Instruction Manual for HK
Contents
1. distributed by RESTROOM DIRECT 704 937 2673 www RestroomDirect com Operating Instructions and Parts Manual H an d D rye rs Operating Instructions and Parts Manual H an d D rye rs Operation Shake excess water from hands Place hands under the outlet to start operation Rub hands lightly and rapidly Stops automatically when hands are removed Maintenance Easy to maintain If the surface is dirty or dusty just wipe to clean Troubleshooting Chart Symptom Corrective Action Blower motor stops running Turn off power to the dryer at electrical panel Remove cover Check all wiring connections from terminal board to the motor Check blower wheel and spin to make sure it rotates freely Look for objects blocking the free movement Replace cover and turn on power to the hand dryer If motor fails to start have a qualified electrician check the Push On Switch thermostat motor and capacitor for proper operation Replace if necessary Dryer blows cold air Turn off power to the dryer at the electrical panel Remove cover Check all wiring connections to make sure all terminals are firmly mounted in place and the wire insulation is in good condition Have a qualified electrician check the thermal cut off and heating element Replace cover turn on power to the hand dryer If dryer continues to blow cold air replace defective thermal cut off and or heating element Dryer2. Manual General safety information A WARNING Disconnect power before installation or servicing A WARNING This product intended for installation by a qualified service person Use 1 2 mm solid conductor for wiring A WARNING All units must be supplied with a 3 wire service The ground wire must be connected to the dryer s backplate A DANGER Failure to properly ground unit could result in severe electrical shock and or death NOTE Do not install dryer over washbasin Installation 1 Fix the mounting instruction sheet on the wall Suitable height for hole C is 50 from ground 2 Drill 4 holes A B C D 3 diameter 1 4 depth 3 Take off the mounting instruction sheet Hammer dowels into 4 holes SCREW CUSHIO WALL A Hand Dryers 4 Remove the housing from the base plate put the power cord at least 2 1 4 through the hole of the base plate then secure the base plate onto the wall 5 Connections A Connect the live wire colored red or brown to the terminal block marked L B Connect the neutral wire colored black or blue to the terminal block marked N C Connect the ground wire colored green and yellow to the terminal block marked 6 Attach housing back to base plate at an angle of 10 degrees then secure properly
3. does not respond Make sure power is on and available to the unit Place to hand movement hands under sensor A clicking sound indicates sensor is functioning properly 7 No clicking sound would indicate a bad sensor and or contactor Replace if necessary Dryer will not shut off or will Replace timer assembly not run for a complete cycle EEE A 15 m Automatic distributed by RESTROOM DIRECT 704 937 2673 www RestroomDirect com
4. FFESTDRY Operating Instructions and Parts Manual H an d D rye rs Repair parts list Reference Number NOVO BR WD 10 11 12 13 14 15 Description Motor mounting bracket Motor Fan enclosure Air outlet guard Timer assembly Plate Enclosure Push button Motor capacitor 2uf 450Vac Dowel assembly Fan blower Heater assembly Thermal cut off L key Fix screw Part C01 005 E01 001 N A N A TIAO1 1 N A BO1 001 B01 002 B01 003 B01 004 B01 005 B01 006 B01 007 PBO3 F01 001 D03 003 C01 001 HE01 E01 016 N A N A Nanananana Ajla a am l O a lo AR a Push button riand dryer HK 2200 Series User Manual Automatic amp Push button Operation distributed by RESTROOM DIRECT 704 937 2673 www RestroomDirect com Hand Dryer Operating Instructions and Parts Manual Description Automatic amp Push button operation hand dryer Casing Chrome plated aluminum Painted cast aluminum Satin Chrome plated aluminum Steel cover Porcelain enameled coating t 2 0mm Stainless Steel Satin finished 304 t 1 2mm Brushless motor 1 8 HP 100W 2850 R P M 50Hz 3250 R P M 60Hz Designed with 221 F 105 C thermostat Heater assembly Designed with 189 F 87 C thermostat Designed with 286 F 141 C thermal cut off Air speed 14 5 m s 50Hz 16 5 m s 60Hz Air delivery 150 CFM 255 m h 50Hz 171 CFM 291 m h 60Hz Sound level 6343 db Appr
5. oximately 30 35 seconds drying time Adjustable sensitive distance of sensor from 10 to 30 cm automatic Adjustable timer control range from 20 to 55 seconds push button Power cut off automatically in case of irregular use over 60 seconds 2 vandal proof lock screws and key wrench Drip proof IPX1 6 Weight 13 4 Ibs 6 1 kgs unpacked 14 1 Ibs 6 4 kgs packed Certification Up LVD USTED y HAND DRYER Specifications and Dimensions Model Volts Watts Amps HK 2200 Series 110 120Vac 2020 2200W 18 4A 220Vac 2020 2200W 9 2 10A 230 240Vac 2020 2200W 8 8 9 2A Wiring Diagrams Heater Thermal C AUTOMATIC PUSH BUTTON Operating Instructions and Parts Manual H an d D rye rs Push button distributed by RESTROOM DIRECT 704 937 2673 www RestroomDirect com Operating Instructions and Parts Manual Repair parts list Reference Number Description 1 Motor mounting bracket 2 Motor 3 Fan enclosure 4 Air outlet guard 5 Sensor assembly 6 Timer assembly 7 Plate 8 Enclosure 9 Motor capacitor 2uf 450Vac 10 Dowel assembly 11 Fan blower 12 Heater assembly 13 Thermal cut off 14 L key 15 Fix screw Hand Dryers Part C01 005 E01 001 N A N A F02 003 1 TIAO1 1 N A BO2 001 B02 002 B02 003 B02 004 B02 005 B02 006 B02 007 F01 001 D03 003 C01 001 HE01 E01 016 N A N A Naana nana afm a om aana aA a a ana naja om nananana Automatic Operating Instructions and Parts
Download Pdf Manuals
Related Search