Owner`s Manual - American Range
Contents
1. G Use pipe joint compound G Use pipe joint compound 7 G The gas pressure regulator must be installed in the gas line failure to install a pressure regulator will void the equipment warranty The regulators supplied with ranges have 3 4 NPT connections the regulator is adjusted at the factory for 5 W C water column manifold gas pressure natural gas or W C manifold gas pressure for propane gas operation Before connecting the regulator check the incoming line pressure as these regulators can only withstand a maximum inlet pressure of I4 WC 1 2 PSI exceeding this pressure will damage them Visually double check any installer supplied intake pipes and or blow them out using compressed air to clear any dirt or debris threading chips or other foreign matter before installing a service line Those particles will clog gas orifices when gas pressure is applied Compounds used on threaded joints ofthis appliance piping must be resistant to the action of NG and LP gas and provide a gas tight seal to prevent leaks If the gas supply line pressure is greater than this amount a step down regulator will be required A gas flow direction arrow is cast into the body of the regulator to minimize installation error it should point downstream to the appliance The blue air vent cap on the top of the regulator is part of the regulator and should not be removed Any adjustment to the regulator must be ma2. Owners Manual AR Series Ranges Y COOKING ROGIFNAMT INSTALLATION ELECTRIC UTILITY CONNECTIONS STANDARDS AND CODES WARNING Qualified installation personnel are individuals a firm or a company which either in person or through a representative are engaged in and responsible for the installation of electrical wiring from the electric meter main control box or service outlet to the electric appliance The installation instructions contained here are for the use of qualified installation and service personnel only Installation or service by other than qualified personnel will void the warranty and may result in damage to the oven and or injury to the operator Qualified installation personnel licensed and bonded must be experienced in such work familiar with all precautions required and have complied with all requirements of state or local authorities having jurisdiction U S AND CANADIAN INSTALLATIONS All ovens when installed must be electrically grounded in accordance with local codes or in the absence of codes with the National Electrical Code ANSI NFPA 70 Latest Edition and or Canadian National Electrical Code C22 2 as applicable The ventilation of these ranges should be in accordance with local codes In absence of local codes refer to the national ventilation code titled Standard for the Installation of Equipment for the Removal of Smoke and Grease Laden Vapors from Commercial Cooking Equipment NFPA
3. HIESHELF INSTALLATION iconos teoria teo Ec Pott rehenes bittorrent 9 MAINTENANCE T iotaiis 10 Raised Griddle Brol Ef 10 deccm LEES 10 a 10 EXPLODED VIEW DRAWINGS PARTS LISTS 11 14 AR Re 1 12 13 14 TRO BES enne tutened 15 Intertek Intertek 13592 Desmond St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free www americanrange com Owners Manual AR Series Ranges SALITY COOKING ROGIFNAMT IMPORTANT PLEASE READ AND FOLLOW Before beginning please read all the instructions carefully DO NOT remove permanently affixed labels warnings or plates from product This will void the warranty All local and national codes and ordinances must be observed installation must conform with local codes The Installer must leave these instructions with the consumer who should retain for local inspectors use and for future reference Installation and service must be performed by a qualified installer service agency or gas supplier Please ensure that the product is properly grounded Your safety and the safety of others is very important We have provided many important safety messages in this manual and on your appliance Always read and obey all safety messages This is the SAFETY ALERT SYMBOL This symbol alerts you to hazards Hazards or unsafe practices which may result
4. maximum temperature and operate the unit for an additional hour This will drive off any manufacturing oils remaining in the unit Let the unit cool then thoroughly clean interior surfaces using hot soapy water HI SHELF INSTALLATION CLEARANCES NON COMBUSTIBLE WALLS COMBUSTIBLE WALLS q e q e For installation on a non combustible floor only a HI SHELF ASSY MOUNTING CHANNEL MOUNTING CHANNEL FA BZ Ze GZ Be RANGE BODY BACK REAR VIEW SHOWN Slide hi shelf assembly from top with mounting channels going inside the body sides 2 Seton top of support brackets and screw to body sides at rear monu Intertek Intertek 13592 Desmond St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free www americanrange com DRALITY Owner s Manual AR Series Ranges MAINTENANCE Periodic Remove surface burners and clean with warm water and wire brush Make sure the tiny burner ports are not clogged 2 Check valves for operation and clean if necessary Consult your service agency or local gas company RAISED GRIDDLE BROILER Daily Season prior to use To season pour a small amount of cooking oil ounce sq ft or 28g sq meter of surface over the top With a cloth spread oil over the entire surface to create a thi
5. Oven interior Polarized outlet No GFCI Installation Read User Manual Gas Connection Review Safety Instructions Verify fuel Natural or LP Proximity to cabinets Gas shut off present and accessible Backguard in place Gas Supply line properly sized Level Gas Supply pressure checked Ventilation system Operating pressure checked All connections checked for leaks Ignition Burners Flame Adjustment Air Gas Mixture Valve Operation Griddle Burners Burners Burners Char Broiler Griddle Griddle U Griddle Oven Burner Char Broiler Char Broiler Char Broiler Infrared Broiler Oven Burner Oven Burner LI Oven Burner Infrared Broiler Infrared Broiler Infrared Broiler Controls Burner Knobs Oven Door Thermostats Alignment Char Broiler Door Seal Convection Oven Fan amp Switch Hinges Oven Light Switch Customer Copy Intertek Intertek 13592 Desmond St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free www americanrange com Owner s Manual AR Series Ranges OwALITY OPERATING INSTRUCTIONS Before lighting check all joints in the gas supply line for leaks DO NOT USE OPEN FLAME TO CHECK FOR LEAKS Use soap and water solution TO CHECK FOR GAS LEAKS USING A SOAPY WATER SOLUTION Turn pilot valves to OFF position by turning adjustment screws clockwise 2 Turn ON the manual gas valve at the inlet side of the gas supply line 3 Check for gas leaks at the flexible coupling or gas
6. St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free www americanrange com WARRANTY REQUIREMENT For reliable operation and for your own safety this professional cooking equipment must be installed by a certified licensed contractor Failure to comply will void any written or implied warranty Should the equipment require service during the standard warranty period the receipt proving certified installation must be made available to American Range for verification If installation was not performed by a certified licensed contractor be prepared to submit a major credit card for payment for proper installation prior to service DESIGNED amp BUILT IN USA m 13592 Desmond Street Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free AMERICAN SSRANGE QUALITY COOKING EQUIPMENT Www americanrange com R70028 020612
7. connector fitting using a solution of one part soap and three parts water 4 Sparingly spray or brush the soapy solution at the gas fittings active bubbling indicates location of gas leak 5 Ifa gas leak is detected turn off the manual gas valve at the inlet side of the gas line Call your certified and licensed service technician OPEN BURNER GRIDDLE RAISED GRIDDLE BROILER PILOT ADJUSTMENT SCREW Turn pilot adjustment screw counter clockwise then light standing pilot and adjust flame 1 4 high 2 Turn ON gas valves to light main burners 3 For complete shut down shut off gas valves and turn pilot adjustment screw clockwise to shut off gas to the pilots OVEN MORE GAS Turn thermostat to the OFF position Wait five minutes Access the burner compartment by lifting up the kickplate and rotating forward to expose the safety valve Push in and hold the safety valve button at the bottom of the oven Light the pilot by repeatedly pressing the piezo electric ignition button keep safety valve button pressed in until the pilot stays lit when released 6 If pilot goes out repeat steps 2 5 7 Setthermostat to desired temperature 8 Turn the thermostat to the OFF position for complete shut down shut off main gas valve Un d w B2 LIGHTING INSTRUCTIONS FOR GAS FIRED CONVECTION OVENS Before attempting to light this appliance the cover if so equipped should be open 2 Turn OFF the manual gas valve
8. in severe DAN G E R personal injury or death WARN N G Hazards or unsafe practices which may result in severe personal injury or death CAU T Hazards or unsafe practices which may result in minor personal injury or property damage SHIPPING DAMAGE CLAIM PROCEDURE The equipment is crafted and inspected carefully by skilled personnel before leaving the factory The transportation company assumes full responsibility for the safe delivery upon acceptance of the equipment If you receive a damaged product immediately contact your delivery company your dealer your builder or installer Do not install or attempt to operate a damaged appliance Note any visible loss or damage on the freight bill or express delivery and have the note signed by the person making the delivery 2 File claim for damages immediately regardless of the extent of damages 3 For damage noticed after unpacking concealed loss or damage notify the transportation company immediately and file a Concealed Damage claim with them This should be done within fifteen 15 days from the date that delivery is made to you Retain the shipping container for inspection CALIFORNIA PROPOSITION 65 WARNING The burning of gas cooking fuel generates some by products which are on the list of substances known by the State of California to cause cancer or reproductive harm California law requires businesses to warn customers of potential exposure
9. to back and side to side If the unit is not level cakes casseroles and any other liquid or semi liquid batter will not bake evenly burner combustion may become erratic and the unit will not function properly If the kitchen floor is relatively smooth and level the unit may be leveled by turning the foot section of the leg since casters are not adjustable Identify the high corner and level the unit if the adjustment required exceeds the 1 4 limit use metal shims CAU T When lighting the gas oven DO NOT stand with your face close to the combustion chamber All American Range Corporation appliances are adjusted and tested before leaving the factory effectively matching them to appropriate atmospheric conditions We recommend that adjustments and calibrations are performed upon installation to assure proper operation of the unit and avoid possible problems caused by rough handling or vibration during shipment This work must be performed only by qualified service personnel These adjustments are the responsibility of the customer and or dealer and are not covered by warranty Check all gas connections for leaks with a soapy water solution before lighting the oven DO NOT USEAN OPEN FLAMETO CHECK FOR LEAKS Putting an open flame beside a new gas connection is extremely dangerous and may result in serious injury or death Intertek Intertek 13592 Desmond St Pacoima CA 91331 818 897 0808 tel 888 753 989
10. 0 5SL 2 AR SAG 27 R14020 Burner Bake Oven ARROB ARRSB AR Ranges 28 A44003 Nut Speed 6 Push Black 10601 25 26 30 A38000 Name Plate American Range 8 Quality Commercial Chrome 32 A32001 Knob Gas ON OFF Glossy Black 34 A80109 Valve Gas Manual ON OFF UL 10419 36 A29301 Valve Dual Gas Pilot 1 8 X 3 16C 37 A24000 Elbow Orifice Mixr 3 8C 3 8 27 10442 38 A99713 Bracket Orifice Bracket ARC A29000 Orifice Hood 39 1 2 Brass 11039 A29007 Orifice Hood 53 1 2 Brass 39 DD d Intertek Intertek 13592 Desmond St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free www americanrange com Owners Manual AR Series Ranges AMERICANS RANGE TROUBLESHOOTING GUIDE POSSIBLE CAUSE SUGGESTED ACTION SYMPTOM Heating elements do not come on Unit is not connected to gas or electrical service Visually check unit is wired to gas or electrical service Thermostat is set to very low temperature Set temperature to desired value May not have been on long enough SYMPTOM Oven does not reach selected temperature Unit preheats to 350 F in about ten minutes Thermostat may be defective Unit will require service Too little gas pressure dirty gas line Call for authorized service SYMPTOM Convection fan does not operate Unit is n
11. 13100 Term 51 A11200 Pilot Tip Assembly Short New Front Open Burner AR Series A80110 Valve Pressure Regulator 3 4 Natural Gas 52 A11201 Pilot Tip Assembly Long New Front Open Burner AR Series 6 A80011 Valve Pressure Regulator 3 4 LP Gas 53 A14037 Air Shutter 2 10464 7 28032 Elbow 3 8 Compression Brass 54 A14025 Burner Venturi Short Only 10446 8 A80101 Solenoid Valve Safety Gas 115V 55 A17000 Grate Top 12 X 12 Cast Iron 10450 122 9 A29303 Elbow 3 16CC 1 8COMPC Brass 10 A28038 Elbow Brass 3 8CC X 3 8 MNPT 11 A15037 Manifold Pipe Convection AR 12 A35014 Caster 4 Swivel Plate Mount No Brake NSF AR AGBU ACB 13 A35015 Caster 4 Swivel Plate Mount W Brake NSF AR AGBU ACB 14 A35001 Leg 6 Cone 3 Adjustable Bullet Chrome Plated NSF 15 A11105 Thermostat KXT Electric M MSD 16 A60001 Timer Cooking 60 Minute 10408 M MSD ARC 17 A99713 Bracket KXT Thermostat M MSD 1330 ARC 18 A32017 Knob Timer M MSD Series 19 A32005 Knob Dial KXT Thermostat 10411 M MSD Series ARC SAG 20 A32012 Bezel BJ Thermostat 21 A10011 Light Indicator 120V Red 12 7 10407 W Wire Lead amp Male Term 22 A10002 Switch Rocker ON OFF Innovection Oven 23 A28020 Nut Reducer 1 4 3 16CC 10428 24 A28021 Sleeve Ball 3 16 Tube Barrel A11118 Orifice Bell 018 AR AF Nat Gas A11110 Orifice Bell 010 LPG Gas A11104 Pilot Nat Gas 018 5SL 2 AR SAG A11132 Pilot LP Gas 01
12. 8 toll free www americanrange com Owner s Manual AR Series Ranges TYPICAL MODEL amp PARTS IDENTIFICATION OVEN BURNER ON LIGHT LEFT LEFT CENTER CENTER RIGHT RIGHT REAR FRONT REAR FRONT REAR FRONT OVEN THERMOSTAT CONVECTION INNOVECTION I Pilot 2 High Shelf 3 Grates 4 Ignition 5 Door 6 Burner Valves Intertek Intertek 13592 Desmond St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free www americanrange com Owners Manual AR Series Ranges Y COOKING ROGIFNAMT INSTALLATION CHECKLIST This checklist has been developed to assure proper installation of your oven To validate warranty you must mail e mail or fax this form and a copy of your receipt to AMERICAN RANGE CUSTOMER SERVICE 13592 DESMOND STREET PACOIMA CA 91331 service americanrange com 818 897 8839 FAX Street Purchase Date City State Zip Code Installation Date E mail Installers Name Telephone Company Dealer Telephone CHECK ALL THAT APPLY Appearance and Aesthetics Electrical Connection Exterior Correct voltage section Grounded outlet
13. 96 Latest Edition GENERAL EXPORT INSTALLATIONS Installation must conform to Local and National Standards Local installation codes and or requirements may vary If you have any questions regarding the proper installation or operation of your American Range Convection Oven please contact your local distributor If you do not have a local distributor contact American Range Corporation at 1 888 53 9898 or visit us at www americanrange com ELECTRICAL CONNECTION The standard gas operated convection ovens require a 120 VAC 60 Hz 15 AMP electrical service for operation The supply cord provided on the appliance is equipped with a three prong grounding plug for protection against electrical shock hazard The electrical service in the building must be equipped with a properly grounded three prong receptacle in accordance with local codes or in the absence of local codes with the National Electrical Code ANSI NFPA 70 or in Canada to Canadian electrical codes CSA 22 2 Do not cut or remove the grounding prong from this plug ELECTRICAL GROUNDING INSTRUCTIONS The appliance is equipped with a three prong grounding plug for your A WARN N G protection against electrical shock hazard and should be plugged directly into a properly grounded three prong receptacle Do not cut or remove the grounding prong from the plug f N For gas fired 120VAC units and any NEC compliant receptacle proper ground and correct CAUTION polarity is re
14. A 91331 818 897 0808 tel 888 753 9898 toll free Intertek Intertek Owners Manual AR Series Ranges AMERICANS RANGE OEALITY COOKING ROZIFNAMT ITEM ITEM PART Quality Commercial Chrome Intertek Intertek 13592 Desmond St Pacoima CA 91331 12 NO PART NO DESCRIPTION NO NO DESCRIPTION 8 A14023 Burner Head Lift Off Standard AR 48 A32012 Bezel BJ Thermostat 10440 9 A14024 Burner Venturi Long Only 10447 50 A32001 Knob Gas On Off Glossy Black Flat Down 10 A99585 Hanger Burner AR Series 1180 A53034 Tube Handle AR6 Heavy Duty SS 049W 1 1 4 x 27 75 180 11 A29301 Valve Dual Gas Pilot 1 8 x 3 16C 10432 51 am 12A A11200 Pilot Tip Assembly Short New Front Open Burner AR Series e E PUY 12B A32012 Pilot Tip Assembly Long New Rear Open Burner AR Series A99500 Door AR 6 36 Oven Assembly 10214 36 Heavy Duty 13 A14037 Air Shutter 2 10464 52 Construction 14 A14025 Burner Venturi Short Only 10446 A99649 Door AR 4 Oven Assembly 10214 24 Heavy Duty Construction 15 A17000 Grates Top 12 x 12 Cast Iron 10450 12 53 A47002 Rivet 3 16 x 1 8 Steel 16 A99317 Flue Oven AR Ranges 10207 5A A32150 FE Door Handle Heavy Duty 18164 Chrome Plated AR 17 e Valves IEF GaS SELT H A99010 F
15. AMERICAN RANGE QUALITY COOKING EQUIPMENT PROFESSIONAL QUALITY COOKING EQUIPMENT OWNER S MANUAL FOR RESTAURANT SERIES RANGES AR SERIES AR C SERIES AR NV SERIES DESIGN CLASS FUNCTION 2012 American Range MI lh All Rights Reserved 13592 Desmon d St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free www americanrange com Intertek Intertek AR Series Ranges Installation Operation and Owner s Manual Maintenance Instructions ex FOR YOUR SAFETY Do not store or use gasoline or other flammable vapors or liquids in the vicinity of this or any other appliance WARNING Improper installation adjustment alteration service or maintenance can cause property damage injury IMPROPER or death and will void warranty Read the IMPROPER INSTALLATION installation operating and maintenance instructions INSTALLATION thoroughly before installing or servicing this equipment IMPORTANT SERVICE NOTICE Using any part other than genuine American Range factory supplied parts relieves the manufacturer of all liability American Range reserves the right to change specifications and product design without notice Such revisons do not entitle the buyer to corresponding changes improvements additions or replacements for the previously purchased equipment Instruction to be followed in the event the user smells gas should be posted in a prominent loc
16. at Gas 018 5SL 2 AR SAG 10413 A11132 Pilot LP Gas AR Series Ranges 10413L SAG 41 A23010 Plug 1 8 Pipe Hex Black All Manifolds A15000 Manifold 36 AR Range Standard A15006 Manifold 24 AR Range Standard 42 A15013 Manifold 48 AR Range Standard A15014 Manifold 60 AR Range Standard A15016 Manifold 72 AR Range Standard 43 A44003 Nut Speed 6 Push Black 10601 44 A80109 Valve Manual On Off UL 10419 AR ARKB ARRB AECB 45 A38000 Name Plate American Range 8 10499 DESIGNED amp BUILT IN USA 818 897 0808 tel 888 753 9898 toll free www americanrange com Ta o0 e ad 0 iv CE lt Owners Manual AR 6NV TL V Qe DESIGNED amp BUILT IN USA 13 com nge www americanral 13592 Desmond St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free Owner s Manual AR Series Ranges QUALITY COOKING ROGIFNAMT AR 6NV ITEM ITEM PART NO PART NO DESCRIPTION NO NO DESCRIPTION 1 A91100 Motor Innovection Fan Assembly ARR Range Series NV 40 A14049 Air Shutter 1 Ranges 41 A31025 Rack Oven AR6 26 3 8 X 20 7 8 47 A14023 Burner Lift Off Head Standard 48 A14024 Burner Venturi Long Only 10447 A91206 Fan Blade Innovection Motor 4 A91202 Blower Baffle Cord Power NEMA 5 15P SJT 16 3 6 Black Roj 5 1 2 GRN 10 5 A
17. ation This information should be obtained by consulting the local gas supplier RETAIN THIS MANUAL FOR FUTURE REFERENCE This equipment is design engineered for commercial use only Model Number Serial Number Purchase Date Installed By Install Date Gas Type Electrical Information Intertek Intertek 13592 Desmond St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free www americanrange com AMERICAN S amp S RANGE QUALITY COOKING EQUIPMENT PROFESSIONAL QUALITY COOKING EQUIPMENT To Our Most Valued Customer Congratulations on your purchase of an American Range product We hope you will enjoy the design manufactured quality innovative features and cooking performance of this product it represents our continuing dedication to satisfying the most demanding needs of customers like you Please read this manual and become familiar with important safety information about how to install and set up the unit basic operating instructions and how to maintain that just like brand new appearance and performance over years of day to day use If you should encounter any sort of problem turn to the section of the manual entitled Troubleshooting for a quick solution or guidance regarding the next step required to get back to tip top condition Thank you for choosing an American Range product for your kitchen As you can expect this appliance is designed for years of reliable service If you have an
18. ay interfere with the pilot or main burner performance and can also be hard to diagnose If pilot burner or main burner outage problems persist make up air openings or baffles may have to be provided in the room INSTALLATION GAS STANDARDS AND CODES IMPORTANT The installation of this appliance must conform to local codes or in the absence of local codes with the National Fuel Gas Code ANSI Z223 Natural Gas Installation Code CAN CGA B 49 or the Propane Installation Code CAN CGA BI49 2 as applicable including The appliance and its individual shut off valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressure in excess of 1 2 psi 3 45 kPa 2 The appliance must be isolated from the gas supply piping system by closing the individual manual shut off valve during any pressure testing of the gas supply piping system The appliance when installed must be wired and electrically grounded in accordance with local codes or in the absence of local codes with the National Electric Code ANSI NFPA 70 or the Canadian Electrical Code CSA C22 2 as applicable PN DANGER A manual gas shut off valve must be installed in the gas supply service line ahead of the appliance and gas pressure regulator in the gas stream for safety and ease of future maintenance service 2 The gas pressure regulator supplied with the appliance must be installed prior to connectin
19. de only by qualified and licensed service personnel with the proper calibrated test equipment Gas connections should be performed by a qualified licensed contractor DESMOND ST en CA 91331 58 D D Intertek Intertek 3013256 MODEL AR 6 C lt SERIAL NO 999999999 GAS TYPE MAN PRESS SO IN w C INNOVECTION V 120 1 A3 CYCLE CONVECTION V 120 1 Al5 CYCLE g A INPUT BTU HOUR BURNER CLEARANCES RATING PLATE The information on the rating plate defines the model inoue Cuib f OPEN TOP 32000 SM OVEN 27000 p a ooa serial number gas type natural or liquid propane operating pressures and burner GRIDDLE 20000 ST ovens Spes o BTU ratings Keep this information for future reference It is essential for proper HoTTOP 20000 oven 59000 i i LI i 1 FOR USE ONLY ON NONCOMBUSTIBLE FLOORS identification of the unit when requesting additional information or factory support CURE MOUNT MUST HAVE gt OVERHANG INTENDED FOR OTHER THAN HOUSEHOLD USE ANSI Z83 11a CSA 1 8a 2007 Food Service Equipment Rating Plate A WARN G Appliances must be connected only to the type of gas identified on the rating plate tn N f US Intertek Intertek 13592 Desmond St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free www americanrange com
20. g the equipment to the gas supply line Failure to install a regulator will void the equipment warranty and result in a potentially hazardous condition 3 Please contact the factory a factory representative or local service company to perform maintenance and repairs Intertek Intertek 13592 Desmond St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free www americanrange com DRALITY COOKING ROZIFNAMT Owner s Manual AR Series Ranges GAS CONNECTION The single deck oven requires one gas connection the double deck oven requires two gas connections The gas inlet line size of this appliance is 3 4 NPT For proper operation the gas service supply line must be the same size or greater than the inlet line size of the appliance MANUAL SHUT OFF VALVE A gas pressure regulator and a contractor supplied shut off valve must be plumbed in the gas service line ahead of the appliance in a physical location where it can be reached quickly in the event of an emergency NATURAL GAS LP GAS A Gas pressure regulator A Gas pressure regulator YE B 90 Street elbow B 90 Street elbow C Adapter must be 3 4 male pipe thread C Adapter must be 3 4 male pipe thread D Flexible connector D Flexible connector D C E E Manual gas shut off valve E Manual gas shut off valve a a i F 3 4 gas supply F 3 4 gas supply A H Step down regulator
21. hot water to loosen the material then use a wood or nylon scraper Contact the factory factory representative or a local service company to perform maintenance and repairs MAINTENANCE SUMMARY Never attempt to run oven with motor off l 2 Cool down after cooking is finished 3 Periodically lubricate the pivot pins of the oven door hinge Use a multi purpose lubricating oil sparingly 4 Door chain assembly and door bushing must be inspected periodically and adjusted or replaced to ensure satisfactory operation of doors 5 Clean the burner air shutter and burner chamber Remove any accumulation of debris by hand 6 Check blower wheel for any accumulation of debris Remove by hand do not use any tools 7 Replace burned out light bulbs 8 Excessive use will result in excessive wear and tear ED E se lo ae NE ITITFTETYTETITITETTTTTIY Intertek Intertek 13592 Desmond St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free www americanrange com AMERICANS RANGE OWALITY COOKING ROSGIFNAMT Intertek Intertek 13592 Desmond St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free www americanrange com Ta o0 e ad v C LY CE Owners Manual DESIGNED amp BUILT IN USA com ge www americanran 13592 Desmond St Pacoima C
22. located at the outlet side of the gas supply line 3 Turn the manual gas supply valve to the OFF position 4 Setthe thermostat to the OFF position 5 6 7 Press the power switch to the OFF position Wait five minutes This appliance is equipped with an automatic spark ignition device which automatically lights the burner Do not try to light the burner with a match Turn the manual gas supply valve to the ON position Press the power switch to the COOK position Set the thermostat to the desired temperature The direct spark ignitor will light the burner If burner does not light go back to steps 2 9 above and repeat the process If the problem persists call your factory personnel The cover if so equipped should be placed in the closed position 12 If gas odor is detected turn off the gas valve and follow lighting instructions beginning from step O DD i Intertek Intertek 13592 Desmond St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free www americanrange com Owner s Manual AR Series Ranges WALITY COOKING TO SHUT DOWN THE GAS FIRED CONVECTION OVEN Setthe thermostat to the OFF position 2 Press the power switch to the OFF position 3 Turn the manual gas supply valve to the OFF position FINAL PREPARATION On initial installation turn the oven thermostat to 250 F and operate the unit for about one hour then reset the thermostat to its
23. n film Wipe off any excess oil with a cloth Turn burner on very low and allow oil burn off Repeat the procedure three times before regular use Remove and empty grease pan Clean thoroughly and replace Remove rack and grease pans Clean with soap and water Wipe the inside clean Clean griddle plate with warm soapy water Rinse with warm water Turn griddle on and rinse again with warm water to boil out any soap left at the edges of the griddle plate Repeat step one after cleaning process Un dS CU P2 Periodic Remove burner assembly and clean with warm water and wire brush Make sure the tiny burner ports are not clogged 2 Remove griddle plate assembly and thoroughly scrape and clean the underside OVEN Daily Wipe clean the inside of the oven 2 Remove oven racks and clean with soap and water 3 Reassemble after cleaning 4 Remove racks and rack guides convection oven and clean Periodic Remove burner and clean with warm water and wire brush Make sure the tiny burner ports are not clogged 2 Check the rear flue way and clean if any debris exists STAINLESS STEEL PARTS Do not use steel wool abrasive cloths cleansers or powders to clean Stainless Steel surfaces All Stainless Steel parts should be wiped regularly with hot soapy water during the day and a Stainless Steel liquid cleaner at the end of the day To remove encrusted materials soak in
24. ot connected to electrical service Visually check unit is wired to electrical service Power switch is off Move switch to ON position Circuit breaker is tripped Reset the breaker observe operation SYMPTOM General baking problems Unit set to standard bake temperature Set unit to lower convection bake temperature operate for shorter time Thermostat out of calibration Unit will require service WARNING Always disconnect the electrical power service before cleaning or servicing the range Intertek Intertek 13592 Desmond St Pacoima CA 91331 15 DESIGNED amp BUILT IN USA 818 897 0808 tel 888 753 9898 toll free www americanrange com AMERICANS RANGE OWALITY COOKING ROSGIFNAMT Intertek Intertek 13592 Desmond St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free www americanrange com AMERICANS RANGE OWALITY COOKING ROSGIFNAMT Intertek Intertek 13592 Desmond St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free www americanrange com AMERICANS RANGE OWALITY COOKING ROSGIFNAMT Intertek Intertek 13592 Desmond
25. quired Electric convection ovens are configured at the factory for operation from 208 VAC single e phase or 208 VAC three phase electrical service is also an available configuration Consult wiring diagram located at the end of this manual and on the back side of the appliance NO GOOD U 120 VAC POLARITY SPECS ASSA J No attempt should be made to operate this appliance during an electrical N e service failure The appliance is not capable of operation without specified gas and electric requirements 4 DESIGNED amp BUILT IN USA Intertek Intertek 13592 Desmond St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free www americanrange com Owners Manual AR Series Ranges SALITY COOKING ROGIFNAMT CASTER INSTALLATION When installing provided casters match holes on the caster with holes on the oven bottom base and fasten with the hardware provided Locking type casters must be installed in the front Ovens with casters must be installed with the locking front casters supplied a flexible connector complying with ANSI Z2 1 69 CGA6 16 and a quick disconnect device complying with ANSI Z21 41CGA 6 9 Adequate means must be provided to limit the movement of the appliance without depending on the connector and the quick disconnect device or its associated piping to limit the appliance movement LEVELING A carpenter s spirit level should be placed on the oven floor and the unit leveled both front
26. rame Door AR 36 Assembly w Rod Spring Hinges and Cotter A80110 Valve Pressure Regulator 3 4 10480 Nat Gas Set 5 Pin 18 A99602 Channel High Rise AR Range 1037 Standard m A99023 Frame Door AR 24 Assembly w Rod Spring Hinges and Cotter 20 A99314 Bracket Top Grate w Support 1181 Short Aluminized Metal Pin 21 A99315 Bracket Top Grate w Support 1182 Long Aluminized Metal A939931 1020 24 22 A14048 Burner amp Deflector Assembly 59 A99532 Crumb Tray 36 AR 6 ARHP 36 1026 36 23 A28000 Fitting 3 8 CC x 1 4 Brass 10011 A99533 Crumb Tray ARHP 48 SUHP 48 1026 48 AR 8 Range m A11101 Thermostat BJ Griddle Gas Oven 10421 1 Outlet A31020 Rack Oven ARA 20 7 8 x 19 7 8 1321 24 NSF Chrome Plated BJWA25PB 04 48 A31025 Rack Oven AR6 26 3 8 x 20 7 8 1321 36 Chrome Plated 25 A23100 Nipple Flanged BJ Thermostat 10012 A29000 Orifice Hood 39 1 2 Brass 11039 A29007 Orifice Hood 53 1 2 Brass 27 A14049 Air Shutter 1 Oven Burner 10474 AR Range 28 R14020 Burner Bake Oven ARROB ARRSB 29 A11100 Thermocouple 18 20 AR Range 10485 32 A35001 Leg 6 Cone 3 Adjustable Bullet Chrome Plated NSF 33 A35014 Caster 4 Swivel Plate Mount No Brake NSF AR AGBU ACB 34 A35015 Caster 4 Swivel Plate Mount w Brake NSF AR AGBU ACB 37 A80100 Valve Safety TS 11J AR Ranges 10425 38 A24001 Elbow Orifice Mixr 1 4Px3 8 27 10010 39 A10010 Ignitor Piezo amp Locking Nut 10434 A11104 Pilot N
27. to such substances minimize exposure to these substances always operate this unit according to the Owners Manual ensuring you provide proper ventilation when cooking with gas td Intertek Intertek 13592 Desmond St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free www americanrange com Owner s Manual AR Series Ranges DRALITY COOKING ROGIFNAMT INSTALLATION INSTALLATION OPERATION AND SERVICE PERSONNEL Installation of the equipment should be performed by qualified certified licensed and or authorized personnel who are experienced in state local installation codes Operation of the equipment should be performed by qualified or authorized personnel who have read this manual and understand and are familiar with the functions of the equipment Service of the equipment should be performed by qualified personnel who are knowledgeable with American Range products VENTILATION HOODS Means must be provided for any commercial heavy duty cooking appliance to exhaust combustion waste products to the outside of the building Usual practice is to place the unit under an exhaust hood Filters and drip troughs should be part of any industrial hood Consult local codes before constructing and installing a hood Room air movement should be monitored during installation Strong exhaust fans in the hood or in the overall air conditioning system can produce a slight vacuum in the room and or cause air drafts either m
28. y questions or comments please contact the dealer from whom you purchased the unit or contact American Range Customer Service via email info americanrange com at www americanrange com or call 888 753 9898 Sincerely President American Range Corporation Dp Ij ie Desc LRU anion gren Intertek Intertek 13592 Desmond St Pacoima CA 91331 818 897 0808 tel 888 753 9898 toll free www americanrange com Owners Manual Table of Contents GENERAL DR E lS CER aistia Important E Shipping Damage Claim Procedure ee P n 2 7 Installation Operation amp Service Personnel 2 bcn usus e 2 Gas Standards and Codes 2 85 3 Manual 3 Rating ui TM 3 Electric Standard odes aue donde sius 4 dcc 5 S pe OL E 5 Typical Model amp Parts Identification 6 Installation er 7 OPERATING 8 9 Check for Gas US cps iain cease cetaceans eee 8 Open Burner Griddle Raised Griddle 8 ee BM 8 Lighting Conve chien OVen 8 Shut Down Convection Oven acted 9 tud atem lam assets 9
Download Pdf Manuals
Related Search