User manual for - Hyundaipower.ca
Contents
1. aniq aniq aniq an q x e1q om x9e1q an q an q sayoy Ae ny Ix H AM 39018 TANVd 1OH1NOO P Sum januog an q B m poi eng Sum lt HUM yq E pal abuelo en jos 1 EL E abuelo FH pas 291 SUM em P TJ 1 P6 ni 09916 pue uh us oa T B pueog 1ojeoipu a 1 E 9 i Lie lonuoO uoywg au bug H Jojo pay IIO pay yoe q Sum 9 Warranty Terms and Conditions Canadian distribution of Hyundai branded Portable generators are distributed by Midland International 26 Huddersfield Rd Unit 2 M9W 5Z6 Canada This product is warranted to be free of defects in material and workmanship for two years from date of purchase This warranty guarantees that any defective parts will be repaired or replaced at no cost including diagnosis and replacement parts Limited Warranty periods Recreational residential use 2 years limited 1st year parts and labor 2nd year parts o2. 11 4 Operation 4 1 Starting the generator 14 4 2 Using the generator 561 17 4 3 Stopping the generator 23 5 Maintenance 5 1 Importance of 25 5 2 Maintenance 25 5 3 Air filler service ea 27 5 4 Changing engine oil 28 5 5 Spark plug 29 5 6 Transportation 4 32 6 Troubleshooting nemine 34 T Specifications amp Data cierra Padi Yeh panis 36 8 Wiring Diagram respeta ete its 38 9 semet ete edt 40 LO GIOSSARY i ae anne 43 11 Questionnaire du tenent 45 12 48 HYUNDAI 1 PRECAUTIONS 1 1 LABELS This symbol warns of hazards which can result in severe or lethal personal injury This symbol refers to a hazardous or unsafe practice which has the potential to result in personal injury or product property damage CAUTION This symbol warns of immediate hazards which will result in severe or lethal personal injury 1 2 OPERATIONS SAFETY Operate the generator according to instructions for safe and dependable service Always perform pre o
3. Check Bn adjust Replace Valve Check clear readi st to no ance J tice 2 After every 300 hrs refer to notice 2 Fuel tank e refer to and Clean notice 2 Filter Fuel Every 2 years Replace if necessary Refer to NOTICE 1 Service more frequently when used in dusty areas 2 Should be serviced by an authorized dealer HYUNDAI 5 3 Air Filter Service 1 Loosen the cover screws nuts and remove the maintenance cover 2 Remove the air filter cover 3 Remove the air filter sponge refer to Fig 5 0 4 Check the filter sponge to make sure that it is clean and in good condition If the sponge is dirty clean it as described in Fig 5 1 Replace the sponge if it is damaged To clean the sponge 1 Clean the sponge in warm soapy water or nonflammable solvent rinse and allow to dry thoroughly 2 Dip the sponge in clean engine oil and squeeze out all excess oil The engine will smoke when started if too much oil is left in the filter 3 Wipe dirt from the air filter cover using a moist rag Maintenance cover Screws Air filter cover Fig 5 0 Cow ep SD LP Fig 5 1 4 Reinstall the sponge and the air filter cover HYUNDAI 5 Close the maintenance cover with screws 5 4 Changing Engine Oil Make sure the start switch is in the STOP position before draining Please dispose of used motor oil in a manner that is com patible with the environment W
4. HYUNDAI www hyundaipower ca x GreenPewer Inverter Series USER MANUAL 4000 2000 A gt 5 gt REVIEW MANUAL CAREFULLY TO AVOID PERSONAL INJURY HYUNDAI Licensed by Hyundai Corporation Korea HYUNDAI PREFACE Thank you for purchasing a Hyundai Portable Generator Please register your product in order for us to ensure your continuous satisfaction with our product This manual covers the safety operation and maintenance proce dures for the HY1000SI and HY2000SI models All information in this publication is based on the latest product information available at the time of approval for printing No part of this publication may be reproduced without written per mission If a problem should arise please contact us by using the contact information at the end of this manual It is important that this manual be read and fully understood before operating the generator set Failure to do so may cause serious injuries or equipment damage HYUNDAI TABLE CONTENTS 1 Safety Precautions 1 1 Safety labels 3 1 2 Operations 5 3 1 3 AC safety 5 4 1 4 Maintenance 4 1 5 Other safety 5 5 2 Identification of Components 6 3 Pre Operation
5. authorized dealer Disconnecting the charging wire 1 Stop the engine 2 Disconnect the negative black terminal of charging wire from the negative battery terminal 3 Disconnect the positive red terminal of the charging wire from the positive battery terminal 4 Disconnect the charging wire from the DC Receptacle of the generator HYUNDAI 5 MAINTENANCE 5 1 Importance of Maintenance Proper maintenance is important because it will ensure safe eco nomical and trouble free operation It will also reduce air pollution Improper maintenance may cause the generator to malfunction and can lead to serious injuries or death 5 2 Maintenance Schedule Shut off the engine before performing any maintenance When the engine is running make sure the area is well ventilated The exhaust contains poisonous carbon mon oxide gas Use authorized parts or their equivalent The use of replacement parts which are not equivalent quality may damage the generator NOTE Some of these maintenance techniques can be dangerous and should be performed by a qualified technician For HY1000Si HY2000Si In order to maintain good performance and extend the service life of the generator period inspection and adjustments should be done based on the following maintenance schedule HYUNDAI Mainte nance gine level Oil change __ Check Air refer Filter Clean to no tice 1
6. generator The battery gives off explosive gases keep sparks flames and cigarettes away Provide adequate ventilation when charging or using batteries Battery posts terminals and related accessories contain lead components Wash hands after handling c Connect the positive red terminal of the charging wire to the positive battery terminal and negative black terminal of the charging wire to the negative battery terminal 3 Press the start switch to RUN position 4 Press the DC breaker switch to ON position Refer to Fig 4 12 for HY1000Si and Fig 4 13 for HY2000Si 5 Start the generator 4 3 STOPPING THE GENERATOR SET For HY1000Si HY2000Si AC Operation 1 Turn off the device and unplug devices from the generator recep tacles 2 Press the start switch to the STOP position 3 Rotate the fuel switch to the OFF position in the clockwise direc tion NOTICE Be sure the fuel SWITCH is in the OFF position and the start switch is in the STOP position when stopping transporting and or storing the generator HYUNDAI For HY1000Si HY2000Si DC Operation only NOTICE An overloaded DC circuit excessive current draw by the bat tery or a wiring problem will automatically trip turn off the DC breaker switch If this happens wait a few minutes before press ing the breaker switch to the ON position to resume operation the breaker switch continues to go OFF discontinue charging and contact your
7. no defects Recommended Action Send the generator to an authorized dealer Restart if the overload indicator is off If it doesn t work send the generator to an authorized dealer Send the generator to an authorized dealer Send the generator to an authorized dealer If there is no power in the direct current electric outlet Problem Electric circuit breaker is not intact Electric circuit breaker is intact Deficient AC Output Problem Dirty air filter Improper gasoline Recommended Action Replace the electric circuit breaker Send the generator to an authorized dealer Recommended Action Clean or replace air filter sponge Replace gasoline Send generator to authorized dealer HYUNDAI 7 SPECIFICATIONS 8 DATA HY1000i Type Digital Inverter Sine Wave EER Rated AC Output Power kW Max AC Output Power kW LLI GENERATOR Voltage Model XG142F OHV Forced Air Cooling single cylinder 4 stroke Gasoline engine Bore x Stroke mm x mm 43 5 x 36 Displacement cc Rated Power kw 1 2 5000rpm Recommended fuel Fuel tank capacity L Fuel consumption h Engine oil capacity L Continuous work time hours Noise level 7m Type Indicator light AC Overload Protector STANDARD FEATURES AC Socket DC Socket 12v 8 3A Packing dimensions mm 490 x 300 x410 OPTIONAL FEATURES DIMENSIONS G W kg HYUNDAI
8. place of purchase for repair MIDLAND INTERNATIONAL INC SHOULD BE CONTACTED TO PROVIDE A CASE NUMBER BEFORE WARRANTY WORK CAN BEGIN To obtain warranty service Contact our customer support centre Toll free 1 877 528 3772 E mail support Hyundaipower ca Website Hyundaipower ca HYUNDAI 10 GLOSSARY socket The receptacle for the device plug used for applica tion AC Circuit Protector It protects AC circuits from being damaged due to overload or short circuit by stopping the flow of electricity between the generator and device Air Filter lt removes dust from engine intake air Carburetor A device used to properly mix fuel and air in the cor rect proportions and delivering the mixture into the engine s com bustion chamber Choke Rocker It is used to provide proper starting mixture when the engine is cold The choke lever must be pulled out to ON posi tion when starting a cold engine DC Breaker Switch It protects DC circuits from being damaged due to overload or short circuit by stopping the flow of electricity between the generator and device DC socket the receptacle used for charging a 12 V battery Dipstick It seals off engine oil fill hole and is used for indicating the engine oil level Drain Plug A plug that can be removed to allow the fluid contents of the engine to be drained off ECON Switch 15 used for automatically reducing engine speed when all loads are turned off or disconne
9. HY2000Si Type Digital Inverter Sine Wave Frequency Rated AC Output Power Max AC Output Power i Voltage V 120V XG152F OHV Forced Air Cooling single cylinder 4 stroke Gasoline engine Bore x Stroke mm x mm Recommended fuel Fuel tank capacity L 7 GENERATOR Type Fuel consumption h 380g kw h Engine oil capacity L Continuous work time hours Indicator light STANDARD FEATURES AC Socket DC Socket 12v 8 3A T or V Type Packing dimensions mm 575 x 330 x 525 OPTIONAL FEATURES DIMENSIONS G W kg HYUNDAI 8 WIRE DIAGRAMS For HY1000Si Z LLI U93IMS 093 Joyes pul mn A 110 UJ Ir 1109 1 Jaued 10jeoipui Jojou dejs 5 ve 8 3eyoos 21 OUUM 02 Supu 3131552 uaa b pue mojjak U quiesse 1 yoelq 7 pois gy lt Buipui Od saye Juano 20 ov 194991 pe ov NE For HY2000Si DN m u 1 pue 319V1d3938 DA send
10. MB Label Placement For HY2000Si ATTENTION ATTENTION r add fuel when the engine is running Ne jamais ajout r add fuel when engine is hot vays add fuel in a well ventilated area an up fuel spills Toujours transf r Toujours ramasser les fuit Ne jamais ajouter du carburant lorsque le moteur es le carburant dans un endroit bie ATTENTION ATTENTION err Susan to IMPORTANT IMPORTANT ATTENTION ATTENTION HOT SURFACES KEEP CLEAR OF EXHAUS SURFACE CHAUDE GARDER L CART DE Li DU MOTEUR HYUNDAI Voltage Voltage CA DC Voltage tage CC Power Output Sortie de Duration Continuat Engine RPM du moteur Max Output Power 1000 Production maximale de voltage AC Phase Phase insulation class Licensed by Hyundai Corporation Korea Licenci par la corporation Frequency Fr quence Max ambient teperature Temp rature ambiante maxima Cor FOR ELECTRICAL EQUIPMENT ONLY POUR MATERIEL ELE JLEMEMENT FOR USE IN A WEATHER PROTECTED AREA ONLY EMPLOYES UNIQUEMENT DANS UN EMPLACEMENT DES INTEMPERIES DO NOT USE AC AND DC AT THE TIME NE PAS UTILISER ET GC EN MEME TEMPS HY1000si Serial Num ro de DANGER Using a generator indoors KILL YOU IN MINIUTES L utilisation d un g n rateur causer la mort en quelqu Generator e
11. Midland International Inc 26 Huddersfield Rd Please Mail to Unit 2 Online registration at Etobicoke Ontario www Hyundaipower ca M9W 5Z6 Canada HYUNDAI 5 HYUNDAI 5 HYUNDAI 5 HYUNDAI 5 HYUNDAI 5 HYUNDAI
12. YUNDAI gasoline because explosion may occur Turn off the generator set before performing any mainte nance Otherwise it can cause severe personal injury or death Allow the generator set to cool down before performing any maintenance Always wear safety glasses when cleaning the generator set with air Do not clean the generator set with a pressure washer because it can cause damage to the generator set Before working with batteries ventilate the area wear safety glasses do not smoke and always disconnect the negative cable first and reconnect it last Use rubber gloves when coming into contact with engine oil Always stop the generator set before removing the oil filler cap Only qualified maintenance personnel with knowledge of fuels electricity and machinery hazards should perform maintenance procedures 1 5 OTHER SAFETY HAZARDS To avoid breathing in poisonous carbon monoxide from the exhaust gases adequate ventilation should be provided if the generator set is running in a partially enclosed space If the generator set is stored outdoors check all the elec trical components on the control panel before each use Moisture can damage the generator and can lead to an electric shock HYUNDAI 2 IDENTIFICATION OF COMPONENTS For HY1000Si Cover of fuel cap Top maintenance cover Control Panel p Rear Cover Choke Rocker Fuel Switch Maintenance Cover Star
13. ad indicator light red will go ON If the oil level falls below a safe limit the low oil indicator light red comes on and the engine will be automatically stopped If the engine stops or the low oil indicator light comes on when you pull the starter grip check the engine oil level before troubleshoot ing in other areas Refer to 4 12 for HY1000Si and Fig 4 13 for HY2000Si Overload indicator red Overload indicator red Output indicator Output indicator green AC Circuit Protector OJO Oil Alarm indicator red Oil Alarm indicator red Fig 4 12 Fig 4 13 HYUNDAI 3 Plug power cord of the device into the socket turn on the AC circuit protector and turn on the device Refer to Fig 4 10 for HY1000Si and Fig 4 11 for HY2000Si For DC Operation NOTICE The DC socket is only used for charging a 12V battery Refer to Fig 4 14 for HY1000Si and Fig 4 15 for HY2000Si When using the DC socket turn the ECON switch to the OFF posi tion Refer to Fig 4 14 for HY1000Si and Fig 4 15 for HY2000Si DC Breaker switch ECON switch DC Outlet ECON switch Wires 3 DC Outlet D DC Breaker switch Fig 4 15 HYUNDAI 1 Press the switch to the OFF position 2 Connecting the battery charging cable a Connect the battery charging cable to the battery b Plug the charging wires into the DC outlet of the
14. alve brushes fuel injection nozzle valve lubricant or ignition plug are not covered under this warranty All expenses incurred in maintaining and replacing parts for generator shall fall on the purchaser This warranty coverage does not include parts affect ed by accident and or collision corrosion or rust normal wear incorrect fuel type or fuel contamination use in an application for which the product was not intended unauthorized service or any other misuse neglect incorporation or use of unsuitable attachments or parts Damage to voltage regulators caused by failure to ground shorting or overloading will not be covered under this warranty Under this Warranty we do not have the obligation to bear any transportation fees of any product to from an authorized Warranty Center Unauthorized alteration installa tion or any cause other than defects in material or workmanship of the product will not be covered under the warranty Exclusions Not Covered by this Limited Warranty 1 Normal engine alternator wear 2 Damage caused by lack of maintenance as described in the Hyundai manuals or negligence by using improper or impure motor oil coolant or fuel 3 Damage caused by accidents improper installation or stor age 4 Damage caused by water ingestion submersion or external water damage 5 Damage or non performance caused by operation of the gen erator set in a marine application 6 Damage caused by operation with i
15. b 7 to 10 times Move the choke rocker to the CLOSE position and start the engine 4 2 USING THE GENERATOR SET Connections for standby power to a building s electrical system must be done by a qualified electrician and must comply with all applicable laws and electrical codes Im proper connections may cause serious injuries to electrical workers during power outage and when the utility power is restored the generator may explode or cause fires HYUNDAI To prevent electrical shock faulty appliances the generator should be grounded Limit operation requiring maximum power to 30 minutes Do not exceed the current limit specified for any one receptacle Do not connect the generator to a household circuit Do not modify or use the generator for other purpose than it is intended for When an extension cable 15 required be sure to use a rubber sheathed flexible cable Limit length of extension cables 60 m for cables of 1 5mm and 100 m for cables of 2 5 mm Keep the generator away from other electric cables or wires such as distribution network The DC receptacle can be used while the AC power 15 in use If you use both at the same time be sure not to exceed the total power for AC and DC HYUNDAI Before a device to the generator make sure the electrical rating of the device does not exceed the elec trical rating of the generator Be sure the device is turned off before plu
16. cted If high electrical loads are connected simultaneously turn the ECON switch to OFF position to reduce voltage changes When using the DC output turn the ECON switch to OFF position ON position To minimize fuel consumption and further reduce noise levels when no load is applied OFF position The ECON system does not operate Fuel Switch It controls flow of fuel from fuel tank to carburetor Ground Terminal It connects generator to ground wire for ground ing protection Oil Indicator light Before the oil level falls below a safe limit the Oil Indicator light red will go ON and the Oil Alert system will auto matically stop the engine HYUNDAI LLI Output Indicator Light The output indicator light green is illumi nated when the generator is operating normally It indicates that the generator is producing power at the receptacles Overload Indicator Light If the generator is overloaded or if there is a short circuit in a connected device the overload indicator light red will go ON It will stay ON and after about four seconds the device will shut off and the output indicator light green will go OFF Recoil Starter A pull cord is attached to the engine and you pull the T handle attached to the starter cord assembly to spin the fly wheel and start the engine Spark Plug A device screwed into the combustion chamber of a spark ignition engine The plug supplied the spark that ignites the air fuel m
17. e suggest you take it in a sealed container to your local service station for reclama tion Do not throw it in the trash or pour it on the ground Do not use gasoline for cleaning since it is flammable and explosive under certain conditions 1 Press the start switch to the STOP position and make sure the fuel cap 15 fully closed 2 Loosen the cover screws and remove the maintenance cover 3 Place a container next to the engine to catch the used oil Refer to Fig 5 2 for HY1000Si and Fig 5 3 for HY2000Si 4 Remove the oil filler cap dipstick and drain the oil into the con tainer by tilting the generator Releasing Oil Oil Container Oil Container HYUNDAI Fig 5 2 Fig 5 3 5 With the engine in a level position add oil to the upper level mark Refer to Fig 5 4 TD e KOM o jua dE la od Upper limit Dipstick Lower limit Fig 5 4 6 Reinstall the oil filler cap dipstick securely 7 Reinstall the maintenance cover and tighten the cover screws securely 5 5 Spark Plug Service 1 Remove the top screw and the top maintenance cover Refer to Fig 5 5 for HY1000Si and Fig 5 6 for HY2000Si Top maintenance cover Top maintenance cover 2 Remove the ignition coil Refer to Fig 5 7 for HY1000Si and Fig HYUNDAI 2 D Fig 5 8 Fig 5 10 and Fig 5 12 for HY2000Si Fig 5 10 Fig 5 7 3 Clean any dirt and debr
18. esistance then return the starter grip gently This closes the valves so moisture cannot enter HYUNDAI 6 TROUBLESHOOTING troubleshooting procedures present hazards which can result in severe personal injury or death Only trained and experienced service personnel with knowledge of fuels electricity and machinery hazards should perform service procedures Review Safety Precautions A hot generator can cause severe burns Always allow the generator set to cool before performing any maintenance service If the engine doesn t start Make sure there 15 no spilled fuel around the spark plug If the engine still doesn t start have the generator repaired by a licensed repair person Problem Recommended Action Start switch and fuel valve not ON Turn them to the ON position Not enough lubricating oil Add more oil Start a few times to ensure fuel No fuel in the carburator enters the carburator Spark plug not working Replace spark plug Send generator to authorized dealer HYUNDAI If the device that connects the generator doesn t start Problem Both the Output indicator light and the Overload indicator are no ON If the Output indicator light is ON but device doesn t work after plugging in directly Both the Output indicator light and the Overload indicator light are ON but device has no defects Both the Output indicator light and the Overload indicator light are ON but device has
19. gging in the power cord When the output indicator light green is OFF and the overload indicator light red is ON press the start switch to the STOP position stop the engine at once and then start the engine again NOTICE When the device requires a large starting power the overload indicator light red and the output indicator light green may be ON together for a short period but this is no abnormality After the device starts the overload indicator light red will go out and the output indicator light green will stay ON GROUND TERMINAL Before using generator a ground wire must be connected to the ground terminal Before using the ground terminal consult a qualified electrician Refer to 4 8 for HY1000Si and Fig 4 9 for HY2000Si HYUNDAI For Operation 1 Turn off the switches of the device before connecting to the generator 2 Start the generator and make sure the output indicator lights green come on Refer to Fig 4 10 for HY1000Si and Fig 4 11 for HY2000Si Overload indicator red Output indicator green Fig 4 10 HYUNDAI Overload indicator red Output indicator green ES gt Sa Fig 4 11 NOTICE Under normal operating conditions the output indicator light green will be ON If the generator is overloaded in excess 100W or if there is a short circuit in a connected device the overlo
20. ine Don t use fuel containing alcohol Fuel system damage or engine performance problems will result from the use of fuels that contain alcohol Avoid repeated or prolonged contact with skin or breath ing of fuel vapor Cover of fuel cap Fuel cap HYUNDAI Check the air filter Never run the engine without the air filter Rapid engine wear will result from contaminants such as dust and dirt being drawn through the carburetor into the engine 1 Loosen the cover screws nuts and remove the maintenance cover Remove the air filter cover and the air filter sponge Refer to Fig 3 4 2 Observe the sponge for cleanliness 3 Clean sponge with soap and water or solvent Squeeze dry and then soak in clean engine oil Squeeze out all excess oil and reinstall 4 Replace the sponge it is damaged Air filter sponge Maintenance Cover Fig 3 4 Screws 4 OPERATION 4 1 STARTING THE GENERATING SET NOTICE A hot engine will not start if there is too much gasoline in the cylin der If this happens wait for 5 to 10 minutes for the engine to cool down before starting The engine will stop automatically when it is out of gasoline HYUNDAI 1 Rotate the fuel switch to the position according to the row direction Refer to Fig 4 0 for HY1000Si and Fig 4 1 for HY2000Si Turn the fuel switch to ON counterclockwise Fig 4 0 Fig 4 1 2 If the engine is cold move the choke roc
21. is around the spark plug base Spark Plug Wrench Fig 5 9 4 Use a wrench to remove the spark plug Refer to Fig 5 9 and Fig 5 11 for HY1000Si 5 8 for HY2000Si HYUNDAI Z LLI Ignition Coil Ignition High Voltage wire DC Wire High Voltage wire DC Wir Spark Plug Fig 5 11 5 Visually inspect the spark plug Clean the spark plug with a brush if it is to be reused 6 Measure the plug gap with a feeler gauge The gap should be 0 7 to 0 8 mm 0 028 to 0 031 inch Correct as necessary by care fully bending the side electrode Refer to Fig 5 13 0 7 0 8 mm 0 0280 031 inp Side Electrode Fig 5 13 7 Install the correctly gapped spark plug back into the original posi tion 8 Reinstall the ignition coil securely 9 Close the top maintenance cover and tighten the screw HYUNDAI WARNING The spark plug must be securely tightened An improperly tightened plug can become very hot and possibly damage the generator WARNING Never use a spark plug with an improper heat range Never use a spark plug without damping resistance or it will cause no AC output 5 6 Transportation 4 Storage Gasoline is extremely flammable and explosive under certain conditions Do not smoke or allow flames or sparks in the area When transporting the generator Do not overfill the tank Ifthe generator has been used allow it to cool for at least 15 minutes bef
22. ixture so that combustion can occur HYUNDAI Please complete and mail the form below or register online by visiting our website HYUNDAI www Hyundaipower ca Personal Information First name Last name Address City Postal code Province Product Information Model name Serial number Date of purchase Y M D Questionnaire Store name and number Purchase price Why our generator Price Ease of use Power rating Brand Portability Appearance HYUNDAI Questionnaire How did you find out about us In Store Internet Print Radio TV Store flyer Word of mouth Primary usage Recreational Emergency Tools Primary location of usage Home Work Gender Male Female Martial status Married Single Date of birth Y M D HYUNDAI Questionnaire Number of people in household 1 2 3 other Primary residence Own Rent Education Partial Full University Secondary Secondary College Household income thousand Primary method of purchasing items In Store Online TV Mail order
23. ker to the CLOSE posi tion Refer to Fig 4 2 for HY1000Si and Fig 4 3 for HY2000Si Open Choke Rocker Close Close Choke Rocker open Fig 4 2 Fig 4 3 Primer Bulb 3 Press the start switch to the RUN position Refer Fig 4 4 for HY1000Si and Fig 4 5 for HY2000Si Note The choke lever direction of HY1000Si is opposite to that of HY2000Si HYUNDAI Start switch Fig 4 4 Fig 4 5 4 Pull slightly on the starter grip until you feel resistance and then pull briskly Refer to Fig 4 6 for HY1000Si and Fig 4 7 for HY2000Si Fig 4 6 Fig 4 7 5 After the engine warms up above 50 F slowly turn the choke rocker to the OPEN position HYUNDAI WARNING Do not allow the starter grip to snap back Return it slowly by hand Grasp the carrying handle firmly to prevent the generator from falling over when pulling the starting grip NOTICE If the engine stops and will not restart check the engine oil level before troubleshooting other areas Make sure the ECON switch is OFF before turning on the con nected device Primer Bulb For HY2000Si only The primer bulb is used for bringing small amounts of gasoline to the throat opening of the carburetor The problem is that sometimes generator cannot start because the fuel cannot reach the carbure tor Refer to Fig 4 3 Procedure for using the primer bulb a Set the choke rocker in the OPEN position b Push the primer bul
24. mproper fuel or at speeds loads conditions or modifications contrary to published specifications 7 Items not supplied by Hyundai including but not limited to starting batteries battery cables external wiring fuel lines filters etc refer to exclusions 8 Repairs made during the warranty period without first obtain ing a case number from Hyundai Batteries supplied with any generator product should be consid ered a bonus item and not covered by warranty Batteries can be damaged by shock shorting terminals heat acid spillage and a number of other factors that cannot be controlled after they have HYUNDAI left our facility It is the customer s responsibility to take great care when handling a battery so no spillage of acid will occur and cause corrosion damage caused by battery acid is not covered under this warranty Product Registration Product registration is required for product support and warranty coverage The owner s registration found in the user manual can be com pleted and mailed You can also register Online at www hyundaip ower ca You should keep your receipt for proof of purchase Warranty Claim Procedure Warranty service must be performed by one of our authorized service dealers If you feel your generator is malfunctioning due to a defect or misuse simply contact our customer support center for technical advice a warranty claim or general information Do nat return your generator to the
25. nly Commercial use 6 months limited parts and labor This limited warranty begins at the initial time of retail purchase and covers manufacturer s defects caused by a defect in compo nents or workmanship during the two 2 Year period The war ranty coverage is continual from the initial date of purchase and does not restart at anytime under any circumstances This limited warranty is valid for residential or recreational applications only and only when the generator receives all necessary preventative maintenance as described in the Hyundai Generators Operation Manual The repair or replacement of a generator will take place within a reasonable period of time during normal business hours All repair and replacement parts shall be warranted for 90 days after the initial date of installation or purchase Limitation of Remedies and Disclaimers Midland International Inc disclaims any responsibility for loss of time or use of the generator in a recreational vehicle or any ve hicle in which the generator is installed transportation commercial loss or any other incidental or consequential damage Any implied warranties are limited to the duration of this written warranty THE FOREGOING LIMITED WARRANTY IS EXCLUSIVE OF AND IN LIEU OF ALL OTHER WARRANTIES OF MERCHANTABIL HYUNDAI ITY FITNESS FOR PARTICULAR PURPOSE AND OF ANY OTHER WARRANTY WHETHER EXPRESS OR IMPLIED Consumable parts such as oil or fuel filters fuel cut off v
26. nt DANGER Using generator indoors KILL YOU IN MINIUTES L utilisation d un g n rateur l enclos pourrait causer la mort en quelques minutes ATTENTION ATTENTIO Generator exhaust contains carbon monoxide This is a poison you cannot see or smell BR L chappement d un g n rateur contient du monoxyde de carbone Le monoxyde de carbone poison mortel qui est sans odeur ni couleur apparent gt Only use OUTSIDE and far away from windows doors and vents ys utiliser l ext rieur et bien loin portes et des fen tres NEVER use inside a home or garage EVEN IF doors and windows are open Ne jamais utiliser l ir un garage m me si sont ouvertes IMPORTANT IMPORTANT ra sal AIR CLEANER MAINTENANCE ATTENTION ATTENTION HOT SURFACES very 10 hours i KEEP CLEAR OF EXHAUST uay condo SURFACE CHAUDE GARDER L CART DE L CHAPPEMENT DU MOTEUR pre Information importante sur le Moteur ENTRETIEN DU CE MOTEUR RENCONTRE LES Important Engine Information THIS ENGINE CONFORMS TO US EPA REGS FOR 2009 Date of manufacture 01 2009 Exhaust Em ontot EM THIS ENGINE IS CERTIFIED TO NORMES ACTUELLES DE DES ETATS UNIS POUR L ANN E 2009 Nom de famil du moteur 5 d chapper Prode da conformit d chapporan equis du bean MOTEUR EST CERTIFI POUR OP RER SUR DU CARBURANT SANS OPERATE ON UNLEADED GASOLINE PLO
27. ore loading it on the transport vehicle To prevent fuel spillage the generator should be secured upright in its normal operating condition with the start switch in the STOP position Donot drop or strike the generator when transporting Do not place heavy objects on the generator Storage Procedure 1 Drain the gasoline Unscrew the fuel tank cap remove the debris screen under the cap and empty the fuel tank into an approved gasoline pot Rotate the fuel switch to the ON position Refer to Fig 4 0 for HY1000Si and Fig 4 1 for HY2000Si 2 Start the generator and operate it in the idle position until all remaining fuel is gone and the engine stops automatically Refer to HYUNDAI Fig 5 14 HY1000Si and Fig 5 15 HY2000Si Fig 5 14 Fig 5 15 3 Discharge Oil a Press the start switch to the STOP position and make sure the fuel 15 fully closed b Loosen the cover screws and remove the maintenance cover Place a container next to the engine to catch the used oil d Remove the oil filler cap dipstick and drain the oil into the container by tilting the generator e Remove the screw top maintenance cover and the spark plug f Fill the spark plug orifice with 2 cc s about a tablespoon of fresh oil Pull the start motor 3 4 times to distribute the oil 9 Reinstall the spark plug top maintenance cover and screw securely h Pull the starter grip slowly until you feel r
28. peration check before starting the engine Properly clean and maintain the equipment Read the user manual carefully before operation Other wise it may result in personal injuries or equipment dam age Never run the generator in an enclosed area since the exhaust emits poisonous carbon monoxide gas Gasoline is a highly flammable and explosive liquid Refuel in a well ventilated area with the engine stopped Be careful not to touch the exhaust system during opera tion because can cause burns Pay attention to the warning labels because the engine exhaust system will become heated during operation and remain hot immediately after the engine 15 stopped When refueling the generator keep it away from the ciga HYUNDAI rettes open flames smoke and or sparks Connections for standby power to a building s electrical system must be done by a qualified electrician and must comply with all applicable laws and electrical codes Im proper connections may cause serious injuries to electrical workers during power outage and when the utility power 15 restored the generator may explode or cause fires Place the generator at least 3ft away from buildings other equipment during operation Run the generator on a level surface If the generator tilts fuel spillage may result Know how to stop the generator quickly and understand operation of all the controls Never permit anyone to ope
29. r ate the generator without proper instructions Keep children pets and rotating parts away from the gen erator during operation Do not operate the generator in rain or snow Do not allow any moisture to come in contact with the generator Do not touch the spark plug while the generator 15 operat ing and shortly after the generator has been shut down 1 3 AC SAFETY GUIDELINES Before connecting the generator to an electrical device or power cord Make sure that everything 15 in right working order Faulty devices or power cords can lead to an electrical shock Turn off the generator immediately if the device begins to operate abnormally Then disconnect the device and inves tigate the problem Make sure that the electrical rating of the device does not exceed that of the generator If the power level of the device 15 between the maximum output power and the run ning power of the generator the generator should not be used for more than 30 minutes The connections from the generator to the household pow er supply should be done by professional electrical techni cians Improper connections may lead to a fire hazard or damages to the generator set 1 4 MAINTENANCE SAFETY After any maintenance 15 performed wash your body im mediately using soap and clean water because repeated exposure to lubricant may cause skin irritation Do not clean the filter sponge with flammable fluids like H
30. ter Grip HYUNDAI For HY2000Si Fuel Switch Top maintenance cover Starter Grip Primer Bulb Choke Rocker Cover of fuel cap Maintenance cover Control Panel Rear Cover HYUNDAI Control Panel HY1000Si Low Gil indicat r Overload indicator Output indicator DC breaker AC socket Grounding Start switch ECON switch DC socket AC Circuit Protector Control Panel for 20005 Overload Output indicator Low oil indicator indicator 4 AC Circuit 40 02 Protector HE AC socket DC breaker DC socket ECON switch Grounding Start switch HYUNDAI Label Placement AC Voltage Duration Voltage Sontinuatic DC Voltage tage Power Output For HY1000Si Engine RPM TR PM du mot Fuel gt Max AC Output Power 1000W Huile Phase Insulation class Frequency FOR USE IN A WEATHER PROTECTED AREA ONLY EMPLOYES UNIQUEMENT DANS UN EMI A L ABRI DES INTEMPERIES DO NOT USE AC AND DC AT THE SAME TIME NE PAS UTILISER ET CC EN MEME HY1000si Serial Num ro de si ATTENTION ATTENTION add fuel when the engine is running jamais ajouter du carburant lo r add fuel when engine is hot eNe jamais ajouter du carburant lorsque le moteur es ways add f tilated area eToujours transf rer le carburant dans un endroit n up fuel spills e Toujours ramasser les fuites de carbura
31. the maintenance cover Refer to Fig 3 0 for HY1000Si and Fig 3 1 for HY2000Si 2 Remove the oil filler cap and wipe the dipstick clean Refer to Fig 3 2 for HY1000Si or HY2000Si Check the oil level by inserting the dipstick into the filler neck without rotating it 3 If the level is low fill to the upper limit of the oil filler neck with the recommended oil 4 Reinstall the maintenance cover and tighten the cover screws Maintenance Cover Cover Screw HYUNDAI Maintenance Cover Cover Screw Dipstick Oil Filler Cap Fig 3 2 Lower limit NOTICE The Oil Alert System will automatically shut off the engine before the oil level falls below the safe limit However to avoid the incon venience of an unexpected shutdown it is still advisable to visually inspect the oil level regularly Fuel level check 1 Turn the engine start switch to STOP position 2 Open the fuel cap cover Remove the fuel cap and check the fuel level 3 Refill the fuel tank if the level is low Refuel carefully to avoid HYUNDAI spilling fuel Do not fill above the upper limit mark Refer to Fig 3 3 CAUTION Gasoline is highly flammable and explosive Keep the engine away from heat spark and open flame Refuel in a well ventilated area with the engine stopped Handle fuel only outdoors Wipe up spills immediately Avoid getting dirt dust or water in the fuel tank CAUTION Never use an oil gasoline mixture or dirty gasol
32. xhaust contains carbon monoxide This is a poison you cannot see or smell L chappement d un g n rateur contient du monoxyde de carbone Le monoxyde de carbone est un poison mortel qui est sans odeur ni couleur apparente ES gt Only use OUTSIDE and far away from windows doors and vents Toujours utiliser l ext rieur et bien loin NEVER use inside a home or garage EVEN IF doors and windows are open jamais utiliser l int rieur d une mais garage m me si les porte sont ouvertes EE SES j AIR CLEANER MAINTENANCE fires vi cet ENTRETIEN DU FILTRE AIR avec un aude chaque 1 Important Engine Information THIS ENGINE CONFORMS TO US EPA REGS FOR 2008 Engine Family Engine Displaceme Exhaust E ontot EM Emission compl Lubricant requirement SF 1 THIS ENGINE 15 CERTIFIED TO OPERATE ON UNLEADED GASOLINE Information importante sur le Moteur MOTEUR RENCONTRE LES NORMES ACTUELLES DE L EPA DES TATS UNIS POUR L ANN E 2009 Nom de famille du moteur d chappement d Requis lbrant SF 15W 40 CE MOTEUR EST CERTIFI POUR OP RER SUR DU CARBURANT SANS PLOMB 3 PRE OPERATION INSPECTION Be sure to check the generator on a level surface with the engine stopped Ensure the generator 15 on a level surface Engine Oil Inspection Using non detergent oil or 2 stroke engine oil could shorten the generator s life 1 Loosen the cover screws and remove
Download Pdf Manuals
Related Search