Sharon Brush Extractor
Contents
1. K KERRICK OPERATING amp MAINTENANCE MANUAL SHARON BRUSH CARPET amp UPHOLSTERY EXTRACTOR Read Safety amp Operating Instructions Before Commencing Operation Operating amp Maintenance Manual lt A KERDICK Shampoo Machines amp Extractors THESE INSTRUCTIONS MUST BE READ AND ADHERED TO BEFORE OPERATING THIS MACHINE INTORDUCTION Your new Kerrick Upholstery Carpet cleaning machine is a wise investment Manufactured in Italy this is a high quality unit that if treated properly will give many years of service To get the best from your Kerrick machine we suggest you follow the operating and maintenance details contained in this document SAFETY MANAGEMENT PROCEDURES These Instructions must be read and adhered to before operating this machine Failure to do so may result in injury to the operator nearby persons or damage to property or this machine e The packaging around the cleaner plastic bags clips ties etc pose a choking hazard and should be kept out of the reach of children and animals e This machine is not designed to be used by children or mentally disabled individuals and if used incorrectly can be harmful e The end of the suction hose accessories must be kept away from your face and the faces of others at all times during operation as the suction created can cause damage to the eyes ears an mouth in particular e This machine is NOT intended for use on animals e Do not use adapters or2. At this point it is possible to connect the accessories to the machine through the special connecting hoses Q AN SD Vacuum hose Solution hose SHARON BRUSH EXTRACTOR Operating amp Maintenance Manual lt A KERDICK Shampoo Machines amp Extractors O 2 Switch on the vacuum motor by setting their switch to position I and the pump by setting the switches to position II In this way the solution pump always works and it is not necessary to keep pressed the control lever situated on the control panel 3 To spray water you need to press the lever situated on the handle of the accessory Maintenance The Sharon Brush is a commercial machine with 1 year commercial warranty against manufacturing defects Faults due to improper use are not covered by warranty For further details regarding warranty contact the distributor supplying the machine or view the products warranty page on the Kerrick website To get the best value for money and to improve the longevity of your machine take note of the following advice 1 After each use before storing the machine remove all the water from the solution and recovery tank Put a couple of liters of clean water into the solution tank and using the pump only press the lever of the solution valve to clean the internal parts of the pump of the couplings and nozzles removing the detergent residues 2 After every use store the machine in a cool dry place with the cover open t
3. multiple sockets without knowing the electrical input of each user e f any electrical extension is used check that it corresponds to the absorbed power of the machine and that the connection of the plug with the socket is complying and sealed e Take care of the electrical cable It must be protected from water tears and chemical agents Do not repair the cable in case of tears but replace it with a new one The cable must be replaced by the manufacturer or its service agent or a similarly qualified person in order to avoid further hazard e DO NOT pull the cable to drag the machine or to pull the plug out e Pull the plug out only when the machine is switched off e DO NOT handle the plug with wet hands e Unplug cable before servicing machine e DO NOT spray water near electrical outlets e DO NOT use the machine to spray or to suck corrosive liquids acids or bases and explosive or flammable liquids SHARON BRUSH EXTRACTOR Operating amp Maintenance Manual lt A KERDICK Shampoo Machines amp Extractors O e Never use flammable liquids or operate machine in or near flammable liquids vapors or combustible dusts e When using the unit as a wet vacuum cleaner you must check the level of water in the recovery tank to ensure it doesn t get to high If water is sucked into the motor it can cause electrical damage e f the chemical you are using produces foam or if you are cleaning carpet previously treated with shamp
4. Machines amp Extractors IF ANY ASSISTANCE IS REQUIRED CONTACT YOUR NEAREST KERRICK BRANCH SERVICE AGENT OR DISTRIBUTOR gt NEW ZEALAND 0800 2 KERRICK 0800 253 774 gt AUSTRALIA 1300 KERRICK 1300 537 742 KERRICK SERVICING Kerrick s workshop facilities are staffed by experienced technicians providing servicing repair and manufacturing for a range of products including extractors vacuum cleaners water blasters pressure cleaners pumps and more We work on everything from commercial and light industrial to large heavy duty equipment and offer customized design build services We also warehouse and ship a comprehensive range of spare parts for your convenience For more information on your product to book in a service or repair or to order spare parts give Kerrick a call or send through and enquiry on our website Contact details can be seen below KERRICK NEW ZEALAND KERRICK AUSTRALIA 0800 2 KERRICK 0800 253 774 1300 KERRICK 1300 537 742 SALES KERRICK CO NZ SALES KERRICK COM AU WWW KERRICK CO NZ WWW KERRICK COM AU SHARON BRUSH EXTRACTOR
5. control panel 1 Set vacuum motor switch to position I 2 Set the pump switch to position I At this setting the solution pump works only while you rotate the hand grip of the machine SHARON BRUSH EXTRACTOR Operating amp Maintenance Manual lt A KERDICK Shampoo Machines amp Extractors 3 To clean carpets rotate the lever on the vacuum head towards the right side To clean hard floors rotate it towards the left side Set to clean carpets Set to clean hard floors _ CURRCC TRA CCCTSTUTT ETT ACER CCRC eT 4 To activate the rotating brush switch on the power brush motor also activate the correspondent luminous switch located in the near the vacuum head 5 Slowly drag the Sharon Brush across the carpet allowing the injection extraction to break down dirt and suck up the waste water into the extractor Repeat the process over the entire carpet area and then leave to dry with the windows open for a few hours Using Accessories to Clean Small Areas amp Upholstery After filling the tanks with solution and inserting the plug in the wall outlet you need to perform the following operations 1 Connect the machine to the wand or to the hand tool using the solution and vacuum hoses To connect the hoses to the machine remove the vacuum hose which connects the upper tank to the vacuum head and the solution hose which connects the pump to the spraying nozzle situated under the machine
6. cuum cleaner gt DO NOT let the pump run without any water in it Check periodically the level of water in the lower tank while using the machine As soon as it becomes empty you must switch off the machine empty the upper tank which then will be full and refill the lower tank before activating the pump gt Wool carpet must be washed with cold water only Machine Set Up The following steps explain the necessary operations to prepare the machine for use 1 Put the machine in the normal working position and adjust the handle to a height that is comfortable for you va N l ai SHARON BRUSH EXTRACTOR Operating amp Maintenance Manual lt A KERDICK Shampoo Machines amp Extractors 2 Fill in the lower tank solution tank with cold or warm water through the filling hole adding a 5 of not foaming detergent 1 2 liter each 10 liters Higher concentrations can be used in case of particularly dirty surfaces gt BECAREFUL not to over fill the lower tank Water overflowing from the tank can cause the electronics on the system to short Always take care when using water around electrical items 3 Close the filling hose with the cap 4 Insert the plug of the cable into a wall socket Washing Carpet amp Hard Floors The Sharon Brush washes and dries with the spray nozzle and the vacuum head which are situated below the body of the machine To switch on the machine you must use the switches on the
7. e instructions for both the extractor machine and the chemical detergent As a precaution always test a small area of the carpet first For an extra strength clean fill the tank with water and detergent and spray the carpet without using any suction Allow the solution to sit in the carpet and break down the dirt for a few minutes Then go over the area again with the injection extraction system but this time using only clean water and NO detergent SHARON BRUSH EXTRACTOR 3 Operating amp Maintenance Manual lt A KERDICK Shampoo Machines amp Extractors OPERATION INSTRUCTIONS FOR ELITE SILENT The Sharon Brush is designed to clean large areas of carpet and hard floor without the need for external accessories as the washing device is located below the body of the machine It is also possible to clean upholstery inside of cars or hard to reach areas by using additional accessories which must be connected to the machine with connecting hoses see paragraph Use with Accessories Its body is composed of two high density polyethylene tanks kept together with elastic hooks The upper tank is meant to contain the dirty water sucked from the carpet while the lower tank is meant to contain clean water and detergent The lower tank also contains the vacuum motor the pump and the control panel The vacuum head the spray nozzle and the rotating brush are situated below the lower tank ATTENTION gt DO NOT use the machine as a va
8. o prevent humidity and mould forming inside the recovery tank and on the internal parts of the vacuum motor damaging it The damage provoked by humidity that condenses on the motor like the damage caused by the foam sucked by the motor is not covered by warranty 3 Periodically clean the water filter extracting it from the machine and rinsing it under flowing water 4 Eliminate the lime that in time deposits inside the hydraulic circuit of the machine by putting some anti lime solution in the solution tank and leaving it for two to three hours Then empty the tank and rinse You should do this every 6 8 months 5 Periodically check and clean the filter of the vacuum motor which is located under the transparent circular cover of the upper tank 6 Periodically check the consumption of the carbon brushes in vacuum motor This check should be done after 500 working hours 7 Worn out carbon brushes may result in damage to the vacuum motor or pump which are not covered by warranty The check of carbon brushes should be done by a trained technician 8 Periodically check that the brush rotates without problems and remove anything that prevents a free rotation In case of difficulties contact a trained technician NOTE Incorrect use or failure to follow operating and maintenance procedures may produce an injury to a person or damage to the equipment SHARON BRUSH EXTRACTOR Operating amp Maintenance Manual lt A KERDICK Shampoo
9. oo you must add anti foaming liquid into the recovery tank Foam sucked up by unit that gets into the motor can cause damage over the long term e Should the machine leak liquid or foam make strange noise or get abnormally hot switch off the machine immediately and take it in for a service e This extractor should NEVER be immersed in water e DO NOT use solvent or strong detergents to clean this machine e When using warm water for upholstery carpet cleaning the water temperature MUST NOT EXCEED 60 C e Store the machine well cleaned in a cool and dry place WARNINGS gt All the electrical repairs must be performed by qualified personal only gt Kerrick cannot be held responsible for any damage injury caused to persons or property because of the incorrect use of the machine due to procedures being used which are not specified in this instruction manual THE CLEANING SYSTEM INJECTION EXTRACTION Carpets are a natural dust trap and breeding ground for germs and therefore require a professional clean from time to time Kerrick s hygienic and easy to use system injects water mixed with detergent into the pile of the carpet dissolving dirt and grime that has become trapped there As the carpet is being shampooed the waste water is sucked back up into the extraction machine making for mess free easy cleaning and quicker drying times To avoid causing any damage to the fibres of the carpet ensure you read and adhere to all th
Download Pdf Manuals
Related Search