User Manual English
Contents
1. Tamper with the Interlock device e Misuse abuse and or neglect the device e Try to fix or repair the Interlock device Handset WARNING Figure 1 Leave the tamper evident label in place Interlock Components Any attempt to remove the label is considered non compliance with the Interlock Program User Manual June 2002 Page 4 DRAEGER INTERLOCK USING THE INTERLOCK TURNING ON THE SYSTEM Insert key in the ignition switch Turn key to the ON position usually two clicks Turn key back to the OFF position The Interlock will display WAIT on the screen as shown in Figure 2 When the device is ready for the test it will display PLEASE BLOW Figure 2 and make a fast beeping noise Push a clean dry mouthpiece in all the way Figure 3 Align the notch of the mouthpiece with the groove on the handset Figure 3 a Insert mouthpiece Mouthpiece into opening inserted PLEASE Notice groove BLOW Handset Handset Figure 2 Figure 3 Wait Please Blow How to Insert Mouthpiece User Manual June 2002 Page 5 DRAEGER INTERLOC K TAKING THE BREATH TEST At the PLEASE BLOW prompt take a few normal even breaths then e Remove chewing tobacco candy and gum from your mouth You must not smoke during a breath test Trouble with the blow pattern See page 12 e Remove the Interlock from its holster or storage area e Breathe evenly and normally for three full br2. code from the Firmware Software nor shall Purchaser allow any other entity to do so The foregoing license is non transferable except in conjunction with a permanent transfer of the Hardware to another entity and providing such other entity expressly acknowledges and agrees to the terms and conditions of this license Maintenance Repairs of the described instrument may only be performed by Draeger Safety Inc Breathalyzer Division or an authorized service technician Only original Draeger spare parts may be used User Manual June 2002 Page 2 DRAEGER INTERLOCK TABLE OF CONTENTS O VETVICW ee piahasade cacdsgnd esata eee For Your Cy ss i hieikesie Device Components ae Using the Interlock Turning On the SYStel sssssssresrrssrrrernrsneressrrnrrrnnr Taking the Breath Test sen a a rr rr nr rr nr rn on Test ReEstliS i erreren unne E AEE E AGENES iG What Happens If I Fail the Breath Test smsmmssrssrssresersressrrssrserrsrrssrerrr ren TCI UNG asses cages secs se cuacauveeisecasaveconsesesseuadssaccsseseisesqeavacantedeivees Problems with the Breath Test Lockout Resulting from Missed Service cccccceeccecseececeeeeeeeteeeeneeees Proper Interlock Care as Vehicle Malfunction or Repairs and What To Do Index of Displayed Messages 2244042200002000ennnnnnennnnnnnnnnnnnnnnnnn nenn Contact Information 0 ccc cc ceccccccccccceseesessececccc
3. IMPORTANT The device will lock out permanently if not serviced when required LOCKOUT RESULTING FROM MISSED SERVICE What happens if the Interlock locks out for lack of service H If you do not get the device serviced in time it will go into permanent lockout When you try to start your vehicle you will see SERVICE REQUIRED If the device is in permanent lockout you must either e Schedule a service technician to perform a service call at your expense or e Tow the vehicle to a Draeger authorized Service Provider of your choice at your expense NOTE In some cases you may be required to tow your vehicle to the service center if you do not have the device serviced as required User Manual June 2002 Page 11 DRAEGER INTERLOC K PROPER INTERLOCK CARE Give clean breath samples e Make sure you take several normal breaths in and out before taking any test If you have been smoking right before a test Do not blow take a couple more deep breaths to clear your lungs of smoke cigar or Make sure the cab area is clear of thick smoke cigarette smoke into the Interlock e Ifyou have used mouthwash toothpaste anything containing alcohol or anything that can produce alcohol you should wait at least 15 minutes before taking the breath test Use a clean dry mouthpiece e A little fog on the inside of the mouthpiece is normal BUT if you see droplets of water change the mouthpiece Allow the wet one
4. e The device must be serviced every week s e The vehicle will continue to operate for day s after the above service period During these last few days you will see the message DEVICE LOCKOUT IN XX DAYS where XX is the number of days left for the vehicle to start When you see DEVICE LOCKOUT IN 01 DAYS that means the vehicle will stop working at midnight that night You must make immediate arrangements to have the device serviced If the vehicle stops working because you did not bring it in for service as required it will be your responsibility to tow the vehicle into the service center at your expense e The device will display FAILED and temporarily disable the vehicle when there is alcohol present in the breath sample e Ifyou fail test s in a row the device will enter the LOCKOUT period e The FIRST LOCKOUT period is minutes hours long After this time has expired you may try the test again e Ifyou fail another test s in a row the device will enter the SECOND LOCKOUT period for minutes hours After this time has expired you may try the test again e The HIGH BAC LOCKOUT period is minutes hours long e Ifyou do the test incorrectly times in a row the device will enter the FIRST LOCKOUT period After this time has expired you may try the test again If you do the test incorrectly another few times it will enter the SECOND LOCKOUT period After this time has expired you may try the test again e You have minute
5. handset at least 12 from cellular phone and radio Try the breath test again Device detected alcohol in the breath sample Vehicle will not start Wait for device to prompt PLEASE BLOW then take the test again Device will not allow a breath test Wait for Lockout time to expire Breath test passed Device is ready to accept a breath test Blow sample into mouthpiece using correct breath pattern Rolling Retest is required Blow sample into mouthpiece using correct pattern Page 15 DRAEGER INTERLOC K INDEX OF DISPLAYED MESSAGES SERVICE REQUIRED SUCKBLOW TOO HARD TOO SOFT WAIT CALL SERVICE PROVIDER DEVICE SERVICE RESET User Manual June 2002 Device must be serviced Vehicle can t be started Contact Service Technician Incorrect suck blow pattern Try the breath test again Remember that the suck portion is very short followed by a steady even blow Breath sample was too hard Try the breath test again but blow a little softer Breath sample was too soft or too short Try the breath test again but blow a little harder or longer Device is preparing itself for the test Wait for the Interlock to display PLEASE BLOW then take the test Device has detected a need for service Promptly contact Service Technician Device must be exchanged Contact Service Technician Page 16 DRAEGER INTERLOCK The Draeger Interlock device installed in your vehicle is programmed as follows
6. 8 1 2 x II sheet of paper to the technician If an automotive repair facility replaces the battery bring a copy of the full receipt for the charges parts and labor to your next appointment Body Work It is your responsibility to keep the interlock clean Cover the handset with a clean sock or towel while the vehicle is in the body shop If your vehicle will be in the shop for an extended amount of time you may be advised to seek authorization from your monitoring agent for a temporary disconnect of the interlock Ask the body shop to contact the Draeger Interlock technician for instructions OK START If the vehicle battery is low the battery terminals are loose or corroded the alternator belt is slipping or the alternator is bad the interlock may stay on OK START It will ask for a test every few minutes due to abnormal voltage Have the battery tested Clean the terminals Tighten the battery terminals Replace the terminal cable if required Have the alternator tested Check the alternator belt Reminder Do not leave the key in the ON position for the initial test Wait for the OK START DO NOT start the car on PASSED If you start the car and the handset displays OK START turn off the vehicle count to five and then start the engine again while revving the engine a little Make sure the running dot is going across the screen before driving off Vehicle Service Maintenance minor services such as oil change Plea
7. Dr gersafety DRAEGER INTERLOCK IGNITION INTERLOCK SYSTEM User Manual Draeger Interlock Inc 185 Suttle Street Suite 209 Durango CO 81303 7911 Tel 970 385 5900 Fax 970 385 5952 E Mail info ignitioninterlock com www ignitioninterlock com DRAEGER INTERLOCK Copyright 2002 All rights reserved Reproduction of this document in part or whole by any means electronic or otherwise is prohibited except by express written permission from Draeger Safety Inc Breathalyzer Division 185 Suttle Street Suite 105 Durango CO 81303 7911 Disclaimer The authors of this manual have incorporated their best efforts in preparing this information and ensuring that the technical content is completely accurate at the time of publication Draeger Safety Inc Breathalyzer Division accepts no responsibility for technical inaccuracies and reserves the right to make periodiciodic changes enhancements revisions and alterations to the programs and or its manuals without obligation to notify any person institution or organization of such changes enhancements revisions and alterations Safety For correct and effective use of the described instrument it is essential to read and strictly follow the instructions contained in this document The described instrument is to be used only for the purposes specified herein License Agreement The Firmware Software within the instrument is the property of Draeger Safety Inc B
8. The vehicle will not start User Manual June 2002 Page 6 DRAEGER INTERLOC K WHAT HAPPENS IF I FAIL THE BREATH TEST e Ifthe screen shows FAILED after the breath test the vehicle will not start The word DISABLED will flash on the screen for the number of minutes set in your program If the alcohol content of your breath was very high the device may be disabled for longer e Return the ignition key to the ON position and then turn it back to the OFF position The device will prepare for another test as soon as possible BE SURE TO TAKE ANOTHER TEST e When the device starts beeping fast and displays PLEASE BLOW try the test again NOTE Do not use mouthwash or any product containing alcohol for 15 minutes before testing Repeated failed tests could result in the device going into LOCKOUT Do not have food in your mouth while presenting a breath test LOCKOUT A What happens if the device goes into the LOCKOUT mode before I start my vehicle e Ifyou FAILED your first tests wait a few seconds after seeing LOCKOUT followed by DISABLED on the display Figure 5 e The display will show you how many minutes and seconds remain in the LOCKOUT period Plan to LOCKOUT DISABLED take another test e During the countdown the word DISABLED will alternate with the remaining time on the display Dr ger Dr ger e After the LOCKOUT is over the device will turn itself off Take another
9. breath test Turn key to the ON position and then off again Wait for PLEASE BLOW Figure 5 Lockout Mode User Manual June 2002 Page 7 DRAEGER INTERLOCK PROBLEMS WITH THE BREATH TEST TOO SOFT e If you hear two 2 long beeps during the test stop and look at the display TOO SOFT means that you did not blow hard enough or long enough The Interlock will automatically prepare for the next test e Take the test again and blow a little harder or longer TOO HARD e If you hear two 2 long beeps during the test stop and look at the display TOO HARD means that you blew too forcefully The Interlock will automatically prepare for the next test e Take the test again and blow a little softer SUCKBLOW e If you hear two 2 long beeps during the test stop and look at the display SUCKBLOW means that you did not do the suck portion of the breath test correctly e The Interlock will automatically prepare for the next test e Take the test again e Remember The suck portion of the BAC test should be very short See page 6 IMPORTANT A Rolling Retest is required by your State ROLLING RETEST The time interval is set by your State What is a Rolling Retest The Interlock program requires that you take additional tests during the journey You must give additional breath tests at random intervals perhaps several times before you turn off your vehicle The Rolling Retest is easy to do e When the Int
10. ceseeeesescecceseeaeeusnsecesceseeeees User Manual June 2002 PE E 7 Page 3 DRAEGER INTERLOC K OVERVIEW NOTE BAC Breath Alcohol Concentration FN P What does the Draeger Interlock do 7 e It allows you to start your vehicle after you blow a breath sample without alcohol H Use it correctly and you can continue to drive your vehicle A How does it work e The Interlock device measures and records your BAC level before you start your vehicle l When your BAC level is below the set limit your vehicle will start If your BAC level is too high your vehicle will not start The Interlock device will also ask you to blow other tests while you drive e The Interlock records all BAC readings vehicle starts engine shut offs violations etc as well as the date and time of each event These events are uploaded each time you go to the service center for monitoring 7 Does the device have to be serviced after installation e Yes The Interlock will indicate when service is due You will not be able to start your N vehicle if you do not have the device serviced as required e Make sure you get the device serviced as required See page 17 for your service requirements FOR YOUR SAFETY DEVICE COMPONENTS Do e Read and follow all instructions on using and caring for the device e Contact your Service Technician with any questions or concerns e Avoid products containing alcohol ea Mouthpiece Don t
11. e Malfunctions or Repairs and What To Do Charging a dead flat or weak battery Your interlock will detect a loss of power Document the date and time that the battery went flat Give this information in writing on an 8 1 2 x 11 sheet of paper to the technician If the battery really should be replaced purchase a new battery and replace it on the same day Remove both the positive and negative terminals from the battery Consult a manual of the vehicle battery charger for the correct method of charging the battery Disconnecting Battery Your interlock will detect a loss of power Document the time and date that you disconnected your battery and the reason Give this information in writing on an 8 1 2 x 11 sheet of paper to the technician Make copies of all receipts for parts purchased to make a repair or add a component to your vehicle Give the copies to your interlock technician Replacing Battery Your interlock will detect the loss of power Purchase a new battery and replace it on the same day Give a copy of the receipt to the technician at your next appointment User Manual June 2002 Page 13 DRAEGER INTERLOC K Vehicle Malfunctions or Repairs and What To Do Note If you are replacing a battery yourself bring a copy of the receipt for the purchase of the battery to your next monitoring appointment Documentation is required Do not move a battery from one vehicle to another Give this information in writing on an
12. e device may continue to request the Retest D What happens if I don t take the Retest in time e The vehicle s horn may honk on and off and the headlights may also flash e You must pass the retest in order to turn off the horn and lights if applicable e The device may continue to request the Retest 7 What happens if I fail the Rolling Retest e Don t panic Make sure your mouth is free of alcohol vapors food and smoke H e The device may request another sample e Ifthe alcohol level was low the device will automatically start another Retest When you see WAIT then hear the fast beeps take the test as before e Ifthe alcohol level was too high the device may go into the LOCKOUT mode If you see LOCKOUT you must pull over and turn off the engine immediately Wait for the LOCKOUT timer to count down then take the test again BE SURE TO TAKE THE TEST AGAIN User Manual June 2002 Page 9 DRAEGER INTERLOC K SERVICE REQUIRED The device e Must be serviced periodically e Will remind you of an upcoming service appointment by starting a countdown it will not tell you the exact time and date e Will display DEVICE LOCKOUT IN XX DAYS before your next appointment You will see it each time you start your vehicle If you see this message and you have not made an appointment for service call the service provider number to make your appointment e Will remind you before it locks out permanently e On the last day b
13. eaths e Take a deep breath filling your lungs to nearly full and put your lips around the mouthpiece e Give a short sharp suck back less than a half second then an immediate steady blow into the mouthpiece e Do not pause between the suck and the even blow e As you blow into the device it will make a fast beeping noise This sound means you are blowing correctly so DON T STOP e When the fast beeping stops the test is over and you can stop blowing NOTE If you turn key to the ON position just to get enough power to roll Keep the handset at up your windows etc and you see PLEASE BLOW you do not need to take the test Simply turn key to the OFF position least 12 from radio and cell phone TEST RESULTS The Interlock will display PASSED or FAILED if the blow pattern was correct PASSED After a test with no alcohol is detected the PASSED message is replaced with OK START Wait until you see OK START before you start the vehicle When you turn the key you will see CRANKING followed by a scrolling dot NOTE You have at least a minute to start the vehicle after passing a breath test If you do not start the vehicle within that time you must pass another test NOTE If the device message remains on OK START turn off the vehicle and restart it An engine run is indicated by a scrolling dot FAILED After a test with alcohol is detected in the breath sample the device shows FAILED
14. efore it disables the vehicle for lack of service you will see DEVICE LOCKOUT IN 01 DAYS NOTE The message DEVICE LOCKOUT IN 01 DAYS means that the device will lock out at 12 00 AM midnight that night You MUST have the device serviced that day or it will LOCKOUT permanently You must go to your Service Provider eax When Service is required e When the device displays SERVICE REQUIRED meaning it has ne gone beyond its service date REQUIRED e When the vehicle cannot be started due to permanent lockout Dr g The Service Technician will collect the stored information and e Note the odometer reading e Check the Interlock for evidence of tampering eae ak e Check wiring and connections e Calibrate the Interlock at the specified interval e Collect your payment e Schedule your next appointment Figure 6 Service Required Mode User Manual June 2002 Page 10 DRAEGER INTERLOC K VIOLATION RESET The Interlock is programmed to require monitoring earlier than usual if it detects violations VIOLATION RESET might be caused by e A failed Breath Alcohol Test e A skipped Retest e A failed Retest e Tampering e Trying to circumvent the Interlock If you see DEVICE LOCKOUT IN XX DAYS and you know that you are more than about a week from your next appointment contact your Service Provider and make an appointment for service There is an additional fee for violation reset
15. erlock prompts a retest it will make a fast beeping sound e The Interlock will display RE TEST REQUIRED twice then PLEASE BLOW e Take the test exactly as you do when you start your vehicle Immediately put out cigarette e Do the test within the specified time e When you see PASSED put the device back in its storage area and continue your trip e The roaming dot will return to the display e The dot will remain for the duration of the trip or until the next random Retest User Manual June 2002 Page 8 DRAEGER INTERLOCK ROLLING RETEST HINT Remember that you have several minutes to take the Retest If you do not take and pass the Retest within a few minutes you will hear a reminder beep from the handset and the vehicle s horn may honk twice The beeps are a reminder to take the test Should you not feel confident in presenting the Retest while driving bring the car to a halt away from traffic and in a safe area and then perform the Retest 2 What happens if I turn my vehicle off during the Rolling Retest e Once the device asks for a retest you must take and pass the Retest e A violation will be recorded if you don t take the retest in the time allowed e The device may continue to request the Retest 2 What happens if I don t hear the Rolling Retest prompt e Your vehicle s horn may honk twice briefly to alert you e The vehicle s horn may continue to remind you that the Retest is required e Th
16. f the line until the call is returned e Phoning multiple times will not reduce the response time e Most pay phones will not accept incoming calls e If your telephone will not accept calls from phones whose number is blocked you must temporarily disable this feature in order for your call to be returned User Manual June 2002 Page 18
17. reathalyzer Division and is protected by US Copyright Law Trademark Law and International Treaty Provisions No ownership in or title to the Firmware Software is transferred to the Purchaser Draeger Safety Inc Breathalyzer Division does not grant any express or implied right to Purchaser under Draeger Safety Inc Breathalyzer Division s patents copyrights trademarks or trade secret information except as set forth immediately below DSI grants Purchaser a non exclusive license to use the Firmware Software as part of Purchaser s use of the Hardware and under the following terms and conditions 1 Purchaser shall not remove or obscure Draeger Safety Inc Breathalyzer Division s copyright trademark or proprietary notice from the Hardware and any documentation associated with the Hardware 2 Purchaser shall not copy sell transfer loan rent lease modify extend improve or create derivative works or alter the Firmware Software in any way nor shall Purchaser allow any other entity to do so without the express written consent of Draeger Safety Inc Breathalyzer Division 3 Purchaser shall take appropriate steps to prevent any unauthorized copying of the Firmware Software 4 Purchaser shall not take any actions inconsistent with Draeger Safety Inc Breathalyzer Division s ownership of the Firmware Software 5 Purchaser shall not reverse engineer decompile or disassemble the Firmware Software or otherwise attempt to derive source
18. s to start the vehicle after you pass the BAC test e The device will ask you for the first retest to minutes after you start the engine After that the device will ask you for other retests every to minutes e You have minute s to pass the RETEST Failure to pass a RETEST within this time will result ina VIOLATION being recorded and if the engine is running it may honk the horn and or flash the headlights e Ifyour vehicle stalls or you turn it off for any reason you may restart it within minute s without having to pass another breath test e The device will enter the VIOLATION RESET mode after violation s If not serviced within day s your vehicle will become disabled You will see only SERVICE REQUIRED displayed on the interlock User Manual June 2002 Page 17 DRAEGER INTERLOCK CONTACT INFORMATION For appointment information please call Your Program Number is You will need this number whenever you call your service provider For emergencies only please call to contact a service representative Please allow up to 45 minutes for the call to be returned Make sure your phone allows incoming calls from a cell phone or unknown telephone number Remember e Before you phone a service technician please make sure you know exactly which message is being displayed on the interlock Write the message down and take it with you so it will be handy when the call is returned e After you phone please stay of
19. se stay with the vehicle for this type of quick service Ensure that alcohol free solvents are used in your vehicle If not be sure the vehicle is aired out before you take an initial test Vehicle Service major repairs including replacing alternator starter and starter relay Ask the automotive technician to contact the Draeger Interlock technician for instructions Ensure that alcohol free solvents are used in your vehicle If not be sure the vehicle is aired out for at least 15 minutes before you take an initial test If your vehicle repairs take more than a few days you may be required to make up time on your interlock program User Manual June 2002 Page 14 DRAEGER INTERLOC K INDEX OF DISPLAYED MESSAGES DEVICE LOCKOUT hh mm ss IN XX DAYS DISABLED Dot moving across screen OK START FAILED LOCKOUT PASSED PLEASE BLOW J lt p O O A RE TEST REQUIRED User Manual June 2002 Device has indicated LOCKOUT time remaining Wait for countdown to finish Turn key to ON and try test again Device will LOCKOUT in XX days Contact your Service Technician immediately to make a service monitoring appointment If the Interlock shows DEVICE LOCKOUT IN 01 DAYS it will lock out permanently at midnight Device is not ready to accept a breath test Wait Engine is running If you are done driving turn off the vehicle Vehicle can be started Radio Frequency Interference Move
20. to dry before using it again e Ifa mouthpiece becomes dirty inside or out wash it with hot soapy water Let the mouthpiece dry before using it again Keep it dry e Like a radio or cellular phone the Interlock will not work properly when it is wet To keep it dry e Keep the Interlock in a secure place in the vehicle e Make sure your windows and sunroof are closed when you are away from your vehicle e DO NOT spill anything onto the Interlock If you spill something onto or into the Interlock contact your Service Technician immediately DO NOT turn the key to the ON position NOTE You will be held liable for the costs to replace or repair the device if it gets wet User Manual June 2002 Page 12 DRAEGER INTERLOCK PROPER INTERLOCK CARE Exterior care e Use a lightly dampened cloth to wipe off dirt if the outside of the handset becomes dirty e Never use a cleanser or soap on the handset e Fora soiled or dirty handset please request that the Service Technician clean it for you at your next monitoring appointment Misuse Abuse and or Neglect e Take care of the Interlock while you are renting it and it is in your possession e Treat the Interlock with care as you would any portable electronic device e Always place the handset in a secure place in the vehicle e You will be held liable for damage which the Service Provider Manufacturer believes has been caused by misuse abuse and or neglect Vehicl
Download Pdf Manuals
Related Search