X-560 Product Handbook
Contents
1. 2 Slide the handlebars onto the fork Fig 1 3 Locate the Handlebar Lock Pin and insert it into the side of the handlebar ensuring it feeds thru the fork bracket Secure the lock pin using the attached bolt Fig 2 Slide the handlebar clamp up and over the base of the handlebar Tighten the clamp ensuring the front wheel is in proper alignment with the handlebars Fig 3 After the handlebar is securely attached slide the black rubber boot over the connection Page7 1 Attach Throttle and Brake Handle Grips by Inserting the handle grips into the handlebar posts 2 Attach Left amp Right Side Fairings as shown in figure 4 3 Mount trunk cargo rack 4 Mount the seat post to the bottom of the Fig 4 seat then insert seat post into the receiver and tighten the clamp 5 Install the rear taillight to the mounting bracket being sure to attach the plug to the scooter Fig 6 6 Install the enclosed 25amp glass fuse into the fuse holder located on the right side of your scooter Fuse Installation Your scooter comes with a 25amp fuse that is NOT installed at the factory 1 Locate the 25amp glass fuse that came E with your scooter Fig 6 2 Locate the fuse holder on the right side of the scooter 3 Remove the fuse holder cap and insert the fuse into the cap first Then insert fuse cap into fuse holder and gently tighten DO NOT OVER TIGHTEN THE CAP For more detailed assembly instructions g2. by any other event Please contact the manufacturer for a complete warranty listing The manufacturer will cover shipping costs on the first warranted part only Shipping on any additional warranted parts that are needed after the first free shipment will be the responsibility of the customer The manufacturer offers a full 6 month even trade warranty on defective batteries If any battery should become faulty within 6 months from the purchase date the manufacturer will replace the battery free of charge The manufacturer may require that old batteries be returned to for exchange If you have questions about our warranty please contact your dealer X Treme Electric Scooters Manufacturers amp Wholesale Distributors is not responsible for the proper or improper use of merchandise sold We care about our customers and urge you to exercise caution and take necessary safety measures to protect yourself while engaging in cycling X Treme Electric Scooters encourages begs and asks that you wear a helmet and use appropriate lighting while riding at night regardless of the legal requirements in your particular state Potential customers you should check with your local law enforcement agency before purchasing about age requirements for riding electric scooters Some states may have laws restricting the use of scooters on public streets Generally all states allow them on private property such as campgrounds parks etc but many states have age requirements an
3. 1 RECOMMENDED TOO E Susa 11 ADJUSTING THE CHAIN ooooccoccccccoccconcccnncco eee cease nn 11 MAINTENANCE SCHEDULE oooccoccccnccconcconnccnnccnnnn 12 TROUBLESHOOTING GUIDE 12 ADDITIONAL INFORMATION 13 GENERAL INFORMATION TECH SUPPORT coccion 14 Page5 GETTING TO KNOW YOUR X TREME X 560 Variable Speed a 2 and Brakes Oversize Seat m A ege Cargo Rack with a Optional Trunk Box X Treme X 560 Large Headlight ABS Plastic geg with carpet kit 13 Tires with H E pe Chrome Mag Wheels ma a MS lt 500 Watt Motor A 3 gee lt Chain Driven High Tensile Steel Frame Front amp Rear Brakes W s 3 ae 12 Volt Batteries The X 560 Scooter comes with Smart Charger Tool Kit and 3 12 Volt Batteries Photo s may vary Page6 PACKAGE CONTENTS Your X Treme X 560 comes with the following items in the box Please locate all of the following EE E The X Treme X 560 Scooter Right amp Left Side Fairings 36V Battery Charger Tool Kit amp assorted nuts bolts washers Seat amp Seat Post Trunk with Keys amp mounting hardware Trunk Rack amp mounting nuts bolts Spare Fuse s Product Handbook Rear Tail Light Footpad Mat GETTING STARTED h Please read and understand these instructions and the OPERATING Fig 1 Fig 2 PROCEDURES section prior to starting or riding your X 560 Assembly 1 Carefully remove the X 560 from the box
4. X Treme Electric Scooters Model X 560 Product Handbook Photos may vary PLEASE BE SAFE WHEN RIDING ALWAYS WEAR A HELMET AND OBEY ALL LAWS Pagel IMPORTANT BATTERY MAINTENANCE and CHARGING INSTRUCTIONS You MUST charge completely prior to initial use Follow charging instructions in your Product Handbook Charge immediately after each use Charge before storage You must charge every 30 days if not In use Charge the unit for 6 8 hours or until both lights on charger turn green DO NOT allow this unit to deep discharge the battery For safety purposes DO NOT charge for over 24 hours Turn the unit OFF when not in use Failure to follow these INSTRUCTIONS will VOID YOUR WARRANTY This PRODUCT IS NOT INTENDED FOR EXTREME or OFF ROAD Use Please take care of your X 560 DO NOT JUMP or ABUSE THIS PRODUCT DO NOT RIDE IN WET ICY CONDITIONS Failure to follow these instructions will VOID YOUR WARRANTY Page2 IMPORTANT PLEASE READ THIS BEFORE USING THIS PRODUCT READ THIS FIRST WARNING This product does not conform to Federal Motor Vehicle Standards and is not intended for operation on public streets roads or highways Serious injury can result from the unsafe operations of this product Operator can minimize these risks by using certain safety equipment such as safety helmet goggles gloves elbow and kneepads and appropriate footwear DO NOT operate thi
5. d most states require helmets and protective equipment to be worn by certain age children Please always scoot safely and know your laws before you go riding The manufacturer will not take back a scooter if you find your laws do not permit the ridings of this scooter so please check first Pagel3 For General Information or Parts Visit www x tremescooters com For Technical Support or Assistance Visit www x tremescooters com support Pagel4
6. djusted too loose 1 Tighten the tension screw on the brake hub by rotating it counter clockwise until the wheel has a slight drag Fig 7 Squeaky Brakes The brakes may squeak before they are broken in This is normal and will not affect the function or performance of the brakes With continued use the squeak should go away TIRES The X Treme X 560 uses 13 tires on the front and rear wheels Tire wear will differ based on rider weight riding conditions and care Replacement tires can be obtained at your local X Treme dealer through motorcycle shops or from the X Treme website at www x tremescooters com Tire Pressure The tires must be inflated to a maximum of 36 40 P S I It is also recommended to use a tube additive like Slime available from any motorcycle shop to avoid inconvenient punctures Pagel0 MAINTENANCE RECOMMENDED TOOLS To adjust and service the X Treme X 560 you will need the following tools Allen Wrenches 3 4 5 6 mm Wrenches 10 13 13 mm Open end wrench Large Adjustable Crescent Wrench Philips Head Screwdrivers Oil Grease or Lubricant ADJUSTING THE CHAIN The chain will come adjusted from the factory However it may be necessary to adjust the chain from time to time The chain must be well aligned onto the sprockets in order to avoid uneven wear This will result in shortened chain life How tight should the chain be m If the chain is skipping or jumping on the sprockets this is too lo
7. o to http www x tremescooters com electric_scoot ers x560 images adobe x 560 assembly manu al pdf Charging Your scooter comes partially charged out of the carton It is recommended that you charge the unit for 6 8 hours prior to it s first use We also recommend charging your scooter after each use and prior to storage WARNING Do not allow your scooter to go into deep discharge as this will damage the batteries Pages 1 Open the charging socket cover located on the left side of the scooter body Fig 7 2 Locate your Battery Charger Fig 8 Find the charger socket end that has a three prong socket and plug it into the scooter 3 Next plug the AC plug into a wall outlet When first plugged in the charger has a red light and green light that indicate the charging process has begun Once both lights turn green you may remove the charger and close the safety cap Riding Make sure that all of the exposed bolts and screws are tightened Raise the kickstand to its upright position Turn the Ignition key to the on position Gently rotate the THROTTLE GRIP on the right side of the handlebars The X 560 will begin to move on its own power Your scooter has a variable speed hand throttle You can control the speed of your scooter by the amount of pressure you use when rotating the hand throttle The more you rotate the faster you will go OI ES Stopping Braking To brake release the THROTTLE GRIP and de
8. ose and may be harmful m If the chain is making a humming sound when the wheel is turning this is too tight and may cause the chain to snap m The correct tension is achieved by adjusting the chain from its loose position to when it becomes lightly tense To tighten the chains Slightly loosen the two axle bolts on both sides of the rear wheel Fig 8 Then slowly adjust the two adjusting screws on each side of the rear tire Fig 9 until chain reaches the proper tension Rotate the rear wheel to make sure the chain is aligned Finally lock and tighten the rear axle bolts prior to riding Pagell MAINTENANCE SCHEDULE Proper care of your X Treme X 560 will insure optimal performance and longer life span The following are a few maintenance suggestions that will keep your X Treme X 560 running in top condition Daily Maintenance Perform each time you ride your X 560 NW Clean the exterior of the unit with a soft damp rag DO NOT USE WATER TO CLEAN YOUR X 560 NW Check that all nuts and bolts are securely tightened NW Lubricate the chain with any silicone spray 3 amp 1 oil or any good clean motor oil Check battery charger for any frayed cut wires TROUBLESHOOTING GUIDE _ Power switchis off Turn on power key Batteries are drained Charge batteries pi Electrical Fault LCheck allfuses ooo 6 Elecricalfaut Check all connections Lon te pressure Inflatetirto36psi_ JL Popping sound Adjus
9. press the BRAKE LEVER on the left side of the handlebar Depressing the brake will disengage power to the motor When the unit feels like it is loosing power or not accelerating to full soeed the scooter is ready to be re charged BRAKING SYSTEM The X 560 uses a hub brake system on the front and rear wheel of the scooter activated by a hand brake lever on the left amp right side of the handlebar Make sure to release the HAND THROTTLE GRIP when engaging the brakes Practice braking on a smooth dry surface to get used to the feel of the braking system Braking distance is affected by wet conditions and loose and uneven riding surfaces Page9 Adjusting the Brakes The Brakes on the X 560 should come fully adjusted from the factory However it may be necessary to adjust the brakes from time to time To adjust brakes For brakes that are adjusted too tight 1 Loosen the tension screw on the left or right hand brake lever by rotating it counter clockwise until the wheel spins freely Fig 6 For brakes that are adjusted too loose 1 Tighten the tension screw on the left or right hand brake lever by rotating it clockwise until the wheel has a slight drag Fig 6 For further adjustment Locate the adjustment screw on the front or rear brake hub For brakes that are adjusted too tight 1 Loosen the tension screw on the brake hub by rotating it clockwise until the wheel spins freely Fig 7 For brakes that are a
10. rain and never spray or wash off your scooter with water Do not place the battery near fire or heat To avoid damage to the battery do not use the charger if it has been damaged in any way Keep hands face feet and hair away from all moving parts Do not touch the motor or wheels while they are rotating Brakes are designed to control speed as well as stop the scooter Practice braking for proper slowing down and smooth stops Maintain your X Treme X 560 as recommended in this Product Handbook Use only quality replacement parts as recommended by the manufacturer Inspect the entire scooter prior to each use Replace any part that is cracked chipped or damaged before use NEVER ALLOW CHILDREN TO OPERATE THE SCOOTER WITHOUT ADULT SUPERVISION NEVER ATTEMPT TO OPERATE THE SCOOTER WHILE UNDER THE INFLUENCE OF ALCOHOL If a situation arises that is not covered in the manual proceed with caution and use good judgment Contact your dealer or X Treme www x tremescooters com support if you need further assistance Page4 TABLE OF CONTENTS IMPORTANT INFORMATION 2 3 QUICK REFERENCE saab 4 ET RRE IC RR EC H EE 9 GETTING TO KNOW YOUR X TREME A 2p0 6 PACKING CONTENTS asair aiian aaaeaii 7 CEF HNG SIAR TED EE T ASSEMBLY tai E 7 FUSE INSTALLATION vas di 8 CHARGING orante 8 RIDING BRAKING 0 0 cc cece eee eee eee eee eee ee eeeeeaeens 9 BRAKING SYSTEM EE 9 ADJUSTING THE BRAKES n 10 HR 10 MAINTENANCE cuina 1
11. s product in traffic on wet frozen oily or unpaved surfaces or under the influence of drugs and or alcohol Avoid uneven surfaces potholes surface cracks and obstacles DO NOT use a water hose to clean this product See Product Handbook for more information This product is recommended for riders 12 YEARS OF AGE and older SAFETY o Persons without excellent vision balance coordination reflex muscle and bone strength and good decision making capabilities should not use this product e Minors without adult supervision should not use this product eo Persons unwilling or unable to take responsibility for their own actions should not use this product e The user of this product assumes ALL risks associated with its use To minimize these RISKS the user must wear safety helmet goggles gloves elbow and kneepads and appropriate footwear e This product is ELECTRIC DO NOT ride this product in wet conditions puddles or rainy weather Page3 QUICK REFERENCE SAFETY GUIDE SAFETY GUIDE The minimum recommended age for riding this scooter is 12 years old To avoid damage to the motor and footplate do not overload the scooter Never ride with more than one person Inspect your scooter thoroughly before each use for loose or missing parts Avoid unintentional starts by turning the scooter off while not in use To avoid the risk of a short circuit in the electrical parts do not use your X Treme Electric scooter in the
12. t chain drive WARNING This vehicle DOES NOT conform to federal safety standards and is not intended for operation on public streets roads or highways Serious injuries can result from the unsafe operation of this vehicle TO MINIMIZE RISK the user of this vehicle must wear appropriate safety gear such as helmet gloves and knee and elbow pads DO NOT OPERATE THIE VEHCLE IN TRAFFIC ON WET OR FROZEN SURFACES OR OILY UNPAVED SURFACES To avoid damage to your wheels and or wheel bearings avoid uneven surfaces with potholes cracks or obstacles THIS ELECTRIC SCOOTER IS DESIGNED FOR AGES 10 AND UP THE MANUFACTURER WILL NOT BE RESPONSIBLE FOR ANY DAMAGE OR INJURY THAT OCCURS WHILE RIDING Page12 ADDITIONAL INFORMATION Scooter Specifications wi SOO Frame igh Tensile Stool Batteries 12 volt 12amp X 3 Distance per Charge Assembled Dimensions 49 L X 29 W X 39 H Carton Dimensions 46 L X 14 5 W X 26 H 17 21mph speed is not always obtainable but can be reached when riding on a slope Maximum speed depends on terrain the weight of the rider tire pressure battery power and weather conditions Up to 22 miles Distance is also based on variables such as weight terrain tire pressure battery power and weather Warranty 30 day LIMITED manufacturers warranty on all scooter parts and accessories This warranty covers factory defects and defaults only It does not cover misuse or damage caused by the user or
Download Pdf Manuals
Related Search