USER`S MANUAL - Sears PartsDirect
Contents
1. USER S MANUAL MODEL NUMBER PG 50506SRLA SC CUSTOMER SERVICE A DANGER If you smell gas i 2 Er 4 Shut off gas to the appliance Extinguish any open flame Open lid If odor continues keep away from the appliance and immediately call your gas supplier or your fire department id inar buc i Minime PR 888 287 0735 A WARNING Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance2. Model Number PG 50506SRLA SC PermaSteel BBQ Grill Island PERMASTEEL INC Warranties that this Product shall be free from defects in workmanship and materials for a period of 1 Year from the date of original purchase Our obligation under this warranty shall be limited to replacement of parts during the warranty period Our liability shall not extend beyond replacement of parts This warranty excludes normal wear amp tear such as paint loss discoloration and rust on the Product and its parts or components and any damage arising from any of the following negligent use or misuse of the Product use contrary to this User s Manual or alteration by any one other than Permasteel Inc All warranty coverage is void if this grill is ever used for commercial or rental purposes this warranty is valid only in the USA The warranty period of 1 year shall not be extended or renewed by the repair or replacement of parts or compensation for the Product If your Product is defective or otherwise requires service or parts please call Permasteel Customer Service toll free at 888 28 0 35 between 8 00 a m and 5 00 p m PST Consumer is responsible for shipping handling and
3. Gm au PI m wem o 3 3 mmm 7 x Wemememsmr 7 essa 2 pex L3 meme 3 ope 3 s pem L5 S peeses 5 Cx eem L3 pene L Ejs E 5 peine 7 ws peemem O Jeememmx 7 x pesem O serm 7 5 pemamem 7 5 ttn Pane 5 pese me E 7 LN peers 2 pesme 70 7 5 pesas E peweemmesu Lm peeswssss oases 7 Lz peeesexm A pem 7 Right Side Panel Door NN Hole Bushing Left Door Hinge Upper aM Grease Tray Heat Shield Regulator EN 6 7 8 9 30 31 32 33 34 35 NM MP n NI N Al AP a oy REFZ Parts of Left Cabinet 21 Right CounterTop 22 Back Panel 23 24 25 26 Drawer Brackets 27 28 Drawer Seat 29 Drawer Transom 30 Inside Side Panel 31 Drawer Front
4. PRODUCT REGISTRATION First Name Last Name Address City State Zip Code Email Address Phone Product Model Date of Purchase Retail Store Location of Purchase s S US p SSS d ES BEE ERS m Please rate the importance of each feature 1 least important 10 most important Quality Price oize Capacity Cooking Area Appearance Other 5 What other brands did you seriously consider before making this purchase DCS_ CharBroil_ Brinkman_ Members Mark Lynx Other Did not consider other brands How did you hear about our product Magazine Ad Catalog Salesperson Word of Mouth Internet Store Display Other Marital Status Single Married Household Income Below 50 000 50 000 150 000 150 000 _ Education High School College Graduate School Primary Residence Own Rent Comments Suggestions os Se alll TRO ER
5. GARAGE OR ANY OTHER ENCLOSED AREAS 6 TURN OFF ALL CONTROL KNOBS AND LP TANK VALVE WHEN THE D GRILL IS NOT IN USE D 7 IF THE APPLIANCE IS STORED INDOORS THE LP TANK MUST BE DISCONNECTED AND REMOVED FROM THE GRILL 8 LP TANKS MUST BE STORED OUTDOORS IN A WELL VENTILATED AREA DISCONNECTED LP TANKS IN STORAGE OR BEING TRANSPORTED MUST HAVE A SAFETY CAP 9 NEVER LEAVE A LP TANK IN A RECREATIONAL VEHICLE OR BOAT WHICH MAY BECOME OVERHEATED BY THE SUN 10 DO NOT STORE LP TANK IN OR NEAR AN AREA WHERE CHILDREN PLAY 11 FOR ANY OTHER PROBLEMS SEE TROUBLESHOOTING OR CONTACT OUR SERVICE CENTER AT 888 287 0735 At least 36 clearance maintained from combustible constructions to the sides and back of this grill There is no unprotected combustible construction material over the grill c All internal packaging removed Burners are sitting properly on orifices Knobs turn freely The regulator amp hose connected to grill are provided by the manufacturer Pre set for 11 0 water column Unit tested and free of leaks ARM d d d d location
6. E o EN SERRA As Ba NS RE o E SAS SSS VERY IMPORTANT ALWAYS INSPECT THE HOSE PRIOR TO EACH USE BEFORE LIGHTING Inspect the gas supply hose before turning the gas ON If there is evidence of cuts wear or abrasion it must be replaced before use The replacement hose assembly must be that specified by the manufacturer VERY IMPORTANT TO LIGHT MAIN BURNERS OF THE GRILL 1 Read instructions before lighting 2 Turn all knobs to OFF then open the LP tank valve Always keep your face and body as far from the grill as possible when lighting 3 Open lid during lighting 4 Push and turn any control knob slowly to HI position The built in igniter will click and spark simultaneously to light the pilot and burner in sequence Turn the control knob to OFF IMMEDIATELY if the burner does not light within 5 seconds Wait 5 minutes for gas to dispel then repeat the lighting procedure 9 Follow match lighting instructions if burner can t be lit after repeating 3 4 times E TO LIGHT THE MAIN BURNERS BY MATCH AS THE FOLLOWING FIGURE SHOWS If the burner will not light after several attempts then the burner can be match lit Tools Lighting rod hanging behind the right door Usage 1 Read instructions before lighting 2 Open the lid during lighting 3 Strike the match and pl
7. A CAUTION Clean the grill often A grease fire that may damage the grill may occur if the grill has not been cleaned frequently NEVER leave the grill unattended while using z Do not use water to extinguish the grease fire it may cause body injury Turn knobs off and LP tank off in case grease fire occurs Grease fire can t be put out by closing the lid Turn off knobs and LP tank IMMEDIATELY if any grease fire occurs A WARNING For your safety Keep grill area clear and free from any flammable material NEVER let children operate the grill or play near the grill This grill is for outdoor use ONLY NEVER use in a enclosed area such as a carport porch covered patio garage or under a surface that can catch fire Do not block the ventilation holes in the four sides of the grill cart it may affect the combustion performance of the burner due to insufficient air Use the grill at least 36 away from any wall or surface 120 away from objects that may spark and ignite gas i e live electrical appliances pilot lights of water heaters Do not use this grill on or under wood balconies This grill is designed to use only LP gas DO NOT use lava rock briquets charcoal on it NEVER light the burner with the lid closed Non ignited gas accumulated inside a closed grill may cause explosions Check the burner flames periodically Turn of
8. LO check the flame status the flame in LO position should be smaller than in HI position as figure shown below Always check flame before each use see TROUBLESHOOTING if any abnormal status found 4 Call our after service center at 888 287 0735 for warranty replacement parts MI D CLEANING o o 1 COOKING AREA CLEANING D The easiest way to clean the grill is to clean immediately after turning off the flame when cooking is completed Wear a barbeque mitt to protect your hand from the heat and steam Dip a brass bristle barbeque brush in tap water and scrub the hot grill Dip the brush frequently in the water Steam created as water contacts the hot grill assists the cleaning process by softening any food particles The food particles will fall and burn Never immerse a hot part in water 2 GREASE TRAY CLEANING The grease tray should be emptied and wiped down periodically and washed in a mild detergent and warm water solution A small amount of sand may be placed in bottom of the grease tray to absorb the grease 3 GRANITE CONTERTOP Use a high quality penetrating sealant made specifically for granite to protect granite countertops against stains and discoloration The sealant should be applied
9. Only use tanks equipped with this type of valve As the figure shown on the next page FOR YOUR SAFETY Ensure that the black plastic grommets of the regulator provided are in place and that the hose does not come into contact with the heat shield or the grill head CONNECT THE REGULATOR TO THE LP TANK VERY IMPORTANT THE REGULATOR SHALL NOT BE IN A LOCATION THAT WILL ATTAIN A TEMPERATURE ABOVE 140 F 607 THE REGULATOR SHALL INCORPORATE A PRESSURE RELIEF VALVE OR OVERPRESSURE DEVICE THE INLET OF THE PRESSURE REGULATOR SHALL BE FITTED TO CONNECT THE TYPE CONNECTION OF THE TANK VALVE PER ANSIZ21 81 1 Make sure tank valve is in its full off position turn clockwise to stop 2 Check tank valve to assure it has proper external male threads type connection per ANSIZ21 81 3 Make sure all burner knobs are in their off position 4 Remove the protective cap from LP tank valve Always use cap and strap supplied with valve 9 Inspect valve connection port and regulator assembly Look for a
10. Panel 32 Drawer Handle 33 Upper Door Hinge 34 Right Door Handle 3o 36 Door Transom 37 38 Right Door Hinge 39 40 T ER Peele he d 2 2 O 9 o jo S IS 212 F 1a 13 DID rt z o D O a ID olo UJ o ot O UJ Qo UJ U f z fe e N fo T ae s TE SE o Q 7135 D Uic U oi o A o D s V D REF 1 Parts of Left Cabinet Left CounterTop Back Panel Cross Bar Magnets Outside Side Panel Drawer Brackets 7 Sliding Bars Drawer Seat Drawer Transom 10 Inside Side Panel 11 Drawer Front Panel Casters without Brake Casters with Brake STEP I Take out grill body and the cabinets from packing carton and remove all the packing materials Terms ini e Tea Tn I I IER OO tin ii e Ma OO etes mm e ram a SK SSA c Dwar e e a ao RE m eee NNNM c NES SERA s TA b 7 VANUS SSIS D UU USE 6 k ll keep IS WI warming rac ds ing gri then place them in the proper positions shown below ND NOE NEN NAN up sn WO BAAS SL NS FIT NS We SA UN UNS Sm aa el h v pcs IH ORDRE n E a wi j COOk en RO le
11. processing of warranty claims after 30 days of purchase date As proof of purchase a copy of your original purchase receipt must accompany any service request Component Warranty Period Burners 1 Year Stainless Steel Flame Tamer 1 Year Cooking Grids 1 Year Valves 1 Year Frame Housing Cart Control Panel Igniter and Related Parts 1 Year All Stainless Steel Parts 1 Year Granite Countertop 1 Year LIMITATION OF REMEDIES AND LIABILITY We shall not be liable for any incidental or consequential damages for breach of any express or implied warranty on its Product Except to the extent prohibited by applicable law any implied warranty or merchantability or fitness for a particular purpose on this Product shall be limited to the duration of the above warranty Neither us nor anyone else who has been involved in the creation production or delivery of the Product shall be liable for damages of any type including but not limited to any lost profits lost savings loss of anticipated benefits or other incidental or consequential damages which may arise out of the purchase use or inability to use the Product whether arising out of contract negligence strict tort or under any warranty or otherwise even if you have been advised of the possibility of such damage or any other claim by any other party Our liability for any breach of warranty shall be limited to repair or replacement of the defective part or parts as described above S
12. PAGE 21 o O OO REA xem m n S Ye SS ERS RS SS S Ad Thank you for your purchase of our Stainless Steel BBQ Gas Grill We sincerely wish you will enjoy using our fine products Please read this User s Manual in its entirety before using the grill Please contact our customer service at 888 28 0 35 if you have any questions i Please read this User s Manual carefully Failure to follow the provided instruction can result in seriously bodily injury and or property damage Some parts of this grill may have sharp edges Please wear suitable protective gloves IMPORTANT This grill is intended for outdoor use only and is not intended to be installed in or on recreational vehicles or boats NOTE TO INSTALLER Leave this User s Manual with the customer after delivery and or installation NOTE TO CONSUMER Leave this User s Manual in a convenient place for future reference special attention to them The meaning of each of the symbols is listed here A DANGER this symbol indicates an imminently hazardous situation which will result in death or s
13. SSS GENERAL Although all gas connections on the grill are leak tested at the factory prior to shipment a complete gas tightness check must be performed at the installation site due to possible mishandling in shipment or excessive pressure unknowingly being applied to the unit Periodically check the whole system for leaks or immediately check if the smell of gas is detected BEFORE TESTING 1 Make sure that all packing material is removed from the grill including the burner tie down straps 2 Do not smoke while leak testing 3 Never leak test with an open flame 4 Make a soap solution with one part liquid detergent and another part water Prepare a spray bottle brush or rag to apply the solution to the connections For the initial leak test make sure the LP cylinder is full 5 Grill must be leak tested outdoors in a well ventilated area away from ignition sources such as gas fired or electrical appliances and flammable materials 6 Keep grill away from open flames and or sparks while testing Sas SSS SS Se m p CONDES SS SSR BENS EE EUM eS Ss TO TEST 1 Make sure all control knobs are in the OFF position 2 Make sure the regulator is connected to the LP tank tightly 3 Completely open LP tank valve by turning counter clockwise If you hear a POP sound turn gas off IMMEDIATELY as it indicates a heavy leak at the connection Call your gas dealer or fire department 4 Check every connection from the LP t
14. ace approximately 1 2 above lighting hole located on right and left hand side of the grill body 4 Push and turn the knob to HI position make sure the burner lights and stays lighted 9 Repeat 3 4 to light other burners 6 Keep a spray bottle of soapy water near the gas supply valve and check the connections before each use Do not light the grill if odor of gas is present call out service center at 888 28 0 395 FLAME CHARACTERISTICS 1 Check for proper burner flame characteristics Each burner is adjusted prior to shipment however variations in the local gas supply may take subtle necessary adjustments 2 Burner flames should be blue and stable with small yellow tips no excessive noise or lifting If any of these conditions exist call our customer service line If the flame is yellow it indicates insufficient air If the flame is noisy and tends to lift away from the burner it indicates too much air 3 Small yellow tips are ok o EE m SS Se BSS Re SS SESS ASS a 2 UU 3
15. ank up to and including the connection to the manifold pipe assembly the pipe that goes to the burner by brushing or spraying the soapy solution on the connections 9 If soap bubbles appear there is a leak Turn off LP tank valve IMMEDIATELY and retighten connections Open LP tank valve again and recheck 6 If leaks cannot be stopped DO NOT ATTEMPT TO REPAIR Call our service center at 888 287 0 35 for help 7 Always close the LP tank valve after leak testing by turning clockwise Only those parts recommended by the manufacturer should be used on the grill oubstitution will void the warranty Do not use the grill until all connections have been checked and do not leak EE SAFETY TIPS 1 ALWAYS CHECK FOR LEAKS AFTER EVERY LP TANK CHANGE 2 ALWAYS CHECK FOR LEAKS BEFORE EACH USE 3 USE LONG BBQ TOOL TO AVOID BURNS 4 CHECK ALL GAS SUPPLY FITTINGS FOR LEAKS BEFORE EACH USE IT IS HANDY TO KEEP A SPRAY BOTTLE OF SOAPY WATER NEAR THE SHUT OFF VALVE OF THE GAS SUPPLY LINE SPRAY ALL THE FITTINGS BUBBLES INDICATE LEAKS 5 DISCONNECTED LP CYLINDERS MUST HAVE THREADED VALVE PLUGS TIGHTLY INSTALLED AND MUST NOT BE STORED IN A BUILDING
16. ce with local codes or in the absence of local codes with the National Electrical Code ANSI NFPA 70 1990 or the Canadian Electrical Code CSA C22 1 Keep the power cord of the motor away from the hot surfaces of the grill while in use Remove and store the motor in a dry place when not in use This grill is safety certified for use in the United States and Canada only Never modify to use in other places Modification may cause serious bodily injury or property damage PermaSteel is not responsible for any modifications and all warranties will be void FOR YOUR SAFETY PLEASE READ THIS SECTION FIRST f you smell gas Shut off gas to the appliance Extinguish any open flame Open lid f odor continues keep away from the appliance and immediately call your gas supplier or your fire department Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance Any LP cylinder not connected for use should not be stored in the vicinity of this or any other a Em S cuu
17. center PROBLEMS POSSIBLE CAUSE SOLUTIONS Electrode deposited with Use clean swab and alcohol ta clean cooking residues Electrode wires are loose Reconnect or replace with new electrode or fall aff assembly with wires Orice blacked Check the orice for blockage Open the LP tank valve Replace LP tank valve Clear burner tubes Incarrect assembly Burner want light after turning and pushing the knobs Burner can t light by match He assemble between burner and valve Call aur customer service center at 888 28 7 07 35 5as hase bent ar kinked Smooth aut the hose Yellow or orange Incomplete combustion flame with gas odor P Low heat with knab in HI position Flare up Temp too high High winds Find a less windy placa Flame lifting Tao high ofa gas pressure Call the gas dealer O Flashback Bumer port blocked Clean burner port Turn aff knobs and LP tank valve Leave lid open Grease accumulated in Grease fire food and let fire burn out Clean the grill after cooling FETY 1 Always follow the following tips to enjoy safe and healthy outdoor grilling 2 Always use hot soapy water to wash hands surface
18. cooking time 1 Make sure the grill has been leak tested and is properly located 2 Remove any packing material 3 Light the grill burners using the instructions in this manual 4 Turn the control knob to HI and preheat the grill for 15 minutes 9 The grill lid is to be closed during the appliance preheat period 6 Place the food on the grill and cook to the desired doneness Adjust heat setting if necessary The control knob may be set to any position between HIP and LO f The grill is designed to grill efficiently without the use of lava rocks or briquettes of any kind Heat is radiated by the stainless steel flame tamers under the stainless steel cooking grids 8 The hot grill sears the food sealing in the juices The longer the preheat the faster the meat browns 18 MAINTENANCE 1 Keep the grill area clear and free from combustible materials gasoline and other flammable vapors and liquids 2 Keep the holes in the three sides of the cart clear and free from debris thus ensure the flow of combustion and ventilation air is unobstructed 3 Visually check burner flames as following Remove cooking grids and flame tamers Light burners Turn knobs from HI to
19. erious bodily injury if not properly followed A WARNING this symbol indicates a warning of potential serious bodily injury if the instructions are not strictly followed Please be sure to read and follow all these messages carefully A CAUTION this symbol indicates a potentially hazardous situation which may result in minor or moderate bodily injury if the instructions are not properly followed WARNING READ THIS SECTION FIRST BEFORE INSTALLING THE GRILL ps This grill is designed to use LP gas only Please use the grill with the regulator o supplied by PermaSteel Please only use LP gas z The installation of this appliance must conform with local codes or in the absence E of local codes with either the National Fuel Gas Code ANSI Z223 1 or o CAN CGA B149 1 Natural Gas Installation Code or CAN CGA B149 2 Propane o Installation Code 4 The LP gas supply cylinder is to be constructed and marked in accordance with the specifications for LP gas cylinders of the U S Department of Transportation DOT or the National Standard of Canada CAN CSA B339 Cylinders Spheres and Tubes for the Transportation of Dangerous Goods z If an external electrical source is utilized the outdoor cooking gas appliance when installed must be electrically grounded in accordan
20. f the gas supply when the grill is not in use Always turn off the LP tank completely and detach from the grill before moving TOTAL GAS CONSUMPTION Total gas consumption per hour of PG 50506SRLA SC grill with all burners on HP Main burners 60 000 Btu hr Total 60 000 Btu hr GENERAL USE OF THE GRILL The grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris Above the burners are stainless steel radiated The igniter knobs are located on the valve panel Follow the lighting instructions printed on the control panel USING THE GRILL Grilling requires high heat for searing and proper browning Most foods are cooked at the HI heat setting for the entire cooking time However when grilling large pieces of meat or poultry it may be necessary to turn the heat to a lower setting after the initial browning This cooks the food through without burning the outside Foods cooked for a long time or basted with a sugary marinade may need a lower heat setting near the end of the
21. ill Do not attempt to use a natural gas supply unless the grill has been reconfigured for natural gas use The installation of this appliance must conform with local codes or in the absence of local codes with either the National Fuel Gas Code ANSI Z223 1 or CAN CGA B149 2 Propane Installation Code LP TANK REQUIREMENTS THE LP TANK USED WITH YOUR GRILL MUST _ MEET THE FOLLOWING D 1 Measurement 12 30 5cm Diameter X 18 45 cm Tall p 2 Maximum Capacity 20lbs 9Kg o 3 Constructed and marked in accordance with the specification for LP gas cylinders of the U S Department of Transportation DOT or the National Se SSS Standard of Canada CAN CSA B339 Cylinders Spheres and Tubes for the o Transportation of Dangerous Goods See LP tank collar for marking o 4 Is arranged for vapor withdrawal 5 Includes a collar to protect the tank valve 6 Has no dents or rust A dented or rusty LP tank may be hazardous and should be checked by your supplier f Provides a shut ff valve terminating in an LP gas tank valve outlet specified as applicable for connection type QCC1 in the standard for compressed gas tank valve outlet and inlet connection ANSI CGA V 1 LP TANK VALVE USED MUST MEET THE FOLLOWING 1 Have type outlet compatible with regulator provided 2 Have safety relief valve 3 UL listed Overfill Protection Device OPD This OPD safety feature is identified by a unique triangular hand wheel
22. leak tested STOP and call the fire department if any leaks are detected If you cannot stop a gas leak close the LP tank valve IMMEDIATELY call LP gas supplier or the fire department A DANGER NEVER store a spare LP tank under or near grill or in an enclosed area NEVER fill the tank beyond 80 full An overfilled spare LP tank is dangerous because surplus gas may leak from safety relief valve The safety relief valve on a LP tank could activate to release gas and cause a fire The spare LP tank must have safety caps installed on the LP tank outlet If any gas leaks are found on the spare LP tank immediately step away from the grill and call the fire department VERY IMPORTANT DISCONNECT THE TANK WHEN THIS GRILL IS NOT IN USE To disconnect LP gas tank 1 Turn all the knobs off 2 Turn the tank valve off fully turn clockwise to stop 3 Detach the regulator assembly from tank valve by turning the quick coupling nut counterclockwise 4 Install the protective cap back onto the LP tank valve A ces ae T LSS V p ES RREO SUE SN RE o E SAS
23. n CNS NSS SEES NU e s Seen SS the desired location lock the caster brakes th e is in the grill unit in place for safe operation Remove packing material from flame tamers When the grill STEP Il Y S x p S SS STEP IV Place the side cabinets close to grill make them on the same line STEP VII a When the grill island is in the desired location lock the caster brakes of cabinets this will keep them in place for safe operation oo REN SOUTHERN Safety Notice The regulator hose should go through the U shaped bracket in order to prevent the hose from lifting up and touching the hot firebox Note if replacing regulator please make sure to put regulator hose through U shape bracket NN NX SA QT es NW NA SRAN e AEN AW Wy WS AA NNS a Vas CASA A WM NC SA SSAA Bb OS c iz E A Rab mn na NX S a 1 ONLY USE THE REGULATOR AND HOSE ASSEMBLY PROVIDED WITH THIS GRILL REPLACEMENT PRESSURE REGULATORS AND HOSE ASSEMBLIES MUST BE THOSE SUPPLIED BY THE MANUFACTURER E 57 This is a LP Liquefied Petroleum Gas configured gr
24. ny damage or debris Remove any debris Inspect hose for damage Never attempt to use damaged or plugged equipment Contact your local LP gas dealer for repair 6 When connecting regulator assembly to the valve hand tighten nut clockwise to a positive stop Do not use a wrench to tighten Use of a wrench may damage quick coupling nut and result in a hazardous condition As figure shown below OPD HAND WHEEL oM 7 Open tank valve fully counterclockwise Use a soapy water solution to check all connections for leaks before attempting to light grill If a leak is found turn tank valve off and do not use grill until a local L P gas dealer can make repairs A WARNING Never insert any foreign objects into the valve outlet It may damage the valve and cause leak leaking gas may result in fire explosion heavy body injury or even death Do not connect this grill to the self contained LP gas system of a motor home or camper trailer Do not use this grill until
25. ome states do not allow the exclusion or limitation of incidental or consequential damages so the above limitation or exclusion may not apply to you The above warranty gives you specific legal rights and you may have other rights which vary from state to state 5 P v O BEFORE YOU BEGIN MESSAGE TO OUR USERS ee eae a PAGE 1 SAFETY SYMBOLS imc e ae Oa SEDI PAGE 1 INSTALLATION amp SAFETY PRECAUTIONS USE EN PAGE 2 PROPANE amp GAS WARNING 777777 PAGE2 ASSEMBLY PARTS scopsisesceses bass Gs E LIE ELE PAGE 3 STEP 42 22222222 PAGES STEP II amp STEP III PAGE 7 STEP IV amp STEP Veossechseseseseesoecsessseeeeeesseer PAGES SAFETY NOTICE PAGES POST ASSEMBLY GAS CONNECTION 77777777777070007000007007070707707 7 77 PAGE 10 LEAK TESTING 7 7 77 7 7 77 7 7 7 70029 7 2 7 7 7 7 7 7 7 7 7 7 7 7 77 PAGE 13 FINAL INSTALLATION CHECK LIST PAGE 14 GRILL LIGHTING INSTRUCTION PAGE 15 OPERATING INSTRUCTION PAGE 17 CARE amp MAINTENANCE PAGE 19 TROUBLE SHOOTING PAGE 20 FOOD SAFETY 7 9 9 999 9 999 2 9 PAGE 21 GRILL STORAGE
26. periodically throughout the year For standard maintenance on granite countertops wipe with warm water or mild soapy water Cleaners made specifically for cleaning granite may be used as necessary Do not use vinegar cleaners that contain acid abrasive cleaners or furniture polish We suggest the following routine care Clean up spills immediately e Dust with an untreated cloth Use coasters Keep planters off the surface Always keep covered when not in use LIE oe z SPIDER AND INSECT WARNING Spiders and insects can nest in the burners after storing These nests can cause fires inside the tube or beneath the grill This is a very dangerous condition So always clean the burners before use WHEN TO LOOK FOR SPIDERS Inspect the burners at least once a year or immediately if any of the following conditions occur 1 Yellow flame with burning smell 2 Temperature wont rise 3 Heats unevenly 4 Burners make popping noises BEFORE CALLING FOR SERVICE Please check the following problems solutions before contact our service
27. s amp utensils after processing raw meat 3 Always separate raw meat from cooked foods to avoid cross contamination 4 Always use clean utensils to handle the food 9 Always cook the meat thoroughly to kill germs Use a thermometer to inspect the inner temp of the meat if necessary 6 Place the cooked foods and leftovers promptly into the refrigerator when done eating VERY IMPORTANT DO NOT LEAVE THE GRILL UNATTENDED WHILE COOKING GRILL STORAGE 1 Clean the grill 2 Store the grill in a well ventilated dry outdoor area Keep out of the reach of children when LP tank is connected to the grill 3 Store the grill in dry indoors ONLY after the LP tank is turned off and removed The LP tank must be stored outdoors out of the reach of children NEVER store the tank in a building garage or any other enclosed area 4 Put on the supplied vinyl cover if supplied 20 Thank you for purchasing the PermaSteel Grill In order to register your product to receive streamlined customer service please fill out the following Product Registration form and 1 fax the form and a copy of your receipt to FAX 909 287 0733 or 2 mail the form and a copy of your receipt to PermaSteel Inc 14231 Fern Ave Building 10 Chino CA 91710 r I l l l l i l i l i l l l I i l l l l l l l i I l i L
Download Pdf Manuals
Related Search