Spirit Complete User Manual
Contents
1. Obey the instructions and do not continue until all conditions are accepted and engaged A Note identifies important information for a trouble free and optimal use of the water purifier 03 Bluewater June 2015 Safety information 0O O UOO Coe O GO Complete Install the water purifier in accordance with local regulations If you are not sure contact a Bluewater dealer for aid Bluewater has no responsibility for installation of the water purifier Do not drink the water when the service light shows that it is not clean Store water in vessels that are resistant to corrosion This appliance can be used by children who are more than 8 years old It can also be used by persons with reduced physical sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction about the use of the appliance in a safe way and understand the hazards involved Children shall nor play with the appliance Cleaning and user maintenance shall not be made by children without supervision Do not repair or modify parts of the water purifier This can make it operate incorrectly and lead to injury and damage not covered by the warranty Only approved Bluewater staff can do servicing and repairs on the T purifier Only use original replacement cartridges and parts from Bluewater The water to be cleaned must obey the requirements in Technical information Check the cleaned water when th2. min 50 mm HA x1 Figure 13 Install drain water connection Connect the water purifier Do not connect the clean water hose to equipment before Spirit has been flushed Figure 14 Connect the water purifier 11 Bluewater June 2015 After installation When Spirit is installed and after each maintenance the following procedures must be perfomed before operation Flush Spirit O Do not drink the water when the water purifier flushes It is not safe to use The water purifier should always be flushed when it is new and has not been used when it is installed again after storage freeze protection when it has been cleaned when the membrane has been replaced Open the clean water valve immediately when the service button is released If not the Spirit can be damaged Spirit 300 D Ie Figure 15 Flush Spirit Do a check for leaks See Do a check for leaks on page 13 Complete User manual 12 MAINTENANCE After each maintenance all procedures in chapter After installation on page 12 must be perfomed before operation term operation Only educated and approved personnel can do the O Regular maintenance is important for correct function and long maintenance contains high levels of suspended solids more frequent maintenance can The water quality controls the maintenance frequency If the feed water be necessary Fach month Do a check f
3. purifier flushes water Wait for 5 minutes The overflow protection system is Disconnect the water purifier from activated power and clean the base plate If the overflow protection is activated again contact your Bluewater dealer The flow rate from the clean water The water purifier needs to be See Descale on page 14 faucet is low descaled The clean water hose is tensioned Make sure that the clean water hose or jammed can move freely Water does not flow from the The feed water shut off valve is Open the feed water shut off valve clean water faucet closed There is a bad smell from the Microbial growth in the water See Use disinfectant to clean the water purifier because the water purifier has not system on page 18 been used for a week or longer Complete User manual 2e Bluewater Group Danderydsgatan 11 SE 114 26 Stockholm Sweden Tel 46 8 679 45 00 info bluewatergroup com wwwbluewatergroup com For a complete list of sales offices and dealers please visit wwwbluewaterse
4. translations of the original instruction Printing options This manual is made to be printed as a double sided A4 or A5 booklet Limited warranty Refer to www bluewatergroup com for more information on Limited warranty Environment information 80 of the the water purifier components and its packaging have a label to help you recycle and discard it correctly The water purifier is more efficient when it cleans water for longer periods Example do not fill a glass with water Fill a jug instead Disposal At the end of the water purifiers life disconnect the plug from the electrical supply and cut the cable at the point where it enters the appliance Make sure that children do not play with the leftover cable Contact your local authority for information about where the water purifier can be left or contact your dealer Appliances bearing this symbol must be deposited at the designated local reception point for the disposal of electrical and electronic equipment This product may not be disposed of using the normal household refuse collection processes Safety instructions Before you install or operate the device you must read the safety information Obey the instructions in this manual to prevent injuries or damage to the equipment This manual contains CAUTIONS and NOTICES that are applicable for the safe operation of the device A CAUTION identifies conditions that can cause injury or damage to the O equipment
5. 8 Feed water connection with grid filter 4 Service light 9 Drain water hose 5 Front cover 10 Clean water connection Control panel Spirit 300 FILTER SERVICE 4 i Figure 2 Control panel ON 2 Filter light Flashes The water purifier operates The filter must be replaced The water purifier is connected and operates correctly On The water purifier has stopped The filter must be replaced 3 Service light Flashes Decreased water quality On The water purifier has stopped the water quality has decreased 4 Faucet lights Green Shows good water quality this can take up to 120 seconds Spirit 300 Yellow Flashes Something is wrong Look at the control panel Spirit 300Cp N A Yellow On The water purifier has stopped the water quality has decreased 05 Bluewater June 2015 Spirit inside 3 Figure 3 Spirit inside 1 Base plate 3 Reverse osmosis membrane 2 Prefilter Granulated Active Carbon GAC Data plate The data plate is located behind the filter Figure 4 Data plate Move the water purifier Always transport the water purifier upright Install according to Installation on page 09 more or if it is to be disconnected from the water and electricity for some days see Put into storage on page 19 bos Complete User manual 06 Put the water purifier into storage if it will not be used for four months or Fig
6. SPIRIT Water purifier Complete User Manual Document No 822901692 Revision BB1522 pe Q Bluewater Contents INTRODUCTION SYSTEM OVERVI About this manual Limited warranty Environment information DISPOSER Re na O nina et Safety instructions Safety information PRODUCT VS REN an in ATTER 05 SPENTO HE SR AR RA A ON E E 05 Spirit inside ove the water purifier System descripti ntended use Water production LEAK protection SYSCOM ceecccccccsssssssssssssssssssssssssssssssssessssssssssecsescessssssssssssssinssssssssssssssssssssssssseseseeesesessssssssssssssssussssseseese 08 INSTALLAT ON niinniin e aceite dete alee adie ena ati data Medea 09 Be MAINTENANC 4 Position Spirit nstall clean water faucet nstall feed water connection nstall drain water connection Connect the water purifier After installation Each month ECHNICAL INFORMATION T Technical data Requirements on feed water to Water pUriIfiEr 21 ROUBLESHOOTIN Gersi erini EEEE TOA E EE 22 Complete User manual 02 INTRODUCTION About this manua This manual contains complete user instructions for the Spirit It gives you the necessary instructions to safely install operate do maintenance and do troubleshooting on the device Original language The original language of this instruction is English all other languages are
7. e water purifier is installed if the water does not obey these requirements Test the water one time gt year If the water is not clean do not drink it Contact a Bluewater ealer Installation must comply with applicable local plumbing codes and regulations Only connect the water purifier to one clean water faucet supplied by Bluewater Do not connect it to other pipes tanks or dishwashers Do not put or keep objects on top of the water purifier Do not put the water purifier in water Connect the water purifier to an earthed electrical supply Use a plug that is easy to access after installation Only an approved electrician must do permanent wiring on the system A safety switch must be installed on the system Incorrect installation can lead to damage or make the water purifier dangerous to use Do not use the power cord if there are visible signs of damage on it If the power cord is damaged a qualified electrician must replace it in order to prevent danger If the water purifier is disconnected from water and electricity for more than a week store it as described in Complete User manual Storage User manual 04 PRODUCT OVERVIEW a Spirit outside Spirit 300 Electronically controlled Spirit 300Cp Pressure controlled 6 7 8 9 10 Figure 1 Spirit outside 1 Control panel 6 Power cord 2 On light T Electrical connection for faucet Spirit 300 E Filter light
8. fit Other Clean the grid filter The grid filter in the feed water connection catches larger particles If the flow is decreased or if Spirit makes a noise the grid filter can be blocked e X amp Figure 21 Clean the grid filter 17 Bluewater June 2015 Use disinfectant to clean the system O Disinfectant is harmful Always flush the water purifier after disinfectant is used See Flush Spirit on page 12 Complete User manual 18 Put into Storage more or if it is to be disconnected from the water and electricity for some Put the water purifier into storage if it will not be used for four months or days Figure 23 Put into storage 19 Bluewater June 2015 Reinstall after storage Preserving agent is harmful Always flush the water purifier after storage See Flush Spirit on page 12 T Figure 24 Reinstall after storage Complete User manual 20 TECHNICAL INFORMATION Technical data Control Electronically controlled Pressure controlled Size WxDxH mm inch 150x365x462 5 9x14 3x18 2 150x365x462 5 9x14 3x18 2 Weight kg Ibs 15 33 15 33 Power supply earthed supply Power supply earthed supply US 230V 50HZ 10A 15V 50 60HZ 10A 230V SOHZ 10A 15V 50 60HZ 10A Power con
9. ly after completed flush 3 Water purifier in standby mode Spirit is connected to water and power and It is more than 6 hours since the last flush Leak protection system A sensor at the bottom of the water purifier senses water leaks If there is a leak the feed water supply is stopped The water purifier cannot be started again until the leak has been repaired Complete User manual 08 INSTALLATION gt Figure 9 g Install the water purifier in accordance with local regulations If you are not sure contact a Bluewater dealer for aid Bluewater has no responsibility for installation of the water purifier c Install the water purifier in a vertical position on a horizontal surface Make sure that hoses and cables can move freely when the purifier is moved Only connect the water purifier only Spirit 300 to one clean water faucet supplied by Bluewater Do not connect it to other pipes tanks or dishwashers Plumbing must be done by an approved plumber Obey local rules for plumbing and sanitation if you do work yourself Use the hose set that is supplied with the water purifier Do not use used hose sets again Before installation Jnpack Spirit Hold the rear handgrip and the plastic bag to lift Spirit To hold in other places when Spirit is lifted can cause damage to Spirit Warning Discard the packing material It can cause injury to children if they play wi
10. or leaks O The tubing connections must be tight Figure 16 Check for leaks Repair leaks Figure 17 Repair leaks 13 Bluewater June 2015 Wipe off condensation from base plate Figure 18 Wipe off condensation from base plate Fach 4 6 months Descale The descaling product is harmful Keep it where children cannot get it Clean your hands when you have used it Frequency depending on water quality and usage To extend the water purifier lifetime Descale Spirit with 6 month intervals or when the flow is decreased If Spirit has been descaled and the filters have been replaced but the water flow cannot be restored contact your Bluewater dealer during this time Order the descaling product from Bluewater The descale takes approximately 10 hours Do not use the water purifier Complete User manual 14 Figure 19 Descale Bluewater June 2015 15 Replace prefilter Always flush the water purifier after the prefilter is replaced See Flush Spirit on page 12 If the filter is replaced before the fillter light shows that it is necessary reset Spirit as given in step 14 The filter light will go on and then go out when Spirit is started Figure 20 Replace prefilter Complete User manual 16 Each year Test the water An approved lab must do a test of the water that is cleaned by Spirit one time each year if the feed water has been classed as un
11. ot connected Connect the water purifier to power to power 2 The filter light flashes and the The filter must be replaced See Replace prefilter on page 14 yellow light on the faucet flashes 3 The filter light is on and the yellow The water purifier has stopped See Replace prefilter on page 14 light on the faucet is on The filter must be replaced 4 The service light flashes and the The water quality has decreased Contact Bluewater to replace the yellow light on the faucet flashes membrane 5 The service light is on and the The water purifier has stopped A Disconnect the water purifier from yellow light on the faucet is on filter replacement has caused air to power Reconnect it Let the water come into the system purifier do the automatic flush The water purifier has stopped Contact Bluewater to replace the The clean water quality has membrane become too low 6 The service light is on and the The water quality meter does not Contact your Bluewater dealer yellow and the green lights on the function faucet are on The water purifier makes noise The inlet pressure is lower than 1 5 Contact your Bluewater dealer because the water pressure is not bar during operation sufficient ae A ne he grid filter is blocked See Clean the grid filter on page 17 The filter is blocked See Replace prefilter on page 14 The water purifier does not start he water
12. sumption 3A 3A Purified water flow rate V min gal min 2 5 0 5 0 66 0 13 2 2 0 4 0 58 0 10 Sound level installed in undersink cupboard lt 60 dB A lt 60 dB A Faucet with water quality indicator light v NA Power US 350W 3A 350W 3A Recovery 50 60 50 60 Rejection 95 99 97 99 Start signal Electrical Pressure On off bar psi 3 4 Operation sequence productiorvflush min max time 15 15 25 ees Hon Fow Han Rejection Membrane size 3613C 3613C Prefiltration Granulated Active Carbon GAC Granulated Active Carbon GAC Activated by the pressure drop caused by a connected auxiliary applicance that consumes water unattended v Requirements on feed water to water purifier O Do not install the water purifier if the water is microbiologically unsafe Pressure flowing bar psi 1 5 10 21 7 145 1 5 10 21 7 145 Water flow min ga min gt 6 1 6 gt 6 1 6 TDS Total disolved solids mg ppm lt 1200 lt 1200 lt 1200 lt 1200 Conductivity US cm 25 C 77 F lt 1600 lt 1600 Temperature C F 2 35 36 95 2 35 36 95 Hardness dH grains gallon 10 10 4 10 10 4 Iron FetFe maf ppm 0 5K 0 3 K 0 5K 0 3 lt 0 5 0 3 0 5K 0 3 Turbidity FNU lt 05 lt 05 21 Bluewater June 2015 TROUBLESHOOTING 1 The ON light is not on The water purifier is n
13. th it Make sure that Spirit shows no signs of damage and that no accessories are missing Tell the Bluewater dealer about missing parts damage and other problems Tell the transport company immediately if Spirit is damaged during transport Remove the plugs 09 Bluewater June 2015 Position Spirit Put Spirit in a vertical position on a horizontal surface below the kitchen sink Make sure that the surface can support Spirit Position Spirit near the cold water supply the drain and an earthed electrical supply Make sure that it is easy to see the control panel Make sure that the front cover can be opened to get access to the prefilter Hoses and cables can go in all directions from the connection point Make sure that nothing can crush them or A 460 mm c 482 mm B 190 mm D min 20 mm Figure 1 Install clean water faucet The measurement A is found in the specification that comes with the clean water faucet 35 mm 40 mm 16 mm 20 mm Complete User manual 10 Install feed water connection The water purifier is connected to cold water 2 40 C via the feed water hose Figure 12 Install feed water connection Install drain water connection The flushed water goes through the drain water hose to the drain water outlet This hose can be a maximum of four meters long The minimum internal diameter is 13 mm
14. ure 5 Move the water purifier SYSTEM OVERVIEW System description Spirit 300 Spirit 300Cp Figure 6 System overview Water purifier Bracket for drain water hose Power cord Clean water faucet Feed water hose Clean water hose Drain water hose Faucet electrical connection Spirit 300 Intended use The water purifier is intended to produce purified water Do not use it for any other purpose Any use beside indoor home environment and for purposes other than purifying water for household use is considered as unintended use and will automatically void your warranty The electronically controlled Spirit 300 is intended to produce the quantity of water that is normally required for cooking and drinking in a household The pressure controlled Spirit 300Cp can be connected to other devices such as dishwashers O7 Bluewater June 2015 Water production Figure 7 Water production orvoff A 0 Automatic flush An automatic flush will be performed if one of the conditions below are fulfilled or D 205 30s 10s 605 300 4 5 min 300Cp 2 5 min Figure 8 Automatic flushing 1 Flush after drawing water Production cycles shorter than 60 seconds are added together and flush takes place when total drawing time exceeds 60 seconds 2 Flush after maximum operation time 15 minutes Next production cycle can be started immediate
Download Pdf Manuals
Related Search