μPAC-5x07(P) Series
Contents
1. again it takes the control of Bus 000b again The change over time is about 5 seconds Control data is exchanging via Ebus if using a cross cable no require any Ethernet Switch All I O should be RS 485 I O except the status I O in the slot 0 XW107 Use COM1 or COM3 COM8 at the XW5xx RS 232 X board to connect one l 7530 the RS 232 to CAN converter to support CAN CANopen devices and sensors One PAC supports max 3 RS 232 ports to connect max 3 l 7530 modules Please refer to www icodas com gt FAQ gt Software gt ISaGRAF Ver 3 English 086 I O Modules Selection Guide XW Boards www icodas com gt Products gt UPAC 5000 gt XW Board Remote I O Modules Selection Guide RS 485 Remote I O Modules www icodas com gt Products gt Remote I O Modules Units gt l 7000 Modules gt l 7000 l Selection Guide www icpdas com gt Products gt Remote I O Modules Units gt M 7000 Modules gt M 7000 selection Guide RS 485 Remote Hot Swap Expansion Unit I 87K High Profile I O Modules R www icpdas com gt Products gt Remote I O Modules Units gt RU 87P1 2 4 8 Remote I O Expansion Unit gt Selection Guide High Profile 87K VO Modules Ww lcpdas com gt Products gt PAC 8K amp 87K I O Modules RS 485 Remote Expansion Unit I 87K I O Modules R www icpdas com gt Products gt Remote I O Modules Units gt l 87K1 4 5 8 9 Remote I O Expansion Unit gt Selection Guide l 87K I O Modules w2. es y 7000 M 7000 y RU 87Pn Remote I O RS 485 lt pPAC 5x07 P oe er ma ee kD ma Ethernet HPAC Series Expansion card There are several XW Boards to expand more I O channels COM Ports SRAM memory etc Send E mail with One Attached File e pPAC 5x07 P can send Email with one attached file via Ethernet Port The maximum file size is about 488K bytes e One Email can send to 10 receivers at one sending e Please refer to www icpdas com gt FAQ gt Software gt ISaGRAF Ver 3 English gt 067 amp 077 bX 4 Gateway Server in ISP Company D yPAC 5x07 P 1 NS 205 lt 1 COM2 RS 485 Ethernet Y RU 87Pn Y 1 7000 M 7000 Remote I O SMS Short Message Service e Allow user to request information or perform control tasks for the ISaGRAF PAC via personal cellular phone In addition the controller can also send information and alarms to user s cellular phone e Short message can be sent in multiple language format like Chinese English others e More at www icpdas com gt FAQ gt Software gt ISaGRAF Ver 3 English 111 Note tPAC 5207 5307 has built in GPRS no external GSM GPRS modem required A Report GTM 201 RS232 Request Control GSM GPRS Modem yPAC 5x07 P Integrate with CAN CANopen Devices and Sensors e pPAC 5x07 P supports max 3 I 7530 RS 232 to CAN Converters e Plea
3. ion Power reverse polarity protection Frame Ground Yes for ESD Protection Redundant Power Inputs Yes Input Range 12 48 VDC PoE IEEE 802 3af Class 1 Power Consumption 2 W uPAC 5x07D 5x07PD 2 5 W General Temperature Operating 25 C 75 C Storage 30 C 80 C Humidity 10 90 RH non condensing System CPU 80186 80 MHz 16 bit or compatible SRAM 768 KB Battery Backup SRAM 512 KB Data valid up to 5 years max 1024 retain variables FLASH 512 KB 100 000 erase write cycles microSD Expansion Yes ISaGRAF doesn t support NVRAM 31 bytes Battery backup data valid up to 10 years EEPROM 16 KB Retention gt 100 years 1 000 000 erase write cycles 7 Seg LED Display 5 Digit 7 Seg LED on the front of uPAC 5x07 D 5x07P D It can display message and value RTC Real Time Clock Provide second minute hour date day of week month year Watchdog Timers Yes Default 0 8 s NET ID User assigned by software 1 255 Hardware Serial Number Yes 64 bit hardware unique serial number Communication Interface COM1 RS 232 TxD RxD RTS CTS GND Non lsolated Baudrate Max 115200 bps Program downloads port COM 2 RS 485 D2 D2 Non lsolated self tuner ASIC inside Baudrate Max 115200 bps RJ 45 x 1 10 100 Base TX Program downloads port Ethernet Auto negotiating Auto MDI MDI X LED indicator LED Indicator Programmable LED 2 for User Defined Hardware Expansion I O Ex
4. lementation ISaGRAF uPAC supports SaGRAF Ver 3 Workbench e Support IEC 61131 3 Standard Open PLC se 22 Bee One Rane Programming Languages Flow Chart x ayia ey vet 1 LD Quick Ladder Diagram 2 FBD Function Block Diagram 3 SFC Sequential Function Chart 4 ST Structured Text 5 IL Instruction List 6 FC Flow Chart e On line debugging control monitoring e Off line simulation e Simple graphic HMI CY http www icpdas com As h f kaamen 1 of 8 pwPAC 5007 5007P 5107 5107P 5207 5307 Applications mm GPS Applications ISaGRAF PAC plus I 87211W or GPS 721 e wPAC 5007 P 5207 can support one I 87211W via COM1 RS 232 or I 87211W GPS 721 as RS 485 remote GPS I O e For doing auto time synchronization and getting local Longitude and Latitude e Please refer to www icpdas com gt FAQ gt Software gt ISaGRAF Ver 3 English 107 for more information e More GPS receivers at www icpdas com gt Products gt Wireless gt GPS receiver Note tPAC 5107 P pPAC 5307 has built in GPS function GPS Application ISaGRAF PAC I 87211W or GPS 721 iP 8x47 Longitug iw eA all me AN HPAC 5x07 P K VP 25W7 PS 721 ZigBee Wireless Solution e ISaGRAF PAC plus ZB 2550P and ZB 2551P ZigBee to RS 232 485 converters can apply wireless communication reduce the wiring cost and achieve the mission of remote I O control and data acquisi
5. oard supports I 7K I 87K I O modules as Remote I O 87K series must plug on RU 87P High profile or 87K Low profile I O Unit Max 64 I O modules for one PAC Built in COM2 Port to exchange data between ICP DAS s ISaGRAF PACs To exchange data between ICP DAS s ISaGRAF Ethernet PACs via Ethernet port Actively or passively sending E mail via Ethernet port through internet Max 10 receivers for each sending and can send E mail with an attached file Max file size is about 488 KB One of COM1 or COM3 RS 232 in XW Board can link to a GSM modem to support SMS User can request data control the controller by cellular phone The controller can also send data amp alarms to user s cellular phone Optional GSM modem GTM 201 RS232 GSM GPRS 850 900 1800 1 900 Note uPAC 5207 5307 has built in GPRS no external GSM modem required User can write his own protocol applied at COM1 COM2 amp COM3 COMB in XW Board by serial communication function blocks One of COMS3 RS 232 in XW Board supports ICP DAS s MMICON The MMICON is featured with a 240 x 64 dot LCD and a 4 x 4 Keyboard User can use it to display picture String integer float and input a character string integer and float Two PACs plug with XW107 in slot0 One is Master one is Slave Master handles all inputs amp Outputs at run time If Master is damaged or power off Slave will take over the control of Bus7000b If Master is alive from damaged or power up
6. pansion Bus Yes for one XW board Specifications pPAC 5x07 D 5x07P D Dimensions WxHxD PWM Output Pulse Width Modulation Output Counters Parallel DI Counter Remote DI Counter Remote High Speed Counter Protocols Modbus RTU ASCII Master Protocol Modbus RTU Slave Protocol Modbus TCP IP Slave Protocol Remote I O Fbus Ebus Send E mail SMS Short Message Service User defined Protocol MMICON LCD Redundant Solution CAN CANopen 91 mm x 123 mm x 52 mm All XW Board series DO boards support PWM output Max 8 channels for one controller 500 Hz max for Off 1 amp On 1 ms Output square curve Off 1 32767 ms On 1 32767 ms All XW Board series DI boards support DI counter Max 8 channels for one controller Counter value 32 bit 500 Hz max Min ON amp OFF width must gt 1 ms All remote l 7000 amp I 87K DI modules support counters 100 Hz max value 0 65535 Optional I 87082 100 kHz max 32 bit Up to 2 COM Ports COM1 COM2 and COM3 in XW Board support Modbus RTU ASCII Master protocol to connect to other Modbus Slave I O devices Max Mbus_ xxx Function Block amount 128 Up to 2 COM Ports COM1 and one of COM2 COMS in XW Board can support Modbus RTU Slave protocol for connecting ISaGRAF PC HMI OPC Server amp MMI panels Ethernet port supports Modbus TCP IP Slave protocol for connecting ISaGRAF amp PC HMI Max 6 connections One of COM2 or COM3 RS 485 in XW B
7. rts RTU ASCII RS 232 485 422 e Modbus RTU RS 232 485 422 Max 2 COM Ports It supports max 2 COM Ports e Modbus TCP IP Max 6 PC HMI SCADA connections COM1 RS 232 or COM2 RS 485 or COM3 if XW board is plugged in HMI e It can link to Modbus PLC M 7000 I O or Modbus devices ex Power meter temperature controller RS 232 inverter BERG BxO7F w Modbus Device v Lah ae Nap uPAC 5x07 P HMI Touch 8000 RS 485 Touch 6000 Touch 500 Data Acquisition Auto report System e wPAC 5x07 P can use UDP IP to auto report acquisition data amp control data to local or remote internet PC Server e VC 6 0 VB 6 0 and ISaGRAF demo programs are available e Advantage Each ISaGRAF PAC in the different location doesn t require a fixed Internet IP Stable and Cost effective Data Acquisition Auto Report System Y pPAC 5x07 P Provides 4 Level Internet Security Protection RS 485 Ethernet PC Server r y NS 205 uodhus RTU devices 1 7990 1 0 Ethernet ii ee RS 48 ns 205 Y pPAC 5x07 P ww Gateway Server F Ethernet in ISP Company Please refer to www icpdas com gt FAQ gt Software gt ISaGRAF Ver 3 English 065 Applications sm Local amp Remote I O Application Advantage of using RU 87P4 P8 I 87K I O modules e Hot Swap e Auto Configuration at run time e Plug amp Play at run time NOTE RU 87Pn support only High profile I 87K I O modul
8. se refer to www icpdas com gt FAQ gt Software gt ISaGRAF Ver 3 English 086 ISaGRAF Pac g E WinPAC PAC iPAC View PAC WP 8x47 uPAC 7186EG iP 8x47 VP 2117 VP 2xW7 amp 1 7530 RS 232 to CAN Converter t Po CAN NETWORK fi CANopen Device Sensor Applications ssn Data Exchange Ethernet amp RS 485 Data Recorder and Data Log e Through Ethernet Ebus e Through RS 485 Fbus e PAC to PAC Ethernet pPAC 5x07 P VP 2117 iP 8x47 ee pPPAC 5x07 P Ebus Ethernet PAC to PAC Data Exchange Ebus amp Fbus Communication Interface oi x gt i J HMI SCADA 4 Modbus TCP IP Ethernet lt pPAC 5x07 P Modbus Slave RS 232 I O Modules RU 87Pn l 87K High Profile I O Hardware amp Pin Assignment UPAC 5x07 P D Lock and Init Rotary Switch Programmable LED LAN LED LAN Pin Assigmengt Q COMI __COM2 7 Segment LED Display uzergass ZOUMeRMrFFOUADA P GND PWR1 P GND PWR2 F G Specifications pPAC 5x07 D 5x07P D uPAC 5007 D uPAC 5107 D l l Model APAC 5007P D APAC 5107P D uPAC 5207 D uPAC 5307 D System Software OS MiniOS7 DOS like embedded operating system Development Software ISaGRAF Version 3 IEC 61131 3 standard Languages LD ST FBD SFC IL amp FC Max Code Size Accepts max 64 KB ISaGRAF code size Appli x8m must lt 64 KB Power Supply Protect
9. tion e Please refer to www icpdas com gt FAQ gt Software gt ISaGRAF Ver 3 English 110 for more information Wireless Solution ISaGRAF PAC Plus ZigBee RS 232 485 Converter to Connect I 7000 1 87K ZB 2000P Series I O Modules or Modbus RTU ASCII Devices PC PC HMI PC HMI i CG ZB 2551P Slave ZB 2550P Ethernet Modbus TCP IP Host 1 7000 rar RU 87P4 8 I 87K High Profile I O PC HMI ISaGRAF PAC A E XP AEAT 123 NET ID 4 5 6 7 RS 232 485 VP iP f ae ee Pa Br Ki 4 S7 ZB 2000P Series 1 0 1 ZB 2550P NET ID 8 NET ID 9 a Host YS ZB 2551P gt KARN Slave a Se aS eee P ne KIS CC ZB 2551P Slave Modbus RTU ASCII RS 232 485 Device 4 l 7000 1 0 RU 87P4 8 I 87K High Profile 1 O Sis t I q M 70001 O Other Modbus Device a I i NET ID 4 5 6 wm e ee es es NET ID 10 11 12 NET ID 13 14 15 16 Applications sr Multi Client Connection VIP Communication Security yPAC 5x07 P File Edit Tools Options Help amp 2 PsBrm TLR S a sms ref 19 Z yan IP_1 10 0 0 88 Set VIP Very mas IP_2 10 0 0 25 caus IP_3 10 0 0 44 important IP No awe IP_4 10 0 0 7 w ISaGRAF TEST1 I O connec tion 22x am vip maj 1P_5 10 0 0 66 for Modbus TCP IP B ip ne mwj IP_6 N A 2 mn IP_7 N A ra a IP_8 NA security a 7 Modbus Master Modbus RTU TCP Slave Po
10. uPAC 5x07 P Series Advanced Ethernet ISaGRAF PAC ws OF ide Mees UPAC 5007D 4 ISaGRAF Ver 3 SoftLogic sotun Support IEC 61131 3 COM2 RS 485 15 32 User Defined 1 0 Pins Flow Chart 1 MiniOS7 Inside 80186 80 MHz CPU 10 100 Base TX Ethernet With GPS or GPRS wPAC 5x07P with PoE g T 4 Programmable Automation Controller w ow os w UPAC 5007 P 5107 P 5207 5307 GE uPAC 5x07 P Series is a palm size Programmable Automation Controller It has an 80186 CPU SRAM Flash Ethernet port RS 232 and RS 485 port With a DOS like OS MiniOS7 and a developed firmware running inside it can act like a small PC For hardware expansion it also supports an I O expansion bus The I O expansion bus can be used to implement various I O functions such as DI DO A D D A Timer Counter UART and other I O functions Nearly all kinds of I O functions can be implemented by this bus But the bus can support only one board There are more than 10 boards available for PAC 5x07 P series you can choose one of them to expand hardware features uPAC 5x07P is the model of uPAC 5x07 with PoE Power over Ethernet PoE allows power and data to be carried over a single Ethernet cable so a device can operate solely from the power that receives through the data cable This innovation allows greater flexibility in office design higher efficiency in systems design and faster turnaround time in set up and imp
11. ww icpdas com gt Products gt PAC 8K amp 87K I O Modules Ordering Information uPAC 5007 D CR Ethernet ISaGRAF Palm Size Programmable Automation Controller ROHS aaae aura e yPAC 5007 with PoE RoHS aaae a 07 2 uPAC 5007 with GPS RoHS aaae a a a e wPAC 5107 with PoE RoHS TIe A es uPAC 5007 with GPRS RoHS UPAC 5307 D CR UPAC 5007 with GPS GPRS RoHS Optional Using ISaGRAF 32 can control more than 32 I O tags Please refer to ISaGRAF User s Manual Ch 3 4 Note No upgrade service from ISaGRAF 32 to ISaGRAF 256 Development Software ISaGRAF 256 E ISaGRAF Workbench Software Ver 3 256 I O Tags ISaGRAF 256 C with USB Dongle and English Chinese application book E English C Chinese ISaGRAF 32 E ISaGRAF Workbench Software Ver 3 32 I O Tags ISaGRAF 32 C with English Chinese application book E English C Chinese Application Book ISaGRAF Book E ISaGRAF Book C NS 205 CR Unmanaged 5 port Industrial Ethernet Switch ROHS NS 208 CR Unmanaged 8 port Industrial 10 100 Base T Ethernet Switch ROHS NS 205PSE CR Industrial 5 Port PoE Ethernet Switch Power Supply ACE 540A DIN 540A 24 V 1 7 A Output Power Supply DIN 540A ACE 540A with DIN Rail Mount MDR 60 48 48V 1 25A 60 W Power Supply with DIN Rail Mounting Raj ISaGRAF application book E English version C Chinese version
Download Pdf Manuals
Related Search