User manual - Crem International
Contents
1. REASSEMBLE Mixer system 8 Make sure that the motor whippers plane side T will be in accordance with the whippers plane Reassemble the assembly plate by turning side see next G and picture H lock knob F clockwise INSPECT gaskets aja INSPECT f F INSPECT 9 10 11 Assemble whipper pull until Assemble mixer bowl and steam Easily push the mixer bowl you hear a clicking noise H trap J see picture towards according to K and lock with lock knob L Connect outlet hose M NOTE make sure that all water hose are connected at right place 17 8 Cleaning and maintenance Cleaning Future TT Dismantling Cleaning or exchanging coffee filter A Tool dismantling coffee filter following machine 1 Push 4 button in 6 seconds um ad After 6 seconds the display shows Change paper Rotate Push E Mm 2 SS 9 2 Push button for drink 2 a CAF AL LAIT e A en l 3 The machine will rotate in position The display shows Preparing paperload Display shows Change paper open the door and insert the extractor tool through the brewer spout all the way to the back of the cylinder then slide it up until contact is made with the screen assembly Push up on the rear of the screen assembly until it pops out of the cylinder 4 ooak the screen assembly in a solution of 25gr bleach in 3dl water for a maximum of 10 minutes Cleani2. Future TT Combi automat Your retail dealer U GB Rev 061201 1 Table list of contents 1 Table of contents sid 2 2 Generally 3 3 Overview of components membran switch 4 3 Overview of components front 9 3 Overview of components mixing system 6 4 SERVICE Installation and start 7 8 Locate the brewer Connectings Electricity Water Starting up machine Fill canisters 5 DRIFT Brewing of coffee in cup 9 Brewing of jug 10 6 Cleaning program Automatic cleaning of brew mechanism 11 12 Automatic cleaning of mixing bowl 13 Automatic cleaning of In Outlet valves 14 Rotate brew mechanism without water or ingredients 15 7 Weekly cleaning dismantle mixer system 16 wash these parts 16 assemble mixer system 17 8 Cleaning and maintenance dismantling exchange and cleaning of coffee filter 18 outward cleaning 19 9 Cup counter and Easy access 20 10 Safety functions 21 11 Failure messages 21 12 Storage Transport 21 13 Dimension sketch 22 14 Circuit diagram 23 2 Generally Future TT We congratulate to your choice of a Coffee Queen Combi automat Please read through this manual before you take the machine into operation for the first time The manual contents important instructions for a safe and proper usage of the machine Always keep this manual within reach for the user Future TT Combi automat Making coffee cup by cup Jug facility with key switch 8 choices of drinks 3 ingr
3. 6 Cleaning program CLEANING Future TT Rotate brew mechanism without water or ingredients The brew mechanism can be rotatedwithout water and ingredients with the key switch in cup normal position To be used when brew mechanism has been dismounted forwashing and shall be remounted Push button in 6 seconds 9 e z SA es After 4 seconds a signal will go faster The display shows Change paper Rotate 4 SHORT COFFEE Push E CAFE ALI LAIT N DU E 2 Push button 1 Mt h The display shows Rotate cycle without water 8 Push button for drink 1 The display shows Rotate The brew mechanism rotate one turn without water and ingredients and the mechanism falls into position if it has been dismounted Observe The push rod shall be in position 8 o clock If not take out again and repeat the procedure Eight 8 o clock 15 7 CLEANING Weekly cleaning Future TT Dismantle Mixer system 1 Loosen outlet hose A a turn lock knob B anti clockwise 3 Loosen whipper D pull whipper straight out from the machine 2 Loosen mixer bowl Pull apart C 4 Turn lock knob anti clockwise E until it stops 5 Clean with a wet rag and drought drily 6 A Mixer bowl B Steam trap C Whipper D Assembly plate Make sure this parts are dry before use 16 7 CLEANING Weekly cleaning Future TT
4. After 4 secondsa signal will go faster The display shows Total xxx cups The display shows Easy access Conc 1 10096 Push button for drink 2 2 Goto right button choise which you want to display shows Choise 1 free xxx cups change by pushing or button Push button for drink 2 3 Push button for drink 2 display shows Choise 1 coin xxx cups The display shows for example Volyme 4 and Blinking 10096 Push button for drink 2 4 Change by pushing or button display shows Choise 1 xxx cups in can 5 Push button for drink 2 for entering the change 5 Push button to reach to choise 2 etc Press stop to quit Push button for drink 3 to reset the counter 7 Push Stop button to go back to user mode 20 10 Safety functions Future TT The machine is equipped with following safety functions Indication of door Door not closed The display shows Door open 2 When machine is not in use The inlet valves are blocked 11 Failure messages Failure messages which can mostly be corrected without any help from service com Blocked pany The display shows Blocked Water level low Please check incoming water connection Turn off the machine with the main switch wait for 10 sec and turn on again The display shows normal but no drink is coming Possible cause of failure Mechanical stop in the ingredients canisters or whipper Measure Try to find the cause
5. of failure Clean the mixer system and try again 12 Storage Transport Transport and no use in long time 1 Turn off the switch pull out the plug and close incoming water tube 2 Empty the water tanks 3 Keep machine free from frost Long machine storage at temperatures as below 0 C zero degrees celsius can cause damage of the machine Total emptying of water is recommended 21 22 14 Circuit diagram laa Y B SA al Q T Sa LA B O dup FO Mm ag O PD le Q O PIN 3 Price Lines Jam p PIN 4 Price Line 6 25 3 o PIN 5 Flight Deck open Ss PIN 6 Block all PIN 7 Price line 1 28 m gt PIN 8 Price line 2 PIN 9 Price line 3 AN O PIN 10Price line 4 m 5 pu i S IN GND2 FAN N 3 WASTE BOX WHPPER 13 OUT18 ET IN 2 PAPER SENSOR MEE f an IN 1 BREW MEC REF ouns re INO DOOW SWITCH ouna IN GND1 TEMP TEMP HOT WATER og PE TEMP TEMPHOTWATER 42M1 no 1200 z DRIP TRAY WASTE OUTLET 4 OUT o DRIP TRAY WASTE ome our L2 OUTLET 1 OUT ste E jet OUTLET 6 H2OCOOUTS Li HOTTANKMAX OUNET7 OUT2 LO HOT TANK MIN oun HOT TANK GROUND OUGHT BREW OUTO JU m RX232A RX232A 40 V AC2 GND232AGND232A 10 WAT USEF 1 ARES B TX232B 18V AC1 RX232B 18 VAC USE T SA C4 TI c eo m j A gt 23 Future TT COFFEE QUEEN COFFEE QUEEN OF SWEDEN FOR SERVICE Please contac
6. aned with the key switch in cup normal position Place a jug under the outlet dismantle drip tray Turn the key 2 slowly ninety degrees and 4 pn EN back again Push button for drink 3 in 6 seconds 4 SHORT COFFEE 4 0 3 TRE U After 4 secondsa signal will go faster a Ss i After 6 seconds the mixer bowl starts to be cleaned in 10 seconds The display shows Cleaning mixer 2 By cleaning means that water is flushed and whipper motor rotates 13 6 Cleaning program CLEANING Future TT Automatic cleaning of In Outlet valves The In Outlet valves can easily be cleaned with the key switch in cup normal position Place a jug under the outlet dismantle drip tray 0 2 Turn the key slowly ninety degrees and back again 4 COFFEE 3 Push buttons for drinks 1 and 2 at the same time in 6 seconds 0 CAFE ALI LAIT Keep buttons down 4 AllIn Outlet valves will now start to open and close with 2 pulses second in 10 seconds or so long you pushed the buttons The display shows Cleaning valves 4 Push button for drink 1 for making a brew lt i cycle and flush remaining water and scale from e 0 the cleaning 0 CAF AU LAIT j s C PPUCCINO By cleaning is meant that valves knocks away eventual scale and other particles which has been attached in the cylinders and that they are flushed away with the water 14
7. drink 1 M O e lt re turned off before you take out the jug Wait until the light and text Please wait has been 4 IA 6 Serve a jug with good coffee 4 CAPPUCCINO 10 6 Cleaning program CLEANING Future TT Automatic cleaning of brew mechanism mixing bowl Shall been done every week The brewmechanism can easily be cleaned with the key switch in cup normal position Turn the key slowly ninety degress and back again 4 2 1 s x CN Push button for drink 1 in 6 seconds _ NA After 4 seconds a signal will go faster 4 SHORT COFFEE A After 6 seconds The display shows Open door EN load detergent Fill 25gr detergent one portion bag in to the brew CAF AU LAIT mechanism Detergent will be supplied from your retail dealer The display shows Close door The display shows When ready press key Place a jug into the drip tray 8 Push button for drink 1 The display shows Cleaning mixer 2 The display shows Rinsing coffee Soak time The machine start to count down from 300 seconds The display shows Brewer cycle the machine is counting down To stop cleaning process push Stop button The brew mechanism will go back to start position NOTE Dont stop the process when detergent has been loaded Then the cleaning must be finished IMPORTANT Dismantling and cleaning washing brew house After the automatic cleaning program is finished Clean bre
8. edients canisters Brewing mechanism with coffee filter Electronically temperature controlled Adjustable coffee strenght Lighted cup while brewing Clock functions Facts Future TT Height 780mm Width 420 mm Depth 550 mm Weight 35kg emballage c 4kg Tankage 2 4 litre Electricity 230V 2200W Water connection outside thread Capacity Cups of coffee 200 cups filling Ingredients canisters 3 st coffee chocolate topping 3 3 Overview of components membranswitch Drink 1 Drink 2 Drink 3 Drink 4 Future TI Membranswitch COFFEE CHOCOLATE Drink 5 a Qe a sr EE LS Bee A t N SN SHORT COFFEE CHOCO MILE hy i 4 a Drink 6 CAF ALI LAIT CAPPUCCIMO em ESPRESSO CHOC 6 Drink 7 k ES E A e E O 7 TEA WATER Mm Drink 8 4 3 Overview of components front Future TT Display Key switch cup and jug choice Membran switch 8 choices of drinks Door lock Strenght of drinks Water outlet warm and chilled drinks Drip tray with drainage function Drip tray insert 5 3 Overview of components mixer system Future Ingredients canister Ingredients are oe canister Ingredients canister Chute Mixer bowls FUSE holder ON OFF mechanism E switch Outlet Detail Ingredients LUE SR a 4 CIN Canister coffee 160 250 Canister choco Canister toppin
9. g 4 Service Installation and start Future TT Locate the machine on a flat level and waterproof surface Connect the electrical plug to a separate grounded wall socket 230V 104A OBSERVE Make sure there is a space behind the machine for free flow of air minimum 10cm Connect attached water tube to cold water with an R 1 2 Make sure that the water hose not are kinked anywhere when machine is pushed into place Please flush the water tube before connecting to machine this to avoid any particles to destroy the inlet valve Open the water inlet Turn on the switch inside the door Water is been filled into the tank automatically with 2 4 litres of water The heating will not start before the water level reaches the level sensor Set temperature is approx 972C Close door f 4 Service Installation and start Future TT 6 Fill canisters with ingredients Take out this to avoid unnecessery spillage in the machine ingredient canisters and fill them with ingredients i a r T E A p M E dnd i Li x E t j A E 1 EL a ds QA F EF LE LU s EC 2 M 1 PE db gs cde ds Gu or k h p CHITA Li JI T When placing the ingredient canisters Make sure that the outlet pipes on the ingredient canisters are touching the steam traps B and that the coffee powder will fall into the centre of the brew mechanism A When the wate
10. ng of coffee filter 1 97 Celsius A 3 dl water 5 Remountthe screen assembly and close the door Then the machine will return to start position and the machine is ready for use If machine not will go back in start position Restart machine 6 Take out a cup of coffee and waste it just to make sure that there is nothing left of detergent Prolonged contact with bleach may damage the screen assembly Once this is done the screen should then be thoroughly rinsed with dish soap and warm water to remove any leftover residu Cleaning agent brew mechanism Coffee Queen artikel nr 1104161 Filter Drew mechanism Coffee Queen artikel nr 47200211 Tool dismantling filter Coffee Queen artikel nr 4720090 18 8 Cleaning and maintenance CLEANING Future TT Outside cleaning Outside cleaning use a soft rag and liquid cleaning agent which not scratch 19 9 Cup counter Easy Access Future TT Cup counter Easy Access The machine has an in built cup Water and ingredient amount can be counter which is available to adjusted with 15 with the key switch see and reset with the key switch in in cup normal position cup normal position COFFEE Y COFFEE E LITE A M E NEA du e 0000 y y 000 b Y Ec s a CAPPUCCINO CAPPUCCINO 1 Push button in 6 seconds 1 Push and button at the same time After 4 seconds a signal will go faster
11. r is heated up to right temperature the text please wait will disappear and please wait the machine is ready to use 8 5 DRIFT Brewing of coffee in cup Future TT Brewing of coffe etc in a cup 1 Place a cup in the centre of the cup holder 2 The strenght has a standard setting if you wish to increase or decrease it do as follows if not continue to point 3 Stronger drink Increase by pushing or for 5 or 10 alternative Weaker drink Decrease by pushing or for 5 or 10 the indication lamp will go up or down depending of choice 3 Choose drink by pushing on the OU AN button to the right of each menu or Q E L The display will show Please wait SHORT COFFEE 4 y Te 4 and the light on the cup will light up PEN Wait until the light on cup and the text Re Please wait has been turned off before you take your cup GARE ALI LAIT ESFRESSO CHOC 4 pL CAPPUCCINO TEA WATER a 5 Enjoy your drink 9 5 DRIFT Brewing of coffee into jug Future TT Brewing of jug a2 Place a jug in the centre of drip tray For jug 1 8L dismantle drip tray Serving pot 1 8L Serving pot 1 2L art nr 1103091 art nr 110001 Thermos pot 1L art nr 1103251 Turn on the key with jug symbole clockwise 6 cups of brewing is standard settings Change amount of cups by pushing or button Optional up to 12 cups or down to 1 cup brewing Push button for
12. t your retail dealer Your retail dealer Art NO XXX XXXX
13. w house This must be done to make sure that you will remove residual detergents and coffee remnants Do as follow in paragraph 10 19 See fig 1 2 3 4 page11 6 Push button in 6 seconds COFFEE i The display shows Change paper Rotate Push E 4 wu A T Push button for drink 2 rJ The display shows Preparing paperload 4 GAF AU Lar N 6 8 The machine will rotate in position uc The display shows Change paper CAPPUCCIND us 9 Open door dismantle clean and reassemble brew housg page 12 10 Close door If machine not will go back in start position 11 Machine is ready to use again 12 Take out a cup of coffee and waste it just to make sure that there is nothing left of detergent Restart machine 11 j m si LL NOTE When reassemble brew house make sure that B wiper are Reassemble brew house between A arms B o 3 ai c er 9 e Pa O v T E LLI 2 EM c c O 0 D Qo 5 D 8 z a e o c D y Y Lo O D z NP TARN LS TE gt 2 g 2 S Mais aa o C Q 1 72 Ap E O WV Lee o IE SELS Er lt 3 E MENA 7 QE D 7 Z 9 O i U w Te 12 6 Cleaning program CLEANING Future TT Automatic cleaning of mixing bowl If you only wish to clean the mixer bowl Follow these instructions The mixer bowls can easily be cle
Download Pdf Manuals
Related Search