Home

"user manual"

1. lt lt lt lt lt i w i oi lt lei lt Jo lt lt Ww ul el Im Hei LO OO Iech LO T PS c o 2 E D NN 2 i EE E Za ae Sg 280 8 E 00 e Ss 2 E o I 2 lt S gt OS SS 35 6 O Gw SZ SS GC D D Sec se ot fg ZC S 2 a 2 25 2 5 lt Y E 7 3 HOW TO USE YOUR CARAVAN S EQUIPMENT Congratulations on your purchase of a new Buccaneer caravan Within this section of your caravan s handbook we will give you brief details on how to operate all of the caravan s equipment from the gas cooking equipment to the window blinds For further details on the major equipment within your caravan please read the individual appliance instructions contained with your user information pack Please note Before attempting to use any gas equipment please ensure that the gas bottle is connected securely to the caravan s regulator via a high pressure gas hose and the bottle valve is in the on position Also ensure the appliance isolation valves are in the on position as shown in the gas system section Please note Before attempting to use any electrical appliance ensure that you have connected the mains connection cable to a mains hook up and that the mains isolation switch is in the on position HOW TO USE YOUR CARAVAN S EQUIPMENT Control panel 7 N EN O ma ga Go I EXT Z
2. HOW TO USE YOUR CARAVAN S EQUIPMENT E TAPS Kitchen tap operation Swivel the tap spout a to the desired position over the sink lift the control lever b to activate the pump and allow water to flow simultaneously To adjust the temperature swivel the lever c to the left or right as shown Kitchen tap Bathroom and shower tap operation The bathroom and shower taps are operated by lifting the lever and turning the lever right for cold and left for hot water In order for the taps to work the pump switch on the control panel needs to be in the ON position For caravans with fixed water tanks the taps need to be in the TAPS position WARNING The water temperature could be very high so do not lift the lever with the tap turned to the full left position Cleaning It is recommended that a non abrasive damp cloth is used to clean the taps Bathroom Tap NEZ GAS LOCKER DOOR All caravan models are fitted with a gas strut supported door which will remain in the open position without the need for a holding bracket This door will remain open unless locked by the key Please note Itis important when raising your gas locker door that you do not push the door past the vertical position as this could damage the hinges Also care should be taken when leaving the door in the open position to ensure that any wind cannot catch the door and push it open beyond the vertical position
3. Using the Electric Hotplate 1 Ensure the electricity is switched on 2 The hotplate control is numbered from 1 Low to 6 High To turn on rotate the knob either clockwise or anti clockwise to the required position 3 To turn off rotate the knob until the line or pointer on the knob lines up with the zero on the control panel The hotplate is a sealed construction and transfers heat through conduction For maximum efficiency a correctly sized pan with a flat heavy gauge base should be used Pan size should be the same or slightly larger up to 1 2 5cm oversize Before using your hotplate for the first time we recommend that you prime and season it To prime the hotplate switch on the hotplate for a short period without a pan to harden and burn off the coating Use a medium to high setting for 3 5 minutes A non toxic smoke may occur during this process Allow it to cool then season To season the hotplate first heat the hotplate for 30 seconds on a medium setting then switch off Pour a minimal amount of unsalted vegetable oil onto a clean dry cloth or paper towel and apply a thin coat of oil to the hotplate surface Wipe off any excess oil then heat the hotplate on a medium setting for 1 minute Occasional seasoning will help to maintain the hotplate s appearance Operation Depending on specification your appliance may be fitted with a glass lid shut off system which cuts off the power to all
4. iv With a suitable jack jack up the caravan under either the axle tube or the axle mounting plate Please note Do Not Use The Chassis As A Jacking Point If there is lack of ground clearance because of a flat tyre gently move the caravan onto some ramping boards v Support the weight of the caravan with the jack and for added safety lower the front and rear corner steadies on the side of the flat tyre Then remove the ramping boards vi Remove the wheel bolts and remove the wheel vii Before fitting the wheel examine it for distortion or other damage Ensure that all mating surfaces are clean and dry including bolt nut seats Recommended jacking point Please note Always Use the Correct Bolts to Secure the Wheel Check with the dealer if unsure Please note A corner steady brace is not to be used for the next step viii Insert the wheels bolts ix After the bolts have been screwed in as far as possible by hand each bolt should be tightened gradually in sequence Do not over tighten at this point as the final tightening should be done with a calibrated torque wrench The wheels of the caravan will not rotate during tightening as they are held rigid by the wheel hub brake unit x Raise the corner steadies xi Lower the caravan to the ground The wheel bolts should be tightened ensuring that the torque is applied evenly around the wheel Using a suitable torque wrench sequen
5. no 5 for at least 1 second Now the GREEN LED will light up by flashing As long as you see this LED flashing the remote control is searching for contact with the operating system When contact is made the flashing stops The illumination of one or two ORANGE arrows on the indicator LED no 14 central on the control panel shows the position of the caravan In the unlikely event that the caravan is already level then the indicator LED no 14 lights up GREEN B ARRIVING ON SITE sl Which device takes command The device which is switched on first remote control or control panel takes the command to control the system until that device is switched off If you would like to switch from one control device to another you need to switch off the power from the device that was in operation first REMARK 1 In the event of switching over from the remote control to the control panel you have to wait a little time to give the system enough time to switch off contact between the remote control and the operating system REMARK 2 It may be that the operating system is built in such a way that receiving a signal between the remote control and the operating system works poorly or even not at all caused by caravan construction materials e g steel wood plastics etc In this case there is a possibility to move the antenna away from the operating system by means of an optional extension cable length max 2 metres avai
6. xiii xiv xv xvi xvii xviii It is recommended that you provide a dry powder fire extinguisher complying with ISO 7165 of at least 1KG capacity by the exit door and a fire blanket next to the cooker Ensure you read the advice to occupier label fitted to your caravan usually found on the inside of the wardrobe door Never exceed your caravans Maximum Technical Permissible Laden Mass see Caravan Towing Vehicle Weight Ratio The laden nose weight for your caravan should not exceed the lower of the following e Towing vehicles maximum nose weight e Tow bar maximum nose weight The caravan s maximum nose weight Ensure heavy and large items are secured before towing your new caravan to reduce the risk of damage being caused while the caravan is in motion Pull out worktop extensions where fitted are only designed to take maximum weight of 6kgs When your caravan is connected to your towing vehicle it should be level or slightly nose down When your caravan is loaded to its MTPLM and the weight distributed in accordance with the handbook your caravan is designed to be towed ata maximum speed of 100kmh 60mph It is illegal to tow your caravan whilst it is occupied Do not leave children under 14 years of age unattended in your caravan Do not tow your caravan with any water in the water heater or water tank if fitted IMPORTANT Your attention is drawn to the notice af
7. 1 Increase the quantity of warm water by pressing the button When activated the plus symbol changes colour to green 2 The settings are ready If you wish to revert to the basic warm water settings before 30 minutes have expired 1 Reset the warm water by pressing the button 2 The settings are ready Heating with electricity Do as follows to activate heating with electricity The greater the power the better the heating performance In choosing between electricity and gas electricity is given priority 1 Start and step between the various power steps Off 1kW 2kW or 3kW with the button or button The set value is displayed on the screen When activated the plus symbol changes colour to green Certain boilers are equipped with max 2kW 2 The settings are ready and the boiler is working at set temperature 3 In order to switch off gas operation press Off i la HOW TO USE YOUR CARAVAN S EQUIPMENT Sods 5 Heating with gas Do as follows to activate heating with gas If both electricity and gas are selected electricity is given priority Unlocking the tool menu It is possible to go from the setting menu to the tool menu Under the tool menu you can access the other functions of the control panel 1 The control panel in setting 2 The control panel in 3 The control panel in menu Press the unlock unlocking menu Press on setting menu with symbol open padlock then OK o
8. HUSH feature can be used repeatedly until the air has been cleared of the condition causing the alarm Note Dense smoke will override the hush control feature and sound a continuous alarm CAUTION Before using the alarm hush feature identify the source of the smoke and be certain a safe condition exists Flashing LED Light This smoke alarm is equipped with a flashing red indicator light The light is located under the test button and will flash every 40 seconds to indicate that the smoke alarm is receiving power Testing Test by pushing the test button on the cover and holding it down for a minimum of 5 seconds This will sound the alarm if the electronic circuitry horn and battery are working If no alarm sounds the unit has defective batteries or other failure DO NOT use an open flame to test your alarm you could damage the alarm or ignite combustible materials and start a structure fire HOW TO USE YOUR CARAVAN S EQUIPMENT E TEST THE ALARM WEEKLY TO ENSURE PROPER OPERATION Erratic or low sound coming from your alarm may indicate a defective alarm and it should be returned for service Note Weekly testing is required Nuisance Alarms Smoke alarms are designed to minimise nuisance alarms Cigarette smoke will not normally set off the alarm unless the smoke is blown directly into the alarm Combustion particles from cooking may set off the alarm if the alarm is located close to the cooki
9. MANUAL MODE no 6 The indicator LED MANUAL MODE no 9 lights up indicating the manual levelling procedure may begin When the caravan leans too steeply the indicator LED SLOPE TOO STEEP no 1 lights up although this LED lights up you are able to level On the side where the caravan is low fill the space under the axle support footplate with some boards to compensate the difference in height This will avoid the risk it is not possible to level the caravan due to a too large difference in height In case of too large height difference the hydraulic jacks may come to the end of their stroke Step 3 In most common cases there lights up one ORANGE arrow on the control panel no 14 which indicates on which side the caravan has to be lifted Before lifting this side FIRST lower the other axle support till it touches the ground ARRIVING ON SITE E e e Then the other axle support can be extended by holding button LEFT SIDE no 10 or RIGHT SIDE no 13 pressed down The levelling procedure automatically stops when the caravan is levelled in the left right direction The ORANGE arrow level LED no 14 goes out LEFT SIDE no 10 INDICATOR LED no 14 RIGHT SIDE READ MANUAL FIRST LEES EERST DE GEBRUIKSAANWIJZING no 1 3 ZUERST HANDBUCH LESEN LISEZ TOUTES LES INSTRUCTIONS N Step 4 Press the button FRONT SIDE no 12 and hold it pressed down till the ORANGE arrow level LED no 14
10. Buccaneer Touring Caravan OWNERS HANDBOOK Issue 1 WELCOME AND INTRODUCTION 1 1 Model Year Designation 1 1 Buccaneer Technical Approvals 1 1 GENERAL SAFETY nsere 2 1 Ventilation seccion 2 2 High Level Ventilation 2 2 Low Level Ventilation 2 2 Ventilation in Separate Bedrooms 2 2 Gas Dispersal Holes nssnnnene a Petrol Diesel FUMES eee SA een 2 2 Fire Extinguishers ln Gase Of Fire 2 2 Fire Retardant Foams s es 2 2 Your Caravan Payload Explained 2 3 PREPARING FOR THE ROAD 3 1 Tyre and wheel checks nsseeneenneeeene 3 1 Caravan Towing Vehicle Weight Ratio 3 1 EA A A 3 1 Internal Loading 8 Checks 3 1 External Loading amp Checks 3 2 Pre Tow Checklist 8 Hitch Up 3 2 Winterhoff Stabiliser Hitch Head A duergeet dese bestet 3 2 Activating the Stabiliser Checking the Stabiliser Connecting To Mains Supply On Arrival SHO a 6 1 Disconnecting Mains Supply When Leaving Site css 6 2 Overseas Electrical Connection 6 2 Gas Safety Advice 00aeeaaenne 6 3 Facts about LPG 6 3 Awning Spaces LPG and Appliance EX iii it 6 3 LPG Gas System 6 3 Gas Supply 6 4 CONNECHON unse 6 4 Changing a Gas Cylinder 6 4 Auto Changeover
11. S EQUIPMENT E Refrigerator Operation The refrigerator is equipped to operate on three power modes e Mains voltage 230V AC e Direct current voltage 12V DC e Gas liquid gas propane butane Select the desired power mode by the energy selector switch battery igniter type models or the energy selector button MES AES Appliances with automatic energy selection AES are additionally provided with automatic mode function Then the AES system automatically selects the best energy source for each particular situation The cooling unit is silent in operation When the appliance is first put into operation there may be a mild odour which will disappear after a few hours The refrigerator will take several hours to reach its operating temperature in the cooling compartment The freezer compartment should be cold about one hour after switching on the refrigerator Cleaning Before starting up the refrigerator it is recommended that you clean it inside and repeat this at regular intervals Use a soft cloth and lukewarm water with a mild detergent Then wipe out the appliance with clean water and dry thoroughly To avoid material alterations do not use soap or hard abrasive or soda based cleaning agents Do not allow the door seal to come into contact with oil or grease Maintenance e In compliance with the applicable regulations please note that the gas unit and the connected ventilation duct
12. WARNING Under no circumstances should alcohol spirit or solvent based liquids be used on GRP or ABS plastic panels as these substances may react with the material and cause visible damage WATER SYSTEMS STERILISATION Clean the water system at the start and end of the season with sterilising fluid When cleaning it is advisable to use a sterilising fluid e g Chempro SDP or similar Please note Itis recommended that for this operation the filter is removed as the fluid reduces the effectiveness of a new filter i Drain down the system Open all taps to allow air in enabling the system to drain quickly See Index Water System Draining ii Remove any water filters fitted and replace with a short length of hose or empty filter cartridge this will ensure the filter is not affected by the disinfectant sterilising solution iii Fill the system by using the pump with a disinfectant sterilising solution Check that the solution at full strength appears at all taps showers Allow to stand for the recommended period of time iv Drain the system down completely v Thoroughly clean the outside of all taps connectors with a cloth soaked in the disinfectant sterilising solution vi Flush the system through with clean drinking water until no traces of disinfectant sterilising solution can be detected at any tap vii After sterilising the system at the start of the season it is recommended that a
13. 10 1 Connection 6 2 Carpets Upholstery and Power Supply Charger 6 1 Curtains UH 10 2 Equipment List Chassis Maintenance 10 7 A 14 1 Chassis Mounted Spare Wheel Carrier 10 4 F Chassis Spare Parts 10 7 Cleaning of all Taps 10 2 Fire Safety ernen 2 2 Cooking Equipment 10 2 Exterior Cleaning 10 1 Furniture hisori ininde 10 1 22 1 E INDEX G Gas Connection cocooccccncccnccncnnnnnnns 6 4 Gas Safety Advice eee 6 3 Generators Charger 7 1 GIOSSAly u na 17 1 H Handbrake eennnnnnessnnrrnerssnnnn 3 5 Heating System EE 8 13 Introduction cccccconccncnncnonoooo 1 1 L AAA ne 3 1 M Mains Un 7 1 Microwave coooocccnncncconoconencnononono 8 16 Model Yeal corria 1 1 N Notification of Change of Ownership coooccccccccccccccnncnnos 19 1 Notification of Change to name and address 20 1 O Oven Hob amp Grill 8 3 P Pitch selecting 5 1 Power Dralion 11 1 Pre Tow Checklist 3 2 R Radio CD with MP3 8 33 RED ann ern 7 1 Refrigerator RM8551 8 7 Reversing isrener 4 1 Road Lights Buccaneer inre 15 2 Roeotltebt c2ogegeutet reegesdeiedrg egen 8 27 S Safety general ceeeeeeeees 2 1 Satellite Dish 8 33 Seating wra
14. Buccaneer nennen 14 1 WIRING DIAGRAM BUCCANEER 15 1 Road Lights Buccaneer 15 2 GENERAL QUESTIONS osen 16 1 GLOSSARY encino narnaranenncnananionnnaceninada 17 1 SERVICE DOCUMENTS use 18 1 NOTIFICATION OF CHANGE OF OWNERSHIP 4 s s5 u22 2 424 240040000000000000 19 1 NOTIFICATION OF CHANGE TO NAME AND ADDRESS une 20 1 USEFUL ADDRESSES aseene 21 1 INDEX c coria aa 22 1 CONTENTS 3 INTRODUCTION WELCOME AND INTRODUCTION Congratulations on choosing a Buccaneer Touring Caravan This Owner s Handbook has been prepared for your guidance to help you derive the greatest amount of pleasure from the use of your caravan and your leisure time We strongly recommend that you read this guide thoroughly so that you are fully aware of all the caravan s features equipment and systems Additional information and detailed appliance instruction manuals are also contained in your Owner s Information Pack which can be found within the white kit box supplied with your caravan Your new Buccaneer caravan has been designed as a recreational vehicle and is intended for recreational use only It is not intended for business hire use or for permanent habitation Buccaneer accepts no liability if the caravan is used for any purpose other than recreational holiday use Any other use other than recreational holiday use will invalidate your warranty Your caravan has been designed for towing be
15. CL IL i To operate the 12V systems for your caravan depress the master switch adjacent to the pump control switches D D ii To operate the pump for your water system depress the left hand rocker switch for operation from an external water source Aqua roll or Water line Note the right hand switch must be in the centre position iii To fill on the onboard water tank the left hand rocker switch must remain in the on position then depress the right hand rocker switch to the EXT position Once the tank is full the pump will automatically switch off iv To use water from the on board water tank the left hand switch must remain in the on position then depress the right hand switch to the INT position Digital readout v When the left hand button is depressed the available battery voltage will be displayed vi When the right hand button is depressed the available water in the water tank will be displayed Note this is to be used as a guide only HOW TO USE YOUR CARAVAN S EQUIPMENT E COMBINED COOKER HOB OVEN AND GRILL OFF FULL RATE LOW RATE o o o v y 2 Sl ui e am Fig 1 Control Operation WARNINGS Use only the gas pressures specified e This appliance is approved for use with Propane and Butane We recommend using Propane gas for this appliance Butane gas may be used although the appliance pe
16. DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations 9th SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations 11th SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations 18 3 6th SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations 8th SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations 10th SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations 12th SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations Fr B SERVICE DOCUMENTS 13th SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations 15th SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordanc
17. Due to the volume of models we produce it is not possible for us to maintain stock levels of every individual component used in our manufacturing process We do stock commonly requested items but some items must be made to order Q 1 Am Having Trouble Booking My Caravan For Its Service In Line With The Requirements What Timescale Is Acceptable A Please refer to the warranty section for the terms and conditions of servicing We would recommend that you plan your services in advance in order to meet the requirements Q I Have A Problem With My Caravan Who Can Help Me A We would always recommend that you contact your supplying Retailer Your local Buccaneer Retailer or Buccaneer Approved Service Centre may be able to assist An inspection can then take place and the necessary course of action agreed Q 1 Am Unhappy With The Service I Have Received From My Retailer Service Centre Where Do I Go From Here A We would recommend that you write to your Retailer Service Centre detailing your problems and requirements requesting a response explaining how they will resolve your complaint A copy of your letter can also be forwarded to Buccaneer Customer Care Department quoting the serial number of your caravan and the name of the Retailer Service Centre Please be assured that we will assist your Retailer Service Centre in resolving any problems 16 2 O GLOSSARY l GLOSSARY from the car the cable will pull the caravan handbr
18. expected number of channels we would recommend you get the TV checked out See step 6 shows how to tune your TV Number of channels picked up from your house connections DTV 0 Programme s Radio 0 Programme s Data O Programme s X DTV 72 Programme s Radio 24 Programme s Data 21 Programme s A Check the coax lead is of good quality Check that the TV aerial lead is of good quality Normally cheap leads from the supermarket give reception problems they are normally mass produced and made to a wider tolerance Ensure the coax lead from the aerial socket to the TV is suitable for digital reception reception if in doubt ask for advice Check location for signal strength Check that the digital tv signal strength where the vehicle is situated is Very Good to Good Go to www digitaluk co uk Enter the postcode and check signal strength HOW TO USE YOUR CARAVAN S EQUIPMENT Hgs ER Note Sometimes transmitters are being repaired or upgraded Go to http www digitaluk co uk help_and_advice engineering_works Check if signal is OK that day week Check there are no obstructions Is the vehicle outside in an open space Check that the vehicle has no obstructions House lean to canopy Trees also blowing in the wind House or other buildings Hills Large vehicles In a valley etc Understand digital signals Troubleshooting guide Checklist
19. flames too high or too low e Turn the knob halfway The cylinder that e Smell of gas was previously in lt lt reserve gt gt will become the cylinder in lt lt service gt gt the Outbreak of fire indicator will turn green as usual If it A planned maintenance schedule of regular stays red this means the system has inspection is recommended replacing been operating on the lt lt reserve gt gt components as necessary cylinder for too long and that this one is also empty It will therefore be necessary We recommend the gas regulator unit be 9 Gg r to change both cylinders replaced every 10 years from the date of manufacture e Close the tap on the empty cylinder Instructions for use Disconnect the cylinder The two inlets of the regulator are to be e Connect the full cylinder Check that the connected by means of two high pressure connections are properly closed and that hoses complying with the specfications of there is no leakage by using leak Standard EN1949 detection fluid The indicator must stay Putting into lt lt service gt gt Figure 1 green er After carrying out a check reposition the After having checked that the indicator arrow on the cylinder previously in use in remains green in the two positions of the order to empty it The new cylinder is now the knob turn the knob so that the arrow is lt lt reserve gt gt cylinder for the system facing to the right or the left The arrow on the knob wil
20. goes out extending of the front corner supports stops by itself when the caravan is levelled in the front to rear direction AUTOMATIC LEVELING SYSTEM FRONT SIDE no 12 INDICATOR LED no 14 READ MANUAL FIRST LEES EERST DE GEBRUIKSAANWIJZING LL ZUERST HANDBUCH LESEN LISEZ TOUTES LES INSTRUCTIONS no 1 1 Step 5 Press the button REAR SIDE no 11 until the corner supports at the rear side are touching the ground Attention The level system does NOT stop automatically 0 Step 6 Press 1x on the button ON OFF no 5 to switch the levelsystem OFF ARRIVING ON SITE E e e Retracting the jacks Follow the procedure below to retract the axle and corner supports 4 I ON OFF RT Zr no 5 AUTOMATIC LEVELING SYSTE H A 0 lt o gt 0 gt 10 SSES SEENEN RETRACT ALL JACKS no 8 O Step 1 Press 1x on the button ON OFF no 5 to switch the levelsystem ON E Er The E amp P logo LED lights up indicating that the levelsystem is switched J on Step 2 Press 1x on the button RETRACT ALL JACKS no 8 once The indicator LED JACKS NOT FULLY RETRACTED no 4 goes out when all jacks have been fully retracted 0 Step 3 Press 1x on the button ON OFF no 5 to switch the levelsystem OFF IMPORTANT Before departure ensure all supports have been retracted Extra functions Calibration setting the zero point The cal
21. 15 seconds 5 Release the knob and turn to required heat setting 6 Ifthe burner has not lit within 15 seconds release knob and wait at least 1 minute before repeating operations 2 to 5 7 Place the oven shelf in the required position and close the door 8 Although the oven heats up quickly a 10 minute preheat is recommended The oven should reach full temperature in about 15 20 mins 9 To turn off rotate the control knob until the line on the knob is aligned with dot on the control panel 10 Always make sure the control knob is in the off position when you have finished For models fitted with spark ignition the procedure is similar except that the burner can be ignited by depressing the ignition button located on the fascia Ignition must be carried out with the door open The oven shelf has been designed to allow good circulation at the rear of the oven A raised bar at the rear of the shelf prevents trays or dishes making contact with the back of the oven To remove a shelf pull forward until it stops raise at front and remove Installation of a shelf is the reverse of this procedure Operation Before first use we recommend heating the oven for about 30 minutes at 200 C to eliminate any residual factory lubricants that might impart unpleasant smells to the meals being cooked A non toxic smoke may occur when using for the first time so open any windows and turn on mechanical ventilators to help
22. 7 8 Fig 1 1 Power ON OFF switch 2 Energy selector button 230V 3 Energy selector button GAS 4 Energy selector button 12V 6 Temperature level selection 7 Temperature level display 8 Indicator LED failure Reset button GAS FAILURE Switching ON OFF Switch ON by pressing button 1 2s Switch OFF by pressing button 1 gt 2s 230V AC operation e Select Mains voltage by pressing button 2 Set temperature step by pressing button 6 12V DC operation vehicle s battery Select Battery voltage by pressing button 4 Set temperature step by pressing button 6 Gas operation Select Gas by pressing button 3 Set temperature step by pressing button 6 RMS8551 models MES appliances manual energy selection Electrical operation oD u 1 2 3 4 AEJ Fig 2 To start the refrigerator press button 1 for 2 seconds The refrigerator starts with the last selected type of energy 230V operaton T gt Press button 2 12V operation Press button 4 Gas operation q Fig 3 Gas operation Press button 3 A The ignition process is activated automatically by means of an automatic igniter The flame extinguishes after reaching the pre set cooling compartment temperature and ignites again if the cooling compartment temperature increases again If the flame is not lit after the first ignitio
23. Buccaneer Customer Care Delves Lane Consett County Durham DH8 7PE www elddis co uk NOTIFICATION OF CHANGE TO NAME AND ADDRESS Previous details E Post Code u a Daytime telephone number uuus sense Date of purchase ene Ir UE Details of your Caravan RANGE dere Mode aus ai Vehicle identification number 17 digits 222444224404244000nnnnenennnnnennnnnnnnnnnnnnnnnnnnnennnn nenn If you do not want to receive information about products and services from Buccaneer please tick LI 20 1 USEFUL ADDRESSES USEFUL ADDRESSES AL KO Chassis Supplier South Warwickshire Business Park Kineton Road Southam Warwickshire CV47 OAL Fax 01926 818562 email mail al ko co uk Thetford Ltd Hobs Grill Oven and Toilet supplier Unit 19 Oakham Drive Parkwood Industrial Estate Rutland Road Sheffield S3 9QX Tel 0114 273 8157 Fax 0114 5753094 email infogb thetford eu Alde International UK Ltd Wet central heating supplier Huxley Close Park Farm South Wellingborough Northants NN8 6AB Tel 01933 677765 Fax 01933 674975 email info alde co uk Dometic UK Ltd Fridge Supplier Dometic House The Brewery Blandford St Mary Dorset DT11 9LS Tel 0844 626 0133 email technical dometic co uk Whale Ltd Munster Simms Engineering Ltd 2 amp 2A Enterprise Road Bangor BT19 7TA Northern Ireland Tel 02891 270531 21 1 FZ o B
24. INDEX E A Interior WallS 10 1 LUDEICAION tecccsecseccsdtessndencece 10 6 Aerial Seitz Windows u a 10 1 O en sn 8 33 Shower Trays Shower Room Alarm and Wash Basin Fittings 10 2 Autowatch Alarm System 8 36 Thetford Toilet 10 3 Automatic Charging System 7 2 TVi OS eenaa 10 4 B Water Containers 10 2 Water Systems Sterilisation 10 3 Battery Charge 8 17 Window Blinds amp Flyscreens 10 1 Battery Installation 7 1 Care of your caravan Battery Maintenance 7 1 Changing a Wheel 10 4 BPW Intelligent Drive Control 8 37 Charging System 7 2 Breakaway Cable use of 3 3 Code of Practice Bulb Range 7 2 Remedial Work 12 3 C KEES tii nadia 11 1 Cables checking 3 5 D Caravan Construction Diamond Standard Wheel Lock 9 2 Main Components o EE 8 30 Awning Channel 13 1 BPW Chassis 22 11210 2 13 1 E Braking System 13 1 Electrical System 74 ees Electricity une 6 1 Locker Door 13 1 12V SyStemS sosesc 6 1 Solid Construction Body Connecting To Mains Supply 6 1 Shell EE 13 1 Disconnecting Mains Supply 6 2 Windows a u une 13 1 Generator Charger ER 6 1 Caravan Handling 4 1 Mains Supp 6 1 Care of your Caravan 10 1 Overseas Electrical Acrylic Windows u
25. Oil level too low or no oil Check for any oil leaks extend towards the ground in the system when the pump is running The pump is not working Repair or exchange correctly There is no or bad electronic Check cables for loss of connection voltage The system does not work Caravan stands too high on Withdrawn the front wheel automatically lamp front the front side wheel lights up NOTHING works even no Possible cause the battery is LED signal fully out of order lt 5V IMPORTANT For all other reports and or malfunctioning of the system please contact your dealer installer ARRIVING ON SITE sal Maintenance The ESP Hydraulics levelsystem does not have parts that need to be maintained periodically When parts have been taken apart the warranty will become invalid If necessary parts could be substituted repaired and or exchanged warranty WARNING In control service work secure the caravan by placing suitable stands under the caravan By not doing this you create a real danger of personal injury or serious accident Preventative Controls e Periodically checking the hydraulic oil level ONLY by dealer installer The hydraulic oil type Pentosin CHF 11S preventative replace after approx 36 months e Periodically check the electronic cables and connections e Periodically check the hydraulic jacks Remove dirt sand mud and other contamination that settles during
26. Shower Mixer Tap HOW TO USE YOUR CARAVAN S EQUIPMENT INTERNAL DOORS Toilet Shower Room Doors Operation from within the shower room To open the door push the small lever down identified in the drawing as A then to unlock push this lever back to the original position Operation from outside the shower room To open and close the door push the lever down If the door is locked and needs to be opened it can be opened by inserting a coin into the lower slot identified in the drawing B and turning the slot OTHER INTERNAL DOORS Other internal doors such as the wardrobe and table storage locker are fitted with a 2 position button lock Push the button to lock the door and the button should remain flush with the door Push the button again to release and the button should then protrude from the door surface Other Internal Doors MAGNETIC CATCHES Magnetic catches work on contact with the metal plate on the rear of the door Simply close the door until the magnet engages and holds the metal plate Pulling the door towards you with a moderate force will be sufficient to disengage the magnetic catch and open the door SPRUNG HINGES Overhead lockers will use sprung hinges These are suitably strong enough when closed to securely retain the door and prevent it from opening in transit Pullin
27. Toilet Unit Malfunctions 8 26 Ee lte E 8 27 The Omivent 12v Rooflight 8 27 Midi Heki Rooflight Mini Heki Rooflight Windows 8 28 Polyplastic Window Opening u 8 28 Blinds amp Elvascreens suniisrssriseriisiisi 8 28 FVS Suit 8 28 Shower 8 28 Taps una 8 29 Gas Locker Door 8 29 Internal Doors 8 30 Magnetic Catches sprung HINGES sinovial cr 8 30 High Level Locker 8 31 Sliding Doors 8 31 Bed M ke u n n een 8 32 Front Wrap Round Seating Option 8 32 Removable Drawer Locker 8 33 Satellite Dish Optional 8 33 Radio CD with MP3 Connectivity 8 33 AVICX EE 8 33 How to use your TV Aerial 8 34 Digital TV set up Guide 0a0neaeeeeanne 8 34 Troubleshooting Guide 8 34 Protect Autowatch Alarm System 8 36 BPW Intelligent Drive Control iDc SYSIEN anna 8 37 SECURITY oia 9 1 Caravan Theft nee 9 1 Diamond Standard Wheel Lock 9 2 How to fit your Diamond Standard Wheel Lock u a 9 2 Hints for using the Diamond Standard Wheel LOCK une 9 2 A unneeesiesseen 9 2 CRIS The Caravan Registration and Identification Scheme eee 9 3 Window Etching amp Chassis Marking 9 3 Electronic Tagging es He 9 3 CARE OF YOUR CARAVAN 10 1 Exterior Cleaning Acrylic Windows Care Instruction
28. but not always this can be folded or removed to provide additional living space Butane Is a form of Liquefied Petroleum Gas LPG which normally comes in blue cylinders This type of gas is most commonly used in the UK although a switch to propane is advised in severely cold weather conditions Calor This is the main supplier of propane red gas cylinders and significant seller of butane blue gas Campingaz This is the trade name of Butane gas Cassette Blind This is a roller blind which is fitted as part of the window assembly often along with a flyscreen thus giving a neat installation Cassette Toilet A form of chemical toilet found in modern caravans where the waste holding tank can be accessed and emptied from outside Chemical Toilet Most modern caravans have them with more up market models having a fully plumbed in flushing version Control Panel Used as the description for the panel of electrical switches and gauges governing 12V and mains electricity systems Corner Steadies The winding device built into each corner of a caravan chassis that is used to stabilise the body once set up on a pitch GLOSSARY Coupling Head See hitch CRiS This is the Caravan Registration and Identification Scheme It is a voluntary scheme which registers caravans in a similar manner to how motor vehicles are registered Allows you to check the legitimate right to ownership of the seller of a sec
29. button RETRACT ALL JACKS no 8 The zero point is programmed Step 6 Press 1x on the button ON OFF no 5 to switch the levelsystem OFF Remote control optional Preface The procedure described below has already been carried out at your dealer installer Consider programming setting the remote control as a condition to make it possible to level the caravan automatically and or manually When this operation for some reason has not been done or has been carried out incorrectly it is not possible to level the caravan with the remote control Antenna Check if there is a antenna connection on the operating system see below If this is not the case the remote control CANNOT communicate with the hydraulic levelling system In principle the antenna connector and the antenna are always present when you purchase the levelsystem including a remote control unit If you purchased the remote control at a later stage then you should remember that this antenna connection on the operating system main unit could be missing The presence of the antenna is dependent on the acquisition period the of the levelsystem After 2013 all operating systems have this antenna connector In this case the dealer installer can directly connect the antenna to the operating system the antenna is supplied with the remote control Operating system including the antenna connection Operating system WITH antenna connection built in protecti
30. is covered Far more information on Thetford toilet fluids see last page of this manual Screw the cap back onto the emptying spout and turn back to its original position Note The Emptying Spout Measuring Cap is supplied in the same packaging as this manual CAUTION Never add toilet fluid directly via the blade or the toilet bowl as this could damage the lip seal of the Waste Holding Tank Always pour the fluids via the emptying spout 6 Slide the Waste Holding Tank back into its original position via the access door Make sure that it is secured with the l F la B HOW TO USE YOUR CARAVAN S EQUIPMENT gs S Standard Control pane HOW TO USE YOUR CARAVAN S EQUIPMENT E safety catch Close the access door and lock it Your Thetford toilet is now ready to use CAUTION Never use force if you cannot get the tank back into place easily This may cause serious damage If blockage occurs always check if the blade handle is in the correct closed position 7 For toilets with own Flush Water Tank Open the water filling door and fill the flush water tank with the correct dosage of Aqua Rinse This Thetford toilet fluid keeps the flush water fresh and improves the flushing Next fill up the flush water tank with clean water approximately 8 litres using a ferry can or hose Your toilet is now ready to use Preparing for use with Optional Features 8 Automatic Ventilator Open th
31. levelling Procedure for automatic deployment extension of the axle and corner supports ON OFF no 5 AUTOMATIC MODE no 7 READ MANUAL FIRST LEES EERST DE GEBRUIKSAANWIJZING ZUERST HANDBUCH LESEN LISEZ TOUTES LES INSTRUCTIONS di Step 1 Press 1x on the button ON OFF no 5 to switch the levelsystem ON Ep The E amp P logo LED lights up indicating that the levelsystem is switched on When there is insufficient or no battery voltage the indicator LED LOW VOLTAGE no 2 lights up In automatic levelling the caravan must be tilted a few degrees forwards The system will indicate whether you have positioned the caravan level enough If you have not the indicator LED FRONT WHEEL no 3 lights up and the system cannot be started automatically The front wheel must be wound down When the caravan leans too steeply the indicator LED SLOPE TOO STEEP no 1 lights up REMARK When the caravan stands too skewed the caravan cannot be automatically levelled You now have two options Stop the levelling procedure and place the caravan on a flatter surface and start again with automatic levelling procedure Or go further with manual levelling procedure 1 Step 2 Press 1x on the button AUTOMATIC MODE no 7 to start the automatic ane levelling procedure When the levelling procedure is complete the indicator LED LEVEL no 14 lights up GREEN REMARK Depending on the angle of the terra
32. new Ultraflow filter cartridge should be fitted Please note Suitable sterilising chemicals are available from your Buccaneer Retailer accessory shop chemists or home brew shops It is not however recommended to use bleach or sodium met bisulphide THETFORD TOILET WARNINGS e Cold Weather Use to prevent freezing during cold weather use add antifreeze to the toilet system fresh water tank Use a non toxic propylene glycol type of antifreeze Refer to chart on container to obtain level of protection e Warmer weather or longer intervals between emptying the waste tank may require additional toilet fluid Use only Thetford toilet fluid to achieve the best results CAUTIONS e Never add toilet fluid directly into toilet bowl Do not use strong household detergents or cleaners that contain chlorine solvents or acid contents e High Altitude and Hot Weather Use with large temperature differences and changing heights during towing over pressure can start to build up in the waste holding tank causing contents to splash upward upon opening the valve blade if opened too fast CARE OF YOUR CARAVAN CHASSIS MOUNTED SPARE WHEEL CARRIER To gain access to your spare wheel lift the spare wheel carrier up and lift up the locking mechanism Then move the mechanism to the horizontal position and the spare wheel carrier will be free to move over the mechanism and allow the spare wheel to drop to the floor to b
33. pulses followed by a pause for 5 seconds Immediately move to fresh air outdoors or by an open door window Do a head count to check that all persons are accounted for Do not re enter the caravan nor move away from the open door window until the emergency services responders have arrived the caravan has been aired out and your alarm remains in its normal condition Call Gas Emergency Services 0800 111 999 or your local Gas Safe Registered Engineer Never restart the source of the CO problem until it has been corrected Never ignore the sound of the alarm If the alarm is sounding pressing the test reset button will terminate the alarm If the CO condition that caused the alert in the first places continues the alarm will reactivate If the unit alarms again within six minutes it is sensing high levels of CO which can quickly become a dangerous situation WARNING Activation of the alarm indicates the presence of Carbon Monoxide CO which can kill you 8 20 Maintenance of your alarm To keep your alarm in good working order Test every week Vacuum regularly to remove dust Keep away from solvents or detergents Avoid spraying air freshener hair spray near the alarm Do not paint the alarm If decorating or using adhesives close to the alarm remove it temporarily The following substances can affect the sensor and cause false alarms Methane Propane Iso butane Iso propanol Ethylene Benzene Toluene E
34. transit position viii Set the refrigerator for 12V operation if any fresh food is stored in it and ensure the door is locked ix Fully close and lock all windows and rooflights Never tow with windows on night setting Leave all curtains and blinds open to prevent damage in transit If your caravan has a rear window this may aid visibility x xi Ensure you remove all items from the microwave and cocktail cabinet before towing PREPARING FOR THE ROAD sal External Loading 8 Checks i Gas cylinders should only be stored correctly positioned and secured in the gas bottle locker The gas should be turned off ii The leisure battery is stored and secured in the battery locker box set into the tray provided and secured Any external connections battery chargers connecting cables etc should be disconnected and stowed iii Check that all exterior locker doors are secure and locked iv Secure and lock the main caravan entrance door PRE TOW CHECKLIST amp HITCH UP Having loaded the touring caravan and secured the lockers and main entrance door i v Check touring caravan wheel bolts are torque tightened to the required level See Index Changing a Wheel Check tyre pressures Refer to the Technical Data Sheet and tyre condition for roadworthiness ii iii Ensure the jockey wheel is down in good contact with the ground clamp tightly secured and th
35. unoccupied even if only for a short length of time Phantom Tracker Your new Buccaneer caravan is fitted with a Phantom Tracker as standard The Phantom ProActive Proiii is the market leading GPS tracking device specifically designed to meet all the requirements for caravans You must phone Tracker immediately to complete the activation process on 0161 476 4050 We will ask you for your chassis or vin number as part of this process though you need not be near the caravan when you make the call We will then send you an installation certificate along with your device number and emergency contact cards This latest generation technology adds a number of innovations including an internet portal to check your system and the ability to remotely control your Alde heating Please take the time to read through the information enclosed within the Document wallet supplied with your caravan and don t forget to return a copy of the installation certificate to us Your first year s subscription is included as part of the package After this initial period Tracker will write to confirm your renewal options For the last 10 years our annual cost has been 99 They have no plans to increase this though there is a monthly Direct Debit option SECURITY DIAMOND STANDARD WHEEL LOCK How to fit your Diamond Standard Wheel Lock 1 The Diamond Standard Wheel Lock is fitted to the nearside wheels 2 Move the caravan until t
36. 2N g UMOIg N g Ulg 10 xal 0409 dul A0EZ NAd aus EN o e Peg J19 a d nd Ind enla n a usalg 19 Pay pay aBuBlO JO MOI 8A IBA SHUM UM En SON vor popa DEEN una eng ma El SOW VOL Maneg 394M 5 pays maja m al Ps vo va v9 e zen ad sindu AZ DO Mdg Asay nojo9 ayeu suen Age a 15 1 ELECTRICAL DRAWINGS ROAD LIGHTS BUCCANEER MS MS 146 Jaye 146 Jaye 18487 YBIH H 18487 YBIH HN MSIMLZ We MLZ W WEL 8 doe SEET ENER T HUM SUM MS syy Joe apis S Wou H T d aj a 3 ES SE 2 3 2 3 num Ei 5 5 UMOJ i 3 z Si S gt ES ys umolg umalg 3 AE usalo usa T T if SM SUM 9 ol Z gt m Lee Ce woe O welg MollaA 9B g Mo aA peg eg SS pay A alo ds E S 213 E 8 3 a 5 E SE Si ON SI ms umolg s y6y Jayrew apis quod SHUM pia MSIMLZ wet doe MIZ MLZ Jojeo pu H H as oney Boy 15 2 GENERAL QUESTIONS l GENERAL QU
37. 3 1 WINDOWS Windows are all of a double glazed acrylic construction and the door frames are extruded aluminium INSULATION Buccaneer caravans are built to comply with grade 3 thermals insulation in accordance with the European Standard BSEN 1645 part 1 This states that an average temperature difference of at least 20 C between the inside and outside temperatures should be achieved when the outside temperature is 0 C FRONT PANEL AND GAS BOTTLE LOCKER DOOR The front panel is constructed from glass reinforced plastic whereas the gas locker door is constructed from moulded acrylic for strength and lightness AWNING CHANNEL Each caravan is fitted as standard with an awning channel as an integral part ofthe near and or off side aluminium roof and body side moulding If it is found necessary to fit additional attachments care must be taken to ensure that any holes which are drilled in the outside of the body are correctly sealed B EQUIPMENT LIST EQUIPMENT LIST BUCCANEER CHASSIS BPW SPACE HEATER ALDE COMBI 3020 WATER HEATER ALDE COMBI 3020 HOB THETFORD ASPIRE 2 GRILL THETFORD ASPIRE 2 COOKER THETFORD ASPIRE 2 REFRIGERATOR DOMETIC RMS8551 SINGLE RMSL8501 TWIN MICROWAVE DAEWOO TAPS CARAFAX MIXER TAP L240 L120 TOILET THETFORD C260S ELECTRICAL CONTROL PANEL CBE WATER FILTER PUMP WHALE IC SYSTEM WITH HIGH FLOW PUMP 12V READING DOWN LIGH
38. AN S EQUIPMENT HOW TO USE YOUR TV AERIAL Digital TV set up guide Connect aerial and power Fix the TV to a bracket or place on a stable flat surface then connect the aerial cable and power lead to the TV and sockets Check the power is on The aerial needs power to work correctly check that the power is switched on Switch on either the mains and or battery power to the vehicle both power sources switch on the aerial 12 Volts Battery On Mains On Tune in TV and choose transmitter Switch on the TV and tune in the channels If the vehicle is moved or a different socket is used you might need to re tune TV If the first transmitter picked up has poor quality pictures then re tune and pick another transmitter With Digital TV s there will be a re tune button on the remote control use this feature and then choose manual re tune Most digital TV s will also allow you to choose the transmitter which is normally available via the Menu function This will vary by TV manufacturer so if you have any problems undertaking this task please refer to your TV manual Troubleshooting Guide Check aerial radio fuse If there is no power check the 5 amp fuse located within the PDU marked radio is in working order f l Q Check TV monitor Check the TV is working correctly by ensuring that the channels tune in correctly in your home If the TV does not pick up the
39. BPW INTELLIGENT DRIVE CONTROL IDC SYSTEM Your new Bucaneer caravans comes fitted with the BPW iDC system and here are some simple instructions on how it operates i The sensors of the iDC system continually measure the lateral accelerations of the caravans axle s ii The iDC system immediately detects any risk of snaking and automatically and gently applies the caravan brakes The gentle braking pulls the caravan back on track iii iDC makes caravan maintenance easier by detecting slack in the braking system iv In the event of a power failure the iDC fails safe so that it automatically returns to the starting position and the service brake is released and remains fully functional For full operating instructions please read the iDC document supplied within your document wallet 8 37 SECURITY l SECURITY Theft deterrent prevention and security of your touring caravan is taken very seriously at Buccaneer That is why we have provided a combination of standard features and optional extras designed to deter and prevent thieves from stealing your property And in the unlikely event that they should succeed aid the identification speedy recovery of your property and assist in the prosecution of the thief Caravan Theft The theft of a caravan can occur in the most unlikely circumstances from a motorway service area even from an owner s driveway Secure all windows and doors when your caravan is
40. D nennen 6 1 BDefr sting Aare een Ee due een Switching off Refrigerator S Power Supply Charger Winter Operation 12V SYSIEMS anna ae 6 1 Alde Heating auananannnennennennnnennen Generator Charger 2200 6 1 Alde 3020 Control Panel 8 Electricity Mains Supply cococcicicoooao 6 1 Battery Charger oocicccccncncconocinonincnnonins CONTENTS 1 MY2015 Buccaneer Smoke Alarm 8 17 Nuisance Alarms 8 18 Battery Replacement 8 18 Cleaning your alarm 0 8 18 Carbon Monoxide Alarm 8 19 Recognising Alarm Signals and Warnings 8 19 Using your Alarm 8 19 Switching on your CO Alarm Re setting the Alarm 8 19 Replacement of Batteries 8 19 Carbon Monoxide Alarm Procedure 8 20 Maintenance of your Alarm 8 20 Thetford Cassette C260S Toilet 8 21 Parse 8 21 Optional Features snnneaaena 8 21 Preparing for use Standard 8 21 Preparing for use with Optional Features Using the toilet Standard Using the toilet with Optional Features 8 23 EMPING ann are 8 23 Emptying with Optional Features 8 24 Cleaning and Maintenance 8 24 Toilet Bowl Waste Holding Tank Winter Operation 8 25 SOMA unse 8 25
41. Digital signals have what the industry calls the Cliff effect The Cliff effect is either you have a picture or not within a very small difference of signal Connect aerial and power strength This happens with both weak and strong signals Picture Cliff Effect Tune in TV and choose transmitter Action vorX Check aerial fuse Check the power is on Check TV monitor Check the coax lead is of good quality Check location for signal strength Check for obstructions Picture Quality e Understand digital signals If after following this guide you still have Signal Strength problems contact your local Retailer or Analog Approved Workshop Digital 8 35 E HOW TO USE YOUR CARAVAN S EQUIPMENT PROTECT AUTOWATCH ALARM SYSTEM The Protect system is fitted as standard on the Odyssey Omega Rallye Crusader and Buccaneer range Manufactured by Autowatch The Protect system is designed to give years of trouble free operation Made with only the highest quality components and using state of the art technology you can be assured that your caravan has the best electronic protection available Each caravan alarm is installed with a Passive Infrared Detector PIR a sensor that detects movement in the caravan and transmits a radio signal to the alarm module If the alarm is on the siren will sound A leg sensor fully sealed against dust and water will detect if t
42. ESTIONS Q Where Can I Obtain Your Latest Brochure A Our latest brochures are available from Approved Retailers or can be viewed and printed from the download section on our website www buccaneer co uk A request form can also be completed should you wish to receive a printed copy of our latest brochures Q Why Is the Handbook Not Specific To My Model A Many of the components used in the manufacture of our caravans are identical throughout our model ranges so we produce a generic handbook which covers all models manufactured for that season If the literature supplied with your caravan does not answer your question then please contact your Retailer for further assistance Q I Require Technical Or Other Information Who Can Help Me A The majority of information you require is available through your Buccaneer Retailer Q Can You Tell Me The Second Hand Price Of My Caravan A As a manufacturer we are not involved in the second hand market You should contact a Retailer The Camping and Caravanning Club and or The Caravan Club They should be able to give some indication of market value Q How Can I Avoid Excessive Caravan Snaking When I Tow And What Should I Do If It Starts A Buccaneer has extensively tested our caravans and we are confident of their stability However many other factors can influence your towing unit When loading your caravan put heavy items low down and mainly over the axle s You should not stow tins b
43. Gas Regulator 6 4 Water System 6 6 High Flow Watermaster Pump with Intelligent Control IC srssiirississisisiis 6 6 Maintenance ssseeeen 6 8 Helpful Hints Troubleshooting Diagnostic Codes 6 9 Winterising eu 6 9 ELECTRICAL SYSTEM 7 1 12v Power Supply ar Battery Installation eee Battery Maintenance seeeseee eeen U ji 3 3 Generators Charger ws AA A men anaiena 230v Power Supply cecccscssccsessssssssseeeeeeee Use of Your Caravans Breakaway Mains Unit enon a eege oe Resetting the RCD Ge Take eacsexsesssu sade ctncanedssaciaresfeae tients e Automatic Charging System 7 2 A laesst Maximum Bulb Ratings for TOWING AND DRIVING eenn 4 1 Internal Lights solace aires 7 2 Reversing G HOW TO USE YOUR CARAVAN S Speed Limits we 4 1 EQUIPMENT 8 1 nn e e SE e re Control Panel s nsessesinsanire eieren eneee 8 2 san Dr le Pe Combined Cooker Hob Oven and Grill 8 3 T nn dl E 453 Using the Hotplate Gas Burners 8 3 OWING Covers ou ecceceeeceeeteeeeeeeeeeeeeseeeeens Using the Electric Hotplate 8 4 ARRIVING ON SITE ee 5 1 Using the Grill z Check Site Regulations neen 5 1 Using the Owen eee 8 5 Selecting a Pitch n z Oven Temperature Control 8 5 The E amp P Hydraulics Levelsystem 5 1 Refrigerator E Operation coooococononccccocccccconcccnannccnonancnnnno GETTING STARTE
44. IN FITTINGS Only clean your shower tray using soap and water Do not use chemical based cleaning agents as this will attack the material CLEANING OF ALL TAPS It is recommended that a non abrasive damp cloth be used for cleaning the taps and showers WATER CONTAINERS i All water remaining in any water container should be disposed of so that the container is empty The outside of external water containers should be thoroughly cleansed and washed down to remove any dirt dust or other contaminant Water at a suitably hot temperature containing an appropriate detergent is recommended for this purpose Water should then be put into the container swirled round then emptied out All containers should then be totally filled with water containing an appropriate disinfectant sterilising solution and allowed to stand for the recommended contact time e g Milton for 15 minutes The solution should be emptied from the container ii iii iv v The opening of any container should be Q CARE OF YOUR CARAVAN l cleaned thoroughly with an appropriate pre prepared wipe impregnated with a disinfectant sterilising solution vi External containers should be inverted whilst stored overnight if possible vii Containers must be filled with mains water only and mains water only should be used for the above cleaning procedure viii On no account should garden hoses be used to fill water tanks
45. If you hold a B E licence you can tow up to a combination weight of 7000kgs The greater the actual laden weight of the caravan in relation to the kerb weight of the towing vehicle the more careful and experienced the driver needs to be and the lower the speed at which instability could occur ii iii iv v vi WARNING It is strongly recommended the loaded weight of the caravan does not exceed the kerb weight of the towing vehicle LOADING Always lower and secure the jockey wheel and the four corner steadies with the brace provided before entering the caravan This will ensure that the caravan does not tip up when you are inside Please note Corner steadies should not be used as a jacking or levelling device Internal Loading amp Checks When loading your caravan it is advisable to i Distribute items evenly over the axle and as low as possible to optimise road holding and achieve the best possible braking effect Do not overload on one side as this will cause the caravan to lean and affect the road holding and stability ii iii Do not stow tins bottles or heavy items in overhead lockers when towing Loose articles should be stowed securely to avoid movement and possible damage Ensure that all lockers cupboard doors and showers doors are closed and room partitions are secured iv v vi Secure all bunks if appropriate vii Store the main dining table in its
46. It is essential that these are not blocked or made ineffective Petrol Diesel Fumes The fitting of a tail pipe to your exhaust will reduce the possibility of fumes entering your caravan through the front fixed ventilation points FIRE SAFETY Fire Extinguishers It is recommended that a 1 kg 2lb minimum capacity dry powder fire extinguisher be carried inside your caravan at all times A pan fire must not have an extinguisher aimed at it but must be smothered with a fire blanket In Case Of Fire i Get everyone out of the caravan as quickly as possible using whichever exit is quickest including windows Do not stop to collect any personal items ii Raise the alarm Call the fire brigade iii Turn off the gas container valve if safe to do so Fire Retardant Foams All caravans are equipped with either Combustion Modified High Resilient C M H R foam cushions or sprung mattresses and fire retardent fabric All furnishings and fabrics used by Buccaneer comply with the Furniture and Furnishings Fire Safety Regulations In addition all upholstery is made of fire retardant fabric Escape Paths Your new touring caravan has been provided with escape paths to be used in the event of an emergency One of which is always the main habitation door and others are the large windows to be used where necessary GENERAL SAFETY T YOUR CARAVAN PAYLOAD EXPLAINED Definitions Plated maximum technical permiss
47. S EQUIPMENT To enlarge the cooling space just remove the freezer compartment Unlock the freezer compartment on both sides and pull it out Store the freezer compartment safely in order to prevent damage Positioning the storage racks Fig 8 The storage racks may be pulled out by smoothly lifting them and may be positioned as desired Note Once the freezer compartment is removed an additional storage rack may be installed The storage rack is a piece of extra equipment and may be obtained by Dometic General advice Switch the refrigerator on approximately 12 hours before filling it e Always store pre cooled foods in the refrigerator Make sure that the food is well cooled when it is bought and also when transporting it Use insulated cooling bags Open the refrigerator door only for a short period of time when removing goods Foods must be packed best of all in closed containers wrapped in aluminium foil or similar and stored separately from each other in order to prevent drying out or odours e Allow foods that have been warmed up to cool down before storing e Avoid storing products in the refrigerator that could emit volatile flammable gases Donot expose the refrigerator to direct sunlight Please bear in mind that the temperature inside a closed vehicle increases sharply if exposed to sunlight and that this can reduce t
48. TS BCA EYEBALL LED LIGHTS RECESSED LED BCA LED RECESSED 14 1 ELECTRICAL DRAWINGS WIRING DIAGRAM BUCCANEER wei E a NS may Pre sur sun Auea eu sino ud pue sapos nojoo Pony sayoyms eunsseud eusajur ue aney sdund Joen og 4 oo Rien Kew suoneoo LJ pue saz s eqes eJoje ay payu eje seayebau au UN m mmol uwo um um 9JON Ges M DEER zem E en yue Joyem pueoquo jeuondo ayy ym BEN pany Aua ase Aay aisen pue euondo aye s ne jene J9 2M 9 Vie eoj pojuajos agold jene Jajem au Im EEN RE SHUMWP9Y UMP9Y UM JO umoug u 19 WG JE Poren on 9e 8 8BUBIO BNO en om Ti mes 7 pay uaald POYO na En an g arlyM nIa um ws wano SS SS we Cis y9eg u 219 119 19 DI anemoon Eed umoygj en g wg nig peyenig Deng mr anig usal gue RER SYUYMAPEIG MAIG usal9 aBuelO W O Gef D saer aBueso pey 10 Pey mm pegiuole ME ISA 9nig 2UM NIM oa oda Son vo fo a Tl E UBBID AIUM 19 UM D D H RO pay umoug poy ug I y aiir
49. TUBES PIN gt BLUE NEUTRAL EARTH SREEN amp VEL Ei d VIEW OF VIEW OF TERMINALS i BLUE NEUTRAL S eve mm met maat RT EARTH GREEN amp YELLOW BROWN UVE CABLE COUPLER WARNING It is essential that connections are made exactly as shown If terminal markings are not in accordance with the above diagram they must be ignored CARAVAN MAINS INLET vii Place any surplus cable under the caravan Ensure that the surplus cable is not coiled up as it could overheat viii Now switch on the mains isolating switch ix x within the caravan this can be found on the main consumer board normally located within the nearside front bed box Check the RCD is working by pressing the test button Once pressed all electrical lights and appliances should cease to operate Reset and then check the electrical system is operational Finally in order to get your 12V system operational ensure the 12V switch is in the ON position Refer to index for further details on the control panel fitted DISCONNECTING MAINS SUPPLY WHEN LEAVING SITE i ii iii Switch OFF at the caravan mains isolating switch Remove the male plug from the site supply Disconnect the female plug from the caravan and store the cable in an appropriate locker OVERSEAS ELECTRICAL CONNECTION Please Note Connection to a mains voltage supply OVERSEAS requires particular atte
50. VING ON SITE sal ARRIVING ON SITE CHECK SITE REGULATIONS On arrival at a site you should always check the site regulations This will help avoid any unnecessary conflict with site management and other site users WARNING Care has to be taken to prevent grounding when traversing ramps or other ground obstacles SELECTING A PITCH Carefully select where you wish to place your caravan The site should be as level as possible preferably not under or near trees well drained and away from possible boggy areas Consider how you will move the caravan when it is time to leave the site On sloping ground it is better to pitch facing downhill especially during wet weather THE E amp P HYDRAULICS LEVELSYSTEM Operation The ESP hydraulics levelling system is an electrically hydraulically driven system A hydraulic pump is powered by a 12V direct current motor which will pump hydraulic oil through a system of hydraulic hoses two hydraulic axle supports and four hydraulic corner supports This with the aim of stabilising and levelling the caravan Mounted to this pump are the oil reservoir the valve block and solenoid magnetic valves The ESP hydraulics level system is electronically controlled by an operating system or so called main unit which is mounted on a central location in the caravan The level system can be operated either fully automatically or manually by means of a built in control panel and or optio
51. Weight This is also known as Combined Weight The maximum permitted weight of an outfit as specified by the tow car manufacturer Gross Vehicle Weight GVW This is the weight of the vehicle laden to its maximum as defined by the manufacturer See also MTPLM GRP Is Glass reinforced plastic but more commonly known as glass fibre not fibre glass which is a trade name Handbook This is a owners manual a guide to the workings of your caravan Hardstanding This is a pitch which has a hard surface made of gravel asphalt concrete etc instead of grass Hitch This is the mechanism which allows a caravan to be attached to a tow ball Hitch Lock A security device that prevents the caravan hitch being used Hook Up This is a facility on a pitch for connection to mains electricity GLOSSARY O l Ingress The entry of water into the caravan structure Jack This is a device for raising the vehicle so that a wheel can be changed for instance Not to be confused with corner steadies which although they are sometimes referred to as corner jacks are steadying not lifting devices Jockey Wheel The small front wheel attached to the caravan A frame used to support the forward end of the caravan when detached from the towing vehicle Kerb Weight This is the empty weight of a motor vehicle as defined by the manufacturer Layout This is the interior design and details where furniture units are p
52. a double bed by pulling out the bed slats Fixed bunks 100 kgs 17 stone stored beneath the chest of drawers or stored N 4 in the bed slat box at the front end of the Fixed single beds 129 kgs ta Son caravan Arrange seat cushions Double fixed bed 250 kgs 39 stone appropriately 8 32 HOW TO USE YOUR CARAVAN S EQUIPMENT E REMOVABLE DRAWER LOCKER To remove from the caravan first locate the two retaining straps at the bottom rear of the unit the straps are released by pulling away and down this releases the thumb catches The locker can now be removed for storage To secure the unit into the caravan first place the locker into position then feed the straps though the thumb locks holding the strap taut push the thumb lock so that is closes on the strap SATELLITE DISH OPTIONAL Operation If you ordered your new Buccaneer caravan with the optional self seeking satellite dish then the full users instructions will be provided within the document wallet provided with the caravan Note Always ensure your dish is in the fully retracted position before travelling Radio CD with MP3 Connectivity Details on how to set up and use the Radio CD will be contained in your document wallet 8 33 AVTEX AERIAL A omnidirectional high gain TV aerial is provided and can receive Digital TV signal AM and FM radio signals and can run up to 3 TV outlet at any one time E HOW TO USE YOUR CARAV
53. a salt spray test to DIN 50021 standard WARNING Holes must not be made without approval of the chassis manufacturer The following maintenance instructions relate to the BPW chassis fitted to your Buccaneer caravan They are a constituent part ofthe warranty conditions Adhere to the relevant operating instructions of the vehicle manufacturer or of the other vehicle component manufacturers Completion of the maintenance work in accordance with the prescribed intervals is essential in order to maintain the operating safety and roadworthiness of the vehicle The correction of any defects found or the replacement of any worn parts should be carried out by a BPW after sales service workshop unless the vehicle user has at his disposal appropriately skilled in company workers and the necessary technical facilities Please note When installing spare parts it is strongly recommended that only original BPW components are used Parts approved by BPW for caravan axles and suspensions regularly undergo special test procedures and as a result BPW is able to guarantee their quality However BPW cannot assess for every single third party product whether it can be used for BPW caravan axles and suspensions without any risk to safety This applies even if an accredited test authority has already tested such products Our warranty becomes null and void if spare parts other than original BPW parts are used Procurement of Spare Parts The cod
54. ake on before snapping 13 pin plug The plug used to connect the caravans electrical system to your towing vehicle to enable the road lights refrigerator and battery charger to operate during towing A Frame This is the triangular part at the front of the caravan s chassis which is between the main body and the hitch it is also called the drawbar ABS This is an acronym for anti lock braking system Actual Laden Weight This is the total weight of the caravan when loaded ready for use by the end user Aquaroll Brand name used generically for a water container that rolls so you don t need to lift it Awning This is a tent like structure of fabric over a supporting framework which can be attached to the side of caravan Battery Charger This is required to keep a leisure battery charged Most caravans include a charging facility which operates via the mains hook up and also has the ability to recharge from the tow car s alternator while travelling Berth s Sleeping place Refers to the number of people a caravan can accommodate for sleeping Blown Air Heating A method of heating the living quarters of a caravan by use of a fan pushing air out through a number of outlets Breakaway Cable A thin steel cable linking the caravan handbrake to the vehicles tow bar In the event of the caravan becoming detached 17 1 Bunk Bed This is a sleeping place usually higher up than a conventional bed Often
55. al Police Station B CARE OF YOUR CARAVAN Q l CARE OF YOUR CARAVAN This section of the guide is devoted to the care cleaning and general preservation of your caravan in order to retain its showroom condition EXTERIOR CLEANING Under no circumstances should an abrasive or harsh cleaner be used It is strongly recommended that you do not use a pressure wash Exterior body parts of the caravan are extremely durable and easy to clean It is recommended you first wash off any heavy dirt and mud with cold water then use a high quality car wash and wax then rinse with plenty of cold water CAUTION The use of a pressure wash on your caravan is not recommended as it can lead to water entering the caravan via any of the external vents and could damage graphics ACRYLIC WINDOWS Your caravan is fitted with shatter resistant acrylic windows To preserve their clarity and unblemished transparency it is essential that the following cleaning instructions are strictly adhered to Road grit dust sand flies lime tree secretions bird droppings etc should be washed off using plenty of cold water do not use a sponge to clean off heavy dirt deposits Any remaining dirt should be washed off using a soft cloth and warm water Please note Under NO circumstances should any abrasive cleaning agents household detergents or proprietary cleaning fluids be used Wash the window again using only cold water and dry off with chamoi
56. arger heavier caravans where the second axle helps carry the greater weight more easily and also makes a longer caravan more stable to tow See also single axle GLOSSARY User Payload The weight of all items carried in the caravan U Shaped Settee Usually a reference to seating that literally is U shaped Vehicle Kerb weight The weight of the tow car often indicated in the manufacturers specifications VIN Vehicle Identification Number This is a unique serial identification number for a vehicle All Cars and motor caravans should carry a VIN Caravans are not obliged to but most of those sold in recent years in the UK do as a result of the CRIS voluntary registration scheme Warranty Is the terms and conditions that spell out your rights with regard to servicing repair or replacement of parts as provided by the manufacturer Wild Camping Term used for staying overnight away from a campsite Illegal in many countries but permission may be granted by individual landowners 17 5 SERVICE DOCUMENTS l SERVICE DOCUMENTS TOURING CARAVANS ANNUAL SERVICE RECORD In order to take full use of your warranty offered by Buccaneer it is essential that your caravan is serviced within the time scale laid down in the warranty terms and conditions See Index Warranty Terms amp Conditions Whether you use your caravan for short journeys or for touring at home or abroad regular servicing will
57. b Swivelling Toilet Bowl c Blade Handle d Flush Button e Waste Holding Tank Level Indicator f Water Filling Door only if toilet has own flush water tank g Rotating Emptying Spout h Automatic Pressure Release Vent i Sliding Cover j Removable Mechanism k Vent Plunger I Pull out Handle m Wheels n Blade Openener o Access Door to Waste Holding Tank 8 21 Optional Features p q r s t Electric Blade Automatic Ventilator Waste Pump Out System Waste Holding Tank Multi Level Indicator Flush Water Tank Level Indicator only if toilet has its own flush water tank Note Optional features can be bought from Thetford dealerships Preparing for use standard 1 Open the access door on the outside of your caravan Remove the Waste Holding Tank by pulling the safety catch which holds the tank in place upwards Pull the Waste Holding Tank outward to the stop Tip it slightly and take the tank fully out Place the tank upright and turn the rotating emptying spout upwards The emptying spout ensures that the tank can be easily and hygienically emptied Remove the cap with the measuring cup inside from the emptying spout and pour the correct dosage of Thetford toilet fluid see product label into the holding tank This avoids unpleasant smells and keeps the inside of the tank clean Next add approximately 2 litres of water enough to ensure that the bottom of the Waste Holding Tank
58. blind flyscreen should not be left in the down position when the caravan is not in use or throughout the winter as the memory of the mechanism may be lost INTERIOR WALLS Your caravan interior walls will only require a wipe over with a damp cloth using a mild detergent to keep them in a showroom condition FURNITURE Treat your caravan furniture as you would the furniture in your home Polish wood surfaces sparingly with a good quality wax or spray polish Use a damp cloth to clean melanate laminated surfaces CARE OF YOUR CARAVAN COOKING EQUIPMENT Caustic pastes abrasive cleaning powders coarse wire wool and hard implements will damage the surface SOFT FURNISHINGS Carpet When cleaning the interior of your caravan please remove the carpet from the vehicle Vacuum the carpets to take the dirt out ofthe pile For general cleaning use a dry shampoo following the products directions For stains use a mixture of 1 3 bleach to 2 3 warm water Immerse a soft cloth in the solution until wet then wring and squeeze the cloth until damp Rub the affected area until the stain has gone NEVER USE DRIPPING WATER The proportion of water to bleach must be accurate Never put the carpet in a washing machine or a tumbler dryer Upholstery Remove dust on a regular basis with your vacuum s upholstery or drape attachment Try to avoid brushing fabric covers because that can damage the pile If you s
59. blinds and flyscreens and are also called rooflights Semi Rigid Pipe work Is water pipes made of a semi rigid plastic and are infinitely preferable to cheaper convoluted piping which can act as a trap for germs and smells Single Axle This is a caravan with a single pair of wheels on one axle See also twin axle Slats Sometimes used for beds and can improve ventilation to mattress cushions Space Heater This is a type of heating equipment for the living quarters Modern units fitted offer gas and mains operation Speed Rating This is the maximum speed at which a tyre may be used as marked on its sidewall Stabiliser A safety device which helps to prevent instability this is done by increasing the friction between the caravan hitch and the tow ball Steady Winder A handle for operating the corner steadies Torque Wrench A form of spanner used to set nuts and bolts to a specified degree of tightness It is recommended for adjustment of wheel fixings on caravans Towing Limit See manufacturer s braked towing limit and manufacturer s unbraked towing limit Towing Mirrors Additional rear vision mirrors added to a towing vehicle to provide a greater width of view to see past a caravan Train Weight The maximum permissible combined weight of tow car and touring caravan Twin Axle Is a caravan with two pairs of wheels on two axles which are located close together These are usually the l
60. button Power level Display Approximate Percentage of Power once P HI 100 twice P 90 90 3 times P 80 80 4 times P 70 70 5 times P 60 60 6 times P 50 50 7 times P 40 40 8 times P 30 30 9 times P 20 20 10 times P 10 10 11 times P 00 0 Battery Charger The battery charger for the caravan battery will automatically switch on when the caravan is connected to a mains supply The battery charger will also provide a 12V supply to the caravan when a battery is not connected Please note that the battery charger fitted is designed to keep your battery charged and is not designed for charging up a flat battery Smoke Alarm Operation The smoke alarm is operating once a fresh battery is installed and testing is complete When products of combustion are sensed the unit sounds a loud 85db pulsating alarm until the air is cleared Hush Control The HUSH feature has the capability of temporarily desensitising the alarm circuit for approximately 8 minutes This feature is to be used only when a known alarm condition such as smoke from cooking activates the alarm If the smoke is not too dense the alarm will silence immediately and the Red LED will flash once every 10 seconds for approximately 8 minutes This indicates that the alarm is in a temporarily desensitised condition The smoke alarm will automatically reset after approximately 8 minutes and sound the alarm if particles of combustion are still present The
61. ce of the tube and pump is recommended After emptying the Waste Holding Tank completely fill it with clean water and empty it again This will clean the pump and the hose Do this once every 3 weeks when on holiday This should ensure proper operation of the system Winter operation You can use your Thetford Cassette Toilet as normal in cold weather as long as the toilet is situated in a heated location If there is a risk of freezing we advise that the toilet is drained by following the instructions under Storage For environmental reasons the use of antifreeze such as that used in car radiators is not recommended Storage It is important that you follow the instructions below if you do not expect to use your Thetford toilet for a long winter period Activate the Control Panel by pressing the flush button Open the blade and press the flush button until water stops flowing into the bowl Close the blade Open the access door on the outside of your caravan and empty the Waste Holding Tank at an authorised waste dump Follow the instructions for cleaning and maintenance To allow the Waste Holding Tank to dry do not place the cap back on the emptying spout of the tank 21 If the toilet has its own flush water tank place a sufficiently large bowl under the drain tube to catch the remaining water from the flush water tank and remove the drain plug When no more water exits put the drain plug on the drain tube pu
62. ck at least one tap is open Turn the pump isolation switch off and on again e Check the battery condition Check the mains isolator switch is on e Check the pump isolator switch is on e Check the contacts in the plug and socket are clean and making contact e Check wiring connections e Check fuse see fuse box b If the pump cylces on off with all taps and shower closed e Check for air or water leaks in taps and piping e Check that non return valve in socket is free from grit by pushing a suitable blunt object for example a ballpoint pen into the socket nipple against the non return valve holding the valve open to dislodge trapped grit e Recalibrate the system see calibration section of the installation section c If pump motor runs steadily and does not stop after 30 40 seconds e Check all connections in pipework e Recalibrate the system Diagnostic Codes To aid with troubleshooting the LED on the back of the Watermaster IC has a number of different flash codes as described in the table below LED State Description Green Constant On Tap open pump running Green Fast Flash lt 1 sec In Calibration Mode Green 200ms blink every 5 sec Calibrated and ready for use Green 200ms blink every 10 sec Un calibrated Green 200ms blink every 15 sec Suspended due to dry run need to turn pump switch on and off Green 200ms blink every 20 sec Suspended due to low battery voltage turn pump switch o
63. cked onto the ball v Wind up the jockey wheel until the wheel supports locate into the cut out sections at the base of the winding section vi Raise and secure the jockey wheel using the clamp The jockey wheel should be parallel to the direction of Fig 3 6 travel at all times vii Check condition of and secure the ii Detachable Ball You must contact the breakaway cable to the tow vehicle tow bar supplier for advice Other Means of Attachment Alternatively it may be possible to attach the cable assembly to a permanent part of the tow bar structure with the approval of the tow bar supplier or to an accessory sold for the purposes of breakaway cable attachment PREPARING FOR THE ROAD HANDBRAKE Your caravan is fitted with BPW running gear and handbrake It is essential that prior to towing you ensure that your handbrake is in the fully off position This can be confirmed by ensuring that the handbrake arm is resting on the blue stop fitted to the side of the A frame as shown in Fig 3 7 below Fig 3 7 CABLES For peace of mind you may wish to check the ability of the cables to be able to cope with towing the vehicle at extreme angles before setting off To do so position the vehicle at alternate extreme angles and check that the cables do not pull too tight are liable to stretch or become unplugged No cables should be allowed to touch the ground as they will wear and become damag
64. connecting plug sockets 10 Overall tests etc 11 Awning lights 12 Electronic ignition hob 13 230V system where applicable Continued Fr B SERVICE DOCUMENTS SECTION E GAS INSTALLATION Hotplate SECTION F FINAL Road test D gr Be a es Refrigerator Heater Leak tested Water heated Fully operational CARE WARRANTY It is a condition of this warranty that a service and safety check is carried out by your caravan retailer at least once a year 12 months from the date of purchase in accordance with the NCC recommendations ANNUAL SERVICE RECORD 1st SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations 3rd SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations 18 2 2nd SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations 4th SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations SERVICE DOCUMENTS 5th SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations 7th SERVICE
65. contact your retailer It is with the retailer that your contract of sale exists and consequently they have the responsibility to ensure any complaints and warranty issues are addressed Any approved Buccaneer Retailer or Service Centre may carry out work at their convenience or discretion but are not obliged to do so All Buccaneer products are classed as portable and therefore all work under warranty requires the caravan to be delivered and collected from the selling retailer The cost of transporting the caravan by any means to and from the place of repair is the responsibility of the owner Conditions attached to the warranty cover If you have your caravan serviced at an NCC approved workshop and then warranty work is required this work will have to be undertaken at an Elddis Approved Retailer or Service Centre and an additional charge may be required to cover the second inspection e You must retain the original sale invoice for the caravan All new caravans must be registered with Buccaneer within 6 weeks of purchase as new Your retailer can forward this information to us Please keep us informed of any name or address changes by using the Notification of Change to Name and Address form WARRANTY O l The caravan must have an annual service and damp check carried out by an Approved Buccaneer Retailer or Service Centre Original invoices and damp reports must be retained as proof that the annual ser
66. cturer by any express or implied undertaking or representation Model Year 2015
67. d be heated for about 20 minutes to eliminate any residual factory lubricants that might impart unpleasant smells to the food being cooked A non toxic smoke may occur when using for the first time open any windows and turn on mechanical ventilators to help remove the smoke Although the grill heats up quickly it is recommended that a few minutes preheat be allowed Itis normal for the flames on this burner to develop yellow tips as the grill heats up Depending on the food to be cooked the correct grilling height can be achieved by inverting the pan trivet into either the high or low position The grill area can get hot when the oven is in use even if the grill is switched off HOW TO USE YOUR CARAVAN S EQUIPMENT E Care should be taken when removing pans from the grill i e use of oven gloves and by making use of the removal grill pan handle The grill pan supplied is multi functional for use in grill oven The handle design allows removal or insertion whilst the pan is in use Always remove the handle when the pan is in use The grill must only be used with the door open Operation Using the Oven 1 Ensure gas cylinder supply is connected and turned on 2 Open door push in the control knob and turn to full rate Gas Mark 9 240 C 3 Continue depressing the knob whilst holding a lighted match or taper to the burner 4 After the burner is lit continue depressing the knob for approximately 10
68. d you require any replacement parts for your caravan it is necessary that you contact the Retailer from whom you purchased the caravan or any Buccaneer approved Retailer and give the following information which will help in identifying the required component i Model and make of caravan ii VIN number iii Description of required part iv Photograph size or diagram of required part Please note All parts must be ordered and supplied through an approved retailer REMEDIAL WORK Buccaneer together with its suppliers is continually undertaking extensive research into testing remedial work procedures and materials such as sealants adhesives gaskets and tapes Therefore if for any reason your new caravan is damaged or requires remedial work then only an approved Buccaneer Retailer or Service Centre should undertake such work All such work should be undertaken using only approved Buccaneer genuine parts recommended sealant and following Buccaneer procedures Buccaneer will also undertake to supply certain specialist repairers with the necessary spare parts In this case your selected repairer must contact the PARTS DEPARTMENT with all enquiries CARAVAN CONSTRUCTION l CARAVAN CONSTRUCTION MAIN COMPONENTS The following is a brief description of the main components used in your caravan More comprehensive descriptions can be found in the equipment manufacturers literature held in the Owner s Informatio
69. e the clutch Change gears smoothly Try not to jerk the clutch CARAVAN HANDLING i ii iii iv v vi vii viii Allow for the caravan being wider than the car Ensure you have a clear view to the rear This may require the fitting of extended mirrors for towing your caravan Give yourself more room when cornering to ensure your caravan wheels do not strike the kerb When passing other vehicles allow more than the normal clearance for driving solo Allow longer to obtain a fast enough speed to pass other vehicles Allow for the vehicle being twice its normal length Do not suddenly swing out Carry out all manoeuvres as smoothly as possible Use the wing mirror to check the caravan has clearly passed other road users when overtaking and changing lanes Adverse weather conditions may affect the steering and braking characteristics of your caravan B TOWING AND DRIVING MOTORWAY DRIVING Important Points 1 Caravans may not be towed in the outside lane of a three or four lane motorway Reduce speed a In high or cross winds b Downhill c In poor visibility High sided vehicles cause air buffeting so extra care must be taken when passing or being passed As much space as possible should be given to avoid the drag created by the high sided vehicle TOWING COVERS We do not recommend that you tow with covers on as it can obscure the road light fitted ARRI
70. e accepted for any consequential loss damage costs expenses or other claims for compensation arising which were not reasonably foreseeable by both parties when the caravan was originally purchased No liability will be accepted for damage caused by fair wear and tear rodent damage willful damage negligence or abnormal working conditions No alteration may be made to the original construction In the case of a dispute Buccaneer will appoint an independent arbitrator Buccaneer will pay for the costs of arbitration subject to the owner paying a 250 deposit If the arbitrator finds in favour of the customer then the deposit will be returned If the arbitrator finds in favour of Buccaneer the customer will lose their deposit Where the arbitrator awards a sum of money less than an offer made by Buccaneer which has already been rejected by the customer then their deposit is forfeited In all cases the arbitrator s decision is final and both parties must agree to abide by the decision Elddis reserve the right to inspect the caravan at any time Exclusions Warranty cover is not given for caravans if they have been used under any of the following circumstances Used for hire Used as a permanent residence Towed behind a commercial vehicle Used for racing or time trials Damage resulting from freezing accident or fire damage Mains electrics It is recommended that you have your mains electrics system inspec
71. e access door on the outside of your caravan and remove the Waste Holding Tank as described above 9 Remove the filter housing cover and if no filter is present place a new filter into the filter housing Peel off the sticker lids on the filter Place back the cover of the filter housing Using the toilet standard 10 Turn the bowl to the desired position with the lid closed and using both hands To activate the control panel press the flush button once The control panel display will stay activated for approximately 5 minutes Run some water into the bowl by pressing the flush button again briefly The toilet may be used with the blade open or closed To open the blade slide the blade handle under the toilet bowl sideways After use open the blade if still closed and flush the toilet by pressing the flush button for several seconds if necessary re activate the control panel Close the blade after use CAUTION If your toilet has its own flush water tank please make sure that you do not travel with a flush water tank that is Ti 12 8 23 too full Do not travel with water in the toilet bowl Failure to adhere to this notice may result in water damage to your caravan Using the toilet with Optional Features 13 Electric Blade Push the electric blade button on the control display to electrically open or close the blade In the case of failure you can manually open or close the blade by sliding the
72. e and type numbers of the axle and chassis components enable us to quickly determine your exact spares requirements when ordering from our BPW agencies and service stations It is therefore recommended that you enter the data showing the type plate located on the centre of the axle Please note For full maintenance details of the BPW chassis undergear and Winterhoff coupling please refer to the individual manufacturer s handbook supplied within your user information pack CARAVAN MOTOR MOVERS Any motor mover fitted shall comply with the design fitment and safety requirements of NCC Code of Practice 305 The installation of a motor mover shall be in accordance with the motor mover manufacturer s installation instructions You should ensure you receive a signed installation certificate of compliance from the installer Failure to do so may invalidate your warranty STORAGE STORAGE LONG TERM amp WINTER STORAGE Ifthe caravan is to be stored for any length of time especially over the winter period the following operations are recommended i Ensure all windows roof lights habitation and exterior locker doors are closed firmly and locked Remove all soft furnishings which could be affected by damp conditions Clean the caravan inside and out as detailed in the previous section Drain the water system see Water system For winter storage and to prevent frost damage all taps must be left in open po
73. e caravan handbrake is fully on Wind up the corner steadies Reverse the car close up to the caravan s hitch It is advisable to seek assistance to guide you so that the car tow ball aligns with the caravan s hitch Use of the caravan handbrake is advised Extreme caution should be taken if manoeuvring the caravan down hill or on wet slippery surfaces Make sure the jockey wheel height is sufficient for the hitch head to clear the towing vehicles tow ball Manoeuvre the hitch head over the tow ball and lower the jockey wheel using the winding handle until the hitch head opening sits comfortably over the tow bar ball iv v vi v WINTERHOFF STABILISER HITCH HEAD OPERATION Coupling The opened ball coupling is placed over the tow ball of the towing vehicle As the coupling load is applied to the tow ball the coupling will automatically close this is indicated when the security lugs become parallel on the side of the housing Fig 3 1 NN ey A CLOSED STABILISER TURNED OFF Fig 3 1 Activating the stabiliser The operating handle will not operate until the automatic closing function has been engaged The handle can now be fully pushed down The hitch will remain coupled with the stabiliser deactivated to facilitate easier manoeuvring Checking the stabiliser With the caravan coupled to your towing vehicle and the stabiliser activated the condition of the friction l
74. e every 30 seconds and the red LED flashes twice End of life of the alarm Replace the alarm Alarm chirps every 30 seconds and red Fault Replace the alarm LED flashes every 30 seconds Red LED on and constant tone Malfunction Replace the alarm Loud continuous alarm with the red LED Dangerous levels of CO have been detected Follow emergency procedures Using your alarm Testing Test your alarm each week by pressing the test button The alarm will beep once followed by 4 loud pulses then a brief pause and then 4 more pulses ending with a single beep While in full alarm the red LED will flash for 10 seconds This confirms that the alarm is powered up and working Re setting the alarm If the alarm sounds the test reset button will silence the alarm unless it is still detecting dangerous levels of CO The green light will then flash every 30 seconds to indicate that the alarm has power Replacement of batteries Under normal operating conditions the batteries will last a minimum of one year These batteries can be purchased from your local retailer HOW TO USE YOUR CARAVAN S EQUIPMENT E End of life This alarm will chirp every 30 seconds with a red LED flash after at least 10 years operation to let you know it has reached its end of life A replacement needs to be purchased Carbon Monoxide Alarm Procedure What to do if your alarm sounds If alarm sounds 4 loud audible
75. e index Do not charge your leisure battery with any charger other than that supplied Failure to comply may cause damage to your battery If you remove your leisure battery ensure that it is not placed on a cold surface as the battery will deteriorate more rapidly than if stored at a suitable temperature Generators Charger All electrical equipment fitted in your new caravan can be run from either a controlled generator or charger whose output is maintained between 11volts and 14volts At least once every 3 years the caravan electrical installation should be inspected and tested and a report on its condition obtained as prescribed in British Standard BS7671 230v POWER SUPPLY Mains Unit The Mains Unit replaces the conventional fuse box Similar but larger ones are often fitted in new houses The unit normally located in the wardrobe gives overloads and earth leakage protection for the 230V electrical supply in your caravan For normal operation all switches on the unit need to be in the ON position The switches on the left of the unit are known as MCB s miniature circuit breakers These take the place of the conventional fuse but are more convenient In the event of a fault the MCB trips i e automatically moves to the OFF position After elimination of the fault the MCB can be re set by switching to the ON position against the spring pressure in an upwards direction If an earth fault develops or a pe
76. e jacks to avoid sliding Manual operation is mainly recommended for uneven surfaces In manual operation all four jacks should always be extended before levelling starts The system cannot handle all angles the limit values differ per caravan If the system makes a slope angle that is too big and no longer responds to requests for automatic levelling we recommend bringing the vehicle as close as possible to the zero point in manual mode ARRIVING ON SITE E e e Troubleshooting In case of an error message check the caravan stands are not too high at the front front wheel must be withdrawn whether the battery has sufficient voltage whether the oil level is correct whether there is any damage to the jacks and check all the cables If this does not lead to a solution for the fault the fault could be located in the drive units As the drive unit does not have any repairable parts you should contact your ESP Hydraulics dealer installer Under normal circumstances all LED s are off and the unit will only respond by pressing the button ON OFF no 5 switching the levelsystem on Problem Possible Causes Solution s The system fails to start Battery voltage low Recharge the battery Charger is defective or there is no voltage being supplied The red battery lamp lights up When the red battery lamp lights continuously the installation is switched off for 4 minutes The support jacks do not
77. e removed To replace the spare wheel simply reverse the operation making sure that the quick release mechanism has been fully pushed down to create a positive lock The carrier is of extra strong lightweight construction and zinc plated for all weather protection It is easy to fit and accepts all conventional wheel sizes S o Zo CD TYRES Please refer to your Technical Data sheet provided with your customer information pack for information regarding tyre pressures and axle loads Pressures It is customary for manufacturers to mark tyres with load and inflation data This information relates to the use of the tyre on cars It is dangerous to drive with under inflated tyres The pressures cold recommended by the manufacturers should be regarded as a minimum Pressure checks including those on the spare tyre should be made with the tyres cold and using an accurate pressure gauge The checks should be carried out before each journey and at regular intervals during storage 10 4 Tyre Wear and Damage The legal requirements for tread depth on motor vehicle tyres apply also to caravans Similarly it is not permitted to mix cross ply and radial tyres on the same axle A redundant tyre must be replaced by one of the same size and construction Wheels should be changed round occasionally to equal wear and prolong the life of the tyres A tyre should be renewed if a blister rupture or cut ex
78. e should always be kept open and unobstructed especially by snow Do not make any additional openings in the floor Outlet sockets located within the caravan should only be used with a dedicated appliance and not an independent unit No appliance shall be used outside when connected to an internal outlet Maintain adequate spacing of combustible materials from sources of heat Do not use additional independent gas appliances inside the caravan B GETTING STARTED GAS SUPPLY Your caravan is designed to operate using either propane or butane liquefied petroleum gas at 30M bar Gas can be obtained from your caravan dealer Your caravan is designed to accept a maximum 2 x 6kg BP Light gas bottles Connection Make sure that heating and cooking appliances and gas cylinders are switched off Each gas appliance is connected to its own gas isolation tap under the cooker These are identified on the tap via a label Below is a key to identify each label To operate the tap the arrow on the tap shows the direction of flow for the gas The arrow should be pointing towards the appliance for the appliance to operate There will be a small label next to the bank of taps under the cooker which is also reproduced below E Een cm Water Heater p Cooking Appliance O Space Heater Hob G Refrigerator Gas On Off X Changing a Gas Cylinder Before commencing to change a gas cylinder ensu
79. e with the manufacturers and NCC recommendations 17th SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations 19th SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations 18 4 14th SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations 16th SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations 18th SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations 20th SERVICE DATE RETAILERS STAMP I We certify that an annual service has been carried out in accordance with the manufacturers and NCC recommendations CHANGE OF OWNERSHIP l NOTIFICATION OF CHANGE OF OWNERSHIP If you purchase this vehicle as a used vehicle it may be possible to transfer the unexpired term of the warranty cover up to a maximum of six years commencing at the original date of purchase from new Please refer to the warranty section of the handbook for terms and conditions Please complete the attached form and post it to
80. ed and ineffective Please Note If having followed this advice you feel you cannot achieve a satisfactory cable arrangement consult your caravan or tow bar supplier or service agent B TOWING AND DRIVING sl TOWING AND DRIVING REVERSING It is advisable to have a second person assisting when reversing the caravan Start practising by choosing a left hand bend for ease Reverse slowly turning the wheel initially the opposite way to the direction you want the caravan to go Now the front of the caravan is nudged out and is moving the rear in the intended direction Take care not to hit the caravan with the car Midways through the manoeuvre when the caravan is correctly angled reduce speed to a crawl and gradually apply opposite lock Make the car follow the caravan round then finally straighten up Please note Proficiency at reversing can only be achieved with practice MZ Fig 4 1 SPEED LIMITS Always adhere to the speed limits in force When national speed limits apply when towing on a single carriageway the speed limit is reduced to 50mph Dual carriageway and motorways the speed limit is reduced to 60mph SETTING OFF i ii iii Pull away smoothly in the towing vehicle Allow more engine speed to produce the power to move the additional weight of the caravan Avoid wear and tear on the clutch and transmission by taking extra care not to rid
81. ed on the back of the socket is designed to be service free and does not contain serviceable parts Please note that the unit is enclosed to protect the electronics opening the unit will result in damage and will invalidate warranty A planned maintenance schedule of regular inspection is recommended for the Watermaster pump kit and socket replacing components as necessary Replacement components are available in service kits from dealers For information on replacement parts and service kits please visit www whalepumps com al Helpful Hints Note If at any stage the user experiences less than optimum performance from the Whale Watermaster IC recalibrate the system as per steps outlined above To obtain efficient running and maximum pump life ensure the following There is sufficient water in the container Maximum pumping period is not more than 15 minutes e All hose connections are firm and water tight e When replenishing the water supply it is possible to create an air lock in the pump As a result the pump will run noisily and give no discharge To remedy unplug from the socket while keeping the pump submerged to dislodge the air pocket in the pump Also shaking the dual hose gently may dislodge the air pocket in the pump or switch off pump at main panel open a tap outlet and switch pump on again at the main panel GETTING STARTED E S e Troubleshooting a Ifthe pump will not run e Che
82. elease Vent open while holding the float of the Automatic Pressure Release Vent on the inside of the tank with the other hand Push the float upwards turn it 180 degrees and remove it from below Remove the rubber seal underneath the float Rinse the float and rubber seal under a tap Replace the rubber seal and float for the Automatic Pressure Release Vent using the same method in reverse The rubber seals in the toilet the lip seal the mechanism seal the automatic pressure release vent seal and the cap seal should be regularly cleaned with water and treated with Thetford High Grade Seal Lubricant This will ensure that the seals remain flexible and in good condition If the toilet is not to be used for any length of time it is important to treat the seals with Thetford High Grade Seal Lubricant after cleaning CAUTION Never use Vaseline or any vegetable oil except olive oil These may cause leakage or malfunction The lip seal is a part of the toilet that is subject to wear Depending upon the extent and manner of use the seals will become less effective and will need replacing periodically Cleaning and Maintenance for Optional Features Automatic Ventilation The filter of the Automatic Ventilation needs to be renewed periodically After approximately 4 full weeks of use the filter loses its absorption power Pump Out Waste System To ensure optimal functionality of the Pump Out Waste System periodical maintenan
83. elling system and may not be used for other work under the caravan such as changing the tyres When the system is operating all persons and animals should keep their distance Body parts e g hands and eyes should never come into contact with released fluids Oil leaving the hydraulic levelling system may be under high pressure and could cause serious injuries to the skin Consult a doctor immediately in case of accidents e The caravan should be parked on a solid level and non slippery surface The parking location must be free of holes of waste and surrounding objects e Ifthe caravan is parked on very soft soil you must place a support plate under each jack in order to distribute the weight e Check if the installation of the hydraulic levelsystem is performed by a skilled mechanic with sufficient practical experience and technical E amp P hydraulics training SJ C ARRIVING ON SITE E e e e In case of repairs malfunctions to the hydraulic levelsystem know what you are doing Never try to repair it yourself but consult your installer or dealer e Fully read this user manual before using the hydraulic levelling system After deploying the hydraulic levelsystem ALWAYS make an inspection tour around the caravan Just to be sure the caravan stands stable all hydraulic jacks are on the ground Control functions Functi
84. er Supply Charger will charge the leisure battery and the 12V systems When connected to the car always disconnect 230V supply the system automatically switches to the car supply When the towing vehicle s engine is running and the caravan s 13 pin plug is connected the internal 12 volt power supply in the caravan is turned off and all internal lights will go out The only 12 volt power left operational within the caravan is the fridge and the battery charger GENERATOR CHARGER When connecting to a generator always switch off the RCD residual current device start the generator and allow running for a few minutes to stabilise When this has happened switch the RCD to the ON position ELECTRICITY MAINS SUPPLY Your caravan s main electrical installation is designed to run on 230V at 50 hertz AC supply CONNECTING TO MAINS SUPPLY ON ARRIVAL AT SITE Before connecting the caravan installation to the mains supply check that i The mains supply is suitable for your installation and appliances e whether itis AC or DC and whether it is at the correct voltage and frequency Your caravan is properly earthed Never accept a supply from a socket outlet or plug having only two pins or from a lighting outlet Any residual current device earth leakage circuit breaker in the mains supply to the caravan has been tested within the last month In case of doubt consult the site owner or their agent Make sure that the
85. fixed in the caravan s wardrobe advising on fire prevention ventilation and what to do in case offire GENERAL SAFETY T VENTILATION All caravans manufactured by Buccaneer are ventilated at both high and low level in accordance with BSEN 721 Safety Ventilation High Level Ventilation This is always provided by fixed ventilation within the fitted roof skylight All roof skylights fitted by Buccaneer provide fixed free area ventilation These roof skylights should be cleaned annually by use of a small brush to remove any dust that may have accumulated around the mesh fitted On some roof skylights the mesh can be easily removed to aid cleaning On fan assisted roof skylights it is essential that the fan is switched off prior to cleaning Low Level Ventilation Low level ventilation is provided under the front chest of drawers The exact position can be identified via a cover used to prevent the ventilation from being obstructed In order to clean the ventilator remove the cover by undoing the two screws and clean using a small brush It is essential that the cover is replaced once cleaning is complete Ventilation in Separate Bedrooms In caravans with separated sleeping areas separate ventilation is required and is provided via a roof skylight at high level and a ventilator at low level within a bed box or under the fixed bed Gas Dispersal Holes All appliances and gas taps have a gas dispersal hole nearby
86. g 3 4 Step 1 STEP 1 Fig 3 4 or PREPARING FOR THE ROAD E e e ii Attach the clip directly to the attachment When The Breakaway Cable Is point Fig 3 5 Step 2 Attached Check To Ensure STEP 2 i That the cable cannot snag in use on the caravan hitch jockey wheel or any u accessories e g a stabiliser bumper shield cycle carrier etc ii That there must be sufficient slack in the cable to allow the towing vehicle and caravan to fully articulate without the cable ever becoming taut and applying the brakes ii That it is not so slack that it can drag on Fig 3 5 the ground Leave it too loose and the cable may scrape along the ground and be weakened so that it fails before doing Note this must be specifically permitted by the caravan manufacturer s guidance as the its job clip may not be sufficiently strong BEFORE SETTING OFF Where No Designated Attachment i Connect the 13 pin plug on the caravan Point Is Provided On The Tow Bar A frame to the towing vehicle i Fixed Ball Loop the cable around the UU Check that all tail lights brake lights neck of the tow ball If you fit the cable road lights and indicators work correctly like this use a single loop only Fig 3 6 iii Ensure that the correct vehicle license Step 3 registration plate is attached to the rear STEP 3 of the touring caravan iv Using the jockey wheel lift the tow ball slightly to check hitch is lo
87. g the handle towards you with moderate force is sufficient to open the locker door and hold it in the open position 8 30 HOW TO USE YOUR CARAVAN S EQUIPMENT ees SLIDING DOORS The room divider should be held in place during transit by the use of the strap with the stud fastening When stationary the room divider can be held shut by contact between a metal plate and magnet Ss HIGH LEVEL LOCKER Ba To open the locker push the handle downwards 8 31 HOW TO USE YOUR CARAVAN S EQUIPMENT BED MAKE UP FRONT WRAP ROUND SEATING Option If you have purchased the wrap round seating option for your new caravan please note that the centre seat can be extended by the use of the locking mechanism which can be found under this seat Parallel Lounge Pull the slats forward then turn the locking plate to be in the direction down the caravan see fig 1 in order to secure the front seat in place ADS NM f E SE EE Fig 1 This will prevent the slats from going back into the front seat and increase the seated area Please ensure you return the locking plate to its normal position see fig 2 if you wish to remove the wrap round seating Fig 2 The two single beds can be easily converted Maximum load for the beds into
88. gerator door open to allow air to enter and to prevent formation of mildew After defrosting freezer compartment and fins free of frost wipe both cooling compartments dry with a cloth Note Water thawing in the main compartment of the refrigerator runs into an appropriate container at the back of the refrigerator From there the water evaporates WARNING The layer of ice must never be removed forcibly nor may defrosting be accelerated using a heat source Switching off refrigerator e Press the MODE button to switch off Keep button A pressed for two seconds The display disappears and the appliance is fully switched off e Release the locking mechanism of the door lock by pushing it and shift it to the front If the door is shut in this position a small gap is nevertheless kept open to prevent formation of mildew e Ifthe refrigerator is to be taken out oA off O Mode Fig 10 of service for an extended period of time close the onboard shut off valve and the cylinder valve Lighting The interior lighting is controlled using a door contact Should the door be kept open more than 2 minutes an acoustic signal is initiated pulsing whistle tone Fig 11 Please contact the authorized Dometic Service if a failure occurs HOW TO USE YOUR CARAVAN S EQUIPMENT Winter operation 1 Check that the ventila
89. guide must always be in place during cooking e Close the door Make sure that it is firmly closed The oven door can be opened at any time during operation by pushing the door open button The oven will automatically shut off To restart the oven close the door and then push the START button The oven automatically cooks on full power unless set to a lower power level e The display will show 0 when the oven is plugged in press and hold Eco button until display is turned on and beep sounds e Display will be returned to the 0 when the cooking time ends e When the STOP CLEAR button is pushed during the oven operation the oven stops cooking and all information retained To erase all information push the STOP CLEAR button once more If the oven door is opened during the oven operation all information is retained e Ifthe START button is pushed and the oven does not operate check the area between the door and door seal for obstructions and make sure the door is closed securely The oven will not start cooking until the door is completely closed or the program has been reset e Display turns off after 10 minutes Make sure the oven is properly installed and plugged into the electrical outlet Wattage Output Chart The power level is set by pushing the Power button The chart shows the display the power level and the percentage of power Push the Power
90. he corner stabilising leg is being raised or lowered and transmits a coded radio signal to the alarm Additional sensors can be purchased from your retailer to enhance security See section below for operation or consult the manufacturers instructions provided in the Owners Information Pack Basic Operation Arming the System i Briefly press large arm disarm button ii Single chirp iii Awning light illuminates for 30 seconds iv Settling time of 15 seconds before responding to triggers v Single intermittent flash of status LED every 2 seconds vi All sensors triggered will result in siren sounding for 30 seconds or until reset by pressing the arm disarm button Disarming the System i Briefly press the large arm disarm button ii Double chirp iii Awning light illuminates briefly on and off and then on again for 30 seconds iv LED off Panic Alarm i Press and hold the small panic button on the transmitter for two seconds ii The siren will sound for thirty seconds unless reset by pressing any of the transmitter buttons Emergency Disarm Insert the touch key briefly into the socket The alarm will turn off Silent Arm and Disarm i Press the small button briefly followed by a press on the arm disarm button ii The alarm will arm disarm without chirps Sensors Each caravan alarm is installed with a Passive Infrared Detector PIR and a leg sensor Additional senso
91. he efficiency of the refrigerator Ensure that air circulation of the cooling unit is not obstructed Keep the ventilation grills free from obstructions Storing food in the freezer compartment Donot keep carbonated drinks in the freezer The freezer compartment is suitable for making ice cubes and for short term storage of frozen foods It is not suitable as a means of freezing foods WARNING When ambient temperatures are lower than 10 C and the refrigerator is exposed to these temperatures for extended periods of time an even regulation of freezer temperature cannot be guaranteed for system related reasons This can cause the temperature in the freezer to rise and the stored goods to defrost a HOW TO USE YOUR CARAVAN S EQUIPMENT soa 1 Fill the ice cubes with drinking water Ww J 2 Place the ice cube tray in the freezer compartment Fig 9 Ice cubes are best frozen overnight At night the refrigerator has less work to do and the unit has more reserves WARNING Only use drinking water Defrosting As time goes by frost builds up on the fins inside the refrigerator A layer of frost thicker on one side may occur and does not represent a malfunction When this layer of frost is about 3mm thick the refrigerator should be defrosted Switch off the refrigerator as described further on Remove all food and the icecube tray e Leave the refri
92. he receiver is located between the wheel spokes Fig 1 3 Push the Diamond Standard Wheel Lock between the rim spaces so that the bolt fits into the receiver Fig 2 4 Push the Diamond Standard Wheel Lock up to the point where the base plate contacts the rim Fig 3 5 Lock the Diamond Standard Wheel Lock with the attached key Fig 4 Hints for using the Diamond Standard Wheel Lock To keep the hole of the receiver clean please use the supplied plug when the Diamond Standard Wheel Lock is not mounted Key Card The number of the lock is only recorded on the key card Without this card you will be unable to order any replacement keys Please keep your key card in a safe place and at all times separate from the wheel lock A jack is required to fit the second wheel lock and this is provided with your new caravan and should only be used for this purpose N EIS A p 4 TA SECURITY CRIS THE CARAVAN REGISTRATION AND IDENTIFICATION SCHEME CriS is the Central Registration amp Identification Scheme that issues touring caravan registration documents equivalent to that of the V5 registration document issued by the DVLA for cars CRIS was established in 1992 by The NCC and provides a method of registering the keeper details of every tourer manufactured by NCC member companies to help prevent and detect caravan related crime Why register with CRiS e Safet
93. help to ensure that you can enjoy it to the full The Annual Service offered by your retailer will include the following work and it is our recommendation you have your caravan serviced to this standard annually in accordance with the NCC recommendations The retailer will complete the record in this guide to show the work has been carried out SECTION A CHASSIS Brakes Suspension Axles and Hubs Tyres and pressures Wheeled nuts Towing hitch and reverse Jockey wheel Breakaway chain Corner steadies 0 Adjusted and lubricated 1 Fully operational a Oo ONO oy BWIN gt SECTION B EXTERIOR Exterior panels Windows Rooflights Entrance door Door locks Wheel boxes Mouldings Gas bottle and fairing Ventilators Paintwork 10 All seals mouldings etc 11 Damp test 12 Striping etc SECTION C INTERIOR 1 Wall panels O NEO Gi ne o N 2 Furniture 3 Curtains Blinds Flyscreens 4 Mattresses 18 1 5 Carpet 6 Doors and drawers 7 All hinges and catches 8 Ventilators 9 Water pumps 10 Hoses and sink plugs 11 Hot water system 12 Cold water system 13 Window hinges and stays 14 Cassette toilet 15 Shower 16 Shower tray 17 Central heating 18 Damp test SECTION D ELECTRICAL 1 Reflectors 2 All interior lights Road lights 3 Water pump and switches 4 Refrigerator 5 Distribution unit 6 Charging unit 7 Junction box Strip 8 Wiring and supports 9 Trailer
94. hind a normal motor car Additional care should be exercised when towing with a 4x4 because of the off road nature of the suspension Owners should not tow their touring caravans with commercial vehicles When selecting a towing vehicle it is recommended that you consult the Caravan Towing Code which is available from the NCC By following the instructions provided in this handbook and maintaining your caravan in a first class roadworthy condition you are sure to have many years of carefree use To ensure the very best quality and reliability all touring caravan designs and new developments are rigorously tested Therefore Buccaneer will accept no liability or uphold the warranty if the caravan is altered or modified in such a way that would adversely affect the reliability 1 1 Please note It is a condition of your warranty that the caravan must have an annual service carried out by a Buccaneer approved Retailer Service Centre or NCC Approved workshop and a record is kept Pages are provided in the back of this guide for your assistance A Buccaneer Approved Retailer Service Centre will be able to supply any replacement parts for your caravan should the need arise and in most cases any accessories you may require Please note It is not possible to purchase replacement parts direct from Buccaneer Changing market and supply situations may prevent us from maintaining the exact specification details in
95. hotplate burners gas and electric if the lid is closed Ensure the glass lid is open before turning on the hotplate burners Remove all spillage from the surface of the glass lid before opening The glass lid has the tendency to snap shut towards the end of lowering This is caused by the travel lock action of the hinges as it is activated Make sure all fingers are clear of the appliance when closing the lid Using the Grill 1 Ensure the gas cylinder is connected and turned on 2 Open door push in the control knob and turn anti clockwise to large flame symbol 3 Continue depressing the knob whilst holding a lighted match to the burner For models fitted with spark ignition the procedure is similar except that burner is ignited by depressing the ignition button located on the fascia 4 After the burner is lit continue depressing the knob for approximately 10 15 seconds before releasing the knob 5 If burner has not lit within 15 seconds release knob and wait at least 1 minute before repeating operations 2 to 4 6 To turn off rotate the control knob until the line on the knob is aligned with dot on the control panel 7 Always make sure the control knob is in the off position when you have finished grilling 8 Ignition must always be carried out with the grill door open 9 Accessible parts may be hot when the grill is in use Young children should be kept away On first use of the grill it shoul
96. ible laden mass PMTPLM As specified by Buccaneer and in compliance with the European Directive on Masses and dimensions of vehicles Actual MTPLM Maximum mass of the vehicle which takes into account operating conditions including factors such as the strength of materials loading capacity of the tyres etc Mass of the caravan in running order MIRO This is the weight of your caravan as it leaves our factory plus the following 18kgs to allow for the carrying of 2 x 6kgs BP gas light bottles Personal effects payload PEP This is calculated by the following formula 10L 10N 50 L is the body length of the caravan in meters N is the number of berths 50 is for normal equipment carried in the caravan a sample list is given below A eg 0 5kgs Bed linen A A ts Saucepans cccoccccccoccnccnnnccnonnnnns Wastemaster ei Aquaroll empty 5kgs Waste bin 1kg Toilet fluid etc 2 5kgs Battery eesriie 25kgs Optional equipment payload OEP This is an amount of weight provided by us for factory fitted options Please note Any options fitted by the retailer will reduce the overall payload available to the customer User Payload is the sum of the PEP and OEP Note It is possible to upgrade your Plated MTPLM to the Actual MTPLM up to the caravan being 3 years old there is an administration fee for this service Note Please ensure you never load yo
97. ibration procedure described below has already been carried out at your dealer installer You don t have to perform this procedure by yourself E amp P Hydraulics has decided to include this chapter as an extra in this manual in case of failure and or service amp repair matters Consider setting the zero point as a condition to make it possible to level the caravan automatically and or manually When this operation for some reason has not been done or has been carried out incorrectly it is not possible to level the caravan The zero point is the point level at which the hydraulic levelling system in an automatic cycle returns Start Manual levelling Before automatic levelling can be activated you must set the zero point For setting the zero point you must FIRST perform the manual levelling procedure REMARK Do this by placing a spirit level in the centre of the caravan ATTENTION Never put the rear brackets first to the ground This in case creating too much load on the caravan ARRIVING ON SITE E e e Setting the zero point Step 1 Press 1x on the button ON OFF no 5 to switch OFF the levelsystem after manual levelling Step 2 Press 1x on the button ON OFF no 5 to switch the levelsystem ON Step 3 Press 5x on the button FRONT SIDE no 12 Step 4 Press 5x on the button REAR SIDE no 11 All LED s on the control panel light up the vehicle stands in zero mode Step 5 Press 3x on the
98. in and type of caravan the automatic levelling procedure takes about 1 minute Step 3 Press 1x on the button ON OFF no 5 to switch the levelsystem OFF 5 6 ARRIVING ON SITE E e e Manual levelling In below the procedure for manual deployment extension of the axle and corner supports The manual levelling function is mainly used when automatic levelling is not possible due to a large tilt ofthe caravan With the help of this feature it is also possible to change the position of the caravan think of your sleeping comfort Most people prefer to sleep with their head up slightly Depending on the orientation of the caravan with this feature you can manually adjust the angle where necessary 1 2 3 MON ON OFF AX N N po OJ no 5 AUTOMATIC LEVELING SYSTEM Ep G MANUAL MODE da no 6 READ MANUAL FIRST LEES EERST DE GEBRUIKSAANWIJZING ZUERST HANDBUCH LESEN LISEZ TOUTES LES INSTRUCTIONS 0 Step1 Press 1x on the button ON OFF no 5 to switch the levelsystem ON Ep The E amp P logo LED lights up indicating that the levelsystem is switched on When there is insufficient or no battery voltage the indicator LED LOW VOLTAGE no 2 lights up In manual levelling the caravan must be tilted a few degrees forwards The Fi system will indicate whether you have positioned the caravan level enough Ifyou have not the indicator LED FRONT WHEEL no 3 lights up Step 2 Press 1x on the button
99. inings can be checked The wear indicator as shown in Fig 3 2 is within the top of the operating handle The bar graph is marked with and symbols with indicating good condition of the pads and indicating that the pads should be checked PREPARING FOR THE ROAD sal Disengaging the stabiliser Lift up the operating handle with care to release the sprung loaded stabiliser function PTS CLOSED 7 _STABILISER GA TURNED OFF MX CLOSED STABILISER TURNED ON Fig 3 3 Uncoupling Before uncoupling disconnect the electrical connections and breakaway cable Also check that it is safe to uncouple your caravan taking into account any gradients With the stabiliser function disengaged simultaneously pull back and lift the operating handle this swings the securing lugs out of the locked position allowing the operating handle to be lifted into the fully open position Before operating the jockey wheel which will lift the caravan free of the tow ball check that both caravan and towing vehicle handbrakes are applied Ifthe caravan is not to be used for any lengthy period of time we recommend the ball coupling is kept in the closed position This can be done easily by pressing the safety ball into the ball space and slowly closing the operating lever USE OF YOUR CARAVANS BREAKAWAY CABLE UK LAW requires that all caravans with brakes e g caravans horse boxes car t
100. irm footing otherwise the axle supports may sink into the ground Note It is important that when you use the system the caravan is standing facing slightly downhill B Never use the system when there is anything attached to the caravan such as an awning or a canopy Never use the levelsystem in automatic mode when the caravan is attached to the vehicle The following safety precautions must be observed when positioning the caravan Apply the caravan handbrake securely Make sure that when the system is being operated no one is present in the vicinity of the caravan Do not use any additional supports underneath the axle and corner supports e Place no blocks during either manual or automatic levelling Make sure that when levelling is being carried out on one is in the caravan e An acoustic signal will be sounded during the levelling process e The levelling program can be stopped at any time by pressing the ON OFF button on the control panel or optional remote control WARNING Before driving off check to make sure that all supports have been withdrawn Safety warnings Not observing the following warnings may lead to damages to the caravan and or serious physical injuries e Using the E amp P hydraulics levelling system for other purposes than supporting the caravan is officially forbidden according the E amp P Hydraulics Limited warranty e This product is exclusively developed as a lev
101. is no danger of pollution of an enclosed awning space from the LPG exhaust from a refrigerator venting into it Space heaters may produce sufficient exhaust to pollute the awning space if it is totally enclosed from a general comfort smell and hygiene point of view In extreme cases there could be a build up of carbon dioxide to a dangerous level Caravan owners are advised to allow some fresh air circulation in the awning space when such appliances are in use Please note Ventilation holes must be clear at all times LPG GAS SYSTEM Buccaneer do not recommend the use of any external cylinders All cylinders in use should be within the gas locker provided If you wish to utilise a larger cylinder and have this outside the gas locker then the connecting hose must not exceed 750mm It is recommended that no flammable material is stored or placed within 300mm of any open flame You are advised not to use any additional gas appliances outside your caravan Please ensure that you have read the operating instructions for each gas appliance contained in your Owners Information Pack Please ensure that any gas hose left unconnected is protected from dirt or other foreign bodies entering the hose WARNINGS e Fresh air circulation should be allowed below the caravan when appliances are in use and when flues terminate below the floor to allow free evacuation of the products of combustion At least three sides of the underfloor spac
102. l indicate the cylinder in lt lt service gt gt use Operation of the lt lt reserve gt gt Figure 2 e The indicator is red which means that the cylinder in lt lt service gt gt has run out lt is now empty and the installation is operating on the lt lt reserve gt gt cylinder Fig 1 Fig 2 Fig 3 INDICATOR INDICATOR INDICATOR SERVICE RESERVE SERVICE RESERVE REPLACEMENT SERVICE CYLINDER CYLINDER CYLINDER CYLINDER CYLINDER CYLINDER B GETTING STARTED WATER SYSTEM High Flow Watermaster Pump with Intelligent Control IC The Watermaster IC unit is a means of control for the Whale Watermaster high flow system which allows it to operate without the need for pressure switch adjustment It offers three key features eliminates rapid water pulsation ensures that the pump turns off at low battery voltages and in a run dry situation when the water supply runs out Installation Please note The manufacturer cannot be held responsible for claims arising from incorrect installation unauthorised modification or misuse of this product Before installing please check that the submersible pump can reach the bottom of the water container and that there is access to the back of the socket To connect the IC Control Unit back of socket Step 1 Switch off the 12V d c supply at the main panel isolator switch Step 2 Unplug the spade connections on the water inlet socket ensuring that you note the
103. lable from E amp P Hydraulics Battery Indicator When the battery level indicator LED no 15 lights RED the device does not stop working immediately After this signal it is possible to use the remove control approx another 4 times Make sure there is a spare battery in the caravan Emergency pump Introduction The optional Emergency Hand pump allows the levelsystem to be operated manually in the emergency event the system is defective or more likely because there is not enough battery voltage present This possibility is offered by E amp P Hydraulic for situations where for whatever reason the levelsystem does not withdraw its support jacks and is therefore preventing you from driving or moving the caravan We call it an emergency situation because in practice the time of withdrawing the hydraulic jack is most often also the time of a planned departure By not automatically withdrawing the support jacks you can no longer move with adverse consequences Therefore E amp P Hydraulics offers you the possibility to integrate an emergency hand pump for the levelsystem As the name implies it is a pump operated by hand that controls the withdrawal of all jacks This means that the time of your departure transport or movement can be guaranteed The emergency hand pump is mounted under the caravan in such a way that it is accessible from the side P Protective pump housing with the connections t
104. laced in relation to each other Leisure Battery This supplies the power for the caravan electrical systems and is sometimes called an auxiliary battery Levelling The process of ensuring that a caravan is level when sited on a pitch It is important for comfort and also to ensure the correct functioning of the fridge and water systems LPG Liquid Petroleum Gas i e butane or propane L Shaped This is a term where the seating area of a caravan is indeed L shaped Mains Hook Up This is a campsite facility where you can plug into a mains electricity supply Maximum Hitch Height The maximum height at which the hitch should be connected to a towing vehicle Maximum Permissible Towing Weight This is the maximum weight that the towing vehicle is allowed to tow Maximum User Payload This is the maximum payload available for the user MIRO Mass In Running Order Weight of the caravan equipped to the manufacturer s standard specification including essential habitational equipment MTPLM Maximum Technically Permissible Laden Mass The technical maximum permissible laden weight of the caravan this must not be exceeded NCC National Caravan Council The only trade association representing manufacturers retailers and suppliers within the caravan industry Nose weight The weight exerted on the tow bar Special scales are available from accessory shops for measuring this weight Number Plate Carava
105. n Pack BPW CHASSIS BPW are one of the largest producers of caravan chassis in Europe The chassis is galvanised special steel fitted with neidhart axles and suspension system Buccaneer utilises the new BPW V TEC Chassis System Please note Holes must not be drilled into the chassis When purchasing a stabiliser consult your retailer who will advise on the correct type to fit BRAKING SYSTEM The Braking System comprises a rod operated overrunning device with expander mechanism and adjuster box An automatic reversing system with a spring loaded reverse lever is attached to the adjuster box The system also incorporates a link device which gives added safety to the handbrake operation when parking on a reverse slope or steep hill Brake adjustment instructions are given in the maintenance section of this guide SOLID CONSTRUCTION BODY SHELL Buccaneer Caravan Bodies are constructed from the highest quality materials The fully insulated floor is a constructed timber frame with plywood internal floor and a GRP underskin for added water resistance and insulation laminated together for strength The walls comprise an insulated foam sandwich having one piece GRP sides for ultimate resistance to minor damage and vinyl coated plywood internal finish Wooded framing is positioned within the sandwich to add strength The latest technology is used to produce the extremely well insulated and robust yet lightweight sections 1
106. n and check all the ventilators annually for blockages and where necessary rectify any blockages found ii Inspect the high pressure flexible gas hose available from your retailer regularly for deterioration and renew as necessary with an approved type in any case no later than the expiry date stated on the hose iii Ensure the gas supply and all appliances are turned off before towing your caravan iv If your caravan has been fitted with a gas BBQ it must be only used for its intended purpose Do not use a gas barbeque within an awning v Never use portable cooking or heating equipment inside your caravan Do not use your fitted cooking equipment as heating at any time vi Never allow modification to your gas or electrical system unless qualified persons carry them out All modification to the gas system must be carried out by a Gas Safe Register approved gas fitter Any modifications carried out on the electrical system must be carried out by an electrician on the roll of the NICEIC or be a member of the ECA vii If you suspect there is a gas leak please open all the windows then vacate the caravan Then contact your nearest Buccaneer Retailer to arrange for them to check the gas system viii In the interest of safety replacement parts for an appliance should conform to the appliance manufacturer s specifications and should be fitted by them or an authorised agent ix x xi xii
107. n attempt the automatic igniter repeats the ignition twice duration 30s at time intervals of 2 minutes If the flame is not lit afterwards a fault is indicated HOW TO USE YOUR CARAVAN S EQUIPMENT E Setting of cooling compartment temperature amp ooon0lAl N e Fig 4 Select the desired cooling compartment temperature by pressing button 6 The LED display 7 of the selected temperature setting is illuminated The scale starts with MIN position at the left LED position small bar highest temperature and climbs up to MAX position at the right LED position large bar lowest temperature Note The temperature levels do not relate to absolute temperature values Door locking CAUTION As a basic rule shut and lock the refrigerator before you start your journey a ys Fig 5 Open the door by pressing the locking button and pull open Fig 6 Shut the door again by pushing it to close The snapping into the lock can be heard While the vehicle is parked the locking hook may be fixed to facilitate opening of the door Fastening and releasing the door lock when parking the vehicle Ifthe vehicle is parked for a longer period of time the locking hook may be clamped by means of a lockbar The door may now be opened by just pulling it without need of pressing the locking button lt _ Fig 6 E HOW TO USE YOUR CARAVAN
108. n off need to charge battery Winterising Watermaster IC does not require any additional winterising For details of how to drain your water system for winterising please see www whalepumps com rv ELECTRICAL SYSTEM k ELECTRICAL SYSTEM 12v POWER SUPPLY Battery Installation Your caravan will be fitted with a BCA Leisure charging and power distribution unit If you wish to install a leisure battery please ensure that it is placed on the battery tray supplied with your caravan Then place the tray in the battery locker fitted to the side of your caravan Connect the battery to the clamp fittings connected to the connection leads within the battery box The type of leisure battery you should utilise will depend on how you wish to use your new caravan If you are going to only use your caravan when it is connected to a mains supply and do not have a motor mover fitted then any good standard leisure battery rated at least 85 ampere hours at 20 hour discharge rate is sufficient However if you are going to use your caravan without a mains connection or have a motor mover fitted then an AGM type battery rated at least 85 ampere hours at 20 hour discharge rate is recommended Battery Maintenance Your leisure battery should be maintained in accordance with the manufacturer s instructions For information on the automatic charging system in your caravan please refer to Automatic Charging System in th
109. n the control knob and turn anti clockwise to full rate large flame see Fig 1 3 Continue depressing the knob whilst holding a lighted match or taper to the burner For models fitted with spark ignition the procedure is similar except that the burner is ignited by depressing the ignition button located on the facia 4 After the burner is lit continue depressing the knob for approximately 10 15 seconds 5 Release knob and turn to required heat setting 6 If burner has not lit within 15 seconds release knob and wait at least 1 minute before repeating operations 2 to 5 7 To turn off rotate the control knob until the line on the knob is aligned with dot on the control panel Always make sure the control knob is in the off position when you have finished using the hotplate burners Each burner will support pans from 10 to 22cm Care should be taken not to overload the appliance as performance may be reduced The following are the maximum pan sizes that we recommend Electric Hotplate 8180mm Auxiliary Burner 200mm Semi Rapid 2 x O200mm or 1 x Burners 220mm with 1 x 180mm When using small pans the flames should not spread beyond the base of the pan as this will reduce the efficiency of the burner Avoid using old or misshapen pans as these may be unstable and may also affect efficiency The glass lid must be fully opened before using the hotplate burners HOW TO USE YOUR CARAVAN S EQUIPMENT E
110. nal remote control In most frequent cases the control panel is mounted in the sidewall at the entrance of the caravan The jacks have the bearing and levelling capacity your caravan requires Each axle supports has a 180 mm stainless steel foot plate on a flexible pivot guaranteeing the greatest firmness possible on any surface Using the hydraulic levelsystem The levelling system is only to be used for creating a stable and horizontal position for the caravan With the electronic spirit level the caravan is adjusted horizontally over its complete width with the aid of the two axle supports and the suspension lifted for corresponding stability Then the caravan is adjusted horizontally in the longitudinal direction with the aid of the four corner supports The whole caravan will be stabilised with the help of a pressure button on the control panel or on the optional remote control Specific characteristics of the hydraulic levelsystem e Automatically extending the jacks from a retracted position e Automatically retracting the jacks from an extended position e Automatically or manually levelling the jacks ARRIVING ON SITE sal Operating instructions Before taking into service the following points must be observed e The noseweight A may not exceed the max 150 kg Make sure that the ground is sufficiently even and that there are no holes and other obstructions present e Place the caravan on a f
111. ng area Large quantities of combustible particles are generated from spills or when boiling Using the fan on a range hood which vents to the outside non recirculating type will also help remove these combustible products from the kitchen If the alarm does sound check for fires first If a fire is discovered get out and call the fire department Maintenance Battery Replacement Note Replacement batteries are available where you purchased your alarm The smoke alarm is powered by a 9V battery A fresh battery should last for one year under normal operating conditions This alarm has a low battery monitor circuit which will cause the alarm to chirp approximately every 30 40 seconds for a minimum of seven days when the battery gets low Replace the battery when this condition occurs Note Use only the following 9 volt batteries for smoke alarm battery replacement Alkaline Type Energizer 522 Duracell MN1604 MX 1604 Gold Peak 1604A Note Weekly testing is required WARNING Use only the batteries specified Use of different batteries may have a detrimental effect on the smoke alarm Cleaning your alarm Your alarm should be cleaned at least once a year To clean your alarm remove it from the mounting bracket You can clean the interior of your alarm sensing chamber by using compressed air or a vacuum cleaner hose and blowing or vacuuming through the openings around the perimeter of the alarm The o
112. ns must display a legal number plate showing the same registration mark as their towing vehicle Optional Equipment Payload The payload required for equipment to enable the caravan to be used for habitation purposes Outfit The caravan and its towing vehicle considered as a unit Owners Club This is a group of people who usually own the same brand of caravan and enjoy meeting up for rallies GLOSSARY Payload The amount you can put into a caravan Specifically the difference between the Maximum Technical Permissible Laden Mass MTPLM and the Mass In Running Order MIRO PDI This is an inspection undertaken by the Retailer prior to handover to the customer Pitch A designated area of a caravan site allocated for the use of one outfit Most sites will be arranged with defined pitches Propane Gas used in colder conditions and is usually supplied in red cylinders RCD This is a residual current device and is part of the electrical system which will trip if there is an electrical fault Gas Regulator Safety device fitted between the gas cylinder and the gas system of a caravan which controls the pressure of gas being released from the cylinder Road Lights The external lights used while the vehicle is travelling Roof Lights See Roof Vent Roof Vent Is an opening unit in the ceiling which lets in ventilation and light these vary in size but the best ones will have integral
113. ntion Care must be taken when connecting supplies abroad since the supplies can be of REVERSE POLARITY The significance of REVERSE POLARITY is that when equipment is switched off it may not be electrically isolated The only certain way of making equipment safe is to unplug it A means of checking the polarity of the mains supply when overseas is recommended There are available several proprietary makes of equipment for the purpose If it can be achieved it is preferable to connect live to live and neutral to neutral to maintain full electrical protection CHECK all caravan equipment is set up to accept the site supply before actually switching on GETTING STARTED GAS SAFETY ADVICE Inthe event of a suspected gas leak the gas must be turned off using the isolation valve on the gas bottle A competent gas fitter should then check the system before it is used reused Regularly check flexible gas hose joints and connections for tightness Finally make sure that each gas appliance is working efficiently to the recommendations of the appliance manufacturers See Index Ventilation FACTS ABOUT LPG LPG is not poisonous Bi products are harmless LPG is dangerous if all air and oxygen is excluded LPG has been given a smell by the manufacturers in order to identify leaks e The gas is heavier than air and therefore sinks to the lowest point AWNING SPACES LPG AND APPLIANCE EXHAUST There
114. o an authorised waste disposal point 17 E HOW TO USE YOUR CARAVAN S EQUIPMENT 18 Push the handle back into its locked position Turn the emptying spout upwards and remove the cap from the spout Hold the Waste Holding Tank in such a way that during emptying you can operate the vent plunger with your thumb To empty the tank without splashing depress the vent plunger while emptying the tank After emptying rinse the tank and blade thoroughly with water CAUTION Do not seriously shake the tank or use high pressure water cleaners This may cause damage to the tank s interior Note The vent plunger should only be depressed once the emptying spout is pointing downwards Prepare the toilet for re use if required Slide the Waste Holding Tank into the toilet and close the access door Emptying with Optional Features 19 Waste Holding Tank Multi Level Indicator The lower lamp indicates that the Waste Holding Tank is almost empty the middle lamp indicates that it is more than half full when the upper lamp lights up the tank needs emptying as it can only take 2 3 further uses Note The Waste Holding Tank Level Indicator will flash when the holding tank is not present In this case the toilet will not flush 20 Waste Pump Out System When activating the control panel this feature automatically lights up When the Waste Holding Tank Level Indicator illuminates press the Waste Pump Out button to pump o
115. o enter the caravan in adverse conditions BLINDS amp FLYSCREENS Blinds i Pull blind down by its centre catch Do not pull down by one side of the blind This will inevitably lead to problems ii Do not allow blinds to spring back freely Always control them by hand Flyscreens i To operate the flyscreen either pull the screen fully down fully up or across dependant on type of window fitted and clip into place on the blind frame ii To release unclip from the blind frame If a cross bar is fitted gently pull the crossbar downwards towards you and allow the tension of the spring to roll up the flyscreen ii Where a crossbar is not fitted disconnect from the blind catch and release gently iv It is recommended that blinds are not in the closed position whilst the caravan is moving SHOWER Using your Caravan Shower To safely enjoy showering in your new caravan the following guidelines should be used e Advise others that you are planning to have a shower and that they should not use other taps whilst you are showering Ensure there is a sufficient supply of cold water available e Divert the shower head or move to the side turn on the shower carefully test the temperature with your hand and regulate the temperature as necessary before standing underneath the shower e Supervise closely the young elderly and those with reduced mentally or sensory impairment CAUTION Water may be very hot
116. o the emergency pump Emergency hand pump ARRIVING ON SITE E e e Putting the Emergency pump into use When actually using the emergency hand pump operation proceed as follows Step 1 Using the allen key turn the gold hexagon bolt on the emergency hand pump clockwise to the right open position Step 2 Place the metal tube handle into the black holder on the emergency hand pump assembly Pump back and forth with the metal tube until all hydraulic jacks are withdrawn all jacks will be withdrawn at the same time The moment you feel pressure resistance building up during this movement is the sign the jacks are fully withdrawn Step 3 Remove the metal tube from the holder Step 4 Using the allen key turn the gold hexagon bolt on the emergency hand pump assembly carefully to the left until it locks closed position Attention carefully turn the lock closed position _ Gold coloured hexagon bolt carefully open and close Step 2 and 3 a Place the metal tube into the holder and pump until you start to feel pressure Weil ARRIVING ON SITE sel Schematic diagram of the hydraulic levelsystem Below the schematic view diagram of the E amp P Hydraulics levelsystem gt Hydraulic corner support front side left Hydraulic corner support front side righ y 1 1 1 Control panel panna Hu u Ma IR H 11 Battery not included Rem
117. ondhand caravan and helps in the recovery of stolen caravans Dinette This is a popular style of seating arrangement where two seats or settees face each other across a table Earth Leakage Circuit Breaker ELCB Earth leakage circuit breaker see residual current device RCD End Kitchen A common term used to describe floor plans which put the kitchen across the rear usually adjacent to a caravan door on one side and washroom on the other Essential Habitation Equipment Those items and fluids required for the safe and proper functioning of the equipment for habitation as defined by the manufacturer of the caravan Flyscreens Mesh fittings for windows doors and roof vents to keep out insects etc Free Standing Table This is a table which because of its leg design can be used inside or outside Full Service Pitch This is a pitch which has individual provision for fresh water supply and waste water disposal in addition to mains electricity and in some cases TV aerial connection Gas Cylinder This is a portable pressurised container for the storage of LPG Gas Cylinder Locker Is the compartment on the caravan for the storage of gas cylinders Gas Drop out Holes These are not part of the ventilation LPG is heavier than air so holes through the floor below gas powered appliances allow any leakage of gas to exit the habitation area Grey Water This is the waste water from sink shower Gross Train
118. ons on the control panel The diagram below shows the appearance of the control panel By using the control panel or remote control you can operate the hydraulic levelsystem 16 1 2 3 4 e i 1 N y it a 13 14 12 Function declaration 1 LED Slope too steep 9 LED Manual mode 2 LED Battery low voltage 10 Button Left side 3 LED Withdraw front wheel 11 Button Rear side 4 LED Jacks not fully retracted 12 Button Front side 5 Button ON OFF 13 Button Right side 6 Button Manual mode 14 LED Level indicator 7 Button Automatic mode 16 LED E amp P logo 8 Button Retract all Jacks ARRIVING ON SITE E e e Functions The diagram below shows the appearance of the remote control By using the remote control you can operate the hydraulic levelsystem HYDRAULICS H LEVELING SYSTEM Function declaration 9 LED Manual mode 1 LED Slope too steep 10 Button Left side 2 LED Battery low voltage 11 Button Rear side 3 LED Withdraw front wheel 12 Button Front side 4 LED Jacks not fully retracted 13 Button Right side 5 Button ON OFF 14 LED Level indicator 6 Button Manual mode 15 LED E amp P logo 7 Button Automatic mode 8 Button Retract all Jacks ARRIVING ON SITE E e e Extensive function declaration 1 Lea SLOPE TOO STEEP In this position the caravan cannot be levelled the
119. order of wires for reconnection with the Watermaster IC See Fig 1 and Fig 2 seen Calibration light Calibration butt rew hole 8 Fig 1 Watermaster IC features Pressure switch adjusting screw amp lock nut REMOVE Fig 2 Wiring connections Watermaster socket Step 3 Unscrew and remove the pressure switch adjusting screw and locking nut see Fig 2 Step 4 Remove securing screw see Fig 3 Fig 3 Preparing Watermaster socket for connecting Watermaster IC and removing the securing screw Step 5 Take Watermaster IC and place countersunk screw into screw holes see Fig 4 Fig 4 Place securing screw into Watermaster IC GETTING STARTED sal Step 6 Plug Watermaster IC onto socket see Fig 5 and tighten screw NB Do Not Overtighten Fig 5 Insert screw into Watermaster IC To connect the plug and pump kit Priming Step 1 Place pump into a full water container Fig 6 los ANA Green calibration LED Fig 7 Installing and calibrating the system Step 2 Insert plug into wall socket and close lid to lock plug in place Step 3 Adjust dust cover over opening in container Note dust cover should not be secured to water container as air must be allowed to enter container to replace water being pumped out Step 4 Switch on 12 volt supply at main panel Isolator switch the pump should sta
120. ote control optional gt Hydrault axle support left Hydrault axle support right Hydraulic corner support rear side ft Hydraulic corner support rear side ight eee ARRIVING ON SITE sal Remarks and recommendations Below is an overview concerning remarks and recommendations tips of the hydraulic levelsystem After 4 minutes of no operation the system will switch off automatically The automatic levelling cycle can only be started after all jacks have been retracted If the jacks are not retracted when the automatic cycle starts the system will do this automatically So it is not possible to make short adjustments to the jacks the system will always first completely retract its jacks Ata low battery voltage the system will automatically switch off e Jacks are extended and you accidentally drive off the system will immediately give an alarm and the jacks are automatically retracted as soon as the handbrake is disengaged In case of vehicles with a pneumatic brake installation this takes place when the engine is started All normal functions of the system are switched off in error mode The jacks always operate 2 at a time at 1 side The left side right side front side and rear side Only when retracting do they operate all 4 at the same time During winter conditions e g in snow and ice put something e g a piece of carpet under th
121. ottles or heavy items in overhead lockers during towing Everything else should be distributed evenly around your caravan front and back and each side of the centre line Should snaking start if at all possible don t brake and don t compensate by steering into the swings Just ease up on the accelerator and allow your speed to gradually decrease until the snaking subsides Q What Is The Correct Awning Size For My Caravan A Ground to ground awning measurements for Buccaneer caravans can be found by looking in the latest model section the Product Archive section on our website or by referring to the relevant Technical Data Sheet However we advise you verify this information by threading a piece of string through the awning channel from ground to ground and then by measuring the string Your awning manufacturer will then advise on the nearest size of awning appropriate for your measurement Q Can I Fit A Bicycle Rack Top Box Air Conditioning To My Caravan A It may be possible to fit accessories to your caravan but this will depend upon the internal construction of the roof walls and whether they can support the weight of the accessory If itis possible your Retailer will be able to advise you or alternatively they will obtain confirmation and a drawing where necessary from Buccaneer Please note that weight of any accessories will reduce your User Payload allowance Q My Interior Lights Are Not Working What Do I Do A It i
122. ourself and your touring caravan never leave the Registration Document in the caravan For security reasons keep it in a safe place If you sell the caravan please follow the instructions on the Touring Caravan Registration Document Please note If you do not receive a Touring Caravan Registration Document lose it or any of the details recorded are incorrect please contact CRIS PO Box 445 Aldershot GU11 9FS Telephone 0203 2821000 Spare windows stencils can be found in your owners information pack for use if you ever need to order a replacement window ELECTRONIC TAGGING In conjunction with the CriS registration scheme all Buccaneer touring caravans are electronically tagged during manufacture for added security and ease vehicle identification The security tag containing the individual identity of your caravan is concealed within the caravan body and can only be read by using a special decoder Please Note Your Local Police Can Obtain The Use Of A Decoder By Contacting C R I S on Telephone No 0203 2821000 SECURITY ADDITIONAL SECURITY Consider fitting any device which might deter or prevent intrusion by thieves For example A wheel lock will prevent towing of the caravan and removal of the wheel FREE CRIME PREVENTION advice about securing your caravan protecting your valuables property marking either at home or whilst on site can be obtained from the Crime Prevention Officer through your loc
123. p round 8 32 Security Additional Security 9 4 Caravan Theft occon 9 1 Electronic Tagging 9 3 Service Documents 1aaeesee 18 1 Setting Of ac 4 1 Site Regulations 5 1 Speed Limits nn 4 1 Stabiliser Hitch Head Operation 22 0 cee 3 2 Storage Long Term amp Winter 11 1 T e eng 8 28 Toilet Thetford C260 8 21 Towing Weight Ratio 3 1 Tyres a2 einen 10 4 U UNCOUPIING nenn 3 3 22 2 INDEX V Ventilation inssin 2 2 W Water System eueesessseesirenees 6 6 Whale IC System with High Flow Pumpen 6 6 Wheel Changing eeens 10 4 Windows 8 28 Wiring Diagrams Buccaneer iron 15 1 22 3 Designed and Printed by Preset Graphics Ltd Tel 01332 549278 MY2015 Ref 21379 The Explorer Group Limited Delves Lane Consett Co Durham DH8 7PE Telephone 01207 699000 e Facsimile 01207 699001 e www explorer group co uk All the illustrations and descriptive matter in this guide are intended to give a general idea of the caravan Changing market and supply situations may prevent the manufacturer from maintaining the exact specifications and details in this handbook and we therefore reserve the right to alter specifications and materials as conditions demand Retailers are independent of the manufacturer and have absolutely no authority to bind the manufa
124. pill something on your upholstery blot up the excess immediately Avoid detergents which may damage the fabric s protection Use a sponge or a clean white cloth but do not wash or rub the fabric Leave to dry in normal conditions These actions will not affect the Fire Retardent treatment of the fabric Heavy soiling will require professional cleaning All fabrics will fade to some degree if exposed to direct sunlight Try not to leave newspapers lying on your cushions ink can stain the covers It isn t alway easy to avoid that from happening however proper ventilation can help Try to keep pets off the upholstery and be careful of sharp objects such as belt buckles toys and watch straps snagging the fabric If snags do occur carefully cut off the loose ends with scissors or tuck back in do not pull them under any circumstances 10 2 WINTERISATION AND STORAGE Mattresses are made from fire retardent fabric and are a C M H R foam encapsulated sprung unit It is recommended that mattresses be stored on edge during winter Try to keep your cushions away from direct sunlight Curtains It is recommended that the curtains in your caravan are washed on a delicate cycle at 30 C This will not damage the clip glides Shrinkage may be caused should you decide to dry clean your curtains Curtains should not be left closed during daytime otherwise some fading will be experienced SHOWER TRAYS SHOWER ROOM AND WASH BAS
125. posing the casing is detected If the tyre has suffered a violent impact e g against a kerb it should be examined by a specialist as soon as possible CHANGING A WHEEL Whenever road wheels are removed and re fitted they must be tightened using a calibrated Torque Wrench set to 102Nm for steel wheels and 130Nm for alloy wheels Only use the wheel bolts supplied with your caravan If you need to replace these bolts you should obtain bolts from an approved Buccaneer Retailer The bolt fixings should be tightened in the sequence shown in the diagram below Do NOT simply tighten clockwise or anti clockwise Remember to over tighten is just as dangerous as to under tighten as this can distort the wheel rims Avoid the use of power wrenches Wheel bolts should NEVER be lubricated Alloy wheel bolts can be used to fit the steel wheel until the alloy wheel is ready for refitting Never use steel wheel bolts to fit an Alloy wheel Q CARE OF YOUR CARAVAN E The corner steadies must not be used to jack up the caravan They can be lowered to touch the ground only as a safety measure to stabilise the caravan i Apply the handbrake fully as for parking Do nat forget to give the caravan a slight rearwards push to stop the reversing lever collapsing ii Slacken off the wheel bolts on the wheel to be changed ii Ensure all corner steadies are in the up position before commencing jacking of the caravan
126. r unlocked tool menu In MENU to unlock the tools order to get to the tool menu When activated the menu press the symbol symbol changes colour to green Truma Telemetric link to the Alde heating system Your Alde heating system is supplied with the wallet supplied with your caravan Please Truma Telemetric Link which can operate the read these instructions before operating the Heating system via a mobile phone link The Link operational instructions and the sim card for the Link will be provided within the document E HOW TO USE YOUR CARAVAN S EQUIPMENT Microwave ou Ki N DISPLAY Cooking time and power level are displayed AUTO COOK Used to cook or reheat many favourite foods WEIGHT DEFROST Defrost food based on weight TIME DEFROST Defrost food by time POWER Used to set power level ONE TOUCH COOK Used to cook or reheat specific quantities of food TIME SET BUTTON Used to set the cooking time and weight STOP CLEAR Used to stop the oven operation or delete the cooking data START 30 SEC Used to start the oven and also used to set a reheat time 10 Eco Used to turn the AC power on the oven Operation Procedure e Plug power supply cord into 230V AC 50Hz power outlet Press eco button until beep sounds and display is turned on e After placing the food in a suitable container open the oven door and put it on the glass tray The glass tray and roller
127. ransporters etc built on or after 1st October 1982 are fitted with a safety device to provide protection in the unlikely event of the separation of the main coupling while in motion It s also a legal requirement to use the breakaway cable whenever it s provided The purpose of the breakaway cable is to apply the caravan s brakes if it becomes separated from its towing vehicle The cable assembly is designed to part allowing the caravan to come to a halt away from the towing vehicle Construction Usually a thin steel cable possibly plastic coated and fitted with a means of attachment to connect to the towing vehicle Operation The cable should be able to pull tight to engage the caravan s brakes without any hindrance to its action if the main coupling of the caravan separates from the towing vehicle It should never become taut during normal use Correct Procedure For Use i Check cable assembly for damage If in doubt contact your Retailer or Service Centre ii Make sure the cable runs as straight as possible and goes through a cable guide underneath the caravan coupling iii Determine whether or not you have a designated attachment point a feature of the tow bar which has been identified by the tow bar supplier as being for the attachment of a breakaway cable Where a Designated Attachment Point Is Provided On The Tow Bar i Pass the cable through attachment point and clip it back on itself Fi
128. re that the valve on the cylinder is turned fully off Turn off all gas operated appliances Remove the gas hose from gas cylinder Before refitting a gas cylinder ensure that all gas operated appliances are turned off particularly after winterisation Ensure all connections are secure When the cylinder is connected please ensure that the high pressure hose is not placed under any strain WARNING If cylinders other than those recommended are used ensure that the cylinders are adequately supported do not block ventilation openings and cannot cause damage to fixtures and fittings located in the compartment Auto Changeover Gas Regulator The Whale Auto Changeover Gas Regulator Type 924N has been specially designed to supply a caravan or motorhome gas installation in compliance with the requirements of annex D of standard EN 12864 Supply pressure for appliances is standardised at 30 mbar for the whole of Europe Note Not suitable for use in caravans or motorhomes when the vehicle is in transit WARNING This product is designed for use with all liquefied petroleum gases propane butane and LPG LPG is highly flammable Important In the following cases shut off the cock on the cylinder IMMEDIATELY and contact your dealer or Whale Support 44 0 845 217 2933 GETTING STARTED E S e Abnormal combustion at the burner s of a Replacing the empty cylinder Figure 3 gas appliance
129. red with a cover in place POWER DRAIN To reduce the power drain while your caravan is in storage ensure that your refrigerator is switched off Please note Do not work under the caravan unless the corner steadies are down and the axle is supported Should the caravan be stored for a prolonged period of time it is strongly recommended that the caravan is fully serviced before the commencement of use Your retailer will ensure that your caravan is safe secure and ready for your enjoyment Please note Caravans stored for any length of time should not have the handbrake or brakes applied The wheels should be chocked or wedged and the handbrake released The hitch head should be checked to see that it is fully extended and that there is no load on the braking system It is recommended that you place a bowl of salt within your caravan to absorb any moisture during the winter months VES warranty O l CARAVAN WARRANTY COVER Introduction At Buccaneer we are confident that our new caravans are engineered using the latest manufacturing techniques and advanced materials technology ensuring that when buying one of our products you are buying the very best We extend this philosophy to our customers by offering long term peace of mind and reassurance through our extensive warranty cover Your warranty cover commences on the day your new caravan is purchased and comprises two key elements 1 Three year manufact
130. remove the smoke WARNING The pans and trays supplied with this appliance are the maximum sizes recommended for use Larger pans and trays may restrict good circulation of heat increasing cooking times Always ensure food is properly cooked prior to serving Oven Temperature Control The temperature in the oven is controlled by a thermostatic gas tap and is variable over the range of 130 C to 240 C The table on next page giving a guide to the approximate temperatures at each of the shelf positions with respect to the gas mark setting Good use can be made of the temperature variation between the shelf positions in several dishes requiring different temperatures may be cooked at the same time In this way maximum benefit can be obtained from the gas used to heat the oven Care should be taken not to overload the oven allow adequate spacing to ensure free circulation of heat When roasting with aluminium foil ensure the foil does not impair circulation of heat or block any oven flue outlet Ee lt Dish 1 4 1 2 90 C 110 C 130 C Very cool Meringues 1 110 C 130 C 150 C Cool Stewed fruit 2 120 C 140 C 1 160 C Cool Rich fruit cake rice pudding 3 130 C 150 C 170 CC Warm Baked custard shortbread finger 4 140 C 160 C 185 C Moderate Victoria sponge 5 155 C 180 C 1 200 C Fairly hot Whisked sponges ginger nuts 6 170 C 190 C 215 C Hot Short crust pastr
131. rformance may be compromised when the ambient temperature is below 10 C Butane should not be used when ambient temperature is below 5 C Before using the appliance for the first time remove all accessories and packing in the grill and oven including any plastic surface protection film e Clean all surfaces with hot soapy water to remove any residual protective covering of oil and rinse carefully The burners on this appliance have fixed aeration and no adjustment is required The burners should flame as follows Propane The flames should burn quietly with a blue green colour with no sign of yellow tips Butane Normally on initial lighting a small amount of yellow tipping will occur This then increases slightly as the burner heats up LPG is a mixture of Propane and Butane therefore the exact flame appearance depends upon the proportions of Propane and Butane in the gas being used Correct burner operation can only be determined by the use of a calibrated combustion gas analyser by a competent operative in accordance with relevant European and National Standards The burners are controlled individually and each is monitored by a thermocouple probe In the event the burner flames are accidentally extinguished turn off the burner control and do not attempt to re ignite the burner for at least one minute Operation Using the hotplate gas burners 1 Ensure gas supply is connected and turned on 2 Push i
132. rs can be purchased from your dealer to enhance security Passive Infra Red Sensor The wireless PIR sensor will detect movement in the caravan and transmit a radio signal to the alarm module if the alarm is on the siren will sound Leg Sensor The leg sensor will detect the corner stabilising leg being raised or lowered and transmit a radio signal to the alarm The leg sensor is fully sealed against dust and water and has a battery life expectancy of three years When the battery becomes exhausted the sensor will need to be replaced Enhanced Features Arming The System In At Home Mode In the at home mode any sensor that is programmed to be isolated such as the PIR sensor will not trigger the alarm Other sensors such as the leg sensor will trigger the siren Arm as normal followed by a second press on the arm disarm button within 2 seconds Normal on tone followed by at home tone indicating isolation is active Settling time of 15 seconds before responding to triggers Armed in the isolation mode will be indicated by a double flash intermittently of the LED The at home sensors will be isolated other sensors will trigger the siren for 30 seconds HOW TO USE YOUR CARAVAN S EQUIPMENT ees Arming the System in Test Or Buzz Mode In the buzz mode the siren will sound a short tone when a sensor is triggered instead of sounding for 30 seconds It is advisable to test all the sensors
133. rson was to touch a live piece of equipment the leakage of current to earth should immediately operate the RCD residual current device and trip the main switch to the OFF position This switch can only be re set after elimination of the fault Please Note In case of difficulty consult an approved electrical installation contractor who may be the local electricity board It is dangerous to attempt modifications and additions yourself Lamp holder plugs bayonet cap adaptors should not be used under any circumstances Resetting the RCD To re set operate the switch as for MCB s Periodically the RCD should be checked by operating the test button marked T The unit should immediately switch to the OFF position If the unit does not switch off then a qualified electrician should be consulted If the unit does switch off the test is complete and the switch can be re set restoring the supply back to normal Please note Simultaneous operation of all of the 230V mains electrical equipment may not be possible A typical UK caravan site mains hook up point provides a maximum output of 10 amps and on some continental sites the available output may be as low as 5 amps If your loading exceeds the site supply ELECTRICAL SYSTEM it may trip the site circuit breaker Please check the available mains output with your site operator The following items need to be added together if used simultaneously 230V mains eq
134. rt to run Step 5 Open one cold tap eg kitchen sink Step 6 After trapped air has been expelled water will flow from the open tap Step 7 When air has enn expelled turn off tap the pump should turn off after approximately 10 seconds To calibrate the System Step 1 Press and hold the calibration button until the green LED starts to flash after 1 3 seconds Fig 7 Step 2 Open the tap and the pump should start there maybe a short delay Step 3 After approximately 30 seconds turn off the tap Step 4 After approximately 10 seconds the pump should still be running press the calibration button again Step 5 The LED should turn solid green and the pump will stop after approximately 10 seconds The green LED should turn off and blink briefly every 5 seconds The system is now calibrated The Watermaster IC is now installed and your water system is ready for use Note In normal operation the pump may continue to run for up to 15 seconds after the tap is closed B GETTING STARTED Instructions for Pump Storage when not in use Pump hose can be inserted into groove on plug to keep pump off ground while refilling water container Fig 8 The plug should always be removed before moving the caravan When removing plug Step 1 Lift the lid to unlock the plug Step 2 Pull out plug from socket using hand grip Step 3 Shut lid Maintenance The Watermaster IC control unit locat
135. s displayed if an outdoor temperature sensor has been connected The background lights up when you press the screen or the MENU button Start the setting menu by pressing the MENU button The background lights up and those functions which can be set are displayed The settings are automatically saved after 10 seconds The control panel reverts to standby automatically after 30 seconds if no buttons are pressed or if the MENU button in the setting menu is pressed Control panel in standby 5 E HOW TO USE YOUR CARAVAN S EQUIPMENT Set the required temperature The temperature can be set from 5 C to 30 C in steps of 0 5 C Warm water is always available 50 C when the boiler is on and running on LPG or electricity During summer when only warm water is required adjust the temperature setting to below the surrounding temperature so that the central heating pump does not start 1 The temperature displayed is the temperature which is set at present in this case 22 0 C 2 Raise the temperature by pressing the button Lower the temperature by pressing the button 3 The settings are ready and the central heating pump will work at the set temperature Extra warm water If you need more warm water you can raise the water temperature temporarily from 50 C to 65 C After 30 minutes the boiler reverts to normal operation When you have selected more warm water the circulation pump stops
136. s leather Please note Should scratches appear on the acrylic windows these can often be removed with an acrylic polish i e ICI Perspex polish Gentle polishing with a liquid metal polish i e Brasso may also have the desired effect consult your retailer BEFORE attempting to remove any but the slightest scratch 10 1 CARE INSTRUCTIONS FOR SEITZ WINDOWS Use soap suds and plenty of water or Seitz special cleaning agents to wash the acrylic window Use talcum powder to care for the rubber seals Only use water and mild soap suds to clean the blinds Please note Do not keep the blinds closed for long periods of time as this can result in material fatigue CARE INSTRUCTIONS FOR SEITZ ROOFLIGHTS Clean the acrylic rooflight with soap suds and plenty of water or use the Seitz special cleaner Use talcum to care for the rubber seals Only use water and mild soap suds to clean the blinds Please note The 12 month guarantee becomes null and void if these instructions are not followed WINDOW BLINDS amp FLYSCREENS To clean the blinds and flyscreens moisten a soft cloth or sponge with a small amount of water and mild soap suds and gently wipe dirt off Allow to dry before retracting failure to due this could result in mildew forming Pleated blinds where fitted should be cleaned using a soft brush and if necessary hoovered using a soft brush attachment on the device Winterisation Storage Please note The
137. s for Seitz Windows 10 1 Care Instructions for Seitz Rooflights 10 1 Window Blinds amp Flyscreens 10 1 Winterisation Storage 0 eee 10 1 Interior Walls O ernennen eigenen Cooking Equipment een 10 2 Soft Furnishings Winterisation and Storage 10 2 Shower Trays Shower Room and Wash Basin Fittings 10 2 Cleaning of all Taps 0see oeiee 10 2 Water Containers oooccnncnnionessnnesnnnoso 10 2 Water Systems Sterilisation 10 3 leie We 10 3 Chassis Mounted Spare Wheel Carrier 10 4 BK 10 4 A O eege eege 10 4 Tyre Wear and Damage 10 4 Changing a Wheel s sseseseeeneeerseeeesene 10 4 Jacking up your Buccaneer Caravan 10 6 A A 10 6 Maintenance of your BPW Chassis 10 7 Procurement of Spare Parts 10 7 Caravan Motor Movers esenee 10 7 STORAGE soii 11 1 Long Term amp Winter Storage Caravan Covers Zo Power Drain u s ssss0r ernst 11 1 CONTENTS 2 gt B CONTENTS CARAVAN WARRANTY COVER 12 1 Non Warranty Repairs ur Remedial Work CARAVAN CONSTRUCTION MAIN COMPONENTS eessen 13 1 BPW Chassis Sr Braking System eeeneennnn 13 1 Solid Construction Body Shell 13 1 Windows e Insulation Front Panel and Gas Bottle Locker Door cutre 13 1 Awning Channel 13 1 EQUIPMENT LIST seess keen 14 1
138. s must be checked by authorised technical personnel after first use and after every other year for compliance with the European Standard EN 1949 A test certificate has to be issued It is the user s responsibility to arrange this test The gas burner must be inspected and cleaned as necessary at least once a year When using liquefied petroleum gas tank or refill cylinders the maintenance interval is reduced to half yearly or quarterly Keep the evidence of maintenance work carried out on your refrigerator Work on gas and electrical equipment shall be carried out by qualified personnel only It is recommended that this is carried out by an authorised customer care department We recommend maintenance following an extended shutdown of the vehicle Please contact our customer care Electrical operation 12V voltage on board power supply CAUTION The refrigerator should only be used in 12V DC operation while the vehicle s engine is running otherwise the on board battery would be discharged within a few hours Mains power 230V CAUTION This option should only be selected where the supply voltage of the connection for power supply corresponds to the value specified on the data plate Any difference in values may result in damage to the appliance HOW TO USE YOUR CARAVAN S EQUIPMENT E ER Manual energy selection automatic ignition on MES Dometic Sei oonpflal 1 2 3 4 6
139. s possible that all of the 230V mains electrical equipment may not be operated simultaneously Check fuses battery connections and power supply master light switch Refer to your Retailer for further assistance PLEASE NOTE The internal lights in your caravan will not operate whilst the caravan s electrical hitch cables are connected to a towing vehicle with the engine running 16 1 B GENERAL QUESTIONS d Q Where Can I Get Spare Parts For My Caravan A Retailers will be able to source most parts you require For details of your nearest Buccaneer Retailer please refer to our Find A Retailer section on our website or call 0371 964 2113 for assistance Q How Many Years Will Spare Parts Be Available For My Caravan A Buccaneer will endeavour to supply spare parts for a caravan for at least 8 years from new Q What If The Parts Are No Longer Available A Where an original part is no longer available whenever possible we will suggest a suitable alternative if it is available Q Who Can Carry Out Warranty Work On My Caravan A Your supplying Retailer is obliged to undertake your warranty work However any approved Buccaneer Group Retailer or Service Centre can undertake the work but this is at their discretion We will also accept services completed by aNCC approved service centre but they will not be able to undertake warranty work ifthey are not approved by Buccaneer Q Why Don t You Stock Parts At Buccaneer A
140. sition For those caravans with lift up taps please ensure the taps are left in the central position All blinds and flyscreens should be left in the retracted position Check all fixed ventilation apertures are not obstructed Ensure that the refrigerator freezer compartment doors are secured in the vent position using the door catch viii Check that the site you have chosen to store the caravan is open fairly high and dry and if possible not exposed to gales etc If this proves impossible it is recommended that the caravan chassis is anchored to the ground Jack up the caravan use bottle or screw jack do NOT use the corner steadies so that the wheels are clear of the ground Support the caravan axle with wooden blocks axle stands or similar so that when the jacks are removed the wheels remain clear of the ground Lower the corner steadies to just site the caravan Cover the tyres to prevent deterioration Release the handbrake Security Lowering and locking the corner steadies and removing the wheels will reduce the risk of caravan theft ii iii iv v vi vii ix x xi CARAVAN COVERS Caravan covers may be used to protect your new Buccaneer caravan provided that the cover used is of a breathable type Unscrew the TV antenna and ensure the cover is well tied down to avoid the cover being punctured Your caravan must be ventilated every 4 to 6 weeks if it is to be sto
141. small handle under the toilet bowl sideways 14 Automatic Ventilator The ventilator automatically starts when the control panel is activated by pressing the flush button and will automatically shut off after approximately 5 minutes The Automatic Ventilator Indicator will flash until automatic shut off occurs If you want to stop the ventilator press the Automatic Ventilator button If you want to re start the ventilator press the button again the LED will start flashing again Flush Water Tank Level Indicator only for toilets with own flush water tank When the Flush Water Tank Level Indicator lights up refill the flush water tank as only about 1 5 litres of water is left in the tank which is sufficient for approximately 2 flushes 15 Emptying The Waste Holding Tank has a capacity of 18 litres and requires emptying when the red light LED on the toilet control display lights up when the Waste Holding Tank only has capacity for approximately 2 more litres which is no more than two to three further uses Make sure that the blade is closed Open the access door located outside the vehicle pull the safety catch upwards and remove the Waste Holding Tank 16 Place the Waste Holding Tank in an upright position Pull Out Handle at the top Wheels at the bottom Slide the handle sideways to the front of the tank until it snaps out of its locked position Pull the handle up and wheel the Waste Holding Tank t
142. stem or if the buyer makes settings independently In case of abuse or negligence overloading damage through accident incorrect loading or incorrect weight distribution damage through improper use or improper maintenance connection to wrong parts or repair attempts by other persons than the acknowledged E amp P Hydraulics dealer installer This warranty does not apply to physical damage damage as a result of force majeure in case of commercial use or adaptation of the product or for products that are sold as a special offer and or with defects This warranty will become invalid if the product s identification criteria which were attached in the factory are changed or removed GETTING STARTED sul GETTING STARTED You have arrived at your destination and now want to start to enjoy your new Buccaneer caravan The following is a step by step guide to connecting your services and getting everything in your caravan working ELECTRICITY Power Supply Charger Your caravan is fitted with a power supply charger This will charge the caravan battery not supplied when fitted and also power the 12V systems in your caravan It is recommended that you always carry a leisure battery The Charger is fully automatic and will not overcharge the leisure battery 12v Systems Your caravan is fitted with an automatic system for selection of power When connected to the 230V site supply the automatic Pow
143. surface is not even enough If necessary switch over to manual mode 2 BATTERY LOW VOLTAGE The battery is empty of the voltage is too low to be able to work safely 3 Fi WITHDRAW FRONT WHEEL The caravan is too high at the front withdrawn the front wheel and the LED will go out 4 m JACKS NOT fully One or more jacks are extended or not fully retracted RETRACTED 9 MM MANUAL MODE Indicates that the caravan can now be brought to the correct level manually 14 B LEVEL zero point Indicates that the caravan can now be brought to the correct level 15 D BATTERY 9V VOLTAGE The battery voltage of the remote control is too low only present on the remote control 16 Ep E amp P LOGO Indicates that the levelsystem is switched on only present on the remote control BUTTONS 5 O ON OFF Switches the levelsystem on or off 6 MANUAL MODE Switches the levelsystem into manual mode for levelling the caravan 7 AUTOMATIC MODE Switches the levelsystem into automatic mode for levelling the caravan jm E amp Sh o 8 H RETRACT ALL JACKS Automatically retracts all jacks 10 LEFT SIDE Controls retracting and extending the left jacks 11 N REAR SIDE Controls retracting and extending the rear jacks 12 FRONT SIDE Controls retracting and extending the front jacks 13 RIGHT SIDE Controls retracting and extending the right jacks ARRIVING ON SITE E e e Operating the levelsystem Automatic
144. switch at the site supply point is off and that all electrical equipment in the caravan is switched off by ensuring your caravan mains isolating switch on the MCB miniature circuit breaker is in the OFF position ELECTRICAL WARNING Attention Always disconnect the electrical connector between the towing vehicle and the caravan before connecting a mains electric supply to the caravan and before charging the caravan battery by any other means Once the above checks have been made ii iii iv v Open the battery box on your caravan and insert the female connector of the mains connection cable supplied with your caravan into the inlet within the battery box as shown below vi Locate the site supply and remove any cover from the socket outlet provided at the supply point Insert the male plug at the other end of the flexible orange supply cable Switch on the main switch at the site supply point if appropriate B GETTING STARTED sl WIRING OF CONNECTING CABLE AND CARAVAN MAINS INLET PITCH SUPPLY OUTLET VIEW OF TERMINALS lt a VIEW OF VIEW OF TERMINALS EN SOCKET TUBES PINS LIVE NEUTRAL NEUTRAL RLUTRAL W I OO oo BLACK ROWA Le BROWN n EARTH EARTH EAATR GREER amp YELLOW EARTH GREEN amp YELLOW NEUTRAL S x FLEXIBLE 3 CORE CABLE 5mm Be VIEW OF VIEW OF TERMINALS SOCKET
145. t it back in its original position and close the access door If the toilet is connected to HOW TO USE YOUR CARAVAN S EQUIPMENT E ER the vehicle s water tank please follow your vehicle s instructions for draining the central water system If your toilet is optionally featured with a Waste Pump Out System take out the Waste Holding Tank and completely clean it see Cleaning and Maintenance After cleaning fill it with water put it back and empty it via the waste pump out system Repeat this twice Toilet unit malfunctions Contact your dealer or a Thetford Service Centre We advise draining the fresh water tank prior to travelling Antifreeze should not be required if the motor home is heated If you do wish to use antifreeze brands containing the following properties may be used in the fresh water tank e Ethylene glycol e Mono Ethylene glycol e Propane diol e Glycerol e Ethane diol e Glycol Never use alcohol based antifreeze i e Methanol Ethanol and Iso propanol 8 26 HOW TO USE YOUR CARAVAN S EQUIPMENT E ROOFLIGHTS Your caravan is fitted with at least one type of the following roof lights The Omivent 12v Rooflight The Omivent is a double glazed roof light constructed from a synthetic ultra violet screened material Its side operating mechanism allows a completely free central opening with built in fixed ventilation when closed It operates as an extrac
146. ted by a NICEIC approved contractor every 3 years 12 2 WARRANTY O Transfer of ownership If you purchase this vehicle as a used vehicle it may be possible to transfer the unexpired term of the warranty cover up to a maximum of six years commencing at the original date of purchase from new The warranty cover for a used vehicle commences from the original date of purchase from new and is as follows 1 Three year manufacturer s warranty 2 A maximum of six years body integrity warranty The warranty is subject to the usual terms and conditions set out in the handbook and is only transferable on payment of a 50 administration fee Full documentary evidence that the caravan has been serviced annually should be provided at the time of transfer in accordance with the terms and conditions of the warranty stated in the handbook Transfer of ownership must be completed within three months of change of legal ownership Please complete the Notification of Change of Ownership form in your handbook This warranty does not affect the purchaser s statutory rights The warranty shall be governed and construed in accordance with the laws of England and the parties irrevocably submit to the exclusive jurisdiction of the courts of England For second owners the service in years 3 and 6 must be completed no more than 60 days on or before the anniversary of the original date of purchase NON WARRANTY REPAIRS Shoul
147. this guide and we therefore reserve the right to alter specifications as materials and conditions demand Enjoy your new caravan Model Year Designation All Touring caravans manufactured by Buccaneer are designated by their model year The 2015 model year runs from 1st September 2014 to 31st August 2015 Buccaneer Technical Approvals All Buccaneer Caravans have been European Commission Whole Vehicle Type Approved via the Vehicle Certification Agency VCA In order to ensure your new caravan is safe to use Buccaneer are members of and have been inspected by the following bodies NCC who operated a certification scheme to ensure compliance with the European safety standards for caravans National Inspection Council for Electrical Installation and Contracting NICEIC who carry out an annual inspection of Buccaneer electrical installations within caravans Gas Safe Register approved installers carry out an annual inspection to ensure that the gas installations carried out by Buccaneer fully comply with all relevant regulations and standards Buccaneer has also obtained ISO9001 2008 accreditation and this is audited by SGS UK Limited GENERAL SAFETY T GENERAL SAFETY Please read before using your new caravan In order for you to get the most out of your new Buccaneer caravan it is necessary for you to be aware of the following i Do not obstruct ventilators and clean them regularly it is advisable to clea
148. thyl acetate Hydrogen Sulphide Hydrogen Sulphur Dioxide alcohol based products paints thinners solvents adhesives hair sprays aftershaves or perfumes and some cleaning agents WARNING This Carbon Monoxide alarm is not a smoke alarm It will not sense smoke fire or any poisonous gas other than carbon monoxide HOW TO USE YOUR CARAVAN S EQUIPMENT E THETFORD CASSETTE C260S TOILET Introduction The Thetford Cassette Toilet is a high quality product The toilet forms an integral part of your caravan bathroom thanks to its functional design which combines modern styling and ease of use The C 260 Cassette Toilet is manufactured from high quality synthetic materials which makes it a durable user and maintenance friendly toilet The toilet is made up of two parts a permanently fixed part and a Waste Holding Tank that is accessible from the outside The removable Waste Holding Tank is located under the toilet bowl and can be removed via a door on the outside of the caravan The Thetford Cassette Toilet is the solution to the sanitary problem in your caravan The operating instructions cover Thetford Cassette Toilet models C 260S C 260CS models connected to the vehicle s central water tank and C 260CWE model with its own flush water tank There are differences in the use ofthese models Please ensure that you follow the instructions that apply to your toilet model PARTS a Removable Seat and Lid
149. tially tighten the steel bolts to a torque of 102Nm for steel wheels and 130Nm for alloy wheels following the sequence stated above IMPORTANT The torque settings should be re checked after 50 km 30 miles Do not loosen the wheel bolts to carry out this operation whilst the road wheel is supporting the weight of the caravan e Wheel bolts should NEVER be lubricated xii NB If you upgrade from steel to alloy wheels you must ensure you use the correct bolts for the new wheel CARE OF YOUR CARAVAN Jacking up your Buccaneer Caravan Under no circumstances should the corner steadies be used to jack up the caravan This is achieved by using the self levelling system fitted to your caravan Full details of how to operate the system are contained within the ESP handbook contained in your caravans document wallet LUBRICATION Lubricate the Jockey Wheel Lightly oil the wheel axle and screw thread Lubricate the Brake Linkage Lightly oil all moving parts Lubricate the Corner Steadies Lightly oil the screw and pivot pins 10 6 CHECK WEAR ON BRAKE LININGS ON ALL MODELS GREASE GREASE CORNER STEADIES HITCH GREASE NIPPLES CHECK BRAKES ADJUST IF NECESSARY CHECK WHEEL BEARINGS CATEGORY OF EXPOSURE amp DURATION OF PROTECTION The BPW chassis is protected by a hot dip galvanising process in accordance to DIN EN ISO 1461 The duration of protection is according to
150. tion grills and the extractor have not been blocked by snow leaves or similar 2 When the ambient temperature falls below 8 C the optional winter covers should be fitted This protects the unit from excessively cold air 3 Affix the cover and fasten it TIP It is also recommended that the winter cover should be used when the vehicle is taken out of service for an extended period of time 3 HOW TO USE YOUR CARAVAN S EQUIPMENT gs ALDE HEATING Alde 3020 Control Panel Starting the boiler e Press the On Off button and the start up display is displayed The boiler starts with the last selected setting The control panel in standby mode D E F A Clock The clock shows day and time B Outdoor temperature The outdoor temperature is displayed if a sensor probe is mounted C Indoor temperature The indoor temperature is displayed automatically D Circulation pump This symbol is displayed when the heating pump is requested E LPG bottle full empty This symbol is displayed when the sensor on the cylinder changeover is connected and activated F 230 volts This symbol is displayed when 230V is connected to the boiler G MENU button Button for setting menu H On Off button Shut down turn on the boiler From standby mode to setting menu When on standby the indoor temperature is displayed and the outdoor temperature i
151. tor fan and air intake fan Please note Do not change the direction of the fan unless it has been switched off O position and the blades have stopped rotating Mini Heki Rooflight The mini Heki S with fixed ventilation has five opening positions and easy to operate handles It is equipped with blind and flynet and allows adjusted natural lighting and shading as required Using the solid handles the rooflight can be easily opened and placed into one of the five opening positions up to a height of approx 80 mm Midi Heki Rooflight Fig 1 i To open push the large central button Fig 2 ii Whilst depressed slide the bar to the desired position and locate into the stops provided Fig 3 Fig 3 E HOW TO USE YOUR CARAVAN S EQUIPMENT WINDOWS Your caravan will be fitted with Polyplastic framed windows Polyplastic Window Opening i In order to open the Polyplastic window it is only necessary to move the catch upwards and release the catch from the backing plate ii The Polyplastic window should remain in the open position once opened however if it does not then tighten the friction control on the window stays to increase the holding force ii The Polyplastic window is also fitted with a night ventilation position where the catch is set to the centre position on the backing plate in this position it may be possible for rain t
152. uipment typical consumption figures e Refrigerator Charger ed Water bester css e Colour TV e Microwave e Air conditioning 4 00 amps AUTOMATIC CHARGING SYSTEM The battery charger will operate automatically when the caravan is connected to the mains outlet on a caravan site The 12V system with the exception of the 12V refrigerator and battery charging will not operate when the caravan is connected to the towing vehicle CHECK all caravan equipment is set up to accept the site supply before actually switching on MAXIMUM BULB RATINGS FOR INTERNAL LIGHTS Type of Light Maximum Bulb Rating Front window light 4 watts Downlighters 2222 1 2 watts Reading NIGMS eege dee Erde 1 2 watts AA nee 0 36 watts Above locker strip lights 500mm 1 2 watts Above locker strip lights 800mm 2 2 watts Awning lights een 5 watts Please note Ensure that you only replace a blown bulb with one of the same rating Never replace a bulb with one with a higher rating You should ensure that when fitted no bulb is in contact with the surface of the lamp or shade Note All LED lights can only be replaced with a new complete unit and not a replacement bulb CAUTION Do not look directly at LED lights ELECTRICAL SYSTEM MAINS UNIT FRIDGE HEATER CHARGER BOILER 6A 16A 16A SOCKETS NEE I IL MCB
153. ur caravan above the plated MTPLM PREPARING FOR THE ROAD sal PREPARING FOR THE ROAD Tyre and wheel checks Before setting off please ensure that the tyres are inflated to the correct pressure and have at least the legal minimum of tread 1 6mm which should be in a continuous band throughout the central three quarters of the tread width throughout the whole of the circumference of the tyre and are in a good condition with no bulges or visible defects You should also check that the wheel bolts have been tightened to the correct torque 130Nm for Alloy wheels and 102Nm for steel wheels CARAVAN TOWING VEHICLE WEIGHT RATIO This ratio has a major influence on stability It is recommended that i The laden nose weight for your caravan should not exceed the lower of the following Towing vehicles maximum nose weight Tow bar maximum nose weight The caravan s maximum nose weight The actual laden weight of the caravan should always be kept as light as possible The lighter it is whilst being towed on a road the safer the outfit combination will be What you are able to tow is dependent on your driving licence If you are a B licence holder you can only tow a car caravan combination of total weight not exceeding 3500kgs and the cars kerb weight must be greater than the caravans plated MTPLM Note It is strongly recommended that the caravan plated MTPLM should not exceed the cars kerb weight
154. urer s warranty 2 Ten year body integrity warranty Scope This applies to all new Buccaneer products manufactured from 2012 model year onwards Three year manufacturer s warranty Year 1 warranty Covers all original components including permanently fitted equipment forming part of the original product specification Year 2 and 3 warranty Covers all original components including permanently fitted equipment forming part of the original product specification with the exception of the following items e Microwave TV e Tyres e Batteries e Windows and glass e Deterioration of exterior paint work e Soft furnishings carpets and floor coverings Entertainment equipment e Fluorescent tubes bulbs LEDs and fuses e Plastic and GRP exterior panels e Plastic products including A frame covers wheel spats and shower trays e Minor adjustment of blinds hinges catches stays and doors Exterior decals 12 1 Ten year body integrity warranty Buccaneer products are covered against water ingress damage for 10 years from the original date of purchase of a new product 6 years for subsequent owners from the 1st owners original date of purchase This applies to water ingress through any permanently sealed seam joints In order to comply with the terms of the above cover the following conditions must be met Reporting a fault In the unlikely event that you experience a problem with your caravan please
155. us along with the following information A copy of the new CRIS registration form e A copy of the service handbook displaying complete and up to date service history e A cheque for 50 made payable to Buccaneer Transfer of ownership must be made within the first three months of any change of legal ownership in order for the warranty cover to remain valid Buccaneer Customer Care Delves lane Consett County Durham DH8 7PE www elddis co uk This form is also available for you to print from our web site NOTIFICATION OF CHANGE OF OWNERSHIP Previous owner details if known EMail anna aa a aer iE aaia ieai ENER Eai EE POSECOUE zuesere essen Daytime telephone number Date Of purchase ans Tu EE Details of Caravan En Re Model cidos Vehicle identification number 17 diGitS u unten In order for you warranty to remain valid your caravan must have been serviced annually by an Approved Buccaneer Retailer or Service Centre If you do not want to receive information about products and services from Buccaneer please tick a 19 1 CHANGE OF ADDRESS l NOTIFICATION OF CHANGE TO NAME AND ADDRESS In order that we can provide you with the very best level of service we ask that you keep us informed of any changes to your contact details Should your details change please complete the online form on our website in our Customers section Alternatively please complete the attached form and post to us
156. use it may obstruct the operation of the hydraulic levelling system Ifthe jacks remain extended for a longer period of time the exposed legs must be protected by weekly spraying them with a silicon lubricant Do this every 2 or 3 days if the caravan is located in a salty environment e In winter slippery conditions we advise you to take additional safety and precautionary measures Especially because your safety during operation of the system For optimal performance under extreme conditions 30 degrees we recommend the use of a special hydraulic oil for low temperatures consult an authorized dealer Furthermore during the winter period we have to deal with situations in which de icing salt will tack to the outside of the system Preventative maintenance should be Good cleaning of the jacks Clean the stainless steel cylinder piston rod and spray with a silicone lubricant Remove dirt from the stainless steel foot plate especially at the bottom this is the area your caravan stands on Try to put the caravan in a location as clean and flat as possible Place a piece of rubber e g piece of carpet between the frozen slippery surface and the footplate Before leaving make an additional check round the caravan if necessary remove snow and ice from the jacks then you are free to withdraw the jacks Warranty Repairs to the caravan must be performed by dealers recognized by E amp P H
157. ut the waste from the holding tank into the vehicle s waste tank The button will flash while the waste is being pumped and will stop automatically after approximately 5 minutes when all waste has been transferred If the vehicle s waste tank is full the Waste Pump Out light will flash rapidly and no pump out will be possible until the central tank is emptied Check the level of the vehicle s waste tank on the vehicle s central console After the Waste Holding Tank has been emptied there will be approximately 1 5 litres of waste left in the tank This is normal Add 2 litres of water and a correct dosage of Thetford toilet fluids to the Waste Holding Tank CAUTION It is vital that the correct amount of toilet fluid is added to ensure the proper breakdown of the waste in the holding tank Only use the system when the tank is full Using the system too often on an empty tank can cause damage to the pump which could cause the system to fail Cleaning and Maintenance The toilet should be cleaned and maintained regularly depending on the amount of use To clean Thetford toilets we advise using water and Thetford Bathroom Cleaner CAUTION Never use bleach vinegar or other powerful household cleaners that contain these substances These may cause permanent damage to the seals and other toilet components Toilet Bowl Squirt Thetford Bathroom Cleaner into the toilet bowl Flush the toilet bowl with water and wipe do
158. utside of the alarm can be wiped with a damp cloth After cleaning reinstall your alarm and test it by using the test button If cleaning does not restore the alarm to normal operation the alarm should be replaced HOW TO USE YOUR CARAVAN S EQUIPMENT E CARBON MONOXIDE ALARM Test Reset Green Button Power LED Red Alarm LED p Operate 5 Carbon Monoxide Alarm Model 7CO Switching on your CO alarm Note Your CO alarm must be installed by a competent person using the following guidance Remove the batteries from the pack and insert them into the battery compartment Make sure that you fit the batteries correctly to the polarity markings or shown within the battery compartment If correctly installed the alarm will give a short beep e To test the alarm press the test button The alarm will beep once followed by 4 loud pulses then a brief pause and then 4 more pulses ending with a single beep e Check that the green LED flashes at 30 second intervals to show that the alarm has power This is easiest to see in a dark area or with lights switched off Recognising alarm signals and warnings Feature What this means Required Action Green LED flashes every 30 seconds Normal operation None The alarm chirps every 60 seconds and the red LED flashes Low batteries Replace batteries as soon as possible Alarm chirps twic
159. ve casing Operating system main unit ge Se Antenna connection Antenna 5 10 ARRIVING ON SITE E e Battery Remove the battery cover on the rear side of Remote control Ei the remote control by firmly pressing the Battery 9V cover and then sliding out Insert the 9V ee ae battery carefully reassemble the battery cover in most common cases the battery is already fitted TC GE ks ___ Registration De label Programming the remote control Step 1 In order to pair the remote control to the system remove the fuse 30 Amp out ofthe cable assembly from the hydraulic levelsystem Step 2 Press the buttons AUTOMATIC MODE no 7 and RETRACT ALL JACKS no 8 simultaneously When done the Indicator LED no 14 with the surrounding 4 arrows starts blinking GREEN ORANGE rapidly This means the remote control is looking for its receiver mounted within the operating system Step 3 Reconnect the fuse to the system The pairing process should be made within a certain time approx 20 sec The remote control turns off automatically When the Indicator LED no 14 goes off the pairing process is complete Putting the remote control into use After programming the remote control you now have the possibility to operate the levelsystem with the remote control Step 1 Switch the remote control ON by pressing button ON OFF
160. vices have been carried out in accordance with our warranty terms Service intervals a In years 1 2 and 4 through to 9 the service must be completed no more than 60 days either side of the anniversary of the date of purchase b In Years 3 and 10 the service must be completed no more than 60 days before the anniversary of the date of purchase c For second owners the service in years 3 and 6 must be completed no more than 60 days on or before the anniversary of the original date of purchase d No service interval should exceed 14 months e Failure to service the vehicle within the specified time limits will invalidate your warranty Where an annual service identifies that repairs are necessary the caravan must be made available for repair within six weeks of the date of inspection for the purpose of carrying out the repair work Buccaneer reserves the right to inspect the vehicle before work commences Work may only be undertaken by an Approved Buccaneer Retailer or Service Centre and only after approval by Buccaneer depending upon individual circumstances Buccaneer will pay the costs of remedial work to the repairer only after approved work has been carried out The cost of transporting towing or moving the caravan by any means to or from the place of repair is the responsibility of the owner The Policy is not retrospective and is applicable to 2012 model year caravans onwards No liability will b
161. wn the rest of the toilet with a damp cloth Clean seat and lid The seat and lid can easily be removed Lift the seat and lid assembly and pull the round pins inside the assembly outwards from the pin holes After cleaning replace the seat and lid by positioning the round pins in front of the pin holes and push the lid and seat downwards To keep your flush water fresh and to prevent deposits from forming in your toilet bowl add a correct dosage of Aqua Rinse in your flush water tank if present on your toilet Tip For a really shining toilet dry with a soft dry cloth after cleaning HOW TO USE YOUR CARAVAN S EQUIPMENT E Waste Holding Tank To keep your Waste Holding Tank fresh and clean Thetford has developed a number of different toilet fluids Thetford toilet fluids suppress smells reduce formation of gas promote breakdown of toilet waste and increase the life span of a mobile toilet We advise a thorough cleaning of the Waste Holding Tank once each season Next to using Thetford s Cassette Tank Cleaner the powerful cleaning agent for the periodical cleaning of the Waste Holding Tank of your toilet we suggest the following Remove the removable mechanism from the Waste Holding Tank by turning it anti clockwise and rinse it under a tap Remove the cover plate from the Automatic Pressure Release Vent by prising it up using a small screwdriver Use one hand to push the Automatic Pressure R
162. y Security Warranty Did you know e You should not take a tourer abroad without a registration document If you go abroad your CRIS registration certificate provides the necessary proof required by the police and other authorities that you are its registered keeper e Ifyou need to make a claim on your insurance CRIS can help speed up claims by providing details of your tourer and its purchase date to relevant parties e CRIS can help your tourer s manufacturer contact you in the event that there is any kind of product recall or fault that could affect the safety of your caravan For help support and advice contact CRIS NCC CRIS Ltd PO Box 445 Aldershot GU11 9SF Tel 0203 282 1000 www cris co uk Opening Hours Monday Friday 8am to 8pm Saturday 9am to 5pm Sunday 10am to 5pm WINDOW ETCHING amp CHASSIS MARKING WARNING THIS CARAVAN IS SECURITY MARKED AND ELECTRONICALLY PROTECTED BY cris DEU me canan ECO REGISTRATION AND IDENTIFIC ATION SCHEME The VIN number is stamped onto the chassis of the touring caravan and etched onto all of the windows acting as a further deterrent Your Touring Caravan Registration Document will include a 17 character VIN Vehicle Identification Number shown in the top right hand corner This 17 character VIN will be die stamped into the caravan drawbar and chemically etched on up to a maximum of 10 eye level windows To protect y
163. y 7 185 C 210 C 1230 C Hot Bread scones flaky pastry 8 200 C 220 C 1245 C Very hot Puff pastry 9 215 C 240 C 260 C Very hot Quick browning Do s and Don ts DO Read the user instructions carefully before using the appliances for the first time DO Allow the burners to heat before using for the first time in order to expel any smells before the introduction of food DO Clean the appliance regularly DO Remove spills as soon as they occur DO Always use oven gloves when removing food shelves and trays from the oven DO Turn pan handles away from the front so that they cannot be caught accidentally DO Check that controls are in the off position when finished DO NOT Allow children near the cooker when in use DO NOT Allow fats or oils to build up in the oven trays or base DO NOT Use abrasive cleaners or powders that will scratch the surface of the appliance DO NOT Under any circumstances use the oven as a space heater DO NOT Put heavy objects onto open grill and oven doors Leaks If a smell of gas becomes apparent the supply should be turned off at the cylinder IMMEDIATELY e Extinguish naked lights including cigarettes and pipes e Do not operate electrical switches e Open all doors and windows to disperse any gas escape e Never check for leaks with a naked flame use a leak detector spray e Check the gas is not escaping from an unlighted appliance HOW TO USE YOUR CARAVAN
164. ydraulics For systems which are not or cannot be changed installed or repaired by a recognized E amp P Hydraulics dealer the warranty cannot be used E amp P Hydraulics gives guarantees for parts of its hydraulic levelsystem against faults in material and manufacturing for a period of 24 months starting from the date of purchase If an E amp P Hydraulics product was checked by an official E amp P Hydraulics dealer and a fault in material or manufacturing was discovered within the aforementioned period E amp P Hydraulics is able to choose the following actions e Repairing or replacing the faulty part for free in E amp P Hydraulics factory or another location determined by E amp P Hydraulics e Sending a mechanic to the location where the caravan is at that moment in order to repair or replace the product part on site e Writing out a credit note for the defective product part ARRIVING ON SITE All warranty claims require a product test and approval by a dealer of E amp P Hydraulics All repairs must be approved by E amp P Hydraulics before the work starts There can be no exceptions to this procedure Immediately contact E amp P Hydraulics directly before trying to perform a repair or change to your E amp P Hydraulics product Claims for alleged damages to products are only allowed if E amp P Hydraulics has had the opportunity to check the claim The warranty becomes invalid when If the buyer modifies the sy

"user manual"

Contents

Download Pdf Manuals

Related Search

Related Contents

&quot;user manual&quot;

Contents

Download Pdf Manuals

Related Search

Related Contents

"user manual"