User Guide & Installation
Contents
1. validate it 3 2 STARTING UP MODEL WINE C18S R WITH HEATER 3 2 1 CONNECTING THE AIR CONDITIONER When you plug it into the electrical socket The fan in the cellar starts up immediately The compressor may not come on until 2 minutes later if the temperature of the cellar is higher than the set temperature If the temperature of the cellar is the same as the setting on the thermostat the compressor will not come on 3 2 2 SETTING THE TEMPERATURE The thermostat is equipped with a joystick on the right hand side ref 1 which can be used to change the setting To change the setting simply press on the symbol J for 5 seconds The display ref 5 then displays SET Press the symbol once again briefly The set temperature is displayed To increase it press the up arrow To reduce it press the down arroww When The temperature on the display is correct confirm by pressing to symbol until it shows again SET Diode 2 indicates that the device is defrosting Diode 3 indicates that it is in heating mode Diode 4 indicates that the compressor is running When there is no diode lit the cellar temperature is close to the set temperature After changing a setting because of a fitting which prevents it from starting up too frequently the compressor will only start up after a few minutes Page 30 WINEMASTER C18 C18S R USER GUIDE November 2002 3 3 AUTOMATIC DEFROST The program of the thermostat will run an automatic defro2. 8 C18 S R 5 40 30 20 8 50 40 30 10 60 40 40 12 80 50 40 14 90 60 50 15 100 70 60 16 110 80 70 17 120 90 80 18 130 100 90 1 2 2 INSULATING WALLS AND CEILING The manufacturers propose their insulating panels in several forms insulation alone complexes the insulation is lined with a facing plaster mineral sandwiches the insulation is lined on each side with a wooden or plaster panel The panel facing is important it protects the insulation from shocks and guarantees long life Do not use mineral fibre insulation Glasswool stonewool because it stores humidity Page 26 WINEMASTER C18 C18S R USER GUIDE November 2002 Protection against rodents some insulating materials are damaged by rodents mice rats It is therefore essential to make sure that the walls of the cellar do not contain holes which would allow rodents access to the insulation This insulation must be lined on the inner surface of the cellar with a protective facing Polyurethane insulation because of its chemical composition is not attacked by rodents 1 2 3 FLOOR INSULATION The cellar floor must be able to support shelves and the wine stored on them You should therefore choose an insulating material with adequate compression resistance for this part Manufacturers recommend appropriate insulation or materials designed specifically for floor insulation in their documentation Puncture resistance feet of shelves in p
3. ONDIS WINEMASTER cellar air conditioner Contact us if you have any questions So even if there may be long years to wait before the wine reaches perfection the great day will come when you face the delicate job of uncorking Hold the bottle carefully do not remove the capsule on a level with the mouth use a good quality tool or lever remove the cork without shaking the bottle and examine the mirror But that s another story SERVICE CLIENTS FONDIS Tel 0 589 377 500 7 Fax 0 389 377 589 E mail contact fondis com Attention Wart for 24 hours before switching on the air conditioner Page 24 WINEMASTER C18 C18S R USER GUIDE November 2002 CHARACTERISTICS WINE C18 C18S R Setting the temperature Preset to 12 C adjustable between 4 and 15 C Maximum outdoor temperature DCF Cooling power 550 W at 15 C Electricity supply 230 240 C 50 Hz with earth connection supplied with 3 m cable Electrical power 400 W Heating power 250 w only for C18S R The circuit breaker must be at least 16 Amps The insulation quality and thickness has to be in accordance with the volume of the cellar and the set temperature The cooling performance is dependant from the outside temperature Therefore the set temperature of 12 C for the cellar cannot be maintained if the outside temperature of the cellar is maintained at 35 C If the thermal safety functions to often there is a risk for the condens
4. TIONER Page 3 2 2 SETTING THE TEMPERATURE ass Page 3 AUTOMATIC DEFROST EEE Page 4 MAINTAINING THE WINEMASTER AIR CONDITIONER Page 4 1 CHANGING THE FILTER WITHOUT REMOVING THE COVER Page 4 2 CHANGING THE FILTER BY UNSCREWING THE COVER Page 5 GUARANTEE Page 5 1 TWO YEAR CONTRACTUAL GUARANTEE Page 5 2 TERMS OF APPLICATION OF THE GUARANTEE Page 5 3 EXCLUSIONS AND LIMITS OF GUARANTEE Page November 2002 Page 23 WINEMASTER C18 C18S R USER GUIDE November 2002 FROM VINEYARD TO WINE In former times good french cellars were built to maintain a temperature not exceeding 14 to 16 C in all seasons Today this is rarely the case Nevertheless a cellar worthy of the name must be protected against wide variations in temperature be as damp as necessary and ventilated dark and free of vibration This 1s why for more than fifteen years we have used the expertise of specialists and enthusiastic amateurs to design develop test and produce thousands of air conditioners destined to help in the storage and ageing of wine If you follow our advice and respect our recommendations Winemaster will provide the optimal ageing conditions for your treasured wine collection Don t hesitate to read the installation and operating guide for your F
5. WINEMASTER C18 C18S R USER GUIDE INSTRUCTIONS FOR USE TABLE OF CONTENTS Introduction From Vineyard to wine Page 1 INSTALLATION OF THE WINEMASTER Page 1 12 EVACUATION ROOM srka sacked Een ne eee aes Page 1 2 TAB CELLAR EQUIPMENT saxcedtvdie Page A PINS D S TION Page 1 2 2 INSULATION WALLS AND CELLING Page 1 2 3 FLOOR INSULATION ssa peie er ae AN Seite Page A Ova DOOR aussen Page 1 2 5 INSULATION OF OTHER ITEMS Page 2 INSTALLING THE WINEMASTER AIR CONDITIONER Page 2 1 PIERCING THE WALE sans 66 Page 2 2 SEALING AND LEVELLING THE WOODEN FRAME Page 2 3 INSTALLING THE AIR CONDITIONER Page 2 3 1 REMOVE THE PLASTIC COVER esse Page 2 3 2 FITTING THE DEVICE INTO THE FRAME Page 2 3 3 INTALLING THE WATER DRAINAGE SYSTEM Page 3 USING THE WINEMASTER AIR CONDITIONER Page 3 1 STARTING UP MODEL WINE C18 Page 3 1 1 CONNECTING THE AIR CONDITIONER Page 3 1 2 SETTING THE TEMPERATURE Page 3 2 STARTING UP MODEL WINE C18S R With heater Page 3 2 1 CONNECTING THE AIR CONDI
6. articular is provided by using complex insulation panels lined on the upper surface with a strong panel by facing the insulation with a panel of chipboard approx 15 mm thick or any other suitable covering plaster and slab for example 1 2 4 THE DOOR It is part of the continuity of insulation There are two possible solutions to insulate the existing door using the same type as insulation as was used for the cellar walls Insert a seal such as foam between the door panel and the frame all around the edge use a FONDIS ISOTHERMAL DOOR lined with polyurethane foam It includes a seal around its periphery with a magnetic closure 1 2 5 INSULATION OF OTHER ITEMS A fridge or another appliance producing heat must not be placed inside the cellar For example any hot water pipe going through the cellar must also be insulated 2 INSTALLING THE WINEMASTER AIR CONDITIONER Tools 1 PHILIPS SCREWDRIVER PZ 2 2 WATER LEVEL 3 UNIVERSAL WRENCH 4 METER TAPE Page 27 WINEMASTER C18 C18S R USER GUIDE November 2002 2 1 PIERCING THE WALL Cut the wall as necessary to fit the wooden frame The outer dimension of the wooden frame is 514 mm long by 374 mm high Be careful to leave at least 10 cm room below the ceiling both in the cellar and outside 2 2 SEALING AND LEVELLING THE WOODEN FRAME Seal the wooden frame so that it is flush with the inside of the cellar wall If the wall is thicker than the w
7. ator and starter to be damaged In all the cases it must be avoided that the outside temperature remains at 35 C This high temperature should be limited to the summer period 1 INSTALLATION OF THE WINEMASTER The WINEMASTER is to be built in a wall of the cellar If the compressor runs the unit expells air at the outside air outlet at 20 C above the temperature of the air inlet insulated door This hot air must be cooled in a well aerated room or be expelled outside insulated wall Cellar Room WineMaster 1 1 EVACUATION ROOM The hot side of the WINEMASTER must be inside a room Exceptionnaly an outdoor installation is possible if the ouside part is sheltered and protected from the weather direct rain snow etc WARNING Starting the compressor at a negative temperature will destroy it To avoid this problem you must not change the setting of thermosat if the outside temperature is under zero This specification doesn t concern the model WINE C18SR equipped with an heating belt on the compressor This model should be prefered for outside installation The room into which the wine evacuates the hot air must be well ventilated so that the temperature does not exceed 35 C A space of at least 10 cm must remain all around the WINEMASTER so that the cover can be removed and that hot air expelled is not aspired again in the air inlet The outside of the WINEMASTER must bed integrated in an underground cel
8. ctive following the intervention of a qualified representative In the event of an electrical breakdown FONDIS will replace any part recognized as defective following the intervention of a qualified stockist or his representative In the event of cooling system breakdown FONDIS can ask for the part to be returned for repair following the intervention of a qualified representative The equipment will be packed and held available for the FONDIS carrier to collect it Operations and returns must be made with the written agreement of FONDIS after sales service 5 2 TERMS OF APPLICATION OF THE GUARANTEE The contractual guarantee applies to all devices installed and used in accordance with the Installation and operating guide Application of the contractual guarantee depends on the guarantee card at the back of the booklet being returned within 15 days of purchase 5 3 EXCLUSIONS AND LIMITS OF GUARANTEE The guarantee is refused in the following cases The cellar and installation have not been insulated in accordance with this guide The damage is due to negligence poor maintenance defective or inappropriate use of the WINEMASTER Part exchanges or replacements under guarantee will not have the effect of extending it FONDIS SA cannot be held responsible under any circumstances for the direct or indirect consequences of the air conditioner s failure to function The guarantee is limited only to the product supplied by FONDIS SA Pa
9. ge 32 gt CERTIFICAT DE GARANTIE WWINEMASTER FONDIS Pour valider votre garantie contractuelle de 2 ans conformement aux conditions de garantie pr cis es dans le guide d utilisation merci de nous retourner ce bon d ment rempli dans les 15 jours suivant votre achat Pour renvoyer votre bon de garantie a FONDIS il vous suffit de le mettre dans une enveloppe sans l affranchir a l adresse suivante FONDIS SA LIBRE REPONSE 90010 68804 THANN Cedex CACHET DU POINT DE VENTE DATE D ACHAT DATE D INSTALLATION INSTALLATEUR NOM en a a ra Bet PRENOM aus ca ee Nous vous remercions de nous pr ciser ci dessous les conditions d installation de votre climatiseur de cave Caract ristiques de l isolation Volume climatis m Descriptif materiaux et paisseur Type d isolant et epaisseur Mur Sol Plafond Porte Comment avez vous connu le Winemaster FONDIS J Par le revendeur C Par une foire J Par un article r dactionnel J Par la publicit LP Autre preesen ee x D GARANTIESCHEIN F R WINEMASTER FONDIS Damit Ihre vertragliche 2 Jahres Garantie wirksam werden kann m ssen Sie gem den in der Gebrauchsanleitung beschriebenen Bedingungen diesen Garantieschein ausf llen und innerhalb von 2 Wochen nach dem Kaufdatum an FONDIS einsenden Sie k nnen den Garantieschein in einem frankie
10. lar window or in a too little space The wall where the device is to built in must not be more than 22 cm thick Otherwise the wall must be cut in a wedgeshape 1 2 THE CELLAR EQUIPMENT 1 2 1 INSULATION Insulation of the 4 walls the door the ceiling and the floor is essential for the Winemaster to work properly Adequate insulation helps to obtain the stability of the temperature and the humidity Page 25 WINEMASTER C18 C18S R USER GUIDE November 2002 The board on the next page choice of insulation can be used to determine the type and the thickness of insulation needed according to the internal volume of the cellar and a cellar temperature of 12 C Insulation continuity Insulating components must be assembled preferably by interlocking panels or glueing the panels together to ensure perfect continuity of insulation This is very important it prevents heat and humidity entering from the outside which would counter the effects of regulation IMPORTANT The validity of the WINEMASTER guarantee depends on the values in the Choice of insulation table being strictly respected for all the cellar walls including floor and ceiling door as well as perfect continuity of insulation CHOICE OF INSULATION MINIMUM THICKNESS OF INSULATION mm for 12 C cellar temperature EXPANDED EXTRUDED POLYURETHANE CELLAR POLYSTYRENE POLYSTYRENE FOAM VOLUME 3 m A 0 044Wlm C A 0 030W m C 0 025W m C WINE C1
11. ooden frame cut a wedge shape in the wall as shown in the diagram above The joint between the wooden frame and the insulation must be filled with polyurethane foam for example to ensure continuity of insulation WARNING DO NOT PUT POLYURETHANE FOAM BETWEEN THE WINEMASTER AND THE WOODEN FRAME THE WINEMASTER MUST BE REMOVABLE J WARM SIDE w Q D lt gt T COLD SIDE The wooden frame must be level the widest side should be horizontal CORRECT CORRECT INCORRECT CORRECT INCORRECT 2 3 INSTALLING THE AIR CONDITIONER 2 3 1 REMOVE THE PLASTIC COVER Unscrew the 2 screws on each side of the Remove the cover Winemaster Page 28 WINEMASTER C18 C18S R USER GUIDE November 2002 2 3 2 FITTING THE DEVICE INTO THE FRAME l iN N Vs iy 1 ANA Position the air conditioner in the Tighten the two screw washer units at Tighten the two screw washer units frame from inside the cellar the top on the side Check the seal between the wooden frame and the Winemaster The electrical connection cable and the PVC condensate tube are situated inside the cellar 2 3 3 INSTALLING THE WATER DRAINAGE SYSTEM The container for collecting condensate is glued onto the cover You are recommended to attach the pipe when the cover is off Push the PVC pipe on being careful to support the tray with the other hand Place the collar as close to the cover as possible for better adhesion Flow from
12. rten Umschlag an folgende Adresse schicken FONDIS S A F 68801 THANN CEDEX STEMPFEL DES FACHGESCH FTES SERIENNUMMER KAUFDATUM VORNAME Bitte geben Sie hier an wie Ihre Weinklimaanlage installiert wurde Beschaffenheit der D mmung Klimatisierter Rauminhalt m Materialbeschreibung und Dicke Art des D mmstoffs und Dicke W nde Boden Decke T r Wie sind Sie auf WINEMASTER von FONDIS aufmerksam geworden J Durch meinen Fachh ndler J Auf einer Verbrauchermesse J Durch einen Zeitungsartikel J Durch Werbung J Sonstiges bitte erl utern Warranty Cerriricate Fonnis In order to validate your 2 year contractual warranty in accordance with the specified warranty conditions stated in the WineMaster user manual please complete and return this warranty certificate within 15 days from the date of purchase to the following address FONDIS S A F 68801 THANN CEDEX Model POINT OF SALE STAMP Serial number Purchase date Installation date Installer The volume of your wine cellar in meters squared FIRST NAME LAST NAME ADDRESS POSTAL CODE CITY COUNTRY In the following section please specify the insulation characteristics of your cellar Type of material and thickness Type of insulation and
13. st time several times a day During this position the compressor cannot sart Only the fan in the cellar can function The condensate water produced during this period will be evacuated through the tube 4 MAINTAINING THE WINEMASTER AIR CONDITIONER THE DUST FILTER It is essential to replace the dust filter which is outside the cellar as soon as necessary and at least once a year If it is clogged the air conditioner may be seriously damaged 4 1 CHANGING THE FILTER WITHOUT REMOVING THE COVER LE 22793 F AP E ee oo e ZA p If the wall is not too thick you don t need to remove the cover in order to change the dust filter Raise it at the notch under the air conditioner and remove it from underneath Repeat this action in reverse order to replace it 4 2 CHANGING THE FILTER BY UNSCREWING THE COVER Er ollie Ser Dale P 2 a A gt te 7 gt Er 4 ae 3 gt 7 If the wall is thicker than the air conditioner the bevel in the partition is not big enough to allow the filter to be removed In this case you must unscrew the four screws holding the cover in place and then lift the filter out Page 31 WINEMASTER C18 C18S R USER GUIDE November 2002 5 GUARANTEE 5 1 TWO YEAR CONTRACTUAL GUARANTEE The air conditioner is guaranteed for two years against manufacturing defects During the contractual guarantee period FONDIS will replace any part recognized as defe
14. the condensate collection tray Tighten the collar using a universal Refit the cover on the Winemaster The pipe is well attached wrench or pliers and tighten the 4 screws Important Wait for 24 hours before switching on the air conditioner Page 29 WINEMASTER C18 C18S R USER GUIDE November 2002 3 USING THE WINEMASTER AIR CONDITIONER The thermostat indicates the temperature in the wine cellar with a precision of 2 C A temperature change of the air does not mean the same change of temperature of the liquid due to the thermal capacity of the liquid The temperature is set at 12 C in the factory During installation the set temperature must be controlled and adjusted as shown in next paragraph if necessary paragraph 3 1 2 amp 3 2 2 3 1 STARTING UP MODEL WINE C18 3 1 1 CONNECTING THE AIR CONDITIONER When you plug it into the electrical socket the air conditioner starts up immediately lf the temperature in the cellar is higher than the thermostat setteing the compressor starts up immediately If the temperature in the cellar corresponds to the setting only the cellar fan which functions permanently will start 3 1 2 SETTING THE TEMPERATURE The temperature is set on the thermostat as follows Press buttons 1 and 2 at the same time until the set temperature is flashing Use button 1 to increase and button 2 to decrease the set temperature When the setting is right press both buttons at the same time to
15. thickness How did you learn about FONDIS WineMaster cellar air conditioning systems J through a trade show J through a vendor J through an editorial article J through an advertisement J other please specify
Download Pdf Manuals
Related Search