN wire
7. fold them back to the left and right to create the required space Even with all possible cables there it is possible to fit the iMIV there Step 9 testing the iMIV Return any removed connector to its original connection DO NOT LEAVE ANY CONNECTOR OUT NOW At least not from the air conditioning control panel Check all connections for the last time and place the HU back in its original place Put the car key in the ignition and switch it to II Wait a second and then switch on your HU If it is already on leave it on Depending on the HU you have it should now give 2 additional sources being 2 of the following HU X50 SAT1 SAT2 SAT 3 and CD C HU XOX and X1X and 1205 MD C and CD C Page 7 of 10 z BR ontact details Copyright 2014 VolvoTech EU Replication prohibited Volvotecm EU C BE CD 140812 V 2 00 RD 140812 HC 4 FC 3 00 support volvotech eu VolvoTech EU manual EN installation iMIV frontmount v2 0 VOLVOTECH EU INSTALLATION MANUAL IMIV WITH ANY HU FRONTMOUNT Turn source knob to find these sources If you have connected an iPod cable please connect it now to see if it starts charging Select the SAT 1 or MD C source depending on radio again this is your iPod source Play music from iPod now just press play start music and if you hear audio and it sounds correctly you re ready Select CD C only if you also installed the Auxiliary connection and connect any Audio player c
8. m the older units Cables cannot be exchanged with older non mfi units Sorry but we cannot deliver installation support on used iMIV s Page 9 of 10 c ile ontact details Copyright 2014 VolvoTech EU Replication prohibited VolvoTech EU C BE CD 140812 V 2 00 RD 140812 HC 4 FC 3 00 h Volvo Tech EU manual EN installation iMIV frontmount v2 0 support volvotech eu
9. r SRS warning light active after installation how come and what should I do A Most probably you actually did put ignition to position 2 before all connections on the air conditioning panel had been returned to their original position You ll need to see the Volvo dealer to reset this warning light No actual damages are done the circuit had been broken and the car stores that situation as an error and warns you about it How do I operate the iMIV and iPod in my car A Please read the iMIV user manual available on our website Q Can I install and use the iMIV if the internal 4 or 6 CD Exchanger is broken and does not operate at all anymore It even gives CD ERROR A Yes The iMIV will operate on a different source than the CD changer Actually it is a good replacement for the internal CD Exchanger Q If I use the Auxiliary source there is a squelching noise audible in low volume parts of the songs being played A Generally this is not from the Auxiliary source or the connected device but from the device charging the player connected to the Auxiliary Please remove that charger from the device If the squelch is not audible anymore then please replace the charger with a better one Q I bought a second hand iMIV the device looks different manual does not match iPod is not charging iPhone is giving error messages etc A Since our current devices are MFI compliant they have changed fro
10. rest described in this manual in iPhone iPod mount next to HU cable trough bracket next to HU in glove compartment Page 1 of 10 c ile ontact details Copyright 2014 VolvoTech EU Replication prohibited VolvoTech EU C BE CD 140812 V 2 00 RD 140812 HC 4 FC 3 00 h Volvo Tech EU manual EN installation iMIV frontmount v2 0 support volvotech eu VOLVOTECH EU INSTALLATION MANUAL i IMIV WITH ANY HU FRONTMOUNT STEP O prepare your Volvo Remove key from ignition and only put back once ALL connections are made or all connectors are put back into original position For HUXOX and X1X MY1999 2004 find instructions for removing HU X50 further down this document STEP 1 Remove pen holder and gear shift cover Remove the pen holder Pull it carefully in the direction of the gear shifter Unlock and remove the panel around the gear shifter by gently but firmly pressing the 4 clips STEP 2 removing climate control panel Remove the 2 Torx screws from the temperature control unit the lower part of the whole panel and move the bottom of that panel towards the gear shifter Then remove it carefully by pulling it out DO NOT REMOVE ANY CABLES FROM THIS PANEL besides the cigarette lighter connector Now put the unit carefully on a towel to avoid damages on the left side of the tunnel and leave it there Page 2 of 10 Copyright 2014 VolvoTech EU Replication prohibited C BE CD 140812
Download Pdf Manuals
Related Search